Replacing maize with pearl millet in laying hens’ diets

Pearl millet grain could be considered as an alternative feed ingredient for poultry. In a 12 wks experiment, the performance of laying hens fed diets containing pearl millet were compared with those fed diets containing corn. Maize grain was replaced by pearl millet on an equal-weight at either 0, 25, 50, 75 or 100%. Results showed that use of 25, 50 and 75% of pearl millet in place of maize in the diet resulted in similar (P > 0.05) hen-day egg production, egg mass, egg weight, feed intake and feed conversion ratio to those of control group. Totally replacement of maize grain with pearl millet significantly (P < 0.05) reduced all production parameters. Egg quality parameters did not affect by using pearl millet in the diet. These results showed that maize grain can be replaced by pearl millet up to 75% in the diets of laying hens without any adverse effect on hen performance or egg quality.     

Using locally produced millet as a feed ingredient for poultry production in Sub-Saharan Africa

Using locally produced feedstuffs for poultry production in developing countries can greatly lower production costs. Pearl millet is a drought-resistant plant that produces a nutritious grain. Its cultivation in Mali spans thousands of years, but the suitability of the millet grain currently produced in Mali for poultry production is unknown. Therefore, the nutrient composition of 7 different, widely available varieties of pearl millet grown in Mali was assessed before completing experiments in which laying hens or broilers were fed diets containing 0, 14, 28, or 43% whole pearl millet. The 7 varieties of pearl millet grown in different regions of Mali all had protein concentrations that were better than corn and had apparent digestible amino acid coefficients similar to corn. The nitrogen-corrected true metabolizable energy values ranged from 3,395 to 3,738 Kcal/kg on an as-is basis. Egg production and egg weight did not differ between the hens fed the different levels of millet through out a 16-wk experiment. Broilers fed the highest level of pearl millet from 1 to 42 d of age gained less (3.088 versus 2.949 kg) body weight than those fed the control diet. However, body weight gains did not differ between the broilers fed the control diet and the diets containing 14 or 28% whole millet. The results indicate that Malian-grown pearl millet would be an effective feed ingredient for poultry production and that this small seed could be added in whole form into laying hen and broiler diets.     

Effects of an experimental phytase on performance, egg quality, tibia ash content and phosphorus bioavailability in laying hens fed on maize- or barley-based diets

A 24-week performance trial was conducted to evaluate the efficacy of an experimental phytase on performance, egg quality, tibia ash content and phosphorus excretion in laying hens fed on either a maize- or a barley-based diet. At the end of the trial, an ileal absorption assay was conducted in order to determine the influence of phytase supplementation on the apparent absorption of calcium and total phosphorus (P). Each experimental diet was formulated either as a positive control containing 3.2 g/kg non-phytate phosphorus (NPP), with the addition of dicalcium phosphate (DCP), or as a low P one, without DCP addition. Both low P diets (containing 1.3 or 1.1 g/kg NPP) were supplemented with microbial phytase at 0, 150, 300 and 450 U/kg. The birds were housed in cages, allocating two hens per cage as the experimental unit. Each of 10 dietary treatments was assigned to 16 replicates. Low dietary NPP (below 1.3 g/kg) was not able to support optimum performance of hens during the laying cycle (from 22 to 46 weeks of age), either in maize or barley diets. Rate of lay, daily egg mass output, feed consumption, tibia ash percentage and weight gain were reduced in hens fed low NPP diets. The adverse effects of a low P diet were more severe in hens on a maize diet than in those on a barley diet. Low dietary NPP reduced egg production, weight gain, feed consumption and tibia ash content and microbial phytase supplementation improved these parameters. Hens given low NPP diets supplemented with phytase performed as well as the hens on positive control diets containing 3.2 g/kg of NPP. A 49% reduction of excreta P content was achieved by feeding hens on low NPP diets supplemented with phytase, without compromising performance. Phytase addition to low NPP diets increased total phosphorus absorption at the ileal level, from 0.25 to 0.51 in the maize diet and from 0.34 to 0.58 in the barley diet. Phosphorus absorption increased linearly with increasing levels of dietary phytase. Mean phosphorus absorption was higher in barley diets than in maize diets (0.49 vs 0.39).     

Effect of enzyme preparation containing xylanase and beta-glucanase on performance of laying hens fed wheat/barley- or maize/soybean meal-based diets

1. A commercial enzyme preparation (Quatrazyme HP) containing xylanase and beta-glucanase was examined in two laying hen experiments with wheat/barley- or maize-based diets. The activities of other enzymes were measured also. Starch, cell wall contents and effects of Quatrazyme HP on in vitro viscosity of wheat, barley, maize and soybean meal were determined. 2. In the first experiment, 90 ISA Brown laying hens at 28 weeks of age were given a wheat/barley basal diet with or without 20mg of Quatrazyme HP, which provided 560 and 2,800 IU of xylanase and beta-glucanase/kg diet. In the second experiment, 66 ISA Brown laying hens at 45 weeks of age were given a maize/soybean meal basal diet with or without 20 mg of Quatrazyme HP/kg diet for 9 weeks. Egg production, egg weight, egg mass, feed conversion ratio and change in body weight were recorded as response criteria. 3. There was a significant improvement in feed conversion ratio with enzyme supplementation. Birds given an enzyme-supplemented diet gained 86 g while those fed on the unsupplemented diet lost 103 g of their body weight by the end of the experiment. 4. The enzyme preparation did not affect either egg production, egg weight or egg mass of birds fed on the maize/soybean meal diet. However, a significant improvement in feed conversion ratio was detected. Birds on either the supplemented or unsupplemented diet exhibited an increase in their body weight at the end of the experiment. 5. Addition of xylanase and beta-glucanase decreased in vitro viscosity of wheat, barley, maize and soybean meal. This effect was greater for wheat and barley than for maize and soybean meal. 6. It was concluded that the beneficial effect of using an enzyme preparation containing xylanase and beta-glucanase is not limited to wheat/barley-based diets but also occurs with maize/soybean meal-based diets.     

日粮中添加辣诺素对海兰褐蛋鸡产蛋性能和蛋品质的影响

本试验旨在研究日粮中添加辣诺素（辣木和诺丽果的提取物）对蛋鸡生产性能及蛋品质的影响。将产蛋高峰期（22周龄）的海兰褐商品蛋鸡540只随机分为6个处理,每个处理6个重复,每个重复15只鸡。负对照组（NC）饲喂基础日粮,正对照组（PC）饲喂添加50 mg/kg杆菌肽锌的基础日粮,4个试验组分别饲喂添加0.25、0.50、0.75和1.00 g/kg辣诺素（LNS）的基础日粮。试验期24周。结果显示：①日粮处理对蛋鸡试验前期和后期生产性能均无显著影响（P>0.05）,试验后期添加0.50和0.75 g/kg辣诺素有改善料蛋比的趋势（P=0.087）;日粮处理对试验前期和后期鸡蛋蛋形指数、蛋壳强度、蛋壳厚度、蛋黄重和哈氏单位均无显著影响（P>0.05）,但日粮中添加杆菌肽锌和辣诺素有提高蛋壳强度的趋势（P=0.062）,其中以添加0.75g/kg辣诺素组鸡蛋强度最高。②与正、负对照组相比,添加辣诺素显著增加了生蛋黄和熟蛋黄的罗氏蛋黄色比率（P<0.05）,显著降低了蛋黄胆固醇的含量（0.25 LNS组除外）（P<0.05）。③与负对照组相比,添加0.50 g/kg辣诺素显著提高了鸡蛋总黄酮、二十二碳六烯酸（DHA）、卵磷脂、亚麻酸和亚油酸含量（P<0.05）。综合以上试验结果,辣诺素作为饲料添加剂具有提高鸡蛋营养品质的功能,考虑到添加成本,产蛋鸡日粮中添加0.25~0.50 g/kg为宜。     

Effects of Microbial Phytase Supplementation on Egg Production and Egg Quality in Hy-line Brown Hens During the Late Laying Period

The objective of this study was to evaluate the effects of microbial phytase on egg production and egg quality in older hens. A total of 216, 63-week-old Hy-line brown laying hens were distributed in a randomized complete design 10-week feeding trial of 3 dietary treatments with 12 replications per treatment and 6 hens per replication. The 3 dietary treatments were corn-soybean meal-based diets supplemented with 0% (CON), 0.06% (TRT1), and 0.12% (TRT2) microbial phytase. Significantly higher hen-day egg production was observed in the TRT1 treatment compared to CON (P<0.05), except during the first two weeks of the experiment. During weeks 3, 4, and 9, TRT2 had a greater hen-day egg production percentage than CON (P<0.05). The damaged egg ratio was not affected. The egg quality parameters (e.g., eggshell color, eggshell strength, albumen height, egg weight, and the Haugh unit) were affected by microbial phytase supplementation (P<0.05). However, there were no significant effects on the eggshell thickness and yolk color. In conclusion, microbial phytase supplementation to the diets of older hens could improve production performance, extend the peak laying period, and alter the egg quality parameters.     

The effects of dietary fat and bird age on the weights of eggs and egg components in the laying hen

1. A low-fat diet or an isoenergetic and isonitrogenous high-fat diet containing 55 g maize oil/kg were fed to laying hens at different stages during the laying year in two experiments. 2. Feeding the high-fat diet to young hens resulted in a rapid increase of 2.5 g in egg weight, made up of increases in both yolk and albumen weights. 3. Switching the diets at 50 weeks caused changes in egg weight that were accounted for entirely by changes in egg albumen weight. 4. Feeding the high-fat diet from 46 weeks in a second experiment increased egg and egg albumen weights by 1.26 and 1.34 g respectively. 5. The increase in egg weight with age was associated with a greater increase in the proportion of yolk, at the expense of albumen, compared to egg weight increases related to dietary fat. 6. It is concluded that dietary fatty acids increase egg weight by a mechanism different from that causing age-related increases in weight and that the mechanism involves a stimulation of oviduct protein synthesis.     

Effect of sweet green pepper on yolk color and performance of laying hens

An experiment was conducted to evaluate the effects of sweet green pepper (SGP) on the performance and egg quality of commercial laying hens. A total of 144 Hy Line W36 egg layers were randomly assigned to 4 treatments with 9 replicate groups of 4 hens each. Treatments consisted of the following diets: 1) basal diet (BD), 2) BD + 75 ppm SGP, 3) BD + 125 ppm SGP, 4) BD + 225 ppm SGP. The diets contained 2,730 kcal/kg metabolizable energy and 15.5% crude protein. Egg production and egg quality were monitored for 16 weeks. Feed intake, hen-day egg production, egg mass, and feed conversion per dozen were not significantly affected by the addition of SGP to the diets. The addition of 225 ppm of SGP decreased egg weight. Specific gravity, albumen height, Haugh unit, yolk weight, albumen weight, albumen percentage, and yolk yellowness (b*) were not significantly affected by the addition of SGP. The addition of SGP to the diets increased yolk percentage, yolk color using a Roche fan, and yolk redness (a*). Based on these data, SGP was shown to be a useful feed ingredient for laying hens; it can be included in diets without negative effects on performance and egg quality. However, owing to the depression of egg weight with the inclusion of SGP, it may be of interest to producers and industry to control egg size in old layers and possibly improve shell quality. The addition of SGP to the diets impacted yolk color and may be useful in specialty markets.     

Effect of high moisture storage of pearl millet (Pennisetum typhoides) with or without feed enzymes on growth and nutrient utilization in broiler chickens

Effect of reconstitution of pearl millet with or without enzymes on its utilization in broiler chickens was studied. The pearl millet grains were reconstituted by adding water to raise the moisture level to 30%, followed by storage in sealed plastic buckets with or without feed enzymes (0.5 g/kg) for 21 days at room temperature (25°C). Subsequently, the grains were sun-dried to reduce the moisture content up to 10% to avoid mould growth. Nine dietary treatments were formulated incorporating pearl millet either raw with or without enzymes or reconstituted with or without enzymes in maize-soya based control diet replacing maize at 50 and 75% levels. The birds fed on diets containing enzyme reconstituted pearl millet accrued higher body weight than maize based control diet. Addition of enzymes to raw pearl-millet based diet improved the body weight gain significantly. The reconstitution of pearl millet with or without enzymes increased ( P  < 0.01) the dietary nitrogen corrected apparent metabolizable energy (AMEn) values and the highest improvement (6.11%) was recorded in diets containing pearl millet reconstituted with enzymes at 75% level of maize replacement. The percent nitrogen retention in pearl millet based diets was comparable to maize based control diet. It may be concluded that the supplementation of the feed enzymes or reconstitution of pearl millet may improve the utilization of pearl millet in broiler chickens.     

苜草素对产蛋后期蛋鸡脂肪肝出血综合征的预防作用

本试验旨在研究苜草素对产蛋后期蛋鸡脂肪肝出血综合征(FLHS)的预防作用。选用500日龄京红1号产蛋鸡1 008只,随机等分为7组,每组6个重复,每个重复24只鸡。Ⅰ组为对照组,饲喂常规饲粮(代谢能11.10 MJ/kg,粗蛋白质17.68%);Ⅱ~Ⅶ组为试验组,饲喂高能低蛋白质饲粮(代谢能12.87 MJ/kg,粗蛋白质13.84%),并分别在饲粮中添加0、200、400、600、800、1 000 mg/kg苜草素。试验期60 d。结果表明:1)与对照组相比,高能低蛋白质饲粮组(Ⅱ组)蛋鸡第30天时即可表现出明显的FLHS病理特征,第1~30天平均日采食量、产蛋率、蛋重、产蛋量显著降低(P0.05),料蛋比显著升高(P0.05),第1~60天趋势更加显著(P0.05);第42天蛋白高度和哈氏单位显著降低(P0.05)。2)在高能低蛋白质饲粮中添加不同梯度的苜草素均能降低FLHS发生率,提高第1~60天的平均日采食量、产蛋率、产蛋量,降低料蛋比;提高第42天的蛋白高度、哈氏单位。由此可见,高能低蛋白质饲粮能够诱导蛋鸡FLHS,补充苜草素具有预防作用。     

Laying Performance of Broiler Breeder Chickens Fed Various Millets or Broken Rice as a Source of Energy at a Constant Nutrient Intake

Laying performance, egg quality and carcase traits were recorded in broiler breeders (29–48 weeks of age) fed diets in which pearl millet (Pennisetum typhoides), finger millet (Eleusine coracana), foxtail millet (Setaria italica) or broken rice fully replaced yellow maize (50% of the diet) from the reference diet. Constant ratios of metabolizable energy to other nutrients were maintained in all the diets. Each diet provided 1.38 MJ metabolizable energy (ME)/bird per day to 8 replicate groups of 10 layers each, maintained in deep litter pens.The hen-day egg production and the ME required to produce 12 eggs in birds fed pearl millet or broken rice were similar (p>0.05) to those fed on the maize diet, while birds fed foxtail millet or finger millet required more energy to produce the same number of eggs. The egg production and the efficiency of energy utilization were significantly (p<0.05) reduced in the birds fed these two cereals. Egg quality was not affected by replacing maize with the different cereals. However, the yolk colour index was significantly (p<0.05) reduced in the cereal-fed groups in comparison to the maize-fed birds. The gizzard and giblet weights were heavier (p<0.05) in the birds fed foxtail millet or finger millet than in those fed broken rice. Deposition of abdominal fat and the liver fat content were significantly (p<0.05) higher in the birds fed pearl millet than in the other groups. Depending on the local prices, the cost of feeding may be reduced considerably by using any of the cereals tested as the principal energy source in place of maize in broiler breeder diets.     

Feeding of Unground Pearl Millet to Laying Hens

The use of new varieties of pearl millet (PM) as an alternative feed ingredient for poultry has gained increased interest due to the favorable nutritional characteristics of this grain. However, its incorporation into poultry feeds has been limited because commercial availability of PM in the United States is currently low and also because many feed mills lack the capacity to store more than 1 ground grain. Previous studies have demonstrated the advantages of the inclusion of moderate levels of whole grains in poultry feeds. A series of 3 experiments was conducted to investigate whether unground PM would be a satisfactory feed ingredient for laying hens. In Experiment 1, diets containing 5, 10, 20, 30, and 40% unground PM were fed. At the end of a 7-d feeding period, it was determined that the percentage of whole seed disappearance was equal to or greater than 98% at all levels of inclusion. No significant differences in whole seed disappearance were detected among treatments, indicating that laying hens have the capacity to break down whole PM seeds. In Experiment 2, diets containing 0 or 15% inclusion of either ground or unground PM were fed to laying hens for a 7-d feeding period. Starch digestibility of the diets was determined to be >97% for all treatments. Significantly greater starch digestibility was observed in the hens fed the 15% unground PM as compared with the hens receiving the ground PM diet. In Experiment 3, after a 4-wk feeding period, it was determined that the inclusion of 10% unground PM does not have a negative or positive effect on feed consumption or egg production. These results indicate that PM is a satisfactory feed ingredient for laying hens that can be included in the unground form at moderate levels.     

Evaluation of pearl millet and flaxseed effects on egg production and n-3 fatty acid content

1. A 6-week trial was conducted to evaluate the effects of pearl millet (PM) as a replacement for maize, in combination with flaxseed (FS), on productivity, egg trait parameters and egg n-3 fatty acid (FA) content in White Leghorn hens. 2. Six diet treatments were used: a control (CTL, maize-soybean meal based) diet, and diets containing 0, 2, 4, 8 or 12% FS, in which all maize was replaced by PM (PM-0, PM-2, PM-4, PM-8 and PM-12, respectively). All diets were isocaloric and isonitrogenous and met NRC (1994) requirements. Eight cage replicates per treatment were used (three hens per cage). At the end of each week, three eggs were randomly collected from each cage to measure egg trait parameters and yolks were separated, pooled and lyophilised for FA determination. Body weights and feed consumption were recorded weekly. Egg production (number of eggs and egg mass produced) was recorded daily. At the end of the experiment, all hens were killed to determine liver haemorrhage score. 3. Egg traits and flock performance parameters were not different among treatments except at week 4, when birds on the PM-12 diet produced smaller eggs than hens on the PM-0 and PM-2 diets. Yolk pigmentation scores were lower for the PM-0 and PM-2 diets (1.60 +/- 0.24 and 1.80 +/- 0.20, respectively), increased with higher inclusions of FS (2.75 +/- 0.47 for PM-12 diet) but did not reach control levels (6.00 +/- 0.01). Liver haemorrhage scores were not affected by dietary treatment. Hens given the PM-8 and PM-12 diets produced eggs with n-3 FA content higher than required to be considered as n-3 FA enriched eggs, and had a lower n-6/n-3 FA acid ratio than eggs of hens consuming CTL or the PM based diets with lower FS supplementation. 4. These results suggest that PM can be used to substitute for maize in the diets of layers and may reduce the amount of FS needed to obtain n-3 FA enriched eggs.     

Long-Term Feeding of Conjugated Linoleic Acid and Fish Oil to Laying Hens: Effects on Hepatic Histopathology,Egg Quality,and Lipid Components

The present study was conducted to investigate the effect of long-term feeding of conjugated linoleic acid (CLA) and fish oil on egg quality characteristics, production performance, liver pathology, and egg fatty acid content of laying hens. Single Comb White Leghorn laying hens (n = 112), 21 wk old, were placed in cages and randomly assigned to 4 diets (28 hens/diet, 4 replicates of 7 hens) containing 3.0% yellow grease (control), 2.75% yellow grease + 0.25% CLA (YG-CLA), 2.5% yellow grease + 0.25% CLA + 0.25% fish oil (YG-CLA-FO), and 2.75% yellow grease + 0.25% fish oil (YG-FO). The experimental diets were fed for 12 mo. Eggs were collected daily for 12 mo. Feed consumption, hen-day egg production, and feed efficiency were monitored. At the end of the trial, hepatic tissue was collected for histopathology. No effect of diet was found on feed consumption, hen-day egg production, feed efficiency, egg weight, yolk weight, shell weight, or Haugh unit. The YG-CLA and YG-CLA-FO diets produced an increase in CLA and saturated fatty acids in the egg and liver tissue with a concomitant reduction in monounsaturated fatty acids (P < 0.05). Feeding YG-CLA-FO and YG-FO increased the n-3 fatty acids in egg yolk and liver of hens (P < 0.05). No difference was observed in the number of fat vacuoles in the liver tissue. The total fat content of hepatic and abdominal fat pads did not differ among treatments (P > 0.05). Regardless of the diet, as the hens aged, egg weight, yolk weight, and egg total fat increased, and shell weight decreased (P < 0.05). These data demonstrate that eggs with increased n-3 fatty acids and CLA can be generated by minor diet modifications without affecting the production performance or health of birds.     

The effect of dietary supplementation with phytase transgenic maize and different concentrations of non-phytate phosphorus on the performance of laying hens

1. The objective of this study was to evaluate the effects of dietary supplementation with phytase transgenic corn (maize) (PTC) which has a phytase activity of 21 000 units (U) phytase per kg of maize on productive performance, egg quality, tibia bone quality and phosphorus (P) excretion in laying hens.

2. In the experiment, 1800 44-week-old Hy-line brown laying hens were divided into 5 groups with 6 replicates per group and 60 hens per replicate. The experiment lasted for 12 weeks. The layers in the control group (control) were given a basal diet with 0.36% non-phytate P (NPP), while the treatment groups received diets containing 360 U of exogenous phytase/kg with 0.26% NPP (EP) or 360 phytase U of PTC/kg diet with 0.26% (PTC1), 0.21% (PTC2) or 0.16% (PTC3) NPP.

3. The results showed that there was no significant difference in egg production, average daily feed intake, feed efficiency, rate of broken or soft-shell egg production or egg mass among the treatments. There was no significant difference in eggshell thickness or eggshell strength. On the other hand, no differences in any of the bone variables were found between treatments. The faecal P percentage content in EP, PTC1, PTC2 and PTC3 groups was significantly lower than the control group.

4. In summary, the PTC could be used in the feed of laying hens instead of EP to reduce P excretion without effecting production and bone mineralisation.     

Effects of carbohydrase enzyme supplementation on performance,eggshell quality,and bone parameters of laying hens fed on maize- and wheat-based diets

1. This study was conducted to determine the effects of enzyme supplementation of maize/wheat-based diets on the performance, egg quality, and serum and bone parameters of laying hens.

2. During the 12-week experimental period, a total of 72 laying hens aged 52 weeks were randomly distributed among 6 experimental groups. Each experimental group contained 4 replicates, each with three birds. The experiment was a randomised design consisting of a 3 × 2 factorial arrangement, with three levels of wheat substitution and two levels of enzyme (xylanase: 1500.00 U/kg, β-glucanase: 100 000 U/kg, cellulase: 1 000 000 U/kg, α-amylase: 160 000 U/kg) inclusion in the diet. Wheat replaced 0, 50, or 100% of maize with or without 1.0 g/kg enzyme supplementation in iso-nitrogenous and iso-caloric experimental diets.

3. Body weight, egg production, egg weight, egg mass, eggshell thickness, and the feed conversion ratio were adversely affected by the wheat-based diet. The eggshell quality parameters decreased with enzyme supplementation to the diet.

4. Wheat-based diets adversely affected calcium and phosphorus concentrations in the tibia, but the addition of the enzymes to the wheat-based diet prevented the negative effects of wheat-based diets on tibia mineralisation in laying hens. The wheat-based diets tended to reduce plasma mineral contents, and the addition of enzymes tended to affect plasma minerals and biomechanical properties of the tibia positively in laying hens.

5. These results indicate that wheat-based diets in aged laying hens adversely affected the mineral metabolism compared with maize-based diets, and the negative effects of wheat on bone mineralisation can be prevented by enzyme supplementation to the diets in laying hens.     

提高均匀度差的蛋鸡生产性能试验

对两批18周龄体重分别仅有1013和1021克,均匀度55.1和58.8％的京白823商品代母鸡,采取加强防疫、提高营养水平,减少各种应激等项综合性饲养管理措施。结果5760只入舍母鸡的72周龄入舍鸡和饲养日产蛋量分别达到268.75和276.85枚/只,全程平均蛋重为58.33克/枚, 21～72周龄耗料量为41.21。公斤/只,存活率为85.56％。说明均匀度差,体重轻的鸡,通过合理的饲养管理,可以取得理想的生产成绩。同时也说明北京白鸡有着很大的生产潜力。     

Effect of reduced energy, protein and entire substitution of inorganic phosphorus by phytase on performance and bone mineralisation of laying hens

1. The objective of this study was to evaluate the effects of total removal of dietary inorganic phosphorus and reduced energy and protein, without and with phytase supplementation, on the performance, egg quality and bone composition of laying hens. 2. Lohmann pink-shell hens were randomly assigned at 56 weeks of age to 5 treatments for 20 weeks as follows: (1) a positive control (PC) with 155 g CP/kg, 11·09 MJ ME/kg, calcium (Ca) 3·40% and non-phytic phosphorus (NPP) 0·26%, (2) a negative control (NC1) diet based on PC diet with Ca decreased to 3·30% and NPP to 0·14%, (3) NC2 diet was formulated on the basis of NC1 diet with 152·7 g CP/kg, 10·90 MJ/kg, (4) NC1 and (5) NC2 supplemented with phytase (300 FTU/kg) each. 3. Feed intake, hen-day or hen-housed egg production, egg number per hen-housed, and final body weight were depressed with NC1 and NC2 diets, but restored by phytase inclusion. There were no significant differences between the dietary treatments for feed conversion efficiency, rates of cracked and broken eggs, egg-shell thickness or egg-shell strength. Mortality was significantly increased by NC2 diet without phytase. Tibia ash was significantly decreased by both NC1 and NC2 diets. Bone strength, and Ca and P contents in tibia ash were significantly increased by phytase inclusion in the NC1 diet. 4. In conclusion, the NC1 and NC2 diets significantly depressed performance and tibia quality, but the addition of phytase (300 FTU/kg) significantly improved performance and tibia integrity.     

Effects of toxic and non‐toxic blue mussel meal on health and product quality of laying hens

Blue mussels (Mytilus edulis) are a potential protein source in poultry feeds because of their high methionine and cystein content. However, mussels may temporarily be contaminated with the toxin, okadaic acid. The aim of this small scale study was to evaluate the effects on animal health and morphology of the digestive tract of laying hens fed three different diets; a commercial feed and diets containing 15% normal or 15% toxic mussel meal, i.e. a concentration of 198.6 μg toxin per kg feed. Twelve laying hens were divided into six groups and fed the experimental diets for 8 weeks. Animal health, production performance and egg quality were recorded. At sacrifice, tissue samples were prepared for histological evaluation using light microscopy. Okadaic acid did not have any adverse effects on animal health or production parameters and no histological changes indicating disturbances in the digestive tract was observed. Internal egg quality was improved as eggs from hens fed either of the two mussel meal diets had an increased yolk colour. These results show that mussel meal functions as a novel protein source for laying hens and those toxic mussels at this level may be included in the feed without negative effects on parameters evaluated in this study.     

Sweet white Lupinus Albus (cv buttercup) as a feedstuff for layers

1. An experiment was conducted with laying hens to determine to what extent sweet white lupins (Lupinus albus, cv Buttercup) could be used as a protein source in their diets.

2. Twenty five individually caged 20 week‐old Hisex laying hens were used per treatment. The hens were housed in a convection house for the duration of the study which lasted 52 weeks. Two diets were formulated, one containing 300 g sweet lupins/kg and the other containing sunflower oil cake and fish meal as protein sources. These diets were blended to obtain seven diets with lupin inclusion rates of 0, 50, 100, 150, 200, 250 and 300 g/k.

3. Results indicated that up to 300 g lupins/kg diet can be fed to Hisex laying hens without a significant effect on egg production, egg mass, efficiency of food utilisation, egg shell thickness, Haugh units or yolk colour. Food intake was however, significantly (P<0.05) positively correlated with lupin inclusion rates.