Experimental Study on the Extended Length of Negative Reinforcement Cut-in Phases in Continuous Beams

In this paper through the static loading tests of 6 inflexion zones and 2 cantilever zones in full-size constrained R/C beams, the stress performance in rebars cut-in-phases and subjected to negative moment is studied. The stress properties of extended length of rebars with different shear-span ratiosare analysed on basis of the full measurement of strain distributions combined with the investigation on state and regularity of the diagonal cracks development and series of new knowledge are obtained. It is found that current Concrete Design Code provisions on the extended length are inadequate for the high shear-span ratio and superfluous for the low shear-span ratio. The theoretical and experimental foundations are provided for determining proper value of extended length for rebars cut-in-phases.     

论碾压混凝土坝上游面喷丙乳砂浆的防渗作用

碾压混凝土具有施工速度快，水泥用量少，投资省等明显的优点。国内的理论研究和工程实践都取得了突飞猛进的进展，在防渗问题方面也进行了卓有成效的探索，如福建省几座已建成的碾压混凝土坝均采用不同的防渗类型。文章结合福建省重点工程连江山仔水利枢纽工程碾压混凝土坝的施工情况，介绍了能够充分发挥碾压混凝土坝快速施工特点的悬臂钢模、改性混凝土的施工方法，论述了喷丙乳砂浆作为碾压混凝土坝上游主防渗体与这一施工特点相统一所具有的优越性。     

火成岩纤维水工混凝土的抗冲性能试验研究

在室内及自然强感潮河口地区进行了火成岩纤维水工混凝土抗冲刷性能的试验,研究了火成岩纤维不同掺加量时混凝土的抗冲性能。结果表明,火成岩纤维增加了水工混凝土的抗冲性能,其较好的掺加量为水泥体积的0.5%。     

溪洛渡水电站无压泄洪洞衬砌混凝土秋季施工温控方案优选

为研究溪洛渡水电站无压泄洪洞秋季施工的温控防裂问题,运用三维有限元法模拟施工过程与温控措施,通过改变混凝土表面的热对流系数来模拟洒水、流水养护的影响,采用直接法模拟冷却水管的作用。运用ANSYS软件对1.0m厚衬砌混凝土秋季施工的5种工况,包括基本工况、基本工况加洒水养护、恒温流水养护、加洒水及恒温流水养护、无通水冷却,进行了仿真计算。通过比较相应工况中特定断面的表面点在不同时间的温度应力值和抗裂安全系数,得出结论:洒水能够有效降低拉应力;常温流水会加大内表温差;通水冷却有效降低最高温度,但应力改善效果不明显。秋季浇筑混凝土,早期宜洒水和通水冷却,后期恒温流水养护,这样能够有效避免温度裂缝的产生。     

育肥猪舍用混凝土微缝地板的截面优化

为解决现有混凝土微缝地板因截面设计不尽合理产生的承载力富余过大,导致实际生产中板体自重大、生产和运输成本高等问题。该文通过计算假定、截面和荷载转化的方法,对混凝土微缝地板的结构进行了理论剖析,对其制造材料、板体尺寸、配筋等进行了优化和力学性能计算。在截面面积减少3600mm2、纵向钢筋面积减少213mm2、混凝土的标号由C30调至C25的情况下,单块地板的正截面抗弯值为3.14kN.m,斜截面抗剪值为3.56kN,裂缝宽度值为0.167mm,跨中截面挠度值为3.70mm,均可满足育肥猪安全使用要求。优化后,单块地板混凝土使用量可节省0.01m3,每平米地面铺设成本降低18%。     

基于XFEM的重力坝裂纹开展数值分析研究

扩展有限元法是近年来出现的一种在常规有限元框架内求解不连续问题的数值方法.利用扩展有限元法分别分析了网格密度、廊道、坝基弹性模量对混凝土重力坝裂纹开展方向的影响.计算结果表明,网格密度对裂纹扩展方向影响不大;裂纹扩展方向有靠向廊道的趋势;坝基弹模对重力坝裂纹的扩展方向几乎没有影响,随着坝基弹模的增大,裂纹扩展长度加大.     

特细砂混凝土的研究进展

砂是混凝土的重要组成成分。目前我国中砂和粗砂的产量已经逐渐不能满足建筑需求,而特细砂给建筑行业带来了新的曙光,亟需将特细砂资源的潜在价值挖掘出来。对国内外特细砂混凝土的研究情况进行系统论述,并展望特细砂混凝土的发展前景,以期为新的建筑材料的开发提供参考。     

THE FULL LOADING HISTORY ANALYSTS OF PRESTRESSED CONCRETE GRIDS WITH UNBONDED TENDONS

This paper presents a matrix structural analysis of variable stiffness on the complete loading history of prestressed concrete grids with unbonded tendons. A model of torsional rigidity affected by moment is derived by the analogy of space truss, and the effect of torque on flexural rigidity is also studied. In order to calculate the increment of stresses in tendons, a corresponding equation is created. Comparison of calculation shows well agreement with the experimental results.     

Design method and homogeneity control of bridge fair-faced concrete

According to the structural characteristics of bridge engineering, the mix optimization design method of bridge fair-faced concrete was presented, and C30~C50 concrete with high cohesion and package, outstanding fluidity and excellent mechanical properties were prepared. Through the test of air content of fresh concrete, micro hardness and micro structure in different parts of hardened concrete specimens, effects of viscosity-modifying admixtures on homogeneity of concrete were discussed. The results showed that the composition of bridge fair-faced concrete were relatively homogeneous, and the microstructure were relatively dense. When C30 concrete mixed with 5 × 10 -5 cellulose ether or 6% silica fume (mass fraction of cementitious material), air content of fresh concrete were less than 2%, and slurry viscosity values were between 1 900 and 2 000 MPa·s. Also, the micro hardness values in different parts of hardened concrete specimens were closed. The results were applied in practical bridge engineering, which generally meets the apparent quality requirements of bridge fair faced concrete.