Phytic acid,in vitro protein digestibility,dietary fiber,and minerals of pulses as influenced by processing methods

The objective of this project was to determine the effect of various types of processing on selected nutrition related parameters of commonly consumed Indian pulses and soybean. Germination reduced the phytic acid content of chickpea and pigeonpea seeds by over 60%, and that of mung bean, urd bean, and soybean by about 40%. Fermentation reduced phytic acid contents by 26–39% in all these legumes with the exception of pigeonpea in which it was reduced by more than 50%. Autoclaving and roasting were more effective in reducing phytic acid in chickpea and pigeonpea than in urd bean, mung bean, and soybean. Germination and fermentation greatly increased the in vitro protein digestibility (IVPD). IVPD was only slightly increased by roasting and autoclaving of all legumes. Germination and fermentation also remarkably decreased the total dietary fiber (TDF) in all legumes. Autoclaving and roasting resulted in slight increases in TDF values. All the processing treatments had little effect on calcium, magnesium and iron contents.     

Relationship between total sulphur and sulphur amino acids in chickpea (Cicer arietinum L.) and pigeonpea (Cajanus cajan [L.] Millsp.)

Total sulphur was determined in seed meal of 30 chickpea and 24 pigeonpea cultivars by the wet digestion procedure and by using the Leco sulphur analyser. Methionine and cystine were determined after performic acid oxidation in an amino acid analyser. The two methods used for total sulphur determinations were highly correlated (r=0.943). Percent meal protein was significantly correlated (r=0.476) with total sulphur in chickpea but not in the case of pigeonpea. Total sulphur content exhibited a significant positive correlation (r=0.651) with sulphur amino acids of pigeonpea when expressed as percent of protein but not in the case of chickpea. Correlation coefficients between total sulphur and sulphur amino acids when the results were expressed as percent of sample were positive for both chickpea (r=0.494) and pigeonpea (r=0.534). The amount of sulphur in methionine and cystine accounted for 54.8% of the total sulphur in chickpea and for 75.5% in pigeonpea. In both chickpea and pigeonpea, methionine was positively and significantly correlated with cystine when they were expressed either as percent of sample or as percent of protein.Submitted as J.A. no. 159 by the International Crops Research Institute for the Semi-Arid Tropics (ICRISAT).     

不同基因型玉米磷素分配及子粒植酸磷积累的研究

对不同基因型玉米磷素分配及子粒植酸磷积累进行研究。结果表明,不同杂交种玉米各营养器官磷素分配与子粒植酸磷浓度及其积累量存在基因型差异,郑单958和浚单20相对植酸磷浓度低,分别为1.57、1.59 g/kg。子粒中植酸磷占总磷的比例平均值为56%,其中,永玉2号最高,约为62%;浚单20和郑单958较低,约为49%。不同基因型玉米各部位磷浓度、积累量与子粒植酸磷浓度完熟期存在相关性,其上部叶、下部叶、苞叶、穗轴、子粒的磷浓度和茎秆、上部叶、下部叶、苞叶、穗轴、子粒的磷积累量与子粒的植酸磷积累量均达显著水平(P0.05)。     

Effects of various water or hydrothermal treatments on certain antinutritional compounds in the seeds of the tribal pulse,Dolichos lablab var.vulgaris L.

Effects of soaking, cooking and autoclaving on changes in polyphenols, phytohaemagglutinating activity, phytic acid, hydrogen cyanide (HCN), oligosaccharides and in vitro protein digestibility were investigated in seeds ofDolichos lablab var.vulgaris. Both distilled water and NaHCO₃ solution soaking and autoclaving significantly reduced the contents of total free phenolics (85–88%) compared to raw seeds. Autoclaving (45 min) reduced the content of tannins by upto 72%. Soaking seemed to have limited effect in eliminating phytohaemagglutinating activity, whereas autoclaving (45 min) seemed to eliminate the haemagglutinating activity completely. The reduction in content of phytic acid was found to be some what greater in distilled water soaking (28%) compared to NaHCO₃ solution soaking (22%). Only a limited loss in content of phytic acid was observed under cooking as well as autoclaving. Loss of HCN was greater under autoclaving (87%) compared to the other processes studied. Of the three sugars analysed, soaking reduced the level of verbascose more than that of stachyose and raffinose. Autoclaving reduced the content of oligosaccharides more efficiently (67–86%) than ordinary cooking (53–76%). Autoclaving improved the in vitro protein digestibility (IVPD) significantly (13%). Of all the different water and hydrothermal treatments studied autoclaving seemed to be the most efficient method in improving IVPD and eliminating the antinutrients investigated except phytic acid.     

籽粒植酸含量降低率作为磷高效大豆品种辅助筛选指标的可行性研究

为了明确籽粒植酸含量降低率作为磷高效大豆品种筛选指标的可行性,本试验以26个大豆品种为材料,采用沙培盆栽法,测定正常磷和低磷水平下各品种产量、农艺性状、生理指标和植酸含量并分析各指标间的相关性。根据产量损失率将26个品种聚类成A^G共7个类型,A类品种产量损失率均小于10%,G类品种产量损失率大于60%;B^F各类品种产量损失率介于A、G中间。产量、植酸含量与株高、茎粗、叶绿素含量、净光合速率、地上及地下部含磷量均呈正相关关系,其中与茎粗和净光合速率呈显著正相关。在正常磷及低磷条件下,A^G各类型品种籽粒植酸含量变化无明显规律,但A类大豆品种籽粒植酸含量降低率小于30%,G类则大于80%。田间种植试验进一步证实植酸含量降低率低于30%的品种耐低磷指数大于1.0,属于强磷高效类型;G类品种耐低磷指数小于0.6,属于弱磷高效类型;B^F各类品种介于A、G中间。综上所述,正常磷与低磷水平下大豆籽粒植酸含量降低率可以作为又一个关键指标,与产量及部分农艺性状协同筛选磷高效大豆品种。     

Effect ofCallosobruchus chinensis (Bruchid) infestation on antinutritional factors in stored legumes

Effect of bruchid infestation on selected antinutritional factors, saponin, phytic acid and trypsin inhibitor activities, of three (mung bean, chickpea and pigeon pea) legumes stored for six months was studied. The three antinutritional factors, saponin, phytic acid and trypsin inhibitor activity (TIA), increased with increased storage period. Saponin, phytic acid and trypsin inhibitor activity values were significantly lower in control samples compared to stored infested samples. The difference between the contents of antinutritional factors were significant (p<0.05) during different storage periods.     

Effect of domestic processing on the cooking time,nutrients, antinutrients andin vitro Protein digestibility of the African yambean (Sphenostylis stenocarpa)

The effects of processing (soaking, dehulling, fermentation and heat treatment) on the cooking time, protien, mineral, tannin, phytate and in vitro protein digestibility (IVPD) of the african yambean (AYB) were examined. The cooking time ranged from 90–155 minutes. Soaking reduced cooking time by about 50 percent. Soaking for 12 hours was the most appropriate to reduce cooking time, tannin and phytate levels. It improved in vitro protein digestibility (IVPD). Prolonged soaking (24 hours) decreased calcium (Ca) and iron (Fe) values by 19 percent and 35 percent, respectively. Dehulling showed that Ca, Fe, magnesium (Mg) and zinc (Zn) were concentrated in the seed coat of the AYB. The seeds soaked and dehulled retained Mg and Zn. Dehulling reduced tannin but had no significant effect on phytate and the IVPD of the AYB except for seeds soaked for 12 hours before dehulling. Soaking for 24 hours before dehulling significantly increased crude protein content by 16 percent (p<0.05). Blanching and roasting increased the IVPD by 8–11 percent. Fermentation had no effect on the crude protein, Ca, Fe, Mg and Zn but significantly reduced phytate content of the AYB. Fermentation had no advantage over heat treatment with respect to improving the in vitro protein digestibility of the AYB.     

Content of antinutrients and in vitro protein digestibility of the African yambean,pigeon and cowpea

The protein, trypsin inhibitor (TI), tannin, phytate, phytic acid phosphorus and in vitro protein digestibility (IVPD) of cultivars of the African yambean (Sphenostylis stenocarpa) — AYB, pigeon pea (Cajanus cajan) — PP and cowpea (Vigna unguiculata) — CP were determined. The protein content of CP (24–28.0%) was higher than those of PP (21–22.5%) and AYB (21–22.5%). The cream and speckled AYB contained more TI (30.9 and 25.3 mg/g) than PP (7.5–14.1 mg/g) and CP (9.8–20.5 mg/g). Apart from the white CP cultivar, they contained more tannin (1.24–1.42 mg/g) than PP (0.14–0.97 mg/g) and AYB (0.71–1.17 mg/g). Phytate was lowest in the AYB (6.30–7.49 mg/g) than PP (8.31–11.31 mg/g) and CP (8.40–9.92 mg/g). Phytic acid contributed 67–74% of the phosphorous in the AYB, 66–75% in PP and 54–59% in CP. The IVPD of the AYB (73.3±0.7%) was significantly lower (p<0.05) than those of PP (76.34±0.2%) and CP (77.8±0.4%). There was a significant negative correlation between TI and IVPD (r=–0.63,p<0.05). There was no significant correlation between IVPD and phytate and tannin contents. There was a positive correlation between protein content and IVPD (r=0.69**) for the legumes under study. These legumes may pose no serious problems to populations consuming them especially when heat treatment is applied before consumption.     

Effect of nitrogen fixation,nitrogen fertilization and viral infection on yield,tannin and protein contents and in vitro protein digestibility of faba bean

A field investigation of two faba bean cultivars (cv.), Agabat and Silaim, showed that bean yellow mosaic virus (BYMV) infection reduced (p≤0.001) yield (Kg/ha), protein content and in vitro protein digestibility (IVPD) but increased (p≤0.05) tannin content (mg/100 ml). Nitrogen fertilization with viral infection significantly reduced yield and IVPD for cv. Silaim and increased (p≤0.05) protein and tannin contents. Nitrogen fertilization alone was found to increase (p≤0.05) yield, protein and tannin contents but slightly reduced IVPD.Rhizobium inoculation with viral infection significantly decreased yield per unit area, protein content and IVPD, but increased (p≤0.05) tannin content.Rhizobium inoculation alone significantly increased (p≤0.001) yield and tannin content and slightly increased protein content but decreased IVPD. The results indicated that nitrogen fertilization or nitrogen fixation increased yield, protein and tannin contents and decreased IVPD. Viral infection had an adverse effect on yield, protein content and IVPD but had no effect on tannin content.     

Nutritional Evaluation and Shelf Life Studies of Papads Prepared from Wheat–Legume Composite Flours

The present study was carried out to develop papads from wheat and legume blends and to analyze them for organoleptic acceptability, nutritional quality, and keeping quality. Papad is a dehydrated product prepared from dhals or rice. A firm but pliable dough is made from the flours of dhals or rice with addition of suitable seasoning. It is shaped into balls, rolled out thin, dried and toasted over open fire so as to give a light, crisp product. Mung flour papads were kept as control and wheat flour, chickpea flour, and pea flour were used to supplement mung flour papads. Three different proportions (10, 20, 30%) of each flour were used to supplement Mung flour. Papads with wheat flour (10%), chickpea flour (20%), and pea flour (10%) level of supplementation were found to be most acceptable and these papads were subjected to nutritional evaluation. Protein content significantly increased on supplementation with legume flours at all levels. Fat content was significantly higher in chickpea flour supplemented papads. Ash content varied significantly from 10.17 to 10.78% in papads. Total carbohydrates decreased significantly on supplementation with chickpea flour. Copper content increased significantly on supplementation. A significant decrease in phytic acid and trypsin inhibitor of supplemented papads was found. In vitro protein digestibility significantly increased on supplementation but a significant decrease in in vitro starch digestibility was found in supplemented papads. Storage studies showed that chickpea flour and pea flour supplemented papads can be stored safely for 60 days and wheat flour supplemented papads for 30 days both at room and refrigeration temperatures.     

Distribution of seed protein fractions and amino acids in different anatomical parts of chickpea (Cicer arietinum L.) and pigeonpea (Cajanus cajan L.)

Studies on protein fractionation in seed coat, embryo, cotyledons and whole seed were made to observe the differences, if any, between chickpea and pigeonpea. Results indicated that globulin was the major fraction of embryo and cotyledons of these legumes. Seed-coat nitrogen was observed to be mostly comprised of nonprotein nitrogen and glutelin fractions and thus differed from other components in both chickpea and pigeonpea. The albumin fraction of cotyledons of both crops had the highest concentration of sulphur amino acids, methionine and cystine. Glutelin contained a considerably higher concentration of methionine and cystine than did globulin in chickpea and pigeonpea. This suggests that lines with higher glutelin should be identified to improve their protein quality. The amino acid compositions of different seed components did not show large differences between these two pulse crops.Submitted as JA no. 180 by the International Crops Research Institute for the Semi-Arid Tropics (ICRISAT).     

Genetic variation for phytic acid content in mungbean(Vigna radiata L. Wilczek)

Mungbean(Vigna radiata L. Wilczek) is a short-duration legume crop cultivated for seeds that are rich in protein and carbohydrates. Mungbeans contain phytic acid(PA), an anti-nutritional factor that is the main storage form of organic phosphorus in seeds. It is a strong inhibitor against the absorption of nutrients including iron, zinc, calcium and magnesium in monogastric animals. Genotypes with low phytic acid(lpa) in seed may show increased assimilation of nutrients and be useful in breeding lpa cultivars. The present study was conducted to identify lpa sources, genetic variation, heritability, and association with seed coat color, inorganic phosphorus(IP), and seed size in 102 mungbean genotypes including released varieties, land races, mutants, and wild species grown in two seasons: summer 2011 and rabi 2012. PA and IP in dry seeds were estimated by modified colorimetric method and Chen's modified method,respectively. PA, IP, and 100-seed weight differed significantly in the two seasons. PA content in102 genotypes ranged from 5.74 to 18.98 mg g-1and 5.85 to 20.02 mg g-1in summer 2011 and rabi 2012, respectively. High heritability was found for PA(0.87 and 0.86) and seed size(0.82 and0.83) but low heritability for IP(0.61 and 0.60). A negative correlation was found between PA and seed size(r =-0.183 and-0.267). Yellow and green seed coat genotypes contained significantly less PA than black seed coat genotypes. Cluster analysis revealed the distinctness of wild species, land races and cultivated varieties on the basis of PA content. The genotypes YBSM(6.001 mg g-1) and JL-781(6.179 mg g-1) showed lowest PA. These lpa sources can be used to develop high-yielding mungbean cultivars with low phytic acid.     

Chemical composition and nutritional quality ofCleome dolichostyla seeds

Seeds ofCleome dolichostyla were analysed for proximate composition, mineral element contents and amino acid composition, in-vitro protein digestibility (IVPD) and calculated protein efficiency ratio (C-PER). The seeds (dry basis) were rich in oil (32.1%), protein (24.6%) and fiber (17.8%) content. The contents of various mineral elements mg/100 g) were: Ca=1970, P=493, Mg=127, Na=35, K=465, Fe=71.97, Zn=2.25, Cu=0.44 and Mn=1.45. Aspartic acid, glutamic acid, glycine, arginine and histidine were the major amino acids inC. dolichostyla seed protein accounting for half of the total amino acids. Lysine was the most limiting essential amino acid (FAO/WHO, 1973 reference pattern) with a chemical score of 45 for the protein. The IVPD of cleome seed protein was 72.2% and C-PER was 1.08 relative to the IVPD and C-PER values of 90.0% and 2.50 for the Animal Nutrition Research Council casein.     

Nutritional assessment of seed proteins in rice bean [Vigna Umbellata (Thumb.) Ohwi and Ohashi

Seeds of three rice bean accessions had 17.26 to 21.42% protein, 3.46 to 4.03% fat, 61.09 to 64.73% carbohydrates 3.99 to 4.58% ash and 5.22 to 7.43% fiber (dry weight basis).The most limiting amino acids in the seed meal, albumin and globulin fractions, were methionine and cysteine with chemical scores of these fractions being 38% to 59%. The amino acid pattern of globulin and seed meal were similar.Thein vitro protein digestibility (IVPD) ranged from 82 to 86% for the seed meal, 86 to 88.5% for the albumin and 75.9 to 83.3% for the globulin. Relative nutritive values (RNV) of raw mature seed of two accessions were 22.6% and 42.4% and increased to 55.6% to 79.4% after boiling and roasting.Part of MS thesis of the senior author.     

Digestibility of proteins and starch (in vitro) of amphidiploids (black gram×mung bean) as affected by domestic processing and cooking

The effects of different domestic processing and cooking methods on starch digestibility (in vitro) and protein digestibility (in vitro) of four strains of amphidiploids (black gram×mung bean) were investigated. An increase of 35 to 48% and 22 to 25% was observed in starch digestibility and protein digestibility, respectively, when the seed of amphidiploids were soaked for 18 h. Cooking (both of unsoaked and soaked seeds) and germination improved significantly the starch digestibility and protein digestibility of all the varieties.     

水稻籽粒不同部位植酸含量及其与稻米品质的相关性

 选用13个不同类型的水稻品种,对其籽粒不同部位植酸含量品种间差异及与稻米主要品质性状间的相关性进行了分析。结果表明,供试13个水稻品种米糠、糙米、颖壳、精米的植酸含量平均值分别为48.51、9.77、1.40和0.91 mg/g,而且不同水稻品种间籽粒不同部位的植酸含量存在极显著差异。在籽粒中,米糠中植酸积累最多,其次是精米,颖壳最少。米糠中植酸含量与糙米和颖壳中植酸含量呈极显著正相关。糙米和米糠中植酸含量与稻米蛋白质含量均呈显著的负相关,与千粒重均呈显著正相关。     

Nutritional evaluation of experimental weaning foods prepared from green leaves,peanut oil,and legume flour

Experimental weaning foods were prepared from alfalfa leaves, peanut oil, and mung bean, chickpea or soy flour. The weaning foods were analyzed to determine their yield, proximate composition and amino acid content. Yields from starting materials ranged from 29 to 99%. Highest yields were obtained when 20% legume or oilseed flour was incorporated into leaf protein-peanut oil gels. The moisture content of the weaning foods ranged from 42 to 65%, protein from 3.4 to 6.5%, fat from 23 to 48%, and carbohydrate from 3 to 13%. Proteins in the experimental weaning foods were found to be deficient in the sulfur amino acids. Amino acid scores for weaning foods containing 20% legume or oilseed flour ranged from 50 for mung bean to 62 for soy. It was estimated that a four-ounce daily serving of one of the soy weaning foods would supply 40% of the energy and 35% of the protein needs of a one-year-old infant.     

Effect of treatment on composition and protein and energy utilization of rice and mung bean by rats

Yellow rice derived from stack-burned unthreshed grains had lower lysine content than white milled rice. Stack burning did not affect energy digestibility in growing rats but decreased true nitrogen digestibility and net protein utilization (NPU). Increasing parboiling time from 20 to 60 min had no adverse effect on energy and protein utilization of parboiled milled rice. Defatting of rice bran-polish with petroleum ether at 50°C had no effect on protein utilization but decreased energy content and utilization. Mechanical dehulling of mung bean (Vigna radiata [L.] Wilczek) reduced fiber content, increased energy and protein digestibility but decreased biological value (BV) and NPU. Toasting and winnowing the bean reduced lysine content, improved digestible energy but decreased BV and NPU. Cooking the bean preparations improved the biological value only in mechanically dehulled bean with resultant higher NPU than that of whole bean.     

常见食用豆类提取液抗氧化特性研究

以大豆(黄豆)、绿大豆、黑大豆、黑小豆、蚕豆、绿豆、赤豆、刀豆、芸豆、饭豆、麻豇豆、花豇豆、豌豆、小扁豆、鹰嘴豆等为原料,采用清除[DPPH·]自由基和猪油体系的抗氧化试验来测定其抗氧化特性,为食用豆类功能特性的开发利用提供参考.结果表明:刀豆、黑小豆、花豇豆清除[DPPH·]自由基的能力明显强于其他豆类,鹰嘴豆、绿大豆、黄大豆清除自由基能力较弱.刀豆、芸豆、饭豆的提取液能显著延长猪油氧化的诱导时间,表现出很强的抗猪油氧化能力,赤豆、蚕豆、花豇豆的抗猪油氧化能力则相对较弱.     

Rabadi fermentation of wheat: Changes in phytic acid content andin vitro digestibility

Fermentation of raw as well as autoclaved wheat flour with buttermilk at 30, 35 and 40°C for 6, 12, 18, 24 ad 48h significantly decreased the level of phytic acid; maximum decrease was observed at 40°C for 48h. Starch as well as protein digestibility (in vitro) improved with an increase in temperature and period of fermentation. Phytic acid had a significant (P<0.05) negative correlation with digestibility (in vitro) of both starch and protein ofrabadi.