Chopped palm leaves as an acceptable bedding material for broiler production

An experiment was conducted to examine the suitability of chopped palm leaves to utilize as a bedding material, compared to wood shavings or wheat straw, on growth performance, immune response, and air quality for broiler production. Three bedding materials were used: wood shavings, chopped palm leaves, and wheat straw. A total of 3,240 one-day-old broiler chicks (Ross 308) was randomly distributed into 3 litter groups (1,080 birds each). Each group had 6 replicate pens (180 birds/pen). All birds were kept under similar environmental conditions, except for bedding material. The obtained results revealed that the growth performance and total mortality rate were not significantly affected by bedding material type. However, using chopped palm leaves as bedding material significantly reduced (P < 0.05) ammonia emission compared to wood shavings and wheat straw (4.1, 7.3 and 8.4 ppm, respectively). A similar trend was observed for settled dust concentration (4.0, 10.3, and 5.9 g/m², respectively). Moreover, an improvement in cell-mediated immunity was observed in boilers kept on chopped palm leaves. Carcass characteristics were not significantly affected by bedding material. It was concluded that chopped palm leaves are a good alternative bedding material to wood shavings and wheat straw in commercial broiler production.     

Composting characteristics of three bedding materials

Horse manure management is becoming a major concern in suburban areas of the United States. An average horse can produce eight to ten tons of manure per year, accumulating at a rate of two cubic feet per day, including bedding. If properly composted, the manure and bedding can be transformed into a very useful, odorless, pathogenfree product. The objective of this trial was to compare the characteristics of recycled chopped phone book paper, sawdust and wheat straw bedding during composting. Six horses were stalled on three bedding types: recycled phone book paper, sawdust and straw. Each day manure and soiled bedding types were separately collected and transported to compost sites over an eight-day period. Three compositing bins were each hand constructed from wooden pallets with 10 cm slats. The front of the bin was left open for manipulation of materials during the composting process. Initial volumes of the soiled bedding materials were 1m³, 1m³, and 1.5m³ for paper, sawdust and straw, respectively. Temperatures were taken for each bedding materials using a 51 cm REOTEMP compost thermometer. Temperatures were taken on Day 0 and every four days over the 65-day trial (n=52). Temperature was used to determine the need for moisture addition and aerating by turning to keep the piles microbially active. On Day 37 the C:N ratio was adjusted by the addition of ammonium sulfate, 0.1 kg, 0.1 kg and 0.14 kg for sawdust, phone book paper and straw piles, respectively. Mean standard error and range for compost temperatures (C) were: phone book paper, 33.17±10.33 (13–52); sawdust, 45.6±9.35 (27–58); straw, 30.42±6.57 (16–39). The sawdust composted more readily as compared to the phone book paper or straw. The paper and straw had poorer structure, which caused compaction of the material when moistened; thus, porosity, oxygen supply and microbial activity were reduced.     

Effects of Different Bedding Materials on the Behavior of Horses Housed in Single Stalls

The effects of three different bedding materials (straw, wood shavings, and straw pellets) on the behavior of six warmblood horses (four mares, two of them with foals) housed in single stalls were analyzed. Each material was used for 2 weeks in three consecutive runs. The behavior of the horses was videotaped and analyzed on the first and last 3 days for each bedding alternative in the last of the three runs. The time budgets for the behaviors including standing, eating, lying, occupation with bedding material, and other were generated. Compared with straw pellets and wood shavings, the application of straw bedding led to a significantly higher frequency and longer duration of occupation with bedding material and in turn, shorter fractions of standing and other behaviors. The total duration of lying was significantly longer on straw than on straw pellets. Straw pellets resulted in the least mean recumbency duration per occurrence of this behavior. Because occupation is one of the important functions that bedding material is supposed to fulfill, we concluded that in regard to horse behavior, straw bedding was the best among the three materials analyzed. Further investigations with a more homogeneous group of probands are necessary to verify the observed behavioral reactions.     

Quality of different bedding materials and their influence on the compostability of horse manure

The air quality of the stable and management and composting of manure can be improved by choosing bedding material with certain desirable properties. The optimal bedding material doesn't cause hygiene problems in the stable. It absorbs ammonia, is economic in use, and decomposes quickly with manure. The objective of this trial was to compare both quality of different bedding materials and their influence on the composting process of horse manure. Bedding materials used in the study were wood chips, straw, peat, hemp, linen, sawdust, shredded newspaper and the mixtures, peat/wood chips, peat/sawdust, and peat/straw. Peat and peat mixtures had the best quality of ammonia absorption, water holding, and manure fertilization value. The number of fungi and bacteria were lower in shredded newspaper and wooden materials than in straw, linen, hemp, and peat. The composting temperature became high enough for at least a partial destruction of parasites and seeds within the rubbish heaps in all boxes. Only peat manure was ready for further plant production after one month's composting period. Other bedding materials were decomposed only partially or not at all during the study.     

Investigating duration of nocturnal ingestive and sleep behaviors of horses bedded on straw versus shavings

Horses are stabled overnight for a number of practical reasons; however, there is little research quantifying nocturnal equine behavioral patterns or the extent to which different environments influence nocturnal behavior. The aim of this study was to establish whether differences in duration of sleep and ingestive behaviors were apparent for horses bedded on straw (group 1) or shavings (group 2). Ten geldings of mixed breed (mean age: 7.3 ± 3.53 years) bedded on either shavings (n = 5) or straw (n = 5) were observed between 7 pm and 7 am. Duration of behaviors according to a predefined ethogram was recorded in minutes using a video recorder and continuous focal sampling. Mann–Whitney U tests were used to identify whether any significant differences in duration of ingestion and sleep behaviors occurred for horses bedded on straw compared with shavings. Of the total observation period, group 1 spent, on average, 29.3% of their time budget engaged in recumbent behaviors, compared with 12.2% for group 2. However, no significant differences in duration were established between horses bedded on straw or shavings for standing sleep, sternal recumbency, and lateral recumbency behaviors (P > 0.05). Ingestive behaviors occupied approximately one-third of the time budget, with no significant difference (P > 0.05) observed between groups. On average, group 1 spent a longer proportion of the observation period ingesting bedding (8.1%) compared with group 2 (1%). Duration of bedding ingestion appeared to peak between 1 am and 7 am for both groups. Although not quantified, general observations revealed horses were motivated to alternate between eating hay and bedding in both groups, owing to the prevalence of bedding ingestion. The results indicate that straw bedding facilitates the display of ingestive and sleep behaviors, whereas horses bedded on shavings spent a greater proportion of their nocturnal time budget engaged in “other” behaviors. Further research is required to investigate the extent to which different types of bedding material enrich the environment of horses that are stabled overnight.     

The effect of litter materials on broiler performance: a systematic review and meta-analysis

ABSTRACT

1. Divergence in outcomes from studies on the effects of litter materials on body weight, feed intake, feed conversion and mortality in broilers has led to a need for a meta-analysis to quantify their effects.

2. A systematic search of published quantitative research relating to wood shavings and alternative bedding litters was conducted using databases.

3. Means, standard deviations and sample sizes were extracted from each study. The response variables were analysed using the standardised mean difference (SMD, control treatment minus alternative litters).

4. The literature demonstrated that alternative materials have no impact on feed intake in broilers, compared to wood shavings (SMD = 0.064, 95% CI = ?0.101–0.229, P = 0.44).

5. There was a positive overall effect of wood shavings on body weight (SMD = 0.253, 95% CI = 0.073–0.433, P = 0.006), feed conversion (SMD = ?0.169, 95% CI = ?0.327 – ?0.012, P = 0.03) and mortality (SMD = ?1.069, 95% CI = ?1.983 – ?0.155, P = 0.02) of broilers, compared to other litter types.

6. Subgroup meta-analysis revealed that straw, when used as an alternative litter material to wood shavings, may be responsible for lower body weight (SMD = 0.654, 95% CI = 0.162–1.146, P = 0.009), worse feed conversion (SMD = ?0.487, 95% CI = ?0.828 – ?0.145, P = 0.005) and higher mortality rates of broilers (SMD = ?3.25, 95% CI = ?5.681 – ?0.819, P = 0.009). Rice husks impaired body weight compared to wood shavings (SMD = 0.535, 95% CI = 0.065–1.004, P = 0.02).

7. It was concluded that different litter types do not affect the broilers’ feed intake. Conversely, broilers kept on straw showed lower body weights, worse feed conversion and higher mortality rates, in comparison to wood shavings. Rice husks decreased body weight compared to wood shavings.     

Horse hair coat cleanliness is affected by bedding material: A comparison of clean and used wheat straw, wood shavings and pelleted newspaper

Wheat straw, wood shavings and pelleted recycled newspaper were used as bedding materials and compared in maintaining horse hair coat cleanliness. Each material was sampled prior to use and after use having been wetted with urine in a bedding study conducted with 4 adult horses in box stalls. Because feces were removed daily during stall maintenance, frehhly voided feces were also collected so that all components in a used bedding (clean portion, wetted portion, feces) were represented. Hair coat cleanli-ness was measured in vitro by exposing a tanned pony hide with hair to clean and wet beddings as well as feces. Cleanliness was evaluated in terms of the amounts of moisture, volatile-N and solid matter transferred from each component and type of bedding material to the haired hide. Transfers to wool flannel were also measured as a comparison to the haired hide. Woolen products are used in the horse industry and also come into contact with components of used bedding. Freshly voided feces and used beddings transferred more (P<.05) moisture (85 and 54%, respectively) than clean beddings. Wheat straw transferred less (P<.05) solid matter (86 and 64%, respectively) than wood shavings or pelleted newspaper. Wood shavings transferred more (P<.05) solid matter than wheat straw or pelleted newspaper to wool flannel resulting in a statistically significant used bedding X surface interaction. These data indicate that type as well as components of used beddings affect hair coat cleanliness. The ability of a bedding material to maintain hair coat cleanliness should also be a factor (e.g., cost, availability, moisture holding capacity, nontoxicity) in its consideration for use as a bedding for animals.     

Generation of Airborne Particles from Different Bedding Materials Used for Horse Keeping

Among other factors (eg, feed), bedding material has an important effect on stable air quality with respect to airborne particle formation. This study was designed to establish which material is suited to create an improved stable environment for horses. First, the following materials were analyzed under standardized conditions in a laboratory experiment: wheat straw, dry wood shavings, hemp shives, linen shives, wheat straw pellets, paper cuttings (unprinted newspaper). The second investigation was carried out under in situ conditions in which three of these bedding materials (wheat straw, wood shavings, and straw pellets) were analyzed under practical conditions. In both experiments, airborne particle concentrations were detected online with the gravimetrically measuring analyzer TEOM 1400a (Rupprecht & Patashnick Co., Franklin, MA). In the laboratory experiment, the TEOM was equipped successively with different inlets to measure the particle fractions PM₁, PM_2.5, PM₁₀, and PM₂₀. During the in situ experiment, only the fraction PM₁₀ was detected. In the laboratory experiment, hemp and linen had the highest generation of airborne particles in all fractions. The lowest particle generation was detected with straw pellets. Results of the in situ investigation supported results of the laboratory experiment with respect to mean particle generation of straw pellets. With an average of 111.2 ± 149.2 μg/m³, it was significantly lower than the mean particle generation of wheat straw with 227.5 ± 280.8 μg/m³. The particle generation of wood shavings had an average of 140.9 ± 141.9 μg/m³ and also was significantly lower than the generation by wheat straw. An activity-correlated variation of particle concentrations was found. In conclusion, taking both experiments into consideration, straw pellets seemed to be suitable for horse stables, to promote an improvement in the stable climate in relation to airborne particle formation.     

Chemical, physical, and environmental properties of pelleted newspaper compared to wheat straw and wood shavings as bedding for horses.

Two experiments were conducted comparing pelleted recycled newspaper (PN) to wheat straw (S) and kiln-dried pine wood shavings (WS) as an animal bedding material. Adult horses housed 20 to 21 h/d in boxstalls served as the animal model for comparisons. In Exp. 1 eight boxstalls, each housing one horse, were each bedded with two types of PN (0.32 and 0.64 x 2.54 cm), S, and WS over four 5-d periods (replicated 4 x 4 Latin square). Initial amounts of bedding materials surpassed most commercial conditions, but stalls were cleaned daily of feces only and additional clean bedding was added as needed to maintain animal cleanliness, thus challenging the bedding properties of each material. In Exp. 2 nine boxstalls were bedded with PN (0.32 x 2.54 cm), S, and WS over three 14-d periods (three 3 x 3 Latin squares) during summer and autumn. Feces and wet spots were removed daily and clean bedding was added to reestablish working volume and simulate commercial conditions. In Exp. 1 and 2 daily additions of clean bedding varied (P < 0.05) with material (S > WS > PN). The higher water-holding capacity of PN and WS contributed to fewer bedding replacements. Usage of each material was greater (P < 0.05) during the autumn; PN had the greatest increase. Type of material and season also influenced bedding environment. Bedding pH increased (P < 0.05) with use and was highest in PN and lowest in S. Higher concentrations of breathable NH3 N were present in stalls bedded with PN and during autumn. Higher pH of used PN and decreased ventilation due to closed doors and windows during autumn were contributing factors. Season, type of bedding, and duration of its use affected (P < 0.05) numbers as well as species of microorganisms present in the breathing zone, nasal cavity, and on the leg of the horse. Clean and used WS contained greater (P < 0.05) quantities of particle fines, but with 5 d of use, particle fines in PN also increased. Quantities of breathable dust during cleaning of stalls varied (P < 0.05) with material and duration of its use; dust peaked at d 7 with PN but continued to decrease with S and to increase with WS through d 14. These data indicate that management of bedding materials varies with type of material and season of year. Use of PN as a bedding material has high potential.     

Evaluation of Factors Influencing the Generation of Ammonia in Different Bedding Materials Used for Horse Keeping

Bedding material is an important factor in determining stable air quality in terms of ammonia formation. The objective of this study was to analyze different bedding materials used for horse stables under standardized conditions, to determine which material is best suited for improving the climate of a stable. The particular concern was a reduction in gaseous ammonia concentrations. Therefore, the following materials were examined: wheat straw, wood shavings, hemp shives, linen shives, wheat straw pellets, and paper cuttings. Twelve containers were constructed in an environmentally controlled room, and the same material was placed into two containers, with the amount of material used being determined by its carbon content. A defined ratio of horse manure/urine mixture was added daily to each container over a period of 14 days. The concentrations of gaseous ammonia, carbon dioxide, nitrous oxide, and water vapor were measured continuously above the bedding within the containers. Means of gaseous ammonia were found to be 178.0 mg/m³ for wheat straw, 155.2 mg/m³ for wood shavings, 144.6 mg/m³ for hemp, 133.7 mg/m³ for linen, 60.3 mg/m³ for straw pellets, and 162.6 mg/m³ for paper cuttings. In conclusion, the results of this study have shown that straw pellets are suitable for horse stables, not only to improve air quality but also, first and foremost, in relation to ammonia binding and ammonia transformation within the bedding material, respectively. However, straw pellets may also have disadvantages. The high substrate temperatures that were measured in straw pellets could favor the growth of pathologic germs that can adversely affect animals' health.     

Suitability of biocompost as a bedding material for stabled horses: respiratory hygiene and management practicalities

REASONS FOR PERFORMING STUDY: Bedding material in stables has an important influence on air hygiene and information on the suitability of biocompost and wood shavings is incomplete. OBJECTIVES: To compare the suitability and benefit of biocompost and wood shavings as bedding in horse stables and to determine key air factors for the evaluation of the potential impact of these materials on respiratory health. METHODS: The study was conducted in a naturally ventilated stable with 4 horses. Air hygiene parameters were measured 24 h/day for 7 days with each bedding type: ammonia (NH3), inhalable and respirable dust, endotoxins, colony forming units (CFU) of total mesophilic bacteria, fungi, actinomycetes and thermophilic actinomycetes. Both bedding materials were analysed for general chemical composition, particle size distribution and natural microbial content. The animals' behaviour was monitored by video cameras, and their health and cleanliness status determined by clinical and visual examination. RESULTS: Concentrations of NH3, dust, endoxins and fungi were significantly higher during the monitoring period with wood shavings than with biocompost. In contrast concentrations of mesophilic bacteria, mesophilic actinomycetes and thermophilic actinomycetes microbial pollutants were highest with biocompost. The water content of bulk biocompost was considerably higher than that of wood shavings. Particles < or = 0.4 mm were not detectable in bulk wood shavings. The concentration of thermophilic actinomycetes by weight in raw biocompost was 639 times higher than in raw wood shavings. No significant differences were observed in the time spent by the horses lying down. The biocompost material tended to adhere more intensively to the animals' hair coat. Horses showed no clinical signs indicating any adverse effects of the biocompost material during the trials. CONCLUSIONS: Biocompost cannot be recommended as bedding material for horses in stables, because the concentration of thermophilic actinomycetes and other agents that elicit and maintain recurrent airway obstructions was significantly higher with biocompost than with wood shavings. To ensure the well-being of horses, any new bedding material must be tested very carefully before it is introduced to the market.     

Respirable dust concentrations in equine stables. Part 1: validation of equipment and effect of various management systems

Traditional methods of measuring airborne dust concentrations (ADC) in animal housing have included the collection of dust onto pre-weighed filters permitting the calculation of mean, not maximum, ADC. However real-time continuous particle monitors are advantageous in identifying short duration elevations in ADC which may be detrimental to equine respiratory health in the face of a relatively low mean ADC. These monitors have not previously been used to measure ADC in equine stables. Comparisons of a filter-based sampler and a real-time continuous particle monitor revealed no significant difference (P=0.079) and good agreement (>or=95% of the points fell within two standard deviations of the mean of the differences and the mean of the differences approximated zero) between the devices, with respect to mean respirable dust concentration (RDC) measurements. Investigations of the influence of various equine management systems on RDC revealed that both mean and maximum breathing zone RDC were significantly reduced (P<0.05) in equine stables by changing the environment from hay feed and straw bedding, to haylage feed and wood shavings bedding (reduction in mean - 0.0867mg/m(3) to 0.0260mg/m(3); reduction in maximum - 4.0758mg/m(3) to 0.2182mg/m(3), respectively).     

The Influence of a Particle Separation Technology on the Generation of Airborne Particles from Different Roughages and Bedding Materials Used for Horses

Four different types of bedding materials (wheat straw, wood shavings, hemp shives, flax shives) and two roughages (hay, haylage) were treated using an air-driven particle separation technology. The airborne particle and mold generation of both treated and untreated samples were then analyzed under standardized laboratory conditions. In addition, samples of all the treated materials were stored for 8 weeks either in a pressed or incoherent form and then analyzed again for their ability to generate airborne particles. The airborne particle concentrations were detected online with the gravimetrically measuring analyzer tapered element oscillating microbalance (TEOM) 1400a that was equipped successively with different inlets to measure the particle fractions PM₂₀, PM₁₀, PM_2.5, and PM_1.0 (PM = Particulate matter). The particle separation resulted in a reduction in the airborne particle (PM₂₀) generation in all materials: hay 49.16 to 22.79 mg/m³ (53.6%), haylage 28.57 to 25.04 mg/m³ (12.3%), wood shavings 141.68 to 15.04 mg/m³ (89.4%), wheat straw 143.08 to 22.97 mg/m³ (83.9%), flax 135.11 to 53.31 mg/m³ (60.5%), and hemp 63.67 to 17.64 mg/m³ (72.3%). The 8-week storage of the treated materials as compressed materials led to a renewed significant increase in the airborne particle (PM₁₀) concentration in the haylage (+29.9%), wheat straw (+104.0%), wood shavings (+40.4%), and hemp shives (+30.7%). Storage of the incoherent materials caused a significant increase in these particles only in the wheat straw (+44.2%). The separation treatment reduced the mold production by 92.4% in the wood shavings, 88.0% in the wheat straw, and 85.8% in the hay.     

Ammonia emissions from broiler litter: response to bedding materials and acidifiers

1. In a pen study, NH(3) flux estimates were performed when clean wheat straw or wood shavings were used as bedding materials in combination with two NH(3) control amendments: sodium bisulphate and a commercial premix of phosphoric + hydrochloric + citric acids. 2. Ammonia emissions from wood shavings were 19% greater than from wheat straw around waterers, but statistically similar around feeders. These results could be due to the greater caking observed when wheat straw was used. 3. Sodium bisulphate reduced NH(3) emissions significantly only in the first half of the rearing period; the loss of efficacy in the second half resulted in total NH(3) volatilisation not statistically different from the untreated control. The treatment containing phosphoric + hydrochloric + citric acids did not have a significant effect in decreasing NH(3) emissions. 4. Bird mortality was not affected by the treatments, but broiler weight gain when wheat straw was used was significantly lower than with wood shavings, which could have been caused by the greater caking observed with wheat straw.     

Respirable dust concentrations in equine stables. Part 2: the benefits of soaking hay and optimising the environment in a neighbouring stable

The effect of soaking hay to minimise equine breathing zone respirable dust concentration (RDC) is unknown, as is the duration of soaking required. Additionally, the influence of the bedding and forage used in one stable on the mean and maximum RDC in a neighbouring stable within a common airspace is unknown. Consequently, in the management of equine environmental respiratory disease uncertainty remains about the necessity for optimising conditions in neighbouring stables. Investigations using a real-time continuous particle monitor revealed that when feeding hay, horses' mean breathing zone RDC was significantly reduced if the hay was immersed or soaked for a prolonged time, prior to feeding. There was no advantage in soaking for an extended time period. Implementing management changes in one stable (changing from straw bedding and hay feeding to wood shavings bedding and haylage feeding) significantly reduced mean and maximum background RDC in a neighbouring stable within a common airspace.     

Characteristics of Gas Generation (NH3, CH4, N2O, CO2, H2O) From Horse Manure Added to Different Bedding Materials Used in Deep Litter Bedding Systems

The aim of this study was to analyze the influence of horse manure added to different bedding materials on the generation of gases (ammonia (NH₃), nitrous oxide, carbon dioxide, methane, water vapor) from deep litter bedding under standardized laboratory conditions. Two different types of straw (wheat and rye) and wood shavings were analyzed. The deep litter (substrate) was made of 25 kg of the respective bedding material, 60 kg horse feces, and 60 L ammonium chloride solution (urea), and spread out in identical chambers over 19 days (n = 3). On days 1, 8, 15, and 19, total nitrogen, total carbon, and dry matter content of the substrate, as well as the pH in 500-g samples, were measured along with. At the end of each test period, the nitrite nitrogen, nitrate nitrogen, and ammonium nitrogen contents of the leachate were analyzed. The wheat straw substrate emitted the highest concentration of NH₃ (4.31 mg/m³; P < .0001) and the wood shavings substrate emitted the lowest (1.73 mg/m³; P < .0001); the rye straw substrate generated 3.05 mg/m³. In addition, significant differences occurred during days 1 to 3 with respect to the generation of the gases NH₃, methane, nitrous oxide, carbon dioxide, and water vapor, and after the opening of the chamber on day 15. The nitrogen losses through the leachate occurred mainly in the form of nitrate, where the leachate from the wheat straw substrate had a significantly higher amount of nitrate nitrogen (44.56 mg) as compared with the leachates of the rye straw (14.49 mg; P ≤ .0001) and the wood shaving substrates (22.62 mg; P = .0010).     

Characterization of Aerococcus viridans isolated from milk samples from cows with mastitis and manure samples

Thirty-eight Aerococcus viridans isolates were obtained from milk from 478 cows with clinical mastitis in a farm during the periods between November 2011 and February 2012, and between December 2012 and March 2013. Additional isolates were obtained from processed manure (a mixture of composted manure, straw and hydrated lime) and bedding materials. The processed manure was later used to cover the floor of the stalls in barns as bedding materials. The temperatures recorded in the composted and processed manure were not as high as those generally observed during satisfactory composting. To reveal the association of A. viridans in manure-related products with intramammary infection in cows, isolates were characterized by their DNA fragment patterns as determined by pulsed-field gel electrophoresis (PFGE) and antimicrobial susceptibility testing. Isolates obtained from milk, processed manure and bedding materials had identical DNA fragment patterns. Antimicrobial susceptibilities were determined for 29 isolates from milk, processed manure and bedding materials. Of these, 26 (89.7%) were resistant to clindamycin, whereas virtually all the isolates were susceptible to 12 other antimicrobials including cefalosporins that have been used to treat bovine mastitis in Japan. In vitro, three A. viridans isolates from milk and an isolate from processed manure survived for 3 hr in Good’s buffer (pH 9) at high temperature (50°C). The results suggest that the processed manure and bedding materials in this farm were possible sources of A. viridans that caused infection in the cows with mastitis.     

Alternative bedding materials and litter depth impact litter moisture and footpad dermatitis

A function of bedding material in poultry houses is to absorb and release moisture. New bedding is commonly placed at inadequate depths in houses. Pine shavings are the industry standard for bedding material in the majority of the United States, but can be hard to obtain or costly. Alternative materials were tested for moisture absorption and retention. Peat moss and chopped wheat straw were found to absorb nearly 8× and 7× their own weight in moisture, respectively. Peat moss was then used in a broiler study and compared to fresh and used pine shavings for 6 weeks. Body weight was lower at d 7 for the used litter and peat moss treatment compared to fresh shavings with no differences at d 42. No differences in ammonia generation or litter pH were observed. Litter moisture was higher for peat moss through d 14. Paws were better in the fresh shaving and peat moss pens than used shaving pens at both d 21 and 42. Next, different depths of used and fresh shavings on footpad dermatitis (FPD) were examined. Trials 1 and 2 compared 2.5, 7.6, and 12.7 cm of fresh shavings or used litter, respectively. In Trial 1, 2.5 cm had higher litter moisture than 7.6 and 12.7 cm at d 21, 28, and 35 (P < 0.05). The 12.7 cm had better paw scores than 2.5 cm at d 21 and 35 (P < 0.05). In Trial 2, 12.7 cm had lower litter moisture than 2.5 cm at d 28, 35, and 42 (P < 0.05). The paws in 12.7 cm were better than those in 2.5 cm at d 35 and 42 (P < 0.05). There was little difference in paw quality and litter moisture between 7.6 and 12.7 cm litter depth in both trials. Peat moss may be an acceptable alternative bedding material and should be evaluated on a commercial scale in areas where it can be obtained economically. These findings suggest that broiler houses should have at least 7.6 cm of litter to control litter moisture levels and reduce FPD.     

Evaluating the effects of bedding materials and elevated platforms on contact dermatitis and plumage cleanliness of commercial broilers and on litter condition in broiler houses

1. Experiment 1, comparing wood shavings and ground straw bedding with peat, was performed on 7 broiler farms over two consecutive batches during the winter season. Experiment 2, assessing the effect of elevated (30 cm) platforms, was conducted in three farms replicated with 6 consecutive batches.

2. Footpad lesions were inspected at slaughter following the Welfare Quality® (WQ) assessment and official programme. Hock lesions, plumage cleanliness and litter condition were assessed using the WQ assessment. Litter height, pH, moisture and ammonia were determined.

3. Footpad condition on wood shavings appeared to be worse compared with peat using both methods of assessment and was accompanied by inferior hock skin health. WQ assessment resulted in poorer footpad and hock skin condition on ground straw compared with peat. Farms differed in footpad and hock skin condition. Footpad and hock lesions were not affected by platform treatment. Peat appeared more friable than ground straw. The initial pH of wood shavings was higher and moisture was lower than in peat, but at the end of production period there were no differences. Ground straw exhibited higher initial and lower end pH, and was drier in the beginning than peat. Litter condition and quality were not affected by platform treatment.

4. This study provides new knowledge about the applicability of peat as broiler bedding and shows no negative effects of elevated platforms on litter condition or the occurrence of contact dermatitis in commercial environments. The results suggest a complicated relationship between litter condition, moisture and contact dermatitis. Furthermore, it is concluded that the farmer’s ability to manage litter conditions is important, regardless of the chosen litter material. Peat bedding was beneficial for footpad and hock skin health compared with wood shavings and ground straw.     

Effect of Feeding Endophyte-Infected Feed and Bedding on the Performance of Broilers

Two varieties of chopped grass seed straw, tall fescue (Festuca arundinaces L.) and perennial ryegrass (Lolium perenne L.), were identified as alternative sources to wood sawdust or shavings as bedding for use by Pacific Northwest broiler producers. However, some broiler growers expressed concern that straw may be contaminated with endophytes, symbiotic fungi that are known to be toxic to livestock. The primary toxic compound of concern for livestock in endophyte infected grass straw is ergovaline.Two experiments were conducted to determine if broiler performance was affected by either the feeding of endophyte infected grass seed containing ergovaline, or rearing broilers on endophyte infected grass seed straw. The exposure of broilers to either endophyte-infected chopped straw as bedding and/or feeding endophyte infected ground grass seed in the diet with ergovaline levels as high as 423 ppb, did not significantly affect performance or the micro anatomy of kidney or liver tissues.