Time course and specificity of lipolysis in Swiss cheese

Controlling lipolysis in cheese is necessary to ensure the formation of desirable flavor. To get a better understanding of the mechanism of lipolysis in Swiss cheese, cheeses were manufactured with and without (control) the addition of Propionibacterium freudenreichii. Products of lipolysis were quantified throughout ripening. Half of the free fatty acids (FFA) released in milk (3.66 mg/g fat), in particular the short-chain FFA, were lost in the whey during curd drainage, whereas diglycerides and monoglycerides were retained within the curd. P. freudenreichii was responsible for the release of most FFA during ripening (10.84 and 0.39 mg/g fat in propionibacteria-containing and control cheeses, respectively). Indices of lipolysis displayed low specificity. All types of FFA were released, but butyric and palmitic acids more significantly, which could be due to a low sn-1,3 regioselectivity. All glycerides were hydrolyzed in the following order: monoglycerides>diglycerides>triglycerides. The results of this study show the quantitative and qualitative contributions of the different lipolytic agents to Swiss cheese lipolysis.     

The addition of Propionibacterium freudenreichii to Raclette cheese induces biochemical changes and enhances flavor development

Two mixtures of Propionibacterium freudenreichii commercial strains were tested as adjunct cultures in pasteurized milk Raclette cheese to investigate the ability of propionibacteria (PAB) to enhance flavor development. Cheese flavor was assessed by a trained sensory panel, and levels of free amino acids, free fatty acids, and volatile compounds were determined. The PAB level showed a 1.4 log increase within the ripening period (12 weeks at 11 degrees C). Eye formation, which was not desired, was not observed in PAB cheeses. PAB fermented lactate to acetate and propionate and produced fatty acids by lipolysis, branched chain volatile compounds derived from isoleucine and leucine catabolism and some esters. One of the experimental cheeses received the highest scores for odor and flavor intensity and was characterized by higher frequencies of detection for some minor notes ("propionic"and "whey" odor, "sweet" taste). PAB can therefore be considered as potential adjunct cultures to enhance or modify cheese flavor development.     

Straightforward process for removal of milk fat globule membranes and production of fat-free whey protein concentrate from cheese whey

A straightforward method for the separation of milk fat globule membrane (MFGM) and production of fat-free whey protein concentrate/isolate from cheese whey has been developed. Lowering of the conductivity of the whey from its initial value of about 5600 μS cm(-1) to about 2000-500 μS cm(-1) via diafiltration with water caused selective precipitation of MFGM when incubated for 30 min at pH 4.2 and 35 °C. The whey proteins remained soluble in the supernatant under these conditions. Experimental evidence suggested that precipitation of MFGM at pH 4.2 was not due to a nonspecific effect of lowering of the conductivity of the whey but due to the specific effect of removal of Ca2+ from the whey. The lipid content of whey protein isolate obtained by this process was <0.2%, and the protein loss was <14%. The method provides an industrially feasible process for the production of fat-free whey protein concentrate/isolate. The MFGM, which is reported to contain bioactive/nutraceutical lipids and proteins, is a valuable byproduct of the process.     

Differential characteristics of fatty acids in cheese from milk of various animal species by capillary gas chromatography

The kind of milk used in the manufacture of cheese has been identified by analysis of the fatty acids. The milk fat is extracted from the cheese and saponified. The methyl esters of the fatty acids are prepared and determined by capillary column gas chromatography. Seven major fatty acids are separated and quantitated, namely, C8:0, C10:0, C12:0, C14:0, C16:0, C18:0, and C18:1. Many of the 21 simple ratios that can be formed from these 7 quantities are characteristic of the type of milk from which the fatty acids were obtained. The method allows the identification of cheese prepared with the milk of cows, buffalo, sheep, or goats. Substitution or adulteration of milk can also be detected.     

Phospholipid, sphingolipid, and fatty acid compositions of the milk fat globule membrane are modified by diet

The phospholipid and sphingolipid composition of milk is of considerable interest regarding their nutritional and functional properties. The objective of this article was to determine the lipid composition of the milk fat globule membrane (MFGM) of milk from cows fed a diet rich in polyunsaturated fatty acids. The experiments were performed with 2 groups of 6 cows feeding on (i) maize silage ad libitum (+ grassland hay, mixture of cereals, soyabean meal) or (ii) the maize silage-based diet supplemented with extruded linseed (bringing a lipid proportion of 5% of dry matter). The phospholipid and sphingolipid composition of the MFGM was determined using HPLC/ELSD. The fatty acid (FA) composition of total lipids and phospholipids was determined using GC. As expected, the linseed-supplemented diet decreased the saturated FA and increased the unsaturated FA content in milk fat. MFGM in milk from cows fed the diet rich in polyunsaturated FA resulted in (i) a higher amount of phospholipids (+ 18%), which was related to a smaller size of milk fat globules (ii) an increase of 30% (w/w) of the concentration in sphingomyelin, (iii) a higher content in stearic acid (1.7-fold), unsaturated FA (1.36-fold), and C18:1 trans FA: 7.2 +/- 0.5% (3.7-fold). The MFGM contained a higher concentration of unsaturated FA (C18:1, C18:2, and C18:3) and very long-chain FA (C22:0, C23:0, C24:0, EPA, DHA) compared with total lipids extracted from milk. The technological, sensorial, and nutritional consequences of these changes in the lipid composition of the MFGM induced by dietary manipulation remain to be elucidated.     

Effects of ultra-high-pressure homogenization treatment on the lipolysis and lipid oxidation of milk during refrigerated storage

Free fatty acid (FFA) release and quantification and lipid oxidation extent of ultra-high-pressure homogenized (UHPH) milk samples were evaluated to assess the effect of UHPH on the susceptibility of milk lipids to lipolysis and oxidation. Milk was UHPH-treated at 200 and 300 MPa with inlet temperatures of 30 and 40 degrees C. UHPH-treated samples were compared to high-pasteurized milk (PA; 90 degrees C, 15 s). Results showed that all FFA increased significantly during storage only in 200 MPa samples. Lipid oxidation was measured as an accumulation of lipid hydroperoxides as the primary oxidation product and malondialdehyde and hexanal as the secondary oxidation products. Samples treated at 300 MPa presented higher malondialdehyde and hexanal content compared to 200 MPa treated-samples and to PA milk.     

Effect of processing and storage on the stability of flaxseed lignan added to dairy products

This study investigated the effects of processing and storage on the stability of purified, flaxseed-derived secoisolariciresinol diglucoside (SDG) added to milk prior to the manufacture of different dairy products. We analyzed the effect of high-temperature pasteurization, fermentation, and milk renneting as well as storage on the stability of SDG added to milk, yogurt, and cheese. Also, the stability of SDG in whey-based drinks was studied. Added SDG was found to withstand the studied processes well. In edam cheese manufacture, most of the added SDG was retained in the whey fraction and 6% was found in the cheese curd. SDG was also relatively stable in edam cheese during ripening of 6 weeks at 9 degrees C and in yogurt during storage of 21 days at 4 degrees C. Up to 25% of added SDG was lost in whey-based drinks during storage of 6 months at 8 degrees C. We conclude that SDG can be successfully supplemented in dairy-based products.     

Multiscale characterization of the organization of triglycerides and phospholipids in emmental cheese: from the microscopic to the molecular level

The chemical composition and properties of lipids, both triglycerides and phospholipids, play a major role in the functional and nutritional properties of food products. In this study, the suprastructure of fat, solid fat content, and crystallographic properties of triglycerides were investigated in hard-type cheeses from the microscopic scale to the molecular level using the combination of relevant techniques. Two industrial cheeses with different oiling off properties were compared with experimental cheeses manufactured in the laboratory. Microstructural analysis performed using confocal laser scanning microscopy showed that milk processing led to the disruption of fat globules with the formation of nonglobular fat. For a similar fatty acid composition, oiling off was mainly related to the fat in dry matter content and to the suprastructure of fat in cheese. An exogenous fluorescent phospholipid permitted the localization of milk phospholipids in the cheese matrix, which mainly remain around fat inclusions after disruption of the milk fat globule membrane, and to show heterogeneities. We also showed using differential scanning calorimetry that the suprastructure of fat did not affect the solid fat content in cheese at 4 degrees C: 71.6 +/- 4.9%. The organization of triglyceride molecules in fat crystals, elucidated at a molecular level using X-ray diffraction, corresponded to the coexistence of 2 lamellar structures (2L 40.5 angstroms and 3L 54.6 angstroms) with four polymorphic forms: alpha, two beta' and beta. A schematic representation of the multiscale organization of triglycerides and phospholipids in cheese is proposed.     

Starter bacteria are the prime agents of lipolysis in cheddar cheese

To assess the contribution of starter lactic acid bacteria (LAB) to lipolysis in Cheddar cheese, the evolution of free fatty acids (FFAs) was monitored in Cheddar cheeses manufactured from pasteurized milks with or without starter. Starter-free cheeses were acidified by a combination of lactic acid and glucono-delta-lactone. Starter cultures were found to actively produce FFAs in the cheese vat, and mean levels of FFAs were significantly higher in starter cheeses over ripening. The contribution of nonstarter LAB toward lipolysis appears minimal, especially in starter-acidified cheeses. It is postulated that the moderate increases in FFAs in Cheddar cheese are primarily due to lack of access of esterase of LAB to suitable lipid substrate. The results of this study indicate that starter esterases are the primary contributors to lipolysis in Cheddar cheese made from good quality pasteurized milk.     

Human milk fat globules from different stages of lactation: a lipid composition analysis and microstructure characterization

The physicochemical properties of human milk fat globules (MFG) at different lactation stages from Danish mothers and the microstructure changes of MFG membrane (MFGM) at varied temperatures were investigated, and the relationship between chemical composition and the microstructure of MFGM was elucidated. The fat content in MFG was found to be significantly increased as lactation progressed, and colostrum MFG had the largest mean diameter of 5.75 ± 0.81 μm and the lowest ζ potential of -5.60 ± 0.12 mV. Chemical composition analyses of MFG revealed the following: (i) Colostrum milk fat constituted higher content in PUFAs (ω-6, and long-chain ω-6 and ω-3) than transitional and mature milk fats, with the corresponding lower content of SFA in its sn-2 position. (ii) The content of polar lipids among total lipids varied during lactation course (maximized at transitional stage); however, in terms of subclasses of polar lipids, no significant change of the relative content of sphingomyelin was observed, while the content of phosphatidycholine in mature milk was higher than that in colostrum and transitional milk. (iii) Inspection of fatty acid composition in phospholipids from different lactation milk revealed no remarkable and regular changes could be generalized; and no obvious difference of the morphologies of MFGM at different lactation stages can be visualized. An investigation of the microstructure change of MFGM vs temperature demonstrated that the segregated domains became larger as temperature decreased to 4 °C, while it became smaller when increased to 37 °C. This phenomenon indicated that, in addition to sphingimyelin and cholesterol, phospholipids might also contribute to increasing the segregated domains at lower temperature, while, at elevated temperature, these domains could be diminished, most likely due to a restructuring or distributing of sphingimyelin and cholesterol.     

Quantitative determination of short-chain free fatty acids in milk using solid-phase microextraction and gas chromatography

The objective was to establish a rapid, precise, and accurate methodology for the quantification of short-chain free fatty acids (FFA) (C(4)-C(12)) in milk by solid-phase microextraction and gas chromatography. Sampling conditions such as fiber type, pH, salt addition, temperature, volume, and time were investigated. FFA extraction consisted of placing 40 mL of milk containing 28% NaCl at pH 1.5 in a sealed vial and equilibrating for 30 min at 70 degrees C. A polyacrylate fiber was exposed to the sample headspace for 60 min and desorbed for 5 min into the gas chromatograph. Calibration curves for FFA followed linear relationships with highly significant (p < 0.001) correlation coefficients (R(2) = 0.99). Coefficients of variation of less than 7.7% for FFA concentrations indicated that the technique was reproducible. The limits of quantification for C(4)-C(10) were in the low parts per million level, which were below the concentration range found in fresh pasteurized milk (0.48-2.52 ppm) or rancid milk (4.73-32.31 ppm).     

Transmission electron microscopy of mozzarella cheeses made from microfluidized milk.

The nanostructure of Mozzarella cheeses prepared from microfluidized milk was compared with that of control cheeses made from untreated milk. Milk heated to 10 or 54 degrees C and containing 1.0 or 3.2% fat was homogenized by microfluidization at 34 or 172 MPa prior to cheesemaking. The effects on the casein particles and fat globules in the cheese were determined by transmission electron microscopy after 1 day and 6 weeks of storage at 4 degrees C. The micrographs showed that electron-dense regions theorized to be casein submicelles rearranged from a homogeneous configuration to a pattern of clusters during the storage period. The nanostructure of the cheeses made from milk processed under the mildest conditions resembled the controls, but otherwise the fat droplets decreased in size and increased in number as the pressure and temperature were increased. The results indicate that both homogenization temperature and pressure affect the nanostructure of Mozzarella cheese.     

Protein and lipid oxidation during frozen storage of rainbow trout (Oncorhynchus mykiss)

This study aimed at investigating protein and lipid oxidation during frozen storage of rainbow trout. Rainbow trout fillets were stored for 13 months at -20, -30, or -80 degrees C, and samples were analyzed at regular intervals for lipid and protein oxidation markers. Lipid oxidation was followed by measuring lipid hydroperoxides (PV), as well as secondary oxidation products (volatiles) using dynamic headspace GC-MS. Free fatty acids (FFA) were measured as an estimation of lipolysis. Protein oxidation was followed using the spectrophotometric determination of protein carbonyls and immunoblotting. Significant oxidation was observed in samples stored at -20 degrees C, and at this temperature lipid and protein oxidation seemed to develop simultaneously. FFA, PV, and carbonyls increased significantly for the fish stored at -20 degrees C, whereas the fish stored at -30 and -80 degrees C did not show any increase in oxidation during the entire storage period when these methods were used. In contrast, the more sensitive GC-MS method used for measurement of the volatiles showed that the fish stored at -30 degrees C oxidized more quickly than those stored at -80 degrees C. Detection of protein oxidation using immunoblotting revealed that high molecular weight proteins were oxidized already at t = 0 and that no new protein oxidized during storage irrespective of the storage time and temperature. The results emphasize the need for the development of more sensitive and reliable methods to study protein oxidation in order to gain more explicit knowledge about the significance of protein oxidation for food quality and, especially, to correlate protein oxidation with physical and functional properties of foods.     

Study of light-induced volatile compounds in goat's milk cheese

Light-induced volatile compounds in goat cheese were studied by a combination of solid phase microextraction (SPME)-gas chromatography (GC)-mass spectrometry (MS), headspace oxygen depletion, and sensory evaluation. Samples stored under fluorescent light for 2 days at 30 degrees C had 90% more volatile compounds and 4 times more headspace oxygen depletion than samples stored in the dark at 30 degrees C. The volatiles 1-heptanol, heptanal, nonanal, and 2-decenal were formed and increased only in the light-stored samples, which may be formed from singlet oxygen oxidation of unsaturated fatty acids. Sensory evaluation showed that samples stored under light had significantly more off-flavor than samples stored in the dark at 30 degrees C (P < 0.05), and 1-heptanol, heptanal, nonanal, and 2-decenal increased the goat cheese off-flavor significantly (P < 0.05).     

Lipase-catalyzed incorporation of different Fatty acids into tripalmitin-enriched triacylglycerols: effect of reaction parameters

Tripalmitin-enriched triacylglycerols were concentrated from palm stearin by acetone fractionation and as the substrate reacted with a mixture of equimolar quantities of fatty acids (C8:0-C18:3). The incorporation degree and acyl migration level of the fatty acids and acylglycerols composition were investigated, providing helpful information for the production of human milk fat substitutes. Higher incorporation degrees of the fatty acids were obtained with lipase PS IM, Lipozyme TL IM, and Lipozyme RM IM followed by porcine pancreatic lipase and Novozym 435-catalyzed acidolysis. During reactions catalyzed by Lipozyme TL IM, Lipozyme RM IM, and lipase PS IM, incorporation degrees of C12:0, C14:0, C18:1, and C18:2 were higher than those of other fatty acids at operated variables (molar ratio, temperature, and time), and the triacylglycerols content reached the highest (82.09%) via Lipozyme RM IM-catalyzed acidolysis. On the basis of significantly different levels of acyl migration to the sn-2 position, lipases were in the order of lipase PS IM < Lipozyme TL IM < Lipozyme RM IM.     

Homogenization conditions affect the oxidative stability of fish oil enriched milk emulsions: oxidation linked to changes in protein composition at the oil-water interface

Fish oil was incorporated into milk under different homogenization temperatures (50 and 72 degrees C) and pressures (5, 15, and 22.5 MPa). Subsequently, the oxidative stability of the milk and changes in the protein composition of the milk fat globule membrane (MFGM) were examined. Results showed that high pressure and high temperature (72 degrees C and 22.5 MPa) resulted in less lipid oxidation, whereas low pressure and low temperature (50 degrees C and 5 MPa) resulted in faster lipid oxidation. Analysis of protein oxidation indicated that especially casein was prone to oxidation. The level of free thiol groups was increased by high temperature (72 degrees C) and with increasing pressure. Furthermore, SDS-PAGE and confocal laser scanning microscopy (CLSM) indicated that high temperature resulted in an increase in beta-lactoglobulin adsorbed at the oil-water interface. This was even more pronounced with higher pressure. Less casein seemed to be present at the oil-water interface with increasing pressure. Overall, the results indicated that a combination of more beta-lactoglobulin and less casein at the oil-water interface gave the most stable emulsions with respect to lipid oxidation.     

Analysis of free fatty acids in whey products by solid-phase microextraction

To evaluate the impact of Cheddar cheese starter cultures on the level of free fatty acids in liquid whey, a solid-phase microextraction (SPME) technique was utilized. The determination of response factors relative to an internal standard and the verification of linearity over a wide concentration range allowed for the quantitation of free fatty acids in experimentally produced liquid whey and in a wide range of dry whey ingredients. Results indicated that whey produced with a Lactococcus lactis subsp. lactis starter culture contained the highest level of total free fatty acids with significantly higher levels of lauric, myristic, and palmitic acids. Significant declines in oleic, linoleic, and palmitic acid occurred during storage. Commercial whey ingredients demonstrated a linear increase in free fatty acids with increasing percent protein, except for whey protein isolate, which had the lowest concentration. The use of SPME for the rapid analysis of free fatty acids in whey products should allow for further research to determine the importance of these compounds on the quality and stability of whey products.     

Milk excretion of ivermectin and moxidectin in dairy sheep: assessment of drug residues during cheese elaboration and ripening period

Ivermectin (IVM) and moxidectin (MXD) are broad-spectrum endectocide antiparasitic drugs extensively used in food-producing animals. The patterns of IVM and MXD excretion in milk were comparatively characterized following their subcutaneous administration (200 microg.kg(-1) of body weight) to lactating dairy sheep. The relationship between milk excretion and plasma disposition kinetics of both compounds was characterized. A pool of milk collected from all of the animals in each experimental group was used for cheese elaboration. IVM and MXD residual concentrations were assessed during the cheese-making process and ripening period. IVM and MXD concentrations were measured in plasma, milk, and milk product (whey, curd, and cheese) samples using an HPLC-based methodology with fluorescence detection. IVM and MXD were extensively distributed from the bloodstream to the mammary gland, and large quantities, particularly of MXD, were excreted in milk. Residual concentrations of both compounds were recovered in milk up to 30 (IVM) and 35 (MXD) days post-treatment. The total fraction of the administered dose excreted in milk for MXD was significantly higher than that of IVM. During cheese production, the highest residual concentrations of both molecules were measured in the curd. Thirty-four percent of the total drug residue measured in the pooled milk collected from treated sheep was lost during the cheese-making process. The lowest residual concentrations were measured in the whey. IVM and MXD concentrations in the elaborated cheese tended to increase during the ripening period, reaching the highest residual level at 40 days of cheese maturation. The long persistence of milk residual concentrations of MXD and IVM in lactating dairy sheep and the high concentrations found in cheese and other milk-related products should be seriously considered before recommendation of the extralabel use of these antiparasitic drugs in dairy animals.     

Heat-induced aggregation of whey proteins: comparison of cheese WPC with acid WPC and relevance of mineral composition

Heat-induced aggregation of whey proteins in solutions made from two commercial whey protein concentrates (WPCs), one derived from mineral acid whey (acid WPC) and the other from cheese whey (cheese WPC), was studied using polyacrylamide gel electrophoresis (PAGE), size exclusion chromatography (SEC), and transmission electron microscopy (TEM). Heat treatment (75 degrees C) of acid WPC solutions (12.0%, w/w, pH 6.9) resulted in formation of relatively small "soluble" aggregates that were predominantly disulfide-linked. By contrast, heat treatment of the cheese WPC solutions (under the same conditions) caused formation of relatively large aggregates, containing high proportions of aggregates linked by noncovalent associations. The rate of aggregation of both beta-lactoglobulin and alpha-lactalbumin at 75 degrees C, measured as the loss of native proteins by PAGE, was higher in the cheese WPC solution than in the acid WPC solution. Cross dialysis of the two WPC solutions resulted in alteration of the mineral composition of each WPC solution and reversing their heat-induced aggregation behavior. The results demonstrated that the mineral composition is very important in controlling the aggregation behavior of WPC products.     

Mozzarella干酪加工过程中主要理化指标变化及其产率计算

该文目的在于为干酪功能特性、含水率和产率的控制提供理论依据,使用标准化原料乳经低温巴氏杀菌,采用无盐渍新工艺生产Mozzarella干酪,从添加发酵剂开始,到制成新鲜干酪,测定各阶段干酪凝块的温度、水分含量、pH值和滴定酸度及各阶段乳清和凝块的蛋白和脂肪含量,计算Mozzarella干酪的效能和产率。试验结果表明：在排乳清和粉碎加盐阶段,干酪凝块中的水分含量变化幅度最大,排出乳清中的蛋白和脂肪数量明显增加;干酪的脂肪回收率达到92.22%,实际测得的乳清中脂肪的损失率为7.62%;乳蛋白的回收率达到83.60%,仅有16.72%的蛋白质损失于乳清中;在堆酿阶段pH值有一个从6.3(干酪凝块5.5)至5.25的快速下降过程。Mozzarella干酪的实际产率达到12.38%,达到了同类型干酪的产率要求。Mozzarella干酪的理化指标达到了美国全脂Mozzarella干酪的标准。