草莓浑浊汁维生素C降解动力学模型

为了弄清贮藏温度对草莓浑浊汁内维生素C降解的影响,建立其降解动力学模型,为选择草莓浑浊汁的贮藏温度提供依据。该文通过研究草莓浑浊汁贮藏过程中还原型维生素C和氧化型维生素C的降解与贮藏温度、贮藏时间的关系,建立了还原型维生素C和氧化型维生素C降解动力学模型。结果表明：草莓浑浊汁在贮藏过程中还原型维生素C和氧化型维生素C对热不稳定,还原型维生素C和氧化型维生素C降解符合一级反应动力学。经过验证表明该降解动力学模型有效,可用于草莓浑浊汁贮藏温度的选择和预测不同温度下的贮藏期。     

加工过程中冷打浆沙棘浓缩浊汁理化特性的变化

为了研究沙棘浓缩浊汁加工及其品质的变化,该文以沙棘果为原料,研究了冷打浆法生产沙棘浊汁及浓缩浊汁加工和贮藏过程中的理化变化。结果表明:冷打浆工艺制得到的沙棘浊汁品质优良,其可溶性固形物质量分数高达18.0%,总酸度达4.24%,含维生素C 729.69 mg/100 mL,总黄酮445.17 mg/100 mL,总多酚924.67 mg/100 mL,多糖25.22 mg/100 mL。在45℃,真空度为0.095~0.1 MPa的条件下对沙棘浊汁减压浓缩,随着浓缩倍数的增加,加热时间延长,沙棘浊汁营养和保健成分减少,总酸度增加,pH值减小,褐变指数增大,5-HMF含量增加;与3倍和4倍沙棘浓缩浊汁相比,2倍沙棘浓缩浊汁营养和保健成分保存率最高,褐变指数较小、5-HMF含量较低。不同浓缩倍数的沙棘浊汁在自然室温(10~25℃)和冷藏条件(5~8℃)下放置60 d,维生素C、总黄酮、总多酚和多糖含量呈下降趋势,pH值和总酸度变化不明显,褐变指数增加,5-HMF含量增加;相同浓缩倍数的沙棘浊汁在冷藏条件下放置比在自然室温条件下放置时营养和保健成分的保存率高,冷藏条件下2倍沙棘浓缩浊汁的营养和保健成分的保存率最高,其维生素C、总黄酮、总多酚、多糖的保存率比室温条件下2倍沙棘浓缩浊汁分别高11.46%、20.44%、18.37%、9.83%,且冷藏条件下放置的沙棘浓缩浊汁褐变指数小,5-HMF含量低,冷藏条件有利于沙棘浓缩浊汁的保存;2倍沙棘浓缩浊汁在室温条件下贮藏不稳定,在冷藏条件下其贮藏稳定性优于3倍和4倍沙棘浓缩浊汁。     

大蒜精油-羧甲基纤维素钠复合涂膜提高草莓贮藏效果

为了减少草莓在贮藏过程中的腐败变质延长草莓保质期,在质量分数为1.0%的羧甲基纤维素钠溶液中添加大蒜精油(体积分数:0、2、4、6μL/100 m L)制成复合溶液作为涂膜材料,涂膜液浸泡30 s于新鲜草莓表面,分析草莓在(20±2)℃贮藏过程中的品质变化。结果表明,与对照组未涂膜相比,大蒜精油-羧甲基纤维素钠复合涂膜材料能显著(P0.05)降低草莓在贮藏过程中的的呼吸作用强度和腐烂变质(P0.05),减少果实失重率;延缓草莓果实花色苷的分解,有良好的护色作用;另外,大蒜精油-羧甲基纤维素钠复合涂膜材料减少了草莓中可滴定酸度、维生素C、可溶性固形物的分解及丙二醛的累积。综合不同处理组草莓在贮藏过程中的品质变化,确定当大蒜精油添加量为4μL/100 m L时,草莓有较佳的保鲜效果,可为草莓果实的贮藏保鲜方法提供参考。     

短波紫外线处理对采后香菇褐变的影响

为了控制采后香菇在贮藏过程中的褐变并提高其贮藏品质,本试验采用不同剂量(2、4、6和8 kJ·m^-2) 短波紫外线(UV-C)对新鲜香菇进行预处理,研究不同剂量UV-C处理对香菇色泽、总酚含量、多酚氧化酶(PPO)活性、过氧化物酶(POD)活性、超氧化物歧化酶(SOD)活性、过氧化氢酶(CAT)活性、苯丙氨酸解氨酶(PAL)活性、可溶性蛋白含量、还原糖含量、游离氨基酸含量以及香菇表面微生物的影响。结果表明,UV-C处理延缓了香菇色泽的下降,保持了较高的总酚含量,并且有利于POD、SOD、CAT和PAL活性维持在较高水平,抑制了PPO活性,同时可以保持较高的还原糖和可溶性蛋白含量,在一定程度上延缓了蛋白质的降解,而且可以有效抑制微生物的生长,其中4 kJ·m^-2 UV-C处理效果最佳。综上所述,UV-C处理可以有效地抑制香菇褐变,延长其贮藏期。本研究结果为香菇的贮藏保鲜提供了理论依据。     

果胶酶对草莓果汁澄清效果的研究

澄清是果汁加工中的关键技术环节之一，利用果胶酶澄清果汁，有快速、简便、效果好等特点，在生产中有重要的应用价值。草莓中因含有果胶物质，制得的果汁易产生浑浊、沉淀等现象，严重影响产品的质量。用果胶酶对草莓果汁进行了单因素澄清试验及最适澄清工艺条件的研究。结果表明，果胶酶用量为0.035～0.075 mL/kg、温度35～45℃、pH 3.0～4.0的条件下澄清草莓果汁，透光率达97%以上，果汁中的可溶性固形物含量基本不变；在单因素试验的基础上，通过正交试验，果胶酶对草莓果汁澄清的最佳工艺条件是：果胶酶用量为0.035 mL/kg，温度为35℃，pH值为3.5。     

枸杞沙棘复合固体饮料的研究

以枸杞干果和沙棘为原料，经取汁、澄清、浓缩、调配和离心喷雾干燥等工艺生产复合固体饮料。试验结果得出较优的工艺及配方为：枸杞取汁工艺为破碎→热处理→压榨；用0.05% L-抗坏血酸和0.02% NaHSO₃护色枸杞汁；喷雾干燥使用助干剂麦芽糊精，用量占浓缩汁中可溶性固形含量的80%；饮料配方为浓缩枸杞汁与沙棘汁质量比是6∶2，蛋白糖、蔗糖、柠檬酸添加量分别为0.95%，4.0%和0.1%。     

苹果浑浊汁贮藏过程中浑浊稳定性的研究

为考察苹果浑浊汁在贮藏中的浑浊稳定性，进行了在4、22和40℃贮藏果汁120 d的试验。采用了电子显微镜学、光学显微镜学、Zeta电位和粒径分布分析等技术，结合高效液相色谱(HPLC)分析酚类物质进行研究。结果发现，果汁中相对大尺寸的颗粒先聚集下沉，造成浊度的迅速下降。随着留在瓶上部的大的颗粒数目的减小，颗粒下沉的速率降低。总酚、表儿茶素、绿原酸和单宁的损失随着贮藏温度的升高和储藏时间的延长增大。添加0.006%的维生素C可抑制由酚类物质的氧化聚合产生的不溶性小颗粒的产生，使果汁浊度变化减小。悬浮颗粒的尺寸大于其电性质对浑浊稳定性的影响。     

甘薯全粉加工中无硫复合护色工艺优化

为了优化甘薯全粉无硫复合护色工艺,该文通过考察柠檬酸、柠檬酸亚锡二钠、植酸、亚硫酸氢钠和抗坏血酸5种护色剂对甘薯全粉色泽的影响,优选出柠檬酸和抗坏血酸作为甘薯全粉加工合适的护色剂;通过正交试验,得到柠檬酸-抗坏血酸无硫复合护色剂的最佳护色工艺为:将10 mm厚的甘薯切片在质量分数为0.3%的柠檬酸和0.1%抗坏血酸的复合护色液中护色处理30 min,可使制得的甘薯全粉亮度值L*达90.58,多酚氧化酶的抑制率达88.13%.研究发现柠檬酸的添加能显著提高抗坏血酸的热稳定性;酶促褐变产物紫外-可见光谱扫描显示,加入复合护色剂后410 nm处吸收峰明显减弱,表明复合护色剂能有效抑制酶促褐变反应的发生;圆二色谱研究表明多酚氧化酶经复合护色剂处理后,酶蛋白二级结构中α-螺旋减少,而β-折叠结构增多,酶蛋白的分子构象被改变,从而降低多酚氧化酶活力.该文为甘薯全粉加工中的无硫复合护色工艺提供了参考.     

草莓涂膜保鲜研究

试验研究以"蜂胶/魔芋胶"为原料制成的复合保鲜液涂膜处理对草莓贮藏保鲜品质的影响,测定比较魔芋胶涂膜,蜂胶涂膜对草莓的感官品质、失重率、维生素C含量及可溶性固形物等指标的影响。结果表明:"蜂胶/魔芋胶"复合涂膜液对草莓保鲜效果较好,15d后的失重率仅为8.53%,维生素C含量为59.68mg/100g,可溶性固形物含量为7.26%。综合比较3种复合保鲜液,"蜂胶/魔芋胶"复合涂膜液有效地减少了营养成分和水分的损失,可延长货架期和保持其最佳食用品质。     

苹果液氮降温排氧打浆技术研究

为了抑制苹果制汁过程中的褐变，提高产品质量，该文首次采用自行设计的液氮降温排氧打浆机，对苹果打浆工艺进行了初步研究。具体研究了打浆时添加液氮后苹果浆温度、溶解氧含量、果浆颜色以及多酚氧化酶(PPO)和过氧化物酶(POD)活力等的变化。结果表明：添加1%～2%液氮后，苹果浆温度迅速降低为原来温度的50%，氧气含量降低为对比组的47.7%；果浆色泽L值为53.96，较对比组的L值高44.1％；同时可减少维生素C损失，提高苹果出汁率。     

微波预处理原料对苹果汁褐变的影响

为了防止苹果汁在贮藏过程中褐变,采用不同的微波功率和时间预处理原料苹果,研究微波预处理对苹果汁褐变的影响。结果表明,微波处理可以提高苹果汁的色值,降低多酚氧化酶的活性,引起氨基态氮含量的下降,并使苹果汁的酸度略微提高。在微波功率为720～900 W,处理时间75～125 s时,果汁色值较高。室温贮存45 d后,微波功率900 W,时间为100 s处理的果块,果汁色值为67.8,比未经微波处理的高91.5%。微波预处理是防止苹果汁褐变的一种简便安全、合理经济的加工方法。     

Effect of fining and filtration on the haze formation in bayberry (Myrica rubra Sieb. et Zucc.) juice

Bayberry juice was fined with the methods of xanthan/chitosan (XC) or gelatin/bentonite (GB), and then filtered with diatomaceous earth filtration (DF) or ultrafiltration (UF, MWCO 100 kDa). Their effects on juice haze formation were investigated. The XC fining method was more effective than the GB method in removal of the total monomeric anthocyanin, total phenolics, and protein, with less haze formed in the XC fined juice. The DF reduced 2-5% of the total phenolics and 21-23% of protein, while UF reduced 19-24% of the total phenolics and 34-38% of protein, respectively. The results showed that fining and then UF can reduce but cannot eliminate haze formation in bayberry juice. The storage temperature was a critical factor affecting haze formation, and the juice was more stable when stored at lower temperature (4 degrees C).     

Pineapple juice and its fractions in enzymatic browning inhibition of banana [Musa (AAA group) Gros Michel

The effectiveness of pineapple juice in enzymatic browning inhibition was evaluated on the cut surface of banana slices. After storage of banana slices at 15 degrees C for 3 days, pineapple juice showed browning inhibition to a similar extent as 8 mM ascorbic acid but less than 4 mM sodium metabisulfite. Fractionation of pineapple juice by a solid-phase C18 cartridge revealed that the directly eluted fraction (DE fraction) inhibited banana polyphenol oxidase (PPO) about 100% when compared to the control. The DE fraction also showed more inhibitory effect than 8 mM ascorbic acid in enzymatic browning inhibition of banana puree during storage at 5 degrees C for 24 h. Further identification of the DE fraction by fractionation with ion exchange chromatography and confirmation using model systems indicated that malic acid and citric acid play an important role in the enzymatic browning inhibition of banana PPO.     

Characterization of haze-active proteins in apple juice

The nature of the haze-active protein (HAP) in apple juice was investigated. Heat treatment removed protein indiscriminately while polyvinylpolypyrrolidone (PVPP) treatment was fairly specific for proteins of 15 and 28 kDa. Presumably, the PVPP bound to polyphenols, which in turn were complexed with protein. Three candidate apple HAPs were isolated. Two were extracted from juice with acetone and fractionated by hydrophobic interaction chromatography and solid phase extraction with C18 (HAP I) or SAX (HAP II) material. Hydroxyproline-rich protein was extracted from apple tissue (HAP III). The order of haze formation with tannic acid was gliadin > HAP III > HAP II > HAP I > bovine serum albumin, which shows increasing haze formation with increasing proline content. The sizes of HAP I, II, and III were 28, 15, and 12 kDa; the first two corresponded to the sizes of proteins removed by PVPP treatment and are involved in juice haze formation.     

高压CO2处理保持非还原桃汁的品质

采用高压CO2（high pressure carbon dioxide,HPCD）处理非还原（not from concentrate,NFC）桃汁,分析HPCD处理后NFC桃汁pH值、可溶性固形物、色泽、酚类和抗氧化活性等品质特性的变化,讨论HPCD对NFC桃汁品质的影响。NFC桃汁的pH值和可溶性固形物含量分别为3.82和10.3°Brix,HPCD处理后没有显著变化;HPCD处理后NFC桃汁颜色变暗,色泽参数L、a、b值显著降低,对应的褐变度提高;NFC桃汁中的主要酚类物质有儿茶素、绿原酸、新绿原酸和阿魏酸,HPCD处理后酚类物质含量没有显著变化;采用FRAP和1,1-二苯基苦基苯肼（1,1-diphenyl-picrylhydrazyl,DPPH）清除率2种方法测定NFC桃汁的抗氧化活性,2种方法的测定结果都表明 HPCD 处理后 NFC 桃汁的抗氧化活性提高,并且随着处理时间的延长而逐渐提高。以上结果表明HPCD能较好的保持NFC桃汁的品质,为非热加工技术应用于果蔬加工提供理论基础。     

Use of 2-furoylmethyl derivatives of GABA and arginine as indicators of the initial steps of maillard reaction in orange juice

The formation of 2-furoylmethyl derivatives of GABA (2-FM-GABA) and arginine (2-FM-Arg) as early indicators of nonenzymatic browning in different types of orange juice was studied. In dehydrated orange juice, the presence of 2-FM-GABA and 2-FM-Arg was detected from the first day of storage at 30 degrees C. In this type of juice, the content of these two compounds increased with temperature (30, 50 degrees C) and time (1-7 days) of storage. A noticeable increase in 5-hydroxymethylfurfural was only observed after 4 days of storage at 50 degrees C. No formation of 2-FM-GABA and 2-FM-Arg was detected in liquid orange juice heated under conditions similar to those used in the industry. These furoylmethyl derivatives were also found in commercial orange juice made from concentrates. A slight increase in their concentration was observed in the two samples stored during 8 months at room temperature. According to the results obtained, 2-FM-GABA and 2-FM-Arg contents could be suitable indicators to assess the main modifications due to Maillard reaction produced during the manufacture and/or storage of orange juice concentrates.     

gamma-Radiation influences browning, antioxidant activity, and malondialdehyde level of apple juice

Apple juice was gamma-irradiated at 5 degrees C at doses ranging from 0 to 8.9 kGy and then stored at 5 degrees C for 15 days. Ionizing radiation reduced the browning of apple juice and increased antioxidant activity measured by the ferric-reducing antioxidant power (FRAP) assay. The magnitude of changes increased with radiation dose. The level of malondialdehyde (MDA) measured using the thiobarbituric acid reactive substrates assay increased at radiation doses above 2.67 kGy. The browning of irradiated juices increased during storage at 5 degrees C, but the irradiated juices were still lighter than controls at the end of storage. Differences in FRAP values disappeared during early periods of storage while higher MDA levels were observed in irradiated samples during most of the storage period. Elimination of suspended matter from apple juice did not alter irradiation-induced changes in browning, FRAP, or MDA formation. As compared to irradiation conducted at 5 and 20 degrees C, treatment at -15 degrees C was less effective in reducing browning and in increasing MDA formation but elevated FRAP values. The exclusion of oxygen from juices did not affect the reduction in browning due to irradiation but promoted the increase in FRAP values and decreased the irradiation-induced MDA formation.     

Haze formation in model beer systems

The interaction of a haze-active protein (gliadin) and a haze-active polyphenol (tannic acid) was studied in a model beer system in order to investigate the principle mechanisms of haze formation at low temperatures. Low concentrations (g/L) of tannic acid, high concentrations of gliadin, and comparatively high temperatures lead to maximum haze values. When considered on a molar basis, the greatest haze levels are displayed at an approximate 1:1 equivalence of polyphenol and protein. The greater part of haze formation was completed within 0.5 h, irrespective of the concentration of gliadin, the concentration of tannic acid, and the temperature of the model solution.     

Efficiency of enzymatic and other alternative clarification and fining treatments on turbidity and haze in cherry juice

Several alternative strategies were examined for improving conventional juice fining procedures for cherry juice clarification and fining in laboratory-scale experiments: Centrifugation of freshly pressed juice from 1000g to 35,000g induced decreased turbidity according to a steep, negative power function. Individual and interactive effects on turbidity and haze formation in precentrifuged and uncentrifuged cherry juice of treatments with pectinase, acid protease, bromelain, gallic acid, and gelatin-silica sol were investigated in a factorial experimental design with 32 different parameter combinations. Gelatin-silica sol consistently had the best effect on juice clarity. Centrifugation of cherry juice (10,000g for 15 min) prior to clarification treatment significantly improved juice clarity and diminished the rate of haze formation during cold storage of juice. Both treatment of precentrifuged cherry juice with Novozym 89L protease and co-addition of pectinase and gallic acid improved cherry juice clarity and diminished haze levels. None of the alternative treatments produced the unwieldy colloids notorious to gelatin-silica sol treatment. The data suggest that several alternative clarification strategies deserve further consideration in large-scale cherry juice processing. Precentrifugation of juice before clarification and fining is immediately recommended.     

Cinnamaldehyde inhibits enzymatic browning of cut lettuce by repressing the induction of phenylalanine ammonia-lyase without promotion of microbial growth

Cinnamaldehyde treatment inhibited the browning of cut lettuce during cold storage. In this study, to clarify the mechanism of inhibitory action of cinnamaldehyde against the browning and to show its microbiological merit, its effect on the browning of cut lettuce was compared to that of mild heat treatment. Both cinnamaldehyde and mild heat treatments inhibited the induction of phenylalanine ammonia-lyase (PAL) activity because of cutting. As a result, the biosynthesis of polyphenols, which are substrates of polyphenol oxidase, was inhibited. This reduction of polyphenol synthesis caused the inhibition of the browning. Cinnamaldehyde treatment repressed the induction of PAL mRNA, while mild heat treatment did not repress its induction. The increase in microbes in cut lettuce treated with cinnamaldehyde was less than that treated with mild heat after 12 days.