Adsorption of phenolic compounds and browning products in white wines by yeasts and their cell walls

Dehydrated yeast cells at variable concentrations were used as fining agents to decrease the color of white wines with two different degrees of browning (0.153 and 0.177 au, measured at 420 nm). Both wines showed a linear decrease of browning with increasing yeast concentration. However, in terms of efficiency, the yeasts exhibited a higher color lightening at greater concentrations acting on the darker wine. This suggests a preferential retention of some types of yellow-brown compounds that could increase their concentrations at the higher degree of browning. To confirm the role of yeast cell walls in the retention of browning compounds and to evaluate their potential use as fining agents, they were applied at variable concentrations to a browned wine (0.175 au). The cell walls were found to be the active support for the adsorption of browning compounds, but their efficiency was much lower than that of an equivalent amount of the yeast cells from which they were obtained. Finally, HPLC determinations of low-molecular-weight phenolic compounds showed flavan-3-ol derivatives to be significantly retained by both yeasts and their cell walls.     

优选非酿酒酵母胞外酶增香酿造干白葡萄酒效果

为了研究非酿酒酵母胞外酶促进葡萄酒发酵产香的效果,该文在爱格丽葡萄汁酒精发酵12 h后,分别添加优选胶红酵母(Rhodotorula mucilaginosa,RM)胞外酶液,优选发酵毕赤酵母(Pichia fermentans,PF)胞外酶液和商业糖苷酶制剂(almondβ-glucosidase,AG)(10 mU/mL),以不添加酶制剂的酿酒酵母纯发酵为对照,发酵过程中每24 h取样,采用HS-SPME-GC/MS(headspace solid-phase microextraction-gas chromatography/mass spectrometry)监测挥发性成分的生成变化。葡萄酒含糖量低于2 g/L时终止发酵,低温满罐密封储存,次年4月,进行葡萄酒香气仪器和感官量化分析。胞外酶液共测得6种风味酶活性,其中RM酶液中的β-D-葡萄糖苷酶、α-L-鼠李糖苷酶、β-D-木糖苷酶活性均显著(P<0.05)高于PF中的,而α-L-阿拉伯糖苷酶和酯酶在PF酶液中活性更高(P<0.05)。发酵过程中,胞外酶处理显著促进了(P<0.05)品种香气和发酵香气物质的生成,其中RM酶液显著提高了萜烯类物质和苯乙基类化合物含量,其作用效果分别比商业酶处理高41.7%和31.8%,PF酶液显著促进了发酵香气化合物的生成,尤其是脂肪酸乙酯含量约为对照的2倍。酒样感官分析结果显示,两株酵母的胞外酶处理表现出各自增香酿造的优势,其中RM酶液促进温带酸果类香气的效果突出,PF酶液显著提升了柑橘类香气。研究结果为酵母风味酶应用于葡萄酒的增香酿造提供了理论和实践指导。     

不同浸渍工艺对贵人香干白葡萄酒香气品质的影响

为提升贵人香干白葡萄酒的香气品质,以澄清汁发酵工艺(CQ)为对照,利用顶空固相微萃取结合气相色谱质谱联用技术(HS-SPME/GC-MS)检测浸渍工艺(JZ)和浸渍澄清工艺(JC)处理发酵酒样中的挥发性香气化合物。结果表明,浸渍处理可以明显增加葡萄酒中香气物质的含量。与CQ相比,JZ和JC对发酵酒样中品种香气物质的含量影响显著(P<0.05),萜烯类化合物含量分别增加1.86、1.01倍,且JC酒样中醇类、酯类香气物质含量最高,分别为4 799.38 μg·L^-1和5 013.28 μg·L^-1。主成分分析结合感官评价结果表明,JZ和JC酒样的花香特征相似,且JC酒样的热带水果香气以及醇香特征更为明显;与CQ相比,JC发酵酒样香气优雅、纯正,口感平衡。综合分析,浸渍澄清工艺(JC)可有效提升甘肃河西产区贵人香干白葡萄酒的香气品质。本研究结果可为干白葡萄酒增香酿造提供技术支持。     

Changes in color and odorant compounds during oxidative aging of Pedro Ximenez sweet wines

Pedro Ximenez sweet wines obtained following the typical criaderas and solera method for sherry wines and subjected to oxidative aging for 0, 1.3, 4.2, 7.0, or 11.5 years were studied in terms of color and aroma fraction by using the CIELab method and gas chromatography, respectively. The parameters defining the CIELab color space (a*, b*, and L*) were subjected to a multiple-range test (p<0.05) that allowed discrimination of the five wine aging levels studied into five uniform groups according to aging time. The aroma fraction was found to include 15 active odorant compounds with OAV > 1 that enriched the wines with fruity, fatty, floral, and balsamic notes during the aging process. The changes in color parameters and active odorants were not linearly related to aging time, being especially marked during the first 1.3 years and then less substantial up to the 7 years, the oldest wines exhibiting sensorial properties markedly departing from all others. For the wines aged over 1.3 years (minimum aging), 2,3-butanedione, linalool, and decanal can be used as reliable fingerprints of the older wines' quality.     

不同酶和酵母对干红葡萄酒香气影响的差异分析

为提高甘肃河西产区蛇龙珠干红葡萄酒的香气品质,优化酿酒工艺,该文采用顶空固相微萃取和气相色谱-质谱联用技术,分析比较了添加不同浸渍酶和酵母发酵的蛇龙珠干红葡萄酒的香气构成。结果显示:蛇龙珠干红葡萄酒中初步定性香气化合物75种,主要为酯、醇、酸、萜烯和酚类物质。比较酯类、萜烯类等香气成分质量浓度和香气物质释放总量,EX-V酒样明显高于EX和HC酒样,D254酒样明显高于BDX酒样。各组酒样主要香气成分构成相似,但微量香气成分差异显著。果香是香气强度最高的香气系列,植物香、脂肪香、花香次之,其香气强度EX-V酒样高于EX和HC酒样,D254酒样高于BDX酒样。浸渍酶和酵母对甘肃河西产区蛇龙珠干红葡萄酒香气品质的影响评价显示,浸渍酶EX-V优于EX和HC,酵母D254优于BDX。研究结果可为甘肃河西产区蛇龙珠干红葡萄酒香气品质的提高及酿造工艺研究提供科学数据参考。     

Definitive evidence for the actual contribution of yeast in the transformation of neutral precursors of grape aromas.

Experiments were designed to demonstrate the actual contribution of yeast in the formation of the primary aroma during the vinification of neutral grapes. Ruché was chosen as the model wine to study because of its unique fragrance. A yeast strain specific for Ruché was selected using a new and rapid isolation method for red wines. The results of this study can be summarized as follows: Skins from nonaromatic white or red grapes apparently contain most of the primary aroma compounds that are revealed in the must only after contact with yeast cells under defined conditions. Similar results were obtained with the pulp and seeds fractions; however, the olfactory notes, although well characterized, differed from those obtained with skins alone. Clarification, filtration, and centrifugation of the pulp and seed fractions or sonification of the skins produce different and well-characterized olfaction notes during the contact with yeast. The primary aroma of nonaromatic white and red grapes contained in the skins can be revealed within 24-48 h of yeast contact in a synthetic nutrient medium (SNM). The primary aroma precursors extracted from the skins with methanol, water-saturated butanol, or aqueous buffer at pH 3.2, concentrated and eluted from a C18 resin column, can be transformed to the free form wine aroma markers within 6 h of contact with yeast cells in SNM. By contrast, prolonged maceration of the skins in aqueous alcoholic buffer at pH 3.2 or 1.1, at 50 or 70 degrees C did not release primary odors typical of wine. The individual primary aroma compounds, identified by GC-MS analysis in Ruché wine samples or in Ruché skin-yeast-SNM samples, could not explain the complexity of the typical Ruché wine odor. Only odors common to many wine varieties were identified by GC-olfactometry analysis.     

Effect of oak extract application to Verdejo grapevines on grape and wine aroma

Volatile compounds from a commercial aqueous oak extract application to white Verdejo grapevines at veraison have been studied. Treated grapes under two types of formulation (25% and 100%) have been analyzed at the optimum maturation time, and winemaking was then subsequently carried out. The volatile compounds were analyzed by stir bar sorptive extraction-gas chromatography-mass spectrometry. The results suggest that after the grapevine treatments, grapes store the volatiles in the form of nonvolatile precursors, and some of the volatiles are released during the winemaking process, especially six months after the alcoholic fermentation. The sensory analysis shows that wines maintain the typical aroma properties of Verdejo wines at the end of fermentation; but after six months, the wine color is greener and more astringent, and, in terms of aroma, it has wooden notes as if the wine has been aged in oak barrels.     

Analytical and sensorial characterization of the aroma of wines produced with sour rotten grapes using GC-O and GC-MS: identification of key aroma compounds

In the present work, the aroma profiles of wines elaborated from sound and sour rot-infected grapes as raw material have been studied by sensory analysis, gas chromatography-olfactometry (GC-O), and gas chromatography-mass spectrometry (GC-MS), with the aim of determining the odor volatiles most likely associated with this disease. The effect of sour rot was tested in monovarietal wines produced with the Portuguese red grape variety Trincadeira and in blends of Cabernet Sauvignon and sour rotten Trincadeira grapes. Wines produced from damaged berries exhibited clear honey-like notes not evoked by healthy samples. Ethyl phenylacetate (EPhA) and phenylacetic acid (PAA), both exhibiting sweet honey-like aromas, emerged as key aroma compounds of sour rotten wines. Their levels were 1 order of magnitude above those found in controls and reached 304 and 1668 μg L(-1) of EPhA and PAA, respectively, well above the corresponding odor thresholds. Levels of γ-nonalactone also increased by a factor 3 in sour rot samples. Results also suggest that sour rot exerts a great effect on the secondary metabolism of yeast, decreasing the levels of volatiles related to fatty acids and amino acid synthesis. The highest levels of γ-decalactone of up to 405 μg L(-1) were also found in all of the samples, suggesting that this could be a relevant aroma compound in Trincadeira wine aroma.     

Interactions between yeast lees and wine polyphenols during simulation of wine aging. II. Analysis of desorbed polyphenol compounds from yeast lees

In the first part of this work, the analysis of the polyphenolic compounds remaining in the wine after different contact times with yeast lees during simulation of red wine aging was undertaken. To achieve a more precise view of the wine polyphenols adsorbed on lees during red wine aging and to establish a clear balance between adsorbed and remnant polyphenol compounds, the specific analysis of the chemical composition of the adsorbed polyphenolic compounds (condensed tannins and anthocyanins) after their partial desorbtion from yeast lees by denaturation treatments was realized in the second part of the study. The total recovery of polyphenol compounds from yeast lees was not complete, since a rather important part of the initial wine colored polyphenols, especially those with a dominant blue color component, remained strongly adsorbed on yeast lees, as monitored by color tristimulus and reflectance spectra measurements. All anthocyanins were recovered at a rather high percentage (about 62%), and it was demonstrated that they were not adsorbed in relation with their sole polarity. Very few monomeric phenolic compounds were extracted from yeast lees. With the use of drastic denaturing treatments, the total recovery of condensed tannins reached 83%. Such tannins extracted from yeast lees exhibited very high polymeric size and a rather high percentage of galloylated residues by comparison with initial wine tannins, indicating that nonpolar tannins were preferentially desorbed from yeast lees by the extraction treatments.     

Removal of ochratoxin A in red wines by means of adsorption treatments with commercial fining agents

The presence in wine of the fungal metabolite, ochratoxin A (OTA), represents a serious risk for consumer health. A variety of fining agents, including activated carbon, silica gel, potassium caseinate, egg albumin, and gelatin, was evaluated in relation to their abilities to remove OTA in fortified wines. Freundlich adsorption isotherms were used to model the adsorption behavior between ochratoxin A and the fining agent. Potassium caseinate and activated carbon were found to be the best fining agents that could be used to remove OTA in wine. Potassium caseinate removed up to 82% of OTA when used at 150 g/hL, whereas activated carbon showed the highest specific adsorption capacity due to a high surface area per mass and low adsorption of total polyphenols.     

Wheat gluten used as a clarifying agent of red wines.

Bovine spongiform encephalopathy caused a situation of crisis leading the public and winemakers to lose their confidence in the use of gelatin as a fining agent and to reject animal proteins in general. Therefore, we started the search for a substitute for gelatin and egg protein by comparing gluten with these fining treatments currently used. This study concerned the fining of a Burgundy red wine (Rully, Controlled Appellation). For 6 g/hL, enzymatically hydrolyzed glutens (EHG) gave better efficiencies than deamidated glutens. The efficiency of the egg proteins treatment was situated between those of the hydrolyzed glutens and deamidated glutens. For 12 and 18 g/hL, turbidities of the wine treated by five glutens were 67 to 86% less than that of the control wine. Better results were obtained with egg proteins for short kinetics particularly. Wine fining with gluten was always better than gelatin treatments. The differences between the five glutens became very small when the dose incorporated in the wine increased. The volumes of lees generated by fining with gluten are situated between the values obtained with egg proteins and gelatin. After fining, immunodetection with gluten polyclonal antibodies failed to detect residual deamidated gluten.     

Volatile and color composition of young and model-aged Shiraz wines as affected by diammonium phosphate supplementation before alcoholic fermentation

A Shiraz must with low yeast assimilable nitrogen (YAN) was supplemented with two concentrations of diammonium phosphate (DAP) and then fermented with maceration on grape skins. The nonvolatile, volatile, and color composition of the final wines were investigated. Ethanol and residual sugars were not affected by DAP supplementation, while glycerol, SO 2, and residual YAN increased and acetic acid decreased. DAP-supplemented treatments gave rise to higher concentrations of acetates, fatty acids, and fatty acid ethyl esters but lower concentrations of branched-chain fatty acids and their ethyl esters. No major difference between treatments was observed for higher alcohols, monoterpenes, norisoprenoids, and low-molecular-weight sulfur compounds. DAP-supplemented fermentations resulted in wines with higher concentrations of malvidin-3-glucoside, higher color intensity, and altered color tonality. Model aging studies indicated that higher concentrations of esters are still present in wines from the DAP-treated fermentations after aging. DAP supplementation also resulted in increased concentrations of dimethyl sulfide after model aging. It can be concluded that DAP treatment of a low YAN must fermented by maceration on skins can significantly affect wine color, aroma, and flavor.     

From wine to pepper: rotundone, an obscure sesquiterpene, is a potent spicy aroma compound

An obscure sesquiterpene, rotundone, has been identified as a hitherto unrecognized important aroma impact compound with a strong spicy, peppercorn aroma. Excellent correlations were observed between the concentration of rotundone and the mean 'black pepper' aroma intensity rated by sensory panels for both grape and wine samples, indicating that rotundone is a major contributor to peppery characters in Shiraz grapes and wine (and to a lesser extent in wine of other varieties). Approximately 80% of a sensory panel were very sensitive to the aroma of rotundone (aroma detection threshold levels of 16 ng/L in red wine and 8 ng/L in water). Above these concentrations, these panelists described the spiked samples as more 'peppery' and 'spicy'. However, approximately 20% of panelists could not detect this compound at the highest concentration tested (4000 ng/L), even in water. Thus, the sensory experiences of two consumers enjoying the same glass of Shiraz wine might be very different. Rotundone was found in much higher amounts in other common herbs and spices, especially black and white peppercorns, where it was present at approximately 10000 times the level found in very 'peppery' wine. Rotundone is the first compound found in black or white peppercorns that has a distinctive peppery aroma. Rotundone has an odor activity value in pepper on the order of 50000-250000 and is, on this criterion, by far the most powerful aroma compound yet found in that most important spice.     

Effect of Schizosaccharomyces pombe on aromatic compounds in dry sherry wines containing high levels of gluconic acid

Volatile compounds have been determined in control dry sherry wines and those supplemented with gluconic acid, which were inoculated with the Schizosaccharomyces pombe 1379 (ATCC 26760) yeast strain. These compounds were grouped, according to volatiles exhibiting the identical odor quality, into nine groups of the same odor character (aromatic series) as a way of establishing the aroma profile for the studied wines. Control and supplemented wines showed changes in the balsamic, spicy, roasty, and fruity aromatic series, and tasters judged the aroma as typical of wines subjected to biological aging. This fission yeast may be used as a treatment to reduce gluconic acid contents in wines obtained from rotten grapes, making feasible the incorporation of these wines into the biological aging process. In addition, this procedure may also help to accelerate the traditional biological aging in sherry winemaking due to the contribution of some specific compounds by S. pombe to the wine.     

Determination of the grape invertase content (using PTA-ELISA) following various fining treatments versus changes in the total protein content of wine. relationships with wine foamability

Proteins have proven to play a major role in the stabilization of foam in Champagne wines despite their low concentration that ranges from 4 to 20 mg/L. The aim of this study was to evaluate the effect of fining on total protein and grape invertase contents of champenois base wines and their foaming properties. Data showed that fining and especially the use of bentonite at doses ranging from 10 to 50 g/hL leads to a significant decrease in the total protein content of wines together with that of the grape invertase content, with such a decrease being very detrimental to the foaming properties of the treated wines in terms of foam height (HM) and foam stability (HS). Only a slight decrease in the total protein content, in the grape invertase concentration, and in the foam quality of wines was observed when using casein (10 and 20 g/hL) or bentonite combined with casein (both at 20 g/hL). Our study thus clearly establishes the good correlation existing between the wine protein concentration and its foaming properties. A remarkable correlation was observed between the decrease in the grape invertase content and the total protein content of wines, following bentonite treatments, suggesting that the grape invertase (which represents at least 10-20% of the wine proteins) follows a similar behavior upon fining to other proteins of Champagne wines, despite the high molecular mass and the highly glycosylated structure of this particular protein. Moreover, the decrease in total protein and grape invertase contents of wine after fining with bentonite was found to be correlated with a decrease in the foaming properties of the corresponding wines (with respectively R(2) = 0.89 and 0.95).     

Wine production using yeast immobilized on apple pieces at low and room temperatures

A biocatalyst was prepared by immobilization of Saccharomyces cerevisiae strain AXAZ-1 on apple pieces. It was examined by electron microscope and studied during the fermentation of grape must for batch wine-making. The immobilized yeast showed an important operational stability without any decrease of its activity even at low temperatures (1-12 degrees C). Specifically, at 6 degrees C the biocatalyst favored wine production within 8 days, which is less time than is required for the natural fermentation of grape must. At 1 degrees C wine production was effected in 1 month. This speeding up of the fermentation could be accepted and adopted by the industry for scaling up the wine-making process. Total and volatile acidities were similar to those found in dry wines. The concentrations of higher alcohols (propanol-1 and isobutyl alcohol) were low. The presence of amyl alcohols proved to be temperature dependent and decreased with the temperature decrease. The values of ethyl acetate concentrations were relatively high, up to 154 mg/L. This probably contributes to the fruity aroma and excellent taste of the produced wines. There was no indication of vinegar odor in the product given that the volatile acidity was <0.47 g of acetic acid/L. From the GC-MS analysis it was concluded that cell immobilization did not create serious changes in the product (wine) with regard to the qualitative composition of the aroma compounds.     

Influence of lysozyme treatments on champagne base wine foaming properties

The objective of this study was to estimate the effect of lysozyme on the foaming characteristics of Champagne base wine. Lysozyme additions were made to the musts and also to the wines before and after bentonite or charcoal treatments, which remove endogenous proteins. Treatments with bentonite diminished foamability and foam stability of wines, whatever the dose (30 or 80 g/hL) and variety [Chardonnay, -28%; Pinot noir, -20% (at 30 g/hL)]. An addition of lysozyme in must raised Pinot noir wine foamability by 21%, whereas the difference is hardly perceptible for Chardonnay wine (+3%). Pinot noir and Chardonnay wines, originating from lysozyme-treated musts, in addition to bentonite treatment on the wine, presented higher foamability than wines treated only with bentonite. Lysozyme was removed (91-100%) by the bentonite treatment. Then, it was not responsible for the increase in foamability but seemed to have a protective effect on the wine proteins. When wines were initially treated with bentonite (150 g/hL) and then enriched with 80 g/hL lysozyme, this enzyme was not able to restore foaming properties. Treatments with charcoal always diminished foamability. The average increase in foamability due to an addition of lysozyme after charcoal treatment (80 g/hL) was 23%. Results showed a real positive effect of lysozyme on foam stability when wines have to be treated with charcoal (+25% and +56% for the Pinot noir wine and the Chardonnay wine, respectively, at 30 g/hL).     

戴尔有孢圆酵母调控晚采小芒森葡萄酒乙酸和香气

为降低甜型葡萄酒中的挥发酸,进一步增加其香气复杂度,该研究利用本土戴尔有孢圆酵母R12与酿酒酵母NX11424同时接种和顺序接种发酵,研究其对贺兰山东麓产区晚采小芒森葡萄酒乙酸及香气成分的调控。与酿酒酵母单菌发酵相比,本土戴尔有孢圆酵母与酿酒酵母按照5:1、20:1、50:1的不同菌体数量比例同时接种和间隔5d顺序接种发酵,均可以显著降低晚采小芒森葡萄酒的乙酸含量,其乙酸产率分别降低19.1%、21.2%、38.2%和48.9%。此外,按20:1比例同时接种发酵,可显著提高晚采小芒森葡萄酒中萜烯类和降异戊二烯类等品种香气物质含量,和乙酸异戊酯、丁酸乙酯及苯乙醇等发酵香气物质的含量。该研究表明合理的酿酒酵母接种发酵能有效降低高糖原料酿造葡萄酒挥发酸含量,为贺兰山东麓产区葡萄酒新产品的开发提供了的技术参考。     

Oenological influences on the D/H ratios of wine ethanol

Within the European Union the determination of chaptalization of wine involves the comparison of the D/H ratios of ethanol with the ratios of authentic wine samples that are similar to the suspect wine in terms of geographical origin, grape variety, and vintage. In the frame of a databank project comparison, wines are produced under official control on a small scale. To clarify the influence of the different production conditions between commercial wines and these databank wines, wines that were produced under varying conditions were investigated by the (2)H NMR method. None of the parameters under investigation, such as yeast strain, fermentation temperature, or wine fining, showed a significant influence on the (D/H)(I) ratio of wine ethanol, which is the most indicative parameter for the determination of the addition of extraneous sugar to wine. For the (D/H)(II) ratio, different values were found for different yeast strains used for fermentation and a slight decrease was observed with increasing fermentation temperature. At increasing points of fermentation yield an increase of the D/H ratios was found in the present alcohol. The total increase of the (D/H)(I) ratio throughout the fermentation was approximately 1 ppm, so that with a fermentation yield of more than 50% no statistical difference could be observed.