Volatile monoterpenes in black currant (Ribes nigrum L.) juice: effects of heating and enzymatic treatment by beta-glucosidase

Changes of terpenes in black currant juice induced by the action of heat were investigated in the present study. Limonene, alpha-terpinene, linalool, alpha-terpineol, 4-terpineol, and menthol added to either black currant juice or a model system were thermally treated at 90 degrees C for 30 min. Similar heat-induced decreases in the concentration of the terpenes were observed in the two systems. The concentration of a range of terpene hydrocarbons and oxygenated terpenes increased, alpha-terpineol being a main conversion product of most of the examined compounds. In the main, the measured loss of compounds exceeded the detected concentrations of products formed. In addition, determination of glycosidically bound terpenes in the juice was carried out by two methods of enzymatic hydrolysis, namely, addition of beta-glucosidase to an Amberlite XAD-2 isolate or directly to black currant juice. The two methods gave the same patterns of seven released volatile aglyconic terpenes. However, none of the released terpenes are important for the odor of black currant juice.     

Microbial stability, phytochemical retention, and organoleptic attributes of dense phase CO2 processed muscadine grape juice

Dense phase CO2 processing (DP-CO2) is a promising alternative to thermal pasteurization potentially inactivating microorganisms without affecting food phytochemicals or organoleptic characteristics. To demonstrate these effects, studies were conducted by changing processing pressure and CO2 concentration in relation to microbial destruction. Subsequent storage stability (10 weeks at 4 degrees C) of muscadine grape juice processed by DP-CO2 (34.5 MPa at 8% or 16% CO2) was evaluated and compared to a heat-pasteurized juice (75 degrees C, 15 s). Thermal pasteurization decreased anthocyanins (16%), soluble phenolics (26%), and antioxidant capacity (10%) whereas no changes were observed for both DP-CO2 juices. DP-CO2 juices also retained higher anthocyanins (335 mg/L), polyphenolics (473 mg/L), and antioxidant capacity (10.9 micromol of Trolox equivalents/mL) than thermally pasteurized juices at the end of storage. Insignificant differences in sensory attributes (color, flavor, aroma, and overall likeability) were observed between unprocessed and DP-CO2 juices, while significant differences were observed between unprocessed and heat-pasteurized juices. Panelists preferred DP-CO2 over heat-pasteurized juices throughout the first 6 weeks of storage, whereby the growth of yeast and mold adversely affected the juice aroma. Comparable microbial counts were observed between DP-CO2 and thermally pasteurized juices during the first 5 weeks of storage. DP-CO2 protected phytochemicals in muscadine juice during processing and storage without compromising microbial stability or sensory attributes over 5 weeks of storage.     

Effect of thermal treatment on the quality of cloudy apple juice

Apple juice from eight different varieties of apples was heated at high-temperature (60-90 degrees C) and short-time (20-100 s) (HTST) combinations. To determine the effect of heating conditions on enzymatic browning and cloud stability in apple juices, the activity of polyphenol oxidase and pectinesterase was analyzed and correlated with the thermal treatment conditions and the quality of the juice. Additional investigations included the measurement of pH value, soluble solid content, titratable acidity, color, and turbidity after 3 and 6 months. The results showed that HTST treatment at 80 degrees C already inactivated polyphenol oxidase, whereas pectinesterase activity was reduced to half and could even at 90 degrees C not be inactivated completely. In fact, highest residual pectinesterase activity was found at 60 degrees C. Heating at 70 degrees C caused stable pectinesterase activity and even a slight increase for 50 and 100 s heating times. Turbidity and lightness increased after HTST treatment. In particular, differences in cloud stability between the varieties were measured. HTST parameters did not correlate with the residual cloud stability after 6 months. The sensory evaluation revealed that only a few combinations were distinguishable. The best stability of cloud and color in relation to heat impact was achieved by HTST treatment between 70 degrees C/100 s and 80 degrees C/20 s.     

Stability and sensory shelf life of orange juice pasteurized by continuous ohmic heating

Electrical heating of food products provides rapid and uniform heating, resulting in less thermal damage to the product. The objective of this research was to examine the effects of ohmic heating on the stability of orange juice with comparison to conventional pasteurization. During storage at 4 degrees C, degradation curves of ascorbic acid followed a linear decrease pattern in both ohmic-heated and conventionally pasteurized orange juices. For five representative flavor compounds (decanal, octana, limonene, pinene, and myrcene), higher concentrations were measured during storage in the ohmic-heated orange juice than in conventionally pasteurized juice. Although residual pectin esterase activity remained negligible in both types of juices, particle size was lower in the ohmic-heated orange juice. The sensory shelf life was determined by using the Weibull-Hazard method. Although both thermal treatments prevented the growth of microorganisms for 105 days, the sensory shelf life of ohmic-treated orange juice was >100 days and was almost 2 times longer than that of conventionally pasteurized juice.     

Carotenoid profile modification during refrigerated storage in untreated and pasteurized orange juice and orange juice treated with high-intensity pulsed electric fields

A comparative study was made of the evolution and modification of various carotenoids and vitamin A in untreated orange juice, pasteurized orange juice (90 degrees C, 20 s), and orange juice processed with high-intensity pulsed electric fields (HIPEF) (30 kV/cm, 100 micros), during 7 weeks of storage at 2 and 10 degrees C. The concentration of total carotenoids in the untreated juice decreased by 12.6% when the juice was pasteurized, whereas the decrease was only 6.7% when the juice was treated with HIPEF. Vitamin A was greatest in the untreated orange juice, followed by orange juice treated with HIPEF (decrease of 7.52%) and, last, pasteurized orange juice (decrease of 15.62%). The decrease in the concentrations of total carotenoids and vitamin A during storage in refrigeration was greater in the untreated orange juice and the pasteurized juice than in the juice treated with HIPEF. During storage at 10 degrees C, auroxanthin formed in the untreated juice and in the juice treated with HIPEF. This carotenoid is a degradation product of violaxanthin. The concentration of antheraxanthin decreased during storage, and it was converted into mutatoxanthin, except in the untreated and pasteurized orange juices stored at 2 degrees C.     

锦橙汁辐照和巴氏灭菌处理后相关品质的分析

为探讨辐照和巴氏杀菌对橙汁品质的影响,对锦橙汁分别进行1.4、2.8、5.6kGy3种不同剂量辐照及巴氏灭菌处理,使用固相微萃取-气质联用技术对挥发性成分进行分析,测定橙汁色度、pH值和Vc含量,并对橙汁香气进行感官评定。在鲜橙汁、巴氏灭菌汁和3种辐照样品中分别检测到了54、47、57、55和53种成分,2.8kGy剂量辐照处理后橙汁挥发性成分总峰面积最高,β-月桂烯、柠檬烯和γ-松油烯等橙汁特征香气物质经辐照后保持率高于巴氏灭菌。各种处理后Vc含量均有所下降,橙汁橙香均减弱。1.4kGy辐照后的橙汁感官评价结果最好,因此可以对橙汁进行低剂量辐照灭菌。     

Effect of ultrahigh-temperature continuous ohmic heating treatment on fresh orange juice

The scope of this study is the effect of ohmic heating thermal treatment on liquid fruit juice made of oranges. Effects of ohmic heating on the quality of orange juice were examined and compared to those of heat pasteurization at 90 degrees C for 50 s. Orange juice was treated at temperatures of 90, 120, and 150 degrees C for 1.13, 0.85, and 0.68 s in an ohmic heating system. Microbial counts showed complete inactivation of bacteria, yeast, and mold during ohmic and conventional treatments. The ohmic heating treatment reduced pectin esterase activity by 98%. The reduction in vitamin C was 15%. Ohmic-heated orange juice maintained higher amounts of the five representative flavor compounds than did heat-pasteurized juice. Sensory evaluation tests showed no difference between fresh and ohmic-heated orange juice. Thus, high-temperature ohmic-heating treatment can be effectively used to pasteurize fresh orange juice with minimal sensory deterioration.     

Comparison of isolation methods for the determination of important aroma compounds in black currant (Ribes nigrum L.) juice, using nasal impact frequency profiling

The influence of isolation method on the determination of important aroma compounds in black currant juice was investigated by surface of nasal impact frequency (SNIF) gas chromatography-olfactometry (GC-O). The applied methods were solvent extraction, static headspace, and purge and trap using 15 and 60 min of purge time. By the four methods, a total of 59 odors were observed, and, of these, 44 corresponded to compounds that could be identified. For the headspace methods increasing purge volumes resulted in recoveries of additional, less volatile compounds. The main compound groups recovered by the headspace methods were esters and terpenes, whereas compounds recovered by solvent extraction were not as dominated by fruity odors. For most compounds there was agreement between the size of the SNIF value obtained by GC-O and the amount of the measurable compound found by gas chromatography-mass spectrometry.     

Effect of black currant anthocyanins on the activation of endothelial nitric oxide synthase (eNOS) in vitro in human endothelial cells

Polyphenols are known to induce vasodilatory function via activation of the redox-sensitive phosphatidylinositol-3 (PI3)/protein kinase B (Akt) pathway. Black currant fruits have appreciable amounts of polyphenolic compounds including cyanidin-3-O-glucoside, cyanidin-3-O-rutinoside, delphinidin-3-O-glucoside, and delphinidin-3-O-rutinoside. It was hypothesized that black currant fruit extracts would cause activation of endothelial nitric oxide synthase (eNOS) through activation of redox-sensitive PI3 kinase/Akt signaling pathway. To test this hypothesis, human umbilical vein endothelial cells (HUVECs) were treated with different concentrations/times of black currant juice concentrates (Ben Gairn and Ben Hope) and the activation of Akt and eNOS was measured using immunoblotting. Vitamin C is also known to activate Akt and eNOS in in vitro models, and black currants are rich in vitamin C. Therefore, the effect of black currant extracts with and without coexisting vitamin C was investigated, using SPE columns to eliminate vitamin C content. The individual (and combined) effects of the major anthocyanins present in black currant juice samples with and without vitamin C were investigated and compared to the effects of the whole extract. Black currant juice samples (1 μL/mL) significantly increased the phosphorylation of Akt (p-Akt) and eNOS (p-eNOS) (P < 0.05). Activation of Akt and eNOS was abolished by incubation with wortmannin, a PI3K inhibitor, supporting the involvement of PI3K/Akt. Vitamin C alone significantly increased the p-Akt and p-eNOS (P < 0.05); however, removal of vitamin C from black currant did not significantly affect p-Akt and p-eNOS compared to black currant with vitamin C. Assessment of individual anthocyanins also showed significant effects on p-Akt and p-eNOS. In summary, in the present study data suggested that black currant concentrates, Ben Gairn and Ben Hope, activated eNOS via Akt/PI3 kinase pathway in vitro in HUVECs and that the effect was not dependent on vitamin C.     

Flavor, color, and vitamin C retention of pulsed electric field processed orange juice in different packaging materials

Effects of packaging materials, storage temperature, and time on the stability of pulsed electric field (PEF) processed orange juice were investigated. Single-strength orange juice was treated with PEF at an electric field strength of 35 kV/cm for 59 micros using an integrated pilot plant scale PEF processing and glovebox packaging system. The retention of eight orange juice aroma compounds, color, and vitamin C in glass, polyethylene terephthalate (PET), high-density polyethylene, and low-density polyethylene were evaluated at 4 and 22 degrees C for 112 days. Packaging material had a significant effect (p < or = 0.05) on the retention of orange juice aroma compounds, color, and vitamin C. PEF-treated orange juice had a shelf life of >16 weeks in glass and PET at 4 degrees C.     

Protease-assisted clarification of black currant juice: synergy with other clarifying agents and effects on the phenol content

Conventional clarification with gelatin and silica sol removes a considerable amount of antioxidant phenolics from berry juices. This study examined the clarification and haze-diminishing effects of alternative clarification strategies on black currant juice including centrifugation and addition of acidic protease and pectinolytic enzyme preparations and gallic acid. Centrifugation of freshly pressed juice (10,000 g for 15 min) resulted in a approximately 95% reduction of immediate turbidity and had a decreasing effect on haze development in the juice during cold storage without significantly compromising the total phenols levels. The extent of clarification and haze diminishment varied after individual treatments with five different acidic proteases, but one of the protease preparations, Enzeco, derived from Aspergillus niger, consistently tended to perform best. The individual and interactive effects on juice turbidity, total phenols, and total anthocyanin contents of clarification treatments involving the use of two selected acid proteases (Enzeco and Novozyme 89L), a pectinase (Pectinex BE 3-L), and gallic acid were evaluated in a full factorial 2(4) experimental design. Haze development during cold storage decreased when gallic acid or any of the enzyme preparations were employed individually, but negative interaction effects resulted when the pectinase was employed in combination with any of the proteases. After 28 storage days at 2 degrees C, the lowest levels of haze formation were achieved when the Enzeco protease preparation, added at 0.025 g/L, was added with 0.050 g/L of gallic acid and allowed to react in the juice for 90 min at 50 degrees C. The corresponding anthocyanin reduction was approximately 12% (compared to approximately 30% with gelatin silica sol treatment). The data support the hypothesis that phenol-protein interactions are involved in juice turbidity development during cold storage of berry juices and demonstrate that precentrifugation and protease-assisted clarification show promise as an alternative, phenolics-retaining clarification strategy in black currant juice processing.     

Optimization of solid-phase microextraction analysis for studying change of headspace flavor compounds of banana during ripening

The changes of headspace flavor compounds of banana during ripening were studied by a solid-phase microextraction (SPME) method. Three temperatures, 20, 25, and 30 degrees C, were used to investigate the temperature effect on the changes of headspace flavor compounds of banana during ripening over a period of 8 days. Banana juice concentration, salt concentration, time, and temperature were investigated for optimizing the SPME method. The most suitable concentrations of banana juice and salt were 33.3 and 20%, respectively. The optimal temperature and time are about 50 degrees C and 48 min, respectively. Increasing ripening temperature could accelerate ripening rate. Ethanol developed most rapidly at 30 degrees C, whereas amounts of the other investigated flavor compounds stored at 25 degrees C were greater than those of the ones stored at 20 or 30 degrees C.     

2-Methyl-3-furanthiol and methional are possible off-flavors in stored orange juice: aroma-similarity, NIF/SNIF GC-O, and GC analyses.

The occurrence of methional in fresh orange juice, and possible occurrence of beta-damascenone in heated orange juice, has been previously suggested. Here we report on the occurrence of 2-methyl-3-furanthiol in the headspace, collected by solid-phase micro-extraction, of fresh, pasteurized, and stored orange juice. The contents of 2-methyl-3-furanthiol and methional were quantified, and the relative level of beta-damascenone was estimated, in the headspace of fresh, pasteurized, and stored orange juices using the nasal impact frequency (NIF) and surface of NIF (SNIF) GC-Olfactometry procedure. 2-Methyl-3-furanthiol concentrations were 2 ng/L in fresh and pasteurized Shamuti orange juice, and 270 ng/L in stored juice of the same variety. Methional concentrations were 550, 830, and 11,550 ng/L in fresh, pasteurized, and stored pasteurized juices, respectively. beta-Damascenone content appeared to have increased during pasteurization and storage. Aroma-similarity experiments strongly suggest that 2-methyl-3-furanthiol and methional, at the levels found in stored orange juice (21 days at 35 degrees C), contribute to stored orange juice off-flavor.     

Changes in the aroma of a strawberry drink during storage.

The flavor of a commercially available strawberry drink was investigated with special regard to the changes of the sensory properties during the shelf life of the product. The experiments were performed using gas chromatographic methods after liquid-liquid extraction and after solid-phase microextraction of the headspace. A trained sensory test panel was used to substantiate the results from instrumental analyses. The relative concentrations of several compounds were followed over a storage period of six weeks at elevated temperature (37 degrees C), which corresponds to about 12 months storage at room temperature. Significant concentration changes of several flavor compounds were determined after a short storage time. These results correlate highly with changes in the aroma observed by the sensory test panel. Further on, changes in the sensorial relevance of aroma active compounds were monitored by comparative aroma extract dilution analysis of extracts of the fresh product and the product at the end of the declared shelf-life time. The results showed a significant decrease in flavor dilution factors of compounds with characteristic fruity attributes.     

Processing and storage effects on orange juice aroma: a review

Freshly squeezed orange juice aroma is due to a complex mixture of volatile compounds as it lacks a specific character impact compound. Fresh hand-extracted juice is unstable, and thermal processing is required to reduce enzyme and microbial activity. Heating protocols range from the lightly heated not from concentrate, NFC, to the twice heated, reconstituted from concentrate, RFC, juices. Thermal processing profoundly effects aroma composition. Aroma volatiles are further altered by subsequent time-temperature storage conditions. Heating reduces levels of reactive aroma impact compounds such as neral and geranial, and creates off-flavors or their precursors from Maillard, Strecker, and acid catalyzed hydration reactions. Off-flavors such as 4-vinylguaiacol, p-cymene, and carvone are the products of chemical reactions. Other off-flavors such as butane-2,3-dione, guaiacol, and 2,6-dichlorophenol are indicators of microbial contaminations. Since most orange juice consumed worldwide is processed, the goal of this review is to summarize the widely scattered reports on orange juice aroma differences in the three major juice products and subsequent aroma changes due to packaging, storage, and microbial contamination with special emphasis on results from GC-O studies.     

Degradation kinetics of the antioxidant additive ascorbic acid in packed table olives during storage at different temperatures

The kinetics of ascorbic acid (AA) loss during storage of packed table olives with two different levels of added AA was investigated. Three selected storage temperatures were assayed: 10 degrees C, ambient (20-24 degrees C), and 40 degrees C. The study was carried out in both pasteurized and unpasteurized product. The effect of pasteurization treatment alone on added AA was not significant. In the pasteurized product, in general AA degraded following a first-order kinetics. The activation energy calculated by using the Arrhenius model averaged 9 kcal/mol. For each storage temperature, the increase in initial AA concentration significantly decreased the AA degradation rate. In the unpasteurized product, AA was not detected after 20 days in samples stored at room temperature and AA degradation followed zero-order kinetics at 10 degrees C, whereas at 40 degrees C a second-order reaction showed the best fit. In both pasteurized and unpasteurized product, the low level of initial dehydroascorbic acid disappeared during storage. Furfural appeared to be formed during storage, mainly at 40 degrees C, following zero-order kinetics.     

Combined influence of NaCl and sucrose on heat-induced gelation of bovine serum albumin

The combined influence of a strongly interacting cosolvent (NaCl) and a weakly interacting cosolvent (sucrose) on the heat-induced gelation of bovine serum albumin (BSA) was studied. The dynamic shear rheology of 4 wt % BSA solutions containing 0 or 20 wt % sucrose and 0-200 mM NaCl was monitored as they were heated from 30 to 90 degrees C at 1.5 degrees C min(-)(1), held at 90 degrees C for 120 min, and then cooled back to 30 degrees C at -1.5 degrees C min(-)(1). The turbidity of the same solutions was monitored as they were heated from 30 to 95 degrees C at 1.5 degrees C min(-)(1) or held isothermally at 90 degrees C for 10 min. NaCl had a similar effect on BSA solutions that contained 0 or 20 wt % sucrose, with the gelation temperature decreasing and the final gel strength increasing with increasing salt concentration and the greatest changes occurring between 25 and 100 mM NaCl. Nevertheless, the presence of sucrose did lead to an increase in the gelation temperature and final gel strength and a decrease in the final gel turbidity. The impact of NaCl on gel characteristics was attributed primarily to its ability to screen electrostatic interactions between charged protein surfaces, whereas the impact of sucrose was attributed mainly to its ability to increase protein thermal stability and strengthen the attractive forces between proteins through a preferential interaction mechanism.     

Anthocyanin-flavanol condensation products from black currant (Ribes nigrum L.)

Putative flavanol-anthocyanin condensation products were detected in a polyphenol-rich concentrate from black currant (Ribes nigrum L.). These compounds had UV-vis spectra similar to those of delphinidin-3-O-rutinoside and cyanidin-3-O-rutinoside, but eluted before all previously described anthocyanins on reversed phase HPLC. Mass spectrometric data indicated that they were rutinoside derivatives of novel aglycons 304 amu greater than delphinidin and cyanidin, respectively. The compounds were partly purified by semipreparative HPLC and gave MS and MS2 spectra consistent with anthocyanin rutinosides covalently linked to epigallocatechin or gallocatechin. These compounds are similar in structure to compounds thought to influence color and quality in red wines and strawberry juice products. There was also evidence for the presence of a range of other flavanol-anthocyanin condensation products. The compounds were present at differing levels in juices of 10 black currant varieties, which were roughly correlated to the content of the parent anthocyanins. The flavanol-anthocyanin products were present in polyphenol-enriched concentrates obtained by solid phase extraction, in commercially produced concentrates, and in fresh extracts of black currants. This suggests that the compounds were not artifacts formed during concentration or purification. However, differences in their comparative contents may be related to the lability of the parent anthocyanins during processing. Although present at low levels, the flavanol-anthocyanin products may influence color or quality parameters of black currant juices, and they may confer enhanced stability to the biological activities reported for their anthocyanin parents.     

Use of 2-furoylmethyl derivatives of GABA and arginine as indicators of the initial steps of maillard reaction in orange juice

The formation of 2-furoylmethyl derivatives of GABA (2-FM-GABA) and arginine (2-FM-Arg) as early indicators of nonenzymatic browning in different types of orange juice was studied. In dehydrated orange juice, the presence of 2-FM-GABA and 2-FM-Arg was detected from the first day of storage at 30 degrees C. In this type of juice, the content of these two compounds increased with temperature (30, 50 degrees C) and time (1-7 days) of storage. A noticeable increase in 5-hydroxymethylfurfural was only observed after 4 days of storage at 50 degrees C. No formation of 2-FM-GABA and 2-FM-Arg was detected in liquid orange juice heated under conditions similar to those used in the industry. These furoylmethyl derivatives were also found in commercial orange juice made from concentrates. A slight increase in their concentration was observed in the two samples stored during 8 months at room temperature. According to the results obtained, 2-FM-GABA and 2-FM-Arg contents could be suitable indicators to assess the main modifications due to Maillard reaction produced during the manufacture and/or storage of orange juice concentrates.     

Enzyme-assisted extraction of antioxidative phenols from black currant juice press residues (Ribes nigrum).

Enzymatic release of phenolic compounds from pomace remaining from black currant (Ribes nigrum) juice production was examined. Treatment with each of the commercial pectinolytic enzyme preparations Grindamyl pectinase, Macer8 FJ, Macer8 R, and Pectinex BE, as well as treatment with Novozym 89 protease, significantly increased plant cell wall breakdown of the pomace. Each of the tested enzyme preparations except Grindamyl pectinase also significantly enhanced the amount of phenols extracted from the pomace. Macer8 FJ and Macer8 R decreased the extraction yields of anthocyanins, whereas Pectinex BE and Novozym 89 protease showed no effect. A decrease in pomace particle sizes from 500-1000 microm to <125 microm increased the phenol yields 1.6-5 times. Black currant pomace devoid of seeds gave significantly higher yields of phenols than pomace with seeds and seedless wine pomace. Four selected black currant pomace extracts all exerted a pronounced antioxidant activity against human LDL oxidation in vitro when tested at equimolar phenol concentrations of 7.5-10 microM.