木粉加入量对木／塑复合材料性能影响的研究

研究了聚丙烯与木粉以不同比率复合而成的材料的物理力学性能和复合形态特征。结果表明：不同混合比率的聚丙烯与木粉进行复合后所得的复合材料，除冲击强度有所降低外，其它力学性能均比纯聚丙烯的有较大幅度的提高。木粉表面的酯化处理可以改善木塑界面之间的相容性和复合材料的均匀性。在木塑复合过程中木塑之间发生镶嵌现象使木塑之间产生物理结合。     

余甘子精粉的体外抗氧化活性分析

The antioxidant activities in vitro of refined powder of Phyllanthus emblica L. were detected by methods based on chemical measurement and cell modeling. The results of anti-peroxidation ability and iron reduction ability trials showed that the refined powder of P. emblica L. had strong ability of anti-peroxidation, and it increased with the increasing of concentration with a clear dose-response relationship. When the concentration reached 800 μg·mL^-1, the ability of anti-peroxidation was almost equal to the positive control VC with the same concentration. Meanwhile, it also had iron reduction ability that accompanied by significant dose-response relationship. By in vitro cell culture method, H₂O₂ was used to induce SH-SY5Y cells damages to establish the cell model of oxidative damage. The author detected the effect of different concentrations of powder on cell survival rate for the model cells by MTT assay. The results indicated that refined powder could show better protective effect to oxidative damaged SH-SY5Y cells in the range of 600 1 200 μg·mL^-1. When the concentration reached 1 200 μg·mL^-1, the cell survival rate was the highest and refined powder exhibited the best antioxidant activity. Both methods proved the strong antioxidant activities of refined powder of P. emblica L. in vitro.     

杉木木粉羧甲基化产物及其高吸水树脂特性的研究

研究了杉木(Cunninghamia laceolata)木粉不同粒度对羧甲基取代度及丙烯酸接枝高吸水树脂吸水率的影响规律。结果表明,100目和200目木粉与40目木粉X射线衍射峰没有区别,表明100目和200目木粉纤维结晶没有被破坏,木粉粒度对羧甲基取代度的影响不大;100目和200目木粉直接接枝丙烯酸聚合物吸水倍率明显降低,表明木粉颗粒逐渐变小,木粉原有的空间结构被破坏,不足以形成网络结构;红外光谱分析表明,杉木木粉羧甲基化后,纤维素和半纤维素中引进了大量的羧甲基,且保留了木质素特征峰,但在丙烯酸接枝的高吸水树脂中木质素吸收特征峰不存在,说明过硫酸钾引发剂产生的自由基优先与木质素苯环反应,使木质素苯环开裂,导致木质素苯环的吸收特征峰消失。     

膳食纤维杂粮面包的研制

本试验以绿豆皮粉、黄豆皮粉、红薯皮粉、高筋面粉为主要原料,采用二次发酵法研制膳食纤维杂粮面包,通过口感和外观考察了配方和烘培时间对其风味品质的影响。结果表明,对杂粮面包品质的影响因素依次为改良剂添加量>杂粮皮粉用量>烘焙时间>酵母添加量。通过单因素和正交试验得到杂粮面包的最佳配方为高筋粉50%、杂粮皮粉2.3%(绿豆皮粉:黄豆皮粉:红薯皮粉=3:2:5)、白糖13.1%、酵母0.4%、改良剂0.2%、奶粉0.3%、水21%、鸡蛋6.6%、盐0.5%和黄油5.2%,烘培20min得到的杂粮面包的风味品质最佳,形态丰满完整,色泽均匀,组织有弹性,具有发酵烘烤后特有的面包香味,松软可口。     

云南小粒咖啡果皮粉发酵酸奶的研制

以鲜牛奶为主要原料,添加云南小粒咖啡果皮粉、蔗糖、琼脂,直投式发酵菌种为发酵剂,以酸奶感官品质评分为考察指标,在单因素试验的基础上,应用Box-Behnken试验设计优化确定最佳的云南小粒咖啡果皮粉发酵酸奶的工艺与配方。结果表明:咖啡果皮粉添加量为鲜奶量的0.63%,蔗糖为鲜奶量的7.50%,琼脂为鲜奶量的0.55%,发酵时间6.6h时,获得的发酵酸奶的感官品质评分为91分,产品组织状态均匀,口感细腻,略带有咖啡香味,感官评价最佳。     

婴幼儿配方奶粉中8种常微量元素分析方法的研究

采用湿法消解(电热板消解法)、干式消解法(灰发化)和微波消解法对婴幼儿乳粉样品进行前处理,建立电感耦合等离子体发射光谱仪(ICP-OES)同时测定待测样品中8种常微量元素的方法。结果表明,采用微波消解-电感耦合等离子发射光谱仪测定婴幼儿乳粉样品中8种常微量元素的方法各元素的平均含量较高,相对标准偏差(RSD)最小,且小于2.05%。该方法对质控样品中各元素的相对标准偏差(RSD)均小于2%,回收率在84.6%～103.5%。     

Polymerisation of gluten proteins in developing wheat grain as affected by desiccation

The breadmaking quality of wheat is affected by the composition of gluten proteins and the polymerisation of subunits that are synthesised and accumulated in developing wheat grain. The biological mechanisms and time course of these events during grain development are documented, but not widely confirmed. Therefore, the aim of this study was to monitor the accumulation of gluten protein subunits and the size distribution of protein aggregates during grain development. The effect of desiccation on the polymerisation of gluten proteins and the functional properties of gluten were also studied. The results showed that the size of glutenin polymers remained consistently low until yellow ripeness (YR), while it increased during grain desiccation after YR. Hence, this polymerisation process was presumed to be initiated by desiccation. A similar polymerisation event was also observed when premature grains were dried artificially. The composition of gluten proteins, the ratios of glutenin to gliadin and high molecular weight-glutenin subunits to low molecular weight-glutenin subunits, in premature grain after artificial desiccation showed close association with the size of glutenin polymers in artificially dried grain. Functional properties of gluten in these samples were also associated with polymer size after artificial desiccation.     

不同类型高粱茎秆蜡粉含量变化规律研究

为了探讨不同类型高粱茎秆蜡粉含量变化规律,根据物理学的色差原理,首次采用色差法,对高粱蜡粉进行测定。结果表明,不同类型高粱之间茎秆的蜡粉含量有明显的差异,同一类型不同基因型间也不同;饲草高粱茎秆自上而下各节段的蜡粉含量呈现出高-低-高的变化趋势,中间茎节的蜡粉含量与全株混合蜡粉含量总平均值最接近,可代表全株的蜡粉含量;不同类型高粱进入各生育期的时间和持续天数不同,同一生育期内蜡粉累积量也不同,饲草高粱为抽穗期开花期乳熟期蜡熟期完熟期,甜高粱为乳熟期抽穗期开花期蜡熟期完熟期,开花期与整个生育期平均蜡粉含量最接近,可代表整个生育期的蜡粉含量;不同类型高粱在同一个生育期内蜡粉日变化呈单峰曲线,蜡粉含量的峰值出现在13:00时;高粱蜡粉与茎秆糖锤度部分呈极显著负相关。研究表明,遗传因素导致不同类型高粱茎秆蜡粉含量存在显著差异并且含量变化具有规律性,为选育高蜡粉含量品种从而提升高粱抗逆性提供科学参考。     

复合山楂果粉加工工艺研究

以山楂为原料,以山楂果粉VC和水分含量为考察指标,筛选出制作山楂果粉的最佳干燥方法;同时在单因素试验的基础上,通过正交试验优化了复合山楂果粉的最佳配方。结果表明,山楂果粉以真空冷冻干燥制品中VC含量最高,达55.75 mg/100 g,喷雾干燥山楂果粉水分含量最低,为3.13%;复合山楂果粉的最佳配方为:山楂200 g、红枣35 g、白砂糖5 g、复合酸0.3 g、麦芽糊精30 g,该配方制得的山楂果粉呈淡玫瑰红色、酸甜可口、风味较好。     

信阳绿茶主食面包的研制

将信阳毛尖绿茶研磨成粉添加到主食面包中制备信阳绿茶主食面包,研究不同绿茶粉添加量对主食面包比容、感官品质、水分含量及酸度的影响。结果表明,绿茶粉最佳添加量为面包粉质量的3%,此时得到的绿茶主食面包比容为5.75 m L/g,感官品质评分98分,水分含量32.7%,茶多酚含量0.386 g/100 g,酸度2.98°T;绿茶面包表皮完整且丰满,无焦斑,色泽均匀,稍有茶叶的黄绿色,组织紧密有弹性、耐咀嚼,有茶叶的清香,无茶苦味,且具有较好的营养保健功能,市场前景广阔。