Rennet-induced aggregation of heated pH-adjusted skim milk

Heated (20-100 °C/0-30 min) skim milks (pH 6.5-7.1) were diluted in buffer (pH 7.0). Rennet was added, and the particle size with time was measured. For all samples, the size initially decreased (lag phase) and then increased (aggregation phase). Milks heated at ≤60 °C had short lag phases and rapid aggregation phases regardless of pH. Milks heated at >60 °C at pH 6.5 had long lag phases and slow aggregation phases. As the pH increased, the lag phase shortened and the aggregation phase accelerated. The aggregation time was correlated with the level of whey protein associated with the casein micelles and with the level of κ-casein dissociated from the micelles. Heated milks formed weak gels when renneted. It is proposed that the milks heated at low pH have whey proteins associated with the casein micelles and that these denatured whey proteins stabilize the micelles to aggregation by rennet and therefore inhibit gelation. In the milks heated at higher pH, the whey proteins associate with κ-casein in the serum and, on rennet treatment, the κ-casein-depleted micelles and the serum-phase whey protein/κ-casein complexes aggregate; however, the denatured whey proteins stabilize the aggregates so that gelation is still inhibited.     

Mechanism for the ethanol-dependent heat-induced dissociation of casein micelles

An explanation as to how casein micelles dissociate when heated in the presence of ethanol is presented. Dissociation of casein micelles in milk-ethanol mixtures was studied using (1)H NMR, and the effects of addition of CaCl(2), NaCl, or EDTA or alteration of milk pH on this dissociation were studied. It is proposed that at low temperatures, ethanol reduces the solvent quality of milk serum, but above a critical temperature (approximately 30 degrees C in a 35% ethanol solution), ethanol enhances solvent quality and dissociates the casein micelles. Ethanol reduced protein hydrophobicity and increased the pK(a) value of phosphoserine, effects that are likely to be significant in the dissociating effect of ethanol at elevated temperatures.     

Interaction between casein micelles and whey protein/κ-casein complexes during renneting of heat-treated reconstituted skim milk powder and casein micelle/serum mixtures

Casein micelles were separated from unheated reconstituted skim milk powder (RSMP) and were resuspended in the serum of RSMP that had been heated, with and without dialysis of this serum against unheated RSMP. Using size-exclusion chromatography, it was found that the soluble complexes of whey protein (WP) with κ-casein in the serum of the heated milk bind progressively to unheated casein micelles during renneting, even prior to the onset of clotting. Similar trends were noted when casein micelles from RSMP heated at pH values of 6.7, 7.1, or 6.3, each with different amounts of WP coating the micelles, were renneted in the presence of soluble WP/κ-casein complexes. No matter what was the initial load of micelle-bound WP complexes, all micelle types were capable of binding additional serum protein complexes during renneting. However, it is not clear that this binding of WP/κ-casein complexes to the micellar surface is a direct cause of the impaired rennet clotting of the RSMP.     

Limited enzymatic treatment of skim milk using chymosin affects the micelle/serum distribution of the heat-induced whey protein/kappa-casein aggregates

The effects of heat treatment and limited kappa-casein hydrolysis on the micelle/serum distribution of the heat-induced whey protein/kappa-casein aggregates were investigated as a possible explanation for the gelation properties of combined rennet and acid gels. Reconstituted skim milk was submitted to combinations of 0-67% hydrolysis of the kappa-casein at 5 degrees C and heat treatment at 90 degrees C for 10 min. The protein composition of the ultracentrifugal fractions was obtained by reverse-phase high-performance liquid chromatography (RP-HPLC). The aggregates contained in each phase were isolated by size-exclusion chromatography and analyzed by RP-HPLC and sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Upon heating only, 20-30% of the total kappa-casein dissociated, while 20-30% of the total whey protein attached to the micelles. When heated milk was renneted, little changes were observed in the distribution and composition of the aggregates. Conversely, the heat treatment of partially renneted milk induced the formation of essentially micelle-bound aggregates. The results were discussed in terms of the preferred interaction between hydrophobic para-kappa-casein and denatured whey proteins.     

Solvent-mediated disruption of bovine casein micelles at alkaline pH

The disruption of casein micelles at alkaline pH was investigated using turbidity measurements. The rate and extent of disruption of casein micelles at alkaline pH (8.0-11.0) increased with pH. Furthermore, the extent of alkaline disruption increased with increasing temperature (5-40 degrees C). Preheating milk for 10 min at 90 degrees C did not influence the extent of alkaline disruption of casein micelles, suggesting that whey proteins do not influence the alkaline disruption process. Levels of ionic calcium and serum calcium and phosphate decreased in a logarithmic fashion with increasing pH, indicating precipitation of calcium phosphate onto the casein micelles. A mechanism for alkaline disruption of casein micelles is proposed, in which increasing the milk pH improves the solvent quality for the caseins, thereby leading to the disruption of casein micelles into their constituent nanoclusters; increases in the net-negative charge on the caseins on increasing pH may contribute to micellar dissociation.     

Role of kappa-casein in the association of denatured whey proteins with casein micelles in heated reconstituted skim milk

Reconstituted skim milk at pH from 6.5 to 7.1 was unheated, preheated (68 degrees C/20 min), or heated at 90 degrees C for 20-30 min. On preheating, the size of the casein micelles decreased by about 5-20 nm, with a greater effect at higher pH. The casein micelle size of the heated milk at pH 6.5 increased by about 30 nm when compared to that of the unheated or preheated milk. As the pH was increased before heating, the particle size gradually decreased so that, at pH 7.1, the size was markedly smaller than that for the unheated milk and slightly smaller than that for the preheated milk. High levels (about 85%) of denatured whey protein associated with the casein micelles at pH 6.5, and this level decreased as the pH increased so that, at pH 7.1, low levels (about 15%) were associated with the micelles. Low levels of alphaS-casein and beta-casein were found in the serum regardless of the heat treatment or the pH of the milk. At pH 6.5, low levels (about 10%) of kappa-casein were also found in the milk serum. In the unheated milk, the level of serum kappa-casein increased slightly with increasing pH; in the heated samples, the level of serum kappa-casein increased markedly and linearly with increasing pH so that, at pH 7.1, about 70% of the kappa-casein was in the serum phase. The results of this study indicate that the pH dependence of the levels of serum phase kappa-casein may be responsible for the change in distribution of the whey proteins between the colloidal and serum phases. This is the first report to demonstrate significant levels of dissociation of kappa-casein from the micelles at pH between 6.5 and 6.7, although this dissociation phenomenon is well known on heating milk at high temperatures at pH above 6.7.     

Reversible precipitation of casein micelles with a cationic hydroxyethylcellulose

The cationic hydroxyethylcellulose Polyquaternium 10 (PQ10) was found to produce a dose-dependent destabilization of casein micelles from whole or skim milk without affecting the stability of most of the whey proteins. The anionic phosphate residues on caseins were not determinant in the observed interaction since the destabilization was also observed with dephosphorylated caseins to the same extent. However, the precipitation process was completely inhibited by rising NaCl concentration, indicating an important role of electrostatic interactions. Furthermore, the addition of 150 mM NaCl solubilized preformed PQ10-casein complexes, rendering a stable casein suspension without a disruption of the internal micellar structure as determined by dynamic light scattering. This casein preparation was found to contain most of the Ca2+ and only 10% of the lactose originally present in milk and remained as a stable suspension for at least 4 months at 4 degrees C. The final concentration of PQ10 determined both the size of the casein-polymer aggregates and the amount of milkfat that coprecipitates. The presence of PQ10 in the aggregates did not inhibit the activity of rennet or gastrointestinal proteases and lipases, nor did it affect the growth of several fermentative bacteria. The cationic cellulose PQ10 may cause a reversible electrostatic precipitation of casein micelles without disrupting their internal structure. The reversibility of the interaction described opens the possibility of using this cationic polysaccharide to concentrate and resuspend casein micelles from whole or skim milk in the production of new fiber-enriched lactose-reduced calcium-caseinate dairy products.     

Effect of pH on the association of denatured whey proteins with casein micelles in heated reconstituted skim milk

Skim milk was adjusted to pH values between 6.5 and 6.7 and heated (80, 90, and 100 degrees C) for up to 60 min. Changes in casein micelle size, level of whey protein denaturation, and level of whey protein association with the micelles were monitored for each milk sample. Changes in casein micelle size were markedly affected by the pH at heating. At low pH (6.5-6.55), the casein micelle size increased markedly during the early stages of heating, and the size plateaued on prolonged heating. The maximum increase in size was approximately 30-35 nm. In contrast, at high pH (6.7), much smaller changes in size were observed on heating and the maximum increase in size was only approximately 10 nm. An intermediate behavior was observed at pH values between these two extremes. The rate of denaturation of the major whey proteins, alpha-lactalbumin and beta-lactoglobulin, was essentially unaffected by the pH at heating for the small pH changes involved in this study, and the changes in casein micelle size were poorly related to the level of whey protein denaturation. In contrast, the level of denatured whey proteins associating with the micelles was markedly dependent on the pH at heating, with high levels of association at pH 6.5-6.55 and low levels of association at pH 6.7. Changes in casein micelle size were related to the levels of denatured whey proteins that were associated with the casein micelles, although there was a small deviation from linearity at low levels of association (<15%). Further studies on reconstituted and fresh milk samples at smaller pH steps confirmed that the association of whey proteins with the casein micelles was markedly affected by the pH at heating. These results indicate that the changes in casein micelle size induced by the heat treatment of skim milk were a consequence of the whey proteins associating with the casein micelles and that the level of association was markedly influenced by small pH changes of the milk. It was not possible to determine whether the association itself influenced the casein micelle size or whether parallel reactions involving micellar aggregation caused the increase in micelle size as whey protein association progressed.     

Effect of milk concentration on the irreversible thermal denaturation and disulfide aggregation of beta-lactoglobulin

The kinetics of beta-lactoglobulin (beta-LG) denaturation in reconstituted skim milk samples of various concentrations (9.6-38.4% total solids) over a wide temperature range (75-100 degrees C) was studied. The thermal denaturation of beta-LG had a reaction order of 1.5 at all milk solids concentrations and at all temperatures. The rate of denaturation of beta-LG was markedly dependent on the milk solids concentration and the heating temperature. At 75 degrees C, the thermal denaturation of beta-LG was retarded at higher milk solids concentrations. However, this retardation was less pronounced at higher temperatures so that a similar rate of denaturation was observed at all milk solids concentrations at 100 degrees C. From an examination of the level of disulfide-aggregated beta-LG, it was evident that most, but not all, of the denatured beta-LG was involved in disulfide-aggregated complexes, either with other denatured whey proteins or with the casein micelles. As with beta-LG denaturation, the rate of disulfide aggregation of beta-LG was markedly dependent on the milk solids concentration.     

Disruption and reassociation of casein micelles under high pressure: influence of milk serum composition and casein micelle concentration

In this study, factors influencing the disruption and aggregation of casein micelles during high-pressure (HP) treatment at 250 MPa for 40 min were studied in situ in serum protein-free casein micelle suspensions. In control milk, light transmission increased with treatment time for approximately 15 min, after which a progressive partial reversal of the HP-induced increase in light transmission occurred, indicating initial HP-induced disruption of casein micelles, followed by reformation of casein aggregates from micellar fragments. The extent of HP-induced micellar disruption was negatively correlated with the concentration of casein micelles, milk pH, and levels of added ethanol, calcium chloride, or sodium chloride and positively correlated with the level of added sodium phosphate. The reformation of casein aggregates during prolonged HP treatment did not occur when HP-induced disruption of casein micelles was limited (<60%) or very extensive (>95%) and was promoted by a low initial milk pH or added sodium phosphate, sodium chloride, or ethanol. On the basis of these findings, a mechanism for HP-induced disruption of casein micelles and subsequent aggregation of micellar fragments is proposed, in which the main element appears to be HP-induced solubilization of micellar calcium phosphate.     

Effects of added sodium caseinate on the formation of particles in heated milk

The effects of heat at temperatures in the range of 80-90 degrees C on mixtures of reconstituted skim milk powder (RSMP) and sodium caseinate have been determined. In the absence of caseinate, the action of heat on RSMP produces soluble complexes of whey proteins and kappa-casein, as well as complexes of whey protein with the casein micelles. When sodium caseinate was added to RSMP at levels of 0.5 and 1.0%, the denaturation of the whey protein and the production of the soluble complexes in the serum were hardly affected, either in rate or in amount. However, during the heating, the caseinate disappeared from the serum. Further studies on model mixtures of the different components showed that it was probable that the bulk of the caseinate associated with the casein micelles during heating, probably by binding inside the surface layer of kappa-casein, because no increase in the diameters of the casein micelles could be observed.     

Ethanol-dependent heat-induced dissociation of casein micelles

The dissociation of casein micelles when heated to approximately 65 degrees C in the presence of ethanol [1:1 mixture (v/v) of milk and 65% (w/w) aqueous ethanol] was investigated using L* values and transmission measurements. Mixtures of milk and ethanol became transparent on heating, which suggests dissociation of casein micelles. Results of experiments using confocal laser scanning microscopy, light scattering (static and dynamic), and dialysis to examine the changes of milk during heating in the presence of ethanol supported the assertion that such treatments result in dissociation of casein micelles, as did studies of model beta-casein micellar systems.     

Lactoperoxidase-induced protein oxidation in milk

The reaction between lactoperoxidase (LPO) and H(2)O(2) in the presence of bovine serum albumin (BSA), beta-lactoglobulin, or casein was investigated for the formation of protein radicals by freeze-quench electron spin resonance (ESR) and by the formation of the protein oxidation product, dityrosine. The presence of BSA resulted in a dramatic change after 1 min of reaction in the obtained ESR spectrum compared with the spectrum obtained for LPO and H(2)O(2) alone. Furthermore, experiments employing BSA or beta-lactoglobulin resulted in the formation of long-lived protein radicals detectable 10 min after initiation of the reaction. The presence of casein resulted in a minor change in the fine structure of the ESR spectrum after 1 min of reaction compared with LPO and H(2)O(2) alone, but no difference between the two reaction mixtures could be observed after 10 min of reaction. The formation of dityrosine could be detected in reaction mixtures containing LPO and H(2)O(2) after 1 and 10 min of incubation at 25 degrees C both in the absence and in the presence of BSA, beta-lactoglobulin, or casein. The presence of casein resulted in an increased dityrosine concentration compared with the reaction with LPO and H(2)O(2) alone. Endogenous LPO in unpasteurized milk was activated at 25 degrees C by adding 1 mM H(2)O(2). Radical species could be detected directly in the milk by freeze-quench ESR during the initial phase of the reaction, and dityrosine could be measured after 4 h of incubation. The role of LPO activity in the formation of ESR detectable radical species and dityrosine in milk was further verified in ultrahigh temperature (UHT) milk with no endogenous enzyme activity, as the formation of ESR detectable radical species and dityrosine took place in UHT milk only upon the addition of both H(2)O(2) and exogenous LPO.     

Transmission electron microscopy of mozzarella cheeses made from microfluidized milk.

The nanostructure of Mozzarella cheeses prepared from microfluidized milk was compared with that of control cheeses made from untreated milk. Milk heated to 10 or 54 degrees C and containing 1.0 or 3.2% fat was homogenized by microfluidization at 34 or 172 MPa prior to cheesemaking. The effects on the casein particles and fat globules in the cheese were determined by transmission electron microscopy after 1 day and 6 weeks of storage at 4 degrees C. The micrographs showed that electron-dense regions theorized to be casein submicelles rearranged from a homogeneous configuration to a pattern of clusters during the storage period. The nanostructure of the cheeses made from milk processed under the mildest conditions resembled the controls, but otherwise the fat droplets decreased in size and increased in number as the pressure and temperature were increased. The results indicate that both homogenization temperature and pressure affect the nanostructure of Mozzarella cheese.     

Role of the soluble and micelle-bound heat-induced protein aggregates on network formation in acid skim milk gels

Gel formation was monitored by low amplitude rheometry during acidification at 40 degrees C with 1.5% glucono-delta-lactone in combined milk systems containing soluble and/or micelle-bound heat-induced (95 degrees C/10 min) aggregates of denatured whey proteins and kappa-casein and in heated dairy mixes with varying micellar casein/whey protein ratio (CN/WP). Both soluble and micelle-bound aggregates increased gelation pH and gel strength. Micelle-bound aggregates seemed to modify the micelle surface so that micelles were destabilized at a pH of 5.1 (instead of 4.7), while soluble aggregates precipitated at their calculated pI of approximately 5.3, and initiated an early gelation by interacting with the micelles. Decreasing the CN/WP ratio produced larger aggregates with higher whey protein: kappa-casein ratio, which gave more elastic gels. The specific effects of the micellar and soluble aggregates on gel strength are discussed with respect to their relative proportions in the heated milk.     

Homogenization conditions affect the oxidative stability of fish oil enriched milk emulsions: oxidation linked to changes in protein composition at the oil-water interface

Fish oil was incorporated into milk under different homogenization temperatures (50 and 72 degrees C) and pressures (5, 15, and 22.5 MPa). Subsequently, the oxidative stability of the milk and changes in the protein composition of the milk fat globule membrane (MFGM) were examined. Results showed that high pressure and high temperature (72 degrees C and 22.5 MPa) resulted in less lipid oxidation, whereas low pressure and low temperature (50 degrees C and 5 MPa) resulted in faster lipid oxidation. Analysis of protein oxidation indicated that especially casein was prone to oxidation. The level of free thiol groups was increased by high temperature (72 degrees C) and with increasing pressure. Furthermore, SDS-PAGE and confocal laser scanning microscopy (CLSM) indicated that high temperature resulted in an increase in beta-lactoglobulin adsorbed at the oil-water interface. This was even more pronounced with higher pressure. Less casein seemed to be present at the oil-water interface with increasing pressure. Overall, the results indicated that a combination of more beta-lactoglobulin and less casein at the oil-water interface gave the most stable emulsions with respect to lipid oxidation.     

Rheological properties of acid gels prepared from heated pH-adjusted skim milk

Reconstituted skim milk was adjusted to pH values between 6.5 and 7.1 and heated (90 degrees C) for up to 30 min. The skim milk samples were then readjusted to pH 6.7. Acid gels prepared from heated milk had markedly higher G ' values, a reduced gelation time, and an increased gelation pH than those prepared from unheated milk. An increased pH at heating decreased the gelation time, increased the gelation pH, and increased the final G ' of acid set gels prepared from the heated milk samples. There were only small differences in the level of whey protein denaturation in the samples at different pH values, and these differences could not account for the differences in the G ' of the acid gels. The levels of denatured whey protein associated with the casein micelles decreased and the levels of soluble denatured whey proteins increased as the pH at heating was increased. The results indicated that the soluble denatured whey proteins had a greater effect on the final G ' of the acid gels than the denatured whey proteins associated with the casein micelles.     

Mechanism of pressure-induced gelation of milk.

The pressure-induced gelation of concentrated skimmed milk and milk-sugar mixtures was studied to discover the main components responsible for gelation. The major protein component responsible for gelation is micellar casein. Gelation occurs at similar pressures to casein micelle disintegration in dilute milk, and both can be prevented by inclusion of excess calcium chloride. Transmission electron micrographs show that the protein network is formed from particles with diameters approximately an order of magnitude smaller than those of intact casein micelles. Gelation occurs on decompression and is found to be baroreversible. Concentrations of sugar up to 30% reduce the critical concentration of casein required for gelation, but higher sugar concentrations inhibit gelation. A mechanism of gelation based on the aggregation of casein submicelles formed by pressure-induced disintegration of casein micelles is proposed. Observations on the effect of sucrose on gelation are discussed in terms of the influence of sugars on the solvent quality in aqueous casein systems.     

Control of heat-induced aggregation of whey proteins using casein

The ability of alphas1/beta-casein and micellar casein to protect whey proteins from heat-induced aggregation/precipitation reactions and therefore control their functional behavior was examined. Complete suppression (>99%) of heat-induced aggregation of 0.5% (w/w) whey protein isolate (pH 6.0, 85 degrees C, 10 min) was achieved at a ratio of 1:0.1 (w/w) of whey protein isolate (WPI) to alphas1/beta-casein, giving an effective molar ratio of 1:0.15, at 50% whey protein denaturation. However, in the presence of 100 mM NaCl, heating of the WPI/alphas1/beta-casein dispersions to 85 degrees C for 10 min resulted in precipitation between pH 6 and 5.35. WPI heated with micellar casein in simulated milk ultrafiltrate was stable to precipitation at pH>5.4. Protein particle size and turbidity significantly (P相似文献