Effect of replacing fish meal with soybean meal on growth,feed utilization and nitrogen and phosphorus excretion of juvenile Pseudobagrus ussuriensis

An 8‐week feeding trial was conducted to evaluate the effects of replacing fish meal with soybean meal (SBM) on growth, feed utilization, and nitrogen (N) and phosphorus (P) excretion of juvenile Pseudobagrus ussuriensis (initial average weight 0.50 ± 0.00 g). Seven isonitrogenous and isolipidic diets were formulated to contain SBM to replace fish meal protein at 0% (S0), 10% (S10), 20% (S20), 30% (S30), 40% (S40), 50% (S50) and 60% (S60) respectively. To investigate the effects of supplementation with crystalline amino acid to balance diet S60, one diet was formulated to add 0.30% methionine (SM60). The results showed that there was no significant difference in weight gain among fish fed S0, S10, S20, S30 and S40 diets, however, a significant reduction in this variable occurred when 50% and 60% of fish meal protein was replaced by SBM (P < 0.05). Apparent digestibility coefficients of dry matter, crude protein and phosphorus of diets were affected by dietary SBM levels. N and P excretion indicate that fish meal replacement by SBM led to an increase in N excretion, but led to a reduction in P excretion. No differences were detected in growth, feed utilization and N and P excretion between fish feed diets S60 and SM60. The results of this study show that 40% of fish meal protein could be replaced by SBM in diets of juvenile P. ussuriensis without having a significant negative effect on growth or feed efficiency, but that higher dietary SBM levels reduce fish performance.     

Effect of replacing fish meal with soybean meal on growth,feed utilization and nitrogen and phosphorus excretion on rainbow trout (<Emphasis Type="Italic">Oncorhynchus mykiss</Emphasis>)

The effect of replacing fish meal with soybean meal (SBM) pretreated with phytase on feeds of juvenile rainbow trout was evaluated in a 90-day feeding trial. The rainbow trout (initial body weight, 4.01 ± 0.02 g) were fed five isonitrogenous (crude protein, 44.97%) and isolipidic (crude lipid, 13.42%) feeds. Diets were formulated to contain phytase-pretreated SBM replacing 0, 20, 40, 60 and 80% of fish meal protein, respectively. The results showed that there was no significant difference in weight gain (WG) among fish fed S0, S20, S40 and S60 diets; however, a significant reduction of this variable occurred when 80% of fish meal protein was replaced by phytase-treated SBM (P < 0.05). Similarly, specific growth rate and protein efficiency ratio had a similar trend with WG. Apparent digestibility coefficient (ADC) of protein and lipid in the S80 diet was significantly lower than that of the other diets, and the ADC of phosphorus significantly increased with the increase of dietary phytase-treated SBM level. No significant differences among treatments were detected for moisture, protein, lipid and ash content in whole body and muscle samples. Nitrogen and phosphorus excretion indicated that fish meal replacement by phytase-treated SBM led to an increase in nitrogen excretion, but led to a reduction in total phosphorus excretion. The results of the present study show that 60% of fish meal could be replaced by phytase-treated SBM in diets of juvenile rainbow trout without compromising weight gain or feed efficiency. A quadratic equation according to regression analysis of weight gain against dietary phytase-treated SBM level indicated that the optimal level of dietary phytase-treated SBM replacement for maximum growth was 26.90%.     

Effects of dietary inclusion of soybean meal and cholesterol on the growth,cholesterol status and metabolism of the giant grouper (Epinephelus lanceolatus)

The study evaluated effects of cholesterol supplementation in a diet with high soybean meal (SBM) on the growth and cholesterol metabolism of giant grouper (Epinephelus lanceolatus). All‐fish‐meal diet was used as control. The diet including SBM (replaced 50% of the fish meal protein, SBM diet) and the SBM diet supplemented with 10 g/kg cholesterol (SBM + cholesterol) were used as experimental diets. Three diets were each fed to triplicate groups of juvenile grouper (initial body weight: 12.39 ± 0.36 g) in a recirculating aquaculture system for 8 weeks. Grouper fed the control diet showed higher (p < .05) weight gain, feed intake, feed efficiency and protein efficiency ratio than the other two dietary treatments. Hepatic cholesterol concentrations and 3‐hydroxy‐3‐methylglutaryl coenzyme A reductase gene expressions were higher in fish fed the control diet than fish fed the control diet and SBM + cholesterol diet. Hepatic cholesterol 7α‐hydroxylase gene expression was higher in fish fed the SBM + cholesterol diet than that in fish fed the control diet. Results indicate that giant grouper on a diet low in cholesterol can regulate cholesterol synthesis, suggesting that the reduced dietary cholesterol intake in the fish fed diet containing SBM is sufficiently compensated by increased cholesterol synthesis.     

Effect of partial replacement of dietary fish meal by soybean meal with betaine attractant supplementation on growth performance and fatty acid profiles of juvenile rainbow trout (Oncorhynchus mykiss)

This study was conducted to investigate the effects of dietary incorporation of soybean meal for fish meal replacement and supplementation of betaine as an attractant on growth performance and fatty acid profiles of rainbow trout (Oncorhynchus mykiss). Juvenile trout were fed practical diets, with increasing soybean levels and betaine supplementations. The experimental diets consisted of a control diet with fish meal as the sole protein source (control) and no attractant, 25% soybean‐1% betaine diet (SBM25‐B1), 50% soybean‐2% betaine diet (SBM50‐B2), and 50% soybean‐0% betaine diet (SBM50‐B0). Average body weight was 12.69 ± 0.16 g at the beginning of experiments. Following 54 days feeding programme with experimental diets, average body weights reached 47.45 ± 1.22 g, 58.11 ± 1.77 g, 56.34 ± 1.87 g and 53.76 ± 1.74 g in the control, SBM25‐B1, SBM50‐B2 and SBM50‐B0 groups respectively. As compared with control treatment, significant differences were observed in weight gain, specific growth rate and feed intake of 1% betaine treatment at 25% soybean‐meal‐incorporated diet (p < .05), but no differences were observed in feed conversation ratio and survival rates (p > .05). Compared with the control treatment, betaine‐supplemented groups had significantly higher total saturated fatty acid contents (p < .05). On the other hand, the control treatment showed a significantly higher level of monounsaturated fatty acid than the betaine‐supplemented groups (p < .05). Significant differences were observed in fatty acid profile of 1% betaine‐supplemented group (p < .05) compared with the control. Present findings revealed that 1% betaine supplementation with dietary incorporation of soybean meal at 25% level positively influenced growth performance, feed utilization and fatty acid profiles of rainbow trout juveniles.     

Partial replacement of fish meal by soybean meal with or without methionine and phytase supplement in diets for juvenile Chinese sucker,Myxocyprinus asiaticus

This study was designed to evaluate the effects of using soybean meal supplemented with or without methionine (M) and graded levels of phytase (P) to replace high‐level (60%) fish meal in the diets for juvenile Chinese sucker. Seven experimental diets (about 430 g kg^?1 crude protein on dry matter basis) were formulated from practical ingredients. The control diet (FM) was formulated to contain 400 g kg^?1 white fish meal (FM), whereas in the other six diets (diets 2–7), soybean meal (SBM) was used to replace 60% fish meal with or without methionine (3 g kg ^?1) and 0,500, 1000, 1500 and 2000 U kg^?1 phytase (designated as SBM, SM, SMP500, SMP1000, SMP1500 and SMP2000, respectively). Results from the feeding trial indicated that SBM without any methionine or phytase supplement replacing about 60% FM significantly affected the growth of fish (P < 0.05). Weight gain of fish fed diet SM was significantly higher than the fish fed diet SBM, but still much lower than fish fed the control diet (P < 0.05). SBM with methionine and phytase supplement significantly improved the growth of fish and apparent digestibility coefficients of phosphorus compared with the groups which fed diet SBM and diet SM (P < 0.05). Weight gain of fish fed SMP1000, SMP1500 and SMP2000 had no significant difference than fish fed control diet. Furthermore, fish fed SMP1500 showed optimum weight gain and ADC of phosphorus between these three groups. This suggested that soybean meal with 3 g kg^?1 methionine and 1500 U kg^?1 phytase supplement could successfully replace 60% fish meal in the diet for juvenile Chinese sucker without affecting growth and enhanced the apparent digestibility coefficient of phosphorus.     

Balance trials with African catfish Clarias gariepinus fed phytase-treated soybean meal-based diets

Balance trials were conducted with African catfish Clarias gariepinus to assess the effect of phytase treatment of soybean meal-based diets on growth, feed utilization and nutrient budgets. Isocaloric (20–22 kJ g⁻¹) and isonitrogenous (47–50% protein) diets were tested. In a first experiment the control diet (58% fish meal and 18% soybean meal) was compared with two diets containing 6% fish meal and 69% soybean meal, and two diets containing 29% fish meal and 41% soybean meal. One of each of these two diets had been pretreated with phytase (1000 units per kg dry diet). In the second experiment, the control diet (6% fish meal and 69% soybean meal, pretreated with 1000 units phytase kg⁻¹ dry diet) was compared with four diets that were similar in composition but supplemented with increasing amounts of phytase (15, 380, 750, 1000 units kg⁻¹ dry diet). Replacement of fish meal by soybean meal in the first experiment led to a depression in growth rate and feed utilization parameters. Results of both experiments clearly indicated a positive effect of phytase treatment, particularly on phosphorus digestibility and retention, and consequently the phosphorus conversion efficiency and the phosphorus budget. No differences in these parameters were found between addition of equal amounts of phytase by pretreatment or supplementation.     

Effect of partial replacement of fish meal with soybean meal and feeding frequency on growth,feed utilization and body composition of juvenile Chinese sucker,Myxocyprinus asiaticus (Bleeker)

A factorial (2 × 4) feeding trial was conducted to investigate the effects of feeding frequency and partial replacement of fish meal (FM) with soybean meal (SBM) on the growth performance, feed utilization and body proximate composition of juvenile Chinese sucker. Two feed types including replacement of 30% FM (diet 1) with SBM (diet 2) were used. Triplicate groups of fish (average weight, 11.80 ± 0.19 g) were fed each feed type to visual satiation at four meals per day, three meals per day, two meals per day and one meal per day for 8 weeks. At the end of the feeding trial, the survival of fish was not significantly different among the treatments. Weight gain was affected by the feeding frequency. The highest weight gain was observed in fish fed with diet 1 at three meals per day. There existed a significant difference in daily feed intake (DFI), daily protein intake (DPI), feed conversion ratio (FCR) and protein efficiency ratio (PER) when the feeding frequency was increased from one or two to three or four meals per day (P < 0.001), but not by the feed types. For both two feed types, the highest DFI and DPI were observed at three meals per day. The highest PER was gained at four meals per day, while FCR was the least. The body proximate composition of fish was altered by feeding frequency. The crude lipid content increased with the increase in feeding frequency. Essential amino acids (EAAs) content showed no significant differences among different treatments. The present findings suggest that three feedings per day at visual satiation may be sufficient for the maximal growth performance of Chinese sucker grown from 11 to 45 g. Results also indicate that about 30% of FM protein can be replaced by SBM protein in Chinese sucker diets without adversely affecting growth.     

Fishmeal replacement by soybean,rapeseed and cottonseed meals in hybrid sturgeon Acipenser baerii ♀ × Acipenser schrenckii ♂

A 12‐week feeding trial was conducted to evaluate the effects of replacing fishmeal (FM) with soybean meal (SBM), rapeseed meal (RM) and cottonseed meal (CSM) on growth, feed utilization and body composition of juvenile hybrid sturgeon Acipenser baerii ♀ × Acipenser schrenckii ♂ (initial body weight, 8.63 ± 0.24 g). Five isonitrogenous and isoenergetic diets were formulated as follows: a control diet (FM60) containing 600 g/kg FM and four other diets (FM45, FM30, FM15 and FM0 containing 450, 300, 150 and 0 g/kg FM, respectively) where protein from FM was substituted by a mixture of SBM, RM and CSM. Fish fed FM0 and FM15 had poorer growth performance, feed utilization, apparent digestibility coefficients of dry matter, protein, lipid and gross energy, and fed FM0 had poorer hepatosomatic index and survival compared with the fish fed FM60. The whole body lipid in fish fed FM0 was significantly higher than that in fish fed FM60 and FM15. This study indicates that 300 g/kg of FM can be replaced with a mixture of SBM, RM and CSM in the diet of juvenile hybrid sturgeon without compromising growth performance, feed utilization and body composition.     

Potential of processed animal protein versus soybean meal to replace fish meal in practical diets for European catfish (Silurus glanis): growth response and liver gene expression

A 9‐week study was conducted to evaluate the potential of processed animal protein (PAP) in comparison with soybean meal (SM) to replace fish meal (FM) in practical diets for European catfish, Silurus glanis, on growth performance, liver transaminase activities and expression of growth‐related genes. Seven isonitrogenous (440 g kg^‐1 crude protein) and isoenergetic (16.70 MJ/kg) practical diets were formulated by replacing 0 (control), 30%, 60% and 100% FM with either SM or PAP. Each diet was randomly assigned to triplicate groups of 25 fish per cages fixed in the pond. Fish fed the diet substituted 100% FM from SM or PAP had lower (p < .05) growth performance, feed efficiency and protein retention compared to control and other groups. The decreased growth performance occurred concomitant with a decline in the expression level of liver GHR/IGF‐I axis genes. The gene expression and activity of liver protein metabolism enzymes also positively correlated with growth performance. Findings of this study indicated that both SM and PAP were equally effective in replacing FM up to 60% in the practical diet of Silurus glanis. Total replacement of FM either with SM or PAP induced negative influences on growth and feed utilization.     

Replacing fish meal with increasing levels of meat and bone meal,soybean meal and corn gluten meal,in diets of juvenile bluegill,Lepomis macrochirus

A 60‐day study was conducted to determine the response of juvenile bluegill Lepomis macrochirus to seven experimental diets, formulated using a blend of alternative protein sources as a replacement for fish meal. Adequate levels (digestible basis) of energy, protein and amino acids were maintained in diets 1–6, whereas slightly lower protein and energy levels were provided in diet 7. Feed cost per tonne ranged from $ 798.9 (diet 1, 550 g Kg^?1 fish meal) to $ 515.8 (diet 6, 0 g kg^?1 fish meal), or to $ 507.2 (diet 7, 0 g Kg^?1 fish meal). Three commercial diets were included in the study as reference diets: a high‐energy and a low‐energy trout diet, as well as a catfish diet. Quintuplicate bluegill groups (~22 g, n = 10 fish group^?1) were fed the experimental diets twice daily to apparent satiation. No major differences in feed consumption, feed efficiency and growth rates were detected among the bluegill groups fed the experimental diets. Trout diets generally produced higher fish fat deposition, whereas the catfish diet produced a poorer fish growth rate relative to the experimental diets. Under the reported conditions, results indicate diet 6, comprising predominantly soybean meal and porcine meat and bone meal, to be the most economical diet for juvenile bluegill.     

豆粕替代鱼粉对牛蛙生长、体组成、消化酶活力及肝脏生化指标的影响

为减少牛蛙饲料鱼粉使用量以降低养殖成本,研究了豆粕替代饲料中不同比例的鱼粉对牛蛙的生长性能、体组成、肠道消化酶活力和肝脏生化指标的影响。用豆粕分别替代0%、20%、40%、60%、80%和100%的鱼粉配制出6种等氮等能的实验饲料,每组饲料设3重复,养殖牛蛙60 d。结果显示,豆粕替代鱼粉对牛蛙摄食率、成活率、肝体指数、脏体指数、蛙体水分和灰分含量、蛙腿肌肉组成以及肝脏丙二醛含量的影响不显著;豆粕100%替代鱼粉显著降低牛蛙增重率、特定生长率、饲料系数、蛋白质效率、蛋白质累积率;随豆粕替代鱼粉比例的提高,牛蛙的肥满度和后腿指数呈下降趋势,替代100%鱼粉显著降低牛蛙肥满度,替代60%鱼粉显著降低牛蛙后腿指数;替代80%鱼粉显著降低牛蛙全体粗蛋白的含量;牛蛙全体粗脂肪含量随替代鱼粉比例的提高呈上升的趋势,替代100%鱼粉组粗脂肪含量最高;随着替代比例的提高,牛蛙肠道蛋白酶的活力显著降低,而肠道淀粉酶和脂肪酶活力显著提高。豆粕替代鱼粉显著影响肝脏超氧化物歧化酶和过氧化氢酶活力,其中超氧化物歧化酶活力最低值出现在替代80%鱼粉组,过氧化氢酶活力最低值出现在替代100%鱼粉组。基于以上实验结果,建议牛蛙饲料中豆粕可替代鱼粉的比例为60%~80%。     

Partial replacement of soybean meal with Methylobacterium extorquens single‐cell protein in feeds for rainbow trout (Oncorhynchus mykiss Walbaum)

A feeding trial was conducted with juvenile rainbow trout (15–16 g initial weight) to assess the effects of including single‐cell protein (SCP) produced from Methylobacterium extorquens in trout feeds. Three isonitrogenous and isoenergetic diets were produced: a control diet and two experimental diets containing 5% or 10% bacterial protein meal replacing soybean meal. Triplicate tanks, each containing 35 fish, were fed each diet to apparent satiation in a constant‐temperature (15°C), flow‐through tank system for 12 weeks. No statistically significant differences in final fish weight or other fish growth parameters were observed. Similarly, feed efficiency parameters showed no significant differences among groups. Nutrient retention indices (protein, fat, energy) were relatively high and similar among fish in each dietary treatment group, as were whole body proximate compositions. Fish survival was high, with a small but statistically significant increase for the 10% SCP diet. Overall, results demonstrate that SCP from M. extorquens is a safe and effective alternative protein for rainbow trout diets at the low inclusion levels tested. Slightly lower weight gain in fish fed the 10% SCP diet was largely due to lower feed intake, suggesting that adding palatability‐enhancing ingredients to feeds may allow higher levels of M. extorquens SCP to be used without compromising fish growth.     

The suitable dose of gamma irradiation on soybean meal as a fish meal substitute in diets for golden pompano (Trachinotus ovatus)

A 5‐week feeding trial was conducted to assess the effect of gamma ray irradiation treatment on soybean meal as a fish meal substitute in diets for golden pompano (Trachinotus ovatus). A diet containing 32% fish meal served as a reference (C), and 75% of the fish meal was replaced by soybean meal that either received no gamma ray irradiation (R0) or was irradiated with gamma ray at a dose of 5 (R5), 10 (R10), 15 (R15), 30 (R30) or 60 (R60) kGy respectively. All the diets were formulated to contain 46% crude protein and 6.5% crude lipid. The weight gain was higher in fish fed diets R5, R10, R15 and R30 than in fish fed diet R0. The feed intake was higher in fish fed diets R15, R30 and R60 than in fish fed diets R0, R5 and R10. No significant differences were found in feed conversion ratio, nitrogen retention efficiency, condition factor, hepatosomatic index, body composition, waste outputs of nitrogen and phosphorus between fish fed the diets with non‐irradiated soybean meal or irradiated soybean meal as the fish meal substitute. Proteins with heavy molecular weight in soybean meal were degraded, whereas the contents of proteins with light molecular weight or peptides increased with the increase in the irradiation dose. This study reveals that gamma ray irradiation at a dose of 5 to 15 kGy can significantly improve the level of soybean meal inclusion as a fish meal substitute in diets for golden pompano.     

Effects of phytase pretreatment of soybean meal and phytase-sprayed in diets on growth, apparent digestibility coefficient and nutrient excretion of rainbow trout (Oncorhynchus mykiss Walbaum)

Rainbow trout were fed a diet containing phytase-sprayed and phytase-pretreated soybean meal with different phytase levels. The single factor random block design was used to analyze the effects on rainbow trout of dietary phytase supplementation on growth performance, nutritional ingredient digestibility and nutrient excretion. After 90 days, the results showed that feed conversion ratio (FCR) and protein efficiency ratio (PER) were significantly improved and specific growth rate (SGR) was not affected by spraying phytase, but SGR, FCR and PER were not significantly improved by phytase pretreatment. A digestibility trial conducted after the feeding trial showed that apparent digestibility coefficient (ADC) of diet protein and minerals was increased with phytase supplementation. However, there was a negative effect of phytase on the ADC of lipid. The excretion experiment showed that the supplementation of phytase resulted in decreased nutrient excretion in feces, but lipid excretion was slightly increased with phytase supplementation. In addition, the results of P excretion and ADC of P analyzed by t-test showed that phytase pre-treatment method should be a more rational method than the spraying method. The results of SGR, ADC of P and P excretion analyzed by quadratic regression indicated that 2,000–3,000 U/kg levels by the spraying method could be a rational range of phytase supplementation, and about 1,000 U/kg should be an optimal level by the pretreatment method. Thus, use of phytase in rainbow trout feeds can have economic and environmental benefits.     

Evaluation of soybean meal from different sources as an ingredient in practical diets for Pacific white shrimp Litopenaeus vannamei

Solvent extracted soybean meal (SBM) is generated using different varieties of soybeans grown under a range of conditions and then processed at different crushing plants. Due to its competitive cost and availability, it is a popular plant‐based protein source for shrimp feed formulations. However, there is limited information about effects of variations in the nutritional composition of soybean meal have on performances of shrimp. Hence, the present study was designed to determine the effects of different soybean sources on the growth performances of Litopenaeus vannamei. Two growth trials were conducted with iso‐nitrogenous and iso‐lipidic (350 g/kg protein and 80 g/kg lipid) test diets formulated with 25 sources of soybean meal. Trial one incorporated 14 treatments including a soy‐based diet containing 517 g/kg SBM (eight replicates) and this soy source was then replaced with 13 different soybean sources (four replicates per treatment). The second trial used the same basal diet and 11 different sources of soybean meal (Total 12 diets) with five replicates per treatment. Both growth trials were conducted with a stocking density of 10 shrimps/aquarium in a semi‐closed recirculating system and the initial weight of shrimps for trials 1 and 2 were 0.23 g ± 0.02 and 0.67 g ± 0.02 respectively. During the two trials, shrimp were fed four times/day assuming a FCR of 1.8, over 42 days for trial 1 and 35 days for trial 2. Results indicated that there are differences among sources of soybean meal for standardized percentage TGC. Diet 21 that contained SBM4550 had the largest value for TGC whereas the lowest value for TGC was observed for shrimp fed diet 17 that contained SBM45536. According to the statistical analysis that was used to interpret the growth performance data from the complete chemical profile of the SBM, phosphorous, phytate‐phosphorous and total phytic acid levels had positive correlations (p < 0.005) with TGC whereas raffinose (p = 0.086) had a negative correlation with TGC. Results of this work indicates phosphorous, phosphorous in phytic acid and total phytic acid and raffinose are important components in SBM that may have significant effects on the growth performances of pacific white shrimp.     

Response of juvenile tench (Tinca tinca L.) fed practical diets with different protein contents and substitution levels of fish meal by soybean meal

A basal practical diet for juvenile tench (Tinca tinca) was formulated and elaborated to test several protein contents and substitution possibilities of fish meal (FM) by soybean meal (SBM) in a 90‐day trial with 5‐month‐old juveniles (30.54 mm TL, 0.30 g W). A factorial design included nine feeding treatments: three protein contents (50%, 40% or 30%) and three levels of replacement (0%, 25% or 45%) of FM protein by SBM protein. In addition, a commercial carp feed was used as reference. Final survival ranged from 98.2% to 99.4%. The 50% dietary protein with 0% or 25% replacement and 40% dietary protein with 25% replacement diets enabled higher growth (P < 0.05) and lower FCR (P < 0.05) than the rest of practical diets. Fish fed 50% dietary protein had similar growth than those fed carp feed (63.8% protein). Deformed fish averaged 1% for the practical diets and 87.6% for the carp feed. The basal practical diet has showed to be feasible and levels of 40–50% dietary protein with 25% replacement of FM protein by SBM protein can be recommended for juvenile tench aged 5–8 months.     

Dietary microbial phytase supplementation and the utilization of phosphorus, trace minerals and protein by rainbow trout [Oncorhynchus mykiss (Walbaum)] fed soybean meal-based diets

Effects of thermal and enzymatic treatments of soybean meal on apparent absorption of total phosphorus, phytate phosphorus, nitrogen (protein), ash, calcium, magnesium, copper, iron, manganese, strontium and zinc were examined using rainbow trout, Oncorhynchus mykiss (Walbaum), as the test species. Absorption of the test nutrients was estimated using yttrium as an inert non-absorbable indicator. Thermal treatments (microwaving, dry roasting, steam heating, cooking) had no measurable effect on the apparent absorption of phosphorus and other minerals. Phytase supplementation increased the apparent absorption of phosphorus, nitrogen (protein), ash, calcium, magnesium, copper, iron, strontium and zinc in low-ash diets containing soybean meal, but had little effect in high-ash diets containing both soybean and fish meal. In low-ash diets, the apparent absorption of phosphorus increased in accord with the level of phytase added to the diet, from 27% (no phytase added) up to 90% (phytase added, 4000 units kg⁻¹ diet) or 93% (predigested with phytase, 200 units kg⁻¹ soybean meal). In high-ash diets, dietary acidification with citric acid decreased the effect of phytase, whereas in low-ash diets, acidification markedly increased the effect of the enzyme. Excretion of phosphorus in the faeces of fish fed a low-ash diet containing phytase-treated soybean meal was 0.32 g per kg diet consumed, a 95%−98% reduction compared with phosphorus excretion by fish consuming commercial trout feeds.     

Replacement of fishmeal with commercial soybean meal and EnzoMeal in juvenile barramundi Lates calcarifer

This study investigates the impact of fishmeal replacement by soybean meal (SM) and improved SM known as EnzoMeal (EZ) on fish growth performance. The SM and EZ were used in five experimental diets: fishmeal (600 g/kg) as the control diet, 50% fishmeal replaced with soybean meal (SM50), 50% fishmeal replaced with EnzoMeal (EZ50), 100% fishmeal replaced with soybean meal (SM100) and 100% fishmeal replaced with EnzoMeal (EZ100). Fish in the control group gained the most weight, followed by those under the SM50 and EZ50 diets, while the least weight gain was observed in fish fed the SM100 and EZ100 diets. The specific growth rate (SGR) was higher in the control, but was not different between fish fed SM50 and EZ50, or between SM100 and EZ100. The highest feed intake occurred in the control but decreased sequentially from fish fed SM50 to fish fed EZ50, EZ100 and SM100. Protein digestibility was best in SM50, poorest in EZ100, but no difference between the control, EZ50 and SM100 diets. This study indicates that EnzoMeal, containing high crude protein (56%), is a potential source of plant meal to replace fishmeal in the barramundi diet, but low feed intake is a challenge when EnzoMeal is >300 g/kg.     

Growth, feed efficiency, digestibility and nutrient distribution in Atlantic cod (Gadus morhua) fed two different fish meal qualities at three dietary levels of vegetable protein sources

Atlantic cod were fed six diets where the ratio of protein from fish meal to vegetable protein were varied from 91%, 67% to 46%, respectively. The experimental groups were performed in triplicate in a 20 week growth trial, increasing fish weight from about 167 g to 690 g. The vegetable protein sources constituted full-fat soybean meal and corn gluten meal at a fixed ratio of 1:2, and replaced either a high quality fish meal (DC_Mink 92.3%) or a lower quality fish meal (DC_Mink 85.6%) in the diet. All diets were extruded and balanced to be equal in gross energy, crude protein, lipid, carbohydrate, lysine and phosphorus. No difference in growth (SGR 1%) was observed comparing the two fish meal qualities. However, feed intake was significantly higher (9%) and feed efficiency lower (10%) for lower quality fish meal compared to high quality fish meal. Protein and amino acid digestibility was significantly reduced in the lower quality fish meal, while unaffected by vegetable protein inclusion for both fish meal qualities. Protein utilization as measured by protein efficiency ratio and net protein value was not affected by fish meal inclusion, except in the diet using lower quality fish meal and high vegetable protein inclusion. Lipid and energy digestibility was significantly reduced by vegetable protein inclusion for both fish meals. The lower fish meal quality increased lipid deposition in the liver and affected slaughter quality of cod by increasing HSI and dressing out percentage at low and intermediate substitution levels. Muscle composition showed small dietary changes except for arginine, while liver fatty acid composition clearly reflected fatty acid profile of full-fat soya in the diets. Corn gluten meal and full-fat soybean meal (2:1) can replace approximately 50% of dietary protein without affecting feed intake, growth, protein digestibility or slaughter quality of cod when exchanging high quality fish meal. For the lower quality fish meal diets some lower inclusion of vegetable protein sources seem to be acceptable.     

Effect of replacing soybean meal with yeast‐fermented canola meal on growth and nutrient retention of Nile tilapia,Oreochromis niloticus (Linnaeus 1758)

Yeast fermentation integrated with water soaking was applied as a method to reduce the levels of some anti‐nutritional factors in canola meal. The procedure completely eliminated glucosinolates and it reduced phytic acid content by 18%. It also led to increase of 9% of crude protein and 8–32% of some minerals in the meal. A 60‐day feeding trial was conducted to evaluate replacement of dietary soybean meal protein with yeast‐fermented canola meal for Nile tilapia at ratios of 0, 25, 50, 75 and 100% respectively. Three groups of fish with an initial weight of 10 g were fed with each diet twice a day to an apparent satiation. The results showed that there were non‐significant differences (P > 0.05) in growth, survival rate, feed intake and feed conversion ratio for all fish fed with the test diets. However, replacement with 75 and 100% levels significantly reduced (P < 0.05) protein efficiency ratio and nutrient digestibility of protein, lipid, ash, Ca, Mg and P of fish compared with the lower levels. The low retention of protein, lipid, ash, Ca, Mg and P were also observed. These effects seemed to be related to an increased dietary phytic acid.