Isolation of tetra-acyl sucrose esters from turkish tobacco using supercritical fluid CO2 and comparison with conventional solvent extraction

Pure supercritical CO2 at various pressures and temperatures was used to effect the fractionation of tetra-acyl sucrose esters (SE) from dried, ground Turkish tobacco without any further pretreatment of the matrix. It was determined that SE cannot be extracted using low density CO2 (150 atm, 60 degrees C, and 0.62 gm/mL or 200 atm, 100 degrees C, and 0.49 gm/mL), whereas other analytes, which strongly interfere with the conventional solvent extraction of SE, can be easily removed under the same conditions. At the higher temperature (100 degrees C), these same analytes that interfere with the conventional solvent extraction of SE are even more readily removed, while the very poor extractability of SE is not affected. It was demonstrated, however, that SE can be removed from the pre-extracted tobacco with supercritical CO2 if the density is greater than (or equal to) 0.73 gm/mL. The supercritical fluid extraction method has been compared with other previous extraction methods that employ conventional solvents. This study provides one of the clearest examples of how the variable density property of a supercritical fluid can be utilized to effect the fractionation of a complex mixture.     

SFE-plus-C(18) lipid cleanup and selective extraction method for GC/MS quantitation of polycyclic aromatic hydrocarbons in smoked meat

In biological matrixes lipid material often poses an interference problem for determinations of nonpolar compounds, e.g., polycyclic aromatic hydrocarbons (PAHs). A newly developed supercritical fluid extraction plus adsorbent method, "SFE-plus-C(18)", offers selective extraction of PAHs in lipid-rich biological matrixes without the need for supplementary cleanup. This method eliminates the use of large volumes of toxic solvent and lengthy lipid removal procedures. This study reports the first application of the SFE-plus-C(18) method to the analysis of a genuine food product, i.e., smoked meat (beef). The procedure employs the addition of C(18) adsorbent beads to the initial sample slurry of pureed smoked meat prior to supercritical CO(2) extraction and GC/MS quantitation. During SF extraction, indigenous lipids are preferentially retained on the beads, and PAHs are selectively extracted with supercritical CO(2). In a comparison of determinations of PAHs by SFE-plus-C(18) vs the conventional SFE method, only 11-17% of the indigenous lipids observed by the conventional SFE method were co-extracted using the SFE-plus-C(18) method. The PAHs in smoked meat could thus be determined efficiently in the presence of a reduced background of co-extracted lipids. Out of 10 targeted PAHs, seven were detected with a range of 10.0-26.0 ng/g in the smoked meat sample. The other three PAHs were not present above the detection limit of the instrument (2.5-4.1 pg). The recoveries of PAHs obtained using the conventional SFE method were 63-94% lower than those achieved by SFE-plus-C(18).     

Phenolic and triterpenoid antioxidants from Origanum majorana L. herb and extracts obtained with different solvents

Antioxidant properties of marjoram (Origanum majorana L.) herb and extracts obtained with ethanol, n-hexane, and supercritical CO2 extraction are presented. Individual antioxidants, ursolic acid, carnosic acid, and carnosol, were quantified with high-performance liquid chromatography. The effects of different parameters (temperature and pressure) of high-pressure extraction on the yield of carnosol were studied. Furthermore, two marjoram herbs from Hungary and Egypt were compared measuring hydrogen-donating abilities with 1,1-diphenyl-2-picrylhydrazyl by spectrophotometric and the total scavenger capacities by chemiluminometric methods from the aqueous extracts of the herbs. The antioxidant activities of the solvent extracts were performed using the Rancimat method. The Egyptian herb and its extracts possessed better antioxidant activities than Hungarian ones. Applying supercritical CO2 extraction, the highest value of carnosol was obtained at 400 bar and 60 degrees C.     

Extraction of natural complex phenols and tannins from grape seeds by using supercritical mixtures of carbon dioxide and alcohol

Proanthocyanidins are supposed to have some therapeutical properties as antioxidants and antineoplasics. Most of the proanthocyanidins, however, are not commercialized since their separation from natural sources is either very expensive or not well-known. In this work, the feasibility of application of mixtures of carbon dioxide and alcohol under supercritical conditions for selective extraction of some phenolic compounds from grape seeds has been studied, among them some low polymerized proanthocyanidins, their main monomer units, (+)-catechin and (-)-epicatechin, and some low molecular weight phenolic compounds, like gallic acid. An analytical-scale supercritical fluid extractor, whose operation was previously optimized, was used to carry out the experiments. A commercial concentrate of complex phenols and tannins from grape seeds was subjected to supercritical extraction in order to find the best operation conditions before directly extracting defatted milled grape seeds. The solvent capacity was found to increase with pressure and with the amount of alcohol used as cosolvent as expected. Such variation in solvent capacity could be used for design of a selective separation process where individual phenolic compounds or groups of them could be obtained. HPLC coupled with two types of detectors, diode array and mass spectrometry, was used for tentative identification and quantification of complex phenols and tannins in the extracts and in the raw materials used for extraction.     

Isolation of antioxidant compounds from orange juice by using countercurrent supercritical fluid extraction (CC-SFE).

Antioxidants from orange juice are isolated by the use of countercurrent supercritical fluid extraction (CC-SFE) and characterized by reversed-phase liquid chromatography (RPLC) coupled to mass spectrometry (MS) and diode-array detection (DAD). A pilot-scale SFE plant equipped with a packed column has been employed for countercurrent extraction and fractionation of raw orange juice with carbon dioxide. Several experiments have been performed in order to study the effect of the countercurrent conditions on the content of antioxidative compounds. In this study, the main variable that has been considered is the solvent-to-feed ratio (S/F) because it plays an essential role in the extraction efficiency. The values tested covered a wide range of sample and solvent (CO(2)) flow rates. In each experimental run, two different extracted fractions and the residual nonextracted juice were obtained and characterized. Different flavonoids have been identified in the fractions obtained after CC-SFE. The possibility of using this process for antioxidant compounds enrichment is discussed.     

Extraction of natural vitamin E from wheat germ by supercritical carbon dioxide

An efficient supercritical fluid extraction (SFE) process with carbon dioxide (SFE-CO(2)) was developed for the extraction of natural vitamin E (V(E)) from wheat germ. Both the pretreatment of extracted wheat germ and extraction conditions were optimized to ensure maximal V(E) yield. The extraction was undertaken at the extracting pressure of 4000-5000 psi, the extracting temperature of 40-45 degrees C, and the carbon dioxide flow rate of 2.0 mL/min for 90 min. An optimized pretreatment of wheat germ was usually necessary with a particle size of 30 mesh and a moisture content of 5.1%. A yield comparison of V(E) and its isomers extracted by supercritical CO(2) with those by conventional solvent extraction suggested that this SFE process was a practical process prospectively superior to conventional solvent extraction to prepare V(E) from wheat germ.     

Fractional extraction of compounds from grape seeds by supercritical fluid extraction and analysis for antimicrobial and agrochemical activities

White grape seeds were subjected to sequential supercritical fluid extraction. By increasing the polarity of the supercritical fluid using methanol as a modifier of CO(2), it was possible to fractionate the extracted compounds. Two fractions were obtained; the first, which was obtained with pure CO(2), contained mainly fatty acids, aliphatic aldehydes, and sterols. The second fraction, obtained with methanol-modified CO(2), had phenolic compounds, mainly catechin, epicatechin, and gallic acid. The fractions were bioassayed. Antimicrobial activities were checked on human pathogens, and a high degree of activity was obtained with the lipophilic fraction. Agrochemical activities on phytopathogenic fungi and activities on the etiolated wheat coleoptile bioassay were also checked. The more polar fraction was active in the latter bioassay.     

Comparison of the chemical composition of extracts from Scutellaria lateriflora using accelerated solvent extraction and supercritical fluid extraction versus standard hot water or 70% ethanol extraction

The aqueous extract of American skullcap (Scutellaria lateriflora L. (S. lateriflora), Lamiaceae) has been traditionally used by North American Indians as a nerve tonic and for its sedative and diuretic properties. Recent reports stated that flavonoids and possibly amino acids are responsible for the anxiolytic activity. As a part of our search for environmentally friendly solvents to extract the active components from medicinal plants, we used S. lateriflora in a comparison of accelerated solvent extraction (ASE) using water, and supercritical fluid extraction (SFE) using CO2 and 10% EtOH as modifier, at different temperatures. Flavonoids and amino acids were quantified by HPLC-UV and HPLC-MS, respectively. The flavonoid content was compared with conventional extraction methods (hot water extraction and 70% ethanol). The use of ASE at 85 degrees C with water as solvent gave the best results for flavonoid glycosides and amino acids, whereas SFE gave higher yields of flavonoid aglycones. However, the results obtained for total flavonoids were not significatively superior to hot water extraction or 70% aqueous EtOH extract.     

Effects of supercritical carbon dioxide (SC-CO(2)) oil extraction on the cell wall composition of almond fruits.

Extraction of oil from almond fruits using supercritical carbon dioxide (SC-CO(2)) was carried out at 50 degrees C and 330 bar on three sets of almonds: raw almond seeds, raw almond kernels, and toasted almond seeds. Three different oil extraction percentages were applied on each set ranging from approximately 15 to 16%, from approximately 27 to 33%, and from approximately 49 to 64%. Although no major changes were detected in the fatty acid composition between fresh and partially defatted samples, carbohydrate analysis of partially defatted materials revealed important changes in cell wall polysaccharides from almond tissues. Thus, at low extraction percentages (up to approximately 33%), pectic polysaccharides and hemicellulosic xyloglucans were the main type of polymers affected, suggesting the modification of the cell wall matrix, although without breakage of the walls. Then, as supercritical fluid extraction (SCFE) continues and higher extraction rates are achieved (up to approximately 64%), a major disruption of the cell wall occurred as indicated by the losses of all major types of cell wall polysaccharides, including cellulose. These results suggest that, under the conditions used for oil extraction using SC-CO(2), fatty acid chains are able to exit the cells through nonbroken walls; the modification of the pectin-hemicellulose network might have increased the porosity of the wall. However, as high pressure is being applied, there is a progressive breakage of the cell walls allowing the free transfer of the fatty acid chains from inside the cells. These findings might contribute to providing the basis for the optimization of SCFE procedures based on plant food sources.     

超临界CO2流体萃取海滨锦葵籽油的工艺条件优化

为了提高海滨锦葵籽的利用价值,开发生物柴油新原料,该文以海滨锦葵籽为原料,利用超临界CO2流体萃取技术提取海滨锦葵籽油。通过单因素试验及正交试验研究了萃取压力、萃取温度、CO2流量和萃取时间等因素对油脂得率的影响,确定了超临界CO2流体萃取技术提取海滨锦葵籽油的最佳工艺条件。结果表明,在试验范围内各影响因素对海滨锦葵籽油得率作用的大小依次为：萃取压力＞萃取温度＞CO2流量＞萃取时间。超临界CO2流体萃取技术提取海滨锦葵籽油的最佳工艺参数为：萃取压力25 MPa,萃取温度45℃,CO2流量21 kg/h,萃取时间为100 min,在该工艺条件下萃取3次,海滨锦葵籽油得率达到19.35%。     

Extraction of purine alkaloids from maté (Ilex paraguariensis) using supercritical CO(2).

Experimental data for the supercritical CO(2) extraction of purine alkaloids (caffeine, theobromine, and theophylline) from ground herbal maté tea (Ilex paraguaryensis) using a high-pressure apparatus are presented. Caffeine, theophylline, and theobromine were identified in the extracted fractions using HPLC. Results indicated a much higher CO(2) selectivity for caffeine in comparison with those for theophylline and theobromine. Solubilities of pure compounds in carbon dioxide were also determined at 313.2, 323.2, 338.2, and 343.2 K, and pressures ranging from 14 to 24 MPa. Caffeine solubility exhibited a retrograde behavior with temperature while theophylline and theobromine manifested a normal behavior at conditions explored in this study. Solubilities in binary CO(2)/purine alkaloid model systems were much higher than those obtained during extraction of maté tea, demonstrating the difficulty of using binary data in predicting complex multicomponent behavior.     

Supercritical fluid extraction/enzyme assay: a novel technique to screen for pesticide residues in meat products.

The novel combination of supercritical fluid extraction (SFE) with an enzyme assay system has been used to screen meat products to detect the presence of pesticides. Analytes are collected in water by expanding supercritical carbon dioxide to atmospheric pressure through a restrictor and into an aqueous phase. The solution is then tested for the presence of pesticide residues by enzyme assay. Two experimental approaches have been used. Alachlor-fortified lard and bovine liver were monitored by static SFE coupled with an enzyme immunoassay. SFE of carbofuran-fortified frankfurters was coupled with an enzyme assay based on cholinesterase inhibition. A major benefit of the SFE/enzyme assay technique over conventional screening techniques is that the analyst is not exposed to organic solvents.     

Supercritical fluid extraction of organochlorine pesticides in eggs

The efficacy of supercritical fluid extraction (SFE) for the recovery of 16 common organochlorine pesticides (OCPs) from liquid whole eggs was investigated by employing supercritical carbon dioxide (SC-CO(2)) without the use of a solvent modifier to minimize interfering coextractives. The OCPs tested included aldrin; alpha-, beta-, delta-, and gamma-BHCs; p,p'-DDD, -DDE, and -DDT; dieldrin; endosulfans I, II, and sulfate; endrin; endrin aldehyde; heptachlor; and heptachlor epoxide. The SFE conditions were as follows: 10000 psi (680 bar), 40 degrees C, SC-CO(2) flow rate of 3.0 L/min with an extraction time of 40 min for a total of 120 L of CO(2). The OCPs were trapped off-line in an SPE cartridge containing Florisil and then eluted by an acetone/hexane mixture and analyzed by gas chromatography-electron capture detection (GC-ECD). Recovery studies were carried out on homogenized eggs fortified at the 0.05, 0.10, and 0.20 ppm levels. At the lowest level, 0.05 ppm, recoveries ranged from 81.8 to 108.3%, with CVs < 9.8%. All recoveries were significantly higher than those obtained by an AOAC/FDA solvent extraction method. Eggs containing incurred endosulfan I were also effectively extracted by SFE. This study suggests that the application of SFE for the extraction of OCPs from eggs will result in significant savings in analysis time and lower solvent use and disposal costs compared to conventional solvent extraction procedures.     

Antioxidant properties of various solvent extracts of total phenolic constituents from three different agroclimatic origins of drumstick tree (Moringa oleifera Lam.) leaves

Water, aqueous methanol, and aqueous ethanol extracts of freeze-dried leaves of Moringa oleifera Lam. from different agroclimatic regions were examined for radical scavenging capacities and antioxidant activities. All leaf extracts were capable of scavenging peroxyl and superoxyl radicals. Similar scavenging activities for different solvent extracts of each collection were found for the stable 1,1-diphenyl 2-picrylhydrazyl (DPPH(*)) radical. Among the three different moringa samples, both methanol and ethanol extracts of Indian origins showed the highest antioxidant activities, 65.1 and 66.8%, respectively, in the beta-carotene-linoleic acid system. Nonetheless, increasing concentration of all the extracts had significantly (P < 0.05) increased reducing power, which may in part be responsible for their antioxidant activity. The major bioactive compounds of phenolics were found to be flavonoid groups such as quercetin and kaempferol. On the basis of the results obtained, moringa leaves are found to be a potential source of natural antioxidants due to their marked antioxidant activity. This is the first report on the antioxidant properties of the extracts from freeze-dried moringa leaves. Overall, both methanol (80%) and ethanol (70%) were found to be the best solvents for the extraction of antioxidant compounds from moringa leaves.     

Supercritical fluid extraction of atrazine and other triazine herbicides from fortified and incurred eggs

Triazines are a class of important pre-emergent weed herbicides. Some members of this class of herbicides exhibit carcinogenic and immunotoxicity properties, which make their use controversial in areas where animal feed crops are grown. It is therefore important to determine if triazine residues are transported to animal food products in order to ascertain the extent of human exposure. Most of the current herbicide residue extraction methods are time-consuming and solvent intensive. Supercritical fluid extraction (SFE) using CO(2) has been used as a alternative for other residue extraction methods as a replacement for hazardous organic solvents. In this study, 10 triazines were extracted from eggs fortified at 100 ppb using unmodified supercritical CO(2) at a pressure of 10000 psi and a temperature of 50 degrees C with off-line collection on a solid phase extraction cartridge containing Florisil. Atrazine recovery averaged 90.4% with an RSD of 3.3%. The other triazines were recovered at mean levels >73%. In a separate feeding study, atrazine and two of its dealkyl metabolites were detected in the egg. The results indicate that SFE is a viable technique for isolating triazine residues from eggs, requiring only 8 mL of solvent for each analysis.     

Ein neues Verfahren zur Extraktion von organischen Stoffen aus Böden mit überkritischen Gasen

A new procedure for the extraction of organic matter from soils by supercritical gases Organic solvents beyond critical temperature and pressure have excellent properties for solving polymere organic substances. For soil samples yields of organic material with low ash content are much higher than those obtained by the common NaOH/HCl-extraction. Fractionation of the samples is easily achieved by a simple change of solvent bottles. In comparison to the original material oxygen contents are lower, due to a thermal or solvolytical split off of methanol or water. Extraction with supercritical gases – in addition to oxidative degradation –may be regarded as a useful method to enlighten the structure of humic acids. The effective extraction of firmly bound pesticides in soil is another point of interest.     

Ein neues Verfahren zur Extraktion von organischen Stoffen aus Böden mit überkritischen Gasen 2. Mitteilung

A new procedure for the extraction of organic matter from soils by supercritical gases Extracting soil samples with supercritical gases high amounts of nearly ash-free organic preparations can be obtained. A direct fractionation in classes of compounds with different chemical constitution is achieved by using solvents of variable polarity. Fats and dicarboxylic acids can be solved in pentan, phenols and hemicelluloses in ethanol, lignin and cellulose in ethanol/water. The substances obtained from the pentan extract were identified by GC/MS analysis. The non volatile compounds of the ethanol/water extract were decomposed by permanganate and the products compared with those of the oxidized humic acids. Though there is a high number of different compounds the podzol profile investigated shows typical patterns of distribution for certain components.     

Supercritical fluid extraction of limonoid glucosides from grapefruit molasses

Limonoid glucosides (primarily limonin 17-beta-D-glucopyranoside, LG) were extracted from grapefruit molasses by supercritical fluid extraction using a supercritical carbon dioxide-ethanol (SC CO(2)-ethanol) system. Extraction conditions to maximize the yield of LG were determined by varying pressure, temperature, ethanol concentration, and extraction time. The highest yield of LG at 0.61 mg/g molasses was obtained at a pressure 48.3 MPa, a temperature of 50 degrees C, 10% ethanol (X(Eth) = 0.1), and 40 min of extraction time at a flow rate of 5.0 L/min. The results demonstrated that SC CO(2) extraction of limonoid glucosides from grapefruit molasses has practical significance for commercial production.     

Pressurized fluids for extraction of cedarwood oil from Juniperus virginianna

The extraction of cedarwood oil (CWO) using liquid carbon dioxide (LC-CO(2)) was investigated and compared to supercritical fluid extraction, including the effects of extraction pressure and length of extraction. The chemical composition of the extracts was monitored over the course of the extraction as well. The cumulative yields of CWO from cedarwood chips using 80 L of carbon dioxide varied very little treatment to treatment, with all temperature/pressure combinations yielding between 3.55 and 3.88% CWO, and the cumulative yields were statistically equivalent. The rate of extraction was highest under the supercritical extraction conditions (i.e., 100 degrees C and 6000 psi). Under the liquid CO(2) conditions (i.e., 25 degrees C), the extraction rates did not vary significantly with extraction pressure. However, there were differences in the chemical composition of the collected CWO. Extractions at 100 degrees C gave a much lower ratio of cedrol/cedrene than extractions at 25 degrees C. The highest ratio of cedrol/cedrene was obtained using 25 degrees C and 1500 psi. The use of subcritical water was also investigated for the extraction of CWO as well. Although some CWO was extracted using this method, the temperature/pressure combinations that gave the highest weight percentage yields also gave oils with an off odor while those combinations that gave a higher quality oil had very low yields. It appears that the high temperatures and acidic conditions cause a dehydration of the tertiary alcohol, cedrol, to its hydrocarbon analogue, cedrene, during CO(2) or pressurized water extractions of cedarwood.     

Organic and conventional kiwifruit, myths versus reality: antioxidant, antiproliferative, and health effects

Comparison between organic and conventional kiwifruit cultivars 'Hayward' and 'Bidan', which was done by four radical scavenging assays, ESI-MS, and DSC measurements, showed significant differences between the cultivars. Such results were not estimated in kiwifruit growing under organic and conventional conditions. The extraction of bioactive compounds was done by two different methods: sequential extraction with ethyl acetate followed by methanol and maceration with methanol and ethyl acetate. The highest yield of polyphenols was found in the new cultivar 'Bidan' in comparison with the classic 'Hayward', by direct extraction with methanol. This is the first investigation of 'Bidan' kiwifruit cultivar, grown under organic conditions and compared with 'Hayward' organic. High contents of bioactive compounds and antioxidant and antiproliferative properties of the two kiwifruit cultivars justify their use as sources of valuable antioxidants. It is necessary to continue this study as a long-term experiment to eliminate the influence of seasonality.