Minimum water exchange spares the requirement for dietary methionine for juvenile Litopenaeus vannamei reared under intensive outdoor conditions

We examined if minimum water exchange could spare dietary methionine (Met) required for maximum growth performance of juvenile Litopenaeus vannamei reared in an intensive outdoor system. Shrimp of 1.98 ± 0.13 g were stocked at 70 animals/m² and reared for 72 days in 50 tanks of 1 m³ under flow‐through (14.4% a day) and static (1.4%–2.9% a day) green‐water conditions at 32.0 ± 3.7 g/L salinity. Five diets with a minimum inclusion of fishmeal supplemented with a dipeptide, dl ‐methionyl‐dl ‐methionine, were formulated to contain increasing levels of Met, 4.8, 6.2, 7.2, 8.1 or 9.4 g/kg (on a dry matter basis). Each of the five diets were fed four times daily to five replicate groups. Dietary Met and water exchange significantly influenced shrimp survival, gained yield, apparent feed intake, food conversion ratio and final body weight (p < .05). Raising shrimp under limited water exchange, i.e., static versus flow‐through spared the dependence on higher levels of dietary Met to maximize shrimp body weight, from 9.4 g/kg to 8.0 g/kg (14.0 and 12.6 g/kg Met+Cys respectively). In an intensive rearing system, a reduction in water exchange is desirable as it leads to a lower need for supplemental dietary Met.     

Fishmeal levels can be successfully reduced in white shrimp (Litopenaeus vannamei) if supplemented with DL‐Methionine (DL‐Met) or DL‐Methionyl‐DL‐Methionine (Met‐Met)

The main objective of this study was to evaluate the effect of methionine supplementation when reducing fishmeal levels in diets for white shrimp (Litopenaeus vannamei). Tested diets consisted of a positive control with 260 g/kg fishmeal (D1), two negative controls with 100 g/kg fishmeal and no amino acid (AA) supplementation (D2) or supplemented with lysine but not methionine (D3), and four additional diets with 100g/kg fishmeal supplemented with increasing levels of DL‐Met (1.0, 2.0 or 3.0 g/kg) (D4, D5, D6) or Met‐Met (1.0 g/kg) (D7). Each diet was fed to four groups of 30 shrimp for 8 weeks at a daily rate of 70 g/kg body weight. Reduction in fishmeal from 260 g/kg down to 100 g/kg did not significantly affect survival rate, feed conversion ratio (FCR), protein efficiency ratio (PER) or protein retention efficiency (PR%) of white shrimp. However, growth performance (final body weight, FBW; weight gain, WG; specific growth rate, SGR) was reduced when dietary fishmeal level was reduced from 260 g/kg (D1) to 100 g/kg without methionine supplementation (D2). The growth performance (FBW, WG and SGR) of shrimp was significantly increased by supplementation of the 100 g/kg fishmeal diet with increasing levels of DL‐Met (p < .05). Same performance as positive control (D1) was achieved with diets containing 100 g/kg fishmeal and supplemented with 3.0 g/kg DL‐Met or 1.0 g/kg Met‐Met. The highest values of growth performance (FBW, WG and SGR) were found in shrimp fed D6 and D7 diets, which were significantly higher than those of shrimp fed D2 and D3 diets (p < .05) but without statistical differences with shrimp fed D1, D4 and D5 diets (p > .05). The highest values of whole‐body and muscle protein contents were found in shrimp fed D1 diet, which were significantly higher than those of shrimp fed all other diets (p < .05). The highest value of intestinal tract proteolytic enzyme activity was found in shrimp fed Met‐Met‐supplemented diet (D7) and followed by the positive control diet (D1) and 3 g/kg DL‐Met‐supplemented diet (D6) (p < .05). The highest values of apparent digestibility coefficients (ADCs) of dry matter and crude protein were found in Met‐Met‐supplemented diet (D7) and followed by the positive control diet (D1) (p < .05). Shrimp fed the D1 diet showed the highest value of total essential amino acid (EAA) and was significantly higher than shrimp fed D2–D3 (p < .05) but without significant difference with shrimp fed D4–D7 (p > .05). In conclusion, results showed that same performance can be achieved with diets containing 260 or 100 g/kg fishmeal supplemented with 3.0 g/kg DL‐Met or 1.0 g/kg Met‐Met. Moreover, supplementation of limiting methionine in low‐fishmeal diets seems to improve the digestive proteolytic activity, improving digestibility of dry matter and protein, and eventually to promote growth of juvenile white shrimp in fishmeal reduction diets.     

Effects of water hyacinth (Eichhornia crassipes) leaf protein concentrate as soybean protein replacement in white shrimp Litopenaeus vannamei (Boone) postlarvae diet

The potential of water hyacinth leaf protein concentrate (WHLPC) as an alternative protein source to soybean meal in formulated diets for the white shrimp Litopenaeus vannamei (Boone) postlarvae, was assessed. Isonitrogenous and isolipidic diets were formulated containing 40% protein and 8% lipid. WHLPC replaced 0%, 25%, 50% and 75% of soybean meal protein in the formulated diets. Twenty postlarval Litopenaeus vannamei weighing 5.0 ± 0.00032 mg were randomly assigned to twelve 30‐L aquarium tanks and were fed experimental diets for 70 days. Results show that the overall biological performance of shrimp in terms of specific growth rate (SGR), protein efficiency ratio (PER), feed efficiency (FE) and survival in treatment receiving the 25% WHLPC replacement is comparable to that of the control diet. Replacement levels beyond 25% exhibited significant depression in terms of growth performance of the shrimp. Collectively, these findings indicate that WHLPC can replace 25% of soybean meal protein in the formulated diets of L. vannamei.     

Replacement of fishmeal by canola protein concentrate in diets fed to rainbow trout (Oncorhynchus mykiss)

A dephytinized protein concentrate prepared from canola seed (CPC) was assessed for nutrient digestibility and performance in rainbow trout (Oncorhynchus mykiss). The apparent digestibility coefficients of CPC were: dry matter, 817 g kg^?1; crude protein, 899 g kg^?1; gross energy, 861 g kg^?1; arginine, 945 g kg^?1; lysine, 935 g kg^?1; methionine, 954 g kg^?1; threonine, 893 g kg^?1. A 9‐week performance trial assessed 7 diets. Fishmeal provided 940 g kg^?1 of the protein in the control diet. Test diets consisted of CPC or water‐washed CPC replacing 500 and 750 g kg^?1 of fishmeal protein; and CPC plus an attractant replacing 500 and 750 g kg^?1 of fishmeal protein. No significant differences in performance were observed (P > 0.05). A subsequent 9‐week performance trial evaluated the effect of adding CPC into compound diets containing fishmeal/soybean meal/corn gluten meal. Five diets were prepared: fishmeal provided 670 g kg^?1 of the protein in the control diet, in the remaining diets CPC was incorporated into commercial‐like trout diets at 100, 200 and 300 g kg^?1 replacement of fishmeal protein, the fifth diet included an attractant in the 300 g kg^?1 replacement diet. No significant differences in performance were obtained (P > 0.05). These studies show that dephytinized canola protein concentrate has potential to replace substantial levels of fishmeal in diets for carnivorous fish without compromising performance.     

Using high protein distiller's dried grain product to replace corn protein concentrate and fishmeal in practical diets for the Pacific white shrimp Litopenaeus vannamei

An 8‐week growth trial was conducted to evaluate the use of a high protein distiller's dried grain (HPDDG, NexPro®, Flint Hills Resources, LP, Wichita, KS) on the growth performance of juvenile Pacific white shrimp Litopenaeus vannamei. In the growth trial, graded levels of HPDDG (0.00, 10.00, 15.00, and 20.00%) were used to replace corn protein concentrate (CPC: 12.60, 6.30, 3.15, and 0.00%) or fishmeal (FM: 17.40, 9.79, 6.00, and 2.21%). A commercially produced open‐feed formulation was also included in the trial as a reference. Each diet was randomly assigned to four replicate groups of 30 shrimp stocked in 0.8 m³ culture tanks. Under green water conditions, in the presence of natural foods, the results indicated that growth performance and feed conversion ratio were not statistically influenced by increasing levels of HPDDG when used to replace CPC. The FM replacement series trial results showed that shrimp fed a diet with 20% HPDDG exhibited significantly decreased trend of biomass. Results of this study demonstrate that HPDDG is a good protein source, and 20% HPDDG can be used to replace CPC in shrimp diets, or up to 15% when replacing FM.     

Demonstration that Feeds Containing <1% Fishmeal Can Support Grow‐out of Large Juvenile Red Drum,Sciaenops ocellatus,and Reduce Nutrient Waste

We conducted a 16‐wk feeding trial with large juvenile red drum, Sciaenops ocellatus. Four diets were randomly assigned to six replicate tanks per treatment. Three isonitrogenous (ca. 44.5% protein) and isolipidic (ca. 14.1% lipid) extruded diets were formulated to compare a fishmeal‐based diet with diets using alternative protein sources. Diet 1 contained 19.60% fishmeal and 21.42% poultry meals as primary protein sources. Two alternative diets were formulated reducing the fishmeal to 0.61% by substituting poultry meals (33.85%) and soybean protein concentrate (11.55% in Diet 2 and 11.70% in Diet 3). Diet 3 also included Allzyme Vegpro® and Allzyme® SSF at 0.04%. Diet 4, a natural diet consisting of chopped cigar minnows, squid, and shrimp, was used as a positive control to compare growth rates of formulated feeds to near maximum growth under these culture conditions. We found that reducing the amount of fishmeal to <1% by using alternative protein sources did not affect the growth rate, survival, or health of red drum but improved assimilation of phosphorus, reduced potential release of P to the environment, and significantly lowered the amount of feeder fish needed in feed. The control diet identified performance benchmarks for future feeds development work.     

Efficacy of crystalline methionine and microencapsulation methionine in diets for Pacific white shrimp Litopenaeus vannamei

An 8‐week growth trial was conducted to evaluate the efficacy of crystalline methionine (C‐Met) or microencapsulated methionine (M‐Met) in practical diets for Pacific white shrimp Litopenaeus vannamei. A high fishmeal reference diet was formulated with 15% fishmeal, and then, soybean meal (SBM) was used to replace 50% fishmeal as a low fishmeal basal diet (7.5% fishmeal). Graded levels (0.1%, 0.15% and 0.2%) of methionine originating from C‐Met or M‐Met were added to the basal diet. Each diet was randomly assigned to three tanks (40 shrimps per tank) in an indoor flow through seawater system. The results showed that the shrimp fed the basal diet with 0.15% or 0.20% methionine originating from 0.375% or 0.5% M‐Met had significantly higher final weight and weight gain as compared to shrimp fed the basal diet. The supplementation M‐Met in the basal diets resulted in increased serum ammonia in shrimp. Hepatopancreas amylase activity of shrimp showed a decreasing trend with increasing methionine supplementation, which is in contrast with the upswing trend in trypsin at pancreatic segment. This study indicated that the diets supplemented with 0.15% or 0.20% of methionine from M‐Met (0.58% or 0.65% of dietary methionine respectively) were effective in improving the nutritional value of SBM‐based diets deficient in methionine (0.48%) for the Pacific white shrimp.     

Evaluation of a novel bacterial biomass as a substitution for soybean meal in plant‐based practical diets for Pacific white shrimp Litopenaeus vannamei

Three growth trials and a digestibility trial were designed to evaluate the efficacy of a novel bacterial biomass (BB) in commercial‐type feed formulation for Pacific white shrimp, Litopenaeus vannamei. In trial 1, the basal diet was supplemented with 0, 60 and 120 g/kg BB to replace soybean meal (SBM). Significant improvement was observed in the survival when BB was incorporated in the diets. However, shrimp fed diets containing 120 g/kg BB exhibited significantly lower weight gain (WG) and higher feed conversion ratio (FCR). To confirm the results from trial 1 and explore the effects of BB supplementation at low levels, the basal diet was incorporated with 0, 10, 20, 40, 60 and 120 g/kg BB to replace SBM in trial 2. Significant reductions in WG, FCR, lipid content of whole body, protein retention efficiency and most amino acids retention efficiency were detected in shrimp fed with diet containing 120 g/kg BB. Trial 3 was designed to elucidate whether the digestible protein is the cause of reduced growth. No improvements in terms of growth performance and FCR were detected in the treatments balanced for digestible protein. Apparent digestibility coefficients of energy, protein and amino acid (AA) for BB were determined using chromic oxide as an inert marker and the 70:30 replacement technique. The energy, protein and individual amino acid digestibility coefficients of BB were significantly lower than those of fish meal (FM) and SBM that were given at the same time. Results of this study indicated that BB can be utilized up to 40 g/kg in shrimp feed without causing a decrease in growth. However, supplementations (≥60 g/kg) of BB can result in negative effects on growth response, FCR and protein as well as amino acids retention efficiency. At the lower levels of inclusion, shrimp performance was improved when BB was supplemented on a digestibility basis; however, at the higher level of inclusion, there was no improvement, indicating there may be other nutrients limiting. Based on enhanced survival in the treatment with BB supplementation in trial 1, further research regarding the immune effects of BB in practical shrimp feed will be necessary.     

Assessing feasibility of replacement of fishmeal with enzyme‐treated feather meal in the diet of juvenile turbot (Scophthalmus maximus L.)

A feeding trial was conducted to examine the potential of enzyme‐treated feather meal (EFM) as a fishmeal substitute in the diet of turbot. Fishmeal (650 g/kg) was incrementally replaced (0, 160, 320, 480, 640 and 800 g/kg) by EFM (0, 80, 160, 240, 320, 400 g/kg) to prepare six experimental diets (Control, EFM8, EFM16, EFM24, EFM32 and EFM40). Diet EFM24 was supplemented with lysine and methionine to form seventh diet (EFM24 + AA). The eighth diet was formulated with 240 g/kg steam‐processed feather meal to replace 480 g/kg fishmeal (SFM24). Eight diets were each fed to triplicate groups of juvenile turbot (37.47 g) in a recirculating aquaculture system for 7 weeks. The results showed that fish fed diet EFM24 grew better than those fed SFM24 (p < .05). The growth performance, body composition and serum biochemical indices of fish fed diet EFM8 were not statistically different compared to the control treatment (p > .05). However, further increase in fishmeal replacement (32%–80%) affected negatively growth, nutrients digestibility, serum biochemical indices and body composition (p < .05). Supplementation of lysine and methionine (EFM24 + AA) significantly improved growth performance and diet utilization compared to EFM24 (p < .05). Altogether results suggested that the EFM could comprise 80 g/kg in a diet for juvenile turbot by concurrent reduction of the fishmeal content by 160 g/kg without lysine and methionine supplementation.     

Spent brewer's yeast as a replacement for fishmeal in diets for giant freshwater prawn (Macrobrachium rosenbergii), reared in either clear water or a biofloc environment

A 90‐day feeding experiment was conducted in order to test spent brewer's yeast as a replacement for fishmeal in diets for giant freshwater prawn (Macrobrachium rosenbergii) reared in either a recirculating aquaculture system (RAS) or a biofloc system. Triplicate groups, each of 20 prawn (6.7 ± 0.03 g), were randomly assigned to 24 identical tanks. Twelve tanks were connected to the RAS, and the other 12 tanks were connected to the biofloc system which were initially supplemented with Bacillus subtilis, molasses and blood meal to achieve a C:N ratio of 20:1. Four iso‐nitrogenous (350 g/kg) and iso‐energetic (19 MJ/kg) diets where 0%, 20%, 40% and 60% of fishmeal protein was replaced by spent brewer's yeast. Neither growth nor survival was affected (p > 0.05) by increasing levels of brewer's yeast. The exception, being fish given 60% replacement with brewer's yeast, reared in biofloc, which displayed a higher (p < 0.05) growth than fish given 40% replacement, reared in clear water. The feed conversion ratio of prawn reared in the biofloc environment was lower than in the clear water. We concluded that spent brewer's yeast represents a possible 60% substitute for fishmeal in giant freshwater prawn diets, especially for prawn reared in a biofloc environment.     

Evaluation of dried fermented biomass as a feed ingredient in plant‐based practical diets for juvenile Pacific white shrimp Litopenaeus vannamei

Two growth trials were designed to evaluate the utilization of dried fermented biomass (DFB) in commercial type feed formulation for Pacific white shrimp, Litopenaeus vannamei. In trial 1, four experimental diets were formulated to utilize increasing levels (0, 25, 50 and 100 g/kg) of spray‐dried fermented biomass (SDFB) as a replacement of fish meal (FM). Results indicated that SDFB can be utilized up to 50 g/kg as a substitution for FM without causing growth depression in shrimp. However, dietary SDFB supplementation at 100 g/kg significantly reduced the weight gain (WG) of shrimp and increased feed conversion ratio (FCR). This reduction in performance is likely due to palatability or nutrient imbalances of the feed. In trial 2, nine experimental diets were formulated with increasing levels (0, 20, 40, 60 and 120 g/kg) of spray‐dried (S) or granular (G) DFB to replace soy protein concentrate (SPC) or SPC + corn protein concentrate (CPC). This allowed the comparison between spray‐dried and ring‐dried products. Ring drying produced a granular product, reducing dust and increasing product particle size. Shrimp fed with diet containing 20 g/kg GDFB performed the best in terms of final mean weight, WG and FCR. Significantly reduced growth and increased FCR were observed in shrimp fed diets containing 60 and 120 g/kg SDFB. Lipid content of whole body was significantly reduced when GDFB was incorporated at 120 g/kg. No significant differences were detected in survival, protein retention efficiency as well as protein and ash contents of the whole shrimp. Results from analysis of covariance indicated that the processing method (covariant) had a significant effect on final mean weight, WG and FCR. In general, shrimp fed with diet containing granular product performed better as compared to those fed with diets utilizing spray‐dried product. GDFB can be utilized in the diets up to 120 g/kg in practical shrimp feeds as a substitute for SPC and CPC without compromising the growth of shrimp. However, a significant reduction in WG was observed in the diets containing 60 and 120 g/kg SDFB. The results in the current study demonstrate that processing changes to produce a granular product produced an improved feed ingredient for shrimp.     

Effect of polysaccharides extracts of algae Ulva rigida on growth,antioxidant, immune response and resistance of shrimp,Litopenaeus vannamei against Photobacterium damselae

This study was carried out to investigate the effect of water‐soluble polysaccharides extract of algae Ulva rigida (WPU) as dietary supplement on growth performance, antioxidant enzyme activity, lysozyme and phenoloxidase activity, and resistance of shrimp (Litopenaeus vannamei) subjected to bacterial infection with Photobacterium damselae. Three replicate groups of shrimp (1.0 g) were fed four diets containing four levels, 0 or control, 0.5, 1 and 1.5 g/kg of WPU for 8 weeks over the growth trial. Thereafter, 30 shrimps from each dietary treatment were infected with bacteria P. damselae to evaluate disease resistance of infected shrimp. The results of this study showed that WPU was effective as a growth promoter for L. vannamei. The best growth rate was observed in shrimp fed 1.5 g/kg of WPU diet. Regarding antioxidant defences, the diets supplemented with three levels of WPU stimulated glutathione peroxidase and catalase activates in experimental shrimps. MDA content of L. vannamei‐fed diet containing WPU 1.5 and WPU 1.0 was lower than WPU 0 and WPU 0. 5 diets. Also, lysozyme and phenoloxidase activities of shrimp receiving WPU at 1.0 and 1.5 level were significantly higher than those fed WPU 0 and WPU 0.5 diets. In addition, using WPU extract in all diets decreased mortality in L. vannamei in a dose‐dependent manner after challenge with P. damselae. These results suggest that incorporation of water‐soluble polysaccharides from green algae U. rigida at 1.5 g/kg doses improves growth and antioxidant activity and enhances the immune responses in shrimp L. vannamei.     

Growth of Atlantic Salmon,Salmo salar,Fed Diets Containing Barley Protein Concentrate

A 16-week feeding trial was conducted with juvenile Atlantic salmon (123 g/fish initial weight) to determine the effects of adding either 11% or 22% barley protein concentrate (BPC) to the diet compared to salmon fed a reference diet (0% BPC) containing mostly fishmeal. The fish were stocked into twelve 0.264 m³ tanks, providing 40 fish per tank with an average density of 18.55 kg/m³. Temperature was maintained at ?12°C and salinity at ?2 ppt using ground water during the study. There were no significant differences in specific growth rate (0.62 basal, 0.60 11% BPC, 0.72 22% BPC), feed conversion (1.06, 1.37, 1.09), weight gain (124.3 g, 113.5 g, 155.3 g), proximate composition of the salmon for lipid (8.4%, 7.8%, 9.8%), protein (17.3%, 17.1%, 18.6%), moisture (71.4%, 72.3%, 69.4%), and ash (6.5%, 6.1%, 6.9%) among any of the treatment groups. Salmon fed the diet containing 22% barley protein concentrate, however, had significantly greater energy retention (34%) compared to the fish fed the other diets (23%–28%). The results of this study indicate that barley protein concentrate is an acceptable feed ingredient for Atlantic salmon that should provide performance similar to fishmeal at inclusion rates below 22%.     

Developing a low fishmeal diet for juvenile Pacific white shrimp,Litopenaeus vannamei,using the nutritional value of FM as the reference profile

An 8‐week feeding trial was conducted to evaluate the effect of fish‐meal replacement on growth performance, antioxidative ability, immune capacity and haemolymph metabolites of Litopenaeus vannamei. A 250 g/kg fish‐meal diet was used as control (Diet 1). Other two diets contained 100 g/kg fishmeal, Diet 2 was supplemented with three indispensable amino acids, and Diet 3 was supplemented with microbalance components and phytase. Weight gain was lower in shrimp fed the Diet 2 than shrimp fed the Diet 1. Feed efficiency, protein efficiency ratio and survival were higher in shrimp fed the Diet 1 than other groups. Glutathione and nitric oxide contents in haemolymph were decreased in shrimp fed the Diet 2, and nitric oxide synthetase, phenoloxidase, acid phosphatase and myeloperoxidase activities showed the similar tendency. In hepatopancreas, antioxidative ability and immune capacity also lower in shrimp fed the Diet 2. In haemolymph, 21 differential metabolites were identified, and 13 metabolism pathways were affected by different diets. Generally, the fishmeal inclusion level could be reduced from 250 g/kg to 100 g/kg without affecting the growth performance of L. vannamei, and meanwhile, the protein utilization efficiency and antioxidative ability of shrimp fed the low fishmeal diets should be more focused on in future studies.     

Availability of essential amino acids,nutrient utilisation and growth in juvenile black tiger shrimp,Penaeus monodon,following fishmeal replacement by plant protein

Two trials with juvenile black tiger shrimp (Penaeus monodon) were undertaken to study the effects of replacing fishmeal by different levels of plant proteins on growth performances and nutrient utilisation of shrimp in semi-intensive conditions (Expt. 1) and on the availability of dietary nitrogen (N) and amino acids (Expt. 2). Five isoproteic diets (on crude protein basis) were formulated to contain 34, 24, 16, 8, or 0% fishmeal, with fishmeal being replaced by a mixture of plant protein (corn gluten meal, wheat gluten, and rapeseed meal). In Expt. 1, the shrimp (initial body weight, IBW 1.5 ± 0.1 g) were reared in earthen ponds for 144 days and fed one of the experimental diets. Apparent digestibility of nutrients and AA were assessed in Expt. 2, using 150 L tanks and shrimp of 12.8 ± 0.4 g IBW. After 144 days in grow-out ponds, shrimp fed the diet with 24% of fishmeal had similar growth as those fed the control diet containing 34% fishmeal (0% replacement). When 50% or more of the fishmeal were replaced, weight gain as well as N and energy gains significantly decreased. Digestibility of dry matter, protein and energy was also significantly lower in all fishmeal-replaced diets. In particular, leucine digestibility decreased by 26% at 100% replacement, which was significantly correlated to an increased incorporation of corn gluten meal. Our data confirm the need to improve our knowledge on AA availability and raw material quality in order to improve fishmeal replacement in P. monodon diets.     

Fungus,Aspergillus niger,fermented groundnut oil cake as a fishmeal alternative in the diet of Penaeus vannamei

Commercial de‐fatted groundnut oil cake (GNC) fermented with the fungus Aspergillus niger was evaluated as a fishmeal alternative in the diet of Penaeus vannamei. A 45‐day growth trail was performed using nine iso‐nitrogenous and iso‐lipidic diets. Untreated/fermented GNC was included at the rate of 0 (control), 25, 50, 75 and 100 g/kg by replacing fishmeal (w/w). Each diet was randomly assigned to triplicate group of 20 shrimps (initial weight of 3.09 ± 0.03 g). Results revealed that shrimp fed with diets having untreated GNC up to 50 g/kg has no significant difference in growth, whereas the inclusion level was enhanced to 100 g/kg with fermented GNC with no deleterious effect. The negative linear trend was found for SGR with increasing the inclusion of both untreated and fermented GNC. The feed and protein efficiency measures, viz. feed conversion ratio, protein efficiency ratio and apparent protein utilization, were better in shrimps fed with diets having fermented GNC than those fed the respective level of untreated GNC. The broken‐line analysis indicated that the inclusion of 72.5 g/kg fermented GNC showed the best FCR. No significant difference was observed in survival (86.67%–96.67%) between the dietary treatments. There was a significant difference in ether extract of shrimp between the treatments, whereas other parameters were not affected. Haemolymph indices showed a significant difference in total protein, glucose, cholesterol and triglycerides between control and test diets. The results conclude fermented GNC, which can be better than untreated one in the diet of shrimp.     

Reduced fishmeal allowance with constant protein input for juvenile channel catfish Ictalurus punctatus

In this study, we evaluated different dietary fishmeal and protein levels on growth performance, intestinal structure and intestinal microbial community of juvenile channel catfish, Ictalurus punctatus. A total of 1800 fish distributed into 36 tanks were fed with nine different diets containing three protein levels (300, 330 and 360 g/kg) with three fishmeal (FM) levels (0, 30 and 60 g/kg) for 90 days. The results showed that significant interactions between the protein level and FM level were observed in final weight (FW), weight gain (WG), Na⁺, K⁺‐ATPase and alkaline phosphatase (AKP) activities. The significant lowest FW, WG, Na⁺, K⁺‐ATPase and AKP activities were observed in fish fed with no fishmeal and 300 g/kg protein dietary while the highest were shown in 60 g/kg fishmeal and 330 g/kg protein treatment. Additionally, the microvillar length of the mid‐intestine in catfish was significantly affected by the interaction between dietary protein level and fishmeal level. The intestinal samples were dominated by three major phyla, Firmicutes, Proteobacteria and Fusobacteria. Genera Romboutsia and Turicibacter accounted for probably 800 g/kg of the phylum Firmicutes; meanwhile, genus Cetobacterium represented more than 900 g/kg of the phylum Fusobacteria. In conclusion, this study indicated that channel catfish juveniles can be fed with a practical diet without fishmeal as long as the protein level increased to 360 g/kg; however, if the percentage of dietary protein was 300 g/kg, it seemed that fishmeal need to be supplied as a protein source.     

Proteome modifications of Pacific white shrimp (Litopenaeus vannamei) muscle under biofloc system

The objective of the study was to examine the effects of biofloc technology on the muscle proteome of Litopenaeus vannamei. Two biofloc treatments and one control were compared: biofloc‐based tanks under zero‐water exchange fed with 150 g/kg crude protein (BF15), or with 250 g/kg crude protein (BF25) diets, and clear water tanks with 50% of daily water exchange stocked with shrimp fed with similar amount of a 250 g/kg crude protein diet, referred to as control. The shrimp (5.28 ± 0.42 g) were divided into the 300‐L fibreglass tanks (water volume of 200 L) at a density of 35 shrimp per tank and were cultured for 35 days. The biofloc groups displayed better growth and survival compared to the control. The muscle tissue from the control and BF25 groups was subjected to proteomic analysis. Lactate dehydrogenase, enolase, arginine kinase, mitochondrial ATP synthase subunit alpha, mitochondrial ATPase inhibitor factor 1 precursor, serpin 3 and myeloid differentiation factor 88 had an increased abundance in the BF25 group, while myosin heavy chain type 1 and myosin heavy chain type 2 showed a decreased abundance. The results indicate that biofloc technology could alter the expression of proteins involved in structure, metabolism and immune status of cultured shrimp.     

Use of soy protein concentrate in practical diets for Pacific white shrimp (Litopenaeus vannamei) reared under field conditions

The objective of this study was to evaluate the production response of Litopenaeus vannamei fed with production diets containing increasing percentages (0, 4, 8, and 12%) of soy protein concentrate (SPC). The diets were commercially produced and evaluated in outdoor tanks and 0.1-ha production ponds. In the outdoor green water tank system, the four test diets and a commercial reference diets were offered to juvenile shrimp (1.0 g initial weight) reared over a 10-week period at a stocking density of 30 shrimp per tank. At the conclusion of the tank trial, there were differences in final weight (13.5–15.0) biomass (399 g–432 g), and FCR (1.17–1.28) with the reference diet generally producing significantly better results than the test diets albeit there were no significant differences among the SPC test diets. In addition, the test diets were evaluated in 0.1-ha ponds using four replicates per diet. Nursed juvenile shrimps (0.013 g initial weight) were stocked at 35 shrimp m⁻² and were cultured under standardized pond production conditions for 18 weeks. At the conclusions, net yield (4,190–5,051 kg/ha), final mean weight (13.5–15.7 g), survival (86.7–93.3%), and FCR (1.3–1.59) were evaluated with no significant differences between dietary treatments. The results from this study demonstrated that SPC inclusion up to 12% SPC in soybean-based diet can be used in commercial feed formulations for L. vannamei without causing negative effect on growth, feed conversion, survival and net yield.     

Effects of complete fish meal replacement by rice protein concentrate with or without lysine supplement on growth performance,muscle development and flesh quality of blunt snout bream (Megalobrama amblycephala)

An 8‐week feeding trial was conducted to evaluate the effects of fish meal (FM) replacement by rice protein concentrate (RPC) with supplementation of microcapsule lysine (ML) or crystalline lysine (CL) on growth performance, muscle development and flesh quality of blunt snout bream. Four isonitrogenous and isoenergetic diets were formulated, including FM diet (containing 50 g/kg FM), RPC diet (FM replaced by RPC), MRPC diet (FM replaced by RPC with ML supplementation) and CRPC diet (FM replaced by RPC with CL supplementation). Fish fed FM diet had significantly higher weight gain, feed efficiency, protein efficiency ratio and nitrogen and energy utilization than that of RPC group, but showed no statistical difference with other treatments. In addition, fish fed RPC diet showed higher muscle fibre frequency in the 20‐ to 50‐μm class but lower >50‐μm class and higher cooking loss than that of the other groups. Furthermore, no significant difference was found in whole‐body proximate compositions, frequency distribution of <20‐μm‐diameter fibres, texture, muscle content, collagen, pH 24 hr post‐mortem and sensory quality. The results showed that RPC supplemented with ML or CL could replace fishmeal without any adverse effects on growth performance and flesh quality for blunt snout bream.