Preparation and Storage Characteristics of Ribbon Fish Laminates

Abstract

A process to prepare dehydrated laminates of ribbon fish is reported. Pieces of eviscerated and beheaded fish were pressed under a screw press and the laminates obtained were subjected to air drying at 55°C for 14 hr. The product was golden brown in color, and had 18.4% moisture, 22% rehydration capacity, and pepsin and trypsin digestibilities of 51 and 62%, respectively. Oxidation of lipids during aerobic storage of the product at ambient temperature could be controlled by vacuum packaging. Sensory evaluation of the productfried in vegetable oil after Serobic storing at ambient temperature for 100 days suggested its acceptability. The process has potential for value addition of ribbon fish.     

Drying Kinetics and Quality Characteristics of Slightly Salted Grass Carp Fillets by Hot Air Drying and Vacuum Microwave Drying

Salted grass carp fillets were dried by hot air drying (HD, at 35 and 45°C) and vacuum microwave drying (VMD, at 1, 4, and 7 W/g) to a final moisture content. Compared with hot air drying, the vacuum microwave drying greatly reduced drying time. The rehydration rate constant of salted grass carp fillets dried by microwave vacuum drying at 7-W/g microwave intensity was significantly higher than that of the hot air drying at 35 and 45°C. Compared with hot air drying, the vacuum microwave dried samples had a higher crude fat content (dry basis). The lightness of the samples dried by vacuum microwave drying was higher, and the yellowness was lower than those dried by hot air drying. The drying methods had no significant effect on the hardness and springiness.     

不同干燥方式对封鳊鱼品质的影响

为探明不同干燥方式对封鳊鱼品质及鱼肉理化性质的影响,试验采用自然、冷风、冷冻、冷风—热风联合和热泵5种干燥方式对封鳊鱼进行干燥,研究不同干燥方式对鳊鱼质量损失、干燥速率、硫代巴比妥酸值、挥发性盐基总氮、水分活度、复水率、质构特性和微观结构的影响。试验结果表明,自然干燥的干燥速率低、鱼肉复水率差、氧化最严重、腐败程度较高,但弹性和咀嚼性较好;冷冻干燥的干燥速率最快,鱼肉复水率最高,氧化和腐败程度最低,但弹性和咀嚼性差;冷风干燥的干燥速率低,但鱼肉复水率较好,仅低于冷冻干燥,氧化和腐败程度也仅高于冷冻干燥,且弹性和咀嚼性最好;热泵干燥的干燥速率较高,但鱼肉复水率低、氧化和腐败程度均较高、质构特性较差;联合干燥的干燥速率较快,但鱼肉复水率最低、腐败最严重、质构特性差。     

Textural and Sensory Properties of Fish Sausage from Rainbow Trout

The aim of this study was to determine the textural and sensory properties of fish sausage which were prepared from refrigerated and frozen rainbow trout (Onchorynchus mykiss) and stored for 14 days at 0?4 °C. These two groups of sausages were compared for texture, physical, and sensory properties by carrying out texture profile analysis (TPA), shear test, water holding capacity (WHC), cook loss, color, and sensory analyses. According to TPA and shear test, sausages prepared from frozen fillets exhibited a texture significantly (p < 0.05) weaker than those prepared from refrigerated fillets, but no difference in overall liking was observed.     

Textural and Sensory Properties of Herring (Clupea harengus) Cubes in Chinese-Type Paste as Affected by Prefrying Methods

The aim of this study was to determine the textural and sensory properties of herring (Clupea harengus) cubes prefried by deep frying (DF), mild frying (MF), and vacuum frying (VF) in Chinese-type pastes stored for 25 days at 13–15°C. Three groups of fish cubes in every Chinese-type paste were compared for texture, physical, and sensory properties by carrying out texture profile analysis (TPA), moisture content, color, and sensory analyses; and two types of Chinese-type pastes were investigated, oily Paste (A) and light Paste (B). The results showed that L* of fish cubes decreased significantly (p < 0.05), and a* and b* increased significantly (p < 0.05) in two kinds of Chinese-type pastes. Fish cubes prefried by DF and MF had higher sensory scores in Chinese-type Paste A, while those prefried by DF and VF had higher sensory scores in Chinese-type Paste B.     

包装方式对日本鳀鱼干品质特性的影响

[目的]为探究不同包装对丁香鱼干常温贮藏期间的品质特性影响,[方法] 以空气包装为对照,与真空包装、气调包装和CO2包装做比较,测定贮藏过程中菌落总数、TVB-N、POV、TBA、色差、挥发性风味成分及感官评分的变化。[结果]结果显示,真空、气调、CO2三种包装均能有效抑制丁香鱼干微生物生长,常温25 ℃贮藏8 d后,真空包装组样品TVB-N、POV和TBA值分别较空气包装组降低47.08%、4.13%和25.49%,并且真空包装组样品在减缓样品色泽变化、保护肌纤维结构完整性、保留挥发性风味成分和保持感官特性方面均具有较佳效果,确定了真空包装为丁香鱼干的最佳包装方式。基于Arhenius方程建立了丁香鱼干货架期预测模型,25 ℃和35 ℃下真空包装丁香鱼干的货架期分别为6.07和3.23 d。[意义]本研究成果可为丁香鱼干常温物流过程中的品质控制提供理论依据。     

Setting the Global Context in Discovery and Transformation of Seafood Products

ABSTRACT

The effects of sun drying at ambient temperature in the range of 24°C to 32°C; artificial drying at 35°C, 45°C, or 55°C; or artificial drying at 45°C after treatment with 10% brine, 20% brine, saturated (36%) brine, or dry salt at 28°C for 16 hours on the physical characteristics of the final dried Bombay duck (Harpodon neherius) were studied. Unsalted sundried fish was found unacceptable. Dry salting was more efficient in reducing the moisture level in fish than brining, but was found unsuitable by the panelists due the appearance of a powdered salt crust as the fish dries up. Bombay duck treated with 20% sodium chloride solution, artificially dried at 45°C, and kept in sealed polyethylene pouches was judged superior after sensory evaluation compared to unsalted sundried Bombay duck or unsalted artificial dried Bombay duck at 35°C, 45°C, and 55°C, or artificial dried samples at 45°C after treatment with 10% brine, saturated (36%) brine or dry salt, and kept in sealed polyethylene pouches, respectively, during storage.     

Physical and Sensory Properties of Electrohydrodynamic (EHD) Dried Scallop Muscle

Electrohydrodynamic (EHD) drying was tested as an improved dehydration method for scallop muscle. The scallop muscle was dried in an EHD drying system at 15°C, in an oven at 60°C, and in ambient air at 15°C. The energy consumption of EHD and oven drying, as well as the shrinkage rate, water absorption, solid loss, and sensory properties such as color and anti-crushing durability of the dried scallop muscle were measured. Results showed that the drying rate of scallop muscle significantly improved using the EHD drying system. Under a 45 kV voltage, the drying rate of EHD is 7 times higher compared with that of air drying in the 1st h. Compared with oven drying, EHD drying was more efficient in terms of energy saving. Furthermore, EHD drying cost only 28.67% of the electric energy required for oven drying. The dried scallop muscle by EHD had better sensory qualities and higher anti-crushing durability. EHD drying is very advantageous and can be used as a substitute to the traditional drying method.     

Frozen Storage Studies of Formulated Skipjack Tuna Patties

Plain and flavored formulated skipjack tuna patties with textural characteristics similar to that of ground beef were developed for use in school lunch programs. Shelf life studies of these patties indicated that the nutrient composition of raw and cooked fish patties held under frozen storage for nine months essentially remained the same. In a 100 gm edible serving, raw and cooked tuna patties contained 71%-75% moisture, 18%-21% protein, 0.15%-0.22% fat, 1.8%-2.1% ash, and 3.3%-4.0% carbohydrate. Mean caloric content ranged from 88 to 91 kilocalories/patty. Furthermore, a 100 gm patty serving provided about 29% of the U.S. Recommended Dietary Allowance (RDA) for protein, 18%-20% for niacin, about 14% for phosphorous, 10%-11% for iron, 6% for magnesium, less than 5% for zinc, copper, and manganese, about 2% for thiamin, and less than 2% for vitamins A, E and calcium. Sensory testing on fish patties indicated that cooked patties could be stored up to nine months in frozen storage (minus 24°C) with only slight changes in odor, taste and texture. The storage life for frozen, raw patties appeared to be about three months. If uncooked patties were frozen, they should be cooked and eaten within a three month period. Based on the data gathered in this study it was recommended that the tuna patties be fully cooked, frozen quickly, vacuum-sealed, and stored at -24°C or below in order to maintain a frozen shelf-life of up to nine months.     

Dried leaves of Rosmarinus officinalis as a treatment for streptococcosis in tilapia

Dietary application of dried Rosmarinus officinalis (rosemary) leaves as a treatment for streptococcal infection was studied in tilapia, Oreochromis sp. Feeding with dried rosemary leaves significantly reduced mortality following infection with Streptococcus iniae: 44% mortality in the group fed 8% rosemary, similar to oxytetracycline treatment (43% mortality), and significantly lower than the control (65%). Dietary administration of 16% rosemary significantly reduced mortality because of Streptococcus agalactiae infection in 44 g fish (62% and 76% in 16% rosemary and control, respectively), but not in a similar experiment conducted with 5.5 g fish. The antibacterial effect of rosemary on S. iniae was studied. Activity of rosemary cultivar Israel was reduced during the winter, but there was no significant change in cultivars Oranit and Star. Storage of powdered rosemary leaves at 50 °C resulted in fourfold and eightfold higher MIC_{24 h} values after 3 and 4.5 months, respectively. Storage at ?20 °C, 4 °C and 25 °C and autoclaving (120 °C) each resulted in a twofold increase in MIC_{24 h}. Repeated exposures of S. iniae to rosemary did not affect minimal inhibitory concentration, suggesting no development of resistance to rosemary.     

Effect of Frozen Storage Temperature on Quality-Related Changes in Rainbow Trout (Oncorhynchus mykiss)

The effect of frozen storage temperature on quality-related parameters of rainbow trout (Oncorhynchus mykiss) muscle was studied in the interval from ?10 to ?80°C on samples stored for 1 to 18 months. The following quantities were measured: drip loss, water holding capacity and water distribution, color, lipid oxidation (thiobarbituric acid-reactive substances, TBARS), and membrane stability (enzyme activity). No effect of temperature on drip loss, water holding capacity, water distribution, or membrane stability was observed for samples stored below ?20°C, whereas storage at ?40°C or lower compared to ?30°C or higher resulted in a reduced level of secondary lipid oxidation (TBARS). No advantage was gained by using temperatures below ?40°C for frozen storage of trout regarding any of the properties investigated.     

Changes in the Chemical Characteristics of Gulbi,Salted and Dried Yellow Corvenia,During Drying at Different Temperatures

A few chemical characteristics of Gulbi, a traditional Korean seafood prepared from salted and dried Yellow corvenia (Pseudosciaena manchurica), were investigated during drying at different temperatures. When Gulbi was manufactured by sun-drying (the control), it had the highest thiobarbituric acid reactive substances (TBARS) and volatile basic nitrogen (VBN) values. They increased with increasing drying time at all temperatures in the hot-air drier. The TBARS value of Gulbi was lower when dried at 30 and 35°C than at 40°C and the control. The VBN of the control was higher than that of hot-air dried Gulbi at 30 and 35°C and lower than that of hot-air dried Gulbi at 40°C. The control had a VBN value of 20.8 ± 0.07% and the hot-air dried at 30°C, 18.0 ± 0.06; at 35°C, 18.6 ± 0.06; at 40°C, 23.8 ± 0.08 (p < 0.05), respectively. The salt content of the control and Gulbi dried at 30, 35, and 40°C were 22.9 ± 0.07%, 17.7 ± 0.06%, 18.0 ± 0.06%, and 24.3 ± 0.08%, respectively. The amino nitrogen content was much lower: 63.1 ± 0.80 mg/100 g and 65.5 ± 0.14 mg/100 g at 30 and 35°C than 78.3 ± 0.21 mg/100 g at 40°C. The results of this study also indicate that the Gulbi dried at 30 and 35°C had better chemical characteristics than those dried at 40°C when using hot-air drying and sun drying.     

Using Antioxidants for Extending the Shelf Life of Frozen Nile Karmout (Claries lazera) Fish Mince

Abstract

Nile karmout (Claries lazera)fish mince was treated with 0.5% sodium tripolyphosphate (STPP), 0.5% ascorbic acid, 0.5% citric acid, and 0.1% Na EDTA, then stored at -18°C for 6 months. Yield, proximate composition, thiobarbitunc acid value (TBA), free fatty acid (FFA), salt soluble protein (SSP), non-protein nitrogen (NPN), water holding capacity (WHC), and cooking loss were determined at 0, 2, 4, and 6 months of storage. The yield of skinned fillet from whole fish was 47.0%. Moisture, protein, fat and ash offish mince were 72.9%, 17.6%, 8.5% and 1.0%, respectively. TBA values and FFA levels indicated that ascorbic acid and Na₂EDTA were the most effective antioxidants. Samples treated with STPP had the highest salt soluble protein. STPP was effective in maintaining the WHC of treated sample. Samples treated with citric acid had the highest cooking loss. Results of the study suggested that karmout is an excellent source for producing fish mince for further processing. Samples treated with antioxidants retarded the rancidity during frozen storage.     

Restructured Crispy Fish Cubes Containing Salicornia bigelovii Torr. Developed with Microwave Vacuum Drying

Restructured crispy fish cubes containing Salicornia bigelovii Torr. (S. bigelovii) were developed using microwave vacuum drying. A series of drying experiments and optimization experiments were conducted to optimize the process conditions of microwave vacuum drying. The quality parameters of fish cubes such as crispness, expansion ratio, and sensory score were measured. The optimal expansion ratio and crispness were decided on the basis of optimization experiments by response surface analysis. The results showed that the optimum microwave vacuum conditions were: initial moisture content of surimi was controlled at 60.5% (wet basis, w.b.) and microwave heating for 20 min at the vacuum pressure of 0.090 MPa and microwave power of 11 W/g. The final product had a uniform shape, homogenous texture, pleasant color, and delicious flavor.     

Monitoring Quality of Packaged Pacific Ocean Perch (Sebastes alutus) in Storage

Pacific ocean perch stored under vacuum, 100% CO₂ or air at -3°C and 3°C was subjected to sensory, trimethylamine (TMA), color, microbial and volatile analyses. Unpleasant sensory attributes, TMA and microbial content were negatively correlated to overall quality, and Hunter 'L' value increased with storage time. Principal factor analysis of sensory data resulted in three factors that accounted for 71% of the variance, with factor 1 (53%) mainly related to poor quality attributes. Volatiles analyzed by the dynamic headspace technique included alkanes, alkenes, aldehydes, aromatics and alcohols. Canonical variate analysis on volatile compounds separated excellent and poor quality fish samples, while good and medium samples were grouped together.     

Relationship Between Water Migration and Quality Changes of Yellowfin Tuna (Thunnus albacares) During Storage at 0°C and 4°C by LF-NMR

This study investigated postmortem changes of yellowfin tuna (Thunnus albacares) and water migration upon storage at 0°C and 4°C as determined by low-field nuclear magnetic resonance (LF-NMR ¹H). It clearly showed that with increasing storage time, sensory scores and physical evaluations (hardness, chewiness), proton density of the water, and moisture content decreased, while total volatile basic nitrogen (TVB-N), K value, aerobic plate counts (APCs), and psychrotrophic bacterial counts increased. The results of LF-NMR showed that T₂₁ (trapped water) had extremely significant correlations with sensory evaluation, texture profile analysis, TVB-N, K value, APC, and psychrotrophic bacteria (p < 0.01) and established multiple linear regression. It was concluded that the LF-NMR was an important technique to evaluate storage time and temperature of yellowfin tuna’s quality in terms of water migration during low-temperature storage.     

Effect of a Previous Washing Step with Tannic Acid on the Quality of Minced Horse Mackerel (Trachurus trachurus) During Frozen Storage

Fatty fish have been recognized as potential raw material for production of minced meat; however, they are prone to oxidation and further deterioration. In the present study, the effect of washing and antioxidant (tannic acid) treatment on the quality of minced meat of Trachurus trachurus (horse mackerel) during frozen storage was observed. Minced meat of Trachurus trachurus was divided into three lots (T0, T1, and T2). T1 was washed with cold water, T2 with cold water containing tannic acid (100 mg/kg), and T0 was not washed. All the lots were frozen at ?40°C and stored at ?20 ± 2°C for 125 days and were subjected to biochemical, microbiological, and sensory evaluation at regular intervals of 25 days. The antioxidant treatment with tannic acid at the dosage used was found effective in minimizing the rancidity problems of minced meat (T2), compared to T0 and T1. During the whole period of storage, samples from T2 showed good quality in terms of microbiological, biochemical, and sensory analysis compared to T1 and T0.     

Changes in Protein Oxidation,Water-Holding Capacity,and Texture of Bighead Carp (Aristichthys Nobilis) Fillets Under Chilled and Partial Frozen Storage

This study aimed to evaluate the contribution of protein oxidation to the changes in the water-holding capacity (WHC) and texture of bighead carp (Aristichthys nobilis) fillets under chilled and partial frozen storage (4°C and ?3°C). The results indicated that less protein oxidation occurred to fillets at ?3°C than at 4°C, which was reflected by the higher value of salt-soluble protein contents (SSP), total sulfhydryl content (SH), Ca²⁺-ATPase activity, lower water-soluble protein contents (WSP), total disulfide content (SS), and surface hydrophobicity (So-ANS). However, the fillets had better WHC and texture at 4°C, as well as lower drip loss and higher centrifugal loss, hardness, and springiness. A significant linear relationship existed between protein oxidation parameters with WHC and texture characteristics for fillets under both types of storage, but the process of freezing and then thawing, instead of protein oxidation, was the main factor affecting the texture and WHC of fillets at ?3°C.     

Replacement of Rice Flour by Meat Flour Mechanically Separated from Tilapia on the Technological,Nutritional, and Sensory Quality of Salted Gluten-free Cookies

ABSTRACT

This work evaluated the technological, bacteriological, and sensorial quality of cookies produced with increasing levels (0%, 10%, 20%, 30%, and 40%) of mechanically separated meat flour from tilapia (MSMF) to replace rice flour (RF) in order to identify the optimal level without compromising the overall quality of the product. The cookies were analyzed for expansion index (EI), specific volume (SV), hardness, color, water activity (a_w ), coagulase-positive staphylococci, coliforms at 45°C, Salmonella spp., and sensory acceptance. The inclusion of MSMF affected (P < .05) some characteristics such as EI, SV, a_w , hardness, and color (L*, a*, b*), but all formulations met the legal bacteriological standards. Cookies with 20% substitution of RF by MSMF presented 58.82% carbohydrates, 18.53% proteins, and 11.31% lipids, and was the most accepted (P < .05); 51% of consumers rated it with a score of six or higher (above I liked slightly). It is concluded that the substitution of 20% of RF by MSMF can be used for nutritional enrichment of widely consumed conventional products.     

Effect of vacuum treatment on smoke penetration into boiled skipjack loins for production of smoke-dried skipjack

ABSTRACT: The present work evaluates the effect of vacuum treatment on smoke penetration into boiled skipjack loins for the production of smoke-dried skipjack. Using a vacuum freeze-dryer, the boiled skipjack loins were vacuumed immediately after being boiled at a pressure of 400 Pa for 30 min in order to reduce the lipid and water contents. The vacuumed boiled meats were then smoked and dried at 90 ± 10°C for 3 h a day for 6 days in a metal kiln (internal diameter 24 cm × 24 cm × 70 cm height), using an electric heater (1.2 kW) to heat and generate smoke from cherry tree wood chips. Also, non-vacuumed boiled meats were smoked in the same manner as a control. The vacuum treatment reduced the lipid and water contents by as much as 0.6% and 2.7% on the wet weight basis, respectively. Histological observations showed many clearances among the muscle fibers of the vacuumed boiled meats. The content of phenols that had penetrated the vacuumed boiled meats during the smoke drying procedure was significantly larger ( P < 0.05) than that of the non-vacuumed boiled meats. Accordingly, the vacuum treatment accelerated the penetration of phenols into the boiled meats and enhanced the function of antioxidant substances, which improved the quality of the smoke-dried skipjack.