Antioxidants,free radicals,storage proteins,and proteolytic activities in wheat (Triticum durum) seeds during accelerated aging

Accelerated aging was performed by incubation of wheat seeds at 40 degrees C and 100% relative humidity for 3, 4, 6, 10, and 14 days. The effects of the treatment on seed germinability and on several biochemical characteristics of flour (carotenoids, free radical and protein contents, and proteolytic activity) and gluten (free radical content and flexibility) were evaluated. A decrease of germinability was found during aging, the germination being completely inhibited after 14 days. The lutein content decreased gradually, without going to zero, while that of free radicals increased. A reduction of soluble proteins and a degradation of glutenins and gliadins were observed, associated with a substantial increase of protease activity and a decrease in gluten flexibility. The results were discussed in reference to those previously obtained by natural aging of wheat seeds of the same species and cultivar.     

Aging, free radicals, and antioxidants in wheat seeds

Free radical oxidative attack is considered a major cause of disruption and deteriorative changes observed in aged seeds. Antioxidant defense mechanisms may remove potentially damaging molecular species, and carotenoids may act as radical scavengers. The content of lutein, the major carotenoid in wheat seeds, was determined in the flours. It showed a rapid decrease during seed aging. In addition, the content of free radicals in glutens made from flours of wheat seeds after long-term storage was studied. The concentration of radicals appeared to be age dependent, because the highest content of radicals was detected between 13 and 15 years of aging over 36 years of storage. Specific spin labeling of the sulfhydryl groups of gluten proteins enabled comparative EPR studies of the rigidity of the protein chains. A progressive stiffening of polymeric gluten with seed storage was found.     

Phytochemical profile of main antioxidants in different fractions of purple and blue wheat, and black barley

Two pigmented wheat genotypes (blue and purple) and two black barley genotypes were fractionated in bran and flour fractions, examined, and compared for their free radical scavenging properties against 2,2'-azinobis(3-ethylbenzothiazoline-6-sulfonic acid) diammonium salt radical cation (Trolox equivalent antioxidant capacity, TEAC), ferric reducing antioxidant power (FRAP), total phenolic content (TPC), phenolic acid composition, carotenoid composition, and total anthocyanin content. The results showed that fractionation has a significant influence on the antioxidant properties, TPC, anthocyanin and carotenoid contents, and phenolic acid composition. Bran fractions had the greatest antioxidant activities (1.9-2.3 mmol TEAC/100 g) in all four grain genotypes and were 3-5-fold higher than the respective flour fractions (0.4-0.7 mmol TEAC/100 g). Ferulic acid was the predominant phenolic acid in wheat genotypes (bran fractions) while p-coumaric acid was the predominant phenolic acid in the bran fractions of barley genotypes. High-performance liquid chromatography analysis detected the presence of lutein and zeaxanthin in all fractions with different distribution patterns within the genotypes. The highest contents of anthocyanins were found in the middlings of black barley genotypes or in the shorts of blue and purple wheat. These data suggest the possibility to improve the antioxidant release from cereal-based food through selection of postharvest treatments.     

Degradation of HMW Glutenins During Wheat Sourdough Fermentations

Bakeries use sourdoughs to improve bread properties such as flavor and shelf life. The degradation of gluten proteins during fermentation may, however, crucially alter the gluten network formation. We observed changes that occurred in the HMW glutenins during wheat sourdough fermentations. As fermentation starters, we used either rye sourdough or pure cultures of lactobacilli and yeast. In addition, we incubated wheat flour (WF) in the presence of antibiotics under different pH conditions. The proteolytic activities of cereal and sourdough‐derived proteinases were studied with edestin and casein. During sourdough fermentations, most of the highly polymerized HMW glutenins degraded. A new area of alcohol‐soluble proteins (≈30.000 MW) appeared as a result of the proteolytic breakdown of gluten proteins. Very similar changes were observable as WF was incubated in the presence of antibiotics at pH 3.7. Cereal and sourdough‐derived proteinases hydrolyzed edestin at pH 3.5 but showed no activity at pH 5.5. An aspartic proteinase inhibitor (pepstatin A) arrested 88–100% of the activities of sourdough enzymes. According to these results, the most active proteinases in wheat sourdoughs were the cereal aspartic proteinases. Acidic conditions present in sourdoughs create an ideal environment for cereal aspartic proteinases to be active against gluten proteins.     

Potential of Triticale as a Substitute for Wheat in Flour Tortilla Production

The potential of triticale as a partial or total substitute for wheat in flour tortilla production was evaluated. Different mixtures of triticale and wheat flours were tested in a typical hot‐press formulation. Both grains yielded similar amounts of flour. Wheat flour contained 1.5% more crude protein, 1.6× more gluten, and produced stronger dough than triticale. Triticale flour significantly reduced optimum water absorption and mix time of blends. Flour tortillas with 100% triticale absorbed 8% less water and required 25% of the mix time of the control wheat flour tortilla. The yield of triticale tortillas was lower than the rest of the tortillas due to lower moisture content and water absorption. Triticale dough balls required less proofing and ruptured during hot pressing, thus producing defective tortillas. The 50:50 flour mixture produced doughs with acceptable rheological properties and good quality tortillas. Addition of 1% vital gluten to the 75:25 triticale‐wheat flour mix or 2% to the 100% triticale flour significantly increased water absorption and mix time and improved dough properties and tortilla yields. Textural studies indicated that increasing levels of triticale flour reduced the force required to rupture tortillas. For all tortilla systems, rupture force gradually increased, and extensibility decreased during seven days of storage at room temperature; the highest rate of change occurred during the first day. Sensory evaluation tests indicated that triticale could substitute for 50% of wheat flour without affecting texture, color, flavor, and overall acceptability of tortillas. For production of 100% triticale flour tortillas, at least 2% vital gluten had to be added to the formulation.     

Effects of Wheat Protein Fractions on Flour Tortilla Quality

Commercial wheat protein fractions (10) were evaluated during processing for quality of tortillas prepared using pastry, tortilla, and bread flours. Protein fractions that separately modify dough resistance and extensibility were evaluated in tortillas to determine whether the proteins could increase diameter, opacity, and shelf stability. Tortillas were prepared using laboratory‐scale, commercial equipment with fixed processing parameters. Dough and tortilla properties were evaluated using analytical methods, a texture analyzer, and subjective methods. Tortillas were stored in plastic bags at 22°C for up to 20 days. Adjustments in water absorption and level of reducing agent were made to normalize differences in functionality of 3% added proteins on dough properties. Tortilla weight, moisture, pH, opacity, and specific volume were not affected by added proteins, except for glutenin and vital wheat gluten treatments, which had decreased opacity in tortillas prepared from pastry flour. Increased insoluble polymeric protein content corresponded to decreased tortilla diameter and improved shelf stability. Treatments yielding tortillas with improved shelf stability and similar tortilla properties were produced when commercially processed vital wheat gluten products, FP600, FP6000, FP5000, or gliadin were added to pastry or tortilla flour. These wheat protein fractions improved processing and tortilla quality of wheat flours, especially pastry flour, by modifying protein content and quality.     

Effects of Transglutaminase Enzyme on Fundamental Rheological Properties of Sound and Bug‐Damaged Wheat Flour Doughs

Transglutaminase (TG) catalyzes the formation of nondisulfide covalent crosslinks between peptide‐bound glutaminyl residues and ∊‐amino groups of lysine residues in proteins. Crosslinks among wheat gluten proteins by TG are of particular interest because of their high glutamine content. Depolymerization of wheat gluten proteins by proteolytic enzymes associated with bug damage causes rapid deterioration of dough properties and bread quality. The aim of the present study was to investigate the possibility of using TG to regain gluten strength adversely affected by wheat bug proteases. A heavily bug‐damaged (Eurygaster spp.) wheat flour was blended with sound cv. Augusta or cv. Sharpshooter flours. Dynamic rheological measurements, involving a frequency sweep at a fixed shear stress, were performed after 0, 30, and 60 min of incubation on doughs made from sound or blended flour samples. The complex moduli (G* values) of Augusta and Sharpshooter doughs blended with 10% bug‐damaged flour decreased significantly after 30 min of incubation. These dough samples were extremely soft and sticky and impossible to handle for testing purposes after 60 min of incubation. To test the possibility of using TG to counteract the hydrolyzing effect of bug proteases on gluten proteins, TG was added to the flour blends. The G* values of TG‐treated sound Augusta or Sharpshooter doughs increased significantly after 60 min of incubation. The G* values of the Augusta or Sharpshooter doughs blended with bug‐damaged flour increased significantly rather than decreased after 30 and 60 min of incubation when TG was included in the dough formulation. This indicates that the TG enzyme substantially rebuilds structure of dough hydrolyzed by wheat bug protease enzymes.     

Textural Comparisons of Gluten‐Free and Wheat‐Based Doughs,Batters, and Breads

Studies were conducted with two newly developed gluten‐free bread recipes. One was based on corn starch (relative amount 54), brown rice (25), soya (12.5), and buckwheat flour (8.5), while the other contained brown rice flour (50), skim milk powder (37.5), whole egg (30), potato (25), and corn starch (12.5), and soya flour (12.5). The hydrocolloids used were xanthan gum (1.25) and xanthan (0.9) plus konjac gum (1.5), respectively. Wheat bread and gluten‐free bread made from commercial flour mix were included for comparison. Baking tests showed that wheat and the bread made from the commercial flour mix yielded significantly higher loaf volumes (P < 0.01). All the gluten‐free breads were brittle after two days of storage, detectable by the occurrence of fracture, and the decrease in springiness (P < 0.01), cohesiveness (P < 0.01), and resilience (P < 0.01) derived from texture profile analysis. However, these changes were generally less pronounced for the dairy‐based gluten‐free bread, indicating a better keeping quality. Confocal laser‐scanning microscopy showed that the dairy‐based gluten‐free bread crumb contained network‐like structures resembling the gluten network in wheat bread crumb. It was concluded that the formation of a continuous protein phase is critical for an improved keeping quality of gluten‐free bread.     

Influence of Starch and Gluten Characteristics on Rheological Properties of Wheat Flour Gel at Small and Large Deformation

Starch and gluten were isolated from 10 wheat cultivars or lines with varied amylose content. The rheological properties of 30% wheat flour gel, starch gel, and the gel of isolated gluten mixed with common starch were determined in dynamic mechanical testing under shear deformation, creep‐recovery, and compression tests under uniaxial compression. Variation of wheat samples measured as storage shear modulus (G′), loss shear modulus (G″), and loss tangent (tan δ = G″/G′) was similar between flour and starch gels and correlated significantly between flour and starch gel. The proportion of acetic acid soluble glutenin exhibited a significant relationship with tan δ of gluten‐starch mixture gel. The small difference in amylose content strongly affected the rheological parameters of flour gels in creep‐recovery measurement. Wheat flour gel with lower amylose content showed higher creep and recovery compliance that corresponded to the trend in starch gel. Compressive force of flour gel at 50 and 95% strain correlated significantly with that of starch gel. Gel mixed with the isolated gluten from waxy wheat lines appeared to have a weaker gel structure in dynamic viscoelasticity, creep‐recovery, and compression tests. Starch properties of were primarily responsible for rheological changes in wheat flour gel.     

Antioxidant contents and antioxidative properties of traditional rye breads

The purpose of this research was to find out the effect of flour extraction rate on the antioxidative properties of traditional rye bread and then to compare the bioactive compounds content and antioxidant properties of rye breads with commercial wheat roll. Four types of rye flour with different extraction rates of 100 (whole meal dark flour), 95 (brown flour), 90 (brown flour), and 70% (light flour) originated from Warko rye cultivar were used for traditional bread baking with sourdough fermentation. Four types of the respective rye breads were analyzed for their potentially beneficial components, including tocopherols and tocotrienols, total phenolics and flavonoids, reduced glutathione, and inositol hexaphosphates. Moreover, the phenolic acids profile was provided. The Trolox equivalent antioxidant capacity (TEAC) of the breads was evaluated using free radical scavenging activities of 80% methanol extracts against ABTS*+ radical cation (ABTS radical cation decolorization method) whereas radical scavenging activity (RSA) was determined against 2,2-diphenyl-1-picrylhydrazyl radical (DPPH*). The superoxide dismutase-like activity (SOD-like activity) was evaluated as free radical scavenging activities of PBS extracts against superoxide anion radicals (O2*-). The results were compared to whole meal rye bread as well as to wheat roll taken as representative example of wheat based bakery product. The studies showed that flour extraction rates strongly affected the content of bioactive compounds and antioxidative properties of traditionally baked rye breads. The incorporation of the rye flours with extraction rates from 100 down to 70% in the formulation caused decrease in tocopherol (T), tocotrienol (T3), inositol hexaphosphate (IP6), and phenolic compound (TPC) contents in rye breads. No changes in reduced glutathione (GSH) contents were noted between each type of rye bread. A significant decrease in Trolox equivalent antioxidant capacity and radical DDPH scavenging activity was also found in bread formulated on flour with an extraction rate of 70% in comparison to the breads formulated on flour with extraction rates from 100 to 90%. The highest SOD-like activity was noted for rye bread formulated on flour with an extraction rate of 70%. The four types of rye breads showed better antioxidative properties and higher antioxidant contents when compared to wheat roll with one exception made to tocopherols and tocotrienols.     

小麦粉面团形成过程水分状态及其比例变化

为揭示小麦粉面团形成过程水分状态和比例、面团结构的变化,以及这种变化与粉质仪和拉伸仪表征的质量特性之间的关系;认识面团形成过程表征筋力强弱的物质基础和变化机理。选用中筋(宁春4号)和强筋(师栾02-1)小麦品种为试验材料,利用低场核磁共振技术测定粉质仪和面过程、拉伸仪醒发拉伸过程不同时间点面团水分状态和比例的变化;利用红外显微成像技术分析面团形成过程不同取样点蛋白质和淀粉的分布及结构变化。结果表明,面粉原料中主要为弱结合水。面粉在粉质仪加水搅拌形成面团后,水分状态和比例发生显著变化,面团中的水可以分为强结合水(T_(21))、弱结合水(T_(22))和自由水(T_(23))。面团搅拌形成过程中,中筋小麦品种宁春4号面团中的强结合水比例显著降低;师栾02-1的强结合水的弛豫时间在和面终点消失,弱结合水的弛豫时间显著延长,而自由水的比例显著增加(P0.05)。强筋小麦粉强结合水的保持时间较长。拉伸过程加盐和不加盐对同一取样点、同一种水分状态之间的水分弛豫时间和比例无显著影响;宁春4号自由水的弛豫时间在加盐和不加盐处理时都显著缩短(P0.05)。湿面筋含量高、筋力较强面团的蛋白质网络结构致密。粉质仪和面过程强结合水和弱结合水弛豫时间和比例的变化,与面筋含量和强度有关。该结论可为面制品加工过程和面工艺选择与优化等方面提供一定的理论参考。     

不同工艺马铃薯粉物化特性及氨基酸组成比较

为明确马铃薯渣粉、以马铃薯渣为原料的马铃薯复配粉与马铃薯全粉、马铃薯冻干粉以及高筋小麦粉成分和性质的差异,本研究对其基本成分、物化及感官特性、氨基酸组成进行比较,并以FAO/WHO氨基酸模式为评价标准,采用模糊识别法、氨基酸比值系数评分法、氨基酸评分、必需氨基酸指数、生物价和营养指数多种方法对各样品蛋白的营养价值进行全面评价及对比。结果表明,在样品吸水性方面,马铃薯全粉马铃薯渣粉马铃薯复配粉马铃薯冻干粉高筋小麦粉;氨基酸比值系数最高为马铃薯复配粉(100.00),其次是马铃薯全粉(81.00)和马铃薯薯渣粉(72.25),马铃薯冻干粉和高筋小麦粉最低(68.89);必需氨基酸指数和生物价最高为马铃薯复配粉和马铃薯渣粉,其次为马铃薯冻干粉和马铃薯全粉,高筋小麦粉最低;营养指数从高到低依次为高筋小麦粉、马铃薯全粉、马铃薯冻干粉、马铃薯渣粉及马铃薯复配粉。马铃薯复配粉的成本低,吸水性、加工性能等优于马铃薯全粉,但营养指数暴露出马铃薯复配粉蛋白含量较低的缺陷,后续的加工过程中可以通过向马铃薯复配粉中添加营养价值较高且与马铃薯蛋白氨基酸组成互补的蛋白质,弥补马铃薯复配粉蛋白含量较低的缺陷,这为解决薯渣利用问题提供了新思路。     

Observations on the Quality Characteristics of Waxy (Amylose‐Free) Winter Wheats

Previous investigations have suggested waxy (amylose‐free) wheats (Triticum aestivum L.) possess weak gluten properties and may not be suitable for commercial gluten extraction. This limitation could prevent the use of waxy wheat as a source of unique starch, because gluten is a by‐product of the wheat starch purification process. Fifty waxy wheat lines were used to determine the extent to which gluten protein and other grain quality related traits might vary and, consequently, allow the development of waxy wheat with acceptable gluten properties. Among the waxy lines, significant variation was observed for all measured quality traits with the exception of flour protein concentration. No waxy entries statistically equaled the highest ranking nonwaxy entry for grain volume weight, falling number, flour yield, or mixograph mix time. No waxy lines numerically exceeded or equaled the mean of the nonwaxy controls for falling number, flour yield, or mixograph mix time. For grain and flour protein related variables, however, many waxy lines were identified well within the range of acceptability, relative to the nonwaxy controls used in this study. Approximately 50% of the waxy lines did not differ from the highest ranking nonwaxy cultivar for grain and flour protein concentrations. Forty‐three (86%) of the tested waxy lines were not sig‐nificantly different from the nonwaxy line with the highest mixograph mixing tolerance, 22/50 (44%) of the waxy wheat lines did not differ from the highest ranking nonwaxy line in gluten index scores, and 17/50 (34%) did not differ from the highest ranking nonwaxy line in extracted wet gluten. All waxy experimental lines produced gluten via Glutomatic washing. The quality of the gluten, as measured both by mixograph and gluten index, varied widely among the waxy lines tested. These observations suggest that weak gluten is not a natural consequence of the waxy trait, and waxy cultivars with acceptable gluten properties can be developed.     

Gluten Enhances Cooking,Textural, and Sensory Properties of Oat Noodles

Whole grain oats are widely regarded as conferring significant health benefits. Composite flour of whole grain oat flour, wheat flour, and tapioca starch in the ratio 1:1:0.16 was formulated to make oat noodles with the addition of gluten at various levels. The influence of gluten on pasting and gelling properties of composite flour, and on cooking, textural, and sensory properties of salted oat noodles was evaluated. Addition of gluten decreased the paste viscosity, reduced hardness and springiness of gel, reduced cooking yield, cooking loss, and broken ratio during cooking, and increased the tensile strength and firmness of cooked noodles. Scanning electron microscopy showed that gluten tightened the network of protein in the noodles by forming oriented fibrils. Addition of gluten had little effect on the color of raw and cooked oat noodles, which were somewhat yellow. Sensory evaluation indicated that addition of gluten could enhance the overall acceptability of cooked oat noodles. This study may stimulate further interest in using functional whole grain cereal ingredients in developing healthy staple foods.     

Comparison of Quality Characteristics and Breadmaking Functionality of Hard Red Winter and Hard Red Spring Wheat

Various whole‐kernel, milling, flour, dough, and breadmaking quality parameters were compared between hard red winter (HRW) and hard red spring (HRS) wheat. From the 50 quality parameters evaluated, values of only nine quality characteristics were found to be similar for both classes. These were test weight, grain moisture content, kernel size, polyphenol oxidase content, average gluten index, insoluble polymeric protein (%), free nonpolar lipids, loaf volume potential, and mixograph tolerance. Some of the quality characteristics that had significantly higher levels in HRS than in HRW wheat samples included grain protein content, grain hardness, most milling and flour quality measurements, most dough physicochemical properties, and most baking characteristics. When HRW and HRS wheat samples were grouped to be within the same wheat protein content range (11.4–15.8%), the average value of many grain and breadmaking quality characteristics were similar for both wheat classes but significant differences still existed. Values that were higher for HRW wheat flour were color b*, free polar lipids content, falling number, and farinograph tolerance. Values that were higher for HRS wheat flour were geometric mean diameter, quantity of insoluble polymeric proteins and gliadins, mixograph mix time, alveograph configuration ratio, dough weight, crumb grain score, and SDS sedimentation volume. This research showed that the grain and flour quality of HRS wheat generally exceeds that of HRW wheat whether or not samples are grouped to include a similar protein content range.     

Determination of Surface Tension Properties of Wheat Endosperms,Wheat Flours,and Wheat Glutens

During wheat dough processing, a large part of the interactions with water are governed by wettability properties of flour. The wettability properties of wheat materials (flat slices of wheat endosperm, flour‐based pellets, and gluten‐based pellets) were assessed by the measurement of contact angles of a sessile drop of three reference liquids (water, diiodomethane, and formamide) and estimated by equilibrium properties (contact angles and surface tension properties) and drop penetration rates. The surface tension (γ_s) of wheat materials was measured between 49.6 and 55.3 mJ/m^‐2. The present work permitted the evaluation of specific wheat types (hard wheat vs. soft wheat) and evaluation of the influence of material structure (flat slices of endosperm vs. flour‐based pellets), and material nature (flour‐based pellets vs. gluten‐based pellets) on the wettability properties. The surface tension properties were considered with regard to the nonideal structure of sample surfaces by considering surface roughness and material porosity.     

Wheat Gluten Polymer Structures: The Impact of Genotype,Environment, and Processing on Their Functionality in Various Applications

For a number of applications, gluten protein polymer structures are of the highest importance in determining end‐use properties. The present article focuses on gluten protein structures in the wheat grain, genotype‐ and environment‐related changes, protein structures in various applications, and their impact on quality. Protein structures in mature wheat grain or flour are strongly related to end‐use properties, although influenced by genetic and environment interactions. Nitrogen availability during wheat development and genetically determined plant development rhythm are the most important parameters determining the gluten protein polymer structure, although temperature during plant development interacts with the impact of the mentioned parameters. Glutenin subunits are the main proteins incorporated in the gluten protein polymer in extracted wheat flour. During dough mixing, gliadins are also incorporated through disulfide‐sulfhydryl exchange reactions. Gluten protein polymer size and complexity in the mature grain and changes during dough formation are important for breadmaking quality. When using the gluten proteins to produce plastics, additional proteins are incorporated in the polymer through disulfide‐sulfhydryl exchange, sulfhydryl oxidation, β‐eliminations with lanthionine formation, and isopeptide formation. In promising materials, the protein polymer structure is changed toward β‐sheet structures of both intermolecular and extended type and a hexagonal close‐packed structure is found. Increased understanding of gluten protein polymer structures is extremely important to improve functionality and end‐use quality of wheat‐ and gluten‐based products.     

Phenolic Content,Antioxidant Activity,and Consumer Acceptability of Sorghum Cookies

Cookies were produced from different sorghum flours to determine their potential as vectors of antioxidants. Different sorghum cultivars and their flour extraction rates were evaluated for their effects on phenolic content and antioxidant activity of the cookies. Consumer acceptance of the sorghum cookies was compared with that of wheat flour cookies. For each sorghum cultivar, cookies of 100% extraction rate flours had two to three times more total phenolics compared with those of 70% extraction rate flours, while antioxidant activity was 22–90% higher. Cookies of the condensed tannin sorghum had two to five times more phenolics compared with those of condensed tannin‐free sorghum. Antioxidant activity was 145–227 μMol Trolox equivalents (TE)/g in cookies of condensed tannin sorghum compared with 10–102 μMol TE/g in those of condensed tannin‐free sorghum. The sorghum flours had slightly higher phenolic content and antioxidant activity values than their corresponding cookies. Cookies of the red tannin‐free sorghum flours (PAN 8564/8446) were equally liked as wheat flour cookies, except for texture. However, cookies of condensed tannin sorghum were least accepted compared with wheat flour cookies despite their high antioxidant activity.     

Baking Quality of Bread Wheat Cultivars Damaged by Nysius simulans

Wheat grain may be attacked by different insect species. Among them, some Heteroptera species (e.g., Aelia spp. and Eurygaster spp.) reduce wheat breadmaking quality; others, such as Nysius simulans , commonly extract water and nutrients from soy plants. The aim of this study was to assess the effect of N. simulans infestation on breadmaking quality of different bread wheat cultivars. Twelve wheat cultivars (damaged and undamaged by N. simulans ) were studied. Infested grain percentage varied between 51 and 78%, depending on cultivar. Protein and gluten quantity and quality were significantly reduced in damaged flours, as shown by gluten index, solvent retention capacity, and SDS sedimentation index. SDS‐PAGE from water‐extractable proteins evidenced an important proteolytic activity in damaged samples. Dough rheological properties showed a reduced dough viscoelasticity in damaged samples. Microbread specific volume changed from 3.26 cm³/g for samples made with undamaged flour to 2.77 cm³/g for bread made with damaged flour. No evidence for modification in starch properties was found. The infestation by N. simulans reduced wheat breadmaking quality in all cultivars studied, as a result of proteolytic activity occurring after dough hydration. Results suggest that the presence of N. simulans should be considered as a factor affecting wheat crops, mainly those located next to soy crop areas, which is the usual host for this insect.     

Mixograph Responses of Gluten and Gluten‐Fortified Flour for Gluten Produced by Cold‐Ethanol or Water Displacement of Starch from Wheat Flour

The total protein of gluten obtained by the cold‐ethanol displacement of starch from developed wheat flour dough matches that made by water displacement, but functional properties revealed by mixing are altered. This report characterizes mixing properties in a 10‐g mixograph for cold‐ethanol‐processed wheat gluten concentrates (CE‐gluten) and those for the water‐process concentrates (W‐gluten). Gluten concentrates were produced at a laboratory scale using batter‐like technology: development with water as a batter, dispersion with the displacement fluid, and screening. The displacing fluid was water for W‐gluten and cold ethanol (≥70% vol, ‐12°C) for CE‐gluten. Both gluten types were freeze‐dried at ‐10°C and then milled. Mixograms were obtained for 1) straight gluten concentrates hydrated to absorptions of 123–234%, or 2) gluten blended with a low protein (9.2% protein) soft wheat flour to obtain up to 16.2% total protein. The mixograms for gluten or gluten‐fortified flour were qualitatively and quantitatively distinguishable. We found differences in the mixogram parameters that would lead to the conclusion of greater stability and strength for CE‐gluten than for W‐Gluten. Differences between the mixograms for these gluten types could be markedly exaggerated by increasing the amount of water to the 167–234% range. Mixograms for evaluation of gluten have not been previously reported in this hydration range. Mixograms for fortification suggest that less CE‐gluten than W‐gluten would be required for the same effect.