TCD燃烧系统对柴油机燃烧和排放性能改善效果的试验研究

为探究道依茨TCD2015柴油机上配备的导流燃烧系统(简称TCD燃烧系统,T表示涡轮增压器,Turbocharger,C表示进气中冷,Charge air cooling,D为柴油颗粒捕集器,Diesel particle filter)对改善柴油机燃烧性能和降低污染物排放的效果,采用单缸机试验对TCD燃烧系统在不同转速、负荷和过量空气系数下的燃烧和排放性能进行研究。试验结果表明不同工况下TCD燃烧系统燃油消耗率和Soot排放量均低于传统ω燃烧系统,燃油消耗率最大降幅为7.01%,Soot排放量最大降幅为86.67%,且低过量空气系数(1.2～1.6)下TCD燃烧系统仍具有较好的性能。为揭示TCD燃烧系统改善油气混合促进燃烧的机理,采用AVL Fire软件建立了柴油机性能仿真模型。计算结果表明,TCD燃烧系统的环状凸起结构将燃油导向内外两室,从而促进了缸内燃油发展过程,燃油当量比大于4的浓混合气区域燃油质量比例相比ω燃烧系统降幅最大为9.75%,活塞下移时TCD燃烧系统内油束撞击浅盘侧壁形成撞壁射流扩大了燃油扩散面积,从而改善了缸内油气混合质量,燃油当量比小于1的均匀混合气区域燃油质量比例相比ω燃烧系统降幅最大为7.45%,因此TCD燃烧系统能够有效改善柴油机的燃烧和排放性能,可应用于柴油机高负荷和低过量空气系数工况综合性能提升。研究结果可为柴油机燃烧系统开发和改进提供参考。     

Apparent digestibility coefficients of animal and plant feed ingredients for juvenile Pseudobagrus ussuriensis

A study was conducted to determine apparent digestibility coefficients (ADCs) of dry matter (DM), crude protein (CP), lipid, gross energy, phosphorus and amino acids (AAs) from Peruvian fish meal (PFM), native fish meal (NFM), meat bone meal (MBM), dried daphnia meal (DDM), soybean meal (SBM), full‐fat soybean (FSBM), cottonseed meals (CSM), rapeseed meal (RSM) and corn gluten meal (CGM) for Pseudobagrus ussuriensis (7.8 ± 0.06 g). Test diets were formulated to contain a 70:30 mixture of reference diet to test ingredient with chromic oxide (5 g kg^–1) serving as the inert marker. ADCs of DM ranged from 49.94% (CGM) to 87.11% (PFM), the highest ADCs of DM were observed in PFM and the lowest was found in CGM. ADCs of CP in the test ingredients ranged from 74.92% (CGM) to 93.41% (SBM). ADCs of crude lipid ranged from 51.80% (CGM) to 94.07% (PFM) for fish. ADCs of energy ranged from 56.42% (CGM) to 90.09% (PFM). ADCs of phosphorus ranged from 21.81% (CSM) to 65.70% (PFM). AA availability for the test ingredients followed a similar pattern to ADCs of CP, in which values for PFM, NFM and MBM were generally higher (p < .05) than those of other protein ingredients. Among all plant meals, the AA availability values in SBM were higher (p < .05) than those in CGM, CSM and RSM. The availability of most AAs in CGM was the lowest (p < .05) among all tested ingredients. In conclusion, PFM and NFM are good sources of available protein and AAs. When fishmeal supply is limited, MBM and DDM are substitutes for fishmeal reduction in P. ussuriensis diets; at the same time, SBM and FSBM are also very acceptable protein feedstuffs. However, CSM, RSM and CGM could not be used at high levels in P. ussuriensis diets because of their inferior digestibilities.     

Increased N fertilizer input enhances CH4 and N2O emissions from soil amended with low amount of milk vetch residues

Paddy and Water Environment - The combined use of chemical N fertilizer and crop residue could influence greenhouse gas emissions in agriculture. A pot experiment was performed to examine the...     

寒地玉米多级顺流干燥工艺参数优化

为解决目前北方寒地玉米干燥加工中存在的干燥效率低、设备能耗大和干制品品质差等问题,利用自行设计的多级顺流式谷物干燥试验台,对北方寒地玉米多级顺流干燥特性和干燥加工工艺参数进行了研究。通过二次通用旋转组合试验设计方法,探讨热风温度、热风风速、干燥时间对设备单位能耗和干后玉米品质的影响,建立了相应的数学模型。将多目标综合优化,确定了干燥工艺的最优参数:热风温度103℃、热风风速1.5m/s、干燥时间100min。在此工艺参数条件下,有效地提高了干燥效率,降低了设备单位能耗及玉米干燥过程中营养成分的损失,达到了玉米保质干燥的目的。该研究旨在为北方寒地玉米干燥工业提供了理论基础。     

A Novel and Reliable Spectrophotometric Method for Determination of Lactoperoxidase Activity in Raw Milk

With 3, 3'5, 5'-tetramethylbenzidine(TMB) as the detection substrate, a reliable and highly selective method was established and optimized for the determination of Lactoperoxidase(LP) activity in raw milk. The method was based on the enzymatic reaction principle, where hydrogen peroxide oxidated TMB in the presence of LP. The optimized conditions of this assay system were obtained, consisting of 20 mmol · L~(-1) TMB solution, 0.6 mmol · L~(-1) hydrogen peroxide and 0.1 mol · L~(-1) Citric Acid(CA)/0.2 mol · L~(-1) disodium hydrogen phosphate(Na P) buffer(pH 4.8). TMB detection method was applied to the analysis of LP in milk samples with a practical working concentration range from 2 to 14 mg · L~(-1). The intra-and inter-batch variation coefficients were all below 5%, indicating a good repeatability. Confirmation test between TMB method and 2, 2-azinobi(3-ethylbenzothiazoline-6-sulphonate) diammonium salt(ABTS) method was carried out, and the results of TMB assay were in accordance with that of ABTS method.     

小卷蛾斯氏线虫对辣椒烟粉虱的控制作用

本文研究了小卷蛾斯氏线虫Steinernema carpocapsae对烟粉虱Bemisia tabaci的侵染能力以及对田间辣椒烟粉虱的控制作用。结果表明，室温（28±2）℃，空气湿度（60±5）%，辣椒叶背面湿润的条件下，线虫约在4 h侵入烟粉虱若虫体内，2～3 d内致其死亡。不同浓度线虫对烟粉虱若虫的控制效果不同，小卷蛾斯氏线虫All品系22、16和13 IJs/mL对烟粉虱高龄（3龄和4龄）若虫的致死率分别为42.79%，34.74%，29.31%，对低龄（1龄和2龄）若虫的致死率分别为44.58%、41.66%、39.61%。助剂5% d-柠檬烯可溶液剂与线虫联合使用具有促进效果，线虫稀释22 IJs/mL，配合1000倍液5% d-柠檬烯可溶液剂时效果最佳，高龄若虫和低龄若虫的致死率分别达到60.61%和61.55%。田间辣椒叶片表面施水量对烟粉虱的防治效果存在明显的影响，在田间施水1.5、1、0.5 L/m²的条件下，高龄若虫校正死亡率分别为66.49%、66.50%、47.78%，低龄若虫校正防治效果分别为69.30%、58.52%、51.83%。综上，喷施小卷蛾斯氏线虫对烟粉虱有一定的控制效果，配合助剂5% d-柠檬烯可溶液剂有促进作用，保持辣椒叶片表面湿润可以提高对烟粉虱的防治效果。     

秸秆粉碎机实际生产效能改进研究

随着我国生物质能开发与利用地不断提高,生物质颗粒燃料需求量逐年提高,生物质颗粒燃料生产逐步向规模化、效益化方向发展,秸秆等生物质的粉碎则至关重要。分析各种锤片式粉碎机在实际生产过程中的效能,并与改进后的粉碎机效能进行对比,以提高现有秸秆粉碎机效能,逐步标准化各主要部件,为生物质颗粒燃料规模化生产提供基础保障。     

增温加氮对两种不同来源加拿大一枝黄花子一代生长的影响

为探讨模拟气候变暖(增温2℃)和大气氮沉降(4 g·m-2·a-1)对入侵植物子代生长的影响,以中国和北美两种来源的加拿大一枝黄花子一代为研究对象,研究了子一代幼苗的生长和生物量分配的响应.结果表明:(1)增温降低中国来源加拿大一枝黄花的地上生物量,但提高其根冠比,增温降低北美来源加拿大一枝黄花的根冠比;(2)与北美来源加拿大一枝黄花相比,加氮对中国来源加拿大一枝黄花叶片数、地下生物量和总生物量的促进作用更大;(3)加氮促进加拿大一枝黄花地上生物量、地下生物量和总生物量的积累,但增温减缓了这种促进作用.这些结果表明,气候变暖可能会部分抵消氮沉降对加拿大一枝黄花子一代幼苗生长的促进作用.     

南方双季稻区小行距插秧机的改进设计与试验

针对300mm行距插秧机在南方双季稻区栽插行距过大、穴数过少及不能充分发挥机插稻的增产潜力问题,在300mm行距插秧机结构的基础上,通过机械优化设计和田间农艺技术相结合的方法,对其插植部箱体、苗箱、支架(包括左右支架和中间支架)和浮板4个关键部位技术参数改进设计,研制出了适合南方双季稻区作业的2ZS-488B型(264mm行距)插秧机,并于2012-2013年在江西省2个试验点进行不同早晚稻品种机插行距的大田对比试验。结果表明:该插秧机作业性能稳定,漂秧率、伤秧率和漏插率分别为1.55%、2.68%和1.93%,相对均匀度合格率为89.54%。与300mm行距插秧机相比,其产量平均增产529.43kg/hm2,平均增产率达8.57%。该研究结果创新了南方双季稻区新的机械化栽插方式,有利于农机农艺的有效融合。     

添加复合酶对临武鸭瓜尔豆胚芽养分、氨基酸和能量利用率的影响

本试验旨在研究添加复合酶对临武鸭瓜尔豆胚芽养分、氨基酸和能量利用率的影响。试验选用24只体重2.0 kg左右的健康成年临武鸭公鸭,随机分为3组,每组8个重复,每个重复1只鸭。采用绝食强饲-全收粪法进行代谢试验。1、2组试验鸭每只强饲60 g/d饲粮,2组饲粮中添加250 mg/kg的复合酶,3组强饲60 g/d无氮饲粮。测定添加复合酶对临武鸭瓜尔豆胚芽中干物质(DM)、粗蛋白质(CP)、粗脂肪(EE)、粗纤维(CF)和17种氨基酸的表观利用率、真可利用率、表观代谢能(AME)和真代谢能(TME)。结果表明,临武鸭对瓜尔豆胚芽DM、CP、EE、CF和能量的真可利用率分别为67.07%、67.57%、65.52%、82.88%和77.39%,AME和TME分别为11.34和13.31 MJ/kg,17种氨基酸的真可利用率为67.72%~93.70%;添加复合酶使临武鸭的DM、CP、EE、CF和能量的真可利用率分别提高了5.23%、8.02%、5.80%、3.66%和3.31%(P0.05),AME和TME分别提高了3.97%和3.27%(P0.05),17种氨基酸的真可利用率提高了1.73%~11.62%,其中丝氨酸、甘氨酸、亮氨酸、酪氨酸和苯丙氨酸的真可利用率显著提高(P0.05)。由此可知,添加含有蛋白酶和非淀粉多糖酶的复合酶能够提高临武鸭对瓜尔豆胚芽中养分、氨基酸和能量的利用率。