PLANT JUICES IN RELATION TO SILAGE FERMENTATION

The release of the plant-cell juices is a prerequisite for a lactic-acid fermentation in silage. Investigations with plant material at different moisture contents have indicated that above about 2 g water per g dry matter sufficient juice is released from properly ensiled material to permit the onset of fermentation; below this moisture content lactic-acid production is delayed, if not prevented.
When material of suitable moisture content is ensiled at a temperature of 25°C, the onset of fermentation is somewhat slower than at 40°C. However, within these limits, the temperature is not critical, provided that the silage is completely sealed to exclude air. The infiltration of even small amounts of fresh air delays the release of the juices and, especially at the lower temperatures, often results in an undesirable fermentation.
A number of miscellaneous treatments, designed to hasten the release of the juices, failed to show any advantages in small-scale tests.     

PLANT JUICES IN RELATION TO SILAGE FERMENTATION

Using ryegrass and lucerne silages, investigations were made into the relationship between plant-cell breakdown, as evidenced by a collapse of the silage mass and by an increase in its electrical conductivity, and the initiation of lactic-acid production. Changes in the water activity of the juices available as a medium for the silage bacteria were also examined. It has been shown that cell breakdown and the resultant release of the plant juices Is a necessary pre-requisite for the production of significant amounts of lactic acid during ensilage. The investigation also confirms that the complete exclusion of fresh air from the silage mass can usually be expected to result in cell breakdown within a few hours.     

PLANT JUICES IN RELATION TO SILAGE FERMENTATION III. Effect of water activity of juice

The water activity of juice available for fermentation, after breakdown of the cell walls during the ensiling of plant material, depends largely on the moisture content of the sample. Water activity increases with moisture content, but probably never becomes so high as seriously to limit lactic-acid fermentation, although high moisture contents have other detrimental effects. With low moisture contents, the limited availability of the juice rather than its lowered water activity is most probably the factor primarily responsible for poor lactic-acid production.     

The antimicrobial spectra of some salts of organic acids and glutaraldehyde in respect to their potential as silage additives

Salts of formic, acetic and propionic acids and glutaraldehyde were subjected to an assay with representatives of the major groups of silage micro-organisms at pH 4·0, 4·5, 5·0 and 6·0. The antimicrobial spectra of the salts suggested that they are most effective against the least desirable components of the bacterial flora of silage, coliforms, Clostridia and bacilli, and would create conditions for a desirable fermentation in practice. In many instances the activity of the salts was better than the corresponding free acid and it was postulated that, if supplemented with acid, aerobic stability of silage might also be improved. Glutaraldehyde, whilst being less selective as an antimicrobial agent, possesses properties which would encourage a lactic-acid fermentation in silage.     

不同添加剂对柱花草青贮品质的影响

以热研2号柱花草为原料， 通过直接青贮（CK）、 添加山梨酸（0.2％）、 蔗糖（2％）、 青贮宝（0.1％）等处理， 30 d后测定了柱花草青贮饲料pH值、 乳酸、 乙酸、 丙酸、丁酸等含量并分析其主要营养成分含量。结果表明： 柱花草直接青贮品质较差， 添加山梨酸、 蔗糖、 青贮宝等处理能降低pH值和提高乳酸含量， 添加2％蔗糖能极显著降低pH值(p<0.01)、 提高乳酸含量(p<0.05)， 改善青贮品质， 提高营养价值。     

Processing of materials derived from sweet sorghum for biobased products

Sweet sorghum (Sorghum bicolor (L.) Moench) is particularly suitable as a feedstock for a variety of bioprocesses, largely because of its high yields of both lignocellulosic biomass and fermentable saccharides. Sweet sorghum is less economically important for refined sugar production than other sugar crops, e.g., sugar beet and sugarcane, but can produce more raw fermentable sugar under marginal conditions than those crops. In this review, the agronomic requirements of sorghum (viz., water, soil, and nutrient requirements), cultural practices, and plant morphology are discussed from a bioprocessing perspective. Historically, sugar extraction from the plant in the form of juice has been of primary interest; these methods, along with modern developments are presented. Recently, the direct yeast fermentation of sorghum juice for ethanol production has been studied. Additionally, the bagasse resulting from the juice extraction has been used for a variety of potential products: forage, silage, combustion energy, synthesis gas, and paper. The bagasse contains high levels of relatively low crystallinity cellulose, along with relatively labile lignin, and so is itself of interest as a fermentation feedstock. Whole sorghum stalk, and its bagasse, have been subjected to studies of a wide array of pretreatment, enzymatic hydrolysis, and fermentation processes. The potential fermentation products of sweet sorghum are wide ranging; those demonstrated include ethanol, acetone, butanol, various lipids, lactic acid, hydrogen, and methane. Several potential native products of the plant, in addition to cellulose for paper production, are also identified: waxes, proteins, and allelopathic compounds, such as sorgoleone.     

THE CONSERVATION OF GRASS IN SEALED METAL AND PLASTIC CONTAINERS, WITH AND WITHOUT GROUND BARLEY MEAL

Two experiments are described in which ground harley meal was added to freshly-cut grass hefore ensiling it in small air-tight metal containers and polythene containers. The mean DM loss from the air-tight metal containers was 1 % and from the polythene containers 18.8%. The silages were all of satisfactory fermentation quality, as assessed hy pH, voladle acids, lactic-acid and Tolatile-hase content. The addition of the harley meal significantly improved the nutritive content of the ensiled material, and the resulting silage in the air-tight metal containers. Sheep were used to measure the voluntary intakes of the silages conserved in the polythene containers.     

THE EFFECT OF FERTILIZER NITROGEN ON SILAGE FERMENTATION

Direct-cut grass which has been heavily fertilized often produces silage with a poor fermentation. An investigation was carried out to study the effect of rate and timing of N applications to herbage intended for direct-cut silage. A small but consistent increase in silage pH was recorded after high levels of N were applied 7–8 weeks before cutting. The application of additional N fertilizer 10–14 days before cutting the sward had an adverse effect on silage fermentation. Changes in herbage composition following different levels of applied N are outlined.     

热研4号王草利用概述

介绍热研4号王草的植物学特性和繁殖要点，阐述王草在青饲、青贮、氨化、微贮、EM和青干草等方面的研究和利用。株高1.5 m以下的王草适宜青饲、青贮和制作青干草，稍老的王草可以进行化、微贮和EM处理。     

The influence of the carbohydrate fraction and additives on silage quality

Respiration losses, effect of sugar content, formic acid addition and inoculation were evaluated in relation to initial fermentation and silage quality in three experiments. Changes in the content of fermentable substrate during post–harvest respiration and initial fermentation were studied in the laboratory. Soluble carbohydrates were estimated as glucose, fructose, sucrose, fructans and starch by an enzymatic method.
About 70% of the sugars remained after 30 h of conventional wilting, as opposed to less than 50% in a chopped sample kept in the dark. During the first days of fermentation the metabolic activity was very intensive. Sugars, which accounted for 10% of the dry matter, were fermented within 4 d. There were indications, mainly in clover silages, that substances other than water-soluble carbohydrates were used as energy sources.
Low-sugar crops were obtained by shading the fields. After 3 d the sugar in the grass had decreased to half of the original content. This effect was less pronounced in clover. The amount of available substrate and dry matter (DM) content had a major influence on silage quality. In an unwilted crop at least 25 g of water-soluble carbohydrate was needed per kg of fresh material to obtain an acceptable silage quality in the controls, while 20 g was sufficient in inoculated silage. Formic acid addition makes the fermentation less sensitive to water–soluble carbohydrate content. Inoculation of willed silage increased lactic acid production and decreased the pH. There was also less variation in silage quality.     

Effects of an indigenous and a commercial Lactobacillus buchneri strain on quality of sugar cane silage

The aim was to evaluate the effects of adding a novel Lactobacillus buchneri strain and a commercial inoculant on the fermentation and aerobic stability of sugar cane silages (Saccharum spp.). In the first experiment samples were collected from sugar cane silage at 5, 20, 40 and 80 d after ensilage in experimental silos and microorganisms belonging to the Lactobacillus genus were isolated and identified, with a wild strain of L. buchneri, UFLA SIL 72, being selected as an inoculant. In the second experiment sugar cane was inoculated with either the novel bacteria or a commercial inoculant at the moment of ensiling and compared with a control silage prepared without an inoculant. Experimental silos were opened at 0, 3, 10, 30, 60 and 90 d of ensilage and their chemical composition measured. The silages opened after 90 d were also assessed for aerobic stability. The addition of L. buchneri resulted in a higher concentration of acetic acid and reduced populations of yeasts in silage compared to the other silage treatments, and a lower ethanol concentration in the silage. The novel L. buchneri isolate and the commercial inoculant also improved aerobic stability of the sugar cane silages. It was concluded that the addition of the novel inoculants L. buchneri UFLA SIL 72 to sugar cane silage can be recommended.     

The effect of addition of sugar and inoculation with two commercial inoculants on the fermentation of lucerne silage in laboratory silos

Lucerne (DM 236 g kg^-1, WSC 49 g (kg DM)^-1) was ensiled in test-tube silos with or without either glucose or fructose and with or without one of two commercial inoculants. The WSC content of the forage as ensiled was too low to obtain a well preserved untreated silage. By day 4 the pH values of the silages with added sugar or inoculant were significantly lower (P< 0·001) than the control silage. A satisfactory fermentation was attained only in the silages to which sugar and an inoculant had been added. These silages had a lower pH, more protein-N (P< 0·001), less ammonia-N (P<0·001), a faster increase in counts of lactic acid bacteria, and decrease in counts of coliforms than the other silages. Homo-fermentative lactic acid bacteria dominated the fermentation in the inoculated silages while leuconostocs dominated the early stages of fermentation in the control silages. The results indicate that if there is insufficient sugar in the original crop, then the bacteria in an inoculant will not be able to produce enough lactic acid to lower the pH to an acceptable level. This has important implications for the ensilage of lucerne and other highly buffered low sugar crops.     

Intake, liveweight gain and feed preference by steers fed combinations of lucerne and Westerwolds ryegrass silages

Nutritive value and voluntary intake of legumes are generally considered to be higher than those of grasses when ensiled at similar digestibility, although high levels of soluble protein can result in low N utilization by animals and high losses to the environment. The objectives of this experiment were to describe the optimum combination of Westerwolds ryegrass ( Lolium multiflorum Lam. cv. Aubade) and lucerne ( Medicago sativa L. cv. AC Caribou) silages to maximize liveweight gain of steers fed silage, determine chemical components that are important and ascertain whether steers selected the optimum mixture when given a choice. Both silages contained similar concentrations of dry matter (DM), acid-detergent fibre (ADF) and organic acids, but lucerne silage had higher concentrations of N, soluble-N and ammonia-N. Westerwolds ryegrass silage contained more neutral-detergent fibre (NDF). In a 12-week experiment, voluntary intake by Hereford steers was not influenced when the proportion of the two silages was changed from 1 to 0 in 0·25 increments. However, liveweight gain and feed efficiency increased linearly ( P  < 0·001) as the proportion of ryegrass silage fed was increased. When preconditioned to either of the two silages, steers showed a significant preference for ryegrass over lucerne ( P  < 0·05). When conditioned to a mixture of both silages, no preference was elicited. It is suggested that extensive solubilization and deamination of protein in the lucerne silage may have caused the preference for Westerwolds ryegrass silage and the higher liveweight gains on diets containing higher proportions of Westerwolds ryegrass silage.     

Possibilities of increasing the residual water‐soluble carbohydrate concentration and aerobic stability of low dry‐matter perennial ryegrass silage through additive and cultivar use

Increasing the residual water‐soluble carbohydrate (WSC) concentration in silage may improve the nutritional value but impair aerobic stability. Our aim was to determine whether the residual WSC concentration and aerobic stability of low dry‐matter (<135 g kg^?1) perennial ryegrass silage could be manipulated through the judicious use of additive and cultivar. Seven additive treatments, including three innovative treatments, were compared across four consecutive harvests of the cultivars AberDart (bred to accumulate high concentrations of herbage WSC) and Fennema (control). The standard of fermentation of silage ensiled without additive (untreated) ranged from very bad to excellent. Application of ammonium tetraformate, at 3 and 6 L t^?1, or homofermentative lactic acid bacteria (LAB) alone had an inconsistent effect on the fermentation and aerobic stability, and negligible effect on residual WSC concentration. A mixture of Lactobacillus buchneri and homofermentative LAB was not an effective silage additive, producing generally poorly fermented silage. An antimicrobial mixture of sodium benzoate, sodium propionate, sodium nitrite and hexamethylenetetramine, applied at 2·5 and 5 L t^?1, frequently improved the standard of fermentation, but the effects were subject to the application rate. The high application rate was the most effective additive evaluated at improving the fermentation and increasing residual WSC concentration and consistently produced silage of excellent standard of fermentation. However, the antimicrobial mixture was not effective at protecting against aerobic instability. The effects of additive treatment were largely inconsistent across cultivars. Overall, AberDart had a negligible effect on the silage fermentation, residual WSC concentration and aerobic stability compared with Fennema.     

THE EFFECT OF FEEDING RED CLOVER CONSERVED BY DRYING OR ENSILING ON REPRODUCTION IN THE EWE

Forage diets were prepared from ryegrass (non oestrogenic control) and from red clover as pellets or as unwilted silage. Each diet was fed to separate groups of 20 Border Leicester × Cheviot ewes for three weeks prior to the introduction of the ram, and for two cycles after mating. Subsequently, all three groups of ewes were fed in a similar manner until lambing and the reproductive performance of the ewes was measured. The control diet was prepared by barn drying a primary growth crop of perennial ryegrass, Lolium perenne cv S23. Tetraploid red clover, Trifolium pratense cv. Hungarpoly, was harvested as a first regrowth crop and the pelleted diet prepared by high temperature drying, grinding (2 mm screen) and pelleting. The silage was prepared without wilting. The level of formononetin in the red-clover silage was three times that in the dried red-clover pellets. Compared with the control grass diet, the feeding of red clover in either form significantly reduced (P<0·001) the number of lambs born. The incidence of barrenness was higher (P<0·001) for ewes fed red-clover silage compared with red-clover pellets and the control diet. The rate of twinning was significantly (P<0·001) higher for the ewes fed the control grass diet than for either of the red-clover diets. The resultant lambing percentages were 190,165, and 100% for the control grass, red-clover pellet and red-clover silage treatments. In flock management, both the grazing of red clover and the feeding of red-clover pellets or silage, prior to and during mating, should be avoided.     

The effect of partial replacement of grass silage with fresh grass on rumen fermentation characteristics and rumen outflow rates in cattle

An experiment was designed to examine the effects of partially replacing extensively fermented grass silage with varying proportions of fresh grass (0, 0–33, 0–67 and 100) on rumen fermentation, degradation of dry matter (DM) and rate of outflow of liquid and particulate phases from the rumen with four mature Limousin steers. The fresh grass had a higher pH and water-soluble carbohydrate and lower ammonia-N and lactic acid concentrations than the silage. Partial replacement of silage with fresh grass resulted in a reduction in rumen ammonia concentration, and in the proportion of rumen propionate, i-butyrate and n -valerate and an increase in the proportion of rumen acetate and in both die particulate and liquid outflow rates from the rumen. These changes in rumen fermentation parameters could account for increases in animal performance in situations in which grass silage is partially replaced with fresh grass.     

Changes in temperature and silo gas composition during ensiling, storage and feeding-out grass silage

An experiment is reported in which two bunker silos were filled with about 12 t of ryegrass; one was compacted with a surface pressure of 4·1 kPa and the other was not. Both were instrumented to record temperatures and gas compositions during fermentation and feed-out. Cores of silage (100 mm diameter) were removed from the bunkers and subjected to forced aeration in insulated cylinders. Simple mathematical models were used to simulate CO₂ leakage from the silos and the associated loss of dry matter, and temperature changes during the forced aeration of silage cores. The leakage of CO₂ from the silos, as shown by the fall in CO₂ concentration with time, could be described empirically by an exponential equation and could be simulated with a simple mathematical model. Experimental evidence supported the hypothesis that permeation was the main method of gaseous exchange during fermentation and feed-out, but gas mixing by diffusion and/or convection also occurred within the silos during fermentation. Dry-matter losses by aerobic activity during storage of 120–150 d were conservatively estimated to be about 0·3% and 0·9% for the uncompacted and compacted bunkers respectively. These were considered to be lower than those that could be expected in farm silos, because the sealing was likely to be more thorough. The silages were also more stable, when subject to aeration, than others examined in this laboratory, probably because of high contents of acetic, propionic and butyric acids. Simple mathematical models were of value, but greater sophistication is needed (e.g. multi-compartmental models) to deal comprehensively with the heat and gas flows found in the complex biophysical systems of silage.     

Effects of inoculants and wilting on silage fermentation and nutritive characteristics of red clover–grass mixtures

Various management practices (e.g. wilting, application of silage additives or adding a grass component) can be used to improve silage fermentation of pure red clover (Trifolium pratense L.). Therefore, the aim of this laboratory ensiling study was to investigate the effects of varying proportions of red clover and perennial ryegrass (100/0, 66/33, 33/66, 0/100) on silage quality during two consecutive years. In addition, two wilting levels [target dry matter (DM): 300 vs. 400 g kg^?1] in combination with lactic acid bacteria (LAB) additives were tested. Herbage was ensiled, either untreated or inoculated with homofermentative LAB (low wilted) or homo‐ and heterofermentative LAB (high wilted). In most cases, lactic and acetic acid decreased as the proportions of ryegrass were increased. Data concerning ammonia‐N concentrations showed considerable differences between cuts and years. Silages treated with homofermentative LAB generally had high lactic acid and low final pH, whereas acetic acid and 1,2‐propanediol tended to be higher when homo‐ and heterofermentative LAB were applied. Inoculants had a positive effect on DM losses and ammonia‐N in only a few silages. Wilting decreased DM losses and fermentation acids at most cuts, irrespective of the grass/clover ratio in the herbage mixture. There was a strong year effect on the organic matter digestibility (DOM) of the silages. In conclusion, the optimal strategy for successful silage fermentation of red clover is the ensiling in mixtures with ryegrass. Furthermore, herbage should be wilted to a DM content of about 300–350 g kg^?1. The application of LAB inoculants did not alter the DOM but did improve silage fermentation.     

Silage quality when Moringa oleifera is ensiled in mixtures with Elephant grass,sugar cane and molasses

Fourteen different silages were prepared using mixtures of Moringa (Moringa oleifera), Elephant grass (Pennisetum purpureum cv Taiwan) or sugar cane (Saccharum officinarum). Molasses from sugar cane was used in the amounts of either 10 or 50 g kg^?1 fresh matter (FM) in treatments without sugar cane. A completely randomized design with three replicates of each treatment was used. The silages were prepared in 1800 mL micro silos and opened after 120 d. The presence of Moringa and Elephant grass in the silage changed the pH by ?0·8 and +0·7, respectively (P < 0·001), indicating a favourable effect of Moringa on silage pH. Overall differences were found among treatments for dry matter content, crude protein and acetic acid concentrations, weight loss, CO₂ production and silage pH after spoilage (P < 0·001). Weight loss was proportionately 0·034 and 0·014 in silages with and without sugar cane respectively (P < 0·001). Overall, differences (P < 0·05) were also found for neutral‐detergent fibre and lactic acid concentrations, lactic acid bacteria counts, clostridial counts and time to spoilage of the silages. Treatments containing Moringa had higher lactic acid concentrations (+16 g kg^?1 DM; P < 0·01) compared to treatments without but the presence of Moringa decreased time to spoilage by 67 h (P < 0·05). No differences were found in propionic acid concentration or fungal growth of the silages. It is concluded that Moringa can be used as a component of high quality silages which also contain high concentrations of crude protein.     

The effect of dry feed additives on the nutritive value of silage

Silages were prepared in late September from a mixed crop of perennial ryegrass and white clover with low dry matter and high nitrogen content. Six different treatments were used during ensiling; addition of either molassed sugar beet pulp or rolled barley, at 50 kg and 25 kg (t fresh grass)^?1, formic acid at 51 t^?1 and no additive (control). All silages were well fermented with low levels of ammonia and pH. The addition of rolled barley or sugar beet pulp increased the dry matter content of the silages incrementally and appeared to assist the retention of nitrogen in the silage. Dry matter intakes of silages with 50 kg of barley or sugar beet pulp tonne^?1 were similar to the control silage when fed to wether sheep but at 25 kg t^?1, dry matter intake increased by 0·15 with barley and 0·04 with sugar beet pulp compared to the control. The digestibility of dry matter (DM) and organic matter (OM) were significantly higher than the control for silages treated with formic acid or high levels of barley and sugar beet pulp whereas neutral-detergent fibre (NDF) digestibility did not appear to be significantly affected. All treated silages had a significantly higher metabolizable energy (ME) content than the control, and additions of barley or sugar beet increased the ME content. The ME intakes of all treated silages were also significantly greater than those of the control, and the formic acid-treated and low barley silages were the highest. This appeared to be associated with significantly higher energy digestibility and DM intake. Addition of rolled barley during ensilage resulted in greater nitrogen intake, availability and retention compared to additions of sugar beet pulp. The higher retention with barley silages was associated with a significantly lower proportional loss of absorbed nitrogen in urine, which indicated a more efficient utilization of nitrogen. These differences require further study to determine the mechanisms involved in the interactions between the energy source and herbage protein, both during fermentation and in the rumen.