Marine shrimp aquaculture: a novel waste treatment system

Ecuadorian Penaeus vannamei were cultured in dirt ponds (each of approximately 163 m²) at four different stocking densities, i.e. 5 shrimp m⁻², 10 shrimp m⁻², 15 shrimp m⁻² and 20 shrimp m⁻². Experiments were carried out over three different periods during the year. Each experiment lasted for 11–14 weeks. No commercial feed was given to the shrimp. The only input to the ponds was about 30 kg of cattle manure per pond per week. Chemical composition of the cattle manure was analyzed. Water quality parameters such as temperature, pH, DO and turbidity were recorded twice daily for each experiment; nutrients (nitrite, nitrate, ammonium and phosphate), water ATP, sediment ATP, H₂S and chlorophyll were measured twice weekly for each experiment. Shrimp were sampled either weekly or bi-weekly for body weight measurements.

The results showed a negative correlation between stocking density and growth. Weekly growth ranged from 0·44 to 1·58 g week⁻¹. Survival was over 50% in all treatments and averaged at 70·8%. Under these stocking densities, shrimp production ranged from 4·4 to 18·8 kg ha⁻¹ day⁻¹. The stocking density of 15 shrimps m⁻² provides better production than the other stocking densities.

Water quality data did not relate to any shrimp growth. Water nutrient levels in pond discharge water were less than or equal to the nutrients in the incoming water in spite of the weekly addition of cattle manure and did not increase with the addition of cattle manure. No coliform bacteria were detected in any pond water samples through the study period. This indicates digestion of cattle manure in marine shrimp ponds would not pollute the environment with high concentrations of dissolved nutrients.

Thus, a marine shrimp pond can be considered a dissolved nutrient marine treatment plant converting unwanted cattle manure (1841 kg cattle manure ha⁻¹ week⁻¹ in this study) into a valuable commodity — shrimp.     

Behavioral responses of tilapia (Oreochromis niloticus) to acute fluctuations in dissolved oxygen levels as monitored by computer vision

Behavioral and ventilatory parameters have the possibility of predicting the stress state of fish in vivo and in situ. This paper presents a new image-processing algorithm for quantifying the average swimming speed of a fish school in an aquarium. This method is based on the alteration in projected area caused by the movement of individual fish during frame sequences captured at given time intervals. The image enhancement method increases the contrast between fish and background, and is thus suitable for use in turbid aquaculture water. Behavioral parameters (swimming activity and distribution parameters) and changes in ventilation frequency (VF) of tilapia (Oreochromis niloticus) responded to acute fluctuations in dissolved oxygen (DO) which were monitored continuously in the course of normoxia, falling DO level, maintenance of hypoxia (three levels of 1.5, 0.8 and 0.3 mg l⁻¹) and subsequent recovery to normoxia. These parameters responded sensitively to acute variations in DO level; they displayed significant changes (P < 0.05) during severe hypoxia (0.8 and 0.3 mg l⁻¹ level) compared with normoxic condition, but there was no significant difference under conditions of mild hypoxia (1.5 mg l⁻¹ level). There was no significant difference in VF between two levels of severe hypoxia 0.8 and 0.3 mg l⁻¹ level during the low DO condition. The activity and distribution parameters displayed distinguishable differences between the 0.8 and 0.3 mg l⁻¹ levels. The behavioral parameters are thus capable of distinguishing between different degrees of severe hypoxia, though there were relatively large fluctuations.     

Effects of secondary crops on bacterial growth and nitrogen removal in shrimp farm effluent treatment systems

Secondary crops provide a means of assimilating some effluent nitrogen from eutrophic shrimp farm settlement ponds. However, a more important role may be their stimulation of beneficial bacterial nitrogen removal processes. In this study, bacterial biomass, growth and nitrogen removal capacity were quantified in shrimp farm effluent treatment systems containing vertical artificial substrates and either the banana shrimp Penaeus merguiensis (de Man) or the grey mullet, Mugil cephalus L. Banana shrimp were found to actively graze biofilm on the artificial substrates and significantly reduced bacterial biomass relative to a control (24.5±5.6 mg C m⁻² and 39.2±8.7 mg C m⁻², respectively). Bacterial volumetric growth rates, however, were significantly increased in the presence of the shrimp relative to the control (45.2±11.3 mg C m⁻² per day and 22.0±4.3 mg C m⁻² per day, respectively). Specific growth rate, or growth rate per cell, of bacteria was therefore appreciably stimulated by the banana shrimp. Nitrate assimilation was found to be significantly higher on grazed substrate biofilm relative to the control (223±54 mg N m⁻² per day and 126±36 mg N m⁻² per day, respectively), suggesting that increased bacterial growth rate does relate to enhanced nitrogen uptake. Regulated banana shrimp feeding activity therefore can increase the rate of new bacterial biomass production and also the capacity for bacterial effluent nitrogen assimilation. Mullet had a negligible influence on the biofilm associated with the artificial substrate but reduced sediment bacterial biomass (224±92 mg C m⁻²) relative to undisturbed sediment (650±254 mg C m⁻²). Net, or volumetric bacterial growth in the sediment was similar in treatments with and without mullet, suggesting that the growth rate per cell of bacteria in grazed sediments was enhanced. Similar rates of dissolved nitrogen mineralisation were found in sediments with and without mullet but nitrification was reduced. Presence of mullet increased water column suspended solids concentrations, water column bacterial growth and dissolved nutrient uptake. This study has shown that secondary crops, particularly banana shrimp, can play a stimulatory role in the bacterial processing of effluent nitrogen in eutrophic shrimp effluent treatment systems.     

Characterization of water quality factors during intensive raceway production of juvenile Litopenaeus vannamei using limited discharge and biosecure management tools

Disease epizootics have negatively affected production and expansion of the shrimp culture industry. This, along with environmental concerns regarding limited water resources and contamination of receiving streams, has caused the industry to investigate more sustainable and biosecure management practices. A study was conducted to evaluate the effect of limited water exchange on water quality, growth and survival of the Pacific white shrimp Litopenaeus vannamei postlarvae (PL) in greenhouse-enclosed raceways. Concentrations of NH₄-N did not exceed 2.0 mg l⁻¹ during this period; whereas, NO₂-N exceeded 26.4 mg l⁻¹, indicating assimilation of primary amines by primary productivity. Periodic removal of suspended solids by a common pressurized sand filter and injection of oxygen into culture water resulted in high-survival rates for both raceways (97.5 and 106.0%) with an average biomass yield of 4.29 ± 0.06 kg m⁻³. Shrimp samples collected during the nursery trial and at harvest showed no signs of bacterial or viral pathogen infections.     

Metabolic scope, swimming performance and the effects of hypoxia in the mulloway, Argyrosomus japonicus (Pisces: Sciaenidae)

The culture of the mulloway (Argyrosomus japonicus), like many other Sciaenidae fishes, is rapidly growing. However there is no information on their metabolic physiology. In this study, the effects of various hypoxia levels on the swimming performance and metabolic scope of juvenile mulloway (0.34 ± 0.01 kg, mean ± SE, n = 30) was investigated (water temperature = 22 °C). In normoxic conditions (dissolved oxygen = 6.85 mg l^− 1), mulloway oxygen consumption rate (M·o₂) increased exponentially with swimming speed to a maximum velocity (U_crit) of 1.7 ± < 0.1 body lengths s^− 1 (BL s^− 1) (n = 6). Mulloway standard metabolic rate (SMR) was typical for non-tuna fishes (73 ± 8 mg kg^− 1 h^− 1) and they had a moderate scope for aerobic metabolism (5 times the SMR). Mulloway minimum gross cost of transport (GCOT_min, 0.14 ± 0.01 mg kg^− 1 m^− 1) and optimum swimming velocity (U_opt, 1.3 ± 0.2 BL s^− 1) were comparable to many other body and caudal fin swimming fish species. Energy expenditure was minimum when swimming between 0.3 and 0.5 BL s^− 1. The critical dissolved oxygen level was 1.80 mg l^− 1 for mulloway swimming at 0.9 BL s^− 1. This reveals that mulloway are well adapted to hypoxia, which is probably adaptive from their natural early life history within estuaries. In all levels of hypoxia (75% saturation = 5.23, 50% = 3.64, and 25% = 1 .86 mg l^− 1), M·o₂ increased linearly with swimming speed and active metabolic rate (AMR) was reduced (218 ± 17, 202 ± 14 and 175 ± 10 mg kg^− 1 h^− 1 for 75%, 50% and 25% saturation respectively). However, U_crit was only reduced at 50% and 25% saturation (1.4 ± < 0.1 and 1.4 ± < 0.1 BL s^− 1 respectively). This demonstrates that although the metabolic capacity of mulloway is reduced in mild hypoxia (75% saturation) they are able to compensate to maintain swimming performance. GCOT_min (0.09 ± 0.01 mg kg^− 1 m^− 1) and U_opt (0.8 ± 0.1 BL s^− 1) were significantly reduced at 25% dissolved oxygen saturation. As mulloway metabolic scope was significantly reduced at all hypoxia levels, it suggests that even mild hypoxia may reduce growth productivity.     

Using a macroalgae Ulva pertusa biofilter in a recirculating system for production of juvenile sea cucumber Apostichopus japonicus

A simple indoor recirculating system for production of juvenile sea cucumber (Apostichopus japonicus) was operated on a commercial scale for 90 days during winter. The system consists of three 70 m³ sea cucumber rearing tanks and one biofilter tank where macroalgae (Ulva pertusa) was used as a biofilter in order to reduce water requirements. Effluent from the sea cucumber tanks drained into the macroalgae biofilter tank and were then returned to the sea cucumber tanks by a discontinuous-flow recirculation system. Survival and growth rates in the sea cucumber culture tanks were similar to those in the control tank (with one water exchange per day). The survival rate averaged about 87%. The average body weight increased from 3.5 ± 0.3 g to 8.1 ± 0.8 g and total sea cucumber biomass production over the experimental period was 745 g m⁻² after initial stocking densities of 375 g m⁻². The growth rate of U. pertusa was 3.3% day⁻¹. U. pertusa was efficient in removing toxic ammonia and in maintaining the water quality within acceptable levels for sea cucumber culture; there were only small daily variations of temperature, pH and DO. The U. pertusa tank removed 68% of the TAN (total ammonia-nitrogen) and 26% of the orthophosphate from the sea cucumber culture effluent; the macroalgae biofilter removed ammonia at an average rate of 0.459 g N m⁻² day⁻¹. It would be efficient to use the U. pertusa biofilter in a recirculating system for production of A. japonicus juveniles in winter.     

Free water productivity measurements in leaky mariculture ponds

The rate of net organic productivity in experimental shrimp mariculture ponds was determined via free water methods for each hour over a two month period in late summer 1985. Automated measurements of pH and temperature served as the basis for development of a mass balance budget for dissolved inorganic carbon. Pond surface area and volume changed with depth in a complex but predictable fashion. The seepage rate, which is a quantitatively important term in the inorganic carbon budget, was determined with the salt mass balance. Seepage rates averaged 136–182 mm day⁻¹ (23–37% of pond volume per day). Close agreement between evaporation rates, independently determined from water budgets for each of the four adiacent ponds, demonstrated that the calculated seepage rates were accurate. All four ponds were net producers of organic matter despite the fact that three of the four received additions of allochthonous organic matter. Net productivity averaged 14–65 mmol C m⁻² day⁻¹.     

Observations of pond hydrodynamics

This paper provides a detailed observation of pond hydrodynamics. Bathymetry and aerator deployment largely control the hydrodynamic regime. Aerators drive pond circulation, which is resisted by bottom and bank friction. Hydrodynamic friction is characterized by sediment grain size. One particular pond is offered as a proxy representative of Australian mariculture ponds in general: Pond X. The pond had been stocked with P. monodon at densities in the range 25–35 m⁻² about ten times during the period from 1989 to 1995. Observations were made in the year 1996. The site was on the east coast of Australia at 18° south latitude. The location was sheltered by a mountainous offshore island, such that winds effecting the pond averaged 2.3 m s⁻¹. Water exchange occurred at a rate of about 8.3% of pond capacity per day. Pond X was found to be rectangular, 120 m long and 87 m wide. The banks were found to slope between 1:1.5 and 1:7.6, with an average slope near 1:3. The pond was shallowest in one corner, where depth was 834 mm, and drained diagonally with 1872-mm maximum water depth. Aeration was provided by a total of six 1.5-kW machines, comprised of two of the paddlewheel type and four of the propeller-aspirator type. Each machine was found to deliver 200 N of horizontal thrust into the pond water column. The combined effect of the aerators created a circulation current averaging about 11 cm s⁻¹ around the pond periphery. The central region of the pond was found to have a fluctuating velocity of less than 1 cm s⁻¹. The mass-average size of pond soil and sediment was found to vary from 25 μm in the central region to 250 μm at the banks and where the bottom was swept by paddlewheels.     

Stocking density and shelter type for the optimal growth and survival of western rock lobster Panulirus cygnus (George)

The growth and survival of three size classes of wild caught western rock lobster, Panulirus cygnus (post-pueruli: mean 2.14 ± 0.07 g, 13.2 ± 0.1 mm CL; year 1: post-settlement juveniles, 57.1 ± 1.1 g, 38.7 ± 0.28 mm CL; and year 2 post-settlement juveniles, mean 138.2 ± 2.26 g, 51.9 ± 0.25 mm CL) were examined at combinations of two stocking densities (post-pueruli: 50 and 100 m^− 2; year 1: 11 and 23 m^− 2; year 2: 10 and 19 m^− 2) and two shelter types (a novel rigid plastic mesh shelter or bricks) over a period of 6 months. Survival of lobsters held at the lower densities (90–95%) was significantly greater than for lobsters held at higher densities (post-pueruli = 78%, year 1 = 86%, year 2 = 88%). Post-pueruli survival was significantly higher in tanks with mesh shelters (91.7%) than brick shelters (75.8%) with a similar trend exhibited by year 1 and year 2 lobsters. Densities tested did not significantly affect lobster growth for any size class. Growth of post-pueruli was considerably higher in tanks with mesh shelters (641.7% weight gain; specific growth rate 1.07 BW day^− 1) (p < 0.05) but there was no difference in the growth of year 1 and year 2 lobsters between mesh and brick shelters. Feed intake (g pellet dry matter lobster^− 1 day^− 1) was not significantly different between densities. This study has shown that P. cygnus is well suited for aquaculture based on the collection and ongrowing of wild caught pueruli, as this species exhibits good survival at high densities (up to 100 m^− 2) without adverse effects on growth, and shows no captivity-related health problems. We recommend mesh shelters, with stocking densities of 50 m^− 2 for post-pueruli and between 20 and 25 m^− 2 for year 1 and year 2 juveniles, to maximise survival and production.     

Energy balance of Litopenaeus vannamei postlarvae fed on animal or vegetable protein based compounded feeds

L. vannamei postlarvae are normally raised with a protein dense diet (50% protein) rich in fishmeal. Part of the protein is utilized for energy purpose instead of protein synthesis. Based on a previous energy partitioning study, the effects of two isoenergetic compounded feed treatments – animal protein (AP) and vegetable protein and carbohydrates (VPC) – upon growth efficiency and energy budget of shrimp postlarvae and early juveniles were determined. Recovered energy (RE) or production (P) after 50 days trial was similar (2 J day^− 1) in both treatments, from PL₁₄ to PL₁₉. However, early juveniles discriminated between animal protein (116 J day^− 1) and vegetable protein and carbohydrates (88 J day^− 1). The difference in respiration indicated a higher heat increment with AP compared to VPC. At maintenance level, energy used was lower with AP than VPC treatment. Postlarvae and early juveniles employed protein as a main energy substrate (O:N < 20). Differences in the efficiencies observed in the calculated energy budget were attributed to the presence of carbohydrates in diet and not to the protein source. The advantage of incorporating vegetable protein source in the diet of harvesting shrimp may eventually contribute towards a reduction of fishmeal costs and waste products as well as to achieve sustainable shrimp farming.     

Effects of dissolved oxygen on hemolymph parameters of freshwater giant prawn, Macrobrachium rosenbergii (de Man)

Profiles of changes in physiological parameters of freshwater giant prawns, Macrobrachium rosenbergii, exposed to various dissolved oxygen (DO) levels of 7.75, 4.75, 2.75, and 1.75 mg l⁻¹ are reported. The parameters involved in osmoregulation and oxygen transport were monitored for a 6-day period. Notable depressions in hemolymph osmolality, Na⁺, K⁺, and Cl⁻ contents were observed within 24 h after exposure to hypoxia at 2.75 and 1.75 mg O₂ l⁻¹, and thereafter remained at rather steady levels, which were significantly lower than those under normoxic conditions (4.75–7.75 mg O₂ l⁻¹). The extent of depression of osmotic-related constituents, hemolymph osmolality and Cl⁻ in particular, increased with decreased DO.

Oxyhemocyanin constituted 65.46–65.84% of total hemolymph proteins under the various DO levels examined; both hemolymph oxyhemocyanin and proteins showed notable elevations 24 h after exposure to hypoxic conditions, and reached the highest and constant level by 48 h after exposure. The compensatory responses of prawns to reduced O₂ were manifested by increased O₂ uptake through augmentation of hemocyanin, which results in enhancement of oxygen binding capacity of the hemolymph. In the same period, a significant surge of the respiratory products, PCO₂ and HCO₃⁻, was also demonstrated 6 h after exposure to hypoxic conditions which resulted in hemolymph alkalosis. These processes likely resulted in an increase in water influx and consequent declines in hemolymph osmolality and ion composition. Furthermore, hyperventilation and respiratory alkalosis, indicated by increased oxyhemocyanin and pH, respectively, were found to be predominant responses of M. rosenbergii to hypoxic stress.     

Preliminary tests of an aerated tank system for tilapia culture

A simple tank system, using artificial aeration to supply oxygen and incoming water to dilute metabolic by-products and other wastes, was tested. Blue tilapia, Oreochromis aureus, were grown under a wide range of loads, 7–31 kg liter⁻¹ min⁻¹, and densities, 19–77 kg fish m⁻³ culture unit. Average yield ranged from 6–10 kg m⁻³ culture unit per month. Approximately 14–20 m³ of water was used for each kilogram of fish produced.     

Effects of elevated atmospheric CO2 on growth, photosynthesis and nitrogen metabolism in the economic brown seaweed, Hizikia fusiforme (Sargassaceae, Phaeophyta)

Hizikia fusiforme (Harv.) Okamura (brown seaweed) was cultured using aeration with two CO₂ conditions: outdoor air (actual atmospheric CO₂ concentration, averaging 360 μl l^− 1) and CO₂-enriched air (averaging 700 μl l^− 1), to investigate the possible adjustments of elevated atmospheric CO₂ to the growth, photosynthesis and nitrogen metabolism in this mariculture species. Aeration with CO₂-enriched air reduced the pH in the culture medium in comparison with aeration with air. The mean relative growth rate was enhanced when H. fusiforme was grown at high CO₂ with respect to normal CO₂. There was little change in the rate of light-saturated photosynthesis, dark respiratory rate and apparent photosynthetic efficiency, measured in natural seawater, between thalli grown in high and normal CO₂ contents. However, both the mean nitrate uptake rate and the activity of nitrate reductase at light period were increased following culture at high CO₂, indicating an enhanced nitrogen assimilation of H. fusiforme thalli with the CO₂ enrichment in culture. It was proposed that the intensive cultivation of H. fusiforme would remove nutrients more efficiently with the future elevation of CO₂ levels in seawater, which could be a possible solution to the problem of ongoing coastal eutrophication.     

Outdoor phytoplankton continuous culture in a marine fish–phytoplankton–bivalve integrated system: combined effects of dilution rate and ambient conditions on growth rate, biomass and nutrient cycling

Natural phytoplankton populations were cultured in outdoor continuous cultures using fish-farm effluents as the source of nutrients. The dilution rate was assumed to be the integrating factor of phytoplankton growth and biomass development (flux and stock). In this context, the combined effects of (i) dilution rates of the outdoor culture and (ii) ambient conditions were tested on phytoplankton growth, biomass and cycling of the major nutrient elements (C, N and P). Experiments were carried out in outdoor polyester tanks (0.7 m deep), homogenised by gentle aeration. Si/P ratio was balanced at around 5 in the inflow in order to induce diatom domination while maintaining high N and P assimilation by phytoplankton. Nutrient cycling was assessed through analyses of the different forms of particulate and dissolved nutrients in the inflow and the outflow. Culture dilution rates determined the longevity of the culture and the assimilation efficiency of nutrients. Dissolved phosphorus was the most limiting nutrient. The optimal dilution rate was approximately 0.5 day⁻¹ at 10 °C and 1.5 day⁻¹ at 20 °C with a mean diatom biomass of 9 μM P. Under these conditions, 80% of the dissolved nutrients provided to the tanks were transformed, a production of 8 g C m⁻² day⁻¹ and an assimilation rate of 0.3 g P m⁻² day⁻¹ were recorded. Assimilation by diatoms was the major pathway of nutrient cycling. During the experiment, a bottom sediment developed progressively and this also played an important role in denitrifying the excess dissolved nitrogen in the fish-farm effluent. However, the results showed that diatom biomass can collapse and we hypothesize that this was the consequence of an increase in cellular sinking rates due to cell aggregation under nutrient or light stress. Modelling approaches are needed in future research in order to determine optimal dilution rates taking into account phytoplankton growth rates, nutrient inputs and ambient conditions (e.g. light and temperature).     

A simple test to estimate the salinity resistance of fish with specific application to O. niloticus and S. melanotheron

In order to develop a simple and accurate index of the salinity resistance of tilapia, batches of 10 juveniles (5 to 20 g) of two different species Oreochromis niloticus and Sarotherodon melanotheron reared in freshwater were subjected to gradual increases in salinity until 100% mortality. Seven daily increments of salinity were tested with 4 replicates: 2, 4, 6, 8, 10, 12 and 14 g l⁻¹ day⁻¹, while control batches were kept in fresh water. The temperature was maintained at 27 °C. The concentration of oxygen, ammonia and the pH were not limiting factors. The mortality, monitored on a daily basis, appeared after 2–51 days and was spread out over 1–20 days, depending on the increment of salinity. The higher the daily rate in salinity increase, then the shorter the time lapse before total mortality occurred. The cumulative mortality as a function of salinity fit well with simple linear regressions. The criterion of the resistance to salinity was the index MLS (median lethal salinity) defined at each daily rate as the salinity at which 50% of fish died. For S. melanotheron, the mean MLS was 123.7±3.5 g l⁻¹ whatever the daily rate in salinity. For O. niloticus, the MLS was 46.3±3.4 g l⁻¹ for daily increases in salinity ranging from 2 to 8 g l⁻¹ day⁻¹ and decreased significantly (P<0.05) above this level. The MLS-8 g l⁻¹ day⁻¹ ,which takes into account the full capacity of the fish to adapt to the increasing salinity, appeared to be a simple, optimized and efficient criterion for assessing the resistance to salinity for O. niloticus and S. melanotheron. This criterion can be a useful tool for ranking the different parental strains and hybrids of different genus and species of tilapia used in programmes of genetic selection for growth and salinity tolerance.     

The effects of the decomposition of mangrove leaf litter on water quality, growth and survival of black tiger shrimp (Penaeus monodon Fabricius, 1798)

An experiment was conducted for 8 weeks at the Cantho University, Vietnam, to determine the acceptable level of mangrove leaf litter load and its effect on water quality, growth and survival rate of tiger shrimp (Penaeus monodon). Shrimps were cultured in plastic tanks containing 50 L of brackish water (salinity of 15‰). Leaf litter of Rhizophora apiculata, Avicennia officinalis, Excoecaria agallocha and Acacia auriculiformis were loaded to tanks at rates of 0.0 (control), 0.125, 0.25, 0.5, 1.0 and 2.0 g L^− 1 with and without aeration. Tiger shrimp post-larvae (PL; 0.05 ± 0.01 g) obtained from the shrimp hatchery of Cantho University were stocked at a density of 20 PL per tank and fed with pelleted feed containing 38% protein at a rate of 10% body weight (BW) day^− 1.

The high leaf-loading rates significantly reduced dissolved oxygen (DO) and survival rates of shrimp in the non-aerated treatments, and all shrimps died after 2 days in the treatments with loading rates above 0.5 g L^− 1. Leaf litter loads significantly increased tannin content, chemical oxygen demand (COD), H₂S and pH in the aerated treatments. Stepwise regression analysis showed COD, tannin and H₂S concentrations had negative effects on shrimp growth in the aerated treatments. Tannin concentration was found to be highest in the treatments with Excoecaria (32 mg L^− 1) and Avicennia (24 mg L^− 1) leaves. However, there were no significant differences in growth and survival rates of shrimp among the aerobic treatments loaded with different leaf types. The results of this study showed that moderate load of mangrove leaves could play an important role in promoting shrimp growth and survival in aerobic condition. Mangrove leaves at a loading rate of 1 g L^− 1 positively influenced both the survival and growth rate of shrimps.     

The hydraulically integrated serial turbidostat algal reactor (HISTAR) for microalgal production

A hydraulically integrated serial turbidostat algal reactor (HISTAR) for the mass production of microalgae was designed, constructed and preliminarily evaluated. The 9266-l experimental system consists of two enclosed turbidostats hydraulically linked to a series of six open continuous-flow, stirred-tank reactors (CFSTRs). The system was monitored and controlled using GENESIS process control software. A production study was preformed using Isochrysis sp. (C-iso) to assess system stability and production potential under commercial-like conditions. The study was performed at the following target system parameters: system dilution rate of 0.49 per day, pH 7.6, NITROGEN=10 mg l⁻¹, PHOSPHORUS=2 mg l⁻¹, and artificial illumination (photosynthetic photon flux density) from 1000 W metal halide LAMPS=800 μmol s⁻¹ m⁻². At steady state conditions, daily harvested algal paste was 1454 g (wet), mean areal system PRODUCTIVITY=47.8±3.04 g m⁻² per day (17.1±1.09 g C m⁻² per day) and mean CFSTR6 DENSITY=105.5±6.71 mg l⁻¹.     

Performance and operation of a rotating biological contactor in a tilapia recirculating aquaculture system

This paper describes the performance characteristics of an industrial-scale air-driven rotating biological contactor (RBC) installed in a recirculating aquaculture system (RAS) rearing tilapia at 28 °C. This three-staged RBC system was configured with stages 1 and 2 possessing approximately the same total surface area and stage 3 having approximately 25% smaller. The total surface area provided by the RBC equaled 13,380 m². Ammonia removal efficiency averaged 31.5% per pass for all systems examined, which equated to an average (± standard deviation) total ammonia nitrogen (TAN) areal removal rate of 0.43 ± 0.16 g/m²/day. First-order ammonia removal rate (K₁) constants for stages 1–3 were 2.4, 1.5, and 3.0 h⁻¹, respectively. The nitrite first-order rate constants (K₂) were higher, averaging 16.2 h⁻¹ for stage 1, 7.7 h⁻¹ for stage 2, and 9.0 h⁻¹ stage 3. Dissolved organic carbon (DOC) levels decreased an averaged 6.6% per pass across the RBC. Concurrently, increasing influent DOC concentrations decreased ammonia removal efficiency. With respect to dissolved gas conditioning, the RBC system reduced carbon dioxide concentrations approximately 39% as the water flowed through the vessel. The cumulative feed burden – describes the mass of food delivered to the system per unit volume of freshwater added to the system daily – ranged between 5.5 and 7.3 kg feed/m³ of freshwater; however, there was no detectable relationship between the feed loading rate and ammonia oxidation performance.     

Dopamine modulates the physiological response of the tiger shrimp Penaeus monodon

Levels of glucose, lactate, pO₂, pCO₂, HCO₃⁻, TCO₂, Na⁺, K⁺, Cl⁻, protein, and oxyhemocyanin in the hemolymph and its osmolality and pH were measured when tiger shrimp, Penaeus monodon (13.5 ± 1.5 g body weight), were individually injected with saline or dopamine at 10^− 8, 10^− 7, or 10^− 6 mol shrimp^− 1. Results showed that hemolymph glucose, lactate, pCO₂, HCO₃⁻, and TCO₂ values increased from 2 to 4 h; hemolymph osmolality, Na⁺, and total protein had increased at 2 h; and hemolymph K⁺ decreased from 2 to 8 h after the dopamine injection. All physiological parameters returned to the control values 4–16 h after receiving dopamine. The dopamine injection also significantly decreased the oxyhemocyanin/protein ratio of P. monodon which occurred at 2 h, resulting from an elevation of hemolymph protein and a slight decrease of oxyhemocyanin. These results suggest that stress-inducing dopamine caused a transient period of modulation of energy metabolism, osmoregulation, respiration, and the acid–base balance in P. monodon in adapting to this environmental stress.     

Performance of packed column aerator at low hydraulic loading

A laboratory-scale packed column aerator filled with ceramic Raschig rings was tested for its performance with hydraulic loadings in the range of 16–86·3 m³ m⁻² h⁻¹. Two columns of 0·19 m and 0·24 m inside diameter and packing sizes of 15, 25 and 36 mm were used. The system equation developed by previous workers for trickling filters in waste-water treatment was not generally applicable across the lower hydraulic loadings. The system coefficient incorporating the oxygen absorption coefficient (k_La) was found to vary within the range of hydraulic loadings studied. The oxygen transfer rate equation developed for surface and submerged aerators was used for estimating standard oxygen transfer efficiency of the packed column aerator, which, in this case, ranged from 6·2 to 22·6 kg O₂ kWh⁻¹.