Liquid chromatographic determination of N-methylcarbamate insecticides and metabolites in crops. II. Analytical characteristics and residue findings

Four laboratories obtained 177 carbamate recovery values using a liquid chromatographic method. The average recovery of 11 carbamates (aldicarb, aldicarb sulfone, bufencarb, carbaryl, carbofuran, 3-hydroxy carbofuran, 3-keto carbofuran, methiocarb, methiocarb sulfoxide, methomyl, and oxamyl) from 14 crops was 99% with a coefficient of variation of 8% (0.03-1.8 ppm fortification levels). No statistical difference in recovery was found between oxime and phenyl carbamates, or between parent and metabolite carbamates. Average recovery of aldicarb sulfoxide was 59% due to loss in the liquid-liquid partitioning because of the polarity of this compound. A fifth laboratory contributed 34 carbamate recoveries (average 99%) on table-ready food products for 4 carbamates. Bendiocarb, dioxacarb, isoprocarb, and propoxur are also quantitatively recovered through the method. Previously reported carbamate and noncarbamate recovery data are also discussed. In the Food and Drug Administration's (FDA) analysis of 319 samples (mainly crops), 86 (27%) were found to contain residues of carbamate insecticides and/or toxic carbamate metabolites. Carbaryl and methomyl were the most common carbamate residues found on the food products excluding the aldicarb sulfone and sulfoxide residues found on potatoes. In one FDA Total Diet Program "market basket", 11 of 69 table-ready food commodities contained from 0.005 to 0.094 ppm carbamate residues. Carbaryl was the most prevalent residue. Several laboratories reported adverse effects on the determinative system when inadequately purified reagents were used.     

Determination of coumaphos and its oxygen analog in eggs by in situ fluorometry.

A method is reported for the simultaneous determination of coumaphos (o,o-diethyl o(3-chloro-4-methyl-2-oxo-2H-1-benzopyran-7-yl)phosphorothioate) and its oxygen analog, Coroxon, in eggs in the ppb range. The residues are extracted with acetone and chloroform. The extract is purified by liquid-liquid partition followed by column chromatography and then by 2-dimensional thin layer chromatography. The fluorescence is measured directly on the chromatogram.     

Liquid chromatographic determination of carbadox residues in animal feed

A liquid chromatographic (LC) method for determining residues of carbadox in the 0.01-10 ppm range in swine feed is described. Carbadox is extracted from ground feed with 25% acidified methanol-CHCl3, removed from emulsion-forming coextractables via an alumina column, separated from highly colored pigments by acid-base liquid-liquid partitioning, and finally isolated from interferences on a second alumina column. Isocratic reverse phase LC at 305 nm is used for quantitation. The average overall recovery at the 0.1, 0.5, and 1.0 ppm spike levels was 83.0% with a standard deviation of 2.04% and a coefficient of variation of 2.46%.     

Liquid chromatographic determination of acifluorfen in soil and water

An analytical method based on the use of a liquid chromatograph equipped with a UV detector was developed for the determination of acifluorfen in soil and water. Acifluorfen was extracted from soil in methanol-0.10N NaOH (80 + 20 v/v) and from water by partition with dichloromethane. Solvent partitioning and solid-phase extraction were used to separate acifluorfen from major interfering sample components. Average recoveries from soil at 1, 0.1, and 0.01 ppm fortification levels were 95.1 +/- 3.4, 92.6 +/- 2.9, and 73.9 +/- 3.0%, respectively. Recoveries from water spiked at levels from 0.01 to 1 ppm averaged 96.5 +/- 5.4%. Method limits of detection were 0.006 ppm in soil and 0.003 ppm in water.     

Liquid chromatographic determination of N-methylcarbamate insecticides and metabolites in crops. I. Collaborative study

A liquid chromatographic (LC) multiresidue method for determining residues of N-methylcarbamate insecticides in crops was collaboratively studied in 6 laboratories. Methanol and a mechanical ultrasonic homogenizer are used to extract the carbamates. Water-soluble plant coextractives and nonpolar plant lipid materials are removed from the carbamate residues by liquid-liquid partitioning. Additional crop coextractives (e.g., carotenes, chlorophylls) are removed with a Nuchar SN-silanized Celite column. The carbamate residues are then separated on a reverse phase LC column, using an acetonitrile-water gradient mobile phase. Eluted residues are detected by an in-line post-column fluorometric detection technique. Seven carbamates and 2 carbamate metabolites were included in the collaborative study. Each collaborator determined all the carbamates at 2 levels (approximately 0.05 ppm and United States tolerance) in blind duplicate samples of grapes and potatoes. Fortified and control samples were analyzed. Repeatability coefficients of variation for all the carbamates on the 2 crops averaged 4.7% and ranged from 2.4 to 7.1%. Reproducibility coefficients of variation for all the carbamates on the 2 crops averaged 8.7% and ranged from 5.3 to 12.4%. Accuracy, measured by comparison with fortification values, averaged 95% and ranged from 79 to 103%. The estimated limit of quantitation is 0.01 ppm. The method has been adopted official first action.     

Gas-liquid chromatographic determination of famphur and its oxygen analog in tissues of reindeer and cattle.

A gas chromatography equipped with a flame photometric detector operating in the phosphorus mode provided a sensitive method for determining residues of famphur, O,O-dimethyl O-[p-(dimethylsulfamoyl)phenyl]phosphorothioate, and its oxygen analog in reindeer and cattle tissues. With extraction and cleanup, 0.025 ppm famphur and 0.06 ppm oxygen analog could be detected in the body tissues. Recoveries of 73-100% were obtained from fat, muscle, liver, and kidney.     

Ion-pairing liquid chromatographic determination of benzimidazole fungicides in foods

A method is described for determining residues in foods of thiabendazole, thiophanate methyl, the di-oxygen analogue metabolite [dimethyl 4,4'-O-phenylene bis (allophanate)] that is the metabolite name of the latter, and methyl-2-benzimidazole carbamate, which is the major metabolite and fungitoxic principle common to both thiophanate methyl and benomyl. The residues are extracted from the product using methanol and are partitioned into dichloromethane after initial acidification and again after subsequent alkalinization of the extract. Residues are separated and quantified by reverse-phase liquid chromatography using an ion-pairing mobile phase with UV and fluorescence detectors in tandem. Recoveries from 7 different food crops fortified at 0.2-35 ppm levels ranged from 64 to 105%.     

Sephadex LH-20 cleanup, high pressure liquid chromatographic assay, and fluorescence detection of zearalenone in animal feeds

A high pressure liquid chromatographic (HPLC) method is described to determine zearalenone in animal feeds at levels as low as 0.01 ppm. Samples are extracted with chloroform-ethanol and initially purified using a SEP-PAK silica cartridge, followed by column chromatography using Sephadex LH-20. Separation by normal phase HPLC is followed by fluorescence detection. Recoveries at levels of 1.0-0.01 ppm averaged greater than 90%. Confirmation included HPLC analysis of the sample and a zearalenone standard, using 3 different excitation wavelengths, and comparison of fluorescence responses obtained. The method was successfully applied to the analysis of 1 corn and 3 cornmeal samples. Zearalenone was detected in all 4 samples at levels of 0.379-19.2 ppm.     

Liquid chromatographic determination of three sulfonamides in animal tissue and egg

Sulfonamides are widely used as a feed additive in animal production in Japan. The present paper is a determination of 3 sulfonamides: sulfamethazine (SMZ), sulfamonomethoxine [SMX, 4-amino-N-(3-methoxypyrazinyl)-benzenesulfonamide], and sulfadimethoxine (SDX) in animal tissue and egg by liquid chromatography (LC). Tissues were extracted with acetonitrile and fat was removed by liquid/liquid partition. The sulfonamides were purified by an ODS cartridge column; then each compound was separated by an ODS LC column and detected at 268 nm. Quantification levels were 0.02 ppm for SMZ and SMX, and 0.04 ppm for SDX; detection limits were 0.01 ppm for SMZ and SMX, and 0.02 ppm for SDX. Calibration curves were linear between 2 and 40 ng for SMZ and SMX, and between 4 and 80 ng for SDX. Recoveries from muscle and egg samples spiked with 1-2 micrograms/10 g were 81-98%.     

Liquid chromatographic determination of oxfendazole in swine feeds

A relatively simple analytical method is presented for determination of oxfendazole (2-(methoxycarbonylamino)-5-phenylsulfinyl-benzimidazole) at levels as low as 0.012% in swine feeds, using cation exchange liquid chromatography (LC). The sample was extracted with a solvent mixture of methanol-glacial acetic acid (90 + 10) at 45 degrees C, using a gyrorotory shaker. Plant pigments and other feed excipients were removed using zinc acetate treatment and pH-controlled extraction. Oxfendazole was further separated from the remaining interferences and quantitatively determined by LC on a Partisil SCX column with acetonitrile-0.01M phosphate buffer as mobile phase. The method is stability-specific, linear, precise, and accurate at 80-120% labeled strength (relative standard deviation 0.9-1.7 with mean recovery of 98-99%). Supporting data at a level of 0.0135% oxfendazole in swine feed indicated that this method is capable of complete recovery of oxfendazole from medicated swine feeds.     

Liquid chromatographic method for determining the macrolide antibiotic sedecamycin and its major metabolites in swine plasma and tissues

A liquid chromatographic (LC) method was developed to determine sedecamycin, a 17-membered macrolide antibiotic used for treating swine dysentery, and its major metabolites (lankacidin C, lankacidinol A, and lankacidinol) in swine plasma and tissues. Plasma is directly extracted with ethyl acetate and analyzed by liquid chromatography without purification. Tissues are homogenized in a phosphate buffer containing sodium chloride, and then extracted with ethyl acetate. The extracts are subjected to silica gel-Florisil, double-layered column chromatography to remove endogenous interfering substances. The LC determination uses silica gel and ODS-silica as a stationary phase. The detection limits for sedecamycin and its metabolites were less than or equal to 0.05 ppm, and average recoveries and coefficients of variation (0.2-1 ppm range) were greater than 75% and less than 10%, respectively.     

Gas chromatographic determination of pentachlorophenol in gelatin: collaborative study

Eleven collaborators participated in this study of a gas chromatographic method for the determination of pentachlorophenol (PCP) in gelatin. Following acid hydrolysis of a 2 g sample, PCP is extracted with hexane and partitioned into KOH solution. After reacidification, PCP is again extracted with hexane for determination by electron capture gas chromatography on a 1% SP-1240DA column. Three duplicate practice samples (0.0, 0.5, and 1.5 ppm) and 5 blind duplicate collaborative samples (0.0, 0.02, 0.1, 0.5, and 2.0 ppm) were analyzed by each collaborator. Mean recoveries of PCP in the collaborative samples ranged from 88% at the 0.02 ppm fortification level to 102% at the 0.1 ppm level; the overall mean recovery was 96%. Interlaboratory coefficients of variation ranged from 16.4% for the 0.1 ppm fortification level to 22.9% for the 0.5 ppm level; the overall interlaboratory coefficient of variation was 19.5%. The method has been adopted official first action.     

Liquid chromatographic determination of the processing aid 4-hexylresorcinol in shrimp.

A rapid, sensitive, liquid chromatographic (LC) method has been developed for determination of residuals of the processing aid, 4-hexylresorcinol, on shrimp meat. An aqueous homogenate of shrimp meat is extracted with ethyl acetate followed by precolumn preparation on a silica Sep-Pak cartridge. LC determination is preformed with a Nova-Pak C18 column, with UV detection at 214 nm. Sensitivity was 0.006 micrograms, and recovery from shrimp meat samples of known 4-hexylresorcinol addition was 94%. Shrimp treated with 4-hexylresorcinol under the recommended dip protocol had mean residuals of 1.18 ppm, with a standard deviation of 0.13 ppm.     

Liquid chromatographic determination of amprolium in chicken tissues, using post-column reaction and fluorometric detection

A method is presented for determination of amprolium residues in chicken muscles by a liquid chromatographic post-column reaction system. The drug is extracted from muscles with methanol, and the extract is concentrated to 3-4 mL. This aqueous solution is rinsed with n-hexane and cleaned up by alumina column chromatography. The drug is separated from the interferences on a LiChrosorb RP-8 column, reacted with ferricyanide in alkaline solution, and quantitated by fluorometric detection at 367 nm (excitation) and 470 nm (emission). Recoveries of amprolium added to chicken muscles at levels of 0.1 and 0.2 ppm were 74.9 and 80.9%, respectively. The detection limit was 1 ng for amprolium standard and 0.01 ppm in chicken muscles.     

Gas-liquid chromatographic determination of pentachlorophenol in milk

A gas-liquid chromatographic (GLC) method developed by other workers for determining pentachlorophenol (PCP) in water has been adapted for determining PCP in raw and homogenized milk. PCP is extracted from milk with benzene and from the benzene into a potassium carbonate solution. Acetic anhydride is added to the aqueous solution to form PCP acetate, which is extracted into hexane and then determined by electron capture GLC. Duplicate determinations of PCP in milk fortified at levels of 0.02, 0.2, and 2.0 ppm gave respective average recoveries of 80.0, 87.2, and 85.0%. PCP levels as low as 0.005 ppm can be detected in 20 g milk.     

Rapid confirmatory assay for determining 12 sulfonamide antimicrobials in milk and eggs by matrix solid-phase dispersion and liquid chromatography-mass spectrometry

A rapid confirmatory method for determining 12 sulfonamide (SAs) antibacterials in whole milk and eggs is presented. This method is based on the matrix solid-phase dispersion technique with hot water as extractant followed by liquid chromatography (LC)-mass spectrometry (MS). The LC-MS instrument was equipped with an electrospray ion source and a single quadrupole. After 4 mL of a milk sample containing the analytes had been deposited on sand (crystobalite), this material was packed into an extraction cell. SAs were extracted by flowing 4 mL of water through the cell heated at 75 degrees C. With some modifications, this procedure was applied also to eggs. After pH adjustment and filtration, 0.5 mL of the final extracts was then injected into the LC column. MS data acquisition was performed in the positive-ion mode and by monitoring at least three ions for each target compound. The in-source collision-induced dissociation process produced confirmatory ions. At the 50 ng/g level, recovery of the analytes in milk and eggs was 77-92% with relative standard deviations ranging between 1 and 11%. Estimated limits of quantification (S/N = 10) were 1-3 ng/g of SAs in milk and 2-6 ng/g in eggs. With both matrices, attempts to reduce the analysis time by using a short chromatographic run time caused severe ion signal suppression for the early-eluted SAs. This effect was traced to competition effects by polar endogenous coextractives, maybe proteinaceous species, which are eluted in the first part of the chromatographic run. This unwelcome effect was almost completely removed by simply adopting more selective chromatographic conditions.     

Gas-liquid chromatographic determination of thiabendazole and methyl 2-benzimidazole carbamate in fruits and crops.

A method is described for the electron capture gas-liquid chromatographic determination of thiabendazole and methyl 2-benzimidazole carbamate (MBC) after derivatization with pentafluorobenzyl bromide (PFB-Br). The samples are extracted with ethyl acetate, and the residual thiabendazole, benomyl, and MBC are isolated by liquid-liquid extraction into dilute HCl. After neutralization and re-extraction with ethyl acetate, thiabendazole and MBC are reacted with PFB-Br to form the PFB derivatives. Alumina column chromatography was used to clean up extracts, and the derivatives could be detected as low as 5-10 pg. Recoveries were 95-98% from fruits fortified with 0.3-2.0 ppm thiabenzadole; recoveries were 91-97% when 0.05-1.0 ppm benomyl/MBC were added to fruits/crops. The PFB derivatives were identified by gas-liquid chromatography-mass spectrometry.     

High-speed liquid chromatographic determination of monensin, narasin, and salinomycin in feeds, using post-column derivatization

A high-speed liquid chromatographic (LC) method using post-column derivatization is described for the determination of monensin, narasin, and salinomycin in a variety of animal feeds. The ionophores are extracted with hexane-ethyl acetate (90 + 10). A portion of the sample is evaporated, diluted to a known volume, and analyzed using a 6 cm 3 microns C18 column and an absorbance detector after post-column reaction with vanillin. The method has been applied to poultry and swine feeds with levels of 3-100 ppm added antibiotic. A comparison was also carried out with medicated poultry feed and beef feed lot supplement samples previously analyzed by 2 separate bioassay methods for monensin and salinomycin, respectively. Recoveries for the LC method ranged from 92.1 to 103% with an average recovery of 98.1% and a coefficient of variation of 3.65%.     

Gas chromatographic determination of mecarbam and its metabolites mecarboxon, diethoate, and diethoxon in cottonseeds

A gas chromatographic method is described for determining residues of mecarbam and 3 of its metabolites, mecarboxon, diethoate, and diethoxon, in cottonseeds. For mecarbam analysis, following Soxhlet extraction with chloroform (after blending), the oily extract is partitioned with propylene carbonate and cleaned up on a silica gel column. Metabolites are extracted by the same method, followed by cleanup of mecarboxon on a silica gel column or diethoxon on an alumina column; cleanup of diethoate can be performed on either column. All 4 compounds are determined using a flame photometric detector equipped with a phosphorus filter. Average recoveries for cottonseed samples fortified with 0.03-1.0 ppm mecarbam ranged from 80 to 88%. Average recoveries were 81-88% for mecarboxon and 90-92% for diethoate (alumina column) and diethoxon from samples fortified with 0.05-1.0 ppm. Average recovery of diethoate from samples cleaned up on the silica gel column were 84-88% in the range of 0.05-0.2 ppm. Values obtained for mecarbam residues in field-treated samples are also presented.     

Liquid chromatographic determination of chlortetracycline hydrochloride in ruminant and poultry/swine feeds.

A liquid chromatographic (LC) method is described for the determination of chlortetracycline hydrochloride (CTC) in poultry/swine and ruminant feeds in the 10-100 ppm range and in premix. CTC is extracted from ground feed/premix with acidified acetone, and the extract is filtered through a Millex-HV filter or disposable C18 column. The filtrate is partitioned with methylene chloride when additional cleanup is necessary. A Nova-Pak C18 column is used for LC separation with determination at 370 nm. The average recovery of CTC from premix was 95% with a standard deviation (SD) of 1.70 and a coefficient of variation (CV) of 1.79%. The overall average recovery from feeds was 77% with an SD of 3.18 and a CV of 4.10%.