有机基质臭氧消毒设备设计与试验

为实现有机基质的绿色、高效消毒,设计了有机基质臭氧消毒设备。基于离散元软件EDEM建立了有机基质颗粒模型,根据有机质物料输送及抛撒动力学特性与臭氧消毒工艺流程,利用Solid Works软件构建了有机基质臭氧消毒设备结构模型,并对两种模型进行接触参数标定。以有机基质倾尽角为评价指标,以抄板弯折角、转筒转速、填充率为试验因素,进行了三因素五水平正交旋转组合仿真试验。根据仿真结果,利用Design-Expert软件回归分析法建立倾尽角回归数学模型,对有机基质臭氧消毒设备模型中的抄板弯折角、转筒转速、填充率进行了参数优化与试验验证。结果表明,在各因素取值范围内,抄板弯折角对有机基质倾尽角影响极显著,转筒转速对倾尽角影响显著,填充率对倾尽角影响不显著;有机基质臭氧消毒装置最优作业参数组合为:抄板弯折角124.23°、转筒转速6.29 r/min,此时物料倾尽角仿真值为89.3°。臭氧消毒灭菌性能试验验证结果为:臭氧初始质量浓度64.2 mg/m~3,消毒60 min后,细菌灭菌率88.9%,真菌灭菌率97.9%,能够满足有机基质消毒生产要求。     

Effects of superheated steam processing on common buckwheat grains: Lipase inactivation and its association with lipidomics profile during storage

Superheated steam (SS) at 170 °C for 5 min was used to inactivate lipase of common buckwheat grains in this study, which effectively retarded lipid hydrolytic rancidity and maintained lipid nutrition of common buckwheat. Higher stabilities based on lower free fatty acid accumulation and lipase activity were observed in SS-treated buckwheat samples during storage. Meanwhile, SS could suppress oxidation of unsaturated fatty acids (UFA) in buckwheat, significantly retard the increase of saturated fatty acids and the decrease of polyunsaturated fatty acids during storage. Moreover, the lipidomics profile results indicated that SS processing could retard the increased hydrolysis and oxidation of sulfoquinovosyl diacylglycerol, phosphatidylethanolamine, phosphatidylserine and lysophosphatidic acid during storage, while regulate the content of galactolipids. Thus, SS processing could effectively inactivate lipase, suppress UFA oxidation, change glycerolipids and glycerophospholipids subclass metabolism, and consequently retard hydrolytic rancidity and the loss of lipid nutrition in buckwheat during storage. SS processing was proved to effectively protect the quality of buckwheat during storage for the first time.     

大型海藻干燥技术研究进展

干燥是海藻储存、加工、生产的重要方法之一,不同的干燥方式对海藻脱水效率、能耗和品质影响很大。本文对藻类传统干燥和新型干燥技术的特点、研究及应用现状进行了分析。研究表明,太阳能干燥技术能够充分做到干燥过程中绿色、环保,与空气热泵构成组合干燥模式,可解决太阳能不连续的问题;过热蒸汽干燥效率高、能耗低,藻类干燥后复水性好;真空冷冻干燥产品品质好,能最大限度保持藻类的营养和功能性成分;远红外加热技术对海带进行干燥,与同风速的热风干燥相比,可显著缩短干燥时间,降低能耗;微波真空干燥技术干燥江蓠,在保持品质的基础上干燥时间较热风干燥减少70%。本文同时对藻类干燥技术与设备存在的问题进行了总结,对国内藻类干燥技术及装备的发展趋势进行了展望并提出了措施与建议。     

红花山玉兰组织培养外植体的选择及其消毒方法

为筛选出红花山玉兰组织培养适宜的外植体类型及其消毒方法，为红花山玉兰的无性繁殖提供技术支持，对灭菌时间、外植体类型和取材时间等进行研究。结果表明：茎段和顶芽的存活率分别为40．0％和33．33％，较叶片和叶柄的存活率高，且茎段和顶芽的存活率较叶片的存在显著差异，二者的死亡率均与叶柄和叶片的存在显著差异；茎段和顶芽为适宜的外植体。茎段在6月取材优于12月，且采用0．1％的升汞消毒10 min，其存活率为40．0％；顶芽在6月和12月取材均可，消毒后去除托叶能够有效地降低顶芽的污染率，提高其存活率。最佳消毒组合：先用75％的酒精表面喷洒预处理，再用0．1％的升汞消毒10 min，之后去除顶芽的托叶。该方法污染率和死亡率低，存活率最高，依次分别为6．67％、7．78％和85．55％，且芽启动率高。     

Can water disinfection prevent the transmission of infectious koi herpesvirus to naïve carp? – a case report

Hygienic measures such as disinfection are important tools for the maintenance of fish health in aquaculture. While little information is available on the disinfection of water intended for fish containment, Huwa‐San^®, a disinfectant used in food and water industries, was used for daily treatment at concentrations of approximately 60 ppm over a total period of 3 months (experiment 1) with a 3‐week treatment‐free interval after 2 months (experiment 2). During this period, koi herpesvirus (KHV) was added to the water of two aquaria, one used as a normal contact control, the other one receiving daily water disinfectant treatments that prevented KHV infection of carp. In the second experiment, Huwa‐San^® treatment was interrupted and KHV infection was prevalent. However, when naïve fish were introduced to the same aquarium after re‐application of disinfectant, KHV could not be detected in those naïve fish. Whilst KHV could not be detected in samples where disinfectant had been applied, it was present in samples of naïve fish cohabiting with infection contact control animals which had undergone no disinfectant treatment over experiments 1 and 2. The results presented here show that water treatment with a disinfectant may prevent transmission of infectious KHV to naïve carp cohabited with infected carp.     

Effect of disinfection with peracetic acid on the microbial community of a seawater aquaculture recirculation system for Pacific white shrimp (Litopenaeus vannamei)

When tropical shrimps are kept in recirculating aquaculture systems (RAS), one of the limiting factors is the maintenance of a sufficient water quality, and therefore, often disinfectants like peracetic acid (PAA) are added to the water either as prophylactic or treatment measure. In this study, PAA in concentrations of 0.1 mg/L, 1 mg/L and 10 mg/L was applied continuously for 56 days to small-scale seawater RAS stocked with Litopenaeus vannamei. Treatment with 0.1 mg/L did not result in a reduction in the total bacterial amount and therefore was not effective. A concentration of 10 mg/L led to significant changes in the chemical water parameters already after 2 days and was therefore not recommendable. A concentration of 1 mg/L led to increased levels of ammonia and nitrite within 2 days and to a significant increase in the bacterial amount in the water, most probably due to an enhanced growth of heterotrophic bacteria. The microflora showed significant fluctuations, and there were indications that the welfare of the shrimps was affected. Using 1 mg PAA/L for prophylactic use is therefore also not recommendable but might be an alternative option for short-term treatment in cases of disease outbreaks.     

Salmonella Infantis and Salmonella Enteritidis specific bacteriophages isolated form poultry faeces as a complementary tool for cleaning and disinfection against Salmonella

Salmonellosis represents an important public health concern. Several authors point out the inefficiency of the cleaning and disinfection protocols to remove the bacteria from the field. For this reason, innovative techniques, as bacteriophages, could be implemented to control the bacteria. The main objectives of this study were to assess the effect of bacteriophages against Salmonella Infantis and Salmonella Enteritidis on farm surfaces, and to evaluate bacteriophage procedure application as sanitiser against Salmonella in field conditions. Thus, most prevalent serovars in poultry production were selected (Salmonella Infantis and Salmonella Enteritidis) to contaminate farm facilities. Then, two specific bacteriophages isolated from poultry faeces were applied against them. Results showed Salmonella Infantis and Salmonella Enteritidis decreased of 4.55 log₁₀CFU/mL and 3.85 log₁₀CFU/mL, respectively; the maximum reduction in Salmonella was the 5^th day, after 10⁸ PFU/mL and 10³ PFU/mL bacteriophage application. These results highlight bacteriophages as a promising tool together with cleaning and disinfection.     

Use of a foaming disinfectant and cleaner to reduce aerobic bacteria on poultry transport coops

Poultry transportation coops are rarely washed and have been demonstrated to be a point of cross-contamination of broiler carcasses. Foaming disinfectants and cleaners, commonly used within processing plants, may be used to clean and disinfect poultry transportation coops. In this study, homogenized fecal material was evenly applied to the floors of precleaned broiler transportation coops and allowed to dry. Treatments consisted of a water rinse, a foam additive alone, foaming cleaner, and a disinfectant plus a foam additive. All foaming treatments were applied using a compressed air foam system (2,271 L/min; 600 gal/min), similar to what firefighters would use. A high-pressure water rinse (HPWR) was added prior to or following the treatments to determine whether rinsing prior to product application or rinsing after product application would improve efficacy. Based on our data, a compressed air foam system may be used in combination with a commercially available disinfectant or foam cleaner to reduce aerobic bacteria on the surfaces of commercial broiler transportation coops. Furthermore, the addition of a HPWR did not further reduce the level of aerobic bacteria on broiler transportation coop floors.     

麦秸半焦低温催化气化实验研究

以麦秸半焦为研究对象,比较麦秸半焦和酸洗麦秸半焦700℃下水蒸气气化实验,研究了麦秸灰分中碱金属含量、催化剂种类(K基、Ca基和Fe基)对气化过程的影响。实验结果表明,麦秸灰分中较高含量的碱金属K能够有效促进半焦气化的进行,使得在非催化条件下半焦的碳转化率达到63.4%,相比酸洗麦秸半焦提高了2.6倍。低温下碱金属K基催化剂对半焦气化的促进作用显著,在700℃和K/Al催化剂条件下H2产率和碳转化率分别达到118.60 mol/kg和98.5%,相较于Ca/Al、Fe/Al催化剂而言,H2产率分别提高了10.7%和20.5%,碳转化率提高了12.4%和31.0%;而Ca/Al及Fe/Al催化剂有利于水气变换反应的进行,可提高气化产物中H2体积分数,降低CO体积分数。综合考虑碳转化率、气体产率及气体组分含量等因素,在催化效果较好的K基催化剂中添加适量的Ca基催化剂有利于调节产气成分,从而进一步提纯获得富氢气体。     

喷气式网带单板干燥机节能途径探讨

为了提高单板干燥过程中的能源利用效率,对单板干燥过程进行了分析并提出有效的节能措施与途径。提出利用单板干燥尾气余热回收系统,以减少尾气直接排入大气时的热量损失,对尾气余热回收利用;提出蒸汽梯级利用回收冷凝水的热量,达到对冷凝水余热回收利用的目的。