Organ weight, intestinal morphology, and fasting whole-body oxygen consumption in growing pigs fed diets containing distillers dried grains with solubles alone or in combination with a multienzyme supplement

The effects of adding a multienzyme complex to a diet containing distillers dried grains with solubles (DDGS) produced from a 1:1 mixture of corn and wheat on visceral organ weight, intestinal morphology, and fasting whole-body oxygen consumption (FWBOC) were investigated in growing pigs in a 28-d trial. Twenty-four pigs (BW = 19.9 ± 0.5 kg) were individually housed in floor pens and randomly assigned to 3 experimental diets (8 pigs per diet). The diets contained corn and soybean meal with 0% (control) or 30% DDGS (DDGS diet); the third diet was supplemented with a multienzyme complex in addition to the 30% DDGS (DDGS + enzyme diet). All diets had similar nutrient concentrations and met the 1998 NRC nutrient requirements for growing pigs. Pigs were fed at 4% of their BW once daily. On d 15, 4 pigs from each dietary treatment were randomly selected for measurement of FWBOC during the 24- to 30-h postprandial period using an open-circuit indirect calorimeter. At the end of the study, pigs were killed to determine visceral organ weights, ileal and cecal digesta viscosity, and intestinal morphology. There was no effect (P > 0.05) of dietary treatment on final BW, WBFOC, or digesta viscosity. Empty BW of pigs fed the control diet was heavier (P = 0.02) than that of pigs fed the DDGS diet, but the empty BW of pigs fed the DDGS + enzyme diet was not different (P > 0.05) from that of pigs fed the control or DDGS diet. There were no differences (P > 0.05) in empty BW of liver, spleen, pancreas, heart, stomach, small intestine, and cecum among dietary treatments on a per kilogram basis. However, pigs fed the DDGS diet had heavier (P < 0.05) colon plus rectum and portal-drained viscera (PDV) than pigs fed the control diet, but weights of colon plus rectum and PDV in pigs fed the DDGS + enzyme diet were not different (P > 0.05) from those of pigs fed the control diet. Although morphological data showed no differences (P > 0.05) in the duodenum, jejunum, and colon segments among dietary treatments, the DDGS diet tended to decrease (P < 0.10) villous height and villous height to crypt depth in the ileum. The results of this experiment indicated that pigs fed a diet containing 30% DDGS have reduced dressing percentage and increased visceral organ mass compared with pigs fed a corn-soybean meal diet. However, the addition of a multienzyme complex to the DDGS diet resulted in pigs having a dressing percentage and visceral organ mass that are not different from those of pigs fed a corn-soybean meal diet.     

Evaluation of methods to reduce bacteria concentrations in spray-dried animal plasma and its effects on nursery pig performance

Four experiments with 1,040 weanling pigs (17 +/- 2 d of age at weaning) were conducted to evaluate the effects of spray-dried animal plasma source, drying technique, and methods of bacterial reduction on nursery pig performance. In Exp. 1, 180 barrows and gilts (initial BW 5.9 +/- 1.8 kg) were used to compare effects of animal plasma, animal plasma source, drying technique (spray-dried or freeze-dried), and plasma irradiation in nursery pig diets. From d 0 to 10, pigs fed diets containing irradiated spray-dried animal plasma had increased ADG and ADFI (P < 0.05) compared with pigs fed diets containing nonirradiated spray-dried animal plasma. Pigs fed irradiated animal plasma Sources 1 and 2 were similar in ADG and ADFI, but pigs fed animal plasma Source 1 had greater ADG (P < 0.05) than pigs fed animal plasma Source 2 and pigs not fed plasma. Pigs fed freeze-dried animal plasma had growth performance similar (P > 0.36) to pigs fed spray-dried animal plasma. Overall (d 0 to 24), pigs fed irradiated spray-dried animal plasma were heavier (P < 0.05) than pigs fed no animal plasma, whereas pigs fed nonirradiated spray-dried plasma were intermediate. In Exp. 2, 325 barrows and gilts (initial BW 5.8 +/- 1.7 kg) were used to compare the effects of irradiation or formaldehyde treatment of animal plasma and formaldehyde treatment of the whole diet. Pigs fed diets containing irradiated animal plasma had greater ADG (P < 0.05) than pigs fed nonirradiated plasma. Pigs fed formaldehyde-treated plasma had greater ADG and ADFI (P < 0.05) than pigs fed diets with either nonirradiated plasma or whole diet treated with formaldehyde. In Exp. 3 (360 barrows and gilts; initial BW 6.3 +/- 2.7 kg) and Exp. 4 (175 barrows and gilts; initial BW 6.1 +/- 1.7 kg), the irradiation of feed (high bacteria) and food-grade (low bacteria) animal plasma in nursery pig diets was examined. Pigs fed irradiated feed-grade plasma Product 2 had increased ADG (P < 0.05) compared with pigs fed nonirradiated plasma Product 2 and pigs fed the control diet without plasma. In Exp. 3 and 4, pigs fed irradiated food-grade plasma had growth performance similar to pigs fed nonirradiated food-grade plasma (P > 0.12). These studies indicate that bacterial reduction of feed-grade, but not food-grade animal plasma, improves nursery pig performance.     

Growth performance, diet apparent digestibility, and plasma metabolite concentrations of barrows fed corn-soybean meal diets or low-protein, amino acid-supplemented diets at different feeding level

Two experiments, each with 36 barrows with high-lean-gain potential, were conducted to evaluate apparent nutrient digestibilities and performance and plasma metabolites of pigs fed corn-soybean meal diets (CONTROL) and low-protein diets. The low-protein diets were supplemented with crystalline lysine, threonine, tryptophan, and methionine either on an ideal protein basis (IDEAL) or in a pattern similar to that of the control diet (AACON). Amino acids were added on a true ileally digestible basis. The initial and final BW were, respectively, 31.5 and 82.3 kg in Exp. 1 and 32.7 and 57.1 kg in Exp. 2. In Exp. 1, the CONTROL and IDEAL diets were offered on an ad libitum basis or by feeding 90 or 80% of ad libitum intake. Pigs were fed for 55 d. In Exp. 2, the CONTROL, IDEAL, and AACON diets were offered on an ad libitum basis or by feeding 80% of the ad libitum intake. Pigs were fed for 27 d. Pigs fed the CONTROL diet had greater (P < 0.05) ADG and feed efficiency (G/F) than pigs fed the IDEAL (Exp. 1 and 2) and AACON diets (Exp. 2). As the level of feed intake decreased, ADG decreased (P < 0.05), but G/F tended to improve (P < 0.10) for pigs fed 90% of ad libitum in Exp. 1 and for pigs fed 80% of ad libitum in Exp. 2. In Exp. 1, the apparent total tract digestibilities of DM and energy were greater (P < 0.01) for pigs fed the IDEAL diet than for pigs fed the CONTROL diet. In Exp. 2, the apparent total tract digestibility of protein was greatest in pigs fed the CONTROL diet (P < 0.05) and was greater (P < 0.05) in pigs fed the AACON diet than in pigs fed the IDEAL diet. Plasma urea concentrations were lower in pigs fed the IDEAL diet than in pigs fed the CONTROL diet, regardless of feeding level. For pigs fed the CONTROL diet, plasma urea concentrations were lower when feed intake was 80% of ad libitum (diet level, P < 0.01). In summary, pigs fed the IDEAL and the AACON diets gained less and had lower plasma urea concentrations than pigs fed the CONTROL diet. Based on these data, it seems that the growth potential of pigs fed the IDEAL and AACON diets may have been limited by a deficiency of lysine, threonine, and(or) tryptophan and that the amino acid pattern(s) used was not ideal for these pigs.     

Effects of dietary iodine value product on growth performance and carcass fat quality of finishing pigs

A total of 120 barrows (initial BW = 47.9 ± 3.6 kg; PIC 1050) were used in an 83-d study to determine the effects of dietary iodine value (IV) product (IVP) on growth performance and fat quality. Pigs were blocked by BW and randomly allotted to 1 of 6 treatments with 2 pigs per pen and 10 pens per treatment. Dietary treatments were fed in 3 phases and formulated to 3 IVP concentrations (low, medium, and high) in each phase. Treatments were 1) corn-soybean meal control diet with no added fat (low IVP), 2) corn-extruded expelled soybean meal (EESM) diet with no added fat (medium IVP), 3) corn-soybean meal diet with 15% distillers dried grains with solubles and choice white grease (DDGS + CWG; medium IVP), 4) corn-soybean meal diet with low CWG (medium IVP), 5) corn-EESM diet with 15% DDGS (high IVP), and 6) corn-soybean meal diet with high CWG (high IVP). On d 83, pigs were slaughtered and backfat and jowl fat samples were collected and analyzed. The calculated and analyzed dietary IVP values were highly correlated (r(2) = 0.86, P < 0.01). Pigs fed the control diet, EESM, or high CWG had greater (P < 0.05) ADG than pigs fed EESM + DDGS. Pigs fed the control diet had greater (P < 0.05) ADFI than pigs fed all other diets. Pigs fed EESM + DDGS and high CWG had improved (P < 0.05) G:F compared with pigs fed the control diet or DDGS + CWG. Pigs fed diets with DDGS had greater (P < 0.05) backfat and jowl fat IV, C18:2n-6, and PUFA and less SFA than pigs fed all other treatments. Pigs fed EESM had greater (P < 0.05) backfat and jowl fat IV, C18:2n-6, and PUFA than pigs fed the control diet, low CWG, or high CWG. Pigs fed low CWG or high CWG had greater (P < 0.05) jowl fat IV than control pigs. Feeding ingredients high in unsaturated fatty acids, such as DDGS and EESM, had a greater impact on fat IV than CWG, even when diet IVP was similar. Therefore, IVP was a poor predictor of carcass fat IV in pigs fed diets with different fat sources and amounts of unsaturated fats formulated with similar IVP. Dietary C18:2n-6 content was a better predictor of carcass fat IV than diet IVP.     

Effects of pantothenic acid on growth performance and carcass characteristics of growing-finishing pigs fed diets with or without ractopamine hydrochloride

Two experiments evaluated effects of added pantothenic acid on performance of growing-finishing pigs. In Exp. 1, 156 pigs (PIC, initial BW = 25.7 kg) were used in a 3 x 2 x 2 factorial to evaluate the effects of added pantothenic acid (PA; 0, 22.5, or 45 ppm), ractopamine.HCl (RAC; 0 or 10 mg/kg), and sex on growth performance and carcass traits. Pigs were fed increasing PA from 25.7 to 123.6 kg (d 0 to 98) and RAC for the last 28 d before slaughter. Increasing the amount of added PA had no effect (P > 0.40) on ADG, ADFI, or G:F from d 0 to 70. A PA x sex interaction (P < 0.03) was observed for ADG and G:F from d 71 to 98. Increasing the amount of added PA increased ADG and G:F in gilts, but not in barrows. Increasing the amount of added PA had no effect (P > 0.38) on carcass traits. Added RAC increased (P < 0.01) ADG and G:F for d 71 to 98 and d 0 to 98 and increased (P < 0.01) LM area and percentage lean. In Exp. 2, 1,080 pigs (PIC, initial BW = 40.4 kg, final BW = 123.6 kg) were used to determine the effects of increasing PA on growth performance and carcass characteristics of growing-finishing pigs reared in a commercial finishing facility. Pigs were fed 0, 22.5, 45.0, or 90 mg/kg of added PA. Increasing the amount of added PA had no effect (P > 0.45) on ADG, ADFI, or G:F, and no differences were observed (P > 0.07) for carcass traits. In summary, adding dietary PA to diets during the growing-finishing phase did not provide any advantages in growth performance or carcass composition of growing-finishing pigs. Furthermore, it appears that the pantothenic acid in corn and soybean meal may be sufficient to meet the requirements of 25- to 120-kg pigs.     

Dietary supplementation with phosphorylated mannans improves growth response and modulates immune function of weanling pigs

Phosphorylated mannans derived from the yeast cell wall of Saccharomyces cerevisiae may beneficially modulate immune function in the weanling pig, possibly providing an alternative to the use of dietary growth-promoting antibiotics. Therefore, in this study, 32 pigs averaging 19 d of age and 5.7 +/- 0.2 kg initial BW were randomly assigned to 16 pens in an environmentally controlled nursery to determine the effects of dietary supplementation with phosphorylated mannans on growth and immune function. Average daily gain and G:F ratio increased (P < 0.05) when pigs were fed diets supplemented with mannans from d 0 to 14 after weaning and in the overall experiment. Percentage of neutrophils was lower (P < 0.08) and percentage of lymphocytes was higher (P < 0.05) in blood from pigs fed mannans than when pigs were fed the basal diet. Lamina propria macrophages isolated from pigs fed diets containing mannans phagocytosed a greater (P < 0.05) number of sheep red blood cells (2.63 +/- 0.11) than did lamina propria macrophages isolated from pigs fed the basal diet (2.31 +/- 0.11). On d 19 after weaning, pigs fed diets supplemented with mannans tended to have a greater (P < 0.10) percentage of CD14+ lamina propria leukocytes than did pigs fed the basal diet. On d 21 following weaning, the percentage of CD14+MHCII+ leukocytes isolated from lamina propria tissue tended (P < 0.10) to be lower when pigs were fed mannans than when pigs were fed the basal diet. Pigs fed diets containing mannans had a lower (P < 0.05) ratio of CD3+CD4+:CD3+CD8+ T lymphocytes isolated from jejunal lamina propria tissue only on d 21 after weaning compared with pigs fed the basal diet. Supplementation of mannans in the diets of weanling pigs improved gain and efficiency, and intermittently affected selected components of the young pigs' immune function both systemically and enterically.     

Glycemic index of starch affects nitrogen retention in grower pigs

Three studies were performed to examine the effect of starch and protein digestion rates on N retention in grower pigs. In Exp. 1, the glycemic index (GI) of corn, a malting barley, and a slow-rumen-degradable barley (SRD-barley) were measured using 6 barrows (BW = 18.0 ± 0.5 kg). The GI of malting barley was greater (P < 0.05) than that of SRD-barley (71.1 vs. 49.4), and the GI of both barley cultivars was less (P < 0.05) than that of corn (104.8). In Exp. 2, the standardized ileal digestibility of AA and DE content of the 3 ingredients were determined using 5 ileal-cannulated barrows (BW = 20.7 ± 2.3). The apparent total-tract energy digestibility values of corn (86.1%) and malting barley (85.7%) were greater (P < 0.05) than that of SRD-barley (82.3%). The standardized ileal digestibility of Lys was 94.0, 92.6, and 92.4% for corn, malting barley, and SRD-barley, respectively, and did not differ among grains. In Exp. 3, 6 diets were formulated to equal DE (3.40 Mcal/kg), standardized ileal digestibility of Lys (8.6 g/kg), starch (424.9 g/kg), and digestible CP (180.0 g/kg) using the values obtained in Exp. 2. Three GI [high (corn), medium (malting barley), and low (SRD-barley)] and 2 rates of protein digestion [rapid (soy protein hydrolysate) and slow (soy protein isolate)] were tested in a 3 × 2 factorial arrangement with 36 barrows (BW = 32.2 ± 2.5 kg). Pigs were fed 3.0 times the maintenance energy requirement daily in 2 meals for 2 wk and were housed in metabolic crates to collect feces and urine separately. At the end of the study, intestinal contents were collected from 4 equal-length segments of the small intestine. The percentage of unabsorbed CP in segment 1 relative to dietary CP was greater (P < 0.05) for the soy protein isolate diet than for the soy protein hydrolysate diet (170.3 vs. 116.5%). The percentages of unabsorbed starch in segments 1 and 2 were greater (P < 0.05) for the SRD-barley diet than for the malting barley or corn diet. Nitrogen intake and fecal N excretion were greater (P < 0.05) for pigs fed the malting barley and SRD-barley diets than for pigs fed the corn diet. Urinary N excretion was greater (P < 0.05) for pigs fed the SRD-barley diet than for pigs fed the corn or malting barley diet. Pigs fed slowly digestible starch (SRD-barley; 46.6%) had less (P < 0.05) net N retention than pigs fed corn or malting barley (54.7 and 54.1%, respectively). In conclusion, slowly digestible starch sources such as SRD-barley may not be suitable to support maximum protein deposition in restricted-fed grower pigs.     

Effects of increasing choice white grease in corn- and sorghum-based diets on growth performance, carcass characteristics, and fat quality characteristics of finishing pigs

A total of 120 pigs (60 barrows and 60 gilts; TR4 × PIC 1050; 54.4 kg initial BW) were used in an 83-d study to evaluate the effects of added fat in corn- and sorghum-based diets on growth performance, carcass characteristics, and carcass fat quality. Treatments were arranged in a 2 × 3 factorial with grain source (corn or sorghum) and added fat (0, 2.5, or 5% choice white grease; CWG) as factors. There were 2 pigs (1 barrow and 1 gilt) per pen and 10 replicate pens per treatment. Pigs and feeders were weighed on d 14, 22, 39, 53, 67, and 83 to calculate ADG, ADFI, and G:F. At the end of the trial, pigs were slaughtered and jowl fat and backfat samples were collected and analyzed for fatty acid profile. No interactions were observed for growth performance. Pigs fed sorghum-based diets had greater (P < 0.01) ADG than pigs fed corn-based diets. Adding CWG improved (linear, P < 0.01) ADG. Pigs fed corn-based diets tended to have greater (P < 0.09) carcass yield, 10th-rib backfat, and percentage lean than pigs fed sorghum-based diets. Adding CWG increased (linear, P = 0.02) 10th-rib backfat, tended to increase (linear, P = 0.08) HCW, and tended to decrease (linear, P = 0.07) percentage lean. There was no grain source × fat level interaction for iodine value (IV) in backfat, but an interaction (P = 0.03) was observed for IV in jowl fat. Adding CWG increased (P < 0.01) IV in jowl fat for pigs fed sorghum- and corn-based diets; however, the greatest increase was between 0 and 2.5% CWG in sorghum-based diets and between 2.5 and 5% CWG in corn-based diets. Pigs fed corn-based diets had less (P = 0.01) C18:1 cis-9 and MUFA but greater (P = 0.01) C18:2n-6, PUFA, and backfat IV than pigs fed sorghum-based diets. Increasing CWG in the diet increased (linear, P = 0.01) backfat IV. Of the 2 fat depots, backfat generally had a reduced IV than jowl fat. In summary, feeding sorghum-based diets reduced carcass fat IV and unsaturated fats compared with corn-based diets. As expected, adding CWG increased carcass fat IV regardless of the cereal grain in the diet.     

Effects of modified tall oil versus a commercial source of conjugated linoleic acid and increasing levels of modified tall oil on growth performance and carcass characteristics of growing-finishing pigs

Two experiments were conducted to evaluate the effects of conjugated linoleic acid (CLA)-enriched feed additives for swine. These additives included a source of CLA that was commercially available (CLA-60) and modified tall oil (MTO). Experiment 1 used 36 barrows (initially 37.6+/-2.8 kg) to compare the effects of CLA-60 and MTO on growth performance and carcass characteristics of finishing pigs. The corn-soybean meal diets contained .50% soybean oil (control), .50% CLA-60, or .50% MTO. Pigs fed CLA-60 had less (P = .03) ADG from 37.6 to 72.6 kg than the control pigs; otherwise, pigs fed either CLA-60 or MTO had growth performance similar (P > .15) to that of the control pigs. Pigs fed MTO grew faster (P = .03) and consumed more feed (P = .10) over the duration of the experiment (37.6 to 106.4 kg) than pigs fed CLA-60. Dietary treatment did not affect (P > .15) plasma triglycerides or carcass characteristics, but pigs fed either MTO or CLA-60 had greater saturation of fatty acids in the adipose tissue at the 10th rib than pigs fed the control diet. Experiment 2 used 80 barrows (initially 33.4+/-2.2 kg) to examine the effects of increasing levels of MTO on growth performance and carcass characteristics of finishing pigs. The corn-soybean meal diet contained 1% cornstarch, which was replaced with MTO to give dietary levels of .25, .50, or 1.00% MTO. Dietary treatment did not affect (P > .15) growth performance. Feeding increasing levels of MTO quadratically decreased (P = .02) average backfat thickness and longissimus muscle drip loss (P = .04) and quadratically increased longissimus muscle area (P = .07) and percentage lean (P = .03). Feeding MTO tended to increase belly firmness (P < .10) compared with pigs fed the control diet. These traits appeared to be optimized with .50% MTO. In summary, pigs fed MTO had greater ADG, ADFI, and ending BW than pigs fed CLA-60. Feeding MTO does not appear to affect growth performance but improves carcass lean content and may additionally improve some aspects of meat quality in growing-finishing pigs.     

Effects of feeding diets containing bacitracin methylene disalicylate to heat-stressed finishing pigs

The objective of this study was to evaluate the effects of heat stress and dietary bacitracin methylene disalicylate (BMD) on growth performance, carcass characteristics, and immunological responses in finishing pigs. Four groups of 32 finishing pigs (n = 128) with initial BW between 80 to 90 kg were used. Pigs were fed a corn-soybean meal-distillers grains-based control or BMD (31.5 mg/kg) diet for a 14-d adaptation period at the thermal neutral temperature (23°C), and continued to be fed their respective diets when exposed to a constant temperature (23°C) or a cyclical heat stress environment (37°C from 1000 to 1900 h and 27°C from 1900 to 1000 h) for a 28-d experimental period. Each group of pigs was housed in 4 rooms, with 2 pens/room and 4 pigs/pen. Saliva samples from each pig were collected on d -1 (initial baseline), 1, 13, and 27 for cortisol analysis. Concentrations of haptoglobin, IL-1β, and tumor necrosis factor-α were determined in serum samples on d -1, 1, 13, and 27. Pigs exposed to heat stress had 31% less ADG (P < 0.001), 23% less ADFI (P < 0.001), 9% less G:F (P < 0.001), and 34% greater average daily water intake (P = 0.03) than those in the non-heat-stress conditions. Dietary BMD tended to reduce ADG (P < 0.07) compared with the control (0.66 vs. 0.73 kg/d, respectively). Heat stress increased (P < 0.05) saliva cortisol on d 1, but no effects were observed on subsequent days. Serum haptoglobin concentrations were greater (P < 0.05) in heat-stressed pigs on d 1, and concentrations tended to remain greater (P < 0.1) on d 13. Pigs fed the BMD diet tended to have a longer villus height (P = 0.07) in the duodenum and greater crypt depths in the duodenum (P = 0.09) and jejunum (P = 0.07). Heat-stressed pigs tended to have a decreased proportion of propionate (P = 0.08), greater acetate:propionate (P = 0.08), and a reduced proportion of valerate (P = 0.02) in the cecum. These results indicate that BMD did not counteract the negative effects of heat stress on growth performance, but BMD appears to increase villus height and crypt depth in the duodenum. Furthermore, heat stress appears to alter VFA production in finishing pigs.     

Effects of lactose and yeast-dried milk on growth performance, fecal microbiota, and immune parameters of nursery pigs

An experiment was conducted to evaluate the effects of dietary lactose alone or in combination with a yeast-dried milk product (50% dried near-dated milk and 50% dried yeast) on growth performance, fecal microbiota, and immune status in nursery pigs (Sus scrofa). A total of 108 pigs (age, 20 ± 1 d; initial BW, 6.07 ± 0.03 kg) were randomly allotted to 18 pens (6 pigs/pen; 6 pens/treatment). Dietary treatments were: 1) control, 2) control + lactose, and 3) control + lactose + 5% yeast-dried milk. Except for the control diet, diets in Phase 1 (wk 1 and 2), 2 (wk 3 and 4), and 3 (wk 5) contained 20, 15, and 5% total lactose, respectively. Blood samples were collected from all pigs at d 0, 14, 28, and 35 to determine circulating IgG, IgA, and tumor necrosis factor (TNF)-α concentrations. At d 0, 7, and 14, fecal samples were collected (n = 18; 6 pigs/treatment) to evaluate fecal microbiota using PCR-denaturing gradient gel electrophoresis. Compared with pigs fed the control diet, pigs fed lactose and lactose with yeast-dried milk had greater (P < 0.05) ADG and tended (P = 0.07) to have greater BW and ADFI during Phase 1. There were no differences for BW, ADG, or ADFI during Phase 2, 3, or the overall experimental period. A main effect of treatment was observed for circulating IgA where control pigs had greater (P < 0.01) IgA compared with pigs fed lactose with or without yeast-dried milk; however, no effects of treatment were observed (P > 0.10) for circulating IgG or TNF-α. No differences (P > 0.10) in microbial diversity indices were observed on d 7 or 14 among treatments. However, a shift in microbial composition was observed on d 7, with lactose-fed pigs having greater (P < 0.05) putative L. johnsonii staining intensity compared with control pigs and pigs fed lactose plus yeast-dried milk. On d 14, L. delbrueckii was eliminated (P < 0.04) by feeding lactose with or without yeast-dried milk. This research indicates that growth performance, immune status, and fecal microbiota are affected by dietary inclusion of lactose alone, or in combination with yeast-dried milk.     

Effects of wet corn gluten feed and roughage levels on performance, carcass characteristics, and feeding behavior of feedlot cattle

Two experiments were conducted to evaluate the effects of feeding different levels of wet corn gluten feed (WCGF) and dietary roughage on performance, carcass characteristics, and feeding behavior of feedlot cattle fed diets based on steam-flaked corn (SFC). In Exp. 1, crossbred steers (n = 200; BW = 314 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based diet containing 9% roughage (CON) and 3 SFC-based diets containing 40% WCGF, with either 9, 4.5, or 0% roughage. A linear (P = 0.04) increase in final BW and DMI (P < 0.01) was observed in diets containing WCGF as dietary roughage increased. Steers fed WCGF and higher levels of roughage had greater (P = 0.01) ADG than steers fed lower levels of roughage. Steers fed the CON diet had lower (P = 0.04) daily DMI and greater (P = 0.03) G:F than those fed WCGF. Most carcass characteristics of steers fed CON did not differ (P > 0.10) from those of steers fed WCGF. Based on feed disappearance and visual scan data, consumption rate did not differ (P > 0.10) among treatments; however, feeding intensity (animals present at the bunk after feeding) was greater for steers fed CON (P < 0.01) than for steers fed WCGF. In Exp. 2, yearling crossbred steers (n = 1,983; BW = 339 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based control diet that contained 9% roughage (CON) and 3 SFC-based diets containing either 20% WCGF and 9% roughage or 40% WCGF with 9 or 4.5% roughage. Steers fed the CON diet tended to have lower final BW (P = 0.14), ADG (P = 0.01), and DMI (P < 0.01) than steers fed diets containing WCGF. Steers fed the 20% WCGF diet had greater (P = 0.08) G:F than steers fed the 40% WCGF diets. With 40% WCGF, increasing roughage from 4.5 to 9% decreased (P < 0.01) G:F and increased (P = 0.06) DMI. Gain efficiency was improved (P < 0.01) for steers fed CON vs. those fed diets containing WCGF, whereas HCW (P = 0.02) and dressing percentage (P < 0.01) were greater for steers fed WCGF. Percentage of cattle grading USDA Choice was greater (P = 0.02) for cattle fed WCGF. Results suggest that replacing SFC with up to 40% WCGF increased ADG and decreased G:F when 4.5 to 9.0% roughage was supplied. More CON steers were present at the feed bunk during the first hour after feeding than WCGF steers, suggesting that including WCGF at 40% of the diet affected feeding behavior.     

Response of pigs to dietary inclusion of formic acid and ammonium formate

The objective of this study was to determine the optimal inclusion rate of dietary formic acid-ammonium formate (composition by weight was 62% formic acid and 37% ammonium formate) in nursery and grower-finisher diets or grower-finisher diets only. At weaning (d 21 +/- 2), 224 pigs (equal numbers of gilts and barrows) were blocked by BW within sex (28 pigs per BW block, 4 pigs per pen) and assigned randomly to 1 of 7 dietary treatments within each block. Dietary treatments (TRT), listed as percentage of dietary formic acid-ammonium formate in the nursery (NR) and the grower-finisher (GRF) diets, were as follows (NR and GRF): TRT 1: 0.0 and 0.0; TRT 2: 1.2 and 1.0; TRT 3: 0.0 and 1.0; TRT 4: 1.0 and 0.8; TRT 5: 0.0 and 0.8; TRT 6: 0.8 and 0.6; and TRT 7: 0.0 and 0.6. During the grower 2 (GR2) period, pigs fed treatments containing formic acid-ammonium formate in the nursery diets (TRT 2, TRT 4, and TRT 6) had greater (P < 0.05) ADG and G:F than pigs fed diets containing formic acid-ammonium formate in the grower period only (TRT 3, TRT 5, and TRT 7). Average daily feed intake tended to decrease (NR1, P = 0.07) or decreased (NR2, P < 0.05) for pigs fed formic acid-ammonium formate in the nursery (TRT 2, TRT 4, and TRT 6) compared with pigs fed control diets (TRT 1, TRT 3, TRT 5, and TRT 7). The ADFI also decreased (P < 0.05) during the GR1 and GR2 periods for pigs fed diets containing formic acid-ammonium formate compared with pigs fed control (TRT 1). In the combined nursery data, there was no effect (P > 0.10) of treatment on ADG. Pigs on diets containing formic acid-ammonium formate ate less feed (P < 0.05) and had improved G:F (P < 0.05) compared with pigs on the control treatments (TRT 1, TRT 3, TRT 5, and TRT 7). Combining the grower-finisher phases, G:F was greater (P = 0.05) for pigs fed diets containing formic acid-ammonium formate than for pigs fed the control feed. The efficiency of gain (i.e., G:F) was improved by 3.5% for pigs fed all formic acid-ammonium formate treatments and ranged from 2.3 (TRT 7) to 5.9% (TRT 4) compared with pigs fed control (TRT 1). Combining all phases from nursery to finisher, the G:F ratio tended (P = 0.08) to be greater for pigs fed formic acid-ammonium formate compared with pigs fed control. The efficiency of gain was improved by 3.0% for pigs fed all formic acid-ammonium formate treatments, ranging from 1.8 (TRT 7) to 5.2% (TRT 4), compared with pigs fed the control diet (TRT 1).     

Effect of different protein sources on growth and carcass traits in growing-finishing pigs

Crossbred gilts (n = 180) and barrows (n = 180) from the Louisiana State University (LSU) Agricultural Center and the University of Illinois (UI) were used to compare the effect of soybean meal in swine diets, relative to other protein sources, on growth performance and carcass traits of growing-finishing pigs. Four replications with five pigs each at each location were allotted to nine dietary treatments: soybean meal control (SBM), crystalline AA (corn-AA), extruded soybeans (ESB), canola meal (CAN), peanut meal (PNT), sunflower meal (SFLR), ground peas, meat and bone meal (MBM), and poultry by-product meal (PLTY). The diets were formulated to meet or exceed NRC nutrient requirements and to have equal Lys:ME according to dietary phase and sex. Corn was the grain source in all diets and the protein sources were the sole source of supplemental protein in all diets except when AA were added to meet the requirement. Pigs (three per pen at each location) were killed at an average final BW of 114 kg in the LSU or UI Meat Science Laboratories. Pigs fed SBM had greater (P < 0.05) ADG than pigs fed the corn-AA, CAN, SFLR, MBM, or PLTY and greater (P < 0.05) ADFI relative to pigs fed the corn-AA, ESB, MBM, or PLTY. Gain:feed was decreased (P < 0.05) in pigs fed corn-AA or SFLR but increased (P < 0.05) in pigs fed ESB compared with pigs fed the SBM diet. Loin muscle area was decreased (P < 0.05) in pigs fed the corn-AA or MBM diets compared with pigs fed the SBM diet. Tenth-rib backfat thickness was greater (P < 0.10) in pigs fed corn-AA, peas, or MBM than in those fed SBM. The NPPC percentage acceptable quality lean and kilograms of lean were decreased (P < 0.10) in pigs fed corn-AA, peas, or MBM compared with those fed SBM. Results from this experiment suggest that pigs fed SBM have equal or better growth performance and carcass traits than pigs fed other protein sources.     

The effect of birth weight and feeding of supplemental milk replacer to piglets during lactation on preweaning and postweaning growth performance and carcass characteristics

The effects of piglet birth weight and liquid milk replacer supplementation of piglets during lactation on growth performance to slaughter weight was evaluated in a study carried out with 32 sows (PIC C-22) and their piglets (n = 384; progeny of PIC Line 337 sires). A randomized block design with a 2 x 2 factorial arrangement of treatments was used. Treatments were birth weight (Heavy vs Light) and liquid milk replacer (Supplemented vs Unsupplemented). The study was divided into two periods. At the start of period 1 (birth to weaning), pigs were assigned to either Heavy or Light (1.8 [SD = 0.09] vs 1.3 kg [SD = 0.07] BW, respectively, P < 0.001) litters of 12 pigs and half of the litters were given ad libitum access to supplemental milk replacer from d 3 of lactation to weaning (21 +/- 0.2 d). In period 2 (weaning to 110 kg BW), a total of 308 pigs were randomly selected from within previous treatment and sex subclasses and placed in pens of four pigs. Pigs were given ad libitum access to diets that met or exceeded nutrient requirements. Pigs in heavy litters were heavier at weaning (6.6 vs 5.7 kg BW; SE = 0.14; P < 0.001) and tended to have more pigs weaned (11.4 vs 10.9 pigs/litter; SE = 0.21; P = 0.10). After weaning, pigs in the Heavy litter had greater ADG (851 vs 796 g; SE = 6.7; P < 0.001) and ADFI (1,866 vs 1,783 g; SE = 17.6; P < 0.001), similar gain:feed (0.46 vs 0.45; SE = 0.003; P > 0.05), and required seven fewer days (P < 0.001) to reach slaughter weight compared to pigs in the Light treatment. Feeding supplemental milk replacer during lactation produced heavier pigs at weaning (6.6 vs 5.7 kg BW; SE = 0.14; P < 0.001) and tended to increase the number of pigs weaned (11.4 vs 10.9 pigs/litter; SE = 0.21; P = 0.10) but had no effect (P > 0.05) on growth performance from weaning to slaughter. However, pigs fed milk replacer required three fewer days (P < 0.01) to reach 110 kg BW. Sow feed intake and BW loss during lactation were not affected (P > 0.05) by either birth weight or milk replacer treatment. In conclusion, birth weight has a substantially greater impact on pig growth performance after weaning than increasing nutrient intake during lactation.     

Effects of pelleting and pellet conditioning temperatures on weanling pig performance

We conducted two experiments to study the effects of pelleting and pellet conditioning temperature on weanling pig performance. In Exp. 1, 252 weanling pigs (PIC, L326 x C22) averaging 6.0 +/- 1.3 kg and 21 +/- 3 d of age were used to evaluate six corn-soybean meal-based diets containing 15% dried whey and formulated to contain 1.4% lysine. Treatments consisted of a control diet without spray-dried animal protein (SDAP) fed in meal form, a diet with 5% SDAP fed in meal form, and four diets with 5% SDAP that were conditioned at 60, 66, 71, or 77 degrees C for 10 s prior to pelleting. Pellets had a 3.97-mm diameter. The experimental diets were fed from d 0 to 14 after weaning, and all pigs were fed a common diet in meal form from d 14 to 28 after weaning. From d 0 to 7 after weaning, pigs fed diets containing SDAP had greater ADG, gain/feed (P < 0.001), and ADFI (P < 0.05) than pigs fed the control diet. No differences (P > 0.10) were observed between pigs fed the pelleted diets and those fed the SDAP diet in meal form. Conditioning temperature had no effect (P > 0.10) on weanling pig performance from d 0 to 14, and the diet fed from d 0 to 14 had no effect on overall performance (d 0 to 28). In Exp. 2, 252 weanling pigs (6.3 +/- 1.5 kg and 22 +/- 4 d of age) were used to evaluate diets with same composition as in Exp. 1, but treatments consisted of diets with or without SDAP conditioned at 60 degrees C before pelleting, and four diets containing 5% SDAP that were conditioned at 68, 77, 85, and 93 degrees C before pelleting. As in Exp. 1, conditioning lasted 10 s, pellets were 3.97 in mm diameter, and experimental diets were fed for the first 14 d of the 28-d experiment. From d 0 to 7, pigs fed the SDAP diet conditioned at 60 degrees C had greater ADFI (P < 0.05) and tended (P = 0.12) to have greater ADG than pigs fed the diet without SDAP and conditioned at 60 degrees C. From d 0 to 7, ADG (quadratic effect, P < 0.03) and ADFI (linear effect, P < 0.002) decreased as conditioning temperature increased, with the largest decrease observed above 77 degrees C. From d 0 to 14 and 0 to 28, ADG was not affected (P > 0.10) by pellet conditioning temperature or SDAP fed from d 0 to 14. The results of these studies suggest that conditioning diets containing 5% SDAP at temperatures above 77 degrees C decreases weanling pig growth performance.     

Effect of irradiation of individual feed ingredients and the complete diet on nursery pig performance

A total of 1,210 nursery pigs was used in two experiments to evaluate the effects of irradiation of typical nursery diet ingredients, specialty protein products, and the whole diet on nursery pig performance. In Exp. 1, 880 barrows and gilts (15 +/- 2 d of age at weaning) were used in two growth trials (14 d and 12 d for Trials 1 and 2, respectively) to determine the effects of individual ingredient and whole-diet irradiation on nursery pig performance. Overall (d 0 to 14 of Trial 1 and d 0 to 12 of Trial 2), ADG was greater (P < 0.05) for pigs fed irradiated animal plasma compared with pigs fed the control, the diet containing irradiated microingredients, and the diet that was manufactured and irradiated. Also, pigs fed irradiated soybean meal had greater (P < 0.05) ADFI compared with pigs fed the manufactured diet that was irradiated. Pigs fed the diet containing irradiated animal plasma had improved feed efficiency (G:F; P < 0.05) compared with those fed the diet with irradiated microingredients and when all ingredients were irradiated before manufacturing of complete feed. Finally, pigs fed irradiated corn, whey, fishmeal, soybean oil, microingredients, or if all ingredients or the whole diet were irradiated, had similar ADG, ADFI, and G:F (P > 0.12) to control pigs. In Exp. 2, 330 nursery pigs (20 +/- 2 d of age at weaning) were used to determine the effects of irradiation of commercially available specialty protein products in diets for nursery pigs. Overall, ADG was greater (P < 0.05) when pigs were fed diets containing nonirradiated spray-dried animal plasma and egg combination (SDAPE) and dried porcine digest (DPD) compared with pigs fed the control diet containing no specialty protein products. In addition, G:F was improved (P < 0.05) when pigs were fed diets containing nonirradiated SDAPE, DPD, spray-dried beef muscle (SDBM), and spray-dried whole egg (SDWE) compared with pigs fed the control diet. Pigs fed irradiated SDAPE and SDBM had greater (P < 0.05) ADG than pigs fed the nonirradiated forms. Pigs fed irradiated SDBM had improved (P < 0.05) G:F compared with pigs fed the nonirradiated form. In Exp. 1 and 2, an irradiation treatment level of 8.5 kGy was effective in reducing the total bacterial concentration of all ingredients evaluated, as well as the whole diet in Exp.1. Irradiation of certain ingredients, but not the complete diet, increased growth performance of nursery pigs.     

Effects of pea chips on pig performance, carcass quality and composition, and palatability of pork

Pea chips are produced as a by-product when field peas are processed to produce split peas for human consumption. The objective of this experiment was to test the hypothesis that inclusion of pea chips in diets fed to finishing pigs does not negatively influence pig growth performance, carcass composition, and the palatability of pork. A total of 24 barrows (initial BW: 58.0 ± 6.6 kg) were allotted to 1 of 4 treatments and fed early finishing diets for 35 d and late finishing diets for 35 d. A corn-soybean meal (SBM) control diet and 3 diets containing pea chips were formulated for each phase. Pea chips replaced 33.3, 66.6, or 100% of the SBM in the control diet. Pigs were housed individually, and all pigs were slaughtered at the conclusion of the experiment. Overall, there were no differences (P > 0.11) in final BW, ADFI, and G:F of pigs among treatments, but there was a quadratic response in ADG (P = 0.04), with the smallest value observed in pigs fed the control diet. Dressing percentage linearly decreased (P = 0.04) as pea chips replaced SBM in diets, but there were no differences (P > 0.20) among treatments in HCW, LM area, 10th-rib backfat, lean meat percentage, and marbling. Likewise, pH in loin and ham, drip loss, and purge loss were not influenced (P > 0.13) by treatment. However, there was a quadratic response (P = 0.08) in 24-h pH in the shoulder, with the smallest value present in pigs fed the diet, in which 66.6% of the SBM was replaced by pea chips. Subjective LM color and Japanese color score standard were reduced (quadratic, P = 0.03 and 0.05, respectively) and LM b* values and hue angle were increased (quadratic, P = 0.09 and 0.10, respectively) when pea chips replaced SBM in the diets. Ham L* (quadratic, P = 0.04), a* (linear, P = 0.02), b* (quadratic, P = 0.07), color saturation (linear, P = 0.02), and hue angle (quadratic, P = 0.05) were increased when pea chips replaced SBM. However, there were no differences (P > 0.16) in shoulder and fat color. Moreover, cook loss percentage, shear force, juiciness, and pork flavor of pork chops were not different (P > 0.10) among treatments, but tenderness of pork chops linearly decreased (P = 0.04) as SBM replaced pea chips. It is concluded that all the SBM in diets fed to growing-finishing pigs may be replaced by pea chips without negatively influencing growth performance or carcass composition. However, pigs fed pea chips will have pork chops and hams that are lighter, and chops may be less tender if pigs are fed pea chips rather than corn and SBM.     

Feed physical form and formic acid addition to the feed affect the gastrointestinal ecology and growth performance of growing pigs

The effect of feeding a coarsely ground meal (COARSE) and a finely ground pelleted diet with 1.8% (as-fed basis) added formic acid (ACID) was compared with feeding a standard finely ground pelleted diet (STD) on the gastrointestinal ecology of growing pigs at different intervals after feeding. One hundred five castrated male growing-finishing pigs (initial BW 27 kg) were used. At a BW of 63 kg, 60 pigs were killed 0.5, 2.5, 4.5, 6.5, and 8.5 h after feeding, and samples from the gastrointestinal tract (GIT) were obtained. The remaining 45 pigs were kept on the experimental diets to a BW of 99 kg. Feeding the three diets resulted in a similar pattern of gastric pH with time, (i.e., highest pH values 0.5 h after feeding and decreasing values at the following sampling times, to reach a value of 2.12 at 8.5 h after feeding). The pH of the gastric digesta of pigs fed the ACID diet was below 4 at all sampling times, whereas the digesta from the other two dietary groups had values above pH 4 at the first sampling times. Feeding the ACID diet decreased the counts of total anaerobes in the proximal GIT (P < or = 0.007), and of lactic acid bacteria (P < or = 0.001), enterobacteria (P < or = 0.02), and yeasts (P < or = 0.01) along the GIT compared with feeding the other two diets. Feeding the COARSE diet stimulated the growth of total anaerobes and lactic acid bacteria in the stomach and distal small intestine increased the microbial diversity mainly in the stomach (P = 0.001), compared with feeding the other two diets (P < or = 0.09), and decreased the number of enterobacteria in the cecum compared with the STD diet (P = 0.03), with the same tendency in the mid-colon (P = 0.07). The concentration of lactic acid in the stomach was highest in the pigs fed the COARSE diet compared with the other two groups (P < 0.05). The concentration of formic acid was highest in the stomach and all segments of the small intestine of the pigs fed the ACID diet compared with those fed the STD and COARSE diets (P < 0.05). The results from this study suggest that feeding a coarsely ground diet and a finely ground diet with added formic acid affect the gastrointestinal ecology of pigs mainly by changing the environment in the proximal GIT. The presence of organic acids in the proximal GIT is a crucial factor contributing to the decrease in the number of enterobacteria along the GIT. The time after feeding at which samples are taken to measure characteristics describing the gastrointestinal ecology affects the results from the stomach and small intestine.     

Effect of chromium propionate and metabolizable energy on growth,carcass traits,and pork quality of growing-finishing pigs

An experiment was conducted to evaluate the dietary effects of Cr propionate (CrProp) and metabolizable energy (ME) on growth, carcass traits, and pork quality of growing-finishing pigs. One hundred forty-four Cambrough-22 barrows were allotted to four dietary treatments in a randomized complete block design (six replicates of six pigs per replicate; average initial and final body weight were 27 and 113 kg, respectively). The dietary treatments were: 1) corn-soybean meal basal (B; low ME), 2) B + 200 ppb of Cr (as CrProp), 3) B + 200 kcal ME/kg (4.5% added fat; high ME), or 4) B + 200 kcal ME/kg + 200 ppb of Cr. At trial termination, three pigs per replicate were killed to determine dietary effects on carcass traits and pork quality. Overall average daily gain, average daily feed intake, and gain:feed ratio were not affected (P > 0.10) by diet. During the early growing period, average daily gain was increased in pigs fed the CrProp-low-ME diets, but decreased in pigs fed the CrProp-high ME diets (Cr x ME, P < 0.04). Feed intake was increased (P < 0.05) in pigs fed the high-ME diets during the early growing period. Forty-five min and 24 h pH were not affected (P > 0.10) by diet. The CIE L* tended (P = 0.07) to be increased and shear force tended (P = 0.06) to be decreased in pigs fed high-ME diets. Subjective marbling was increased (P < 0.03) and longissimus muscle percentage moisture and thaw loss were decreased (P < 0.04) in pigs fed CrProp. Chromium propionate had no consistent effect on growth and carcass traits in this experiment; however, CrProp did affect some aspects of pork quality.