Evaluation of the combined effects of enzymatic treatment and aging on lees on the aroma of wine from Bombino bianco grapes

In this study, two different doses of commercial beta-glucanase enzyme preparation were tested to verify their effect on wines aged on lees. These wines were compared with two samples with no enzymatic treatment. The former was aged on lees (control), and the latter was readily filtered off from the yeast cell biomass (standard). Analysis of variance (one-way ANOVA), the Tukey test, and principal component analysis (PCA) were applied to all of the samples, which were analyzed for aroma composition, along with galacturonic acid, total acidity, pH, and color. Results showed a large number of statistically significant differences among samples. In general, wines treated with beta-glucanase were characterized by higher concentration of many volatile compounds. The presence of lees and even more the exogenous enzymatic action enhanced almost all volatile compounds. Besides the high presence of ethyl esters, it is worth mentioning the behavior of hexanol and trans-3-hexenol, which are strongly enhanced by the presence of lees and by enzymatic treatments.     

Influence of wine turbidity on the accumulation of volatile compounds from the oak barrel

In this work the influence of the turbidity of a red wine aged in oak barrels on the accumulation of volatile compounds has been studied. From the results obtained, it may be concluded that the wine turbidity had an effect on the concentration of many of the oak volatile compounds, especially furanic and phenolic compounds. In all cases the concentrations of furanic aldehydes and vanillin were significantly higher (p < 0.01) in the filtered wine than in the unfiltered wine. However, in the unfiltered wine the concentrations of gamma-butyrolactone and eugenol were higher. This difference in the concentrations would be due to the different compositions of the wines and the binding of compounds to some components of the lees. Likewise, it has been observed that the composition of the lees is fundamental in the binding of volatile compounds to the lees as the fermentative lees behave differently from the lees from the wine aging in barrels.     

Impact of oxygen consumption by yeast lees on the autolysis phenomenon during simulation of wine aging on lees

Potential oxygen consumption by lees, more precisely by nonviable yeasts, during wine aging was recently described. Additionally, yeast autolysis is described as the main mechanism of degradation of lees during wine aging. Thus, to understand the effect of oxygen consumption by yeast lees during wine aging, an accelerated wine aging methodology was tested. Wine aging in the presence of yeast lees was studied both in the presence and in the absence of oxygen. Different markers of yeast autolysis were followed to find a relationship between oxygen consumption by yeast lees and changes in the final wine composition after aging. No differences for compounds tested were found in the wine and in the lees except among sterol compounds in lees: in the presence of oxygen, the concentration of ergosterol in lees was significantly lower than that in the absence of oxygen. It was hypothesized that ergosterol could be oxidized under the influence of oxygen, but none of the known products of ergosterol oxidation were recovered in the corresponding yeast lees. In addition, the decrease of ergosterol content in yeast lees cannot account for the total amount of oxygen consumed by yeast lees during such wine aging.     

Formulation of low-cost fermentative media for lactic acid production with Lactobacillus rhamnosus using vinification lees as nutrients

Lees coming from different steps in white wine and red wine vinification were characterized under physicochemical analyses to determine the content in carbon, nitrogen, ashes, solids in suspension, organic compounds, and minerals. Due to the hydrolytic activity of Lactobacillus strains, lees without autolysis treatments were used directly as the unique nutrient or in combination with corn steep liquor to carry out the glucose to lactic acid fermentation with Lactobacillus rhamnosus CECT-288. Time courses of glucose and lactic acid were modeled according to reported models. Using 20 g/L of lees coming from the white wine technology and re-collected after the second decanting step before distillation, as the only nutrient, the values achieved (P = 105.5 g/L, Q(P) = 2.470 g/L.h) were even higher than those obtained with the costly MRS broth (P = 104.3 g/L, Q(P) = 2.251 g/L.h).     

不同酶和酵母对干红葡萄酒香气影响的差异分析

为提高甘肃河西产区蛇龙珠干红葡萄酒的香气品质,优化酿酒工艺,该文采用顶空固相微萃取和气相色谱-质谱联用技术,分析比较了添加不同浸渍酶和酵母发酵的蛇龙珠干红葡萄酒的香气构成。结果显示:蛇龙珠干红葡萄酒中初步定性香气化合物75种,主要为酯、醇、酸、萜烯和酚类物质。比较酯类、萜烯类等香气成分质量浓度和香气物质释放总量,EX-V酒样明显高于EX和HC酒样,D254酒样明显高于BDX酒样。各组酒样主要香气成分构成相似,但微量香气成分差异显著。果香是香气强度最高的香气系列,植物香、脂肪香、花香次之,其香气强度EX-V酒样高于EX和HC酒样,D254酒样高于BDX酒样。浸渍酶和酵母对甘肃河西产区蛇龙珠干红葡萄酒香气品质的影响评价显示,浸渍酶EX-V优于EX和HC,酵母D254优于BDX。研究结果可为甘肃河西产区蛇龙珠干红葡萄酒香气品质的提高及酿造工艺研究提供科学数据参考。     

Evaluation of vinification lees as a general medium for lactobacillus strains

Lactobacillus species present high nutritional requirements, so it is necessary to find new low-cost nutrient components for fermentation media. This work compares the utilization of vinification lees (an important residue of wineries) from red and white winemaking technology, distilled or not. An amount of 20 g of lees/L was used as the unique nutrient to obtain lactic acid from glucose using Lactobacillus strains with different properties: L. plantarum CECT-221, L. pentosus CECT-4023, L. casei CECT-5275, and L. coryniformis subsp. torquens CECT-25600. Only L. casei using distilled lees showed values (Pmax = 92.1 g/L and Y(P/S) = 1.05 g/g) similar to those obtained with the MRS broth. The UV spectra of white and red lees, distilled or not, allowed an interpretation of the different phenolic compounds present and their influence on the fermentation. Their detoxification by extraction with organic compounds and fermentation with L. pentosus was also considered. Time courses of glucose and lactic acid were modeled according to reported models to obtain more information about the process.     

Quantitative ester analysis in cachaca and distilled spirits by gas chromatography-mass spectrometry (GC-MS)

An analytical procedure for the separation and quantification of ethyl acetate, ethyl butyrate, ethyl hexanoate, ethyl lactate, ethyl octanoate, ethyl nonanoate, ethyl decanoate, isoamyl octanoate, and ethyl laurate in cachaca, rum, and whisky by direct injection gas chromatography-mass spectrometry was developed. The analytical method is simple, selective, and appropriated for the determination of esters in distilled spirits. The limit of detection ranged from 29 (ethyl hexanoate) to 530 (ethyl acetate) microg L(-1), whereas the standard deviation for repeatability was between 0.774% (ethyl hexanoate) and 5.05% (isoamyl octanoate). Relative standard deviation values for accuracy vary from 90.3 to 98.5% for ethyl butyrate and ethyl acetate, respectively. Ethyl acetate was shown to be the major ester in cachaca (median content of 22.6 mg 100 mL(-1) anhydrous alcohol), followed by ethyl lactate (median content of 8.32 mg 100 mL(-1) anhydrous alcohol). Cachaca produced in copper and hybrid alembic present a higher content of ethyl acetate and ethyl lactate than those produced in a stainless-steel column, whereas cachaca produced by distillation in a stainless-steel column present a higher content of ethyl octanoate, ethyl decanoate, and ethyl laurate. As expected, ethyl acetate is the major ester in whiskey and rum, followed by ethyl lactate for samples of rum. Nevertheless, whiskey samples exhibit ethyl lactate at contents lower or at the same order of magnitude of the fatty esters.     

加热处理对蜂蜜酒香气物质的影响

为研究适合蜂蜜酒发酵的优良工艺条件,以2批荆条蜜(白色和浅琥珀色)为原料,在酒精发酵前对发酵醪液进行加热处理,以不加热处理的样品为对照,采用酿酒酵母FX10进行发酵,发酵结束后测定蜂蜜酒的各项理化指标及挥发性化合物的含量。结果表明,供试酒样中共检测出77种挥发性物质,其中酯类39种、醇类20种、酸类8种、萜烯类4种、羰基化合物6种。加热处理可以显著增加蜂蜜酒中香气物质的种类和含量,含量较高的香气物质有乙酸乙酯、乙酸苯乙酯、乙酸异戊酯、己酸乙酯、辛酸乙酯、癸酸乙酯、月桂酸乙酯、9-十六碳烯酸乙酯、异戊醇、β-苯乙醇、辛酸和癸酸。对蜂蜜酒中香气物质进行主成分分析,发现加热处理的酒样中酯类物质对酒香贡献较大;对照酒样中酯类物质对酒香贡献较小,而醇类物质是其主要挥发性成分。本研究结果为蜂蜜酒的生产提供了一定的理论依据。     

Influence of distillation system,oak wood type,and aging time on volatile compounds of cider brandy

A study of the influence of distillation system, oak wood type, and aging time on volatile compounds of cider brandy was carried out. Acetaldehyde and acetaldehyde diethyl acetal were influenced by distillation technology, oak wood type, and maturation time. The majority ester, ethyl ethanoate, increased during aging, the highest level of this ester being detected in spirits distilled by double distillation. The alcohols of higher molecular weight were better recovered in the rectification column than in the double distillation system. Ethanoate esters decreased throughout aging of the spirits, and their degradation velocity was lower in distillates obtained from double distillation. Fatty acids and their ethyl esters presented the opposite evolution during aging, detecting an increase in ethyl esters and a decrease in their corresponding fatty acids. An increase of 1,1,3-triethoxypropane was detected during aging. French oak contributes the trans isomer of beta-methyl-gamma-octalactone and American oak contributes the cis isomer.     

Fate of quinoxyfen residues in grapes, wine, and their processing products

Quinoxyfen is a new fungicide that belongs to the family of the quinolines, recently introduced to control powdery mildew (Uncinula necator). In this paper the fate of quinoxyfen residues from vine to wine and in their processing products was studied. After the last of four applications at the recommended rate, 0.38 mg/kg of residue was found on the grapes, which is under the legal limit fixed in Italy (0.5 mg/kg). The degradation rate was according to a pseudo-first-order kinetics (r = 0.964) and the half-life was 7.24 days. Vinification was carried out with and without maceration. During the vinifications without maceration <50% of the residues passed from the grapes to the musts. Separation of the lees (8%) from the must by centrifugation caused no detectable residues in centrifuged must. At the end of fermentation with and without maceration no quinoxyfen residues were determinable in the wine. No effect on the alcoholic or malolactic fermentation was observed even in the presence of higher quinoxyfen concentrations than those found in the grapes at harvest time. During fermentation, the yeasts partially degraded the pesticides and completly adsorbed them. Bacteria, on the other hand, do not have any degradative effect on the pesticides. The raisins obtained by sun-drying did not contain any residues, whereas those obtained by oven-drying show the same amount of residues as in the fresh grapes. During the sun-drying process the fruit weight decreased by a factor of 4; the decrease in the oven-drying was equivalent. Samples of dregs and liquid lees, fortified with high levels of quinoxyfen. were double-distilled. The first dregs distillate, with an alcohol content of 32.1%, did not show any residues, whereas the first lees distillate, with an alcohol content of 34.5%, showed 7% of the initial residues. After the second lees distillation, the obtained product showed an alcoholic content of 81.2% and no residues of quinoxyfen (<0.01 mg/kg).     

Interactions between yeast lees and wine polyphenols during simulation of wine aging. II. Analysis of desorbed polyphenol compounds from yeast lees

In the first part of this work, the analysis of the polyphenolic compounds remaining in the wine after different contact times with yeast lees during simulation of red wine aging was undertaken. To achieve a more precise view of the wine polyphenols adsorbed on lees during red wine aging and to establish a clear balance between adsorbed and remnant polyphenol compounds, the specific analysis of the chemical composition of the adsorbed polyphenolic compounds (condensed tannins and anthocyanins) after their partial desorbtion from yeast lees by denaturation treatments was realized in the second part of the study. The total recovery of polyphenol compounds from yeast lees was not complete, since a rather important part of the initial wine colored polyphenols, especially those with a dominant blue color component, remained strongly adsorbed on yeast lees, as monitored by color tristimulus and reflectance spectra measurements. All anthocyanins were recovered at a rather high percentage (about 62%), and it was demonstrated that they were not adsorbed in relation with their sole polarity. Very few monomeric phenolic compounds were extracted from yeast lees. With the use of drastic denaturing treatments, the total recovery of condensed tannins reached 83%. Such tannins extracted from yeast lees exhibited very high polymeric size and a rather high percentage of galloylated residues by comparison with initial wine tannins, indicating that nonpolar tannins were preferentially desorbed from yeast lees by the extraction treatments.     

戴尔有孢圆酵母调控晚采小芒森葡萄酒乙酸和香气

为降低甜型葡萄酒中的挥发酸,进一步增加其香气复杂度,该研究利用本土戴尔有孢圆酵母R12与酿酒酵母NX11424同时接种和顺序接种发酵,研究其对贺兰山东麓产区晚采小芒森葡萄酒乙酸及香气成分的调控。与酿酒酵母单菌发酵相比,本土戴尔有孢圆酵母与酿酒酵母按照5:1、20:1、50:1的不同菌体数量比例同时接种和间隔5d顺序接种发酵,均可以显著降低晚采小芒森葡萄酒的乙酸含量,其乙酸产率分别降低19.1%、21.2%、38.2%和48.9%。此外,按20:1比例同时接种发酵,可显著提高晚采小芒森葡萄酒中萜烯类和降异戊二烯类等品种香气物质含量,和乙酸异戊酯、丁酸乙酯及苯乙醇等发酵香气物质的含量。该研究表明合理的酿酒酵母接种发酵能有效降低高糖原料酿造葡萄酒挥发酸含量,为贺兰山东麓产区葡萄酒新产品的开发提供了的技术参考。     

Changes in the concentration of yeast-derived volatile compounds of red wine during malolactic fermentation with four commercial starter cultures of Oenococcus oeni

The effects of malolactic fermentation (MLF) on the concentration of volatile compounds released by yeasts during the production of red wine were investigated by inoculation with four commercial starters of Oenococcus oeni. Volatile compounds in wine at the end of MLF were extracted, analyzed by GC-MS and GC, and compared with those extracted form a noninoculated reference sample. Several esters known to play a role in the aroma profile of red wine, such as C4-C8 ethyl fatty acid esters and 3-methylbutyl acetate, were found to increase with MLF, and their final concentration was dependent on the bacterial starter employed for the induction of MLF. The overall increase of ethyl fatty acid esters was generally larger than the one observed for acetate esters. Ethyl lactate, 3-hydroxybutanoate, 2-phenylethanol, methionol, and gamma-butyrolactone were also increased by bacterial metabolism. The impact of MLF on other volatiles or red wine, including several higher alcohols, fatty acids, and nitrogen compounds, was generally negligible.     

Interactions between yeast lees and wine polyphenols during simulation of wine aging: I. Analysis of remnant polyphenolic compounds in the resulting wines

Wine aging on yeast lees is a traditional enological practice used during the manufacture of wines. This technique has increased in popularity in recent years for the aging of red wines. Although wine polyphenols interact with yeast lees to a limited extent, such interactions have a large effect on the reactivity toward oxygen of wine polyphenolic compounds and yeast lees. Various domains of the yeast cell wall are protected by wine polyphenols from the action of extracellular hydrolytic enzymatic activities. Polysaccharides released during autolysis are thought to exert a significant effect on the sensory qualities of wine. We studied the chemical composition of polyphenolic compounds remaining in solution or adsorbed on yeast lees after various contact times during the simulation of wine aging. The analysis of the remnant polyphenols in the wine indicated that wine polyphenols adsorption on yeast lees follows biphasic kinetics. An initial and rapid fixation is followed by a slow, constant, and saturating fixation that reaches its maximum after about 1 week. Only very few monomeric phenolic compounds remained adsorbed on yeast lees, and no preferential adsorption of low or high polymeric size tannins occurred. The remnant condensed tannins in the wine contained fewer epigallocatechin units than the initial tannins, indicating that polar condensed tannins were preferentially adsorbed on yeast lees. Conversely, the efficiency of anthocyanin adsorption on yeast lees was unrelated to its polarity.     

Wine production using yeast immobilized on apple pieces at low and room temperatures

A biocatalyst was prepared by immobilization of Saccharomyces cerevisiae strain AXAZ-1 on apple pieces. It was examined by electron microscope and studied during the fermentation of grape must for batch wine-making. The immobilized yeast showed an important operational stability without any decrease of its activity even at low temperatures (1-12 degrees C). Specifically, at 6 degrees C the biocatalyst favored wine production within 8 days, which is less time than is required for the natural fermentation of grape must. At 1 degrees C wine production was effected in 1 month. This speeding up of the fermentation could be accepted and adopted by the industry for scaling up the wine-making process. Total and volatile acidities were similar to those found in dry wines. The concentrations of higher alcohols (propanol-1 and isobutyl alcohol) were low. The presence of amyl alcohols proved to be temperature dependent and decreased with the temperature decrease. The values of ethyl acetate concentrations were relatively high, up to 154 mg/L. This probably contributes to the fruity aroma and excellent taste of the produced wines. There was no indication of vinegar odor in the product given that the volatile acidity was <0.47 g of acetic acid/L. From the GC-MS analysis it was concluded that cell immobilization did not create serious changes in the product (wine) with regard to the qualitative composition of the aroma compounds.     

Optimization of making barrel-fermented dry muscatel wines

The optimization of making barrel-fermented muscatel wines requires determining what type of must clarification is most suitable for the quality of the wine, as well as what type of barrel will yield the most acceptable wines. This is achieved by adding pectolytic enzymes to clarify part of the muscatel must statically; the rest is clarified by vacuum filtration. The musts obtained are fermented in French and American oak barrels and, once fermentation has ceased, they are kept with their lees for 2 months, with periodic stirring. Eleven conventional parameters and 31 volatile compounds were quantified, and a sensory analysis of the wines was produced, which led us to conclude that static clarification with pectolytic enzymes from the muscatel musts produces the best-structured wines and the larger content of higher alcohols, esters, and terpenic compounds. The wines fermented in American oak barrels received the highest overall marks, which may be due to the greater aromatic complexity given off by the compounds in the wood.     

Effect of the stone content on the quality of plum and cherry spirits produced from mash fermentations with commercial and laboratory yeast strains

To evaluate the influence of stone content on spirit quality from stone fruit, cherry and plum mashes were prepared and fermented with a commercial and a diploid laboratory yeast strain. Fermentation parameters such as sugar content and ethanol production were followed. Despite an initial lag phase in cherry spirits, both yeast strains performed similarly, as substantiated by the determination of specific flavor compounds, ethyl carbamate, and methanol in the mashes and after distillation. The spirits produced were subjected to sensory analyses by trained panels of at least 25 judges. Although mashes retaining the stones could be clearly distinguished from those where the stones had been removed, no significant preference could be attributed to either spirit, indicating that qualities added by the presence of stones during fermentation are largely a matter of personal taste. Interestingly, the yeast strain used for fermentation seemed to have little influence on the spirit quality.     

Evolution of the aroma profile of sherry wine vinegars during an experimental aging in wood

Changes in the aroma profile of five Sherry wine vinegars submitted to an experimental static aging in wood were followed along 24 months. Eighteen volatile compounds were determined by GC-FID. The results were subjected to multivariate analyses: principal component analysis and linear discriminant analysis. The aroma profile of vinegar can be useful to discriminate vinegars produced from different substrates or with different aging times. During the experimental aging, volatile compounds such as methyl acetate, methanol, diacetyl, and gamma-butyrolactone underwent significant concentration increases. Moreover, the initial ethanol content of vinegars is a factor in the final aromatic richness. The formation of ethyl acetate stood out in samples with an initial ethanol content of approximately 2 alcoholic degrees.