软红冬小麦品质性状与饼干直径的关系

以57份软红冬小麦品种(系)为材料,通过测定出粉率、面粉颗粒度、蛋白质含量、溶剂保持力和RVA参数等指标,研究了小麦品质性状与饼干直径的关系。结果表明,品种(系)间的品质性状和饼干直径变异较大。在16个品质性状中,有11个与饼干直径呈显著或极显著相关,其中碳酸钠SRC、水SRC、蔗糖SRC与饼干直径的相关最密切,相关系数分别为-0.8643(P0.01)、-0.8579(P0.01)和-0.7566(P0.01),可作为饼干品质的筛选指标。采用最短距离法对57份小麦品种(系)的饼干直径进行聚类分析,结果聚为3大类及若干亚类,3大类饼干平均直径分别为16.75、15.14和18.45cm。筛选出9个饼干直径超过宁麦9号的种质资源,可作为优质饼干小麦品种选育的中间材料加以利用。     

日东原油管道高黏油掺混输送工艺

日东原油管道通过使用静态掺混装置实现了高黏油的在线掺混输送,并积累了大量的生产数据和经验。介绍了日东原油管道的掺混工艺、输送油品的物性、掺混界面的移动对运行参数的影响及油品静置对启输的影响。以黏度异常事件为例,对比分析了事件前后管道流量、压力、黏度及水力坡降等重要参数和数据,最终确定高稠油掺入比和部分管段沉积的杂质颗粒黏团为两个关键影响因素。为确保管道的运行安全,避免再次发生黏度异常事件,建议结合生产实际情况,以取样数据为依据,严格控制掺混比例和黏度等运行参数,明确清管频次,进一步优化管道生产运行。研究成果可为管道安全输送掺混油提供技术支持。     

The influence of xylanase on the fermentability,digestibility, and physicochemical properties of insoluble corn-based fiber along the gastrointestinal tract of growing pigs

In theory, supplementing xylanase in corn-based swine diets should improve nutrient and energy digestibility and fiber fermentability, but its efficacy is inconsistent. The experimental objective was to investigate the impact of xylanase on energy and nutrient digestibility, digesta viscosity, and fermentation when pigs are fed a diet high in insoluble fiber (>20% neutral detergent fiber; NDF) and given a 46-d dietary adaptation period. A total of 3 replicates of 20 growing gilts were blocked by initial body weight, individually housed, and assigned to 1 of 4 dietary treatments: a low-fiber control (LF) with 7.5% NDF, a 30% corn bran high-fiber control (HF; 21.9% NDF), HF + 100 mg xylanase/kg (HF + XY [Econase XT 25P; AB Vista, Marlborough, UK]) providing 16,000 birch xylan units/kg; and HF + 50 mg arabinoxylan-oligosaccharide (AXOS) product/kg (HF + AX [XOS 35A; Shandong Longlive Biotechnology, Shandong, China]) providing AXOS with 3–7 degrees of polymerization. Gilts were allowed ad libitum access to fed for 36-d. On d 36, pigs were housed in metabolism crates for a 10-d period, limit fed, and feces were collected. On d 46, pigs were euthanized and ileal, cecal, and colonic digesta were collected. Data were analyzed as a linear mixed model with block and replication as random effects, and treatment as a fixed effect. Compared with LF, HF reduced the apparent ileal digestibility (AID), apparent cecal digestibility (ACED), apparent colonic digestibility (ACOD), and apparent total tract digestibility (ATTD) of dry matter (DM), gross energy (GE), crude protein (CP), acid detergent fiber (ADF), NDF, and hemicellulose (P < 0.01). Relative to HF, HF + XY improved the AID of GE, CP, and NDF (P < 0.05), and improved the ACED, ACOD, and ATTD of DM, GE, CP, NDF, ADF, and hemicellulose (P < 0.05). Among treatments, pigs fed HF had increased hindgut DM disappearance (P = 0.031). Relative to HF, HF + XY improved cecal disappearance of DM (162 vs. 98 g; P = 0.008) and NDF (44 vs. 13 g; P < 0.01). Pigs fed xylanase had a greater proportion of acetate in cecal digesta and butyrate in colonic digesta among treatments (P < 0.05). Compared with LF, HF increased ileal, cecal, and colonic viscosity, but HF + XY decreased ileal viscosity compared with HF (P < 0.001). In conclusion, increased insoluble corn-based fiber decreases digestibility, reduces cecal fermentation, and increases digesta viscosity, but supplementing xylanase partially mitigated that effect.     

粳稻谷储藏期间品质变化的动力学研究

通过对不同温度条件下(15℃、20℃、25℃、30℃)储藏的粳稻谷过氧化物酶(POD)活性、峰值粘度变化进行监测(储藏时间为180d,测定周期为30d),结合动力学分析方法,在研究储藏条件对粳稻谷品质影响的基础上建立相应的品质变化预测模型。结果表明:过氧化物酶活性随着储藏时间的延长而逐渐下降,且温度越高,下降得越快,在温度为30℃、25℃、20℃、15℃条件下储藏180d后,粳稻谷过氧化物酶残余活力依次下降至16.74%、23.85%、38.35%、40.17%;峰值粘度随着储藏时间的延长而呈现波动上升的趋势,温度越高,上升的趋势越明显,在30℃条件下储藏180d后,峰值粘度上升至3495cP,而在温度为25℃、20℃、15℃条件下储藏的粳稻谷样品,峰值粘度依次上升至3307cP、3262cP、3018cP。粳稻谷过氧化物酶活性、峰值粘度的预测模型依次是:lnAt=-e-31007.16/RT×t+4.6052、lnAt=-e-24467/RT×t+7.7337。动力学模型预测值与实际测量值的相对误差在1%~12%之间,可以对储藏期间粳稻谷品质变化进行预测。     

Digesta viscosity, nutrient digestibility and organ weights in African catfish (Clarias gariepinus) fed diets supplemented with different levels of a soluble non-starch polysaccharide

The objective of the present study was to investigate if dietary soluble non‐starch polysaccharides (NSP) increase digesta viscosity, reduce nutrient digestibility and increase organ weights in African catfish. The fish (mean weight 80 g) were fed diets supplemented with the soluble NSP guar gum at three levels, 0 g kg^?1 (GG0), 40 g kg^?1 (GG4) and 80 g kg^?1 (GG8). Guar gum inclusion significantly increased digesta viscosity in the proximal (GG0: 1.7 centipoise or cP; GG4: 84.9 cP; GG8: 98.3 cP) and distal (GG0: 1.9 cP; GG4: 109.8 cP; GG8: 66.4 cP) intestine. Apparent digestibility coefficients (ADC) were significantly lower for the GG8 diet than the GG0 diet (dry matter: 52% versus 69%; protein: 77% versus 90%; ash: 41% versus 54%; energy: 60% versus 77%). The ADC of dry matter and energy were significantly lower for the GG4 diet than the GG0 diet. The relative growth rate of metabolic weight (14.5–15.4 g kg^?0.8 day^?1) and feed conversion ratio (0.8) did not differ between diets. Fish fed the GG8 diet had a significantly higher somatic stomach index than GG0 fish (0.71% versus 0.65% body weight). The intestinal somatic index tended to increase with increasing guar gum supplementation (GG0: 1.08%; GG4: 1.23%; GG8: 1.59%). In conclusion, high digesta viscosities in the guar gum fed fish may explain the observed reduced nutrient digestibilities and increases in digestive organ weights.     

浑浊型饲用微生态菌剂悬浮剂的制备及稳定性研究

[目的] 建立一种浑浊型微生态菌剂悬浮剂的制备方法,并对其稳定性进行评价。[方法] 以黄原胶和羧甲基纤维素钠为稳定剂,以饲用微生态菌剂干粉为悬浮成分,制备微生物水悬浮体系。对制备的悬浮剂进行稳定性评价,测定指标包括稳定系数、黏度、存放稳定性、冷贮存稳定性和活菌总数。[结果] 随着稳定剂添加比例的增加,悬浮剂的稳定系数逐渐增加。添加0.20%稳定剂,体系的稳定系数达到91.38%,极显著（P<0.01）高于空白对照组。悬浮体系的黏度随着稳定剂添加量的增加和贮存温度的降低而增大,当稳定剂添加比例为0.20%时,体系不出现分层现象,达到稳定状态。经过24 h冷贮存（4 ℃）后,添加0.10%稳定剂的悬浮剂活菌数出现下降,添加0.10%~0.25%稳定剂显著（P<0.05）低于空白对照组,但仍维持在10⁹ CFU/mL以上。[结论] 稳定剂添加量为0.20%时,饲用微生态菌剂悬浮剂无分层现象出现,无论常温还是冷贮存24 h后,制成的悬浮剂中活菌数均保持在10⁹ CFU/mL以上,能够保证饲用微生态菌剂的有效活菌数。     

加工参数对涂抹型再制干酪物理性质和微观结构的影响

加工参数是影响涂抹型再制干酪物性和微观结构的重要因素.通过测定样品的质构性质、融化性、表观黏度和结合微观结构观察,确定加工参数对涂抹型再制干酪的影响.结果表明:剪切速率、加工温度和时间对样品质构指标和融化距离影响显著(P<0.05),剪切速率由800 r/min升高到1400 r/min的过程中,硬度、涂抹功和黏着性没...     

Influence of growth ring angle,adhesive system and viscosity on the shear strength of adhesive bonds

Abstract

To investigate the influence of growth ring angle, adhesive system and viscosity on the bonding properties of adhesive bonds, shear tension tests according to DIN EN 302-1 (2004) were conducted using one-component moisture-curing polyurethane, polyvinylacetate and urea-formaldehyde. Significant differences between the systems could be detected, which were reflected in the predominant failure behaviour for each system. Specimens showing wood failure were influenced mainly by the wood factors, whereas samples which had failed in the adhesive part of the bond differed only in the adhesive properties. The growth ring angle showed the same tendencies as it does in plain wood. Therefore, to gain more information on the adhesive performance in the bond, a loading along the LT plane seems more appropriate for beech wood used in DIN EN 302-1 (2004).     

Design and experimental validation of a novel double ring plate gear reducer

A novel double ring plate gear reducer (DRPGR) is designed and its experimental validation is conducted. By using the closed graph method, the modification coefficients of internal gearing in DRPGR are determined. Based on this, the overall structure of the reducer is designed and its kinematics simulation is achieved. With APDL programming language of ANSYS, a 3D finite element (FE) model of DRPGR is established, and its modal analysis and loaded tooth contact analysis (LTCA) are conducted respectively. The modal analysis reveals that the lower natural frequencies of DRPGR are much higher than the input frequency and the lower modes can be classified as vertical and horizontal bending of input and output shafts. The LTCA indicates that three pairs of gear teeth contact simultaneously at rated output torque. Due to the multi teeth contacts, the maximum stress is much lower than the permissible stress of internal gearings. The experimental tests of the prototype validate that DRPGR is adapted to both single driven and dual driven work condition. When single droved, DRPGR can eliminate the kinematic uncertainty by non 180 degree phase difference design. DRPGR claims a better dynamic performance in dual driven work condition. The efficiency of DRPGR increases with the increment of output torque and the reducer has an excellent short term overloaded capacity. The experimental results validate that the proposed method can be used to guide the design of that kind of reducer.     

食用甘薯品种的部分理化特性与口感品质的关系

对浙6025、宁紫薯1号、南京0281、南京0304、南京0364等优质食用甘薯品种进行了淀粉糊化特性测定、淀粉粒显微观察及相关食用口感品质调查.糊化特性测定结果显示,南京0304 和宁紫薯1号淀粉的峰值粘度较高,这与其在食用品质调查中口感较粘一致.宁紫薯1号、南京0281及南京0364的淀粉显微结构显示其淀粉颗粒大小较为均匀,口感品尝其均匀度较好.浙6025小颗粒淀粉分布较多,因此在蒸煮品尝调查中薯肉口感较细腻.表明,甘薯的理化特性与食用口感品质具有一定程度的关联.