Study of the effect of soy proteins on the acid-induced gelation of casein micelles

The objective of this research was to understand whether addition of soy protein to milk protein affects the properties of acid-induced casein gels. Different samples were prepared by suspending casein micelles pellets in milk serum containing soy proteins or whey proteins as well as mixtures of the two proteins. Glucono-delta-lactone was added, and the changes in apparent size (in diluted systems) as well as the viscoelastic properties of the mixtures were measured. Size exclusion chromatography was also carried out to characterize the soluble phase of the various mixtures before and after heating. Soy protein affected the gelation of the mixtures; however, not to the same extent as whey proteins, which dominated formation of the network in soy-whey-casein systems. It was concluded that, up to a critical ratio of soy/whey proteins, soy proteins can be incorporated in the mix without a significant change in structure of the casein gels.     

Rheological properties of acid gels prepared from heated pH-adjusted skim milk

Reconstituted skim milk was adjusted to pH values between 6.5 and 7.1 and heated (90 degrees C) for up to 30 min. The skim milk samples were then readjusted to pH 6.7. Acid gels prepared from heated milk had markedly higher G ' values, a reduced gelation time, and an increased gelation pH than those prepared from unheated milk. An increased pH at heating decreased the gelation time, increased the gelation pH, and increased the final G ' of acid set gels prepared from the heated milk samples. There were only small differences in the level of whey protein denaturation in the samples at different pH values, and these differences could not account for the differences in the G ' of the acid gels. The levels of denatured whey protein associated with the casein micelles decreased and the levels of soluble denatured whey proteins increased as the pH at heating was increased. The results indicated that the soluble denatured whey proteins had a greater effect on the final G ' of the acid gels than the denatured whey proteins associated with the casein micelles.     

Rennet-induced aggregation of heated pH-adjusted skim milk

Heated (20-100 °C/0-30 min) skim milks (pH 6.5-7.1) were diluted in buffer (pH 7.0). Rennet was added, and the particle size with time was measured. For all samples, the size initially decreased (lag phase) and then increased (aggregation phase). Milks heated at ≤60 °C had short lag phases and rapid aggregation phases regardless of pH. Milks heated at >60 °C at pH 6.5 had long lag phases and slow aggregation phases. As the pH increased, the lag phase shortened and the aggregation phase accelerated. The aggregation time was correlated with the level of whey protein associated with the casein micelles and with the level of κ-casein dissociated from the micelles. Heated milks formed weak gels when renneted. It is proposed that the milks heated at low pH have whey proteins associated with the casein micelles and that these denatured whey proteins stabilize the micelles to aggregation by rennet and therefore inhibit gelation. In the milks heated at higher pH, the whey proteins associate with κ-casein in the serum and, on rennet treatment, the κ-casein-depleted micelles and the serum-phase whey protein/κ-casein complexes aggregate; however, the denatured whey proteins stabilize the aggregates so that gelation is still inhibited.     

Role of kappa-casein in the association of denatured whey proteins with casein micelles in heated reconstituted skim milk

Reconstituted skim milk at pH from 6.5 to 7.1 was unheated, preheated (68 degrees C/20 min), or heated at 90 degrees C for 20-30 min. On preheating, the size of the casein micelles decreased by about 5-20 nm, with a greater effect at higher pH. The casein micelle size of the heated milk at pH 6.5 increased by about 30 nm when compared to that of the unheated or preheated milk. As the pH was increased before heating, the particle size gradually decreased so that, at pH 7.1, the size was markedly smaller than that for the unheated milk and slightly smaller than that for the preheated milk. High levels (about 85%) of denatured whey protein associated with the casein micelles at pH 6.5, and this level decreased as the pH increased so that, at pH 7.1, low levels (about 15%) were associated with the micelles. Low levels of alphaS-casein and beta-casein were found in the serum regardless of the heat treatment or the pH of the milk. At pH 6.5, low levels (about 10%) of kappa-casein were also found in the milk serum. In the unheated milk, the level of serum kappa-casein increased slightly with increasing pH; in the heated samples, the level of serum kappa-casein increased markedly and linearly with increasing pH so that, at pH 7.1, about 70% of the kappa-casein was in the serum phase. The results of this study indicate that the pH dependence of the levels of serum phase kappa-casein may be responsible for the change in distribution of the whey proteins between the colloidal and serum phases. This is the first report to demonstrate significant levels of dissociation of kappa-casein from the micelles at pH between 6.5 and 6.7, although this dissociation phenomenon is well known on heating milk at high temperatures at pH above 6.7.     

Role of the soluble and micelle-bound heat-induced protein aggregates on network formation in acid skim milk gels

Gel formation was monitored by low amplitude rheometry during acidification at 40 degrees C with 1.5% glucono-delta-lactone in combined milk systems containing soluble and/or micelle-bound heat-induced (95 degrees C/10 min) aggregates of denatured whey proteins and kappa-casein and in heated dairy mixes with varying micellar casein/whey protein ratio (CN/WP). Both soluble and micelle-bound aggregates increased gelation pH and gel strength. Micelle-bound aggregates seemed to modify the micelle surface so that micelles were destabilized at a pH of 5.1 (instead of 4.7), while soluble aggregates precipitated at their calculated pI of approximately 5.3, and initiated an early gelation by interacting with the micelles. Decreasing the CN/WP ratio produced larger aggregates with higher whey protein: kappa-casein ratio, which gave more elastic gels. The specific effects of the micellar and soluble aggregates on gel strength are discussed with respect to their relative proportions in the heated milk.     

Limited enzymatic treatment of skim milk using chymosin affects the micelle/serum distribution of the heat-induced whey protein/kappa-casein aggregates

The effects of heat treatment and limited kappa-casein hydrolysis on the micelle/serum distribution of the heat-induced whey protein/kappa-casein aggregates were investigated as a possible explanation for the gelation properties of combined rennet and acid gels. Reconstituted skim milk was submitted to combinations of 0-67% hydrolysis of the kappa-casein at 5 degrees C and heat treatment at 90 degrees C for 10 min. The protein composition of the ultracentrifugal fractions was obtained by reverse-phase high-performance liquid chromatography (RP-HPLC). The aggregates contained in each phase were isolated by size-exclusion chromatography and analyzed by RP-HPLC and sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Upon heating only, 20-30% of the total kappa-casein dissociated, while 20-30% of the total whey protein attached to the micelles. When heated milk was renneted, little changes were observed in the distribution and composition of the aggregates. Conversely, the heat treatment of partially renneted milk induced the formation of essentially micelle-bound aggregates. The results were discussed in terms of the preferred interaction between hydrophobic para-kappa-casein and denatured whey proteins.     

Interaction between casein micelles and whey protein/κ-casein complexes during renneting of heat-treated reconstituted skim milk powder and casein micelle/serum mixtures

Casein micelles were separated from unheated reconstituted skim milk powder (RSMP) and were resuspended in the serum of RSMP that had been heated, with and without dialysis of this serum against unheated RSMP. Using size-exclusion chromatography, it was found that the soluble complexes of whey protein (WP) with κ-casein in the serum of the heated milk bind progressively to unheated casein micelles during renneting, even prior to the onset of clotting. Similar trends were noted when casein micelles from RSMP heated at pH values of 6.7, 7.1, or 6.3, each with different amounts of WP coating the micelles, were renneted in the presence of soluble WP/κ-casein complexes. No matter what was the initial load of micelle-bound WP complexes, all micelle types were capable of binding additional serum protein complexes during renneting. However, it is not clear that this binding of WP/κ-casein complexes to the micellar surface is a direct cause of the impaired rennet clotting of the RSMP.     

Control of heat-induced aggregation of whey proteins using casein

The ability of alphas1/beta-casein and micellar casein to protect whey proteins from heat-induced aggregation/precipitation reactions and therefore control their functional behavior was examined. Complete suppression (>99%) of heat-induced aggregation of 0.5% (w/w) whey protein isolate (pH 6.0, 85 degrees C, 10 min) was achieved at a ratio of 1:0.1 (w/w) of whey protein isolate (WPI) to alphas1/beta-casein, giving an effective molar ratio of 1:0.15, at 50% whey protein denaturation. However, in the presence of 100 mM NaCl, heating of the WPI/alphas1/beta-casein dispersions to 85 degrees C for 10 min resulted in precipitation between pH 6 and 5.35. WPI heated with micellar casein in simulated milk ultrafiltrate was stable to precipitation at pH>5.4. Protein particle size and turbidity significantly (P相似文献   

Effect of pH on the association of denatured whey proteins with casein micelles in heated reconstituted skim milk

Skim milk was adjusted to pH values between 6.5 and 6.7 and heated (80, 90, and 100 degrees C) for up to 60 min. Changes in casein micelle size, level of whey protein denaturation, and level of whey protein association with the micelles were monitored for each milk sample. Changes in casein micelle size were markedly affected by the pH at heating. At low pH (6.5-6.55), the casein micelle size increased markedly during the early stages of heating, and the size plateaued on prolonged heating. The maximum increase in size was approximately 30-35 nm. In contrast, at high pH (6.7), much smaller changes in size were observed on heating and the maximum increase in size was only approximately 10 nm. An intermediate behavior was observed at pH values between these two extremes. The rate of denaturation of the major whey proteins, alpha-lactalbumin and beta-lactoglobulin, was essentially unaffected by the pH at heating for the small pH changes involved in this study, and the changes in casein micelle size were poorly related to the level of whey protein denaturation. In contrast, the level of denatured whey proteins associating with the micelles was markedly dependent on the pH at heating, with high levels of association at pH 6.5-6.55 and low levels of association at pH 6.7. Changes in casein micelle size were related to the levels of denatured whey proteins that were associated with the casein micelles, although there was a small deviation from linearity at low levels of association (<15%). Further studies on reconstituted and fresh milk samples at smaller pH steps confirmed that the association of whey proteins with the casein micelles was markedly affected by the pH at heating. These results indicate that the changes in casein micelle size induced by the heat treatment of skim milk were a consequence of the whey proteins associating with the casein micelles and that the level of association was markedly influenced by small pH changes of the milk. It was not possible to determine whether the association itself influenced the casein micelle size or whether parallel reactions involving micellar aggregation caused the increase in micelle size as whey protein association progressed.     

Characterization of heat-induced changes in skim milk using asymmetrical flow field-flow fractionation coupled with multiangle laser light scattering

Separation and size measurement of protein particles are a relevant approach to monitor heat-induced changes in skim milk. Unfortunately, no method is currently available at low cost and without excessive preparation of the samples. Therefore, the present study aimed at evaluating the interest of asymmetrical flow field-flow fractionation (AFlFFF) coupled with multiangle laser light scattering (MALLS) for this purpose. Unheated and heated skim milk samples at pH 6.5 and 7.2 were prepared and comparatively analyzed using AFlFFF-MALLS, size exclusion chromatography (SEC-MALLS) and dynamic light scattering. The results showed that AFlFFF could evidence the conversion of the native whey proteins of unheated milk into heat-induced whey protein/κ-casein complexes in the serum phase of milk and possibly on the surface of the casein micelles. The pH-induced changes in the partition of the complexes between the serum and the micellar phases could also be observed. The results therefore showed the interest of AFlFFF-MALLS to monitor the heat-induced changes in particle sizes in skim milk and to separate the different protein components of unheated and heated skim milk.     

Effects of adding low levels of a disulfide reducing agent on the disulfide interactions of β-lactoglobulin and κ-casein in skim milk

Low concentrations of a disulfide reducing agent were added to unheated and heated (80 °C for 30 min) skim milk, with and without added whey protein. The reduction of the β-lactoglobulin and κ-casein disulfide bonds was monitored over time using electrophoresis. The distribution of the proteins between the colloidal and serum phases was also investigated. κ-Casein disulfide bonds were reduced in preference to those of β-lactoglobulin in both unheated and heated skim milk (with or without added whey protein). In addition, in heated skim milk, while the serum κ-casein was reduced more readily than the colloidal κ-casein, the distribution of κ-casein between the two phases was not affected.     

Flavanols and methylxanthines in commercially available dark chocolate: a study of the correlation with nonfat cocoa solids

Intake of flavanols, a subgroup of dietary polyphenols present in many fruits and vegetables, may be associated with health benefits, particularly with reducing the risk of coronary diseases. Cocoa and chocolate products are rich in flavanol monomers, oligomers, and polymers (procyanidins). This study used normal phase HPLC to detect, identify, and quantify epicatechin, catechin, total monomers, procyanidin oligomers and polymers in 14 commercially available chocolate bars. In addition, methylxanthines (theobromine and caffeine) were also quantified. Nonfat cocoa solids (NFCS) were determined both gravimetrically and by calculation from theobromine contents. The flavanol levels of 12 commonly consumed brands of dark chocolate have been quantified and correlated with % theobromine and % NFCS. Epicatechin comprised the largest fraction of total chocolate flavonoids, with the remainder being catechin and procyanidins. Calculated NFCS did not reflect epicatechin (R(2) = 0.41) or total flavanol contents (R(2) = 0.49). Epicatechin (R(2) = 0.96) was a reliable marker of total flavanols, catechin (R(2) = 0.67) to a lesser extent. All dark chocolate tested contained higher levels of total flavanols (93.5-651.1 mg of epicatechin equiv/100 g of product) than a milk or a white "chocolate" (40.6 and 0.0 mg of epicatechin equiv/100 g, respectively). The amount and integrity of procyanidins often suffer in the manufacturing of chocolate, chiefly due to oxidation and alkalinization. In this study, the labeled cocoa content of the chocolate did not always reflect analyzed levels of flavonoids. Increasingly, high % NFCS is being used commercially to reflect chocolate quality. If the flavanol content of chocolate is accepted to be a key determinant of health benefits, then continued monitoring of flavanol levels in commercially available chocolate products may be essential for consumer assurance.     

Correlations between biochemical characteristics and foam-forming and -stabilizing ability of whey and casein hydrolysates

Whey protein and casein were hydrolyzed with 11 commercially available enzymes. Foam properties of 44 samples were measured and were related to biochemical properties of the hydrolysates using statistical data analysis. All casein hydrolysates formed high initial foam levels, whereas whey hydrolysates differed in their foam-forming abilities. Regression analysis using the molecular weight distribution of whey hydrolysates as predictors showed that the hydrolysate fraction containing peptides of 3-5 kDa was most strongly related to foam formation. Foam stability of whey hydrolysates and of most casein hydrolysates was inferior to that of the intact proteins. The foam stability of casein hydrolysate foams was correlated to the molecular weight distribution of the hydrolysates; a high proportion of peptides >7 kDa, composed of both intact casein and high molecular weight peptides, was positively related to foam stability.     

Effects of added sodium caseinate on the formation of particles in heated milk

The effects of heat at temperatures in the range of 80-90 degrees C on mixtures of reconstituted skim milk powder (RSMP) and sodium caseinate have been determined. In the absence of caseinate, the action of heat on RSMP produces soluble complexes of whey proteins and kappa-casein, as well as complexes of whey protein with the casein micelles. When sodium caseinate was added to RSMP at levels of 0.5 and 1.0%, the denaturation of the whey protein and the production of the soluble complexes in the serum were hardly affected, either in rate or in amount. However, during the heating, the caseinate disappeared from the serum. Further studies on model mixtures of the different components showed that it was probable that the bulk of the caseinate associated with the casein micelles during heating, probably by binding inside the surface layer of kappa-casein, because no increase in the diameters of the casein micelles could be observed.     

Mechanisms of the antioxidant activity of a high molecular weight fraction of whey

The antioxidant mechanisms of whey proteins in a Tween 20-stabilized salmon oil-in-water emulsion were investigated. The antioxidant activity of the high molecular weight (HMW) fraction of whey from pasteurized milk was found to increase with concentration, as determined by its ability to inhibit TBARS and lipid peroxide formation. The ability of sulfhydryl-blocked whey to inhibit TBARS formation was reduced 60% compared to the HMW fraction alone at 7 days of storage. HMW fraction was able to scavenge peroxyl radicals, with scavenging decreasing approximately 20% when sulfhydryls were blocked. HMW fraction was able to chelate iron away from the surface of negatively charged BSA-stabilized emulsion droplets, indicating that the whey proteins were able to chelate iron. A better understanding of the mechanisms by which whey proteins inhibit lipid oxidation could increase the use of whey proteins as food antioxidants.     

Acid gelation properties of heated skim milk as a result of enzymatically induced changes in the micelle/serum distribution of the whey protein/kappa-casein aggregates

Changes in the acid gelation properties of skim milk as a result of variations in the micelle/serum distribution of the heat-induced whey protein/kappa-casein aggregates, induced by the combination of heat treatment and limited renneting, were investigated. No dramatic change in the zeta potential or the isoelectric point of the casein micelles was suggested, whether the aggregates were all attached to the casein micelle or not. Fluorescence intensity measurement using 8-anilino-1-naphthalenesulfonic acid (ANS) showed that the heat-induced aggregates were highly hydrophobic. Dynamic oscillation viscosimetry showed that acid gelation using glucono-delta-lactone (GDL) started at a higher pH value in prerenneted milk. However, no change in the gelation profile of skim milk could be related to the proportion of aggregates bound to the surface of the casein micelles. The results support the idea of an early interaction between the serum aggregates and the casein micelles on acidification.     

Aggregation of casein micelles by interactions with chitosans: a study by Monte Carlo simulations

Recently, it was found that the addition of chitosan, a cationic polymer, to whole or skim milk produces the destabilization and coagulation of casein micelles which takes place without modifications in the milk pH or in the stability of most of the whey proteins. In the present work, Monte Carlo simulations are employed to show that the phase separation of casein micelles induced by chitosan can be explained by a depletion mechanism, where an effective attraction between the casein micelles is induced by the presence of chitosan molecules. This interaction is described on the basis of Vrij's model, where the depletion of polymer from the gap between neighboring casein micelles originates an effective attractive interaction that leads to a phase transition. This model, that considers volume restriction effects, accounts for several qualitative and even quantitative aspects of the experimental data for the coagulation of casein through chitosan addition.     

Formation of soluble and micelle-bound protein aggregates in heated milk

The formation of heat-induced aggregates of kappa-casein and denatured whey proteins was investigated in milk-based dairy mixtures containing casein micelles and serum proteins in different ratios. Both soluble and micelle-bound aggregates were isolated from the mixtures heated at 95 degrees C for 10 min, using size exclusion chromatography. Quantitative analysis of the protein composition of the aggregates by reverse phase high-performance liquid chromatography strongly suggested that primary aggregates of beta-lactoglobulin and alpha-lactalbumin in a 3 to 1 ratio were involved as well as kappa-casein, and alpha(s2)-casein in micellar aggregates. The results gave evidence that heat-induced dissociation of micellar kappa-casein was implicated in the formation of the soluble aggregates and indicated that a significant amount of kappa-casein was left unreacted after heating. The average size of the aggregates was 3.5-5.5 million Da, depending on the available kappa-casein or the casein:whey protein ratio in the mixtures. The size and density of these aggregates relative to those of casein micelles were discussed.     

Polyclonal-antibody-based ELISA to detect milk alkaline phosphatase

Polyclonal antibodies (PAb) prepared against bovine milk alkaline phosphatase (ALP) were used to develop a competitive indirect (CI) ELISA. Anti-ALP PAb were specific for milk ALP and did not react with ALP from E. coli or bovine and calf intestinal mucosa. Anti-ALP PAb were 20% cross-reactive with bovine placenta ALP. The anti-ALP antibodies also did not recognize bovine serum albumin, acid glycoprotein, ovalbumin, ferritin, and casein, although some cross-reactivity was observed with whey protein isolate. Anti-ALP PAbs reacted with deglycosylated native ALP, but did not recognize ALP denatured at 100 degrees C in 2% SDS or deglycosylated denatured ALP. When buffered solutions of milk ALP were heated at 70 degrees C, ALP activity decreased at a faster rate than ALP content determined by CI-ELISA. The ELISA differentiated between native and heat denatured ALP. Further studies are warranted to determine if an ELISA can be used to verify pasteurization of fluid milk.