白口铸铁机械性能研究及在农机制造中的应用(I)

为了提高白口铸铁的冲击韧性等机械性能,扩大其在农机具上的应用范围,采用BZ变质剂对白口铸铁进行变质浇铸,并研究了变质剂对白口铸铁中碳化物的断网效果。试验结果表明,变质剂对于含碳量在3.2%以下、含铬量在12%以下的白口铸铁具有较好的断网效果。     

Effect of water deficit in different growth stages on stem sap flux of greenhouse grown pear-jujube tree

The effects of water deficit in different fruit growth stages on the variation of stem sap flux of 6-year old greenhouse-grown pear-jujube trees were investigated. Treatments included sufficient water supply during the whole fruit-growing period (T₁), mild water deficit during the flowering–fruit setting stage (T₂), moderate water deficit during the fruit rapid growth stage (T₃) and severe water deficit during the fruit maturing stage (T₄). Results showed that significant compensation effect on stem sap flux after re-watering was observed in T₂, but not in T₃ and T₄ stages. At the end of rapid growth stage, the diurnal variation of stomatal conductance generally had a similar trend as that of stem sap flux, but with a distinct midday depression from 12:00 to 14:00 p.m. In addition, a linear relationship between the relative available soil water content (RAWC) and the ratio of daily stem sap flux to that of sufficient water treatment was observed (R² = 0.4489).     

Effect of drying on soil strength and corn emergence

Summary Laboratory studies were conducted to evaluate the effects of drying on soil strength and corn emergence (Zea mays L.). Corn was germinated in Billings silty clay under a bank of heat lamps which operated 9, 14, 19, or 24 h per day. Soil strength (modules of rupture), soil moisture content and emergence were measured daily.The relationship of soil strength to corn seedling emergence as influenced by the four light and heat durations and bare and mulched soil surfaces was determined. As soil strength increased emergence decreased until it ceased at soil strengths of about 80 kPa. Strength of this soil had a high negative correlation with soil water content and increased with time. Mulching decreased initial rate of drying, decreased crust strength, and improved corn emergence. The 14-hour light and heat treatment resulted in the highest corn emergence.Contribution from Colorado State Experiment Station, USDA-ARS Snake River Conservation Research Center, and USDA-ARS Fort Collins, respectively     

保护地蔬菜栽培不同灌水方法对表层土壤盐分含量的影响

通过 3年连续保护地栽培蔬菜小区试验 ,对滴灌、渗灌、沟灌 3种灌水方法的土壤盐分积累状况进行了比较研究。试验后 0～ 2 0 cm土层土壤全盐含量以沟灌最高 ,渗灌次之 ,滴灌最低 ;滴灌土壤 p H下降幅度明显低于渗灌和沟灌土壤。在 0～ 2 0 cm土层内全盐含量呈幂指数形式分布 ,即地表处含量最高 ,随深度增加逐渐下降 ;而土壤 p H则随深度增加而直线上升。另外 ,土壤中可溶性盐的阴离以 NO-3 为主 ,阳离子以 Ca2 + 为主。这说明选择合理灌水方法 ,是防止土壤退化、提高保护地作物产量和质量的有效途径。     

苹果糖度在线检测降低杂散光影响研究

基于光谱学原理设计了智能苹果糖度在线分级设备,研究了上置式检测器在线检测中的杂散光问题,通过光路图分析了富士苹果3种摆放方式对杂散光的影响,并提出了遮光降噪方案。利用偏最小二乘(PLS)回归分别建立了3种摆放方式的富士苹果可溶性固形物含量(SSC)在线预测模型。研究结果表明,对于上置式检测器而言,摆放方式和遮光处理尤为重要。其中果柄朝上遮光为最佳降噪措施,所建立的模型校正集均方差(RMSEC)为0.60,校正集相关系数(RC)为0.94,预测集均方差(RMSEP)为0.67,预测集相关系数(RP)为0.87,可以满足实际生产中的在线分级要求。     

管针式土壤含水率探头设计与影响因素分析

为了给基于频域反射法测量土壤质量含水率提供一种方法,设计了一种由圆管和探针组成的管针式土壤质量含水率测量探头。以杨凌地区的塿土为对象,分析了所设计探头间接测量土壤容重的误差;在信号源频率为50、100、150、300、500 MHz下,研究了土壤质量含水率(2.58%~21.43%)、土壤容重(0.80~1.30 g/cm3)和温度(10~50℃)对探针上的电压与信号源输出电压的比值(信号电压比)的影响;建立了信号电压比与土壤温度、容重和质量含水率之间的三元二次方程,分析了模型预测土壤含水率的可行性。结果表明:管针式探头间接测量土壤容重的绝对误差为-0.129~0.016 g/cm3;含水率、容重和温度均影响信号电压比,50、100、150 MHz下含水率对信号电压比影响较显著。在0.01的显著水平上,150 MHz下所建模型较优,其决定系数R2为0.849 6;对该模型的检验结果说明,计算的信号电压比与实际电压比的绝对误差为-0.166~0.159。基于该模型计算的土壤含水率与实际含水率的绝对误差为-3.440%~4.039%。     

对两个材料力学问题的探讨

在材料力学中,对铸铁试件的轴向压缩破坏一般都认为破坏断面与杆件横截面成45°角;在材料的应力分析上,只对平面应力状态进行研究,对三角形单元的应力研究轻少。为此分别采用实验方法和分析法,对上述两个问题进行探讨。其实验结果是:铸铁试件的压缩破坏一般在55°左右,考虑内摩擦力的影响后,得到了很好的理论解释;而对三角形单元的应力分析,用应力圆法求解简单方便。对这两个问题的研究,将有助于材料力学的应用与发展。     

2.25Cr-1Mo与铁铝合金高温抗氧化性能的对比研究

对2．25Cr-10钢与铁铝合金的高温抗氧化性能进行了对比研究。铁铝合金具有许多性能上的优点，尤其在其高温抗氧化性能方面。明显优于不锈钢、铬钼钢等传统的高温结构材料，并且随着温度的升高及铝含量的增加，其优势更加显著。     

铁法预处理糖蜜酒精废液沼气发酵工艺的研究

本研究采用法法预处理糖蜜精废液，并将其进行厌氧发酵试验，试验的厌氧罐容积为１３Ｌ，预处理容积为１．３Ｌ结果表明：经铁法预处理后的糖蜜酒精度液能够稳定地用于沼气发酵，而且所产沼气的Ｈ２Ｓ含量大减少。     

智能粮食水分测试仪的研制

给出以AT89C52单片机为核心的粮食水分测试仪的硬件结构组成,并详细介绍了信号处理和测量方法;通过对传感器的标定并进行相应的数据处理。通过实验发现,该仪器使用方便,测量精度高。