基于离散元法的茶叶抖筛机结构参数优化与试验

茶叶抖筛机是茶叶精加工的关键装备,传统抖筛装备主要通过经验设计,筛分性能较差,主要表现在筛净率较低、误筛率较高。该研究结合抖筛机的筛分原理,运用solidworks构建虚拟样机,利用EDEM软件建立茶叶颗粒离散元仿真模型,通过单因素仿真试验对茶叶颗粒进行动力学分析,结果表明,连杆长度、曲柄半径和筛面倾角是茶叶抖筛机筛分性能的主要影响因素。以筛净率、误筛率为评价指标,设计三因素三水平二次旋转正交试验,并运用Design-Expert软件对试验数据进行回归分析,当连杆长度为1 977 mm、曲柄半径为25 mm、筛面倾角为2.8 °时,茶叶筛净率为94.5%、误筛率为4.61%,筛分性能最优。以最优结构参数进行验证试验,筛净率为93.8%,误筛率为4.73%,生产效率为319kg/h,较优化前筛净率提高3.42%,误筛率降低7.62%,生产效率提高8.87%。该研究结果可为茶叶筛分装备的优化提供理论依据。     

Effect of nitrogen application during ripening period on photosynthesis and dry matter production and its impact on yield and yield components of semidwarf iniica rice varieties under water culture conditions

Abstract

A water culture pot experiment was conducted to analyze the effects of N application during the ripening period (RP) on photosynthesis, dry matter production, and its impact on grain ripening and yield in two semidwarf indica type varieties viz. Gui Zhao 2 (GZ) and BR3 (BR) compared with a japonica type variety Koganemasari (KO) under four N rates viz. 0 (N₀), 10 (N₁₀), 20 (N₂₀), and 40 (N₄₀) mg L^?1. Results showed that N application enabled to maintain a higher leaf area and delay leaf senescence in both indica and japonica type varieties but the decrease in the rate, of leaf area was higher in the former than in the latter and the rate was reduced with increasing N rates. Flag leaf photosynthesis and SPAD values of N treated plants were higher throughout the RP, showing the presence of a significant correlation either for each variety or all the varieties together. Higher photosynthetic rate was supported by higher leaf chlorophyll (SPAD value basis) content, stomatai conductance, and N concentration in leaf blades. Top dry matter content increased with increasing N rates mainly due to mean leaf area rather than NAR except for BR during RP but it was higher in KO than in GZ and BR. Reduction of shoot weight due to translocation of dry matter to panicles during RP was suppressed by N rates both in GZ and BR while shoot weight increased in the N-treated plants in KO. The dependency of KO on current photosynthates for panicle weight was found to be almost hundred percent while the contribution of stored carbohydrates in shoot before heading to panicle weight in GZ and BR was in the range of 4-27 and 33-54%, respectively and the rest was contributed by current photosynthates. The percentage increased with increasing N rates. Percentage of ripened grains (PRG) increased with increasing N rates in GZ and BR due to the increase in dry matter production and in the photosynthetic rates of apex leaves, despite the larger spikelet number and larger hull size. However, KO showed almost no variation although it had the highest PRG among the varieties. Brown rice yield followed the same pattern as that of PRG in GZ and BR and the highest yield was produced by BR followed by GZ and KO. These results suggest that N application during RP was more effective in increasing yield in the semidwarf indica type varieties than in the japonica type variety.     

辽西北霜期气候变化及气象服务对策

为了霜期设施农业充分利用气候资源适应气候变化,规避气象灾害风险,利用辽宁西北部气象资料分析霜期气候资源变化,并探讨霜期设施农业气象服务对策。结果表明：辽西北地区霜期气温升高而不稳,极端最低气温天气更显突出,霜期降雪增加,阴天日数增加,日照时间减少,太阳总辐射减弱,大风强度增加,霜期极端天气现象对霜期设施农业影响显著。霜期设施农业气象服务势在必行,为了推动霜期设施农业的发展,应从设施农业工程、环境控制、利用气候资源节约能源、适应气候变化等方面入手,建立评估、监测、预警气象服务一体化服务系统,通过网络平台,搭建专业化、动态化、多元化、精细化的霜期设施农业气象服务预警平台,提高防灾减灾能力,确保霜期设施农业可持续发展。     

Production of Interesting Peptide Fractions by Enzymatic Hydrolysis of Tuna Dark Muscle By-Product Using Alcalase

ABSTRACT

A protein hydrolysate was prepared from proteins of tuna dark muscle by-product. The hydrolysis conditions (time, temperature, pH, and enzyme concentration) using Alcalase was optimized by response surface methodology (RSM). The regression coefficient close to 1.0, observed during experimental and validation runs, indicated the validity of the model. The hydrolysate produced under the optimum conditions determined by RSM has a low rate of peptide fraction of molecular weight of 4–1 kDa. Meanwhile, the results obtained by hydrolysis under optimal conditions determined by a complementary study (temperature 55°C, time 60 min, 1% enzyme concentration, and pH 8.5) show that the hydrolysate produced has a height rate of the peptide fraction of molecular weight of 4–1 kDa. The amino acid composition of the protein hydrolysate prepared proved to have the potential for application as an ingredient in balanced fish diets and as a source of nitrogen in microbial growth media.     

Assessment of gut microbiota in different developmental stages of Malaysian Mahseer (Tor tambroides)

Malaysian Mahseer (Tor tambroides) has a good prospect for aquaculture because of its high market demand. However, there is a scarce information on gut microbiota associated with Malaysian Mahseer unlike other fish species. Therefore, we constructed and compared gut microbiota in different developmental stages (larval, juvenile, fingerling, yearling, and adult) using culture dependent and PCR‐DGGE fingerprinting technique for better understanding of gut microbiota composition associated with T. tambroides. Culturable gut microbiota composition in all developmental stages were composed of β‐ and γ‐Proteobacteria, and Bacilli. Biodiversity analysis of culturable gut microbiota showed that larval, juvenile, and adult stages have higher diversity than fingerling and yearling stages. Ward's linkage cluster analysis showed that culturable gut microbiota composition in larval and juvenile stages were close to adult stages, whereas fingerling and yearling stage composed same cluster. PCR‐DGGE fingerprinting technique showed that unculturable gut microbiota were constituted by α‐and γ‐Proteobacteria, and Actinobacteria. Ward's linkage cluster analysis showed that unculturable gut microbiota composition in both larval and juvenile stages were distinct from other developmental stages. Our results revealed that gut microbiota composition were varied in different developmental stages of Malaysian Mahseer and continuous shifts of gut microbiota from larval to adult stages.     

Comparison of effectiveness of introduced barn owls,Tyto javanica javanica,and rodenticide treatments on rat control in oil palm plantations

Journal of Pest Science - In Peninsular Malaysia, barn owls (Tyto javanica javanica) have been utilized as biological control of rats since the 1960s. In this study, the impact of introduced barn...     

Electrically conductive paper of polyaniline modified pineapple leaf fiber

This research work reports new electrically conductive paper made of pineapple leaf fiber and polyaniline (PALF/PANI). The conductive paper shows remarkable preservation of mechanical properties while achieving its conductive state. Also it was found that, the amount of PANI needed to achieve the conductivity transformation is as low as 5 wt.%.     

The origin of mangosteen: A review

Genetic Resources and Crop Evolution - Mangosteen (Garcinia mangostana var. mangostana) is an obligate apomictic species which does not require a fertilization process to produce seeds. The absence...     

Effects of fishing practice changes on pelagic shark longline captures in the Gulf of Gabes,Tunisia

1. In order to increase their catches, longliners targeting sharks in the Gulf of Gabes, Tunisia, have increased the number of hooks per basket and have included new bait types instead of mackerel (Scomber scombrus). This paper reports the effects of these changes on catch composition, catch rates, size distribution, life‐stage captures, and mortality at haulback.
2. Data from 48 and 96 longline sets, carried out during the shark fishing seasons of 2007 and 2008, with two hooks per basket, and 2016 and 2017, with five hooks per basket, respectively, were examined to assess the effect of gear change. Moreover, the effects of bait types were inspected based on 33 fishing sets using whole mackerel, 19 using salema (Sarpa salpa) halves, and 27 using pieces of stingray (Dasyatis spp.), sampled during 2016 and 2017.
3. The species composition indicated that longliners expand the vertical distribution of their hooks to operate from the surface to the bottom. The catches with both longline designs were dominated by sandbar shark (Carcharhinus plumbeus). Despite gear changes, the catch rate of C. plumbeus decreased by 42.21%, suggesting population decline. The size composition indicated a shift towards larger specimens, mainly adult females, which could jeopardize the shark population. Moreover, the mortality of the main species at haulback seems to be affected by the design of the longline.
4. The bait used, mainly pieces of stingray, significantly increased the catch rate of sandbar shark, which suggests a greater attractiveness of the new bait; however, fish size and mortality rates at haulback were unchanged in response to bait variation.
5. The fishery operates in shark nursery grounds, which exposes these fish (principally C. plumbeus) to considerable exploitation pressure. The new fishing practices intensified the pressure and thus the risk of a rapid depletion of populations. To preserve the shark species in the area, the use of new gear and attractive bait should be banned.

     

Are circle hooks effective management measures in the pelagic longline fishery for sharks in the Gulf of Gabès?

1. This study evaluated the circle hook use as a tool for shark management in the pelagic longline fishery in the Gulf of Gabès.
2. The usual J‐hook No. 2 with 10° offset, which has been traditionally used by the fishery, was compared to the 18/0 non‐offset circle hook in an alternating fashion along the main line. In total, 22 experimental longline sets were deployed through the shark fishing seasons of 2016 and 2017 to examine the effects of hook types on the catch composition, the catch rates, the hooking location, and the status at haulback.
3. The catch composition differed significantly among hook types. Moreover, an overall increase in catch rates for the main species, the sandbar shark Carcharhinus plumbeus, and the shortfin mako shark Isurus oxyrinchus, was observed when using circle hooks.
4. There was no size‐selective effect of circle hooks for the common species. The circle hooks were not effective at reducing at‐haulback mortality of sandbar shark. Conversely, shortfin mako and smooth‐hound shark Mustelus mustelus showed significantly lower relative mortality at haulback with circle hooks than with J‐hooks. Furthermore, circle hooks were more frequently hooked externally than the J‐hooks for the three shark species.
5. Results demonstrated that the use of 18/0 non‐offset circle hooks in the pelagic shark longline fishery can reduce mortality at haulback for some species without any benefit for the dominant species, the sandbar shark.
6. Overall, it is difficult to promote the adoption of the use of circle hooks as a management measure in this specialized fishery. Management measures focusing on fishing effort controls, fishing closures in critical habitats, and size limits could have significant benefits for the conservation of shark species and may help to improve the sustainability of the shark fishery in the Gulf of Gabès.