首页 | 本学科首页   官方微博 | 高级检索  
     检索      

细颗粒泥沙对离心泵工作特性影响的数值研究
引用本文:王开继,潘永琛,郑俊,李昌烽,KIM Kyoungyoun.细颗粒泥沙对离心泵工作特性影响的数值研究[J].中国农村水利水电,2013,0(5):129-132.
作者姓名:王开继  潘永琛  郑俊  李昌烽  KIM Kyoungyoun
作者单位:1.江苏大学 能源与动力工程学院,江苏 镇江 2.Department of Mechanical Engineering, Hanbat National University, Daejeon, 305-179, South Korea
基金项目:国家自然科学基金资助项目,教育部科学技术研究重点项目
摘    要:基于Eulerian-Eulerian“双流体”模型观点,应用CFD软件 Fluent 对离心泵细颗粒泥沙固液两相流进行了数值模拟。给出了在微米量级尺度上不同粒径及10%颗粒体积浓度以内条件下离心泵固液两相流动规律,得到了相应的离心泵的外特性的变化规律并与清水单相流情形进行了对比。研究结果表明:在叶轮流道内,固相体积浓度分布极不均匀,细颗粒主要集中于流道出口处及叶轮吸力面。在所研究的工况条件下,与清水情况相比,加入某些浓度、粒径的细颗粒离心泵内的湍流粘度,湍动能都有所下降,并且分布规律与颗粒的分布相似,离心泵的扬程与效率有所提高。相同体积流量下,离心泵的扬程和效率在所研究的工况条件下随颗粒浓度和粒径的增加先增大后减小。

关 键 词:离心泵  细颗粒  固液两相流  湍流  数值模拟
收稿时间:2012-12-03
修稿时间:2012-12-31

A Numerical Study of the Impact of Fine Sand-particles on Centrifugal Pump Working Characteristics
Abstract:In order to study the turbulence modulation mechanism due to the fine sand-particles in pump, three-dimensional simulations were performed for the dispersed solid-liquid two-phase turbulent flow in a centrifugal pump by using Fluent CFD software based on Eulerian- Eulerian two-fluid model. The solid-liquid two-phase turbulent flow fields in pump had been simulated for the fine sand- particles of micron-size with the volume fraction less than 10%. The two-phase calculation results were compared with those only with single phase, i.e. clean water. It is concluded that: in impeller channels, the volume fraction contour is extremely non-uniform, showing that solid particles mainly accumulate on the suction side of each impeller. With regards to the working conditions in the study, after certain fine sand-particles with certain volume fraction are added, while having the similar distribution of solid particles the turbulent viscosity and turbulent kinetic energy all decrease comparing with the clean water single-phase flow, and the head and efficiency of pump are improved. For the simulated cases, the head and efficiency of pump both first increase, then decrease with the increase of fine sand-particle size and volume fraction.
Keywords:
本文献已被 万方数据 等数据库收录!
点击此处可从《中国农村水利水电》浏览原始摘要信息
点击此处可从《中国农村水利水电》下载免费的PDF全文
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号