Evaluation of teflubenzuron residue levels in grapes exposed to field treatments and in the must and wine produced from them.

Dissipation of benzoylurea insecticide teflubenzuron in grapes exposed to field treatments was evaluated. Vines of a white grape vineyard located in central Greece were sprayed twice, at a 28-day interval, with a commercial formulation of the insecticide at 12 g of active ingredient/100 L. Residues were determined by HPLC diode array detection, after ethyl acetate extraction and cleanup on silica phase cartridges, with a detection limit of 0.005 mg/kg. Under field conditions teflubenzuron residues in grapes were found to be very stable with no significant reduction for the whole experimental period of 49 days. However, residues were slightly lower than the maximum residue limits set by individual countries. The fate of teflubenzuron during the vinification process was also studied. Residues were found to be transferred completely into the must but, due to their high affinity for the suspended matter, were removed by approximately 98%; thus, very low concentrations were detected in the produced wine. Among various clarifying agents studied, charcoal was the only one found to be effective for removing teflubenzuron residues from wine.     

Fate of quinoxyfen residues in grapes, wine, and their processing products

Quinoxyfen is a new fungicide that belongs to the family of the quinolines, recently introduced to control powdery mildew (Uncinula necator). In this paper the fate of quinoxyfen residues from vine to wine and in their processing products was studied. After the last of four applications at the recommended rate, 0.38 mg/kg of residue was found on the grapes, which is under the legal limit fixed in Italy (0.5 mg/kg). The degradation rate was according to a pseudo-first-order kinetics (r = 0.964) and the half-life was 7.24 days. Vinification was carried out with and without maceration. During the vinifications without maceration <50% of the residues passed from the grapes to the musts. Separation of the lees (8%) from the must by centrifugation caused no detectable residues in centrifuged must. At the end of fermentation with and without maceration no quinoxyfen residues were determinable in the wine. No effect on the alcoholic or malolactic fermentation was observed even in the presence of higher quinoxyfen concentrations than those found in the grapes at harvest time. During fermentation, the yeasts partially degraded the pesticides and completly adsorbed them. Bacteria, on the other hand, do not have any degradative effect on the pesticides. The raisins obtained by sun-drying did not contain any residues, whereas those obtained by oven-drying show the same amount of residues as in the fresh grapes. During the sun-drying process the fruit weight decreased by a factor of 4; the decrease in the oven-drying was equivalent. Samples of dregs and liquid lees, fortified with high levels of quinoxyfen. were double-distilled. The first dregs distillate, with an alcohol content of 32.1%, did not show any residues, whereas the first lees distillate, with an alcohol content of 34.5%, showed 7% of the initial residues. After the second lees distillation, the obtained product showed an alcoholic content of 81.2% and no residues of quinoxyfen (<0.01 mg/kg).     

Residues of azoxystrobin from grapes to raisins

Azoxystrobin, a fungicide of the strobilurin group, has an European Union maximum residue level (MRL) of 2 mg/kg for grapes. This work aimed to assess residues on fresh and washed grapes and on raisins following processing with (i) alkali treatment and sun drying and (ii) sun drying only. QUADRIS 25% SC was applied according to good agricultural practice for two consecutive years on a typical cv. Thomson seedless and a seed-producing clone. Samples were collected 0, 15, and 21 days postapplication and analyzed using gas chromatography/electron capture detection; recoveries were 86 +/- 12% for grapes and 99 +/- 15% for raisins. Residues on grapes were 0.49-1.84 mg/kg, and washing removed 75% of the residue. Residues in raisins produced from seedless grapes were 0.51-1.49 (treatment 1) and 1.42-2.08 mg/kg (treatment 2), with residue transfer factors sometimes >1, even following alkali treatment, which reduced residues considerably. To avoid trade problems, a higher MRL for raisins is necessary.     

Determination of ethylenethiourea in grapes and wine

Residues of ethylenethiourea (ETU) in grapes and wine were determined by capillary gas chromatography and paper chromatography, without a cleanup step, and after derivatization to S-benzyl-ETU. The detection limit was 0.0002 mg/kg for flame ionization detection, 0.008 mg/kg for paper chromatography with photodensitometric evaluation of the detected spot. Results were compared with a generally used GC method specifying electron capture detection of trifluoroacetylated S-benzyl-ETU. The recoveries of ETU in grapes and wine at different concentration levels were determined. ETU residues were determined in treated grapes but no residues were detected in wine.     

Evolution of chlorpyrifos, fenarimol, metalaxyl, penconazole, and vinclozolin in red wines elaborated by carbonic maceration of Monastrell grapes

The influence of the different steps involved in the wine-making process on the disappearance of chlorpyrifos, fenarimol, metalaxyl, penconazole, and vinclozolin in red wines elaborated by carbonic maceration of Monastrell grapes was studied. The initial levels of the residues in grapes ranged from 0.28 mg/kg (penconazole) to 1 mg/kg (chlorpyrifos). Ten days after the beginning of maceration, the compound that had decreased least was chlorpyrifos (83% of initial value remaining), whereas metalaxyl, the least persistent of the residues, had decreased to 49% of its initial value. In the free-run juice, on the other hand, the highest percentage remaining corresponded to metalaxyl (10%) and the lowest to chlorpyrifos (0. 1%). After pressing, the percentages of initial values eliminated in pomace varied from 82.7% for chlorpyrifos to 17.7% for metalaxyl, whereas in the press juice the opposite was the case (37% metalaxyl and 2% chlorpyrifos remaining). In finished wine, there were residues of all the pesticides, with the exception of chlorpyrifos, metalaxyl (21%) being the most persistent. The percentages eliminated in the lees varied from 1.5 to 2.5% of the initial value.     

Evolution of phenolic composition of red wine during vinification and storage and its contribution to wine sensory properties and antioxidant activity

The objective of this work was to study the evolution of the phenolic composition of red wine during vinification and storage and its relationship with some sensory properties (astringency and bitterness) and antioxidant activities. Thus, red wine was made by a classic vinification method with Castela?o and Tinta Miu?da grapes (Vitis vinifera L.) harvested at maturity (3:2; w/w). Samples were taken at 2 and 7 days of maceration, at second racking, at the time of bottling and at 6 and 14 months after bottling. The total polyphenols extract (TPx) in each sample was isolated by column chromatography. The phenolic composition (anthocyanins and proanthocyanidins), in vitro antioxidant activity, and sensory property (astringency, bitterness) of the isolated TPx from different winemaking stages were evaluated through high-performance liquid chromatography-diode array detection, 1,1-diphenyl-2-picrylhidrazyl radical test, ferric reducing antioxidant power assay, total phenolic index, MWI (polyphenol molecular weight index), TSA (tannin specific activity), and sensory panel tasting. The results showed that the phenolic composition of red wine varied significantly during winemaking. The intensity of astringency (IA) and the intensity bitterness (IB) of the isolated TPx from different winemaking stages increased from 2 days of maceration until second racking and then decreased. Furthermore, MWI and TSA are positively correlated with IA and IB. The in vitro antioxidant activity of the isolated TPx from different winemaking stages maintained unchanged after alcoholic fermentation, which was independent of the variation of phenolic composition and sensory properties.     

Fate of ochratoxin A during vinification of Semillon and Shiraz grapes

Semillon and Shiraz grapes containing ochratoxin A (OA) were obtained by inoculation of bunches on the vine with Aspergillus carbonarius. Citric acid content was greater in the inoculated grapes than in healthy grapes. Samples were collected throughout vinification of these grapes and the OA content was quantified using a stable isotope dilution liquid chromatographic-tandem mass spectrometric method. The mass of processed and waste streams during vinification was also noted. Reduction in the amount of OA in juice and wine occurred at every solid-liquid separation stage. The OA concentration (microg/kg) in white and red wine after racking was 4% and 9%, respectively, of that in crushed grapes. This corresponds to 1% and 6% of the total OA content that was initially present in the inoculated grapes. The OA content was divided between solid and liquid phases at each stage of vinification. OA did not appear to be transformed either chemically or biologically by yeast during fermentation, rather was discarded with the marc, juice lees, and gross lees.     

Optimizing the process of making sweet wines to minimize the content of ochratoxin A

During the drying process of raisins, the grapes are subjected to climatic variations that can result in heavy infections of some fungal species that produce ochratoxin A (OTA), a powerful toxic metabolite, whose maximum permitted content is set by the European Union at 2.0 μg/L for grapes, wine and other drinks derived from the grape. The aim of this paper is to optimize the process of making sweet wines in order to minimize the content of ochratoxin A. The results reflect a reduction of the OTA content in grapes dried under controlled conditions in a climatic chamber up to 24% compared to those sunned in the traditional way. A decrease of the concentrations of OTA is also observed during the processes of vinification. Those wines with prefermentative maceration reached a higher OTA content than the wines without maceration, but unexpectedly were not those preferred from a sensorial point of view. In addition, the process of aging in oak casks has been shown to serve as a natural method for reducing the OTA content of these wines.     

Fate of iprovalicarb, indoxacarb, and boscalid residues in grapes and wine by GC-ITMS analysis

The behavior in field and the transfer from grapes to wine during winemaking of iprovalicarb, indoxacarb, and boscalid was studied. The residue levels found in grapes were far below the MRLs set for grapes in EU, accounting at harvest time 0.81, 0.43, and 4.23 mg/kg for iprovalicarb, indoxacarb, and boscalid, respectively. The residue levels in the samples treated with boscalid may have residual problems (due to an accumulation effect) if repeated field treatments will be performed. Winemaking experiments showed a complete transfer of all pesticide from grapes to the must, while in wine the residues were low or negligible due to the adsorbing effect of lees and pomace. The clarification experiments showed a good removal of pesticide residues from the wine media, for all pesticides. The GC-ITMS method showed good performance with adequate recoveries ranging from 75 to 115%, and good method limits of quantitation (LOQs) and of determination (LODs) far below MRLs.     

Pesticide residues in grapes, wine, and their processing products

In this review the results obtained in the 1990s from research on the behavior of pesticide residues on grapes, from treatment to harvest, and their fate in drying, wine-making, and alcoholic beverage processing are reported. The fungicide residues on grapes (cyproconazole, hexaconazole, kresoxim-methyl, myclobutanil, penconazole, tetraconazole, and triadimenol), the application rates of which were of a few tens of grams per hectare, were very low after treatment and were not detectable at harvest. Pyrimethanil residues were constant up to harvest, whereas fluazinam, cyprodinil, mepanipyrim, azoxystrobin, and fludioxonil showed different disappearance rates (t(1/2) = 4.3, 12, 12.8, 15.2, and 24 days, respectively). The decay rate of the organophosphorus insecticides was very fast with t(1/2) ranging between 0.97 and 3.84 days. The drying process determined a fruit concentration of 4 times. Despite this, the residue levels of benalaxyl, phosalone, metalaxyl, and procymidone on sun-dried grapes equalled those on the fresh grape, whereas they were higher for iprodione (1.6 times) and lower for vinclozolin and dimethoate (one-third and one-fifth, respectively). In the oven-drying process, benalaxyl, metalaxyl, and vinclozolin showed the same residue value in the fresh and dried fruit, whereas iprodione and procymidone resides were lower in raisins than in the fresh fruit. The wine-making process begins with the pressing of grapes. From this moment onward, because the pesticide on the grape surface comes into contact with the must, it is in a biphasic system, made up of a liquid phase (the must) and a solid phase (cake and lees), and will be apportioned between the two phases. The new fungicides have shown no effect on alcoholic or malolactic fermentation. In some cases the presence of pesticides has also stimulated the yeasts, especially Kloeckera apiculata, to produce more alcohol. After fermentation, pesticide residues in wine were always smaller than those on the grapes and in the must, except for those pesticides that did not have a preferential partition between liquid and solid phase (azoxystrobin, dimethoate, and pyrimethanil) and were present in wine at the same concentration as on the grapes. In some cases (mepanipyrim, fluazinam, and chlorpyrifos) no detectable residues were found in the wines at the end of fermentation. From a comparison of residues in wine obtained by vinification with and without skins, it can be seen that their values were generally not different. Among the clarifying substances commonly used in wine (bentonite, charcoal, gelatin, polyvinylpolypyrrolidone, potassium caseinate, and colloidal silicon dioxide), charcoal allowed the complete elimination of most pesticides, especially at low levels, whereas the other clarifying substances were ineffective. Wine and its byproducts (cake and lees) are used in the industry to produce alcohol and alcoholic beverages. Fenthion, quinalphos, and vinclozolin pass into the distillate from the lees only if present at very high concentrations, but with a very low transfer percantage (2, 1, and 0.1%, respectively). No residue passed from the cake into the distillate, whereas fenthion and vinclozolin pass from the wine, but only at low transfer percentages (13 and 5%, respectively).     

Lead contamination in Portuguese red wines from the Douro region: from the vineyard to the final product

To quantify lead contamination in wines and to try to identify major lead sources, two winemaking processes were followed during one annual cycle of wine production. Two vineyards from the Douro Portuguese region and two types of wine, one red table wine, which has been produced in a very modern winery, and one red fortified wine (similar to Port), which has been produced by a traditional vinification process, were selected for this study. Aerosols from the vineyards atmosphere, vineyard soil, vine leaves, grapes, and samples from the intermediary and final wine product were collected. Suitable pretreatments, namely, high-pressure microwave assisted digestion (soil, leaves, and grapes) and UV-irradiation (grape juices and samples from the different steps of the vinification processes), were used. The samples were analyzed in terms of lead total concentration and respective isotope ratios by using inductively coupled plasma mass spectrometry and atomic absorption spectrophotometry with electrothermal atomization. It was observed that the major sources of lead were in the vinification system, the more traditional one introducing more lead than the modern one. For the fortified wine, the lead concentration increased from 4.7 microg L(-1), in the grape juice, to 17.2 microg L(-1), in the final product, while for the table wine the increase was from 4.1 to 13.1 microg L(-)(1). Therefore, only about 1/4 (fortified wine) and 1/3 (table wine) of the lead total content of the final products came from soil and atmospheric deposition. Therefore, it is expected that marked reductions of the lead content in the wines would occur if the sources of lead were removed from the tubes and containers used in the vinification system, particularly by using welding alloys and small fittings free of lead. The lead levels in the vine leaves (global mean of 0.43 microg g(dry leave)(-1)) and grapes (global mean of 35 ng g(dry grape)(-1)) were similar in both vineyards.     

Effect of the maceration technique on the relationships between anthocyanin composition and objective color of Syrah wines

The effects of two different vinification techniques, traditional fermentation and carbonic maceration, on the anthocyanin composition and color of young red wines, made with Syrah grapes grown in a warm climate, were compared. Tristimulus colorimetry was applied to study the color of wines during the vinification, and a high-performance liquid chromatography (HPLC) procedure was used for the analysis of anthocyanins. Carbonic maceration led to wines with lower anthocyanin content, mainly monoglucosides, and total phenols. This was related to lighter wines, less saturated, but more colorful (higher chroma C*ab values), and hues hab similar to those of the Syrah wines made by traditional vinification. Thus, the lightness L* had much more influence on the saturation s*uv of the wines obtained by carbonic maceration than the chroma (s*uv = C*uv/L*). From a study of the color-composition relationships using linear and multiple regression, better relationships were found for the wines from traditional vinification, where the chromatic parameters L*, hab, and s*uv could be predicted from the 3-monoglucosides of delphinidin, petunidin, peonidin, and malvidin concentrations (R > 0.9). However, a good prediction of the chroma C*ab from the anthocyanin composition was not possible. On the contrary, C*ab was the best predicted parameter from the anthocyanins monoglucosides (R > 0.9) in the carbonic maceration wines.     

Pulsed electric field-assisted vinification of aglianico and piedirosso grapes

Pulsed electric field (PEF) treatments were applied to increase the polyphenolic content of fresh red wines made from Aglianico and Piedirosso grapes. Prior to the fermentation/maceration step, the grape skins were treated at different PEF intensities (field strengths from 0.5 to 1.5 kV/cm and energy inputs from 1 to 50 kJ/kg), with their permeabilization being characterized by electrical impedance measurements. Furthermore, the release kinetics of the total polyphenols and anthocyanins were characterized during the maceration stage by spectroscopic and Folin-Ciocalteu colorimetric methods, respectively. Finally, the fresh wine, obtained after pressing, was characterized for total acidity, pH, reducing sugar, color intensity, total polyphenols, anthocyanins content, antioxidant activity, and volatile compound composition. PEF treatment on Aglianico grapes induced a significantly higher release of polyphenols (+20%) and anthocyanins (+75%), thus improving the color intensity (+20%) and the antioxidant activity of the wine (+20%) while preserving the other organoleptic characteristics. In contrast, there was only a minor impact on the polyphenolic release kinetics of Piedirosso grapes, despite the significant degree of cell membrane permeabilization.     

Fungicide dissipation curves in winemaking processes with and without maceration step

The evolution of residual levels of four fungicides (cyprodinil, fludioxonil, pyrimethanil, and quinoxyfen) during the elaboration of three types of wine with maceration (traditional red wine, carbonic maceration red wine, and red wine of long maceration and prefermentation at low temperature) and two types of wine without maceration (rose and white) has been studied. The disappearance curves of each fungicide have been analyzed during the period of each winemaking process (21 days) and during the different enological steps involved in the elaborations. The residual levels of fludioxonil reduce most quickly during the winemaking processes without maceration, whereas the decrease in levels of pyrimethanil was the slowest in practically all cases (with and without maceration). During carbonic maceration winemaking, the decay constant of cyprodinil was greater than that of the other pesticides in all assays (time and steps).     

Definitive evidence for the actual contribution of yeast in the transformation of neutral precursors of grape aromas.

Experiments were designed to demonstrate the actual contribution of yeast in the formation of the primary aroma during the vinification of neutral grapes. Ruché was chosen as the model wine to study because of its unique fragrance. A yeast strain specific for Ruché was selected using a new and rapid isolation method for red wines. The results of this study can be summarized as follows: Skins from nonaromatic white or red grapes apparently contain most of the primary aroma compounds that are revealed in the must only after contact with yeast cells under defined conditions. Similar results were obtained with the pulp and seeds fractions; however, the olfactory notes, although well characterized, differed from those obtained with skins alone. Clarification, filtration, and centrifugation of the pulp and seed fractions or sonification of the skins produce different and well-characterized olfaction notes during the contact with yeast. The primary aroma of nonaromatic white and red grapes contained in the skins can be revealed within 24-48 h of yeast contact in a synthetic nutrient medium (SNM). The primary aroma precursors extracted from the skins with methanol, water-saturated butanol, or aqueous buffer at pH 3.2, concentrated and eluted from a C18 resin column, can be transformed to the free form wine aroma markers within 6 h of contact with yeast cells in SNM. By contrast, prolonged maceration of the skins in aqueous alcoholic buffer at pH 3.2 or 1.1, at 50 or 70 degrees C did not release primary odors typical of wine. The individual primary aroma compounds, identified by GC-MS analysis in Ruché wine samples or in Ruché skin-yeast-SNM samples, could not explain the complexity of the typical Ruché wine odor. Only odors common to many wine varieties were identified by GC-olfactometry analysis.     

Levels of stilbene oligomers and astilbin in French varietal wines and in grapes during noble rot development

Phenolics from grapes and wines can play a role against oxidation and development of atherosclerosis. Stilbenes have been shown to have cancer chemopreventive activity and to protect lipoproteins from oxidative damage. A method for the direct determination of stilbene oligomers (viniferin and pallidol) as well as astilbin in different types of wine using high-performance liquid chromatography with UV detection is described. In a survey of 21 commercial wines from the south of France, levels of pallidol and viniferin are reported for the first time in different types of wines. Viniferin was found to be present only in red and botrytized sweet white wines with levels between 0.1 and 1.63 mg/L; pallidol was not found in dry and sweet white wines but only in wines made by maceration with stems, with levels between 0.38 and 2.22 mg/L. Highest levels of astilbin were found in Egiodola (15.13 mg/L), Merlot (11.61 mg/L), and Cabernet Sauvignon (8.24 mg/L) for red wines and in Sauvignon (5.04 mg/L) for white varietal wines. Astilbin levels are highest for recent vintages, but pallidol is not found in older vintages. During noble rot development in Sauvignon or Sémillon grapes from the Sauternes area, levels of trans-astringin, trans-resveratrol, trans-piceid, and pallidol are quite low (<0.5 mg/kg of grapes). Viniferin and astilbin levels become optimum at 2 and 30 mg/kg, respectively, during spot grape and speckle grape stages.     

Determination and depletion of residues of carbadox, tylosin, and virginiamycin in kidney, liver, and muscle of pigs in feeding experiments

The results of residue determinations of the growth promotors carbadox, tylosin, and virginiamycin in kidney, liver, and muscle from pigs in feeding experiments are described as well as the analytical methods used. Residues of the carbadox metabolite quinoxaline-2-carboxylic acid were found in liver from pigs fed 20 mg/kg in the diet with a withdrawal time of 30 days. No residues were detected in muscle with zero withdrawal time. The limit of determination was 0.01 mg/kg for both tissues. No residues of virginiamycin and tylosin were found in pigs fed 50 and 40 mg/kg, respectively, in the diet, even with zero withdrawal time. Residues of tylosin of 0.06 mg/kg and below were detected in liver and kidney from pigs fed 200 or 400 mg/kg and slaughtered within 3 h after the last feeding.     

Field trials to determine residues of chlozolinate in table grapes

Chlozolinate (Serinal) is a dicarboximide fungicide used in southern European countries principally on grapes. Maximum residue levels have not yet been set by FAO/WHO and are under evaluation in the EU. Field trials have been carried out in Greece on two varieties of table grapes (Cardinal and Victoria) during two consecutive years to assess residues remaining after application according to good agricultural practice. Analysis using a multiresidue method with gas chromatography (ECD) showed that the parent compound decays with a first-order rate constant of 0.057 +/- 0.011 day(-)(1) and that residues had fallen below the proposed MRL of 5 mg/kg in all samples by 21 days postapplication (the proposed PHI). The contribution of the main metabolite, S1, to the total residue is generally <20%. Washing removes a substantial amount (up to 80%) of chlozolinate, which appears to be nonsystemic on grapes, thus reducing real consumer exposure to this pesticide.     

Residues of vinclozolin and procymidone after treatment of greenhouse grown lettuce,tomato and cucumber

Residues of the fungicides vinclozolin and procymidone, used to control the Botrytis cinerea disease, were studied in greenhouse grown lettuce, tomato and cucumber. Residue concentrations differed between the species of treated vegetables, and depended mostly on time of picking (harvest), size of fruits and mode of chemical application. The differences in concentration between one and two applications became smaller with time after application. The greatest differences occurred in lettuce. The residue contents in cucumber fruits assigned both for industrial and home processing (pickling) were higher than the legal limit (3 mg/kg). As a result of washing cucumbers, 22–24% of the residue was eliminated, and by peeling them 79–85% of the vinclozolin and procymidone residues were eliminated. Therefore it is reasonable that one or two applications of these fungicides should be used, with a time lapse of 14 days, but only with cucumbers intended for salad consumption. Vinclozolin residues, when used as vaporisation tablets, were in all cases 35–65% lower compared with the wettable powder (WP) formulation; however, the rate of of residue decrease was much slower. When applied in the form of vaporable tablets, the vinclozolin residue concentration was lower in all the sampled fruits in comparison with the WP formulation. The concentration of fungicide residues detected in winter tomato fruits was higher than that of the spring crop. Irrespective of vegetable the detected levels of fungicide residues were lower in ripe and bigger fruits than in green and smaller ones.     

Postharvest UV-C-irradiated grapes as a potential source for producing stilbene-enriched red wines

The use of postharvest controlled irradiation by UV pulses is proposed as a potential method to produce stilbene-enriched red wine. "Monastrell" grapes were UV-C-irradiated to increase stilbene content. The main inducible stilbenes were resveratrol and piceatannol, which are molecules with reported health-beneficial activities. The evolution of both compounds was followed in the different steps of an "analytical" traditional maceration wine-making process. The final wine made from UV-C-irradiated grapes was enriched about 2- and 1.5-fold in resveratrol and piceatannol, respectively, when compared to the control wine. In addition, no difference was detected regarding the standard enological parameters (color, acidity, etc.). It is strongly suggested that, with the use of more susceptible wine grapes to induce bioactive stilbenes upon UV-C irradiation, the stilbene-enrichment of wine can be much higher.