履带拖拉机变速箱壳体生产线技术改造

介绍中国一拖集团有限公司为满足履带拖拉机多样性的市场需求对已有生产线进行技术改造,使其成为适合年产5 000件以上制造能力的51.5～117.6 kW区间多品种履带拖拉机变速箱壳体柔性生产线。     

中国饲料粮消费问题探析

为了准确分析中国当前饲料粮供需情况及影响因素,首先通过供给法计算出1984—2013年的狭义饲料粮可供给数据,其次通过需求法计算中国饲料粮消费数据。推算得出饲料粮供需数据虽有差距但都呈增长趋势。中国粮食政策加剧了饲料粮供需失衡状况。因此提出相应政策建议:一是适当增加肉类产品进口并严厉打击走私;二是粮食政策在确保主粮(大米和小麦)基本自给基础上,适度进口饲料粮(主要是玉米),并在海关政策制订上将精饲料原料通盘考虑,制订考虑替代品如大麦、高粱、DDGS等在内的一揽子关税与配额政策。     

水稻耐寒恢复系科恢36的选育与应用

科恢36是重庆师范大学以明恢63/泰引1号(9)//糯89-1(♂)杂交选育而成的水稻新恢复系,具有耐冷性强、恢复力强、花粉量充足等特点,2013年通过重庆市技术鉴定,所配组合冈优36(冈46A/科恢36)于2012年通过重庆市品种审定.     

Simultaneous detection of multiple mycotoxins in broiler feeds using a liquid chromatography tandem-mass spectrometry

Mycotoxins are secondary fungal metabolites that are typically present in grain and feed ingredients used for animal feeds. An analytical method using LC-ESI-MS/MS was developed to quantify nine mycotoxins, consisting of aflatoxin B₁ (AFB₁), AFB₂, AFG₁, AFG₂, T-2 toxin, deoxynivalenol (DON), nivalenol (NIV), zearalenone (ZEA) and ochratoxin A (OTA) in broiler feeds. In total, 100 samples of broiler feeds were collected from poultry farms in Central Thailand. The survey found that AFB₁ and ZEA were the most prevalent mycotoxins in the feed samples at percentages of 93% and 63%, respectively. The limit of detections (LODs) of investigated mycotoxins was 0.20–0.78 ng/g. AFB₂, DON, AFG₁, NIV and T-2 toxin were also detectable at low contamination levels with percentages of 20%, 9%, 7%, 5% and 1%, respectively, whereas OTA and AFG₂ were not detected in any of the feed samples. These results suggest that there is a very low level of risk of the exposure to mycotoxins in feeds obtained from broiler farms in Central Thailand.     

桑叶养猪实用技术

桑叶养猪实用技术分为桑树种植技术和桑叶干粉发酵养猪技术两个部分。利用荒地种植桑树,降低生猪养殖饲养成本,桑叶养猪种养结合,成为生态农业典范。桑叶干粉发酵技术,提高了桑叶干粉的可消化率和饲料功能。桑叶干粉发酵料占配方6%~10%,做成桑叶猪饲料,替代3%~5%鱼粉、豆粕等蛋白质饲料,节约了饲料成本。桑叶喂养猪(简称桑叶猪,下同)的猪肉中含有肌苷酸等风味物质,显著提高猪肉胴体品质和猪肉风味。设计猪尿处理,采用红泥膜沼气池降解工程工艺应用后,降解水兑2倍清水对桑树喷灌工艺,减少人工处理劳力和成本费用。设计10%抗非洲猪瘟中药饲料添加剂+桑叶饲料,预期防治非洲猪瘟总效果85%以上。桑叶养猪实用技术可行,供同行参考。     

质量控制图在水产饲料氨基酸分析中的应用

通过对实验室自制标准物料-豆粕样品中氨基酸含量的多次测定,建立X-S质量控制图,开展水产饲料氨基酸分析日常质量控制。试验按照GB/T 18246-2000,通过微波水解-离子交换-柱后衍生-紫外检测法对豆粕样品氨基酸含量进行连续测定,并以FAPAS奶粉标准物质验证,利用偏度-峰度检验法对离群值进行判断,建立赖氨酸、甘氨酸、氨基酸总量质量控制图。结果显示,质量控制图中豆粕质控样赖氨酸、甘氨酸、氨基酸总量测定的RSD值均小于4%,FAPAS奶粉标准物质测定值落在参考范围内,建立的质量控制图能对日常氨基酸检测结果进行有效监控。结果表明,所建立氨基酸质量控制图直观有效,能对过程存在的异常因素起到预警作用,并可节约成本。     

凝胶渗透色谱净化-气相色谱法同时测定饲料中4种抗氧化剂

本文建立了凝胶渗透色谱净化(GPC)-气相色谱法(GC)同时测定饲料中2,6-二叔丁基对甲酚(BHT)、叔丁基羟基茴香醚(BHA)、叔丁基对苯二酚(TBHQ)和乙氧喹(EQ)4种抗氧化剂方法。4种抗氧化剂在10～400mg/L时与峰面积有良好的线性关系(r2>0.9999),检出限(3S/N)为0.37～0.46 mg/kg,添加回收率为82.7%～98.8%,相对标准偏差(n=5)为1.7%～4.3%。     

Feed preference and growth response of juvenile Litopenaeus vannamei to supplementation of marine chemoattractants in a fishmeal‐challenged diet

This study compared the feed preference and growth response of Litopenaeus vannamei to chemoattractants. A diet with 3% fishmeal was supplemented with either 3% salmon meal (POS), 3% soy protein concentrate (NEG), 3% krill meal (KRM), 3% squid meal (SQM), 3% shrimp head meal (SHM), 3% shrimp meal (SM), 3% squid liver meal (SLM), or 5% liquid sardine hydrolysate (SAH). Shrimp with a body weight (BW) of 0.99 ± 0.08 g were stocked at 100 animals/m² in 56 tanks of 1 m³ and fed 10 times daily for 74 days. Feed preference was evaluated by feeding shrimp of 10.87 ± 1.82 g in excess twice a day for 10 days in two separate feeding trays allocated in 50 tanks of 0.5 m³. Survival reached 93.3 ± 5.80% and was unaffected by supplementation. Final BW was the highest for shrimp fed the KRM‐supplemented diet (11.97 ± 0.93 g), followed by POS (11.11 ± 0.77 g) and SQM (11.01 ± 1.17 g). Diets SHM, SM, SLM, and NEG showed a lower shrimp BW than POS, but were not statistically different among them. Shrimp fed the SAH diet achieved the lowest BW (10.06 ± 1.02 g). The highest gained yield was obtained with diets KRM and POS. No statistical difference was observed in shrimp yield among other diets. The lowest feed conversion ratio (FCR) was achieved with shrimp fed KRM (1.31 ± 0.05) when compared to diets SHM (1.47 ± 0.05), SAH (1.47 ± 0.07), and SLM (1.45 ± 0.17). Two‐by‐two comparisons indicated that shrimp preferred SHM and KRM, except when these were compared to SQM and SLM. No difference in feed preference was found between diets with SQM and SLM. SAH was the least preferred raw material in all comparisons. Results indicated that KRM acts as a powerful feeding effector and growth enhancer in fishmeal‐challenged diets for whiteleg shrimp. A dietary supplementation with 3% KRM is more effective than the same dose of any other chemoattractant evaluated.