Rapid screening method for aflatoxins and zearalenone in corn.

The methanol-water extraction system used in AOAC Method II for aflatoxins extracts both the aflatoxins and zearalenone from corn. Using this methanol-water extraction system as a base, a rapid screening procedure has been developed for these mycotoxins. The methanol-water extract is defatted with hexane and the pigments are precipitated with copper carbonate. The aflatoxins and zearalenone are subsequently extracted into chloroform and are then detected by half-plate TLC. An elapsed time of about 1 hr is required to analyze 1 sample. The sensitivity of the method is about 2 mu-g/kg for aflatoxin B-1 and 100 mu-g/kg for zearalenone.     

Quantitative fluorodensitometric determination and survey of aflatoxins in nutmeg.

A study is presented for the quantitative fluorodensitometric analysis of aflatoxins in spices, in particular nutmeg (Semen myristicae). Samples were extracted with chloroform, followed by silica gel column cleanup according to the AOAC officail first action method, 26.019(a), and by 2-dimensional thin layer chromatography according to the antidiagonal technique. The method includes a confirmatory test for aflatoxins by hemiacetal formation. The concentrations of aflatoxins in samples were determined by measurement of the fluorescent intensities of the separated aflatoxin spots from sample and standards on the same chromato-plate with a reflectance flying-spot sensitometer. With such a technique, a coefficient of variation value of 5.22 plus or minus 1.24% (P = 99%) was calculated for a series of 5 standard B-1 spots and averaged for 13 TLC plates, demonstrating the precision of the chromatographic and densitometric procedures. An average recovery of 108.4 plus or minus 5.8% (P = 95%) was obtained for 11 spiked nutmeg extracts (5.0-20.0 mu-g B-1 added/kg), whereas an average recovery of 92.6 plus or minus 4.9 (P = 95%) was established for 13 spiked nutmeg samples (5.0-20.0 mu-g B-1 added/kg). The coefficient of variation of the complete analytical procedure for ground nutmeg was 8.80%. In a survey on the occurrence of aflatoxins in 40 commercial nutmeg samples (covering 12 different brands) in The Netherlands, aflatoxins were detected in 30 ground samples (32 ground samples analyzed) in concentrations ranging from 1.0 to 23.2 mu-g B-1/kg or 2.7 to 36.5 mu-g B-1 + B-2 + G-1 + G-2/kg, whereas no aflatoxins were present in whole nutmeg kernels (8 samples analyzed). The lowest level of detection was 1.0 mu-g B-1/kg. In addition, 50 commercial spices consisting of 19 different types of commodities other than nutmeg wer assayed for aflatoxins according to the same procedure. No aflatoxins were detected in these samples, with the exception of 1 sample of bay leaf which contained 5.1 mu-g B-1/kg.     

Caffeine as main interfering compound in radioimmunoassay of aflatoxin B1 in coffee samples

The content of caffeine in coffee extracts prepared for radioimmunoassay of aflatoxin B1 was determined by gas chromatography. The extracts from coffee beans and decaffeinated coffee contained 1.76-4.60 and 0.71-0.85 g caffeine/kg, respectively. These concentrations of caffeine caused false results in radioimmunoassay of aflatoxin B1 in the range 1.0-2.8 micrograms/kg for coffee beans and 0.3-0.4 micrograms/kg for decaffeinated coffee.     

Use of isotope-labeled aflatoxins for LC-MS/MS stable isotope dilution analysis of foods

Aflatoxins are a group of very carcinogenic mycotoxins that can be found on a wide range of food commodities including nuts, cereals, and spices. In this study, the first LC-MS/MS stable isotope dilution assay (SIDA) for the determination of aflatoxins in foods was developed. The development of this method was enabled by easily accessible isotope-labeled (deuterated) aflatoxins B2 and G2, which were synthesized by catalytic deuteration of aflatoxin B1 and G1, purified, and well-characterized by NMR and MS. All four aflatoxins of interest (B1, B2, G1, and G2) were quantified in food samples by using these two labeled internal standards. The response factors (RF) of the linear calibrations were revealed to be matrix independent for labeled aflatoxin B2/aflatoxin B2 and labeled aflatoxin G2/aflatoxin G2. For labeled aflatoxin B 2/aflatoxin B 1 and labeled aflatoxin B2/aflatoxin G1 matrix-matched calibration was performed for the model matrices almonds and wheat flour, showing significant differences of the RFs. Limits of detection (LOD) were determined by applying a statistical approach in the presence of the two model matrices, yielding 0.31 microg/kg (aflatoxin B1), 0.09 microg/kg (aflatoxin B2), 0.38 microg/kg (aflatoxin G1), and 0.32 microg/kg (aflatoxin G2) for almonds (similar LODs were obtained for wheat flour). Recovery rates were between 90 and 105% for all analytes. Coefficients of variation (CV) of 12% (aflatoxin B1), 3.6% (aflatoxin B2), 14% (aflatoxin G1), and 4.8% (aflatoxin G2) were obtained from interassay studies. For further validation, a NIST standard reference food sample was analyzed for aflatoxins B1 and B2. The method was successfully applied to determine trace levels of aflatoxins in diverse food matrices such as peanuts, nuts, grains, and spices. Aflatoxin contents in these samples ranged from about 0.5 to 6 microg/kg.     

Survey of aflatoxins, ochratoxin A, zearalenone, and sterigmatocystin in some Brazilian foods by using multi-toxin thin-layer chromatographic method

A previously published method for ochratoxin A was evaluated and proved appropriate for simultaneous determination of aflatoxins, ochratoxin A, sterigmatocystin, and zearalenone, with considerable savings in time and reagent costs. The detection limits were 2, 5, 15, and 55 micrograms/kg, respectively. The recoveries and coefficients of variation obtained with artificially contaminated samples were 91-101% and 0-16% for aflatoxin B1, 98-117% and 0-17% for sterigmatocystin, and 96-107% and 0-17% for zearalenone, respectively. The coefficients of variation for naturally contaminated samples (aflatoxins in rice and ochratoxin A in beans) ranged from 0 to 8%. The method was used to survey 296 samples that included 10 cultivars of dried beans, 8 types of corn products, 3 types of cassava flour, and both polished and parboiled rice between May 1985 and June 1986 in Campinas, Brazil. Only aflatoxin B1 (9 samples, 20-52 micrograms/kg), aflatoxin G1 (4 samples, 18-31 micrograms/kg), and ochratoxin A (5 samples, 32-160 micrograms/kg) were found. The average contamination percentage was 4.7%; beans showed the highest (6.6%) and rice showed the lowest (3.3%) incidence rates. Zearalenone and sterigmatocystin were not detected. Positive samples were confirmed by chemical derivatization, corroborated by development in 3 solvent systems.     

Mycotoxin contamination of dietary and medicinal wild plants in the Eastern Cape Province of South Africa

Nineteen dietary and 30 medicinal wild plants used by residents of the Eastern Cape Province of South Africa were investigated for the presence of fumonisin B1 and aflatoxin B1. The plants were extracted in water, and cleanup was undertaken on immunoaffinity cartridges; analysis was by HPLC using fluorescence detection. None of the plant extracts contained detectable levels of aflatoxin B1; however, eight plants, four dietary and four medicinal, were positive for fumonisin B1 at levels ranging from 34 to 524 microg/kg and from 8 to 1553 microg/kg, respectively. The presence of fumonisin B1 was confirmed by LC-MS/MS using positive ion electrospray ionization. Fumonisin B1 provided characteristic fragment ions at m/z 704, 686, 546, 528, 370, and 352 corresponding to sequential loss of H2O and tricarboxylic acid moieties from the alkyl backbone. These results indicate that exposure to fumonisin B1 is much more widespread than initially thought and is the first report of mycotoxin contamination in South African medicinal and dietary wild plants.     

Negative ion chemical ionization mass spectrometric method for confirmation of identity of aflatoxin B1: collaborative study

An interlaboratory study of a negative ion chemical ionization mass spectrometric (MS) confirmation procedure for aflatoxin B1 was conducted in laboratories in the United States, England, and West Germany. Twelve partially purified, dry film extracts from naturally and artificially contaminated roasted peanuts, cottonseed, and ginger root containing varying quantities of aflatoxin B1 were distributed to the participating laboratories. The extracts required additional cleanup before MS analysis, using either an acidic alumina column and preparative thin layer chromatography (TLC) or a 2-dimensional TLC procedure. Recovery of purified aflatoxin B1 was influenced by the degree of recovery of sample from acid alumina and/or the TLC plate and incomplete elution of aflatoxin B1 from silica gel. Factors affecting MS confirmation included the purity and recovery of aflatoxin and MS instrument sensitivity. Aflatoxin B1 identity was confirmed in 19.5, 90.9, and 100% of samples containing less than 5, 5-10, and greater than 10 ng aflatoxin B1/g product, respectively, by solid probe introduction using full mass scans. The MS method has been adopted official first action.     

Simultaneous determination of chloramphenicol and aflatoxin M1 residues in milk by triple quadrupole liquid chromatography-tandem mass spectrometry

A reliable, rapid, and sensitive liquid chromatography-tandem mass spectrometry (LC-MS/MS) method for simultaneous determination of chloramphenicol and aflatoxin M(1) in milk has been developed. This method includes simple extraction of sample with acetonitrile, separation on a MGIII-C(18) column using 5 mM ammonium acetate aqueous solution/methanol (60:40, v/v) as mobile phase, and MS/MS detection using multiple reaction monitoring mode. The method was validated according to Commission Decision 2002/657/EC. The limits of detection (LODs) were 0.05 μg/kg for chloramphenicol and 0.005 μg/kg for aflatoxin M(1.) The limits of quantification (LOQs) were 0.2 μg/kg for chloramphenicol and 0.02 μg/kg for aflatoxin M(1). The recovery values ranged from 88.8% to 100.6%, with relative standard deviation lower than 15% in all cases, when samples were fortified at three different concentrations. The decision limits (CCα) and detection capability (CCβ) of the method were also reported. This method has been successfully applied for simultaneous analysis of chloramphenicol and aflatoxin M(1) residues in milk from local supermarkets in China.     

Gas-liquid chromatographic determination of vinyl chloride in alcoholic beverages, vegetable oils, and vinegars.

Vinyl chloride in foods is determined by gas-liquid chromatography either by direct injection of vinegars and alcoholic beverages or by headspace analysis of vegetable oils. The lower limit of detection is 10-15 ng/ml for direct injection and 1-10 ppb for headspace analysis. Confirmation by gas chromatography-mass spectrometry, single ion monitoring at m/c 62, is possible at 50 ppb for either method. The levels of vinyl chloride bottles were 0.0-1.6 mu-g/ml for alcoholic beverages, 0.0-8.4 mu-g/ml for vinegars, and 0.3-3.3 ppm for peanut oil.     

Extraction and thin layer chromatography of aflatoxin B1 in mixed feeds

A method was developed for the determination of aflatoxin B1 in commercially prepared feeds. The method incorporates methylene chloride and citric acid solution extraction, cleanup on a small silica gel column, and thin layer chromatography for quantitation. Commercial turkey starter, catfish chow, medicated pig starter, broiler finisher, rabbit chow, horse feed, rat chow, and dog chow were investigated. The feeds were spiked with naturally contaminated corn at 4 different levels of aflatoxin B1 (16-130 microgram/kg). Three assays were run on each of the 32 combinations of feed and levels of aflatoxin. Mean recoveries were 85.9-92.8% at levels of 16.5, 32.9, 65.8, and 131.6 micrograms/kg. The relative standard deviation per assay was 18.6%. This method is more rapid and less involved than most previously published methods for mixed feeds.     

一株黄曲霉拮抗菌的筛选、鉴定及特性研究

为获得拮抗黄曲霉和降解黄曲霉毒素的生物防治菌株,以烟台黄曲霉污染区域土壤为材料,采用稀释分离法和琼脂扩散法,筛选到一株对黄曲霉有抑制作用且可降解黄曲霉毒素的菌株Y-17-3。根据菌株的形态学特征、生理生化试验结合16S rDNA基因序列分析和系统发育树构建,确定菌株 Y-17-3 为空气芽孢杆菌(Bacillus aerius)。该菌株发酵液经硫酸铵沉淀的抗菌活性及稳定性试验,发现70%饱和硫酸铵沉淀的蛋白粗提物抑制黄曲霉活性最强,可降低黄曲霉孢子的萌发率,抑制菌丝的生长和菌丝球的形成,且该蛋白粗提物对温度、pH值和蛋白酶敏感。菌株Y-17-3能够降解黄曲霉毒素B₁,培养6 d时的降解率达90%。综上,所分离的空气芽孢杆菌Y-17-3菌株能够通过产生拮抗蛋白来抑制黄曲霉生长,且具有较强的黄曲霉毒素降解能力,在农业生物防治领域具有一定的应用前景。     

Comparative study of three different methods for the determination of aflatoxins in tahini

Aflatoxins spiked at three different levels (6.5, 13.0, and 19.5 microg/kg) in tahini, a sesame butter, were analyzed by using three different methods: high-performance liquid chromatography (HPLC), fluorometry, and enzyme-linked immunosorbent assay (ELISA). An immunoaffinity column was used for cleanup and purification of extracts prior to detection by HPLC and fluorometry. All methods were statistically evaluated for accuracy, precision, and simple correlations. Additionally, 14 tahini samples randomly obtained from Turkish retail markets were analyzed using an immunoaffinity column cleanup procedure coupled with the HPLC detection method. The fluorometric determination method involving an immunoaffinity column cleanup step was found to be highly correlated with the HPLC method (r = 0.978). Both methods were found to be effective due to their high recoveries and low variance for the prediction of total aflatoxin contamination in tahini samples. The ELISA method, due to its high variation in replicates, was found to be applicable only as a screening method. The survey study demonstrated the need for control of aflatoxin contamination of foodstuffs involving sesame seeds as an ingredient.     

Optimum methanol concentration and solvent/peanut ratio for extraction of aflatoxin from raw peanuts by modified AOAC method II

The amount of aflatoxin extracted from raw peanuts by using the water-slurry modification of AOAC Method II was determined for 49 different combinations of methanol concentrations and solvent/peanut ratio. Results indicate that the amount of aflatoxins B1 and B2 extracted from raw peanuts is a function of both methanol concentration and solvent/peanut ratio, and a cubic equation was developed, using regression techniques, to describe the combined effects. From the functional relationship, the predicted methanol concentration and solvent/peanut ratio that extracts the most aflatoxin B1 was computed to be 60.0% and 10.8 mL solvent/g peanuts, respectively. This combination extracted 12.1% more aflatoxin than did AOAC Method II.     

Simple, rapid cleanup method for analysis of aflatoxins and comparison with various methods

A method is described for simple and rapid determination of aflatoxins in corn, buckwheat, peanuts, and cheese. Aflatoxins were extracted with chloroform-water and were purified by a Florisil column chromatographic procedure. Column eluates were concentrated and spotted on a high performance thin layer chromatographic (HPTLC) plate, which was then developed in chloroform-acetone (9 + 1) and/or ether-methanol-water (94 + 4.5 + 1.5) or chloroform-isopropanol-acetone (85 + 5 + 10). Each aflatoxin was quantitated by densitometry. The minimum detectable aflatoxin concentrations (micrograms/kg) in various test materials were 0.2, B1; 0.1, B2; 0.2, G1; 0.1, G2; and 0.1, M1. Recoveries of the aflatoxins added to corn, peanut, and cheese samples at 10-30 micrograms/kg were greater than 69% (aflatoxin G2) and averaged 91%, B1; 89%, B2; 91%, G1; 78%, G2; and 92%, M1. The simple method described was compared with the AOAC CB method, AOAC BF method, and AOAC milk and cheese method. These methods were applied to corn, peanut, and cheese composites spiked with known amounts of aflatoxins, and to naturally contaminated buckwheat and cheese. Recoveries were much lower for the BF method compared with our simple method and the CB method.     

Development of milk powder reference materials certified for aflatoxin M1 content (Part II): Certification of milk powder RM 283

The development of a full cream milk powder reference material, certified for its aflatoxin M1 content (target concentration: 0.1 microgram/kg), is described. The material (RM 283) was prepared and certified within the Reference Material Programme of the Community Bureau of Reference, along with other members of a series of milk powder reference materials. Homogeneity, evaluated by determining the aflatoxin M1 content of 30 units, was found to be acceptable (coefficient of variation of analysis results: 9.1%); stability has been demonstrated in a long-term study. The certification exercise involved 7 laboratories. Calibration, control of recoveries, blank values, and independence of the replicate measurements were emphasized. All sets of results of the certification exercise were accepted for statistical evaluation. A certified value for the aflatoxin M1 content: 0.09(+0.04)(-0.02) micrograms/kg was derived. The certification of RM 283 completes the series of 4 milk powder reference materials having certified aflatoxin M1 contents.     

Determination of aflatoxins in vegetable oils

A simple method is proposed for determination of aflatoxins in vegetable oils. The method was successfully applied to both crude and degummed oils. The oil sample, dissolved in hexane, was applied to a silica column and washed with ether, toluene, and chloroform; aflatoxins were eluted from the column with chloroform-methanol (97 + 3). As quantitated by thin layer chromatography and liquid chromatography, the oils analyzed contained aflatoxin B1 at levels of 5-200 micrograms/kg. Recoveries of aflatoxin B1 standards added to aflatoxin-free oils were between 89.5 and 93.5%, with coefficients of variation of 6.3-8.0%.     

Development of an immunoassay-based lateral flow dipstick for the rapid detection of aflatoxin B1 in pig feed

The aim of this work was to develop an immunoassay-based lateral flow dipstick for the rapid detection of aflatoxin B(1) in pig feed. The test consisted of three main components: conjugate pad, membrane, and absorbent pad. The membrane was coated with two capture reagents, that is, aflatoxin B(1)-bovine serum albumin conjugate and rabbit anti-mouse antibodies. The detector reagent consisted of colloidal gold particles coated with affinity-purified monoclonal anti-aflatoxin B(1) antibodies, which saturated the conjugate pad. A comparison of several extraction methods for the pig feed matrix is presented. A mixture of methanol/water (80:20, v/v) gave the best recoveries. After sample extraction and dilution, the dipstick was put in the sample solution at the conjugate pad side and developed for 10 min. Analyte present in the sample competed with the aflatoxin B(1) immobilized on the membrane for binding to the limited amount of antibodies in the detector reagent. Thus, the line color intensity of an aflatoxin B(1)-positive dipstick is visually distinguishable from that of an aflatoxin B(1)-negative sample. The visual detection limit for aflatoxin B(1) is 5 microg/kg. The major advantages of this one-step striptest are that results can be obtained within 10 min and that all reagents are immobilized on the lateral flow dipstick.     

Automated liquid chromatographic determination of aflatoxin M1 in milk using on-line dialysis for sample preparation

A procedure has been developed for the automated isolation of aflatoxin M1 from decreamed milk. The method uses on-line stopped flow dialysis and subsequent trace enrichment on a reverse-phase column. After a back-flush to the analytical liquid chromatography column, aflatoxin M1 is determined with fluorescence detection. Fully automated analysis is possible with reproducible dialysis recoveries above 50% (CV = 7.5%, n = 25 at the 50 ng/kg level) and determination levels of 20 ng/kg within 20 min.     

Effect of pressure cooking on aflatoxin B1 in rice

The effect of pressure cooking on aflatoxin residues in polished rice was conducted to determine reduction of aflatoxin and mutagenic potentials. Three rice lots consisting of naturally contaminated, A. parasiticus-infested, and aflatoxin-spiked rice were steamed by ordinary and pressure cookers after they were washed with water. They were chemically analyzed for aflatoxins using a silica solid phase extraction tube and high-performance liquid chromatography (HPLC)-fluorescence detection (FD), and the presence of aflatoxin residues was confirmed using HPLC-electrospray ionization (ESI)-mass spectrometry (MS). An in vitro mutagenicity test with Salmonella typhimurium TA100 was employed to verify the results based on chemical analyses. The aflatoxin loss (78-88%) was notable after pressure cooking, and the reduction of aflatoxin-induced mutagenic potential (68-78%) was in good agreement with the HPLC results. It can be concluded that Koreans are safe from the aflatoxin-related risk if a pressure cooker is employed for cooking rice. The average Korean daily intake of aflatoxin through the consumption of staple rice would fall to 0.15 ng/kg bw/day, which would not exceed the established tolerable daily intake (0.40 ng/kg bw/day).     

Development and application of solvent-free extraction for the detection of aflatoxin M1 in dairy products by enzyme immunoassay

The official methods for the quantification of aflatoxin M1 in dairy products (cheese and yogurt) include extraction into dichloromethane or chloroform, evaporation of the solvent, partitioning of the reconstituted residue with hexane, and subsequent analysis. To secure a rapid and inexpensive screen for aflatoxin M1 contamination, a sensitive competitive ELISA, using a rabbit polyclonal antibody, was developed for measuring aflatoxin M1 in milk and used in a comparative study for measuring the extraction efficiency of aflatoxin M1 in aqueous or organic solvent buffers using yogurt samples. An aqueous sodium citrate solution was found to be suitable for extracting aflatoxin M1, thus eliminating the need for organic solvents. The citrate extraction proved to be efficient (recovery ranged from 70 to 124%) in fortified samples of very different kinds of dairy products, including yogurt and six types of cheese. Fourteen yogurt and cheese samples were extracted with citrate solution and analyzed by ELISA. A good correlation was observed (y=0.95x-0.59, r2=0.98) when the data were compared with those obtained through the official method, across a wide range of aflatoxin M1 contaminations (10-200 ng/kg).