Impact of different stages of juice processing on the anthocyanin, flavonol, and procyanidin contents of cranberries

Juice is the most common form in which cranberries are consumed; however there is limited information on the changes of polyphenolic content of the berries during juice processing. This study investigated the effects of three different pretreatments (grinding plus blanching; only grinding; only blanching) for cranberry juice processing on the concentrations of anthocyanins, flavonols, and procyanidins throughout processing. Flavonols and procyanidins were retained in the juice to a greater extent than anthocyanins, and pressing resulted in the most significant losses in polyphenolics due to removal of the seeds and skins. Flavonol aglycones were formed during processing as a result of heat treatment. Drying of cranberry pomace resulted in increased extraction of flavonols and procyanidin oligomers but lower extraction of polymeric procyanidins. The results indicate that cranberry polyphenolics are relatively stable during processing compared to other berries; however, more work is needed to determine their fate during storage of juices.     

Sequential fractionation of grape seeds into oils, polyphenols, and procyanidins via a single system employing CO2-based fluids

Pure supercritical CO(2) was used to remove >95% of the oil from the grape seeds. Subcritical CO(2) modified with methanol was used for the extraction of monomeric polyphenols, whereas pure methanol was used for the extraction of polyphenolic dimers/trimers and procyanidins from grape seed. At optimum conditions, 40% methanol-modified CO(2) removed >79% of catechin and epicatechin from the grape seed. This extract was light yellow in color, and no higher molecular weight procyanidins were detected. Extraction of the same sample after removal of the oils and polyphenols, but now under enhanced solvent extraction conditions using methanol as a solvent, provided a dark red solution shown via electrospray ionization HPLC-MS to contain a relatively high concentration of procyanidins. The uniqueness of the study is attested to by the use of CO(2)-based fluids and the employment of a single instrumental extraction system.     

苹果渣多酚提取工艺的优化

为优化苹果渣中多酚提取工艺,并得到提取工艺和多酚组成之间的关系,利用微波辅助提取法设计了由物料颗粒、液料比、乙醇浓度、微波功率和微波提取时间5个因素构成的多酚提取优化试验流程,构建了涵盖黄酮、原花青素2种典型多酚物质和抗氧化能力的提取工艺评价指标体系。采用证据理论对不同工艺在评价指标下的焦元进行识别,并基于信度函数和似真函数得到了不同提取工艺的效用区间和优化方案。优化结果为：物料颗粒60目,液料比30?mL/g,乙醇体积分数60%,微波功率600?W,提取时间70?s,此条件下苹果渣多酚的提取量为213.83?mg/100g,黄酮提取量为83.21?mg/100g,原花青素提取量为52.79?mg/100g,抗氧化的EC50值为3.71?mg/100mL,验证了采用证据理论进行苹果渣多酚提取工艺优化的有效性。     

Polyphenol screening of pomace from red and white grape varieties (Vitis vinifera L.) by HPLC-DAD-MS/MS

Phenolic compounds of 14 pomace samples originating from red and white winemaking were characterized by HPLC-MS. Up to 13 anthocyanins, 11 hydroxybenzoic and hydroxycinnamic acids, and 13 catechins and flavonols as well as 2 stilbenes were identified and quantified in the skins and seeds by HPLC-DAD. Large variabilities comprising all individual phenolic compounds were observed, depending on cultivar and vintage. Grape skins proved to be rich sources of anthocyanins, hydroxycinnamic acids, flavanols, and flavonol glycosides, whereas flavanols were mainly present in the seeds. However, besides the lack of anthocyanins in white grape pomace, no principal differences between red and white grape varieties were observed. This is the first study presenting comprehensive data on the contents of individual phenolic compounds comprising all polyphenolic subclasses of grapes including a comparison of several red and white pomaces from nine cultivars. The results obtained in the present study confirm that both skins and seeds of most grape cultivars constitute a promising source of polyphenolics.     

Extracts enriched in different polyphenolic families normalize increased cardiac NADPH oxidase expression while having differential effects on insulin resistance, hypertension, and cardiac hypertrophy in high-fructose-fed rats

Insulin resistance and oxidative stress act synergistically in the development of cardiovascular complications. The present study compared the efficacy of three polyphenolic extracts in their capacity to prevent hypertension, cardiac hypertrophy, increased production of reactive oxygen species (ROS) by the aorta or the heart, and increased expression of cardiac NAD(P)H oxidase in a model of insulin resistance. Rats were fed a 60%-enriched fructose food and were treated once a day (gavage) for 6 weeks with 10 mL/kg of water only (F group) or the same amount of solution containing a red grape skin polyphenolic extract enriched in anthocyanins (ANT), a grape seed extract enriched in procyanidins and rich in galloylated procyanidins (PRO), or the commercial preparation Vitaflavan (VIT), rich in catechin oligomers. All treatments were administered at the same dose of 21 mg/kg of polyphenols. Our data indicate that (a) the ANT treatment prevented hypertension, cardiac hypertrophy, and production of ROS, (b) the PRO treatment prevented insulin resistance, hypertriglyceridemia, and overproduction of ROS but had only minor effects on hypertension or hypertrophy, while (c) Vitaflavan prevented hypertension, cardiac hypertrophy, and overproduction of ROS. All polyphenolic treatments prevented the increased expression of the p91phox NADPH oxidase subunit. In summary, our study suggest that (a) the pathogeny of cardiac hypertrophy in the fructose-fed rat disease involves both hypertension and hyperproduction of ROS, (b) polyphenolic extracts enriched in different types of polyphenols possess differential effects on insulin resistance, hypertension, and cardiac hypertrophy, and (c) polyphenols modulate the expression of NAD(P)H oxidase.     

Effect of flash release treatment on phenolic extraction and wine composition

The flash release (FR) process, consisting of rapidly heating the grapes and then applying strong vacuum, has been proposed to increase the polyphenol content of red wines. Its impact on polyphenol extraction kinetics and on the polyphenol composition of red juice and wines was studied over two seasons on different grape varieties (Grenache, Mourvedre, Carignan). The FR process allows fast extraction of all phenolic compounds (hydroxycinnamic acids, flavonols, anthocyanins, catechins, proanthocyanidins) and can be used to produce polyphenol-enriched grape juices. However, the concentration of all polyphenols dramatically decreased throughout fermentation when pressing was achieved immediately after FR. The FR wines made with pomace maceration were also enriched in polyphenols compared to the corresponding control wines. Increasing the duration of high-temperature exposure in the FR treatment further increased extraction of phenolic compounds but also accelerated their conversion to derived species. The tannin-to-anthocyanin ratio was particularly low in the wine fermented in the liquid phase, higher after FR than in the control, and even higher after longer heating. FR resulted in an increased tannin-to-anthocyanin ratio and an increased conversion of anthocyanins to tannin-anthocyanin adducts showing the same color properties as anthocyanins. The tannin-to-anthocyanin ratio was particularly low in the wine fermented in the liquid phase that also contained larger amounts of orange sulfite bleaching-resistant pigments.     

苹果渣中不同极性多酚的分离及体外抗氧化活性研究

为了优化苹果多酚提取工艺,进而提高苹果多酚提取物中强效多酚的含量,该文采用液-液萃取方法按极性大小对果渣多酚进行分离,进而采用1,1-二苯基-2-苦苯肼自由基法和铁离子还原/抗氧化力法对不同极性多酚体外抗氧化活性进行评价.结果表明:液-液萃取方法,可以实现不同极性多酚的有效分离,不同极性苹果多酚,其体外抗氧化活性有显著差异,水层多酚活性最强,其次为正丁醇层,乙酸乙酯层相对较弱,即多酚的抗氧化性与其极性呈正相关.因此,工业化提取苹果渣中多酚时,增大提取溶剂的极性有利于强效多酚的获取.     

Efficient one pot extraction and depolymerization of grape (Vitis vinifera) pomace procyanidins for the preparation of antioxidant thio-conjugates

Antioxidant thio-conjugates were obtained from white grape pomace by a clean and efficient one pot extraction and depolymerization method using water and cysteamine hydrochloride. To evaluate the potential of grape pomaces of different origins as sources of proanthocyanidins and conjugates, we conducted varietal comparative studies of polyphenol content, antioxidant power, and procyanidin composition. Xarel.lo proved to be the richest source of polyphenols. The total conversion into the conjugates was as high as 8 g/kg of Xarel.lo grape pomace, with a 50-fold excess of cysteamine, and 3 g/kg, with a 5-fold excess of cysteamine. After purification by preparative cation exchange and reversed phase high-performance liquid chromatography, 17 g of 63% pure 4beta-(2-aminoethylthio)epicatechin (acetate salt) was obtained from 35 kg of moist pomace. The procedure described here will make the antioxidant thio-derivatives efficiently available directly from raw plant byproducts such as grape pomace.     

Biochemical analysis and in vivo hypoglycemic activity of a grape polyphenol-soybean flour complex

Defatted soybean flour (DSF) can efficiently sorb, concentrate, and stabilize polyphenols, but not sugars, from Concord grape juice, to yield grape polyphenol-enriched DSF. Sorption of grape polyphenols to DSF particles was dependent on the ratio of DSF and grape juice concentrate used, but not time of mixing or pH. Depending on ratios of starting materials, 1 g of grape polyphenol-enriched DSF contained 1.6-10.4 mg of anthocyanins, 7.5-93.1 mg of proanthocyanidins, and 20.5-144.5 mg of total polyphenols. LC-MS analysis of grape juice samples before and after addition and removal of DSF and eluate from grape polyphenol-enriched DSF confirmed that a broad range of grape compounds were sorbed to the DSF matrix. Finally, grape polyphenol-enriched DSF was able to significantly lower blood glucose levels in hyperglycemic C57BL/6J mice. The data indicate that grape polyphenol-enriched DSF can provide a high-protein, low-sugar ingredient for delivery of concentrated grape polyphenolics.     

Fractionation of grape anthocyanin classes using multilayer coil countercurrent chromatography with step gradient elution

Grape anthocyanins from rosé wine pomace and grape skins were fractionated by multilayer coil countercurrent chromatography (MLCCC). Tert-butyl methyl ether/n-butanol/acetonitrile/water acidified with trifluoroacetic acid (2/2/x/5) was chosen as the solvent system because of its demonstrated efficiency in separating anthocyanins. A method combining MLCCC and step gradient elution has been developed. This method enabled the fractionation of anthocyanins as series of glucosides, and the corresponding acetylated, coumaroylated, and caffeoylated derivatives. The different anthocyanins were identified on the basis of their UV spectra, their elution time on reversed-phase HPLC as well as by mass spectrometry. A polar-colored fraction free of anthocyanin monomers and corresponding to the material remaining in the stationary phase after the completion of the gradient was recovered.     

Chemical characterization of red wine grape (Vitis vinifera and Vitis interspecific hybrids) and pomace phenolic extracts and their biological activity against Streptococcus mutans

Grapes are rich sources of potentially bioactive polyphenols. However, the phenolic content is variable depending on grape variety, and may be modified during vinification. In this study, we examined the chemical composition and biological activity of phenolic extracts prepared from several red wine grape varieties and their fermented byproduct of winemaking (pomace) on some of the virulence properties of Streptococcus mutans a well-known dental pathogen. Grape phenolic extracts were obtained from Vitis vinifera varieties Cabernet Franc and Pinot Noir and Vitis interspecific hybrid varieties Baco Noir and Noiret. The anthocyanins and flavan-3-ols content were highly variable depending on grape variety and type of extract (whole fruit vs fermented pomace). Nevertheless, all grape phenolic extracts remarkably inhibited glucosyltransferases B and C (70-85% inhibition) at concentrations as low as 62.5 microg/mL (P < 0.01). Furthermore, the glycolytic pH-drop by S. mutans cells was inhibited by the grape extracts without affecting the bacterial viability; an effect that can be attributed to partial inhibition of F-ATPase activity (30-65% inhibition at 125 microg/mL; P < 0.01). The biological activity of fermented pomace was either as effective as or significantly better than whole fruit grape extracts. The results showed that grape phenolic extracts, especially from pomace, are highly effective against specific virulence traits of S. mutans despite major differences in their phenolic content.     

Ellagic acid and flavonoid antioxidant content of muscadine wine and juice

Antioxidant properties of flavonoids and ellagic acid were characterized in eight wines and juices produced by various processing methodologies from red and white muscadine grape cultivars (Vitis rotundifolia). Juices and wines were produced by hot- and cold-pressed techniques, and additional wine was produced following on-hull fermentation for 3, 5, and 7 days. Chromatographic conditions were developed to simultaneously separate anthocyanins, ellagic acid, and flavonols and correlated to a measurement of overall antioxidant capacity (AOX), and their changes were monitored after storage for 60 days at 20 and 37 degrees C. Regression coefficients between concentrations of individual polyphenolics and AOX ranged from 0.55 for ellagic acid to 0.90 for kaempferol. Both red and white wines had higher AOX values after storage than juices made from an identical grape press, despite lower concentrations of individual polyphenolic compounds. Red wines fermented on-hull had higher initial concentrations of antioxidant polyphenolics as compared to a corresponding hot-pressed juice, but changes in AOX during storage were more affected by time than by storage temperature despite lower concentrations of flavonoids and ellagic acid present at 37 degrees C as compared to 20 degrees C. Oxidative or polymerization reactions significantly decreased levels of monomeric anthocyanins during storage with the greatest losses observed for delphinidin and petunidin 3,5-diglucosides. Processing methods for muscadine wine and juice production were important factors influencing concentrations of antioxidant flavonoids and ellagic acid, while the role of fermentation and time had the greatest influence on retention of AOX properties during storage.     

Effects of solvent and temperature on pressurized liquid extraction of anthocyanins and total phenolics from dried red grape skin

Pressurized liquid extraction (PLE) was used to extract anthocyanins from the freeze-dried skin of a highly pigmented red wine grape with six solvents at 50 degrees C, 10.1 MPa, and 3 x 5 min extraction cycles. Temperature (from 20 to 140 degrees C in 20 degrees C increments) effects on anthocyanin recovery by acidified water and acidified 60% methanol were also studied. Acidified methanol extracted the highest levels of total monoglucosides and total anthocyanins, whereas the solvent mixture (40:40:20:0.1 methanol/acetone/water HCl) extracted the highest levels of total phenolics and total acylated anthocyanins. Acidified water extracts obtained by PLE at 80-100 degrees C had the highest levels of total monoglucosides, total acylated anthocyanins, total anthocyanins, total phenolics, and ORAC values. Acidified methanol extracts obtained by PLE at 60 degrees C had the highest levels of total monoglucosides and total anthocyanins, whereas extracts obtained at 120 degrees C had the highest levels of total phenolics. High-temperature PLE (80-100 degrees C) using acidified water, an environmentally friendly solvent, was as effective as acidified 60% methanol in extracting anthocyanins from grape skins.     

Pulsed electric field-assisted vinification of aglianico and piedirosso grapes

Pulsed electric field (PEF) treatments were applied to increase the polyphenolic content of fresh red wines made from Aglianico and Piedirosso grapes. Prior to the fermentation/maceration step, the grape skins were treated at different PEF intensities (field strengths from 0.5 to 1.5 kV/cm and energy inputs from 1 to 50 kJ/kg), with their permeabilization being characterized by electrical impedance measurements. Furthermore, the release kinetics of the total polyphenols and anthocyanins were characterized during the maceration stage by spectroscopic and Folin-Ciocalteu colorimetric methods, respectively. Finally, the fresh wine, obtained after pressing, was characterized for total acidity, pH, reducing sugar, color intensity, total polyphenols, anthocyanins content, antioxidant activity, and volatile compound composition. PEF treatment on Aglianico grapes induced a significantly higher release of polyphenols (+20%) and anthocyanins (+75%), thus improving the color intensity (+20%) and the antioxidant activity of the wine (+20%) while preserving the other organoleptic characteristics. In contrast, there was only a minor impact on the polyphenolic release kinetics of Piedirosso grapes, despite the significant degree of cell membrane permeabilization.     

Phytochemical composition and pigment stability of Açai (Euterpe oleracea Mart.)

Anthocyanin and polyphenolic compounds present in a?ai (Euterpe oleracea Mart.) were determined and their respective contribution to the overall antioxidant capacity established. Color stability of a?ai anthocyanins against hydrogen peroxide (0 and 30 mmol/L) over a range of temperatures (10-30 degrees C) was also determined and compared to common anthocyanin sources. Additionally, stability in a model beverage system was evaluated in the presence of ascorbic acid and naturally occurring polyphenolic cofactors. Cyanidin 3-glucoside (1040 mg/L) was the predominant anthocyanin in a?ai and correlated to antioxidant content, while 16 other polyphenolics were detected from 4 to 212 mg/L. Red grape anthocyanins were most stable in the presence of hydrogen peroxide, while a?ai and pigments rich in acylated anthocyanins displayed lower color stability in a temperature-dependent manner. In the presence of ascorbic acid, acylated anthocyanin sources generally had increased color stability. A?ai was recognized for its functional properties for use in food and nutraceutical products.     

Valorization of grape (Vitis vinifera) byproducts. Antioxidant and biological properties of polyphenolic fractions differing in procyanidin composition and flavonol content

Many byproducts and wastes generated by agroindustries contain polyphenols with potential application as food antioxidants and preventive agents against skin cancer and other diseases. The performance of polyphenolic fractions from Parellada grape (Vitis vinifera) pomace as antioxidants in different physicochemical environments was tested. Fractions containing oligomers with mean degree of polymerization between 3 and 4 and percentage galloylation ca. 30% were the most potent free radical scavengers and efficient antioxidants in an oil-in-water emulsion. A fraction including glycosylated flavonols was also efficient in the emulsion. All the fractions showed low aquatic toxicity and weak influence on proliferation of human melanoma cells.     

Identification and quantification of short oligomeric proanthocyanidins and other polyphenols in boysenberry seeds and juice

Proanthocyanidins and other polyphenols in the seeds and juice of boysenberry were quantitatively analyzed. Polyphenolic extracts were prepared from the waste seeds and commercial juice by chromatographic fractionation. Compositional analysis revealed that both extracts contained six polyphenolic classes: flavanol monomers, proanthocyanidins, anthocyanins, ellagic acid, ellagitannins, and flavonol glycosides. Ellagitannins were the most abundant polyphenols in both extracts. Proanthocyanidins were present as short oligomers consisting of dimeric and trimeric procyanidins and propelargonidins, with the most abundant component being procyanidin B4 in both extracts. Quantification by high-performance liquid chromatography-mass spectrometry (HPLC-MS) revealed that the seeds contained a 72-fold higher amount of proanthocyanidins than the juice. These results indicate that boysenberry fruits contain short oligomeric proanthocyanidins along with flavanol monomers and the seeds represent a good source of short oligomeric proanthocyanidins.     

Extraction of polyphenols from processed black currant (Ribes nigrum L.) residues

The total phenol and anthocyanin contents of black currant pomace and black currant press residue (BPR) extracts, extracted with formic acid in methanol or with methanol/water/acetic acid, were studied. Anthocyanins and other phenols were identified by means of reversed phase HPLC, and differences between the two plant materials were monitored. In all BPR extracts, phenol levels, determined by the Folin-Ciocalteu method, were 8-9 times higher than in the pomace extracts. Acid hydrolysis liberated a much higher concentration of phenols from the pomace than from the black currant press residue. HPLC analysis revealed that delphinidin-3-O-glucoside, delphinidin-3-O-rutinoside, cyanidin-3-O-glucoside, and cyanidin-3-O-rutinoside were the major anthocyanins and constituted the main phenol class ( approximately 90%) in both types of black currant tissues tested. However, anthocyanins were present in considerably lower amounts in the pomace than in the BPR. In accordance with the total phenol content, the antioxidant activity determined by scavenging of 2,2'-azinobis(3-ethylbenzothiazoline-6-sulfonic acid) radical cation, the ABTS(*)(+) assay, showed that BPR extracts prepared by solvent extraction exhibited significantly higher (7-10 times) radical scavenging activity than the pomace extracts, and BPR anthocyanins contributed significantly (74 and 77%) to the observed high radical scavenging capacity of the corresponding extracts.     

Survey of polyphenol constituents in grapes and grape-derived products

A rapid and comprehensive qualitative method has been developed to characterize the different classes of polyphenols, such as anthocyanins, flavonols, phenolic acids, and flavanols/proanthocyanidins, in grape products. The detection was achieved by two runs with the same LC gradient in different MS ionization modes and mobile phase modifiers (positive ionization mode and 0.4% trifluoroacetic acid for anthocyanins and flavonols; negative ionization mode and 0.1% formic acid for phenolic acids and flavanols). From an analysis of the MS and UV data and in comparison with the authenticated standards, a total of 53 compounds were identified, including 33 anthocyanins, 12 flavonols, 4 phenolic acids, and 4 flavanols/proanthocyanidins. With the method developed, a survey was then conducted to qualitatively assess the composition of polyphenols among 29 different grape products including original grape, grape juice, grape wine, and grape-derived dietary supplements, and their chemical profiles were systematically compared. This method provided a comprehensive qualitative insight into the composition of polyphenols in grape-derived products.     

How to improve bayberry (Myrica rubra Sieb. et Zucc.) juice color quality: effect of juice processing on bayberry anthocyanins and polyphenolics

Fresh bayberries (Myrica rubra Sieb. et Zucc.) were processed into juice at an industrialized scale with four treatments: control, SO2 addition, pasteurization of the crushed pulp, and blanching before fruit crushing. Changes in anthocyanin pigments and polyphenolics (hydrobenzoic acids and flavonol glycosides) were monitored during processing. Centrifuged juice yield ranged from 73 to 78% (w/w), but only 12-27% of the anthocyanins and 20-32% of the polyphenolics were recovered in the ultrahigh-temperature (UHT) juices. Fifty-two to 58% of anthocyanins and 30-35% of polyphenolics were present in the centrifuged cakes. The initial processing steps of blanching, crushing, pasteurization, and depectinization caused a great loss of total and individual polyphenolics. Total monomeric anthocyanins were significantly higher (p < 0.05) in pasteurization- and blanching-treated samples than those in the SO2 treated samples, whereas those in the SO2-treated sample were significantly higher (p < 0.05) than those in the control juice. Overall polyphenolic levels were significantly higher (p < 0.05) in pasteurization- and blanching-treated samples than in the SO2-treated and control samples after each processing step. Important changes occurred in the polyphenolic profile with a 50-150% of hydroxybenzoic acids increase due to the free gallic acid from the flavonol glycoside-gallates during the initial processing steps. Flavonol deoxyhexosides were more stable than the flavonol hexosides during bayberry juice processing.