Composition, Digestibility and Application in Breadmaking of Banana Flour

Banana flour (BF) was obtained from unripe banana (Musa paradisiacal L.) and characterized in its chemical composition. Experimental bread was formulated with BF flour and the product was studied regarding chemical composition, available starch (AS), resistant starch (RS) and rate of starch digestion in vitro. The chemical composition of BF showed that total starch (73.36%) and dietary fiber (14.52%) were the highest constituents. Of the total starch, available starch was 56.29% and resistant starch 17.50%. BF bread had higher protein and total starch content than control bread, but the first had higher lipid amount. Appreciable differences were found in available, resistant starch and indigestible fraction between the bread studied, since BF bread showed higher resistant starch and indigestible fraction content. HI-based predicted glycemic index for the BF bread was 65.08%, which was significantly lower than control bread (81.88%), suggesting a “slow carbohydrate” feature for the BF-based goods. Results revealed BF as a potential ingredient for bakery products containing slowly digestible carbohydrates.     

Isolation and Partial Characterization of Mango (Magnifera indica L.) Starch:Morphological,Physicochemical and Functional Studies

Mango (Mangifera indica) is a fruit that grows in tropical regions. The aim of this work was to isolate the starch from two varieties of mango highly consumed in Mexico (criollo and manila), and to evaluate its chemical composition, along with some morphological, physicochemical and functional properties. Mango starch had an amylose content of about 13%, the fat content of criollo variety starch (0.1–0.12%), was similar to that of commercial corn starch used as control (0.2%); both mango starches had higher ash amount (0.2–0.4%) than corn starch. Mango starches presented a smaller granule size (10 m) than corn starch (15 m), along with an A-type X-ray diffraction pattern with slight tendency to a C-type. All values of water retention capacity (WRC) increased with the temperature. When the temperature increased, solubility and swelling values increased and in general, mango starches had higher values than corn starch. Both mango starches had gelatinization temperatures lower than the control, butcriollo variety starch presented higher enthalpy values thanmanila variety and corn starches. Overall, it was concluded that due to its morphological, physicochemical and functional properties, mango starches could be a feasible starch source with adequate properties, suitable for using in the food industry.     

4个抗枯萎病香蕉品种果实性状和品质比较

香蕉枯萎病是危害全球香蕉产业发展的主要病害,选育抗病品种是控制枯萎病的有效措施,而开展抗病香蕉品种的果实特性及品质研究是选育和推广抗病品种的基础。本研究通过以巴西蕉为对照,对4个香蕉枯萎病抗性品种的果实特性、果实品质及感官评价进行分析。结果表明,‘中蕉9号’的单穗重、果梳数和果指直径显著高于巴西蕉,单株产量比巴西蕉增加21.9%,而‘南天红’和‘南天黄’的单穗重、果梳重及果指数均显著低于巴西蕉,‘中蕉4号’的果实性状则与巴西蕉无显著差异。‘南天红’的含水量显著高于巴西蕉,其他3个品种的含水量则与巴西蕉无显著差异。‘中蕉4号’的可食用率显著高于巴西蕉,其他3个品种的可食用率与巴西蕉无显著差异。‘中蕉9号’的果实硬度和维生素C含量显著低于巴西蕉,而可溶性固形物含量则显著高于巴西蕉。‘中蕉9号’和‘南天红’的单宁含量显著低于巴西蕉,‘南天黄’的单宁含量则显著高于巴西蕉。‘南天红’和‘中蕉9号’的果肉色泽、气味、甜味及口感等感官评价显著高于巴西蕉,其他2个品种则与巴西蕉无显著差异。隶属函数法综合分析表明,4个抗枯萎病香蕉品种的综合表现可分为3个等级,‘南天红’和‘中蕉9号’为第1等级,‘中蕉4号’为第2等级,‘南天黄’为第3等级。综上,‘中蕉9号’的单株产量高、综合性状优异,可进一步开展大面积的示范推广。     

Physical and biochemical properties of green banana flour

Banana flour prepared from two cooking banana varieties, namely Alukehel and Monthan, were evaluated for their physical and biochemical characteristics. The yields of flour averaged 31.3% for Alukehel and 25.5% for Monthan. The pH of the flour ranged from 5.4 to 5.7. The bulk density and particle size distribution were also measured. The average chemical composition (% dry matter) of the flours were as follows: crude protein, 3.2; crude fat, 1.3; ash, 3.7; neutral detergent fiber, 8.9; acid detergent fiber, 3.8; cellulose, 3.1; lignin, 1.0 and hemicellulose, 5.0. Carbohydrate composition indicated the flour to contain 2.8% soluble sugars, 70.0% starch and 12.0% non-starch polysaccharides. Potassium is the predominant mineral in banana flour. Fresh green banana is a good source of vitamin C, but almost 65% is lost during the preparation of flour. Oxalate content (1.1–1.6%) of banana flour is probably nutritionally insignificant. The overall results are suggestive of the potential of green bananas as a source of flour.     

Effect of Cooking Procedures and Storage on Starch Bioavailability in Common Beans (<Emphasis Type="Italic">Phaseolus vulgaris</Emphasis> L.)

Common commercial beans were cooked using two procedures: under pressure (autoclaving) and traditional cooking. Total starch extraction was higher in beans cooked with the traditional procedure (41.69–42.81%) than in the autoclaved samples (37.04–38.16%) and did not change during storage at 4 °C. However, available and total resistant starch levels in vitro were not influenced by the cooking procedure or storage. Retrograded resistant starch content was higher in beans cooked with the traditional process (2.65–2.79%) than in autoclaved beans (1.62–1.94%). The initial in vitro -amylolysis rate in freshly cooked beans was higher in the autoclaved preparation than in the beans cooked by the traditional process, but final hydrolysis indices (90 min) were similar for both samples. None of the bean samples showed statistical differences in -amylolysis behavior (=0.05) after storage at 4 °C for 96 hour.     

Physicochemical Properties of Cissus Gum Powder Extracted with the Aid of Edible Starches

Gum powder was extracted from the stem and root of the cissus (Cissus populnea Guill and perr Ampelidacae) plant using water. Extraction was facilitated by the incorporation of 25–50% edible starches of sweet cassava, sweet potato, and maize. Dry samples were milled and sieved through a 250-m sieve. Proximate and physicochemical properties of the gum samples were determined using standard methods. Results of the proximate analyses showed that protein and ash contents of the root gum were appreciably higher than those of the stem gum. Values of the crude fiber and ether extract of the root gum were lower than those of the stem gum. Inclusion of edible starches in the extraction process appreciably lowered proximate values. Results of the physicochemical properties showed that cissus gum samples did not form true gel but a putty-like mass. Addition of starches at various levels did not alter the characteristic putty-like nature of the gum. The gum samples had a remarkably low oil absorption capacity. Cissus gum samples had appreciably higher emulsion capacity and stability than the samples containing starch. The pH of the cissus gum powder and those of the starch-containing samples lie in the low-acid range (5.69–6.49). Cissus gum samples were highly hygroscopic; however, the addition of starch lowered the hygroscopicity. Incorporation of 25% starch into cissus mucilage enhanced extraction of the gum without adverse alteration of the physicochemical properties.     

Tocotrienol and fatty acid composition of barley oil and their effects on lipid metabolism

Barley oil was extracted with hexane from the grain of a high oil waxy hull-les barley. Twelve male broiler chicks were fed corn-based diets with either 10% barley oil, 10% corn oil or 10% margarinead libitum for ten days. Total plasma cholesterol concentration of the chicks fed barley oil was 34% lower (p<0.05) than that of the chicks fed margarine. Plasma low density lipoprotein cholesterol concentration of chicks fed barley oil was 53% and 59% lower (p<0.05) than those of chicks fed corn oil and margarine, respectively. Plasma high density lipoprotein cholesterol and triglyceride concentration of the barley oil group were similar to those of the margarine but higher (p<0.05) than those of the corn oil group. Chicks fed the barley oil gained more (p<0.05) body weight than those fed the corn oil and margarine. Barley oil had an effect in suppression of TC and LDLC in chicks compared to margarine. Barley oil supressed LDLC but not HDLC in chicks compared to corn oil. A greater weight gain of the chicks fed barley oil suggested that these chicks had normally functioning digestion and absorption. -Tocotrienol and -tocotrienol content of the barley oil were 24 and 17 times greater, respectively, than those observed in the corn oil, while the same fractions were not detectable in the margarine. Polyunsaturated fatty acid content of the barley oil was more than threefold that of margarine. These data suggest that -tocotrienol and polyunsaturated fatty acids are hypocholesterolemic components in barley oil.Contribution No. J-2617, Montana Agricultural Experiment Station. This research was supported, in part, by grants from the Montana Wheat and Barley Committee, Great Falls, MT and Ross Laboratories, Columbus, OH.     

In Vitro Colonic Fermentation and Glycemic Response of Different Kinds of Unripe Banana Flour

This work aimed to study the in vitro colonic fermentation profile of unavailable carbohydrates of two different kinds of unripe banana flour and to evaluate their postprandial glycemic responses. The unripe banana mass (UBM), obtained from the cooked pulp of unripe bananas (Musa acuminata, Nanicão variety), and the unripe banana starch (UBS), obtained from isolated starch of unripe banana, plantain type (Musa paradisiaca) in natura, were studied. The fermentability of the flours was evaluated by different parameters, using rat inoculum, as well as the glycemic response produced after the ingestion by healthy volunteers. The flours presented high concentration of unavailable carbohydrates, which varied in the content of resistant starch, dietary fiber and indigestible fraction (IF). The in vitro colonic fermentation of the flours was high, 98% for the UBS and 75% for the UBM when expressed by the total amount of SCFA such as acetate, butyrate and propionate in relation to lactulose. The increase in the area under the glycemic curve after ingestion of the flours was 90% lower for the UBS and 40% lower for the UBM than the increase produced after bread intake. These characteristics highlight the potential of UBM and UBS as functional ingredients. However, in vivo studies are necessary in order to evaluate the possible benefic effects of the fermentation on intestinal health.     

Chemical Composition and Nutritional Value of Unripe Banana Flour (<Emphasis Type="Italic">Musa acuminata</Emphasis>, var. Nanicão)

Banana flour obtained from unripe banana (Musa acuminata, var. Nanicão) under specific drying conditions was evaluated regarding its chemical composition and nutritional value. Results are expressed in dry weight (dw). The unripe banana flour (UBF) presented a high amount of total dietary fiber (DF) (56.24 g/100 g), which consisted of resistant starch (RS) (48.99 g/100 g), fructans (0.05 g/100 g) and DF without RS or fructans (7.2 g/100 g). The contents of available starch (AS) (27.78 g/100 g) and soluble sugars (1.81 g/100 g) were low. The main phytosterols found were campesterol (4.1 mg/100 g), stigmasterol (2.5 mg/100 g) and β-sitosterol (6.2 mg/100 g). The total polyphenol content was 50.65 mg GAE/100 g. Antioxidant activity, by the FRAP and ORAC methods, was moderated, being 358.67 and 261.00 μmol of Trolox equivalent/100 g, respectively. The content of Zn, Ca and Fe and mineral dialyzability were low. The procedure used to obtain UBF resulted in the recovery of undamaged starch granules and in a low-energy product (597 kJ/100 g).     

Significance of furosine as heat-induced marker in cookies

The effects of recipe formulation in terms of leavening agents (ammonium and sodium bicarbonates), sugars (sucrose and glucose), initial moisture content, and baking conditions (temperature and time) on furosine formation in cookies were studied. The cookies were baked at different temperatures for different times to monitor the progress of the early stage of the Maillard reaction. Change in furosine levels as an indicator of the Amadori products showed a typical kinetic behavior with a rapid increase to an apparent maximum followed by exponential decrease during baking. Initial water activity of cookie dough had no remarkable effect on the apparent maximum, but lowering the water activity decreased the time required to attain it. In addition, levels of furosine in the final product are highly correlated to the initial water content of dough at the same baking conditions. The levels of furosine attained were significantly lower in cookies composed of sucrose than in cookies composed of glucose. Early stage of the MR is rapidly overcome during baking as the Amadori product degraded in the advanced stage. Among the leavening agents, ammonium bicarbonate was the most effective for the progress of the Maillard reaction in cookies during baking.     

Significance of furosine as heat-induced marker in cookies

The effects of recipe formulation in terms of leavening agents (ammonium and sodium bicarbonates), sugars (sucrose and glucose), initial moisture content, and baking conditions (temperature and time) on furosine formation in cookies were studied. The cookies were baked at different temperatures for different times to monitor the progress of the early stage of the Maillard reaction. Change in furosine levels as an indicator of the Amadori products showed a typical kinetic behavior with a rapid increase to an apparent maximum followed by exponential decrease during baking. Initial water activity of cookie dough had no remarkable effect on the apparent maximum, but lowering the water activity decreased the time required to attain it. In addition, levels of furosine in the final product are highly correlated to the initial water content of dough at the same baking conditions. The levels of furosine attained were significantly lower in cookies composed of sucrose than in cookies composed of glucose. Early stage of the MR is rapidly overcome during baking as the Amadori product degraded in the advanced stage. Among the leavening agents, ammonium bicarbonate was the most effective for the progress of the Maillard reaction in cookies during baking.     

叶面喷施冠菌素对香蕉幼苗耐寒性的影响

以生长一致、有6片展开叶的威廉斯香蕉幼苗为试验材料,研究0（CK）、1、5、10μmol/L4个浓度的冠菌素喷洒香蕉幼苗后对香蕉幼苗耐寒性的影响。结果表明,1～10μmol/L浓度范围的冠箘素对提高香蕉幼苗抗寒性的效果不明显,并且呈浓度越高反而效果越差的趋势。只有1μmol/L的冠箘素对提高香蕉幼苗的SOD总活性、可溶性糖含量和叶绿素含量,以及降低相对电导率和丙二醛含量具有一定的作用,其中对提高可溶性糖含量的效果最明显,但是没有提高POD活性的效应。     

减量施氮对蕉园土壤养分、农艺性状及产量的影响

香蕉生产中偏施氮肥的现象仍然普遍存在,减少氮肥投入是有效实现化肥总量施用措施。本研究在传统施肥水平基础上,梯度降低氮肥的施用量,测定蕉园土壤养分淋失、农艺性状及产量等指标。结果表明：不同生长期各处理株高、茎围和青叶数等指标均比对照处理生长效果好,在营养生长期株高、茎围及青叶数最高值为T3、T3、T4处理,分别比对照(CK)高14.2%、16%和19.8%,与对照处理(CK)达到显著差异;减少氮肥使用可有效降低氮肥的淋溶,其中在T1～T5处理20～60 cm土层NH4+-N含量较对照分别减少了47.4%、51.3%、30.5%、58.3%和92.1%;施用70%当量氮肥,香蕉产量和经济效益最优, 分别比对照和常规性施肥每公顷增加26.4%和4.8%。     

Estimated Glycemic Index and Dietary Fiber Content of Cookies Elaborated with Extruded Wheat Bran

The increasing demand for high-fiber products has favored the design of numerous bakery products rich in fiber such as bread, cookies, and cakes. The objective of this study was to evaluate the dietary fiber and estimated glycemic index of cookies containing extruded wheat bran. Wheat bran was subjected to extrusion process under three temperature profiles: TP1;(60, 75, 85 and 100 °C), TP2;(60, 80, 100 and 120 °C), and TP3;(60, 80, 110 and 140 °C) and three moisture contents: (15, 23, and 31 %). Cookies were elaborated using extruded wheat bran (30 %), separated into two fractions (coarse and fine). The dietary fiber content of cookies elaborated with extruded wheat bran was higher than the controls; C0 (100 % wheat flour) and C1 (30 % of no extruded bran coarse fraction) and C2 (30 % of no extruded bran fine fraction). The higher values of dietary fiber were observed on cookies from treatments 5 (TP1, 31 % moisture content and coarse fraction) and 11 (TP2, 31 % moisture content and coarse fraction). The estimated glycemic index of cookies ranged from 68.54 to 80.16. The dietary fiber content of cookies was increased and the lowest glycemic index corresponded to the cookies elaborated with extruded wheat bran. Cookie made with the treatment 11 had a better dietary fiber content and lower estimated glycemic index.     

Properties of starch-based foam formed by compression/explosion processing

Single-use foam packaging is used by manufacturers to protect and preserve a wide array of food and industrial products. Starch is one possible alternative material for making foam products. Starch-based foam was made using a compression/explosion process to study its properties and potential for single-use packaging. A feedstock was first prepared which consisted of wheat (WS), corn (CS) or potato starch (PS) that was formed into aggregates (1–3 mm) and conditioned to moisture levels ranging from 8 to 20%. The conditioned aggregates were loaded in an aluminum compression mold heated to 230°C and compressed for 10 s with 3.5 MPa force. The force was instantaneously released resulting in an explosive release of steam as the starch feedstock expanded and filled the mold. The moisture content of the feedstock influenced the density and compressive properties of the foam. Wheat, corn and potato starch feedstock with 17, 17 and 14% moisture content, respectively, produced foam with some physical and mechanical properties similar to those of commercial food containers. The starch foam had the general shape of the mold and appeared similar to polystyrene. The microstructure of the foam revealed a cellular structure with mostly closed cells less than 1 mm in diameter. However, some regions of the foam had a microstructure similar to that of expanded polystyrene except that the cells were much smaller (<0.1 mm).     

菠萝蜜种子淀粉体外消化酶解动力学及血糖值分析

以菠萝蜜种子为原料提取淀粉,以木薯淀粉、大米淀粉、玉米淀粉和马铃薯淀粉为参照,采用体外消化试验测定菠萝蜜种子淀粉的快速消化淀粉、慢消化淀粉和抗性淀粉含量,并进行酶解动力学实验。结果表明:菠萝蜜种子淀粉快速消化淀粉、慢消化淀粉和抗性淀粉的含量分别为4.50%、19.65%和75.85%,酶解速率为0.60 h-1,平衡浓度为36.93%,酶解指数为41.43,血糖指数为62.45,属于中等血糖食物;菠萝蜜种子淀粉消化性、平衡浓度、酶解指数与血糖指数均高于马铃薯淀粉,而低于其他三种淀粉,酶解速率比马铃薯淀粉、木薯淀粉快,比大米淀粉、玉米淀粉慢。      

Protein and starch digestibilities and mineral availability of products developed from potato,soy and corn flour

A technique for development of potato flour was standardized. Five products viz. cake, biscuit, weaning food, panjiri and ladoo were prepared incorporating potato flour, defatted soy flour and corn flour. Baking and roasting were the major processing techniques employed for the development of these products. Protein, ash and fat contents of potato flour were almost similar to those of raw potatoes. Significant differences in protein, ash and fat contents of all the products were observed. Protein and starch digestibility of potato flour was significantly higher than that of raw potatoes. Protein digestibility increased by 12 to 17 percent on baking or roasting of products. Processed products had significantly higher starch digestibility and mineral availability compared to raw products. Thus, it can be concluded that roasting and baking are effective means of improving starch and protein digestibility and mineral availability of products.     

Gluten free rice cookies with resistant starch ingredients from modified waxy rice starches: Nutritional aspects and textural characteristics

Experimental gluten-free (GF) rice cookies were formulated with 100% rice flour (CTR) or by substituting 50% of rice flour with native waxy rice starch (WRS) or with three different resistant starch (RS) ingredients obtained from debranched, annealed or acid and heat-moisture treated WRS (RS_a, RS_b and RS_c, respectively). Chemical composition, in vitro starch digestibility and physical and textural characteristics were carried out. Among cookies, RS_a-cookies had the highest total dietary fibre content, the lowest rapidly digestible starch and the highest RS contents. All the three RS preparations have proved effective in increasing the proportion that tested as RS with respect to native WRS. However, the estimated RS loss for each applied RS ingredients caused by the baking process followed the order of RS_a < RS_c < RS_b. Last, the lowest vitro glycaemic index value was measured for RS_a-cookies. Among cookies, differences in colour and hardness were reported. The partial replacement of commercial rice flour with RS_a could contribute to formulate GF cookies with higher dietary fibre content and likely slowly digestible starch properties more than equivalent amounts of RS_b and RS_c.     

高直链淀粉玉米和普通玉米子粒发育过程中与淀粉合成相关酶活性的比较

对高直链淀粉玉米和普通玉米子粒发育过程中与淀粉合成相关酶活性的变化动态进行了比较研究。结果表明,高直链淀粉玉米子粒发育过程中,束缚态淀粉合成酶(GBSS)活性高于普通玉米,可溶性淀粉合成酶(SSS)和淀粉分支酶(SBE)活性低于普通玉米。高直链淀粉玉米总淀粉积累量少、直链淀粉比例大是SSS、GBSS和SBE综合作用的结果。     

Characteristics of biodegradable Mater-Bi®-starch based foams as affected by ingredient formulations

Expanded polystyrene (EPS) foams are widely used to provide protection to merchandise during shipping and handling. The disposal of EPS foams, however, causes pollution to the environment. Starch based loose fill packaging foams are commercially available to replace the EPS foams. Starch foams dissolve readily in water, and do not possess satisfactory physical and mechanical properties. To improve the functional properties and water resistance of starch foams, regular (25% amylose) and waxy corn starches blended with Mater-Bi® ZF03U (MBI) were extruded into loose-fill packaging foams using a co-rotating twin screw extruder. MBI contents of 10, 25 and 40% and starch moisture contents of 19, 22 and 25% (d.b.) were used. Waxy starch produced foam with greater radial expansion and lower unit and bulk densities than regular starch. Higher levels of MBI reduced radial expansion and increased unit and bulk densities. Foam made with regular starch had a lower water solubility index than foam made with waxy starch. The addition of MBI improved the water solubility. Higher starch moisture contents increased foam water solubility indices. Foams made from both types of starch possessed acceptable mechanical properties. Regular starch produced more rigid foams than the waxy starch as indicated by the higher compressibility values based on both single-piece and bulk samples. Moisture content affected the compressibilities. Higher moisture contents produced more rigid foams. The spring indices of bulk samples were excellent (>95%) for all MBI contents.