Utilization by growing and finishing pigs of raw soybeans of low Kunitz trypsin inhibitor content

Three trials were conducted to compare acceptance and utilization by growing and finishing pigs of diets containing supplemental protein from either heated, solvent-extracted soybean meal (SBM), raw low-Kunitz trypsin inhibitor soybean (LT) or raw commercially grown Williams cultivar soybean with high Kunitz trypsin inhibitor content (HT). In Trial 1, 36 crossbred pigs, averaging 7 kg in weight, were fed 1) corn-SBM, 2)corn-LT or 3) corn-HT diets for 28 d. Diets were formulated to be isolysinic and to have similar calorie:lysine ratios. Average daily gain and gain/feed were higher (P less than .01) for pigs fed the corn-SBM diet than for pigs fed the corn-LT diet; average daily gain and gain/feed were higher (P less than .01) for the corn-LT diet than for the corn-HT. Average daily feed intake did not differ (P greater than .05) among diets. In Trial 2, 48 crossbred pigs averaging 67 kg were fed diets similar to those in Trial 1 but with lower lysine values. The daily gain (.95 kg) of pigs fed the corn-SBM diet was greater (P less than .05) than for pigs fed the corn-LT diet (.87 kg), which in turn was greater (P less than .05) than for the pigs fed the corn-HT diet (.83 kg). Daily feed intake (kg) and gain/feed were 3.27 and .291, 2.97 and .293, and 3.07 and .270, respectively, for pigs fed the corn-SBM, corn-LT and corn-HT diets. In Trial 3, 18 castrate male pigs averaging 12.4 kg were fed cornstarch-based diets with either SBM, LT or HT as the source of protein.(ABSTRACT TRUNCATED AT 250 WORDS)     

Nutritional value of quality protein maize for starter and finisher swine.

Growth trials with starter (n = 120, 6.8 kg initially, 28 d of age, Exp. 1) and finisher (n = 70, 59 kg initially, Exp. 2) pigs were conducted to compare quality protein maize (QPM, .40% lysine) and normal corn (.31% lysine) in simple corn-based diets containing the same levels of soybean meal. In Exp. 1, pig performance was similar (P greater than .10) on all diets, regardless of the level of soybean meal, suggesting that QPM and normal corn have similar feeding value in lysine-adequate (.99 to 1.11%) diets. In Exp. 2, less soybean meal was needed in QPM than in normal corn diets to maximize performance; increasing soybean meal from 10.8 to 13.8% improved rate (P less than .05) and efficiency (P less than .01) of gain of pigs fed normal corn diets but had no effect on performance of pigs fed QPM diets. A QPM-based diet containing 6% soybean meal and supplemental lysine and tryptophan failed to maximize feed efficiency, but growth rate was equal to that obtained on the normal corn diet with 13.8% soybean meal. The apparent fecal digestibility of GE and ileal digestibility of N were similar for QPM and normal corn, but apparent ileal digestibility of most essential amino acids was slightly higher for QPM (Exp. 3). Experiment 4 compared apparent digestibilities of QPM, conventional opaque-2 corn and two high-protein corns. Digestibilities differed (P less than .05) among the corns, but the absolute differences were small and were likely due to differences in amino acid content of the corns.(ABSTRACT TRUNCATED AT 250 WORDS)     

Effect of diet particle size and feeding of H2-receptor antagonists on gastric ulcers in swine

Four experiments were conducted to evaluate the effect of diet and the administration of H2-antagonists in feed on gastric ulcer formation and performance of growing-finishing swine. Pigs receiving a finely ground diet (less than lmm) grew faster (.73 vs .68 kg/d, P less than .01) and had better feed utilization (3.47 vs 3.76, P less than .01) than pigs receiving a cracked corn-based diet. Incidence of ulcers in the esophageal region of the stomach of pigs fed the finely ground diet was greater (P less than .01) than in pigs fed cracked corn. The average daily gain of pigs receiving the finely ground diet was inversely related to ulcer incidence (r = .403, P less than .01, df = 59). The addition of 5, 10, 20 or 100 ppm of the H2-antagonist, metiamide, or 6, 18 or 54 ppm of SK&F 93479 to the finely ground diet did not improve pig performance or affect the incidence of gastric ulceration. The addition of 2, 6 and 18 ppm of SK&F 93479 to a corn-soy diet containing 4.5% alfalfa meal caused a reduction in gastric ulceration (P less than .05) and improved feed utilization by 3.2% (P less than .05). These data suggest that finely ground diets improve the performance of growing-finishing swine, but increase the incidence of ulcers in the esophageal region of the stomach. Severe gastric ulceration adversely affects swine performance. Feeding H2-antagonists does not reduce the ulcerogenic properties of finely ground diets, suggesting factors other than gastric acid secretion are involved in ulcerogenesis. The use of H2-antagonists in corn-soy diets improves feed utilization and reduces ulceration.     

Effects of feed and water restriction and receiving diet crude protein on feeder pig performance

Two experiments were conducted to determine the effects of feed and water restriction and receiving diet crude protein level on feeder pig performance. In Exp. 1, a total of 239 commingled feeder pigs transported over 1,000 km were used in two trials. Pigs given access to feed and water (FW) at the market weighed more (P less than .0001) following marketing and transport than pigs given no feed and water (N) for the comparable 25-h market period (20.7 vs 19.6 kg). While FW pigs weighed less (P less than .02) than N pigs at the conclusion of the trials (93.9 vs 96.6 kg), there was no effect (P greater than .1) on overall average daily gain (.32 vs .35). There were no effects of receiving diets containing 12, 16 or 20% crude protein on daily gain, daily feed intake or feed efficiency for the overall growing-finishing period. Scour scores on d 8, 9, 10, 11, 13 and 14 post-arrival increased (P less than .01) with increased levels of protein in the receiving diets. In Exp. 2, a total of 360 crossbred feeder pigs was mixed and moved from a nursery to grower-finisher facilities in three trials, given feed and water access immediately (FWG) or denied access for 44 h (NG). At the end of the 44-h period, FWG pigs were heavier than NG pigs (P less than .0001; 18.3 vs 16.7 kg). There was no treatment effect on overall pig weight, daily gain or feed efficiency.     

A new phytase expressed in yeast effectively improves the bioavailability of phytate phosphorus to weanling pigs

We have recently expressed a new phytase enzyme in a yeast system. Three experiments with a total of 140 weanling crossbred pigs were conducted to examine the efficacy of this enzyme in improving the bioavailability of phytate-P in corn-soybean meal diets to young pigs. Experiment 1 compared the efficacy of this new phytase with a commercially available phytase (Natuphos, BASF) for 4 wk at an inclusion level of 1,200 U/kg of diet. Experiment 2 compared the responses of pigs to four doses of the new phytase supplementation (300, 600, 900, and 1,200 U/kg of diet) for 4 wk. Experiment 3 compared the efficacy of this new phytase and Natuphos at a marginally optimal dose (700 U/kg of diet) for 5 wk. A group of pigs were fed the P-deficient basal diet as a negative control in Exp. 1, and a group of pigs were fed the basal diet plus .17 or .22% inorganic P as a positive control in all experiments. In Exp. 1, pigs fed the two sources of phytase had similar ADG (564 vs 567 g), gain/feed (.597 vs .589), plasma inorganic P concentrations (8.9 vs 8.4 mg/dL), and mobility scores (4.25 vs 4.46) that were higher (P < .05) than those of the negative control. In Exp. 2, plasma inorganic P concentration was a fairly linear response to the phytase dose (r > .83) at wk 1 and 2. Overall ADG of pigs also tended to increase with the phytase dose (P = .15). In Exp. 3, pigs fed the two sources of phytase had ADG (483 vs 506 g) similar to that of the positive control (508 g). These two groups also had similar plasma inorganic P concentrations (7.7 vs 7.4 mg/dL) that were lower (P < .05) than those of the positive control group (9.7 mg/dL). There was no significant effect of dietary treatments on ADFI in all three experiments. In conclusion, our new phytase was as effective as Natuphos, at the inclusion level of 700 or 1,200 U/kg of a P-deficient, corn-soybean meal diet, in improving phytate-P utilization by young pigs.     

Effects of dried whey and copper sulfate on the growth responses to organic acid in diets for weanling pigs

Five 21-d to 28-d experiments involving 484 pigs weaned at 28 +/- 2 d of age were conducted to evaluate the effects of addition of organic acid to a fortified, corn-soybean meal diet (CS) or to a similar diet containing 15% dried whey (CSW) on performance of pigs. The effects of an antibiotic-sulfonamide combination (110 mg chlortetracycline, 110 mg sulfamethazine, 55 mg penicillin/kg) and the interactive effects of Cu sulfate (250 ppm Cu) and acid also were evaluated. The acid was a commercial product consisting of 96% organic acid (citric acid and Na citrate, 2:1). Treatments in Exp. 1 and 2 were factorial arrangements of the CS or CSW basal diets supplemented with 0 or 1% (Exp. 1) and 0, .5 or 1% (Exp. 2) of the acid product. Pigs fed diets containing whey consumed more feed (P less than .01) and gained weight faster (P less than .05), but they had feed/gain responses similar to those of pigs fed the CS diet. Addition of 1% acid improved (P less than .01) growth rate of pigs fed the CS diet but did not improve (P greater than .25) growth rate of pigs fed the CSW diet. Feed/gain was improved (P less than .01) by acid addition to both the CS and the CSW diets. Improvements in gain and feed/gain were similar for the two levels of acid. In Exp. 3 and 4, factorial combinations of 0 and 1% acid and 0 and 250 ppm Cu were evaluated in diets containing an antibiotic-sulfonamide combination. In addition, a negative control diet (no antibiotics, acid or Cu) was included. Pigs fed diets containing antibiotics gained faster and more efficiently (P less than .01) than those fed the control diet.(ABSTRACT TRUNCATED AT 250 WORDS)     

Influence of dietary protein, fat or amino acids on the response of weanling swine to aflatoxin B1

Two experiments were conducted using corn from clean or aflatoxin B1 (AFB1)-contaminated (182 ppb) sources. Weanling pigs (28 d) were fed one of eight dietary treatments arranged in a 2 x 2 x 2 factorial design. In Exp. 1 (192 pigs), treatments varied in corn source (clean or AFB1-contaminated), CP level (18 or 20%) and added fat (0 or 5%). At the end of the 28-d growth trials, plasma samples were obtained. An AFB1 x CP level interaction was detected (P less than .05) for growth rate (ADG), feed intake (FI) and feed/gain ratio (F/G). Feeding AFB1 reduced (P less than .05) ADG (.30 vs .37 kg/d) and FI (.57 vs .66 kg/d) and increased F/G (1.88 vs 1.78) of pigs fed 18% CP diets. Performance of pigs fed 20% CP diets was not altered by AFB1. Adding 5% fat to diets improved (P less than .05) F/G but did not improve ADG of pigs fed AFB1. There was an AFB1 x CP x fat interaction (P less than .05) for plasma cholesterol. Adding fat or increasing the CP level prevented the depression of plasma cholesterol in pigs fed AFB1. In Exp. 2 (96 pigs), all diets contained 18% CP and the treatments varied in corn source (clean or AFB1-contaminated), added L-lysine HCl (0 or .25%) and added DL-methionine (0 or .15%). Feeding AFB1 reduced (P less than .05) ADG of pigs fed the 18% CP diet (.44 vs .50 kg/d) but not of pigs fed diets supplemented with .25% lysine.(ABSTRACT TRUNCATED AT 250 WORDS)     

Growing-finishing performance and carcass characteristics of pigs fed normal and genetically modified low-phytate corn

A genetically modified corn hybrid homozygous for the lpa1 allele, containing low phytate (LP), and its nearly isogenic equivalent hybrid (normal) were compared in two experiments with growing-finishing swine. In Exp. 1, 210 barrows (27 kg) were allotted to one of six dietary treatments with two corn hybrids (LP and normal) and three P feeding regimens. There were five replicate pens (seven pigs/pen) per treatment. Treatments consisted of diets that were supplemented with P throughout the growing-finishing period (.2% P and .15% supplemental P during growing and finishing phases, respectively) or only during the growing phase (.2% supplemental P) or that were not supplemented with P throughout the growing-finishing period. Performance at the end of the growing phase was based on a 2 x 2 factorial arrangement of treatments with two corn hybrids and two levels of added P (0 and .2%). This resulted in 10 replicates for the treatments supplemented with .2% P. The finishing phase (73 to 112 kg) was a 2 x 3 factorial arrangement of treatments with the two types of corn and three regimens of added P during the finishing period. Breaking load (BL) and ash of the fourth metacarpal were evaluated from one pig/pen at the end of the growing phase and from all pigs after slaughter. Pigs fed the LP corn diet without added P had greater body weight gain, feed efficiency, BL, and ash content of the fourth metacarpal than pigs fed the normal corn diet without added P. Performance was similar between pigs fed the LP diet without added P and pigs fed LP and normal corn with added P. In Exp. 2, 1,092 gilts (34 kg body weight) were allotted by weight in a commercial facility to one of three treatments: 1) normal corn/soybean meal diet containing .29% and .22% available P during the growing and finishing phases, respectively; 2) LP corn/soybean meal diet with the same available P level as Treatment 1; and 3) same as Treatment 2 for 8 wk, then no inorganic P supplementation during the finishing phase. All pigs were slaughtered at approximately 122 kg. There were no significant differences in growing-finishing performance or BL among treatments. However, pigs fed diets containing LP corn possessed carcasses with less backfat and a higher percentage of lean (P < .01). These results confirm that the P in LP corn is available to the pig and suggest that pigs fed diets containing this genetically modified corn will have more desirable carcasses.     

Nutritional value of quality protein maize and food corn for starter and growth pigs

Growth traits with starter and grower pigs and a digestion trial were conducted to compare the nutritional value of Quality Protein Maize (QPM), food corn and conventional feed corn. The QPM, food and feed corn contained .45, .31 and .29% lysine, respectively. The growth trials evaluated a QPM-soybean meal diet formulated on a lysine basis (.96% in starter and .7% in grower diets) and four diets arranged in a 2 (food corn vs feed corn) X 2 (low vs high soybean meal) factorial. Soybean meal was either added in the same amount as in the QPM diet or was added to provide the lysine content of the QPM diet. Performance was similar for pigs fed food corn and feed corn in both trials. The QPM diets resulted in greater performance than food and feed corn diets containing the same level of soybean meal supplementation; starter pigs were more (P less than .10) efficient and grower pigs had a higher (P less than .01) rate and efficiency of gain. However, performance of pigs fed the QPM diets was not equal to that of pigs fed isolysinic food and feed corn diets; growth rate was lower (P less than .05) in starter pigs and gain:feed was lower (P less than .05) in grower pigs. Diets in the digestion trial consisted of the corns plus 3.25% casein. Energy digestibility was similar for all diets. Ileal N and amino acid digestibilities were highest for QPM, intermediate for food corn and lowest for feed corn. In most instances, these differences were significant (P less than .05). Apparent biological value was highest (P less than .05) for QPM. These trials indicate that food corn and feed corn have similar nutritional value, and that starter and grower pigs can benefit from the higher protein quality of QPM.     

Effect of feeding Sarsaponin in cattle and swine diets

In four trials, steer calves were received in the feedlot, processed and fed diets supplemented with soybean meal (SBM), 1% urea (UR) or 1% urea plus sarsaponin (S) over a 28-d period. In trials 1 and 2, the feeding period was extended to approximately 62 d, in which steers were fed a common (SBM) diet the last 34 d. In trials 3 and 4, a SBM plus S diet treatment was included. During the first 28 d (four trial summary) daily gains of steers fed urea plus S (.74 kg) were intermediate to and significantly different from gains of steers fed SBM (.84 kg) or UR (.66 kg) diets. However, at the end of the 62-d feeding period (two trial summary) daily gains, feed intakes and feed efficiency did not differ (P greater than .05) among treatments. No significant improvements in performance were found in steers fed SBM diets supplemented with S. In swine trials, pigs were fed diets containing no additive, 63 mg S X kg-1, 55 mg chlortetracycline (C) X kg-1 or S plus C in a grower-finisher (GF) and grower (G) trial. In the GF trial, overall efficiency of feed conversion was improved (P less than .05) by feeding S or S plus C. In the G trial, daily gains and intakes were greatest for pigs fed S plus C and differed (P less than .1) from those of pigs fed S or C in the diet. Compared with feeding S or C alone, gain and intake of growing pigs were stimulated to a greater extent when S was fed in combination with C. Feeding S with or without C improved efficiency of feed conversion in finishing pigs.     

Response of starter pigs to supplementation of corn-soybean meal diets with organic acids

Four growth experiments were conducted to assess the effects of organic acid supplementation on performance of starter and finisher pigs. Three 4-wk starter experiments utilized 392 pigs fed simple corn-soybean meal diets. A fourth experiment employed 135 finisher pigs in a 6-wk study. Each of the starter experiments was initiated immediately after weaning; piglets were 30 +/- 3 d of age. In Exp. 1, weanling pigs fed a 19% crude protein, simple corn-soybean meal diet were compared with pigs fed similar diets supplemented with 2% propionic, fumaric, or citric acid. Addition of each acid improved (P less than .07) efficiency of gain, while propionate depressed (P less than .05) feed intake. Additions of 1, 2, 3 or 4% fumarate were made in Exp. 2, resulting in linear daily gain and feed efficiency improvements (P less than .05). In Exp. 3, a possible protein-sparing effect of fumaric acid was investigated. Increasing protein levels from 16 to 20% improved daily gain (P less than .01) and feed efficiency (P less than .0001); fumarate supplementation (2%) increased (P less than .01) gain:feed. However, there was no protein X fumaric acid interaction. In Exp. 4, no treatment effects were noted with performance of finisher pigs fed a 14% crude protein, corn-soybean meal diet was compared with that of pigs fed similar diets supplemented with 1.5 or 3% fumaric acid.     

Effects of graded levels of lysine and excess arginine and threonine on young pigs fed practical diets

Three experiments were conducted to estimate the lysine requirement of the weanling pig and the effects of excess arginine and threonine on that estimate. Feeding 1.15% dietary lysine in Exp. 1 and 1.20% in Exp. 2 maximized feed efficiency and resulted in the lowest plasma urea N values. Adding .15% threonine to the diets in Exp. 2 did not affect (P greater than .10) performance of the pigs, but increased (P less than .01) plasma urea N and decreased (P less than .01) plasma lysine concentrations. Supplemental arginine (.22%) did not affect performance of the growing pigs in Exp. 3, but it increased (P less than .01) plasma urea N. Pigs fed a corn-soybean meal diet utilized feed more efficiently (P less than .05) than those fed a corn-fish meal-dried whey diet. The most likely cause for this response was that the corn-soybean diet contained more lysine (.82%) than expected, whereas the corn-fish meal-dried whey diet had close to the expected content of lysine (.72%). From these results, it was concluded that the lysine requirement of the weanling pig fed practical diets is at least 1.15 or 1.20% of the diet. Also, added arginine or threonine did not adversely affect the performance of pigs.     

Evaluation of the effect of fumaric acid and sodium bicarbonate addition on performance of starter pigs fed diets of different types.

Three growth experiments were conducted to assess the effect of fumaric acid (FA) supplementation on the performance of pigs fed different types of diets. These 4-wk experiments involved 550 crossbred pigs weaned at 30 +/- 3 d of age. Pigs in Exp. 1 were fed either a simple corn-soybean meal (SBM) diet or a 75% corn-SBM, 25% dried skim milk (DSM) diet. Zero, 2, or 3% FA were added to the diets to create a 2 x 3 factorial arrangement of treatments. Supplementing diets with DSM improved gain (P less than .05) and gain/feed (P less than .001). Fumaric acid addition improved efficiency of feed utilization (P less than .01). Experiment 2 was conducted to evaluate the effect of protein source (casein or soy protein concentrate [SPC]) on the response to 3% FA. Sodium bicarbonate (BCB; 2.75%) was added to one diet containing casein and FA to negate the effect of FA on growth performance. Addition of FA improved gain and feed efficiency (P less than .05) during the first 2 wk.(ABSTRACT TRUNCATED AT 250 WORDS)     

Sulfur concentration in diets containing corn, soybean meal, and distillers dried grains with solubles does not affect feed preference or growth performance of weanling or growing-finishing pigs

Four experiments were conducted to investigate the effects of distillers dried grains with solubles (DDGS) and dietary S on feed preference and performance of pigs. In a 10-d feed preference experiment (Exp. 1), 48 barrows (20.1 ± 2.2 kg of BW) were randomly allotted to 3 treatment groups, with 8 replicate pens per treatment and 2 pigs per pen. A control diet based on corn and soybean meal, a DDGS diet containing 20% DDGS, and a DDGS-sulfur (DDGS-S) diet were prepared. The DDGS-S diet was similar to the DDGS diet with the exception that 0.74% CaSO(4) was added to the diet. Two diets were provided in separate feeders in each pen: 1) the control diet and the DDGS diet, 2) the control diet and the DDGS-S diet, or 3) the DDGS diet and the DDGS-S diet. Preference for the DDGS diet and the DDGS-S diet vs. the control diet was 35.2 and 32.6%, respectively (P < 0.05), but there was no difference between the DDGS diet and the DDGS-S diet. In Exp. 2, a total of 90 barrows (10.3 ± 1.4 kg of BW) were allotted to 3 treatments, with 10 replicate pens and 3 pigs per pen, and were fed the diets used in Exp. 1 for 28 d, but only 1 diet was provided per pen. Pigs fed the control diet gained more BW (497 vs. 423 and 416 g/d; P < 0.05) and had greater G:F (0.540 vs. 0.471 and 0.455; P < 0.05) than pigs fed the DDGS or the DDGS-S diet, but no differences between the DDGS and the DDGS-S diets were observed. In a 10-d feed preference experiment (Exp. 3), 30 barrows (49.6 ± 2.3 kg of BW) were allotted to 3 treatment groups, with 10 replicates per group. The experimental procedures were the same as in Exp. 1, except that 30% DDGS was included in the DDGS and DDGS-S diets and 1.10% CaSO(4) was added to the DDGS-S diet. Feed preference for the DDGS and the DDGS-S diets, compared with the control diet, was 29.8 and 32.9%, respectively (P < 0.01), but there was no difference between the DDGS and the DDGS-S diets. In Exp. 4, a total of 120 barrows (34.2 ± 2.3 kg of BW) were fed grower diets for 42 d and finisher diets for 42 d. Diets were formulated as in Exp. 3. Pigs on the control diets gained more BW (1,021 vs. 912 and 907 g/d; P < 0.05) and had greater G:F (0.335 vs. 0.316 and 0.307; P < 0.05) than pigs fed the DDGS or DDGS-S diet, respectively, but no differences between pigs fed the DDGS and the DDGS-S diets were observed. In conclusion, dietary S concentration does not negatively affect feed preference, feed intake, or growth performance of weanling or growing-finishing pigs fed diets based on corn, soybean meal, and DDGS.     

Methionine requirement of the finishing pig

Two pig experiments were conducted using a methionine (Met)-deficient feather meal-corn-soybean meal basal diet (13% CP; 3,400 kcal ME/kg diet, .126% Met, 456% cystine) supplemented with an amino acid mixture (lysine, tryptophan, histidine, threonine and phenylalanine) to determine the Met requirement of finishing pigs between 50 and 80 kg live weight. Using young chicks in a Met bioavailability growth assay and cecectomized adult cockerels in a Met digestibility assay, the Met-deficient basal diet was found to contain .115% bioavailable and .110% digestible Met. These results gave a bioavailability estimate (relative to DL-Met set at 100%) of 91.3 +/- 2.5% and a true digestibility estimate of 87.0 +/- 2.2% for Met in the basal pig diet. In Exp. 1, 21 crossbred pigs averaging 61 kg initially were individually fed diets containing .115, .165 or .215% bioavailable Met for 21 d. Average daily gain and gain:feed ratio increased quadratically (P less than .05) as level of Met increased. In Exp. 2, 30 crossbred pigs averaging 53 kg were individually fed diets containing .115, .135, .155, .175 or .195% bioavailable Met for 27 d. Daily gain and gain;feed ratio responded linearly (P less than .01) as Met level increased. Based on the results of Exp. 2, the bioavailable Met requirement of finishing pigs in the weight range 50 to 80 kg was estimated to be .182% of the diet. Assuming an 88% bioavailability of Met in commercial diets based on corn and soybean meal, the total Met level needed in practice would be .207%. If 55% of the finishing pig's sulfur amino acid need can be furnished by cystine, the total sulfur amino acid requirement would be .45% of the diet.     

Use of carbohydrases in corn-soybean meal-based nursery diets

Three experiments were conducted to test the hypothesis that supplementing nursery pig diets with a mixture of carbohydrases (CS) will improve pig performance and nutrient digestibility. The CS used in these experiments contained 7 units/g of alpha-1,6-galactosidase, 22 units/g of beta-1,4-mannanase, beta-1,4 mannosidase, and trace amounts of other enzymes. In Exp. 1, 108 pigs weaned at d 21 of age were fed one of three diets containing 0 (control), 0.1, or 0.2% CS for 5 wk, based on a three-phase feeding program (1, 2, and 2 wk). Over the entire 35-d period, ADG was not affected (P > 0.05) by treatment, but supplementing 0.1% CS increased (P < 0.05) gain:feed by 9%. Experiment 2 used 10 gilts fitted with simple T-cannula in the terminal ileum at 3 wk of age. After cannulation, pigs were fed the same control Phase I and II diets, but the Phase III diet contained either 0 or 0.1% CS. Ileal samples were collected for the 3 d following the 5-d adjustment period during Phase III. Apparent ileal digestibility of GE, lysine, threonine, and tryptophan was greater (P < 0.05) in the CS diet. In Exp. 3, 90 pigs weaned at 21 d of age were fed the same control Phase I and II diets, but the Phase III diet contained either 0 or 0.1% CS. Phase III diets were fed for 3 wk. Average daily gain of the CS group was greater (P < 0.05) than the control group during wk 3. Gain:feed ratio was greater (P < 0.05) for the carbohydrase group during the entire Phase III period. Four pigs per treatment were killed at the end of Exp. 3 to measure villus height and to determine the concentration of raffinose and stachyose in different parts of the gastrointestinal tract. Average villus height was greater (P < 0.05) in pigs fed the CS diet. Carbohydrase supplementation decreased (P < 0.05) the concentration of stachyose in freeze-dried digesta from the proximal and distal small intestine. Raffinose concentration, on the other hand, was decreased (P < 0.05) by CS supplementation only in the distal small intestine. These lower concentrations suggest that CS improved the digestibility of carbohydrate in soybean meal. In conclusion, the addition of CS to Phase I and Phase II nursery diets containing low levels of soybean meal did not improve pig performance, but its addition to corn-soybean meal-based Phase III nursery diets improved gain:feed ratio and energy and AA digestibility.     

Effect of dietary potassium chloride on feeder pig performance, market shrink, carcass traits and selected blood parameters

A total of 288 commingled crossbred feeder pigs were purchased and transported 1,050 km in two trials to investigate the effect of added dietary potassium chloride in receiving and finishing diets on feeder pig shrink recovery, performance and pre-slaughter shrink. Diets containing 0, .48%, .96% or 1.44% added potassium chloride were fed for 2 wk post-arrival and again from 12 wk post- arrival until slaughter. There was no effect (P greater than .1) on gain (22.9 kg pay weight) or feed conversion or on plasma or red blood cell potassium for the 2-wk post-arrival period due to the inclusion of potassium chloride in the 2-wk receiving diet. Also, there was no effect (P greater than .1) of potassium chloride in diets from 12 wk post-arrival until slaughter on gain, feed conversion, market shrink, carcass dressing percentage and plasma or red blood cell potassium concentration at slaughter. These results suggest that corn-soybean meal-based diets contain sufficient potassium for pigs following a period of stress associated with marketing and transport.     

Effect of vitamin E and copper on the vitamin E status and performance of growing pigs

A 13-wk trial was conducted with 32 pigs to determine the effects of dietary Cu (250 ppm) and alpha-tocopheryl acetate (ATA, 22 IU/kg) on the performance, serum enzymes, serum and tissue tocopherols, and antibody production in growing pigs. Pigs were fed corn-soybean meal diets containing 21% CP the first 4 wk and 18% CP during the rest of the trial. All feed was stored a minimum of 14 d before it was fed. The addition of Cu decreased (P less than .01) the concentration of alpha-tocopherol in the feed. alpha-Tocopherol concentrations were less than .01 mg/kg in the starter diet and less than 2 mg/kg in the grower diet after 14 d of storage. Supplemental Cu or ATA had no effect on ADG, feed intake, or gain:feed during the first 4 wk. During wk 5 to 13, the addition of Cu to diets containing no ATA increased daily feed intake and decreased gain:feed, but with ATA addition, feed intake decreased and gain:feed increased, resulting in a Cu x ATA interaction (P less than .05). The addition of Cu or ATA had no effect (P greater than .1) on serum glutathione peroxidase or lactic dehydrogenase activity. Serum tocopherols were reduced (P less than .05) by the addition of Cu during wk 1 to 4, 6 (P less than .01), and 7 (P less than .05) and increased (P less than .01) by ATA addition during the entire experiment. The addition of ATA increased the tocopherol concentrations in bile, ham, heart, pancreas, kidney, spleen, liver, psoas and longissimus muscle (P less than .01), kidney fat, backfat, and adrenal gland (P less than .05).(ABSTRACT TRUNCATED AT 250 WORDS)     

Effectiveness of an experimental consensus phytase in improving dietary phytate-phosphorus utilization by weanling pigs

Consensus phytase is a new biosynthetic, heat-stable enzyme derived from the sequences of multiple homologous phytases. Two experiments were conducted to determine its effectiveness, relative to inorganic P and a mutant enzyme of Escherichia coli phytase (Mutant-EP), in improving dietary phytate-P availability to pigs. In Exp. 1, 36 pigs (3 wk old, 7.00 +/- 0.24 kg of BW) were fed a low-P corn-soybean meal basal diet plus consensus phytase at 0, 250, 500, 750, 1,000, or 1,250 U/kg of feed for 5 wk. Plasma inorganic P concentration, plasma alkaline phosphatase activity, bone strength, and overall ADG and gain:feed ratio of pigs were improved (P < 0.05) by consensus phytase in both linear (R2 = 0.20 to 0.70) and quadratic (R2 = 0.30 to 0.70) dose-dependent fashions. In Exp. 2, 36 pigs (4 wk old, 9.61 +/- 0.52 kg BW) were fed the basal diet + inorganic P at 0.1 or 0.2%, consensus phytase at 750 or 450 U/kg of feed, Mutant-EP at 450 U/kg of feed, or 225 U consensus + 225 U Mutant-EP/kg of feed. Pigs fed 750 U of consensus phytase or 450 U of Mutant-EP/kg feed had plasma inorganic concentrations and bone strength that fell between those of pigs fed 0.1 or 0.2% inorganic P. These two measures were 16 to 29% lower (P < 0.05) in pigs fed 450 U of consensus phytase/kg of feed than those of pigs fed 0.2% inorganic P. Plasma inorganic P concentrations were 14 to 29% higher (P < 0.05) in pigs fed Mutant-EP vs. consensus phytase at 450 U/kg at wk 2 and 3. In conclusion, the experimental consensus phytase effectively releases phytate P from the corn-soy diet for weanling pigs. The inorganic P equivalent of 750 U of consensus phytase/kg of feed may fall between 0.1 and 0.2%, but this requires further determination.     

Growth performance, diet apparent digestibility, and plasma metabolite concentrations of barrows fed corn-soybean meal diets or low-protein, amino acid-supplemented diets at different feeding level

Two experiments, each with 36 barrows with high-lean-gain potential, were conducted to evaluate apparent nutrient digestibilities and performance and plasma metabolites of pigs fed corn-soybean meal diets (CONTROL) and low-protein diets. The low-protein diets were supplemented with crystalline lysine, threonine, tryptophan, and methionine either on an ideal protein basis (IDEAL) or in a pattern similar to that of the control diet (AACON). Amino acids were added on a true ileally digestible basis. The initial and final BW were, respectively, 31.5 and 82.3 kg in Exp. 1 and 32.7 and 57.1 kg in Exp. 2. In Exp. 1, the CONTROL and IDEAL diets were offered on an ad libitum basis or by feeding 90 or 80% of ad libitum intake. Pigs were fed for 55 d. In Exp. 2, the CONTROL, IDEAL, and AACON diets were offered on an ad libitum basis or by feeding 80% of the ad libitum intake. Pigs were fed for 27 d. Pigs fed the CONTROL diet had greater (P < 0.05) ADG and feed efficiency (G/F) than pigs fed the IDEAL (Exp. 1 and 2) and AACON diets (Exp. 2). As the level of feed intake decreased, ADG decreased (P < 0.05), but G/F tended to improve (P < 0.10) for pigs fed 90% of ad libitum in Exp. 1 and for pigs fed 80% of ad libitum in Exp. 2. In Exp. 1, the apparent total tract digestibilities of DM and energy were greater (P < 0.01) for pigs fed the IDEAL diet than for pigs fed the CONTROL diet. In Exp. 2, the apparent total tract digestibility of protein was greatest in pigs fed the CONTROL diet (P < 0.05) and was greater (P < 0.05) in pigs fed the AACON diet than in pigs fed the IDEAL diet. Plasma urea concentrations were lower in pigs fed the IDEAL diet than in pigs fed the CONTROL diet, regardless of feeding level. For pigs fed the CONTROL diet, plasma urea concentrations were lower when feed intake was 80% of ad libitum (diet level, P < 0.01). In summary, pigs fed the IDEAL and the AACON diets gained less and had lower plasma urea concentrations than pigs fed the CONTROL diet. Based on these data, it seems that the growth potential of pigs fed the IDEAL and AACON diets may have been limited by a deficiency of lysine, threonine, and(or) tryptophan and that the amino acid pattern(s) used was not ideal for these pigs.