MB22木聚糖酶发酵条件的研究

通过因素轮换试验和正交试验,对MB22菌产木聚糖酶的培养基配方和发酵条件进行了研究。结果显示最佳培养基组成是:以玉米芯粉和麸皮为碳源,麸皮120g/l,玉米芯280g/l,(NH4)2SO44g/l,CaCO31.5g/l,Tween80,2.0g/l,MgSO4·7H2O1.5g/l;最佳发酵条件为:起始pH5.0,摇床培养温度30℃,转速160r/min,振荡培养84h。在最佳发酵条件下,MB22菌的最高产酶活力可达898.23U/ml。虽然与一些高产菌株相比该菌株的产酶能力还有待于进一步提高,但该试验结果为进一步进行微生物生产木聚糖酶的研究提供了理论依据。     

漏缝地板发酵床对育肥羊养殖气体排放的影响及微生物学机理

为明确漏缝地板发酵床对育肥羊养殖过程氨(NH₃)和温室气体排放特征的影响机制,本研究设置地面和漏缝地板发酵床两个试验处理,测定分析了育肥羊养殖过程NH₃、氧化亚氮(N₂O)、二氧化碳(CO₂)和甲烷(CH₄)的排放特征,并采用宏基因组学解析了影响上述气体排放的微生物学机理。试验结果表明,与地面相比,漏缝地板发酵床能够显著降低育肥羊养殖过程的NH₃排放(P<0.05),其NH₃排放速率为21.64～58.92 mg·m^-2·h^-1,NH₃累积排放量为86.36±1.06 g·m^-2,减排率达58.60%。漏缝地板发酵床同样也能显著降低育肥羊养殖过程的CH₄排放速率(P<0.05),其CH₄累积排放量为26.66 g·m^-2,减排率可达64.42%。然而,漏缝地板发酵床会使得...     

越红工夫茶加工技术及品牌建设研究

本文阐明了越红工夫茶的历史背景和现状,提出了越红工夫茶鲜叶、萎凋、揉捻、发酵、干燥等初制加工工序的操作方法和技术要求,以规范越红工夫茶加工技术,保持品质特征,稳定产品质量。同时,阐述了对越红工夫茶品牌建设的研究。     

纳豆激酶液体发酵条件的优化

利用单因素及正交试验,对纳豆枯草芽孢杆菌(Bacillus subtilis natto)液体发酵生产纳豆激酶(Nattokinase,NK)的培养基组成(碳氮比和离子组成)和培养条件(温度、pH值、发酵时间、接种量和装液量等)对产酶量的影响进行了研究。结果表明,最佳发酵培养基组成及发酵条件分别为:可溶性淀粉2.0%,大豆蛋白胨1.5%,Na2HPO4·12H2O0.4%,KH2PO40.2%,MgSO4·7H2O0.075%,CaCl20.01%,培养温度37℃,pH值7.0,发酵时间24h,转速180r/min,种龄16h,接种量3%,装液量25mL/250mL。在优化发酵条件基础上,进行了5,20L发酵工艺放大的初步研究,在此条件下,摇瓶,5L罐和20L罐发酵酶活最高分别达到915,1086,946IU/mL。     

基于超星学习通的混合式教学模式应用研究—— 以发酵工程课程为例

为了提高发酵工程课程的教学质量和教学效果,针对发酵工程课程的内容和特点,将互联网+技术与教学相结合,进行了基于超星学习通平台的混合式线上线下教学方式的改革,结果表明:在增强了学生自主学习能力的同时,也促进了教师的自我提升.     

Influence of storage time and processing on chemical composition and in vitro ruminal fermentation of olive cake

Olive oil extraction generates olive cake (OC) that could be used in ruminant feeding. However, the chemical composition of OC is affected by multiple factors, being therefore highly variable. The objective of this study was to analyse the influence of storage time and further processing: crude, exhausted (subjected to a second oil extraction) and cyclone (obtained from a cyclone separator) on nutritive value of OC samples. Twelve samples (six crude and six exhausted) were obtained monthly from the same pond from 1 to 6 storage months, and nine samples (three crude, three exhausted and three cyclone) were obtained monthly from a different pond from 6 to 9 months storage. Chemical composition was analysed, and OC samples were fermented in vitro with sheep rumen fluid. Increasing storage time up to 6 months decreased sugars and total soluble polyphenols content but increased fibre content in OC. Dry matter effective degradability (DMED) decreased linearly (p < 0.001) by 35.9 and 45.5% as storage time augmented from 1 to 6 months for crude and exhausted OC, respectively. Crude OC had lower DMED values than exhausted OC (averaged values 0.255 and 0.294 g/g, respectively). Both potential production and rate of gas production were lower (p ≤ 0.018) in crude compared with exhausted OC, which was attributed to the high fat content of crude OC (≥86 g/kg dry matter). For samples stored longer than 6 months, cyclone had greater (p < 0.05) DMED than crude and exhausted OC (averaged values 0.207, 0.164 and 0.164 g/g, respectively). The results indicate that ruminal degradability of OC is reduced with advancing storage time, but only subtle changes were observed during the first two months. Cyclone showed greater degradability than crude and exhausted OC, but differences between crude and exhausted OC became negligible after five storage months.     

Dietary replacement of fish meal by defatted and fermented soybean meals with taurine supplementation for pompano fish: effects on growth performance,nutrient digestibility,and biological parameters in a long-term feeding period

A 16-wk growth trial was conducted to examine the effects of dietary replacement of fish meal by defatted soybean meal (SBM) and fermented soybean meal (FSBM) with taurine supplementation on growth performance, nutrient apparent digestibility coefficient (ADC) and biological parameters of pompano fish. The FSBM was produced by fermenting SBM with Lactobacillus spp. Seven isonitrogenous and isoenergetic diets were formulated to replace 35% or 50% of fish meal by SBM or FSBM with taurine supplementation. The diets are denoted as follows: FM, SBM35, SBM35T, FSBM35T, SBM50, SBM50T, and FSBM50T. The FM (the basal diet) contained fish meal as a main source of dietary protein. Taurine was supplemented to SBM35T, FSBM35T, SBM50T, and FSBM50T at the level of 15 g/kg diet. Pompano juveniles with an initial body weight (BW) of 80 g reared in floating net cages were fed the experimental diets twice daily for 16 wk. Results showed that the final BW, weight gain, and feed conversion ratio of fish fed SBM35 and SBM50 were significantly lower than those of fish fed FM (P < 0.05), indicating that the replacement of fish meal by SBM at the rate of 35% in the diet is excessive for pompano. Supplementation of taurine to the SBM-included diets significantly increased growth performance and feed utilization (P < 0.05); however, these diets did not restore the performance back to a level equivalent to that of fish offered the basal diet. Meanwhile, fish fed FSBM35T had comparable growth and feed performances to those fed FM. Hematocrit values, total biliary bile acid levels, whole body lipid contents, and tissue taurine concentrations of fish fed SBM35 and SBM50 were the lowest among the treatments, but these parameters were improved by taurine supplementation and FSBM inclusion in the diet. Taurine supplementation increased lipid ADC, and SBM fermentation slightly enhanced both lipid and protein ADCs of the fish. These findings suggest that the combination of FSBM and taurine supplementation is an effective way to improve growth performance, nutrient digestibility, and biological parameters, and that FSBM with taurine supplementation can replace 35% of fish meal in pompano diets without any negative effects on growth and feed performances in a long-term feeding period.     

添加亚油酸条件下不同剂量硝酸钠对水牛瘤胃体外发酵脂肪酸组成及相关微生物数量的影响

为了探究添加亚油酸条件下不同剂量硝酸钠对水牛瘤胃体外发酵脂肪酸组成及相关微生物数量的影响,本试验选用3头装有永久性瘤胃瘘管的母水牛,以精粗比40:60为底物进行瘤胃液体外发酵试验.试验组硝酸钠的浓度分别为1、2、3 mg·mL-1,对照组不加硝酸钠,每组均添加0.25 mg·mL-1的亚油酸,每组各5个重复.在体外培养...     

菠萝皮发醇生产饲料蛋白的工艺条件研究

菠萝皮是菠萝加工产生的副产物,为了将菠萝加工企业废弃的菠萝皮有效利用,实现资源的再生,缓解目前蛋白饲料的不足,进行了本研究.结果表明,采用绿色木霉和产朊假丝酵母混合菌种发酵,添加麸皮20%、硫酸铵3%、尿素2%,料水比11,自然pH值,30℃发酵5 d,发酵后的饲料粗蛋白含量提高到25.38%,经水洗后的粗蛋白含量提高到17.03%,检测的16种氨基酸含量均有很大幅度的提高,其总和从2.89%提高到15.6%,提高率达到439.8%.产品气味芳香,适口性大为改善,可用做牛、羊和鱼等养殖的低蛋白能量饲料.     

The effects of potato pulp and feeding level of supplements on digestibility, in situ forage degradation and ruminal fermentation in beef steers

Six ruminally cannulated Wagyu (Japanese Black) steers (average initial bodyweight (BW) 387 ± 29 kg) were used in a split‐plot design experiment, comprising a 3 × 3 Latin square design (whole plot) and a randomized block design (subplot). The whole plot treatments were three different feeding levels of supplemental diet, fed at 0.2, 0.4 and 0.6% of BW, on a dry matter (DM) basis. Subplot treatments were two different supplemental diets: a potato pulp silage‐based diet (PPS) and a grain‐based diet (GRAIN). Chopped, medium‐quality cool‐season grass hay (predominately Timothy, Phleum pratense L) was fed daily at 0.7% BW (on a DM basis) as the basal diet. Each period consisted of 21 d, which included 11 d of adaptation to the diets and 10 d of the collection period. Chromium oxide was used as an indigestible marker. In situ forage degradation was measured using the nylon bag technique. The dry matter intake increased (linear; P < 0.01) as the feeding level increased and was not affected by the diet. Digestibility was not affected by any treatments. The GRAIN diet tended to decrease the rate of in situ forage degradation as the feeding level increased, but this trend was not found in the steers fed the PPS diet. Steers fed the GRAIN diet had a lower (P < 0.1) ruminal pH compared with steers fed the PPS diet. Ruminal pH was not significantly affected by feeding level; however, it was numerically higher for steers supplemented at 0.2% per BW than that for the steers supplemented above 0.4% per BW due probably to the higher starch intake. The total volatile fatty acids concentration numerically increased as the feeding level increased and was not affected by the diet. Increasing the feeding level decreased (linear, P < 0.01) the proportion of acetate. Neither diet nor the feeding level had any effects on the proportion of ruminal propionate. The results suggested that, for steers fed the PPS diet, there are not adverse effects on forage digestion in the rumen that occur as the feeding level is increased.