日粮中性洗涤纤维水平对断奶至2月龄肉兔生产性能、消化代谢和盲肠发酵的影响

80只断奶新西兰兔分成5组,饲喂5种中性洗涤纤维(NDF)水平的日粮(分别为24%、27%、30%33%和36%),研究了日粮NDF水平对断奶至2月龄的肉兔生产性能、营养物质消化利用、免疫指标、盲肠纤维酶活性和盲肠内环境的影响。结果表明:日粮NDF水平对试兔日增重、饲料转化率影响显著(P<0.05),随NDF水平增加,日增重先增加后降低,料重比先降低后增加,30%NDF水平对日增重最高为31.52g/d,饲料转化率最低为3.23:1。随日粮NDF水平的增加,粗纤维、能量、粗蛋白和粗脂肪消化率显著或极显著降低(P<0.05,P<0.01),NDF消化率显著提高(P<0.05),氮沉积先升高后下降,以30%NDF组最高为1.24g/d。不同NDF间胸腺指数和脾脏指数差异不显著(P>0.05)。日粮NDF能极显著提高盲肠纤维素酶的活性(P<0.01),纤维素酶活性由13.79IU/g提高到58.68IU/g。NDF水平对断奶至2月龄试兔盲肠发育影响显著(P<0.05),盲肠占活重的比例随NDF水平的增加呈上升趋势。盲肠氨氮浓度呈下降趋势,24%、27%NDF组与36%NDF组差异显著(P<0.05),总VFA含量呈上升趋势,24%NDF和36%NDF组差异显著(P<0.05),VFA中乙酸比例上升,丙酸、丁酸比例下降。综合以上结果,断奶至2月龄肉兔NDF水平以30%～33%为宜。     

响应面法优化当归补血汤液体发酵工艺

为确定当归补血汤液体发酵的最佳工艺,本试验采用枯草芽孢杆菌为发酵菌种,以多糖提取率为评价指标进行液体发酵工艺优化。首先采用单因素试验考察发酵培养基中葡萄糖和蛋白胨添加量、菌液接种量和发酵时间对多糖提取率的影响,再以此为基础,采用Box-Behnken中心组合试验设计法,选取葡萄糖添加量、蛋白胨添加量、接种量、发酵时间为发酵优化的4个因素,以多糖提取率为响应值,设计4因素3水平的试验方案并进行响应面分析,以确定各因素与响应值多糖提取率的关系。结果显示,各因素对多糖提取率变化的贡献大小依次为葡萄糖添加量、蛋白胨添加量、接种量、发酵时间;利用响应面分析结果显示,蛋白胨添加量与接种量和发酵时间、接种量和发酵时间的交互作用较为显著,最终确定最佳发酵工艺条件为：葡萄糖添加量0.95%,蛋白胨添加量1.52%,接种量2.92%,发酵时间35.8 h。该条件下多糖提取率达到9.23%,与未发酵组（4.62%）相比,多糖含量提高近2倍。该工艺对液体发酵当归补血汤产多糖优化效果显著,为发酵当归补血汤的进一步开发利用提供了理论基础。     

蚕沙和稻秸不同比例组合对瘤胃微生物体外发酵的组合效应

本文采用瘤胃微生物体外发酵法研究了不同比例蚕沙(SE)和稻秸(RS)的组合效应。试验将SE:RS设计为100∶0(SE100组)、80∶20(SE80组)、60∶40(SE60组)、40∶60(SE40组)、20∶80(SE20组)、0∶100(SE0组)的比例,分别进行体外发酵批次培养24 h和体外发酵产气培养72 h,测定产气参数和发酵特性指标。结果表明:1)SE100组理论最大产气量显著高于其他各组(P<0.05),SE80组的24和72 h累积产气量显著高于其他组(P<0.05)。2)24 h时培养液总挥发性脂肪酸浓度为SE80组>SE100组>SE60组>SE40组>SE0组>SE20组,乙酸/丙酸为SE80组SE100组>SE60组>SE80组>SE40组>SE0组。4)随着蚕沙比例的升高,底物体外有机物消化率越高。5)SE80组多项指标组合效应指数为0.76,SE80组>SE40组>SE60组>SE20组。蚕沙和稻秸组合改善了体外瘤胃微生物发酵特性和产气参数,且蚕沙和稻秸的最佳比例为80∶20。     

不同收获期对全株玉米青贮营养价值、发酵品质和瘤胃降解率的影响

本试验旨在研究不同收获期对全株玉米青贮营养价值、发酵品质和瘤胃降解率的影响。试验抽样采集山东省44个区县130个养殖场130份全株玉米青贮饲料样品,按照收获时玉米籽粒的乳线位置,共分为1/2乳线、2/3乳线和3/4乳线3个时期,样品数量分别为40、60和30份,测定其营养价值、发酵品质和瘤胃降解率。结果表明:1)随着收获期的延迟,全株玉米青贮的干物质(DM)含量显著增加(P<0.05),粗灰分(Ash)含量显著降低(P<0.05)。1/2乳线期全株玉米青贮的中性洗涤纤维(NDF)、酸性洗涤纤维(ADF)和酸性洗涤木质素(ADL)含量显著高于2/3乳线期和3/4乳线期(P<0.05)。2)随着收获期的延迟,全株玉米青贮的淀粉(CB1)含量显著增加(P<0.05)。1/2乳线期全株玉米青贮的总碳水化合物(CHO)、可溶性糖(CA)含量显著低于3/4乳线期(P<0.05),1/2乳线期全株玉米青贮的不可利用纤维(CC)和可利用中性洗涤纤维(CB3)含量显著高于2/3乳线期和3/4乳线期(P<0.05)。3)随着收获期的延迟,全株玉米青贮的发酵系数和费氏评分显著增加(P<0.05)。1/2乳线期和2/3乳线期全株玉米青贮的乳酸含量显著高于3/4乳线期(P<0.05),1/2乳线期全株玉米青贮的的丙酸含量显著高于2/3乳线期和3/4乳线期(P<0.05)。4)随着收获期的延迟,全株玉米青贮的总可消化养分含量及消化能、代谢能均显著增加(P<0.05)。1/2乳线期全株玉米青贮的维持净能、增重净能和泌乳净能显著低于2/3乳线期和3/4乳线期(P<0.05)。5)1/2乳线期和2/3乳线期全株玉米青贮的24和48h的干物质降解率显著低于3/4乳线期(P<0.05)。综上所述,收获期为3/4乳线期时,全株玉米青贮的营养价值和发酵品质最优。     

高温高湿条件下添加功能性油脂对奶牛生产性能、瘤胃发酵和生理状态的影响

文章旨在评估功能性油脂替代莫能菌素对高温高湿环境下奶牛生产性能、瘤胃发酵和生理状态的影响。试验选择产奶期(200±50)d,平均体重(600±75)kg的荷斯坦奶牛36头,将其随机分为3组,每组12个重复,每个重复1头牛,进行为期6周的试验(1周适应期,5周试验期),试验共设计3种日粮,对照组饲喂基础日粮,处理1组在基础日粮添加20mg/kg莫能菌素,处理2组在基础日粮添加0.05%功能性油脂。试验期间环境温度、湿度和温湿度指数分别是(25±0.55)℃、(82.0±1.20)%和74.5±0.30,表明奶牛处于高温高湿环境。结果:处理1组较对照组和处理2组显著降低了干物质和有机物的摄入量(P<0.05),较对照组显著降低了粗蛋白质摄入量(P<0.05)。试验时间显著影响有机物、蛋白质摄入量及养分表观消化率(P<0.05),同时显著影响瘤胃pH、氨氮和挥发性脂肪酸含量(P<0.05)。对照组较处理2组显著降低了血清尿素含量(P<0.05),处理和时间对血清尿素含量的影响具有显著交互效应(P<0.05)。处理1组较处理2组显著降低了脂肪产量和乳脂肪含量(P<0.05)。试验时间显著影响乳成分含量及产量(P<0.05)。结论:在本试验条件下,功能性油脂增加了乳脂产量,并且可以代替莫能菌素而不影响奶牛在高温高湿环境下的采食量、养分消化率、瘤胃发酵和生理状态。     

本科酶工程课程教学实践与体会

酶工程是高校生物工程和生物技术专业重要的专业课。结合课程教学实践,总结了酶工程教学过程中的几点体会,以提高酶工程教学质量,达到学生综合能力的培养目的。     

Effects of cyclodextrin-iodopropane complex on methane production, ruminal fermentation and microbes, digestibility and blood metabolites in steers

The effects when adding cyclodextrin‐iodopropane complex (CD‐IP) to a diet, on ruminal fermentation and microbes, digestibility, blood metabolites and methane production, were evaluated using four Holstein steers in a cross‐over design. The steers were fed Sudangrass hay plus concentrate mixture at a ratio 1.5:1, and CD‐IP (1% of dry matter) was given twice daily by mixing with concentrate mixture. Rumen and blood samples were collected at 0, 2, and 5 h after morning dosing. Ruminal pH and numbers of protozoa were unaffected by CD‐IP treatment. Ruminal molar proportion of acetate was decreased (P < 0.05), and propionate was increased (P < 0.01) at 2 h after CD‐IP dosing. Proportion of butyrate was increased (P < 0.05) and ammonia‐N was decreased (P < 0.05) at 2 and 5 h after CD‐IP dosing. Adding CD‐IP had no effect on the feed intake and digestion of nutrients. Plasma glucose was increased and urea‐N was decreased (P < 0.05) at 2 and 5 h after CD‐IP dosing. Methane production was decreased (P < 0.05) by approximately 18% in the treatment steers. Numbers of methanogenic bacteria were decreased (P < 0.05), while total viable counts, cellulolytic, sulfate reducing and acetogenic bacteria were unaffected. The present results are the first to show that CD‐IP can partially inhibit in vivo ruminal methanogenesis without adverse effects on digestion of nutrients.     

马铃薯渣酶法水解液制备单细胞蛋白饲料的研究

本文研究了酶法水解马铃薯渣制备膳食纤维后的滤液制备单细胞蛋白的可行性。试验结果表明,单细胞蛋白边糖化边发酵的摇瓶培养的较优工艺条件为:底物浓度为8%(添加8%的麸皮水)、初始pH值为4.5、接种量为15%、葡萄糖淀粉酶加入量为100U/g(原料中淀粉)、青霉素加入量为80U/g(原料)、培养温度为28℃、培养时间为6h、转速为250r/min。在此条件下,干酵母产量最高为19.920g/L,单细胞蛋白中的蛋白质含量达12.27%。     

乳清酒发酵剂的优选

以2株乳酵母菌、地方性奶酒酵母泥、乳酸菌、丹宝利活性酿酒干酵母为发酵菌种,研究其在乳清酒发酵中各发酵剂的发酵能力、发酵特性并对发酵所得乳清酒品质进行了分析,筛选出5#组合菌种(乳酵母菌2,丹宝利活性酿酒千酵母、保加利亚乳杆菌和嗜热链球菌比例为10:0.1:1)为本研究最佳试验用发酵菌种.     

Palatability and physicochemical properties of sausages prepared via lactic acid fermentation and drying at low temperature

The present study aimed to assess the palatability of sausages undergoing low‐temperature fermentation and drying process. Lactobacillus sakei D‐1001 or Lactobacillus salivarius A001 were used as starter cultures for fermentation, and the following properties of the sausages were investigated: colony‐forming units of lactic acid bacteria; concentrations of lactic acid, protein, peptides, and free amino acids; distribution of protein; composition of free amino acids; and physical properties and taste. Alterations in the composition of proteins, peptides, and free amino acids as well as in various physical properties were caused by fermentation by lactic acid bacteria. A sensory test indicated that the palatability of the fermented sausages was greater than that of the non‐fermented sausages, particularly in terms of hardness and juiciness. This was considered to be due to protein degeneration and changes in the physical properties of the sausages as a result of fermentation by lactic acid bacteria. However, the taste of the fermented sausages was sourer than that of the non‐fermented sausages, and therefore, inferior. Our study revealed that the palatability of the sausages in terms of hardness and juiciness were increased by low‐temperature fermentation by lactic acid bacteria and the drying process.