菠萝蜜种子淀粉制备香草兰微胶囊的工艺研究

以菠萝蜜种子淀粉为壁材,采用饱和水溶液法制备香草兰精油微胶囊,以包埋产率为指标,采用响应面分析法对微胶囊的包埋条件进行优化探讨。结果表明:5个单因素中,影响最显著的因素为壁芯材比例、包埋温度和包埋时间。响应面优化得到香草兰精油微胶囊的最佳工艺条件为壁芯材比例为7.5∶1;包埋时间72 min;包埋温度54℃,此条件下的包埋产率为(95.46±0.2)%,包埋率为(76.35±0.6)%,载油量为(27.73±0.3)%。试验证明,此条件结果与模型预测值相吻合,此工艺条件可为菠萝蜜种子淀粉包埋香草兰精油微胶囊工艺提供理论依据。     

Replacement of fish oil in plant‐based diets for Pacific white shrimp,Litopenaeus vannamei,by stearine fish oil and palm oil

Stearine fish oil (SFO) and palm oil (PO) have emerged as promising alternatives for the replacement of fish oil (FO) in aquafeeds. This study evaluated the replacement of FO with alternative oils in practical diets for Litopenaeus vannamei. In a clear brackish water study (14.1 g/L) utilizing shrimp (0.29 ± 0.02 g, initial weight), FO was replaced by SFO at inclusion ratios of 100:0, 75:25, 50:50, 25:75, and 0:100 (FO:SFO) and PO as 90% of FO. After 55 days, no significant differences (p < 0.05) in final weight, growth, or survival of shrimp were observed. A second trial (8 weeks) in low‐salinity water (2.1 g/L) with shrimp (0.92 ± 0.02 g, initial weight) evaluated diets with 100% FO, 100% SFO, 90% PO, 90% soybean oil (SO), or 90% flaxseed oil (FXO) as a replacement for FO and four commercially produced diets with 2% of FO, SO, PO, or FXO. One treatment received half rations of the commercial FO diet, and one treatment was based entirely on natural productivity. Results show that the fatty acid profiles of the tail muscle conformed to the lipids of the feed, and highly unsaturated fatty acids (HUFAs) were preserved. Following 8 weeks of culture, there were no significant differences in production performance.     

品种间大豆脂肪氧化酶活性差异及β-胡萝卜素漂白性研究

为了解东北地区大豆品种间大豆脂肪氧化酶(LOX)活性差异规律,整理适于东北地区种植的大豆种质资源307份(6份半野生品种,17份地方品种及4份国外品种,其余为栽培品种),统一种植,秋季收获后,测定各品种成熟籽粒脂肪氧化酶总活性。分析品种间脂肪氧化酶总活性分布规律、大豆脂肪氧化酶总活性与β-胡萝卜素漂白性之间关系。结果表明,307份大豆品种间脂肪氧化酶总活性差异极显著,平均值为21.68 U·mL~(-1),最小值为2.51 U·mL~(-1),最大值为42.38 U·mL~(-1)。根据脂肪氧化酶总活性差异,通过聚类分析将307份大豆品种分为3类。低活性品种占总量43.65%,脂肪氧化酶总活性平均值为15.25 U·mL~(-1);中等活性品种占总量43.97%,脂肪氧化酶活性平均值为24.64 U·mL~(-1);高活性品种占总量12.38%,脂肪氧化酶总活性平均值为33.87 U·mL~(-1)。脂肪氧化酶总活性与油分含量呈正相关,与蛋白含量呈负相关,与漂白性呈正相关。     

Engineered-airlift pumps for aquaculture applications using multiphase flow analysis

Currently, very few aquaculture operations are employing airlift pump technology for water recirculation, aeration, and waste removal. This is likely due to the poor design and lower efficiency of traditional airlift design, the limited amount of research effort that has been invested in improving performance capabilities of air lift pumps and the general lack of awareness of the industry about the inherent advantages of airlift systems. A new efficient airlift pump is hydrodynamically designed by incorporating the Volume of Fluid (VOF) multi-phase model along with the K-ε turbulence model utilizing Computational Fluid Dynamics (CFD) tools. The pump is designed to offer a substantial reduction in total energy usage as well as an improved quality of the culture products in order to make it attractive to aquaculture industry. In this study, both numerical and experimental investigations were carried out for airlift systems operating under two different submergence ratios of 50% and 90% in a lab setting using 2.54 cm diameter pumps. Also, the performance of a large-scale pumps of 10.16 cm diameters were also tested in an aquaculture raceway to determine its effect on the operation. The numerical results were found to be in agreement with the experiments within ±20% which is considered very reasonable for multiphase flow analysis. The present study was found to present a great tool for modelling the airlift pump performance, and potentially proposing new designs.     

含刚性沉水植物明渠水流结构的试验研究

【目的】得到含刚性沉水植物明渠的水流结构。【方法】采用粒子图像测速仪(PIV),用有机玻璃棒模拟刚性植物,在不同来水流量、植物密度条件下对明渠水流结构进行了试验研究。【结果】无植物时平均流速沿垂向呈对数分布规律,有植物时则呈现明显的分区分布特性。无植物时紊动强度值沿垂向变化不大,有植物时在植物顶端位置处紊动最剧烈。流量或植物密度越大,植物顶端位置的流速梯度就越大,植物层上方的流速最大值也越大。植物密度越大,植物顶端位置的紊动强度越大,植物密度对水流紊动强度由最大值减小到最小值的区域影响很大。【结论】刚性沉水植物的存在会改变水流结构,增强紊动掺混,增强流体质点交换和能量传递,且上述影响会随着流量或植物密度的增大而增强。     

原油管道改输天然气前的清管实践

为保证原油管道改输天然气后的输气质量和运行安全,必须在管道输气前实施清管。介绍了新疆塔河油田四、六区块4-1计转站至1号联合站原来的原油集输管道改输天然气前的清管方案和清管步骤,分析了其清管效果,指出利用经清管检测达标后的原油管道改输天然气与再建输气管道相比,不仅施工周期短,工艺操作简单,而且还可节约大量的建设资金。     

有摩擦的高速气体管流

本文以多变热力过程为基础建立了有摩擦管路的计算公式,并对计算方法和有关问题作了分析说明.     

Reproduction in three species of rainbowfish (Melanotaeniidae) from rainforest streams in northern Queensland, Australia

Abstract – The reproductive biology of three species of rainbowfish (Melanotaeniidae) in northeastern Australian rainforest streams was investigated. Two species, Melanotaenia eachamensis and Cairnsichthys rhombosomoides are endemic to the area, whereas the third, M. splendida splendida, is more widespread. The species were all highly fecund, producing many hundreds of eggs between 1.10 and 1.24 mm in diameter. Melanotaenia eachamensis was the most fecund, produced the largest eggs of the three species, and consequently exhibited the greatest maternal investment (as measured by gonadosomatic index). The majority of reproductive effort occurred during the dry season, although reproductively active fish were present year-round for each of the species, but particularly so for M. s. splendida and C. rhombosomoides. No evidence for a role by temperature or photoperiod as environmental cues for reproduction was found, and it was suggested that gonad development was strongly tied to somatic growth. The concentration of reproduction to the dry season ensures that larvae are produced during a period of relatively stable and benign physical conditions. Comparison of temporal changes in gonadosomatic index values suggest that the spawning season of M. eachamensis , which occurs in high-elevation streams, is more restricted and commences about 1 month earlier than either other species. A similar phenology was observed for the M. s. splendida population found at high elevation and highlights the potential for spatial differences in stream productivity to influence life history. ^Note     

高压无气喷涂工艺在大型储罐上的应用

分析了大型储罐传统防腐涂装方式的特点,指出了采用新型涂装方式的必要性,介绍了高压无气喷涂工艺的预处理、实施及注意事项,分析了高压无气喷涂工艺的实施效果,提出了储罐防腐的建议.     

高压全膜电力电容器用新浸渍剂苄基甲苯的研究

进行了由氯化苄与甲苯合成苄基甲苯的工艺研究,筛选了精制方法.合成和精制后的油品,检测了理化电性能,作成模型电容器进行各种试验,表明该绝缘油具有优异的性能.