Effect of enzymatic treatment of extracted sunflower proteins on solubility, amino acid composition, and surface activity

Industrial proteins from agriculture of either animal or vegetable origin, including their peptide derivatives, are of great importance, from the qualitative and quantitative point of view, in food formulations (emulsions and foams). A fundamental understanding of the physical, chemical, and functional properties of these proteins is essential if the performance of proteins in foods is to be improved and if underutilized proteins, such as plant proteins (and their hydrolysates and peptides derivatives), are to be increasingly used in traditional and new processed food products (safe, high-quality, health foods with good nutritional value). In this contribution we have determined the main physicochemical characteristics (solubility, composition, and analysis of amino acids) of a sunflower protein isolate (SPI) and its hydrolysates with low (5.62%), medium (23.5%), and high (46.3%) degrees of hydrolysis. The hydrolysates were obtained by enzymatic treatment with Alcalase 2.4 L for DH 5.62 and 23.5% and with Alcalase 2.4 L and Flavorzyme 1000 MG sequentially for DH 46.3%. The protein concentration dependence on surface pressure (surface pressure isotherm), a measure of the surface activity of the products (SPI and its hydrolysates), was obtained by tensiometry. We have observed that the degree of hydrolysis has an effect on solubility, composition, and content of the amino acids of the SPI and its hydrolysates. The superficial activity and the adsorption efficiency were also affected by the degree of hydrolysis.     

Incorporation and stabilization of omega-3 fatty acids in surimi made from cod, Gadus morhua

Surimi containing omega-3 fatty acids from algal oil was prepared by the addition of oil-in-water emulsions or bulk oil. Emulsion and bulk oil were added separately to surimi to provide approximately 500 mg of omega-3 fatty acids per serving of surimi (85 g). Addition of the emulsion had no effect on surimi gel strength, whereas bulk oil decreased gel strength an average of 31%. All surimi treatments containing algal oil increased in Hunter b values due to the presence of carotenoids in the oil. Among cryoprotectants, sodium tripolyphosphate was the major surimi additive responsible for retarding the formation of lipid hydroperoxides and thiobarbituric acid reactive substances (TBARS). Lipid hydroperoxide and TBARS formation was lower in surimi containing bulk oil compared to surimi with emulsified oil. Both EDTA and lipid soluble antioxidants were able to decrease lipid oxidation in surimi fortified with omega-3 fatty acids. This suggests that surimi containing nutritionally beneficial omega-3 fatty acids could be developed with good oxidative stability and gel strength.     

Preparation and characterization of papain-modified sesame (Sesamum indicum L.) protein isolates

Defatted sesame meal ( approximately 40-50% protein content) is very important as a protein source for human consumption due to the presence of sulfur-containing amino acids, mainly methionine. Sesame protein isolate (SPI) is produced from dehulled, defatted sesame meal and used as a starting material to produce protein hydrolysate by papain. Protein solubility at different pH values, emulsifying properties in terms of emulsion activity index (EAI) and emulsion stability index (ESI), foaming properties in terms of foam capacity (FC) and foam stability (FS), and molecular weight distribution of the SPI hydrolysates were investigated. Within 10 min of hydrolysis, the maximum cleavage of peptide bonds occurred as observed from the degree of hydrolysis. Protein hydrolysates have better functional properties than the original SPI. Significant increase in protein solubility, EAI, and ESI were observed. The greatest increase in solubility was observed between pH 5.0 and 7.0. The molecular weight of the hydrolysates was also reduced significantly during hydrolysis. These improved functional properties of different protein hydrolysates would make them useful products, especially in the food, pharmaceutical, and related industries.     

红娘鱼降血压肽的酶解制备工艺优化及酶解产物的抗氧化活性研究

为有效利用红娘鱼制备降血压肽,以红娘鱼鱼糜为原料提取蛋白,并对其进行酶解制备降血压肽。以血管紧张素转换酶ACE抑制率和水解度为指标,通过响应面分析法对酶解红娘鱼鱼糜蛋白制备降血压肽的工艺条件进行优化,并对最优条件下制备的酶解产物进行分子量和抗氧化活性测定。结果表明,碱性蛋白酶是制备降血压肽的最适蛋白酶,响应面法优化制备降血压肽的最佳酶解条件为pH值9、酶与底物的比值(酶底比)1.4%、温度54℃、时间2 h,此条件下酶解制得的降血压多肽ACE抑制率理论值为88%,实际值为89.3%;经高效液相色谱(HPLC)分析可得酶解产物相对分子量<2 000 Da。通过测定酶解产物样品的1,1-二苯基-2-三硝基苯肼(DPPH)自由基清除率、羟自由基(·OH)清除率及还原力判定其体外抗氧化活性,结果表明酶解产物具有较强抗氧化活性。本研究结果为红娘鱼的高值化利用提供了数据支持和理论基础。     

Producing docosahexaenoic acid (DHA)-rich algae from biodiesel-derived crude glycerol: effects of impurities on DHA production and algal biomass composition

Crude glycerol is the primary byproduct of the biodiesel industry. Producing docosahexaenoic acid (DHA, 22:6 n-3) through fermentation of the alga Schizochytrium limacinum on crude glycerol provides a unique opportunity to utilize a large quantity of this byproduct. The objective of this work is to investigate the effects of impurities contained in the crude glycerol on DHA production and algal biomass composition. Crude glycerol streams were obtained from different biodiesel refineries. All of the glycerol samples contained methanol, soaps, and various elements including calcium, phosphorus, potassium, silicon, sodium, and zinc. Both methanol and soap were found to negatively influence algal DHA production; these two impurities can be removed from culture medium by evaporation through autoclaving (for methanol) and by precipitation through pH adjustment (for soap). The glycerol-derived algal biomass contained 45-50% lipid, 14-20% protein, and 25% carbohydrate, with 8-13% ash content. Palmitic acid (C16:0) and DHA were the two major fatty acids in the algal lipid. The algal biomass was rich in lysine and cysteine, relative to many common feedstuffs. Elemental analysis by inductively coupled plasma showed that boron, calcium, copper, iron, magnesium, phosphorus, potassium, silicon, sodium, and sulfur were present in the biomass, whereas no heavy metals (such as mercury) were detected in the algal biomass. Overall, the results show that crude glycerol was a suitable carbon source for algal fermentation. The crude glycerol-derived algal biomass had a high level of DHA and a nutritional profile similar to that of commercial algal biomass, suggesting a great potential for using crude glycerol-derived algae in omega-3-fortified food or feed.     

汽爆处理对鳙鱼骨酶解特性的影响

为研究汽爆预处理对鱼骨蛋白酶解特性的影响,以鳙鱼骨为研究对象,采用Alcalase酶解鳙鱼鱼骨,研究不同保压时间、汽爆压力对鳙鱼骨的水解度、蛋白质回收率、三氯乙酸(TCA)可溶性氮得率的影响。结果表明,汽爆预处理能显著提高鳙鱼骨蛋白的溶出率。0.6 MPa、2.0 min汽爆预处理鱼骨经Alcalase酶解3.0 h后,酶解产物的水解度为8.69%,蛋白质回收率为32.69%,TCA可溶性氮得率为28.79%,均显著高于未处理组;酶解产物相对分子质量主要分布在1 000 Da以下,高达93%。本研究结果为鱼骨资源利用提供了一定的技术支持。     

Antioxidant activity of zein hydrolysates in a liposome system and the possible mode of action

Maize zein was hydrolyzed for 0.5-5 h by alcalase or papain. Protein solubility increased (P < 0.05) with the degree of hydrolysis (DH) and was higher for alcalase-hydrolyzed zein than for papain-hydrolyzed zein. The zein hydrolysates with both enzymes consisted mostly of small peptides or amino acids nondetectable by 15% acrylamide gel electrophoresis. Alcalase-hydrolyzed zein exhibited a stronger (P < 0.05) antioxidant activity than papain-hydrolyzed zein, as indicated by peroxide and thiobarbituric acid-reactive substance values in a liposome-oxidizing system. Zein hydrolysates possessed strong Cu(2+) chelation ability and marked reducing power, both of which were accentuated with hydrolysis time. The protein hydrolysates also showed strong radical-scavenging ability, which was not influenced by hydrolysis time. The antioxidant activity of alcalase-hydrolyzed zein at some specific low concentrations was close or comparable to those of butylated hydroxyanisole, alpha-tocopherol, and ascorbate. Although intact zein displayed an antioxidative effect, it was far less potent than hydrolyzed zein. The results demonstrated that enzyme-hydrolyzed zein can act as a metal ion chelator or a hydrogen donor, as well as a radical stabilizer to inhibit lipid oxidation. The effectiveness of the protein hydrolysates appeared to depend on both the concentration and the peptide/amino acid composition of the soluble protein fraction.     

Hydrolysis of the amyloid prion protein and nonpathogenic meat and bone meal by anaerobic thermophilic prokaryotes and streptomyces subspecies

Transmissible spongiform encephalopathies are caused by accumulation of highly resistant misfolded amyloid prion protein PrPres and can be initiated by penetration of such pathogen molecules from infected tissue to intact organism. Decontamination of animal meal containing amyloid prion protein is proposed thanks to the use of proteolytic enzymes secreted by thermophilic bacteria Thermoanaerobacter, Thermosipho, and Thermococcus subsp. and mesophilic soil bacteria Streptomyces subsp. Keratins alpha and beta, which resemble amyloid structures, were used as the substrates for the screening for microorganisms able to grow on keratins and producing efficient proteases specific for hydrolysis of beta-sheeted proteic structures, hence amyloids. Secretion of keratin-degrading proteases was evidenced by a zymogram method. Enzymes from thermophilic strains VC13, VC15, and S290 and Streptomyces subsp. S6 were strongly active against amyloid recombinant ovine prion protein and animal meal proteins. The studied proteases displayed broad primary specificities hydrolyzing low molecular mass peptide model substrates. Strong amyloidolytic activity of detected proteases was confirmed by experiments of hydrolysis of PrPres in SAFs produced from brain homogenates of mice infected with the 6PB1 BSE strain. The proteases from Thermoanaerobacter subsp. S290 and Streptomyces subsp. S6 are the best candidates for neutralization/elimination of amyloids in meat and bone meal and other protein-containing substances and materials.     

羊奶乳清蛋白水解物的酶解制备

采用Alcalase与Flavourzyme两种酶对羊奶乳清蛋白进行水解,以水解度为指标,对两种酶单独使用及复合使用水解羊奶乳清蛋白的工艺条件进行了研究。试验结果显示:采用Alcalase与Flavourzyme复合水解羊奶乳清蛋白的效果较好,特别是采用先添加Flavourzyme后加入Alcalase进行水解,不仅能提高羊奶乳清蛋白的水解度,使其达到32.81%,而且对改善水解液的口感有较大的作用。     

Enzymatic extractability of soybean meal proteins and carbohydrates: heat and humidity effects

To study the incomplete enzymatic extractability of proteins and carbohydrates of thermally treated soybean meals, one unheated and three heat-treated soybean meals were produced. To obtain truly enzyme-resistant material, the meals were extracted by a repeated hydrolysis procedure using excessive concentrations of different combinations of commercial protease and carbohydrase preparations. The water extractability of protein from the different meals varied considerably (13-67%). For all soybean meals, enzymatic treatment extracted most of the original protein (89-94%). Carbohydrase preparations did not improve protein extraction. High-humidity heat treatment led to a more effective enzymatic extraction, which seemed to correlate with the extent of protein denaturation. Results with purified proteins indicated that the soybean meal matrix affects the enzymatic extraction of protein from the meals. Interactions between protein and other components (e.g., cellulose) may explain the incomplete enzymatic extractability of protein from the meals.     

Partial purification and immobilization/stabilization on highly activated glyoxyl-agarose supports of different proteases from flavourzyme

The fractioning of some components and their immobilization of Flavourzyme, a commercial protease/aminopeptidase preparation, has been investigated to improve its specificity and stability. Adsorption of Flavourzyme on two ionic exchangers yielded two fractions with endoprotease activity and one fraction containing aminopeptidase activity. The use of an amine agarose gel has made it possible to purify a 43 kDa protein with only endoprotease activity. Immobilization of this endoprotease and the original Flavourzyme preparation onto glyoxyl-agarose provided derivatives that were more thermostable than their soluble counterparts. Tests using immobilized Flavourzyme and immobilized purified endoprotease for the hydrolysis of chickpea proteins showed that both preparations can be used for the production of protein hydrolysates and compare very favorably with the original crude Flavourzyme in terms of reducing the production of free amino acids. This was especially so in the case of immobilized endoprotease, which produced only 0.2% free amino acids. Keeping free amino acids content low is very important in protein hydrolysates for nutritional use to avoid excessive osmotic pressure.     

Effects of ionic strength on the enzymatic hydrolysis of diluted and concentrated whey protein isolate

To identify the parameters that affect enzymatic hydrolysis at high substrate concentrations, whey protein isolate (1-30% w/v) was hydrolyzed by Alcalase and Neutrase at constant enzyme-to-substrate ratio. No changes were observed in the solubility and the aggregation state of the proteins. With increasing concentration, both the hydrolysis rate and the final DH decreased, from 0.14 to 0.015 s(-1) and from 24 to 15%, respectively. The presence of 0.5 M NaCl decreased the rate of hydrolysis for low concentrations (to 0.018 s(-1) for 1% WPI), resulting in similar rates of hydrolysis for all substrate concentrations. The conductivity increase (by increasing the protein concentration, or by addition of NaCl) has significant effects on the hydrolysis kinetics, but the reason for this is not yet well understood. The results show the importance of conductivity as a factor that influences the kinetics of the hydrolysis, as well as the composition of the hydrolysates.     

Activity of meadowfoam (Limnanthes alba) seed meal glucolimnanthin degradation products against soilborne pathogens

Meadowfoam (Limnanthes alba L.) is a herbaceous winter-spring annual grown as a commercial oilseed crop. The meal remaining after oil extraction from the seed contains up to 4% of the glucosinolate glucolimnanthin. Degradation of glucolimnanthin yields toxic breakdown products, and therefore the meal may have potential in the management of soilborne pathogens. To maximize the pest-suppressive potential of meadowfoam seed meal, it would be beneficial to know the toxicity of individual glucolimnanthin degradation products against specific soilborne pathogens. Meloidogyne hapla second-stage juveniles (J2) and Pythium irregulare and Verticillium dahliae mycelial cultures were exposed to glucolimnanthin as well as its degradation products. Glucolimnanthin and its degradation product, 2-(3-methoxyphenyl)acetamide, were not toxic to any of the soilborne pathogens at concentrations up to 1.0 mg/mL. Two other degradation products, 2-(3-methoxymethyl)ethanethioamide and 3-methoxyphenylacetonitrile, were toxic to M. hapla and P. irregulare but not V. dahliae. The predominant enzyme degradation product, 3-methoxybenzyl isothiocyanate, was the most toxic compound against all of the soilborne pathogens, with M. hapla being the most sensitive with EC(50) values (0.0025 ± 0.0001 to 0.0027 ± 0.0001 mg/mL) 20-40 times lower than estimated EC(50) mortality values generated for P. irregulare and V. dahliae (0.05 and 0.1 mg/mL, respectively). The potential exists to manipulate meadowfoam seed meal to promote the production of specific degradation products. The conversion of glucolimnanthin into its corresponding isothiocyanate should optimize the biopesticidal properties of meadowfoam seed meal against M. hapla, P. irregulare, and V. dahliae.     

酶解制备鱼鳞蛋白降血压肽的工艺优化

为有效利用鱼鳞制备降血压肽,以罗非鱼鱼鳞为原料,在121℃条件下进行热预处理15 min后,运用响应面分析法优化酶解制备鱼鳞蛋白ACE抑制肽的工艺条件。结果表明,以水解度和ACE抑制率为评价指标,筛选出碱性蛋白酶为最优酶。在单因素试验的基础上,根据Box-Behnken中心组合试验设计原理,最终确立最优的酶解工艺参数为:酶解时间2 h、酶解温度56.3℃、pH值8.0,酶底比1.1%,此条件下ACE抑制率理论值为87.95%,实际值为88.26%。最优条件下制得的酶解产物相对分子质量集中在300～3 000 Da之间,水解效果较好。本研究结果对酶解法制备鱼鳞蛋白降血压活性肽具有一定的实践参考价值。     

Emulsifying and Foaming Properties of Okara Protein Hydrolysates

Okara is a low‐value coproduct of soy milk production. Its dry matter contains 25–30% protein that is of high nutritive quality, has an excellent efficiency ratio, and thus holds promise for applications in food systems. However, okara protein has low solubility. We here optimized its extraction and isolation from okara by using dilute sodium hydroxide and subsequent isoelectric precipitation. The obtained okara protein isolate (OPI) was hydrolyzed with different enzymes into a range of hydrolysates with different degrees of hydrolysis. Most hydrolysates had better emulsifying activity and produced more stable emulsions than OPI. In contrast, hydrolysis had no positive effect on foam‐forming and foam‐stabilizing activity of OPI proteins. Hydrolysis of OPI enhances the emulsifying capacity of the proteins. Furthermore, the emulsifying and foam‐forming capacities of most of the OPI hydrolysates were similar to or even better than those of the commercial (soy) protein hydrolysates used in this study.     

Nutritional quality of sesame seed protein fraction extracted with isopropanol

The nutritional effect of diet containing decorticated sesame seed extracted with isopropanol (DSS-Iso) was evaluated on growth performance, food efficiency ratio, plasma and tissue lipid profile, plasma protein content, and erythrocyte membrane lipid profile of rats on a comparative basis with diets containing casein (control), soybean meal, and decorticated sesame seed extracted with hexane (DSS-Hex). Rats fed a DSS-Iso-based diet showed body weight gain and food efficiency ratio similar to those of the control groups fed diets prepared with casein, soybean meal, and DSS-Hex. However, dietary proteins exerted a separate effect on plasma lipid concentrations of the rats. Rats fed a DSS-Iso-based diet showed significant decreases in plasma total cholesterol (p < 0.01), triglyceride (p < 0.01), and VLDL+LDL cholesterol (p < 0.01) concentrations in comparison to the rats fed diet containing casein. No significant differences in plasma lipid concentrations were observed for the rats fed diets prepared with soybean meal, DSS-Hex, and DSS-Iso. Rats fed the different dietary proteins did not show much variation in plasma proteins, liver lipids, and erythrocyte membrane lipid concentrations, which suggests that DSS-Iso could be a suitable edible protein like casein or soybean meal.     

Enzymatic Hydrolysis of Barley Starch Lipids

The efficiency of phospholipase and lipase preparations in the hydrolysis of lysophospholipids of native and gelatinized barley starch was examined. The degree of hydrolysis was analyzed by determination of the amount of released fatty acids by an enzymatic method. Thermal and structural properties of the enzyme-treated starch were studied by differential scanning calorimetry and light microscopy. Lysophospholipids of the gelatinized barley starch were easily hydrolyzed, in contrast to the lipids of the granular starch. The maximum degree of hydrolysis achieved for the gelatinized starch was 80% and for the native starch ≈20%. Gelatinization enthalpies and micrographs indicated that even though the amount of the released fatty acids from the native starch was small, formation of free fatty acids inhibited swelling and gelatinization of starch granules.     

Enrichment of eicosapentaenoic acid from sardine oil with Delta5-olefinic bond specific lipase from Bacillus licheniformis MTCC 6824

Lipase derived from Bacillus licheniformis MTCC 6824 was purified to homogeneity by anion exchange chromatography on Amberlite IRA 410 (Cl-) and gel filtration using Sephadex G-100 as judged by denaturing polyacrylamide gel electrophoresis. The purified lipase was used for hydrolysis of triacylglycerol in sardine oil to enrich Delta5-polyunsaturated fatty acids (Delta5-PUFAs) namely, arachidonic acid (5,8,11,14-eicosatetraenoic acid, ARA, 20:4n-6) and eicosapentaenoic acid (5,8,11,14,17-eicosapentaenoic acid, EPA, 20:5n-3). The individual fatty acids were determined as fatty acid methyl esters (FAMEs) by gas-liquid chromatography and gas chromatography-mass spectroscopy as FAMEs and N-acyl pyrrolidides. The enzyme exhibited hydrolytic resistance toward ester bonds of Delta5-PUFAs as compared to those of other fatty acids and was proved to be effective for increasing the concentration of EPA and ARA from sardine oil. Utilizing this fatty acid specificity, EPA and ARA from sardine oil were enriched by lipase-mediated hydrolysis followed by urea fractionation at 4 degrees C. The purified lipase produced the highest degree of hydrolysis for SFAs and MUFAs (81.5 and 72.3%, respectively, from their initial content in sardine oil) after 9 h. The profile of conversion by lipase catalysis showed a steady increase up to 6 h and thereafter plateaued down. Lipase-catalyzed hydrolysis of sardine oil followed by urea adduction with methanol provided free fatty acids containing 55.4% EPA and 5.8% ARA, respectively, after complexation of saturated and less unsaturated fatty acids. The combination of enzymatic hydrolysis and urea complexation proved to be a promising method to obtain highly concentrated EPA and ARA from sardine oil.     

Preparation of whey protein hydrolysates using a single- and two-stage enzymatic membrane reactor and their immunological and antioxidant properties: characterization by multivariate data analysis

An initial 5% (w/v), followed thereafter with replacement aliquots of 3% (w/v), whey protein isolate (WPI) (ca. 86.98% Kjeldahl N x 6.38), was hydrolyzed using Protease N Amano G (IUB 3.4.24.28, Bacillus subtilis) in an enzymatic membrane reactor (EMR) fitted with either a 10 or 3 kDa nominal molecular weight cutoff (NMWCO) tangential flow filter (TFF) membrane. The hydrolysates were desalted by adsorption onto a styrene-based macroporous adsorption resin (MAR) and washed with deionized water to remove the alkali, and the peptides were desorbed with 25, 50, and 95% (v/v) ethyl alcohol. The desalted hydrolysates were analyzed for antibody binding, free radical scavenging, and molecular mass analysis as well as total and free amino acids (FAA). For the first time a quantity called IC50, the concentration of peptides causing 50% inhibition of the available antibody, is introduced to quantify inhibition enzyme-linked immunosorbent assay (ELISA) properties. Principal component analysis (PCA) was used for data reduction. The hydrolysate molecular mass provided the most prominent influence (PC1 = 57.35%), followed by inhibition ELISA (PC2 = 18.90%) and the antioxidant properties (PC3 = 10.43%). Ash was significantly reduced in the desalted fractions; the protein adsorption recoveries were high, whereas desorption with alcohol was prominently influenced by the hydrophobic/ hydrophilic amino acid balance. After hydrolysis, some hydrolysates showed increased ELISA reactivity compared with the native WPI.     

Beta-conglycinin embeds active peptides that inhibit lipid accumulation in 3T3-L1 adipocytes in vitro

Obesity is a worldwide health concern because it is a well-recognized predictor of premature mortality. The objective was to identify soybean varieties that have improved potential to inhibit fat accumulation in adipocytes by testing the effects of soy hydrolysates having a range of protein subunit compositions on lipid accumulation and adiponectin expression in 3T3-L1 adipocytes. The results showed that differences in the protein distribution of 15 soy genotypes led to different potentials for the reduction of fat accumulation. The inhibition of lipid accumulation of soy alcalase hydrolysates in 3T3-L1 adipocytes ranged from 29 to 46%. Soy hydrolysates made from genotypes with 45.3 +/- 3.3% of total protein as beta-conglycinin, on average, showed significantly higher inhibition of lipid accumulation compared to those with 24.7 +/- 1.5% of extracted total protein as beta-conglycinin. Moreover, after in vitro simulated digestion with pepsin-pancreatin of the soy alcalase hydrolysates, 86% of the original activity remained. Adiponectin expression was induced in 3T3-L1 adipocytes treated with 15 soy hydrolysates up to 2.49- and 2.63-fold for high and low molecular weight adiponectin, respectively. The inhibition of lipid accumulation calculated from a partial least squares (PLS) analysis model correlated well with experimental data (R(2) = 0.91). In conclusion, it was feasible to differentiate soy varieties on the basis of the potential of their proteins to reduce fat accumulation using a statistical model and a cell-based assay in vitro. Furthermore, beta-conglycinin embeds more peptides than glycinin subunits that inhibit lipid accumulation and induce adiponectin in 3T3-L1 adipocytes. Therefore, soy ingredients containing beta-conglycinin may be important food components for the control of lipid accumulation in adipose tissue.