MB22木聚糖酶发酵条件的研究

通过因素轮换试验和正交试验,对MB22菌产木聚糖酶的培养基配方和发酵条件进行了研究。结果显示最佳培养基组成是:以玉米芯粉和麸皮为碳源,麸皮120g/l,玉米芯280g/l,(NH4)2SO44g/l,CaCO31.5g/l,Tween80,2.0g/l,MgSO4·7H2O1.5g/l;最佳发酵条件为:起始pH5.0,摇床培养温度30℃,转速160r/min,振荡培养84h。在最佳发酵条件下,MB22菌的最高产酶活力可达898.23U/ml。虽然与一些高产菌株相比该菌株的产酶能力还有待于进一步提高,但该试验结果为进一步进行微生物生产木聚糖酶的研究提供了理论依据。     

漏缝地板发酵床对育肥羊养殖气体排放的影响及微生物学机理

为明确漏缝地板发酵床对育肥羊养殖过程氨(NH₃)和温室气体排放特征的影响机制,本研究设置地面和漏缝地板发酵床两个试验处理,测定分析了育肥羊养殖过程NH₃、氧化亚氮(N₂O)、二氧化碳(CO₂)和甲烷(CH₄)的排放特征,并采用宏基因组学解析了影响上述气体排放的微生物学机理。试验结果表明,与地面相比,漏缝地板发酵床能够显著降低育肥羊养殖过程的NH₃排放(P<0.05),其NH₃排放速率为21.64～58.92 mg·m^-2·h^-1,NH₃累积排放量为86.36±1.06 g·m^-2,减排率达58.60%。漏缝地板发酵床同样也能显著降低育肥羊养殖过程的CH₄排放速率(P<0.05),其CH₄累积排放量为26.66 g·m^-2,减排率可达64.42%。然而,漏缝地板发酵床会使得...     

越红工夫茶加工技术及品牌建设研究

本文阐明了越红工夫茶的历史背景和现状,提出了越红工夫茶鲜叶、萎凋、揉捻、发酵、干燥等初制加工工序的操作方法和技术要求,以规范越红工夫茶加工技术,保持品质特征,稳定产品质量。同时,阐述了对越红工夫茶品牌建设的研究。     

白菜与玫瑰秸秆不同比例混合发酵的产气性能研究

以白菜废弃物和玫瑰秸秆为原料,采用批量厌氧消化工艺,在水浴恒温35±1℃的条件下进行混合发酵,探究不同配比的白菜废弃物与玫瑰秸秆混合发酵的产气潜力和产气特性。结果表明,经过33d的发酵周期,白菜废弃物和玫瑰秸秆以质量比0:3、1:2、2:1、3:0不同配比混合发酵,对应的TS产气率分别为254mL/g、248mL/g、213mL/g和191mL/g。单一玫瑰秸秆发酵的产气潜力最优,单一的白菜废弃物发酵的产气潜力最差,添加花卉能够有效提升蔬菜废弃物的产气效果,白菜废弃物和玫瑰秸秆1:2配比下产气潜力要优于2:1配比组。     

纳豆激酶液体发酵条件的优化

利用单因素及正交试验,对纳豆枯草芽孢杆菌(Bacillus subtilis natto)液体发酵生产纳豆激酶(Nattokinase,NK)的培养基组成(碳氮比和离子组成)和培养条件(温度、pH值、发酵时间、接种量和装液量等)对产酶量的影响进行了研究。结果表明,最佳发酵培养基组成及发酵条件分别为:可溶性淀粉2.0%,大豆蛋白胨1.5%,Na2HPO4·12H2O0.4%,KH2PO40.2%,MgSO4·7H2O0.075%,CaCl20.01%,培养温度37℃,pH值7.0,发酵时间24h,转速180r/min,种龄16h,接种量3%,装液量25mL/250mL。在优化发酵条件基础上,进行了5,20L发酵工艺放大的初步研究,在此条件下,摇瓶,5L罐和20L罐发酵酶活最高分别达到915,1086,946IU/mL。     

基于超星学习通的混合式教学模式应用研究—— 以发酵工程课程为例

为了提高发酵工程课程的教学质量和教学效果,针对发酵工程课程的内容和特点,将互联网+技术与教学相结合,进行了基于超星学习通平台的混合式线上线下教学方式的改革,结果表明:在增强了学生自主学习能力的同时,也促进了教师的自我提升.     

不同比例游离脂肪酸对体外发酵参数的影响

采用体外培养方法研究添加不同比例的亚油酸和亚麻酸对瘤胃发酵的影响。以微晶纤维素为发酵底物,混合酸的添加量为5mg,添加比例分别为0∶0、5∶0、4∶1、3∶2、1∶1、2∶3、1∶4和0∶5,每个处理设4个重复。结果表明:随着游离脂肪酸不饱和度的增加提高了培养液中pH值和NH3-N浓度,降低了挥发脂肪酸、24h微晶纤维素的消失率和产气量。     

热带假丝酵母菌与桑叶黄酮对犊牛营养物质代谢和瘤胃发酵的影响

本文旨在研究饲粮中添加热带假丝酵母菌(CT)与桑叶黄酮(MLF)对断奶前后犊牛能量与氮代谢、瘤胃微生物蛋白合成以及瘤胃发酵的影响。选取(20±2)日龄中国荷斯坦公犊牛48头,随机分为4组,对照组(CON)饲喂基础饲粮,断奶前为代乳品和开食料,断奶后为开食料;CT组在基础饲粮中添加CT;MLF组添加MLF;CM组添加CT和MLF。犊牛于56日龄断奶(代乳品),试验期60 d。分别于犊牛28、42、56和80日龄采集瘤胃液,35和63日龄进行消化代谢试验。结果表明:与CT组相比,CM组犊牛断奶前代谢能显著提高(P0.05),较CON组,断奶后CM组氮利用率显著提高(P0.05);断奶前MLF组较CON和CT组氮的生物学价值显著提高(P0.05)。与CON组相比,CT组显著提高了28~80日龄瘤胃液p H和56、80日龄瘤胃液微生物蛋白含量(P0.05),CT、MLF和CM组瘤胃液氨态氮浓度无显著变化(P0.05);与CON组相比,56日龄M LF组总挥发性脂肪酸浓度和丁酸含量显著提高(P0.05);42日龄乙酸/丙酸CT和MLF组较CON组有提高的趋势(P=0.090),各组间乙酸和戊酸含量无显著差异(P0.05)。结果提示,饲粮添加CT有助于改善断奶前犊牛瘤胃液p H和促进瘤胃微生物蛋白的合成;添加CT和MLF有助于提高断奶前犊牛饲粮代谢能和氮的生物学价值,提高断奶后犊牛总能代谢率和氮的利用率,降低粪能和总排出氮量,同时具有改善瘤胃发酵的作用,并且CT与MLF联合使用效果优于单一添加。     

Influence of storage time and processing on chemical composition and in vitro ruminal fermentation of olive cake

Olive oil extraction generates olive cake (OC) that could be used in ruminant feeding. However, the chemical composition of OC is affected by multiple factors, being therefore highly variable. The objective of this study was to analyse the influence of storage time and further processing: crude, exhausted (subjected to a second oil extraction) and cyclone (obtained from a cyclone separator) on nutritive value of OC samples. Twelve samples (six crude and six exhausted) were obtained monthly from the same pond from 1 to 6 storage months, and nine samples (three crude, three exhausted and three cyclone) were obtained monthly from a different pond from 6 to 9 months storage. Chemical composition was analysed, and OC samples were fermented in vitro with sheep rumen fluid. Increasing storage time up to 6 months decreased sugars and total soluble polyphenols content but increased fibre content in OC. Dry matter effective degradability (DMED) decreased linearly (p < 0.001) by 35.9 and 45.5% as storage time augmented from 1 to 6 months for crude and exhausted OC, respectively. Crude OC had lower DMED values than exhausted OC (averaged values 0.255 and 0.294 g/g, respectively). Both potential production and rate of gas production were lower (p ≤ 0.018) in crude compared with exhausted OC, which was attributed to the high fat content of crude OC (≥86 g/kg dry matter). For samples stored longer than 6 months, cyclone had greater (p < 0.05) DMED than crude and exhausted OC (averaged values 0.207, 0.164 and 0.164 g/g, respectively). The results indicate that ruminal degradability of OC is reduced with advancing storage time, but only subtle changes were observed during the first two months. Cyclone showed greater degradability than crude and exhausted OC, but differences between crude and exhausted OC became negligible after five storage months.     

异戊酸对西门塔尔牛瘤胃发酵及尿嘌呤衍生物的影响

选用4头体重(420±8.6)kg,年龄2.5岁装有永久性瘤胃瘘管的中国西门塔尔牛阉牛,采用4×4拉丁方设计,以混合精料和玉米秸秆为基础日粮,研究异戊酸(0、0.02、0.04和0.06 g/kgW)对瘤胃pH、NH3-N、VFA、营养物质降解率及尿嘌呤衍生物浓度的影响。结果表明:0.06 g/kgW组显著降低瘤胃pH(P<0.05),饲喂后3-6 h,0.04 g/kgW组和0.06 g/kgW组NH3-N浓度显著低于对照和0.02 g/kgW组(P<0.05);0.04 g/kgW组和0.06 g/kgW组,豆粕干物质、有机物质和粗蛋白质有效降解率显著低于对照(P<0.05);0.04 g/kgW组玉米秸秆干物质、有机物质、中性洗涤纤维和酸性洗涤纤维的有效降解率显著提高(P<0.05),0.04 g/kgW组瘤胃乙酸、丁酸、乙酸/丙酸比例、总挥发性脂肪酸和尿嘌呤衍生物显著增加(P<0.05)。异戊酸的适宜添加水平为0.04g/kgW。