Incidence,level, and behavior of aflatoxins during coffee bean roasting and decaffeination

Screening for aflatoxins (Afs), isolation and identification of Aspergillus flavus, and the effect of decaffeination and roasting on the level of contamination in coffee beans are studied. The percent frequency of A. flavus ranged between 4 and 80% in green coffee beans (GCB), whereas in ground roasted coffee beans (GRCB), it ranged between 1 and 71%. Aflatoxins were detected in 76.5 and 54.6% of the infected samples with averages of 4.28 and 2.85 microg/kg of GCB and GRCB, respectively. Roasting was demonstrated to lower the concentration of Afs in GCB. The Afs levels were reduced by approximately 42.2-55.9% depending on the type and temperature of roasting. The highest yields of Afs were detected in the decaffeinated green coffee beans (24.29 microg/kg) and roasted coffee beans (16.00 microg/kg). The growth of A. flavus in liquid medium containing 1 or 2% caffeine was reduced by 50%, and the level of aflatoxin in the medium was undetectable.     

Survey of aflatoxins, ochratoxin A, zearalenone, and sterigmatocystin in some Brazilian foods by using multi-toxin thin-layer chromatographic method

A previously published method for ochratoxin A was evaluated and proved appropriate for simultaneous determination of aflatoxins, ochratoxin A, sterigmatocystin, and zearalenone, with considerable savings in time and reagent costs. The detection limits were 2, 5, 15, and 55 micrograms/kg, respectively. The recoveries and coefficients of variation obtained with artificially contaminated samples were 91-101% and 0-16% for aflatoxin B1, 98-117% and 0-17% for sterigmatocystin, and 96-107% and 0-17% for zearalenone, respectively. The coefficients of variation for naturally contaminated samples (aflatoxins in rice and ochratoxin A in beans) ranged from 0 to 8%. The method was used to survey 296 samples that included 10 cultivars of dried beans, 8 types of corn products, 3 types of cassava flour, and both polished and parboiled rice between May 1985 and June 1986 in Campinas, Brazil. Only aflatoxin B1 (9 samples, 20-52 micrograms/kg), aflatoxin G1 (4 samples, 18-31 micrograms/kg), and ochratoxin A (5 samples, 32-160 micrograms/kg) were found. The average contamination percentage was 4.7%; beans showed the highest (6.6%) and rice showed the lowest (3.3%) incidence rates. Zearalenone and sterigmatocystin were not detected. Positive samples were confirmed by chemical derivatization, corroborated by development in 3 solvent systems.     

Liquid chromatographic determination of ochratoxin A in coffee beans and coffee products

A liquid chromatographic method for the determination of ochratoxin A in coffee beans (green and roast), instant coffee, and coffee drink is described. The sample is subjected to extraction with methanol-1% aqueous sodium bicarbonate (1 + 1) and C18 cartridge cleanup. The extract is chromatographed on a Nucleosil 5C18 column with a mobile solvent of acetonitrile-water-0.2M phosphate buffer pH 7.5 (50 + 47 + 3) containing 3 mM cetyltrimethylammonium bromide as an ion-pair reagent. Ochratoxin A is detected with a fluorometer (excitation 365 nm, emission 450 nm). The sensitivity was increased 20-fold by using ion-pair resolution. The detection limits corresponded to 2 micrograms/kg for coffee beans, 5 micrograms/kg for instant coffee, and 0.2 microgram/kg for coffee drink. The recoveries from coffee products were generally better than 80.7% and the relative standard deviations were 3.43-5.93%. The peak coinciding with ochratoxin A can be confirmed by treatment using alcohol (methanol, ethanol, or n-propanol) and H2SO4.     

Simultaneous thin layer chromatographic determination of aflatoxin B1 and ochratoxin A in black olives

A screening method has been developed for simultaneous determination of aflatoxin B1 and ochratoxin A in black olives. The technique includes extraction of both mycotoxins with aqueous methanol, cleanup using lead acetate, defatting with hexane, partitioning in chloroform, and thin layer chromatography. Detection limits are 5-7 micrograms aflatoxin B1 and 20 micrograms ochratoxin A/kg.     

Extraction and thin layer chromatography of aflatoxin B1 in mixed feeds

A method was developed for the determination of aflatoxin B1 in commercially prepared feeds. The method incorporates methylene chloride and citric acid solution extraction, cleanup on a small silica gel column, and thin layer chromatography for quantitation. Commercial turkey starter, catfish chow, medicated pig starter, broiler finisher, rabbit chow, horse feed, rat chow, and dog chow were investigated. The feeds were spiked with naturally contaminated corn at 4 different levels of aflatoxin B1 (16-130 microgram/kg). Three assays were run on each of the 32 combinations of feed and levels of aflatoxin. Mean recoveries were 85.9-92.8% at levels of 16.5, 32.9, 65.8, and 131.6 micrograms/kg. The relative standard deviation per assay was 18.6%. This method is more rapid and less involved than most previously published methods for mixed feeds.     

Determination of aflatoxins in vegetable oils

A simple method is proposed for determination of aflatoxins in vegetable oils. The method was successfully applied to both crude and degummed oils. The oil sample, dissolved in hexane, was applied to a silica column and washed with ether, toluene, and chloroform; aflatoxins were eluted from the column with chloroform-methanol (97 + 3). As quantitated by thin layer chromatography and liquid chromatography, the oils analyzed contained aflatoxin B1 at levels of 5-200 micrograms/kg. Recoveries of aflatoxin B1 standards added to aflatoxin-free oils were between 89.5 and 93.5%, with coefficients of variation of 6.3-8.0%.     

Preparation of partially decaffeinated instant green tea

The caffeine level of instant tea extracted from decaffeinated leaf tea with 4.0 mg g-1 caffeine is commonly above 10.0 mg g-1, the maximum limit of caffeine for decaffeinated instant tea. Further removal of caffeine by active carbon (AC) from the green tea extract was investigated. It showed that the removal of caffeine from the tea extract solutions depended on the treatment time and tea extract concentration while the ethanol concentration and pH had little effect on the removal of caffeine. According to the removal of caffeine and the ratio of total catechins to caffeine in the tested samples, the optimum decaffeination conditions were determined to be as follows: tea extract concentration 15-30 g L-1 for common tea extract but higher for partially decaffeinated tea leaf extract; ratio of tea solution to AC, 100 mL:4 g; treatment time, 4 h; and natural tea extract pH. Instant tea powder extracted from partially decaffeinated leaf tea with a caffeine level of 4.03 mg g-1 and further decaffeinated by AC had a caffeine level of 7.81 mg g-1, which was 31% lower than that without AC treatment.     

Fourier transform infrared and physicochemical analyses of roasted coffee

In this study, Brazilian coffee beans processed to different stages of roast at 210, 220, 230, and 240 °C were analyzed for pH value, titratable acidity, moisture content, and color lightness. Fourier transform infrared (FTIR) spectroscopy, in conjunction with principal component analysis, was conducted to study the effects of process time and temperature on the IR-active components of the acetyl acetate extract of the roasted coffee. The results showed that high-temperature-short-time resulted in higher moisture content, higher pH value, and higher titratable acidity when the beans were roasted beyond the start-of-second-crack stage, as compare to low-temperature-long-time process (LTLT). The LTLT process also resulted in greater IR absorbance for aldehydes, ketones, aliphatic acids, aromatic acids, and caffeine carbonyl bands on the FTIR spectra. Clusters for principal component score plots were well separated, indicating that the changes IR-active components in the coffee extracts, due to the different roasting treatments, can be discriminated by the FTIR technique. On the basis of the loading plots of principal components, changes of IR-active compounds in the coffee extract at various stages of roasting were discussed.     

Alkylpyridiniums. 2. Isolation and quantification in roasted and ground coffees

Recent model studies on trigonelline decomposition have identified nonvolatile alkylpyridiniums as major reaction products under certain physicochemical conditions. The quaternary base 1-methylpyridinium was isolated from roasted and ground coffee and purified by ion exchange and thin-layer chromatography. The compound was characterized by nuclear magnetic resonance spectroscopy ((1)H, (13)C) and mass spectrometry techniques. A liquid chromatography-electrospray ionization tandem mass spectrometry method was developed to quantify the alkaloid in coffee by isotope dilution mass spectrometry. The formation of alkylpyridiniums is positively correlated to the roasting degree in arabica coffee, and highest levels of 1-methylpyridinium, reaching up to 0.25% on a per weight basis, were found in dark roasted coffee beans. Analyses of coffee extracts also showed the presence of dimethylpyridinium, at concentrations ranging from 5 to 25 mg/kg. This is the first report on the isolation and quantification of alkylpyridiniums in coffee. These compounds, described here in detail for the first time, may have an impact on the flavor/aroma profile of coffee directly (e.g., bitterness), or indirectly as precursors, and potentially open new avenues in the flavor/aroma modulation of coffee.     

Thin layer chromatographic determination of aflatoxins, ochratoxins, sterigmatocystin, zearalenone, citrinin, T-2 toxin, diacetoxyscirpenol, penicillic acid, patulin, and penitrem A.

A general method is described for determining 16 mycotoxins in mixed feeds and other food products used in the manufacture of these feedstuffs. The mycotoxins are extracted and cleaned up by extracting with solvents of different pH. Thin layer chromatography is used to separate the toxins; toxins are then quantitated by the limit detection method. The minimum detectable concentration of mycotoxins in various products is: aflatoxin B1 or G1, 4--5 micrograms/kg; ochratoxin A or ethyl ester A 140--145 micrograms/kg; citrinin 600--750 micrograms/kg; zearalenone, 410--500 micrograms/kg; sterigmatocystin, 140--145 micrograms/kg; diacetoxyscirpenol, 2400--2600 micrograms/kg; T-2 toxin, 800--950 micrograms/kg; patulin, 750--800 micrograms/kg; penitrem A 14,000--14,500 micrograms/kg; penicillic acid 3400--3650 micrograms/kg.     

Simple, rapid cleanup method for analysis of aflatoxins and comparison with various methods

A method is described for simple and rapid determination of aflatoxins in corn, buckwheat, peanuts, and cheese. Aflatoxins were extracted with chloroform-water and were purified by a Florisil column chromatographic procedure. Column eluates were concentrated and spotted on a high performance thin layer chromatographic (HPTLC) plate, which was then developed in chloroform-acetone (9 + 1) and/or ether-methanol-water (94 + 4.5 + 1.5) or chloroform-isopropanol-acetone (85 + 5 + 10). Each aflatoxin was quantitated by densitometry. The minimum detectable aflatoxin concentrations (micrograms/kg) in various test materials were 0.2, B1; 0.1, B2; 0.2, G1; 0.1, G2; and 0.1, M1. Recoveries of the aflatoxins added to corn, peanut, and cheese samples at 10-30 micrograms/kg were greater than 69% (aflatoxin G2) and averaged 91%, B1; 89%, B2; 91%, G1; 78%, G2; and 92%, M1. The simple method described was compared with the AOAC CB method, AOAC BF method, and AOAC milk and cheese method. These methods were applied to corn, peanut, and cheese composites spiked with known amounts of aflatoxins, and to naturally contaminated buckwheat and cheese. Recoveries were much lower for the BF method compared with our simple method and the CB method.     

A quantitative method for determination of aflatoxin B in roasted corn.

Roasting aflatoxin-contaminated corn will reduce toxin levels. A quantitative analysis for aflatoxin in roasted corn has been developed by modifying a cleanup technique for green coffee extracts approved as official first action by the AOAC. A chloroform extract is partially purified on a Florisil column, and thin layer chromatographic (TLC) plates are developed with methylene chloride-chloroform-isoamyl alcohol-formic acid (81+15+3+1). Recoveries average 101% and the sensitivity limit is 5 ppb aflatoxin B1. A 2-dimensional TLC procedure can also be used to separate the aflatoxins from background interferences.     

Chlorogenic acids and lactones in regular and water-decaffeinated arabica coffees

The market for decaffeinated coffees has been increasingly expanding over the years. Caffeine extraction may result in losses of other compounds such as chlorogenic acids (CGA) and, consequently, their 1,5-gamma-quinolactones (CGL) in roasted coffee. These phenolic compounds are important for flavor formation as well as the health effects of coffee; therefore, losses due to decaffeination need to be investigated. The present study evaluates the impact of decaffeination processing on CGA and CGL levels of green and roasted arabica coffees. Decaffeination produced a 16% average increase in the levels of total CGA in green coffee (dry matter), along with a 237% increase in CGL direct precursors. Different degrees of roasting showed average increments of 5.5-18% in CGL levels of decaffeinated coffee, compared to regular, a change more consistent with observed levels of total CGA than with those of CGL direct precursors in green samples. On the other hand, CGA levels in roasted coffee were 3-9% lower in decaffeinated coffee compared to regular coffee. Although differences in CGA and CGL contents of regular and decaffeinated roasted coffees appear to be relatively small, they may be enough to affect flavor characteristics as well as the biopharmacological properties of the final beverage, suggesting the need for further study.     

Contribution of chlorogenic acids to the iron-reducing activity of coffee beverages

The iron-reducing activity of coffee beverages was determined by the ferric reducing antioxidant power (FRAP) assay. The influence on FRAP due to the degree of roasting (light, medium, and dark), species (Coffea arabica and Coffea robusta), and caffeine content (regular and decaffeinated) was investigated using ground and soluble coffee samples. The concentration of specific chlorogenic acids and caffeine in the beverages was determined by high-performance liquid chromatography and related to FRAP using Pearson correlation coefficients. All measurements were expressed per unit of soluble solids. Beverages prepared with ground coffee had, on average, 27% higher FRAP values than those prepared with soluble coffee (p < 0.05). In the former beverages, FRAP of C. robusta samples was significantly higher (on average, 50.3%) when compared to that of C. arabica samples, and FRAP values decreased with increasing degree of roasting (p < 0.05). A strong correlation (r > 0.91) was found between FRAP and the total content of chlorogenic acids, particularly that of the caffeoylquinic acid isomers. The iron-reducing activity of coffee beverages was not influenced by caffeine.     

Content of polyphenolic compounds in the Nigerian stimulants Cola nitida ssp. alba, Cola nitida ssp. rubra A. Chev, and Cola acuminata Schott & Endl and their antioxidant capacity

Varieties of kola nuts (Cola nitida alba, Cola nitida rubra A. Chev, and Cola acuminata Schott & Endl), a group of popular Nigerian and West African stimulants, were analyzed for their content of secondary plant metabolites. The three varieties of the kola nuts contained appreciable levels of (+)-catechin (27-37 g/kg), caffeine (18-24 g/kg), (-)-epicatechin (20-21 g/kg), procyanidin B 1 [epicatechin-(4beta-->8)-catechin] (15-19 g/kg), and procyanidin B2 [epicatechin-(4beta-->8)-epicatechin] (7-10 g/kg). Antioxidant capacity of the extracts and purified metabolites was assessed by two HPLC-based and two colorimetric in vitro assays. Extracts of all varieties exhibited antioxidant capacity with IC 50 values in the range 1.70-2.83 and 2.74-4.08 mg/mL in the hypoxanthine/xanthine oxidase and 2-deoxyguanosine HPLC-based assays, respectively. Utilization of HPLC-based assays designed to reflect in situ generation of free radicals (e.g., HO(*)), as opposed to general assays (DPPH, FRAP) in common use which do not, indicate that, of the major secondary plant metabolites present in kola nut extracts, caffeine is potentially the more effective cancer chemopreventive metabolite in terms of its antioxidant capacity.     

Collaborative study of a method for chemical confirmation of the identity of aflatoxin.

The chemical method for confirmation of the identity of aflatoxin by derivative formation directly on the TLC plate was studied collaboratively by 8 participants. The results show that aflatoxin B-1 was confirmed in 17 of 17 sample extracts representing 15 mu-g aflatoxin B-1/kg peanut butter, in 13 of 16 extracts representing 5 mu-g/kg, and in none of the 7 aflatoxin-free extracts. Collaborators commented that the method was easily performed and gave good results. The method has been adopted as official first action.     

Interferences in radioimmunoassay of aflatoxins in food and fodder samples of plant origin

Cross-reactions and resulting nonspecific binding of substances with structures resembling aflatoxins (derivatives of coumarin, and cinnamonic and benzoic acids, etc.) were investigated. The concentrations of these substances causing erroneously high or false positive values in radioimmunoassay were determined. One microgram aflatoxin B1/kg sample may be simulated by the occurrence of 5 g coumarin, 10 g caffeic acid, 16 g chlorogenic acid, or 15 g vanillin/kg fodder or food sample.     

Negative ion chemical ionization mass spectrometric method for confirmation of identity of aflatoxin B1: collaborative study

An interlaboratory study of a negative ion chemical ionization mass spectrometric (MS) confirmation procedure for aflatoxin B1 was conducted in laboratories in the United States, England, and West Germany. Twelve partially purified, dry film extracts from naturally and artificially contaminated roasted peanuts, cottonseed, and ginger root containing varying quantities of aflatoxin B1 were distributed to the participating laboratories. The extracts required additional cleanup before MS analysis, using either an acidic alumina column and preparative thin layer chromatography (TLC) or a 2-dimensional TLC procedure. Recovery of purified aflatoxin B1 was influenced by the degree of recovery of sample from acid alumina and/or the TLC plate and incomplete elution of aflatoxin B1 from silica gel. Factors affecting MS confirmation included the purity and recovery of aflatoxin and MS instrument sensitivity. Aflatoxin B1 identity was confirmed in 19.5, 90.9, and 100% of samples containing less than 5, 5-10, and greater than 10 ng aflatoxin B1/g product, respectively, by solid probe introduction using full mass scans. The MS method has been adopted official first action.     

Mycotoxin contamination of dietary and medicinal wild plants in the Eastern Cape Province of South Africa

Nineteen dietary and 30 medicinal wild plants used by residents of the Eastern Cape Province of South Africa were investigated for the presence of fumonisin B1 and aflatoxin B1. The plants were extracted in water, and cleanup was undertaken on immunoaffinity cartridges; analysis was by HPLC using fluorescence detection. None of the plant extracts contained detectable levels of aflatoxin B1; however, eight plants, four dietary and four medicinal, were positive for fumonisin B1 at levels ranging from 34 to 524 microg/kg and from 8 to 1553 microg/kg, respectively. The presence of fumonisin B1 was confirmed by LC-MS/MS using positive ion electrospray ionization. Fumonisin B1 provided characteristic fragment ions at m/z 704, 686, 546, 528, 370, and 352 corresponding to sequential loss of H2O and tricarboxylic acid moieties from the alkyl backbone. These results indicate that exposure to fumonisin B1 is much more widespread than initially thought and is the first report of mycotoxin contamination in South African medicinal and dietary wild plants.     

Flavoring components of raw monsooned arabica coffee and their changes during radiation processing

Volatile aroma principles, nonvolatile taste constituents (caffeine and chlorogenic and caffeic acids), and glycosidically bound aroma compounds of monsooned and nonmonsooned raw arabica coffee were analyzed using gas chromatography-mass spectrometry (GC-MS) and high-performance liquid chromatography (HPLC). Among the most potent odor active constituents known to contribute to the aroma of the green beans, 3-isopropyl-2-methoxypyrazine, 3-isobutyl-2-methoxypyrazine, 4-vinylguaiacol, beta-damascenone, (E)-2-nonenal, trans,trans-2,4-decadienal, phenylacetaldehyde, and 3-methylbutyric acid were detected by GC-MS in both samples. A decrease in content of methoxypyrazines and an increase in 4-vinylguaiacol and isoeugenol resulted in a dominant spicy note of monsooned coffee. These phenolic compounds exist partly as their glycosides, and their release from the bound precursors during monsooning accounted for their higher content in monsooned coffee. A considerable decrease in astringent chlorogenic acid as a consequence of hydrolysis to bitter caffeic acid was noted in monsooned coffee. Radiation processing of nonmonsooned beans at a dose of 5 kGy resulted in an increased rate of monsooning. At this dose a quantitative increase in most of the aroma active components could be observed in all samples studied. Hydrolysis of chlorogenic acid to caffeic acid was noted in radiation-processed monsooned coffee beans irrespective of whether the treatment was carried out before or after monsooning. These changes were, however, not observed in irradiated, nonmonsooned coffee beans, suggesting an enzymatic rather than a radiolytic cleavage of chlorogenic acid. A rationale behind the mechanism of monsooning and radiation-induced enhancement of the monsooning process is discussed.