Intrinsic phytase in hybrid rye increases the digestibility of phosphorus in corn and soybean meal in diets fed to growing pigs

An experiment was conducted to test the hypothesis that inclusion of hybrid rye in diets containing corn and soybean meal (SBM) without or with microbial phytase improves the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P because of the intrinsic phytase activity in hybrid rye. Forty-eight growing barrows (initial body weight: 39.5 ± 7.7 kg) were allotted to six diets. A basal diet containing corn and SBM; a rye-based diet; and a diet containing corn, SBM, and rye were formulated. Each diet was formulated without and with microbial phytase (500 units/kg of diet) for a total of six diets. Fecal samples were collected for 4 d following a 5-d adaptation period according to the marker-to-marker procedure. Results indicated that no interactions between diets and concentration of phytase were observed for any of the response criteria measured. The ATTD and STTD of P and the ATTD of Ca differed (P < 0.05) among diets, but regardless of diet, the concentration of P in feces was reduced (P < 0.05) by adding microbial phytase to the diets. As a consequence, microbial phytase increased (P < 0.05) ATTD and STTD of P, and the ATTD of Ca was also increased (P < 0.05) by the use of microbial phytase. Measured values for the ATTD and STTD of P in the diets containing corn, SBM, and hybrid rye without or with phytase were greater (P < 0.05) than values that were predicted based on the ATTD and STTD of P for the corn–SBM and the hybrid rye diet. The observation that STTD predicted from the individual ingredients underestimated the STTD of P in the mixed diet indicates that the intrinsic phytase in hybrid rye resulted in increased digestibility of the P in the corn and SBM included in the corn–SBM–hybrid rye diet. In conclusion, microbial phytase increased the ATTD and STTD of P and the ATTD of Ca regardless of feed ingredients used in diets fed to pigs. In addition, the intrinsic phytase from hybrid rye increased the ATTD and STTD of P in corn and SBM.     

Comparison of digestible and metabolizable energy and digestible phosphorus and amino acid content of corn ethanol coproducts from Brazil and the United States produced using fiber separation technology for swine

Three experiments (exp.) were conducted to determine and compare the digestibility of nutrients and energy of corn distillers dried grains with solubles (DDGS) from the United States (USDDGS), a dried mixture of corn bran with solubles (CBS) from Brazil (BRCBS), and high protein corn distillers dried grains (HP-DDG) from the United States (USHPDG) and Brazil (BRHPDG) in growing pigs. The feed ingredients were evaluated for apparent total tract digestibility (ATTD) of gross energy (GE), dry matter (DM), crude protein (CP), ether extract, neutral and acid detergent fiber (NDF and ADF, respectively), and digestible and metabolizable energy (DE and ME, respectively) using the total collection and index methods in exp. 1; ATTD and standardized total tract digestibility (STTD) of phosphorus (P) in exp. 2; and apparent (AID) and standardized (SID) ileal digestibilities of CP and amino acids (AA) in exp. 3. Fifty crossbred barrows (32.4 ± 6.9, 38.3 ± 5.2, and 46.2 ± 5.3 kg body weight [BW], in exp. 1, 2, and 3, respectively) were fed a corn basal diet in exp. 1, a P-free diet in exp. 2, and an N-free diet in exp. 3 or diets with 40% inclusion of test ingredients to provide 10 replications per treatment. Pigs were housed individually in metabolism cages (exp. 1) or in pens (exp. 2 and 3) and fed at 2.8 times the maintenance DE requirement (110 kcal/kg BW^0.75) based on their BW at the beginning of each experiment. Except for ATTD of NDF, which tended (P = 0.058) to be greater by the index method compared with the total collection method, no difference between the total collection and index methods was observed for ATTD of remaining nutrients and DE. The ATTD of DM, GE, NDF, and DE content of BRHPDG were greater (P < 0.001) than USHPDG, BRCBS, and USDDGS. The AID of CP, Arg, His, Ile, Leu, Lys, Thr, and Val and the SID of His, Leu, Lys, and Val of BRHPDG were 8% to 36% greater (P < 0.05) than those from USHPDG. Except for Trp, all AID and SID AA values were greater (P < 0.05) in BRHPDG than in USHPDG. The ATTD of DM, GE, NDF, and ADF; DE and ME content; AID of CP, Arg, Ile, Leu, Phe, Thr, and Trp; and SID of CP, Arg, Phe, and Thr of USDDGS were 9% to 45% greater (P < 0.05) than those in BRCBS. The ATTD and the STTD of P in USHPDG and USDDGS were 26% to 42% greater (P < 0.05) compared with BRHPDG and BRCBS. In conclusion, BRHPDG had a greater digestibility of energy and most of the AA than USHPDG, while the BRCBS evaluated had lower nutritional value than the USDDGS source.     

Formulation of diets for pigs based on a ratio between digestible calcium and digestible phosphorus results in reduced excretion of calcium in urine without affecting retention of calcium and phosphorus compared with formulation based on values for total calcium

An experiment was conducted to test the hypothesis that formulating diets for pigs based on a ratio between standardized total tract digestible (STTD) Ca and STTD P instead of total Ca and STTD P does not decrease Ca retention, but increases P utilization. Forty barrows (59.4 ± 3.8 kg) were individually housed in metabolism crates and allotted to four corn-soybean meal-based diets in a randomized complete block design with two blocks and five pigs per diet in each block. Diets were formulated using a 2 × 2 factorial design with two diet formulation principles (total Ca or STTD Ca) and two inclusion levels of microbial phytase (0 or 500 units per kg of feed). Phytase was assumed to release 0.11% STTD P and 0.16% total Ca. Diets were formulated based on requirements for total Ca and STTD P or a ratio between STTD Ca and STTD P of 1.25:1. Diets were fed for 11 d and fecal and urine samples were collected from feed provided from day 6 to day 10. Interactions (P < 0.05) between diet formulation principle and phytase level were observed for Ca intake, Ca in feces, Ca absorbed, Ca retained, P digestibility, P absorbed, and P in urine. Phytase increased (P < 0.05) the digestibility of Ca in both total Ca and STTD Ca diets. Without phytase, Ca intake, Ca in feces, and Ca absorbed was greater (P < 0.05) from pigs fed total Ca diets than from pigs fed STTD Ca diets, but P absorbed, P digestibility, and P in urine was greater (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. However, in the presence of phytase, no differences between diet formulation principles were observed in these variables. Regardless of phytase, Ca in urine was lower (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. There were no differences in Ca retention between pigs fed STTD Ca diets and total Ca diets, but pigs fed total Ca diets retained less (P < 0.05) Ca if diets contained phytase. No differences in P retention were observed between diet formulation principles, but pigs fed non-phytase diets retained more (P < 0.05) P than pigs fed diets with phytase. In conclusion, because diets formulated based on STTD Ca contain less Ca than total Ca diets, pigs fed STTD Ca diets excreted less Ca in urine, but retention of Ca was not affected. Formulating non-phytase diets based on STTD Ca instead of total Ca increased P absorption, which confirms the detrimental effect of excess Ca on P digestibility. However, P retention was not improved if pigs were fed STTD Ca diets.     

Digestibility of phosphorus by growing pigs of fermented and conventional soybean meal without and with microbial phytase

An experiment was conducted to test the hypothesis that the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P in fermented soybean meal (FSBM) are greater than in conventional soybean meal (SBM-CV) when fed to growing pigs. Four diets were formulated to contain FSBM or SBM-CV and either 0 or 800 units/kg of microbial phytase. The only sources of P in these diets were FSBM and SBM-CV. A P-free diet to estimate basal endogenous losses of P was also formulated. Thirty barrows (initial BW: 14.0 ± 2.3 kg) were placed in metabolism cages and allotted to 5 diets in a randomized complete block design with 6 pigs per diet. Feces were collected for 5 d after a 5-d adaptation period. All samples of ingredients, diets, and feces were analyzed for P, and values for ATTD and STTD of P were calculated. Results indicated that the basal endogenous P losses were 187 mg/kg of DMI. As phytase was added to the diet, the ATTD and STTD of P increased (P < 0.01) from 60.9 to 67.5% and from 65.5 to 71.9%, respectively, in pigs fed FSMB. Likewise, addition of phytase to SBM-CV increased (P < 0.01) the ATTD and STTD of P from 41.6 to 66.2% and from 46.1 to 71.4%, respectively. The ATTD and STTD of P were greater (P < 0.01) in FSBM than in SBM-CV when no phytase was used, but that was not observed when phytase was added to the diet (soybean meal × phytase interaction, P < 0.01). In conclusion, the ATTD and STTD of P in FSBM was greater than SBM-CV when no microbial phytase was added, but when phytase was added to the diets, no differences between FSBM and SBM-CV were observed in the ATTD and STTD of P.     

Nutritional value of a new source of fermented soybean meal fed to growing pigs

Three experiments were conducted to test the hypothesis that the standardized ileal digestibility (SID) of amino acids (AA), concentrations of digestible energy (DE) and metabolizable energy (ME), and the standardized total tract digestibility (STTD) of P in a new source of fermented soybean meal (Fermex 200) are greater than in conventional soybean meal (SBM-CV). In experiment 1, 9 barrows (initial body weight: 9.17 ± 1.03 kg) were surgically fitted with a T-cannula in the distal ileum and allotted to a triplicated 3 × 3 Latin square design. A nitrogen-free diet and 2 diets that contained cornstarch and SBM-CV or Fermex 200 as the sole source of crude protein (CP), and AA were formulated. Results indicated that there were no difference between SBM-CV and Fermex 200 for SID of CP and AA. In experiment 2, 24 growing pigs (initial body weight: 14.19 ± 1.18 kg) were housed individually in metabolism crates. Pigs were allotted to a corn-based diet or 2 diets that contained corn and SBM-CV or corn and Fermex 200. Feces and urine samples were collected using the marker-to-marker approach with 5-d adaptation and 4-d collection periods. Results indicated that the concentration of DE and ME in Fermex 200 were not different from DE and ME in SBM-CV. In experiment 3, 40 barrows (initial body weight: 11.01 ± 1.38 kg) were allotted to 1 of 4 diets with 10 replicate pigs per diet. Four diets were formulated to contain Fermex 200 or SBM-CV and either 0 or 1,000 units/kg of microbial phytase. Pigs were housed individually in metabolism crates. Fecal samples were collected as explained for experiment 2. Results indicated that the STTD of P in Fermex 200 was greater (P < 0.01) than in SBM-CV, but the addition of microbial phytase to the diets increased the ATTD and STTD of P in SBM-CV, but not in Fermex 200 (interaction; P < 0.01). In conclusion, the SID of AA and concentrations of DE and ME in Fermex 200 were not different from values determined for SBM-CV, but the STTD of P was greater in Fermex 200 than in SBM-CV if microbial phytase was not added to the diet.     

Effect of phytase supplementation to a low- and a high-phytate diet for growing pigs on the digestibilities of crude protein, amino acids, and energy

Supplementation of microbial phytase usually improves the digestibility and utilization of phosphorus in feedstuffs of plant origin. The effect of phytase supplementation on the digestibilities of AA also has been examined, but the results have been inconsistent. This study was carried out to determine the effect of phytase (Natuphos) supplementation, at a rate of 2,000 phytase units/kg, to two basal diets on the apparent ileal digestibilities (AID) of GE, CP, and AA, and on the apparent total-tract digestibilities (ATTD) of CP and GE. The basal diets contained 18% CP and were formulated (as-fed basis) to contain either a low (0.22%) or high content (0.48%) of phytate P. The high-phytate diet contained 20% rice bran, which is a rich source of phytate and has low intrinsic phytase activity. Eight barrows (average initial BW = 40.6 kg), fitted with a simple T-cannula at the distal ileum, were fed the four diets according to a replicated 4 x 4 Latin square design. The pigs were fed twice daily at 0800 and 2000, equal amounts each meal, at a rate of 2.4 times the daily maintenance requirement for ME. Each experimental period comprised 14 d. Ileal digesta were collected from 0800 to 2000 on d 12, 13, and 14. Feces were collected from 0800 on d 8 until 0800 on d 12. Chromic oxide was used as the digestibility marker. The AID of GE, CP, and AA and the ATTD of CP and GE were less in the high- than in the low-phytate diet (P < 0.01). With the exception of glutamic acid, phytase supplementation did not affect (P > 0.10) the AID of CP and AA. There was no effect (P > 0.05) of phytase on the ATTD of CP and GE. These results show that if a response occurs to phytase supplementation, it is independent of the dietary phytate content.     

Formulating diets based on digestible calcium instead of total calcium does not affect growth performance or carcass characteristics,but microbial phytase ameliorates bone resorption caused by low calcium in diets fed to pigs from 11 to 130 kg

An experiment was conducted to test the hypothesis that the requirement for Ca expressed as a ratio between standardized total tract digestible (STTD) Ca and STTD P obtained in short-term experiments may be applied to pigs fed diets without or with microbial phytase from 11 to 130 kg. In a 5-phase program, 160 pigs (body weight: 11.2 ± 1.8 kg) were randomly allotted to 32 pens and 4 corn–soybean meal-based diets in a 2 × 2 factorial design with 2 diet formulation principles (total Ca or STTD Ca), and 2 phytase inclusion levels (0 or 500 units/kg of feed) assuming phytase released 0.11% STTD P and 0.16% total Ca. The STTD Ca:STTD P ratios were 1.40:1, 1.35:1, 1.25:1, 1.18:1, and 1.10:1 for phases 1 to 5, and STTD P was at the requirement. Weights of pigs and feed left in feeders were recorded at the end of each phase. At the conclusion of phase 1 (day 24), 1 pig per pen was euthanized and a blood sample and the right femur were collected. At the end of phases 2 to 5, a blood sample was collected from the same pig in each pen. At the conclusion of the experiment (day 126), the right femur of 1 pig per pen was collected and carcass characteristics from this pig were measured. No interactions were observed between diet formulation principle and phytase inclusion for growth performance in any phase and no differences among treatments were observed for overall growth performance. Plasma Ca and P and bone ash at the end of phase 1 were also not influenced by dietary treatments. However, on day 126, pigs fed nonphytase diets formulated based on total Ca had greater bone ash than pigs fed STTD Ca-based diets, but if phytase was used, no differences were observed between the 2 formulation principles (interaction P < 0.05). At the end of phases 2 and 3, pigs fed diets without phytase had greater (P < 0.05) plasma P than pigs fed diets with phytase, but no differences were observed at the end of phases 4 and 5. A negative quadratic effect (P < 0.05) of phase (2 to 5) on the concentration of plasma Ca was observed, whereas plasma P increased (quadratic; P < 0.05) from phases 2 to 5. However, there was no interaction or effect of diet formulation principle or phytase inclusion on any carcass characteristics measured. In conclusion, STTD Ca to STTD P ratios can be used in diet formulation for growing-finishing pigs without affecting growth performance or carcass characteristics and phytase inclusion ameliorates bone resorption caused by low dietary Ca and P.     

Effects of a novel bacterial phytase expressed in Aspergillus Oryzae on digestibility of calcium and phosphorus in diets fed to weanling or growing pigs

In 2 experiments, 48 weanling (initial BW: 13.5 ± 2.4 kg, Exp. 1) and 24 growing pigs (initial BW: 36.2 ± 4.0 kg, Exp. 2) were used to determine effects of a novel bacterial 6-phytase expressed in Aspergillus oryzae on the apparent total tract digestibility (ATTD) of phosphorus and calcium in corn-soybean meal diets fed to weanling and growing pigs. In Exp. 1 and 2, pigs were randomly allotted to 6 dietary treatments using a randomized complete block design and a balanced 2 period changeover design, respectively. In both experiments, 6 diets were formulated. The positive control diet was a corn-soybean meal diet with added inorganic phosphorus (Exp. 1: 0.42 and 0.86% standardized total tract digestible phosphorus and total calcium, respectively; Exp. 2: 0.32 and 0.79% standardized total tract digestible phosphorus and total calcium, respectively). A negative control diet and 4 diets with the novel phytase (Ronozyme HiPhos, DSM Nutritional Products Inc., Parsippany, NJ) added to the negative control diet at levels of 500, 1,000, 2,000, and 4,000 phytase units (FYT)/kg were also formulated. In Exp. 1, the ATTD of phosphorus was greater (P < 0.01) for the positive control diet (60.5%) than for the negative control diet (40.5%), but increased (linear and quadratic, P < 0.01) as phytase was added to the negative control diet (40.5% vs. 61.6%, 65.1%, 68.7%, and 68.0%). The breakpoint for the ATTD of phosphorus (68.4%) was reached at a phytase inclusion level of 1,016 FYT/kg. In Exp. 2, the ATTD of phosphorus was greater (P < 0.01) for the positive control diet (59.4%) than for the negative control diet (39.8%) and increased (linear and quadratic, P < 0.01) as phytase was added to the negative control diet (39.8% vs. 58.1%, 65.4%, 69.1%, and 72.8%). The breakpoint for the ATTD of phosphorus (69.1%) was reached at a phytase inclusion level of 801 FYT/kg. In conclusion, the novel bacterial 6-phytase improved the ATTD of phosphorus and calcium in both weanling and growing pigs. The optimum level of inclusion for this phytase is 800 to 1,000 FYT/kg of complete feed to maximize ATTD of phosphorus and calcium in weanling and growing pigs.     

The effect of short-term phytase supplementation on the apparent total tract digestibility of calcium and phosphorus and the reproductive performance of late gestation and lactating sows fed diets without mineral phosphorus

The objective of this study was to measure apparent total tract digestibility (ATTD) of Ca and P as well as reproductive performance in late gestation and lactating sows supplemented with a novel phytase and to compare the response to phytase supplementation between late gestation and lactating sows. A total of 45 late gestation sows and 45 lactating sows were used in experiments 1 and 2, respectively, in a completely randomized design. The sows were provided with a control diet or the control diet supplemented with 187.5 or 375 FYT phytase/kg feed for 10 days. The diets were prepared according to the formulas in use for production but without any inorganic P supplement. Titanium dioxide was included at 3 g/kg feed as an indigestible marker. Each dietary treatment was replicated with 15 sows individually housed in farrowing stalls. The sows were allowed to adapt to the experimental diets for 5 days before a 5-d fecal collection by grab sampling, and the performance of the sows and their litters were measured until weaning. The results showed that the ATTD of Ca increased linearly (P < 0.001), while the ATTD of P increased both linearly and quadratically (P < 0.01) with increasing supplementation of phytase in both late gestation and lactating sows. There was no significant effect of phytase on the ATTD of dry matter, crude protein, and gross energy, and the performance of the sows and their progenies. The phytase added at 187.5 and 375 FYT/kg feed released 0.07% and 0.10% digested P, respectively, in late gestation sows, which compared with 0.09% and 0.12% digested P in lactating sows. In conclusion, a novel phytase at 187.5–375 FYT/kg feed could release 0.07–0.12% digestible P for sows. It appeared that using the P digestibility values of feed ingredients listed by NRC to formulate a diet for sows might overestimate dietary P supply and a greater response to phytase supplementation could be expected in lactating sows than in late gestation sows.     

Effects of different defatted rice bran sources and processing technologies on nutrient digestibility in cannulated growing pigs

The objective of this study was to evaluate the effects of different defatted rice bran (DFRB) sources and processing technologies on nutrient digestibility in different intestinal segments of pigs. Nine barrows with T-cannula in the distal ileum were randomly allotted to nine different sources in which oil was pressed extracted for seven sources and was solvent extracted for two sources. The experiment contained 6 periods of 12 d, including 8 d for diet adaptation, 2 d for fecal collection, and 2 d for digesta collection. The apparent ileal digestibility (AID) of dry matter (DM), ash, total dietary fiber (TDF), insoluble dietary fiber (IDF), neutral detergent fiber (NDF), acid detergent fiber (ADF), and hemicellulose in different sources of DFRB was quite variable. There were no differences in the AID of dietary gross energy (GE), organic matter (OM), ether extract (EE), crude protein (CP), and soluble dietary fiber (SDF) between different sources of DFRB. There were no differences in the AID of dietary EE, TDF, IDF, and hemicellulose between different processing technologies. Pressed DFRBs have greater (P < 0.05) average AID of dietary GE, DM, ash, OM, CP, SDF, and NDF and lower (P < 0.01) ADF compared with solvent-extracted DFRBs. The apparent total tract digestibility (ATTD) of most of the dietary nutrients, except for the ATTD of dietary EE, SDF, and hemicellulose, significantly varied in different sources of DFRB (P < 0.05). In addition, pressed DFRB had greater (P < 0.05) ATTD of dietary SDF, NDF, ADF, and hemicellulose compared with solvent-extracted DFRB. The apparent hindgut digestibility (AHD) of dietary DM, SDF, NDF, and ADF significantly varied (P <0.05) in different sources of DFRB. Exception with DM, there are no differences in the AHD of nutrients digestibility between pressed DFRB and solvent-extracted DFRB. In conclusion, DFRB in different sources and processing technologies with different physicochemical properties had different effects on nutrient digestibility in the foregut and hindgut of pigs.     

Impact of four fiber-rich supplements on nutrient digestibility,colostrum production,and farrowing performance in sows

This study aimed to investigate the impact of dietary fiber (DF) sources on sow and litter performance, and apparent total tract digestibility (ATTD) of gross energy (GE) and nutrients. A total of 48 sows were stratified for body weight at mating and randomly assigned to one of four DF sources (mixed fiber [MF], palm kernel expellers [PKE], sugar beet pulp [SBP], or soy hulls [SH]) and fed the diet from mating until farrowing. Within DF treatments, sows were supplemented with one of two extra energy sources (glycerol or sugar dissolved in water), whereas a third group (control) received water from day 108 of gestation until farrowing. The number of total born, live-born, and stillborn pigs; birth time and birth weight of the pigs; farrowing duration; and farrowing assistance (FA) were recorded. Live-born pigs were weighed again at 12 and 24 h after birth to record weight gain, which was used to estimate intake and yield of colostrum. Blood samples were collected once daily from day −3 relative to farrowing until day 1 after farrowing in sows and once from selected pigs right after birth. Fecal samples were collected on day 114 of gestation and colostrum at 0, 12, 24, and 36 h after onset of farrowing. Intake of soluble and insoluble nonstarch polysaccharides (NSP) was greater for SBP (P < 0.001) and PKE (P < 0.001) supplemented sows, respectively, when compared with other groups. Farrowing duration and stillbirth rate were not affected by DF sources, but PKE and SH supplemented sows had greater FA than SBP and MF supplemented sows (P < 0.001). Extra energy supplement did not improve the farrowing performance. Concentration (P = 0.02) and output (P = 0.04) of dry matter in colostrum, and ATTD of GE (P < 0.001) and crude protein (CP; P < 0.001) were lower for PKE supplemented sows than in sows from the remaining groups. Intake of insoluble NSP correlated negatively with ATTD of GE (P < 0.001) and CP (P < 0.001). Concentrations of glucose (P < 0.001), lactate (P < 0.001), CO₂ (P < 0.001), and HCO₃ (P < 0.001) in sows blood were increased with time progress relative to farrowing. Newborn pigs from PKE supplemented sows had greater concentration of lactate (P = 0.02) and lower blood pH (P = 0.02) than the remaining treatments. In conclusion, PKE supplement reduced ATTD of GE and CP, and concentration and output of dry matter in colostrum but increased FA. Results of this experiment indicated that the use of PKE as a fiber source for late gestating sows should be avoided.     

The influence of xylanase on the fermentability,digestibility, and physicochemical properties of insoluble corn-based fiber along the gastrointestinal tract of growing pigs

In theory, supplementing xylanase in corn-based swine diets should improve nutrient and energy digestibility and fiber fermentability, but its efficacy is inconsistent. The experimental objective was to investigate the impact of xylanase on energy and nutrient digestibility, digesta viscosity, and fermentation when pigs are fed a diet high in insoluble fiber (>20% neutral detergent fiber; NDF) and given a 46-d dietary adaptation period. A total of 3 replicates of 20 growing gilts were blocked by initial body weight, individually housed, and assigned to 1 of 4 dietary treatments: a low-fiber control (LF) with 7.5% NDF, a 30% corn bran high-fiber control (HF; 21.9% NDF), HF + 100 mg xylanase/kg (HF + XY [Econase XT 25P; AB Vista, Marlborough, UK]) providing 16,000 birch xylan units/kg; and HF + 50 mg arabinoxylan-oligosaccharide (AXOS) product/kg (HF + AX [XOS 35A; Shandong Longlive Biotechnology, Shandong, China]) providing AXOS with 3–7 degrees of polymerization. Gilts were allowed ad libitum access to fed for 36-d. On d 36, pigs were housed in metabolism crates for a 10-d period, limit fed, and feces were collected. On d 46, pigs were euthanized and ileal, cecal, and colonic digesta were collected. Data were analyzed as a linear mixed model with block and replication as random effects, and treatment as a fixed effect. Compared with LF, HF reduced the apparent ileal digestibility (AID), apparent cecal digestibility (ACED), apparent colonic digestibility (ACOD), and apparent total tract digestibility (ATTD) of dry matter (DM), gross energy (GE), crude protein (CP), acid detergent fiber (ADF), NDF, and hemicellulose (P < 0.01). Relative to HF, HF + XY improved the AID of GE, CP, and NDF (P < 0.05), and improved the ACED, ACOD, and ATTD of DM, GE, CP, NDF, ADF, and hemicellulose (P < 0.05). Among treatments, pigs fed HF had increased hindgut DM disappearance (P = 0.031). Relative to HF, HF + XY improved cecal disappearance of DM (162 vs. 98 g; P = 0.008) and NDF (44 vs. 13 g; P < 0.01). Pigs fed xylanase had a greater proportion of acetate in cecal digesta and butyrate in colonic digesta among treatments (P < 0.05). Compared with LF, HF increased ileal, cecal, and colonic viscosity, but HF + XY decreased ileal viscosity compared with HF (P < 0.001). In conclusion, increased insoluble corn-based fiber decreases digestibility, reduces cecal fermentation, and increases digesta viscosity, but supplementing xylanase partially mitigated that effect.     

Effect of low-phytate barley or phytase supplementation to a barley-soybean meal diet on phosphorus retention and excretion by grower pigs

Two studies were conducted to determine the effect of diets containing low-phytate barley or supplemented with phytase on P balance and excretion in grower pigs. In Exp. 1, eight 32-kg barrows were assigned to a repeated, 4 x 4 Latin square design and fed 4 diets that contained 96% barley: normal-phytate hulled barley (HB), low-phytate hulled barley (LPHB), normal-phytate hull-less barley (HLB), and low-phytate hull-less barley (LPHLB). The barley cultivars contained 0.16, 0.05, 0.24, and 0.03% phytate, respectively. Inorganic P (iP) was added to the HB and HLB diets to meet the 1998 National Research Council recommendation of available P (aP, 0.23%), whereas LPHB and LPHLB contained sufficient aP. The diets were fed at 2.5 times the maintenance requirement for ME. The apparent total tract digestibilities (ATTD) of P did not differ between the hulled and hull-less barley diets, but P retention (%) and excretion were greater in pigs fed the hull-less barley diets (P < 0.05). The ATTD of P was greater and P excretion was 35% lower in pigs fed the low-phytate compared with the normal-phytate diets (P < 0.001). The amount of P retained (g/d) was greater (P < 0.001) in pigs fed low-phytate barley, reflecting an ATTD of P of 65 and 49% for low-phytate and normal-phytate barley, respectively (P < 0.001). In Exp. 2, eight 21-kg barrows were assigned to a repeated, 4 x 4 Latin square design and fed 4 diets based on barley and soybean meal (SBM): HB-SBM, HB-SBM + iP, HB-SBM + phytase, and LPHB-SBM. The HB-SBM and HB-SBM + phytase diets were deficient in aP, whereas the HB-SBM + iP and LPHB-SBM diets had adequate aP. The feeding regimen was similar to that of Exp. 1. Adding iP to the HB-SBM diet did not affect the ATTD but increased the amount of P retained (g/d) and excreted (P < 0.001). The ATTD and amount of P retained (g/d) did not differ among pigs fed the HB-SBM + iP, HB-SBM + phytase, and LPHB-SBM diets. However, pigs fed the HB-SBM + phytase and LPHB-SBM diets excreted 32 and 29% less P, respectively, than pigs fed the HB-SBM + iP diet (P < 0.05), confirming that low-phytate barley is as effective as supplemental phytase in improving P digestibility and utilization and decreasing P excretion in grower pigs.     

Nutrient digestibility of extruded canola meal in ileal-cannulated growing pigs and effects of its feeding on diet nutrient digestibility and growth performance in weaned pigs

Canola meal (CM) contains less crude protein (CP) and more fiber and anti-nutritional factors such as glucosinolates than soybean meal (SBM) and consequently has a lower nutrient digestibility. Therefore, processing strategies that may increase the feeding value of CM warrant study. In two experiments, the effects of extrusion of Brassica napus CM on apparent (AID) and standardized ileal digestibility (SID) of amino acids (AA), apparent total tract digestibility (ATTD) of gross energy (GE) in growing pigs, and growth performance and diet digestibility in weaned pigs were assessed. Solvent-extracted CM was extruded using a single-screw extruder at three screw speeds: 250 (CM-250), 350 (CM-350), or 450 (CM-450) rpm. In exp. 1, in a double 4 × 4 Latin square, eight ileal-cannulated barrows (initial body weight [BW], 68.1 kg) were fed corn starch-based diets containing 50% CM or extruded CM. The CM sample contained 43.2% CP, 33.2% total dietary fiber (TDF), and 8.9 µmol of total glucosinolates/g on a dry matter (DM) basis. Extrusion increased (P < 0.05) the AID of CP, reduced (P < 0.05) apparent hindgut fermentation of CP, and decreased (P < 0.05) predicted net energy (NE) value of diets. Extrusion increased diet AID and CM SID of most indispensable AA by 3.1 to 5.3%-units. In exp. 2, 200 weaned pigs (initial BW, 8.3 kg) were fed diets containing 20% SBM, CM, or extruded CM starting 2 wk postweaning for 3 wk. The CM sample contained 42.7% CP, 28.3% TDF, and 5.3 µmol total glucosinolates/g DM. Wheat-based diets provided 2.3 Mcal NE/kg and 5.1 g SID Lys/Mcal NE. Dietary inclusion of extruded CM replacing SBM decreased (P < 0.05) diet ATTD of DM, GE and CP, and DE value. Average daily feed intake, average daily gain (ADG), and gain:feed (G:F) of pigs did not differ between extruded CM and SBM diets and were not affected by extrusion, but increasing extruder screw speed linearly increased (P < 0.05) ADG for day 1 to 7 and G:F for the entire trial. In conclusion, extrusion increased diet AID and CM SID of AA but not DE and predicted NE values of CM. However, increasing extruder speed did not further increase the SID of most of the AA of CM in growing pigs. Dietary inclusion of 20% CM or extruded CM did not affect the growth performance in weaned pigs.     

Prediction of in vivo apparent total tract energy digestibility of barley in grower pigs using an in vitro digestibility technique

The DE content within cereal grains can vary 25% mainly due to changes in apparent total tract digestibility (ATTD) of energy. In vitro digestibility techniques have been developed to predict the DE value among feedstuffs. However, these techniques have not been tested properly for their suitability to predict the variation in energy digestibility and DE content within a cereal grain. The objective of the present study was to establish and evaluate an in vitro digestibility technique to predict in vivo ATTD of energy of barley in grower pigs. Barley grain samples (hulled, n = 21) with a large range in quality were collected; the ADF and CP content ranged from 4.5 to 11.4% and 10.0 to 16.4% (DM basis), respectively. The ATTD of energy was determined using barrows (n = 63, 33 +/- 2.1 kg of initial BW) in 2 periods with 6 observations per sample and ranged from 51.9 to 78.5%, with relative errors between 0.4 and 5.0%. A preliminary study, comparing a 2- and a 3-step in vitro digestibility technique using 3 barley samples, indicated that R(2) between in vivo and in vitro energy digestibility was greater using the 3- than the 2-step technique (0.92 vs. 0.76). Therefore, the 3-step in vitro digestibility technique was used solely in subsequent analyses. Briefly, ground barley was subsequently incubated with pepsin for 6 h, pancreatin for 18 h, and cellulase for 24 h. The DM and GE content of samples and residues were measured to calculate digestibility. The in vitro energy digestibility of the 21 barley samples with duplicate measurements ranged from 63.7 to 82.2%, with relative errors between 0.1 and 2.6%. In vitro energy digestibility was strongly related (y = 1.25 x - 25.22; R(2) = 0.81) to in vivo energy digestibility. Finally, a subset of 7 barley samples was analyzed in quadruplicate using the 3-step in vitro technique. The relationship between in vitro and in vivo energy digestibility was very strong (y = 1.23 x - 25.33; R(2) = 0.97) with relative errors between 0.5 and 2.7%. In vitro DE and energy digestibility were perfectly related (R(2) = 1.00). In summary, the 3-step in vitro energy digestibility technique can accurately predict the ATTD of energy in barley in grower pigs. The 3-step in vitro digestibility technique, thus, might be useful as the reference laboratory procedure to calibrate analytical equipment to rapidly predict the ATTD of energy in barley.     

Energy concentration and phosphorus digestibility in whey powder, whey permeate, and low-ash whey permeate fed to weanling pigs

Two experiments were conducted to determine DE and ME, the apparent total tract digestibility (ATTD) of P, and the standardized total tract digestibility (STTD) of P in whey powder (3,646 kcal/kg), whey permeate (3,426 kcal/kg), and low-ash whey permeate (3,657 kcal/kg) fed to weanling pigs. The DE and ME in the 3 whey products were determined using 32 barrows (9.2 ± 0.4 kg of BW). A basal diet based on corn, soybean meal, and fish meal and 3 diets containing 70% of the basal diet and 30% of each whey product were prepared. Each diet was fed to 8 pigs that were housed individually in metabolism cages. The total collection method was used for fecal and urine collections with 5-d adaptation and 5-d collection periods, and the difference procedure was used to calculate DE and ME in the 3 whey products. The concentrations of DE in whey powder and low-ash whey permeate were greater (P < 0.001) than in whey permeate (3,646 and 3,683 vs. 3,253 kcal/kg of DM). The concentrations of ME in whey powder and low-ash whey permeate were also greater (P < 0.001) than in whey permeate (3,462 and 3,593 vs. 3,081 kcal/kg of DM). The ATTD and STTD of P in the 3 whey products were determined using 32 barrows (11.0 ± 0.81 kg of BW). Three cornstarch-sucrose-based diets containing 30% of each whey product as the sole source of P were prepared. A P-free diet that was used to estimate the basal endogenous losses of P was also formulated. The ATTD of P in whey powder and in whey permeate was greater (P < 0.001) than in low-ash whey permeate (84.3 and 86.1 vs. 55.9%), but the STTD values for P were not different among the 3 ingredients (91.2, 93.1, and 91.8% in whey powder, whey permeate, and low-ash whey permeate, respectively). In conclusion, whey permeate contains less GE, DE, and ME than whey powder and low-ash whey permeate, but all 3 ingredients have an excellent digestibility of P.     

Influence of a novel consensus bacterial 6-phytase variant on mineral digestibility and bone ash in young growing pigs fed diets with different concentrations of phytate-bound phosphorus

A 20-d experiment was conducted to test the hypothesis that phytase increases nutrient digestibility, bone ash, and growth performance of pigs fed diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. Within each level of phytate, five diets were formulated to contain 0, 500, 1,000, 2,000, or 4,000 phytase units (FTU)/kg of a novel phytase (PhyG). Three reference diets were formulated by adding a commercial Buttiauxella phytase (PhyB) at 1,000 FTU/kg to diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. A randomized complete block design with 144 individually housed pigs (12.70 ± 4.01 kg), 18 diets, and 8 replicate pigs per diet was used. Pigs were adapted to diets for 15 d followed by 4 d of fecal collection. Femurs were collected on the last day of the experiment. Results indicated that diets containing 0.35% phytate-bound P had reduced (P < 0.01) digestibility of Ca, P, Mg, and K compared with diets containing less phytate-bound P. Due to increased concentration of total P in diets with high phytate, apparent total tract digestible P and bone ash were increased by PhyG to a greater extent in diets with 0.29% or 0.35% phytate-bound P than in diets with 0.23% phytate-bound P (interaction, P < 0.05). At 1,000 FTU/kg, PhyG increased P digestibility and bone P more (P < 0.05) than PhyB. The PhyG increased (P < 0.01) pig growth performance, and pigs fed diets containing 0.35% or 0.29% phytate-bound P performed better (P < 0.01) than pigs fed the 0.23% phytate-bound P diets. In conclusion, the novel phytase (i.e., PhyG) is effective in increasing bone ash, mineral digestibility, and growth performance of pigs regardless of dietary phytate level.     

Acid-insoluble ash is a better indigestible marker than chromic oxide to measure apparent total tract digestibility in pigs

The aim of this study was to determine the apparent total tract digestibility (ATTD) of nutrients in cottonseed meal (CSM) and soybean meal (SBM) in simple carbohydrate and more complex wheat-based diets using 2 indigestible markers and total faecal collection. Twenty-five Large White × Landrace boars (57.8 kg) were randomly allocated to either a pure wheat diet, 40% CSM or SBM in either a sugar-starch- (1:1) or wheat-based diet for 18 d. Acid-insoluble ash (AIA) and chromic oxide (Cr₂O₃) were included in all diets as indigestible markers. Diets were offered (1,800 g/d per pig) in 3 meals/d from d 1 to 11 and 8 meals/d from d 12 to 17. On d 9, the pigs were moved to individual metabolism cages to allow total faecal collection. On d 18, the pigs were fed hourly for 8 h. After the 8th meal, pigs were anaesthetized and digesta sampled from the terminal ileum and rectum before lethal injection. There were no differences between ATTD of nitrogen (N) determined using AIA as a marker and measured by total faecal collection. On the other hand, the ATTD of N of diets containing CSM in sugar-starch- or wheat-based diets and the pure wheat diet determined using Cr₂O₃ as a marker was less (−3.11%, −4.46% and −6.59%; P < 0.001) than that measured by total faecal collection. The ATTD of N determined using AIA as a marker was highly correlated with that measured using total faecal collection (P < 0.001; R² = 0.95). Similarly, the ATTD of N determined using Cr₂O₃ as a marker was correlated with that measured using total faecal collection, although the correlation was not quite as strong as using AIA (P < 0.001; R² = 0.87). Also, the slope of the regression line and the intercept were closer to unity and zero for the relationship when the ATTD of N was determined using AIA compared to Cr₂O₃ as an indigestible marker. The ATTD of organic and dry matter behaved similarly. These data demonstrate that the basal diet and choice of indigestible marker can substantially influence the ATTD and that the use of AIA as an indigestible marker is more suitable than Cr₂O₃ in digestibility studies in pigs.     

Processing index of barley grain and dietary undigested neutral detergent fiber concentration affected chewing behavior,ruminal pH,and total tract nutrient digestibility of heifers fed a high-grain diet

The objective of this study was to investigate the effects of processing index (PI) of barley grain and dietary undigested neutral detergent fiber (uNDF) concentration on dry matter (DM) intake, chewing activity, ruminal pH and fermentation characteristics, total tract digestibility, gastrointestinal barrier function, and blood metabolites of finishing beef heifers. The PI was measured as the density after processing expressed as a percentage of the density before processing, and a smaller PI equates to a more extensively processed. Six ruminally cannulated heifers (average body weight, 715 ± 29 kg) were used in a 6 × 6 Latin square design with three PI (65%, 75%, and 85%) × 2 uNDF concentration (low and high; 4.6% vs. 5.6% of DM) factorial arrangement. The heifers were fed ad libitum a total mixed ration consisting of 10% barley silage (low uNDF), or 5% silage and 5% straw (high uNDF), 87% dry-rolled barley grain, and 3% mineral and vitamin supplements. Interactions (P < 0.01) of PI × uNDF were observed for DM intake, ruminating and total chewing time, and DM digestibility in the total digestive tract. Intake of DM, organic matter (OM), starch, and crude protein (CP) did not differ (P > 0.14) between low and high uNDF diets, but intakes of NDF and acid detergent fiber were greater (P = 0.01) for high uNDF diets regardless of barley PI. Heifers fed high uNDF diets had longer (P = 0.05) eating times (min/d or min/kg DM) and tended (P = 0.10) to have longer total chewing times (min/kg DM) than those fed low uNDF diets. Additionally, heifers sorted (P = 0.01) against long particles (>19 mm) for high uNDF diets but not for low uNDF diets. Altering PI of barley grain did not affect (P > 0.12) total volatile fatty acid (VFA) concentration, molar percentages of individual VFA, or duration of ruminal pH < 5.8 and <5.6. Total VFA concentration was less (P = 0.01), acetate percentage was greater (P = 0.01), and duration of ruminal pH < 5.8 and <5.6 was less (P = 0.05) for high compared with low uNDF diets. Digestibility of DM, OM, and CP was greater (P = 0.02) for low vs. high uNDF diets with PI of 65% and 75%, with no difference between low and high uNDF diets at PI of 85%. Blood metabolites and gastrointestinal tract barrier function were not affected (P ≥ 0.10) by the treatments. These results suggest that increasing dietary uNDF concentration is an effective strategy to improve ruminal pH status in finishing cattle, regardless of the extent of grain processing, whereas manipulating the extent of barley processing did not reduce the risk of ruminal acidosis.     

Impact of combined α-galactosidase and xylanase enzymes on growth performance,nutrients digestibility,chyme viscosity,and enzymes activity of broilers fed corn–soybean diets

Two experiments were conducted to investigate the effects of a combined α-galactosidase and xylanase preparation on nutrients digestibility and growth performance in broiler chickens. Experiment 1 had 240 broilers allocated to 3 treatments with the dietary supplementation of 0, 300, and 500 g/t of the enzyme combination. Diet and amino acid (AA) digestibility were assessed. Experiment 2 was a 2 × 3 (enzyme × diet) factorial arrangement with 10 replicates of 12 male broilers per replicate. Diets were based on corn–soybean meal (SBM) diet and had 3 nutritional levels (normal, 2% apparent metabolizable energy (AME) and crude protein (CP) reduction, and 4% AME and CP reduction). Each of these diets was fed with or without enzyme supplementation. Growth performance, chyme viscosity, nutrients digestibility, and endogenous enzymes activity were assessed. In experiment 1, enzyme supplementation improved the digestibility of Ca (P = 0.025) and ileal digestibility of total AA, Pro, Alu, Ile, Lys, His, Thr, Glu, Val, Leu, Tyr, and Phe (P < 0.05), and also tended to increase the AME of diets (P < 0.10). In experiment 2, broilers fed the corn–SBM diet with 4% nutrient reduction had better growth performance (P < 0.05), jejunal digesta viscosity at 42 d (P < 0.01), and lower digestibility of gross energy (GE; P < 0.05) when compared with those fed the normal nutrient diet. Enzyme inclusion increased digestibility of CP (P = 0.044), GE (P = 0.009), raffinose (P < 0.001) and stachyose (P < 0.001), improved average daily gain (P = 0.031), and reduced jejunal digesta viscosity at 42 d (P = 0.011). Besides, similar improvements trend in amylase, trypsin, sucrase, and maltase activity with enzyme inclusion were observed as with energy. These data support that the enzyme supplementation increased nutrients and ileal AA digestibility, improved performance and endogenous enzymes activity.