蜗壳式离心泵外特性仿真与实验研究

为探索不同仿真方法的适用性,对ns=157的单级蜗壳离心泵不同工况的扬程和效率进行定常和非定常计算,并分别分析了定常计算时不同叶片夹角及非定常计算时不同时间步长的影响,通过与实验对比,得到的主要结论有:定常计算仅适用于额定工况外特性仿真,其扬程和效率计算误差分别为4.9%和2.9%,而定常多相位的计算误差分别为7.1%和3.2%;非定常仿真计算时,以4°为时间步长,并间隔20°保存一次计算数据,较好地预测出扬程曲线走势,额定工况扬程和效率计算误差约1.1%和1.8%,但小流量和大流量区间扬程计算误差达到10%左右。因此在水力优化设计时,若只关注高效点位置及其扬程和效率,可采用定常计算,若还关注扬程曲线走势,则应采用非定常计算。     

Exogenous application of allelopathic water extracts helps improving tolerance against terminal heat and drought stresses in bread wheat (Triticum aestivum L. Em. Thell.)

The allelopathic water extracts (AWEs) may help improve the tolerance of crop plants against abiotic stresses owing to the presence of the secondary metabolites (i.e., allelochemicals). We conducted four independent experiments to evaluate the influence of exogenous application of AWEs (applied through seed priming or foliage spray) in improving the terminal heat and drought tolerance in bread wheat. In all the experiments, two wheat cultivars, viz. Mairaj‐2008 (drought and heat tolerant) and Faisalabad‐2008 (drought and heat sensitive), were raised in pots. Both wheat cultivars were raised under ambient conditions in the wire house till leaf boot stage (booting) by maintaining the pots at 75% water‐holding capacity (WHC). Then, managed drought and heat stresses were imposed by maintaining the pots at 35% WHC, or shifting the pots inside the glass canopies (at 75% WHC), at booting, anthesis and the grain filling stages. Drought stress reduced the grain yield of wheat by 39%–49%. Foliar application of AWEs improved the grain yield of wheat by 26%–31%, while seed priming with AWEs improved the grain yield by 18%–26%, respectively, than drought stress. Terminal heat stress reduced the grain yield of wheat by 38%. Seed priming with AWEs improved the grain yield by 21%–27%; while foliar application of AWEs improved the grain yield by 25%–29% than the heat stress treatment. In conclusion, the exogenous application of AWEs improved the stay green, accumulation of proline, soluble phenolics and glycine betaine, which helped to stabilize the biological membranes and improved the tolerance against terminal drought and heat stresses.     

Experimental investigation on the transport of different fish species in a jet fish pump

A jet fish pump with a throat of ø60 mm was designed to study its performance in the transport of different fish species and the physiological changes in fish thereafter. Experiments were conducted to investigate the fish transport rate and energy required to transport each ton of fish when transporting Carassius auratus, commonly known as the Chinese goldfish, Megalobrama amblycephala, or Wuchang bream, and Ctenopharyngodon idella, the grass carp. Fish were examined for external injuries as well as for several important enzymes and hormones which are indicators of tissue injury and stress. The results showed that the transport rate for all three species of fish rose dramatically with an increase in the primary stream rate. In this experiment, the transport rates of C. auratus, M. amblycephala and C. idella reached 2357 ± 37.2 kg ∙ h⁻¹, 2888 ± 41.6 kg ∙ h⁻¹, and 2060 ± 40.2 kg ∙ h⁻¹, respectively. However, both injury rate and energy required to transport each ton of fish increased no matter whether the primary stream rate was too low or too high. Considering both transport rate and injury rate, the mean primary stream rate of 80 m³ ∙ h⁻¹ was determined to be the optimal operating condition in this experiment. Fish were stressed and most likely some of their organs were damaged. However, most physiological indexes almost fully recovered after several hours.     

Comparing the behavioural thermoregulation response to heat stress by Atlantic salmon parr (Salmo salar) in two rivers

Climate change is expected to increase the frequency and magnitude of extreme thermal events in rivers. The Little Southwest Miramichi River (LSWM) and the Ouelle River (OR) are two Atlantic salmon (Salmo salar) rivers located in eastern Canada, where in recent years, water temperatures have exceeded known thermal limits (~23°C). Once temperature surpasses this threshold, juvenile salmon exploit thermal heterogeneity to behaviourally thermoregulate, forming aggregations in coolwater refuges. This study aimed to determine whether the behavioural thermoregulation response is universal across rivers, arising from common thermal cues. We detailed the temperature and discharge patterns of two geographically distinct rivers from 2010 to 2012 and compared these with aggregation onset temperature. PIT telemetry and snorkelling were used to confirm the presence of aggregations. Mean daily maximum temperature in 2010 was significantly greater in the OR versus the LSWM (p = 0.005), but not in other years (p = 0.090–0.353). Aggregations occurred on 14 and 9 occasions in the OR and LSWM respectively. Temperature at onset of aggregation was significantly greater in the OR (T_onset = 28.3°C) than in the LSWM (T_onset = 27.3°C; p = 0.049). Logistic regression models varied by river and were able to predict the probability of aggregation based on the preceding number of hours >23°C (R² = 0.61 & 0.65; P₅₀ = 27.4°C & 28.9°C; in the OR and LSWM respectively). These results imply the preceding local thermal regime may influence behaviour and indicate a degree of phenotypic plasticity, illustrating a need for localised management strategies.     

Engineered-airlift pumps for aquaculture applications using multiphase flow analysis

Currently, very few aquaculture operations are employing airlift pump technology for water recirculation, aeration, and waste removal. This is likely due to the poor design and lower efficiency of traditional airlift design, the limited amount of research effort that has been invested in improving performance capabilities of air lift pumps and the general lack of awareness of the industry about the inherent advantages of airlift systems. A new efficient airlift pump is hydrodynamically designed by incorporating the Volume of Fluid (VOF) multi-phase model along with the K-ε turbulence model utilizing Computational Fluid Dynamics (CFD) tools. The pump is designed to offer a substantial reduction in total energy usage as well as an improved quality of the culture products in order to make it attractive to aquaculture industry. In this study, both numerical and experimental investigations were carried out for airlift systems operating under two different submergence ratios of 50% and 90% in a lab setting using 2.54 cm diameter pumps. Also, the performance of a large-scale pumps of 10.16 cm diameters were also tested in an aquaculture raceway to determine its effect on the operation. The numerical results were found to be in agreement with the experiments within ±20% which is considered very reasonable for multiphase flow analysis. The present study was found to present a great tool for modelling the airlift pump performance, and potentially proposing new designs.     

无源蓄冷控温运输箱设计与试验

针对蓄冷运输箱信息化程度低、控温时间短、控温困难等问题,设计了一款集控温、远程监控、定位、故障诊断等功能于一体的蓄冷运输箱。以脐橙为试验对象,结合能耗模型,对蓄冷控温箱控温性能进行了研究。结果表明,箱内各截面温度不均匀系数分别为0.38、0.47、0.78,温度极差最大值为2.8℃,均匀性较好;当蓄冷剂用量为180 kg,预冷脐橙660 kg,在外部环境平均温度26.39℃的条件下,总控温时长为122 h,风机共执行控温21次,且随着蓄冷量减少,风机开启控温所用时间呈指数上升趋势,决定系数不小于0.928 0;结合能耗模型分析得出,该箱体在广州夏季高温环境下可控温5 d以上,能够满足远距离运输要求。     

叶轮出口边对双蜗壳泵压力脉动的影响

泵的叶轮扫掠蜗壳隔舌时产生的压力脉动是引起船用泵振动噪声的原因之一.为尽可能弱化这一影响,分别设计了叶片出口边与前后盖板基本面垂直和倾斜的2种不同形式叶轮,将其配置在相同的双蜗壳中,通过数值计算与样机试验相结合的手段,对蜗壳内9个不同位置的压力脉动情况进行对比分析.结果表明:出口边倾斜的叶轮相比于出口边垂直的叶轮可明显改善蜗壳内次脉动的“驼峰”现象,且可以进一步降低隔舌处主波动的压力峰值;对蜗壳内2个隔舌稍前的位置,出口边倾斜的叶轮反而会使得该点的压力系数幅值明显增大,且该点主波动的周期数发生改变;2种叶轮出口边的不同形式对蜗壳出口位置的压力脉动的影响基本相同;采用出口边倾斜叶轮对改善因叶轮与隔舌间的液流压力脉动是可行的.     

Sorghum extrusion process combined with biofortified sweet potato contributed for high iron bioavailability in Wistar rats

This study aimed to evaluate the effect of sorghum and sweet potato on the bioavailability of iron, gene expression of proteins involved in iron metabolism and the plasma antioxidant capacity in animals fed with whole sorghum grains processed by dry heat or extrusion, combined or not with sweet potato flour with high content of carotenoids. Five experimental groups were tested (n = 7): dry heat sorghum flour (DS); extruded sorghum flour (ES); whole sorghum flour + sweet potato flour (DS + SP); extruded sorghum flour + sweet potato flour (ES + SP) and positive control (FS). The evaluations included: hemoglobin gain, hemoglobin regeneration efficiency, gene expression of divalente metal transporter 1 (DMT-1), duodenal citochroma B (DcytB), ferroportin, hephaestin, transferrin and ferritin and total plasma antioxidant capacity (TAC). The ES + SP group showed higher (p < 0.05) expression of DcytB, ferroportin and hephaestin when compared to the control group. The DS group showed high (p < 0.05) expression of DMT-1 and the ES showed high mRNA expression of transferrin and ferritin. The changes in the sorghum physicochemical properties from extrusion process reduced the iron and phytate content, and increased the gene expression of proteins involved in iron metabolism, improving iron bioavailability. The combination of sweet potato and sorghum flour (dry or extruded) improved the iron capture and total antioxidant capacity, probably due to the presence of β-carotene and antioxidant compounds.     

Effect of chlorogenic acid on intestinal inflammation,antioxidant status,and microbial community of young hens challenged with acute heat stress

Heat stress in poultry is deleterious to productive performance. Chlorogenic acid (CGA) exerts antibacterial, anti-inflammatory, and antioxidant properties. This study was conducted to evaluate the effects of dietary supplemental CGA on the intestinal health and cecal microbiota composition of young hens challenged with acute heat stress. 100-day-old Hy-line brown pullets were randomly divided into four groups. The control group (C) and heat stress group (HS) received a basal diet. HS + CGA₃₀₀ group and HS + CGA₆₀₀ group received a basal diet supplemented with 300- and 600-mg/kg CGA, respectively, for 2 weeks before heat stress exposure. Pullets of HS, HS + CGA₃₀₀, and HS + CGA₆₀₀ group were exposed to 38°C for 4 h while the control group was maintained at 25°C. In this study, dietary CGA supplementation had effect on mitigate the decreased T-AOC and T-SOD activities and the increasing of IL-1β and TNFα induced by acute heat stress. Dietary supplementation with 600 mg/kg CGA had better effect on increasing the relative abundance of beneficial bacterial genera, such as Rikenellaceae RC9_gut_group, Ruminococcaceae UCG-005, and Christensenellaceae R-7_group, and deceasing bacteria genera involved in inflammation, such as Sutterella species. Therefore, CGA can ameliorate acute heat stress damage through suppressing inflammation and improved antioxidant capacity and cecal microbiota composition.