Quality of raw and smoked fillets from clinically healthy Atlantic salmon,Salmo salar L., following an outbreak of pancreas disease (PD)

Pancreas disease (PD) is a viral disease of farmed salmonid fish, which causes huge economic losses. Pathological changes in skeletal muscle, pancreas and heart are hallmarks of PD. Stakeholders in the fish‐smoking industry have claimed that fillets from PD‐affected Atlantic salmon, Salmo salar L., are of poor quality. We therefore examined harvest‐ready, clinically healthy Atlantic salmon from a population of fish previously affected by PD. Histopathological changes in skeletal muscle tissues ranged from minor to severe. Fillet quality measurements showed that fish with severe skeletal muscle changes provided a paler raw fillet and a yellowish and harder cold‐smoked fillet than normal. PD had no significant effect on fillet gaping, bacteriological quality or off‐odour development during storage. An unexpected finding was a significant subendocardial fibrosis in 23% of the PD‐affected fish. The latter may indicate susceptibility to stress‐related heart failure.     

Bleeding of anaesthetized and exhausted Atlantic salmon: body cavity inspection and residual blood in pre‐rigor and smoked fillets as determined by various analytical methods

The bleeding efficiency of anaesthetized and exhausted Atlantic salmon was studied. Unbled fish were used as control groups for both treatments. Several analytical methods (computer vision, Minolta Chroma Meter, transflectance spectroscopy, haemoglobin iron and visual assessment of smoked fillets) were used to evaluate colour or residual blood contents of pre‐rigor and smoked fillets. In all cases, the amount of residual blood in the fillets was modest and blood was not considered a quality problem in terms of fillet appearance. Perimortem stress did not affect residual blood contents of pre‐rigor fillets. Only salting and smoking had a significant effect on filet colour. The low levels of residual blood was partly attributed to filleting shortly after killing allowing washing before the blood had time to coagulate. In addition, a computer vision method was developed for automated blood inspection of the body cavity after gutting and washing. A classifier (‘no blood’ or ‘blood present’) based on linear discriminant analysis was tested and the classification accuracy was over 90% as evaluated with the leave‐one‐out method.     

Added value from an added chromosome: Potential of producing large fillet fish from autumn to spring with triploid rainbow trout,Oncorhynchus mykiss

Three‐summers‐old all‐female triploid and diploid rainbow trout were compared after one on‐growing season in sea net cages. Slaughter traits of round weight, gutted weight, fillet weight, carcass% and fillet% were measured at three times in November 2017, January and April 2018. The triploid group had lower daily growth coefficient mean (4.25) and higher feed conversion ratio (1.18) than diploids (4.48 and 1.05, respectively) during on‐growing (June–November). In November, no difference of means was found between mature or immature diploids and triploids for any of the weight traits when the effect of vertebrae defects was statistically removed. However, the triploids had attained higher means than mature or immature diploids in gutted and fillet weight by January, suggesting that the loss of muscle mass during early winter was lower in triploids. Sexually maturing diploids (46%) had lower slaughter yield means compared to triploids or immature diploids at each measurement time, and these differences also increased during overwintering. Instead, the means of yield traits remained similar between the triploid and immature diploid groups through the winter. Likewise, fillet redness remained at equally high level in triploids and immature diploids, whereas in maturing diploids this attribute decreased substantially during overwintering. The triploid group had a higher incidence of vertebral defects (12.0%) than diploids (5.3%). The present results demonstrate the potential of triploid trout in producing large‐sized (>2 kg) fillet fish until spring markets. However, more detailed investigations are needed, particularly regarding the animal health and growth efficiency in triploids, relative to their diploid counterparts.     

Pre-rigor filleting and drip loss from fillets of farmed Atlantic cod (Gadus morhua L.)

Improved slaughtering procedures of farmed fish may provide sufficient time so that filleting can be performed pre‐rigor while the muscle pH is still high. Such filleting not only reduces fillet gaping but also lowers the transportation costs and makes fresh fillets available to the markets at an earlier stage. The aim of our work was to determine the weight reduction of the fillets due to liquid loss and to study the proteins and enzymes in the drip. After 11 days of cold storage, fillets of farmed Atlantic cod produced pre‐rigor had a weight loss of 10% and a fillet contraction of 19% while for fillets produced post‐rigor the values were 5% and 4% respectively. At the same time, approximately twice the amount of proteins had been lost from the pre‐rigor‐produced fillets. Sodium dodecyl sulphate polyacrylamide gel electrophoresis analysis showed that the proteins in the drip were similar to the sarcoplasmatic proteins extracted from the muscle. Specific analysis of proteolytic enzymes indicated that they are less stable in the expelled liquid than in the flesh during storage. The extensive loss of weight and proteins from pre‐rigor‐produced fillets during subsequent storage must be taken into account if such processing is considered for farmed cod.     

Quality characteristics in raw and smoked fillets of Atlantic salmon, Salmo salar, fed high-energy diets

Atlantic salmon, Salmo salar , were fed four levels of dietary fat (256, 308, 346 and 389 g kg⁻¹ of diet) for 138 days, with the purpose of studying quality characteristics in raw and smoked fish fillets. Dietary fat levels up to 346 g kg⁻¹ resulted in increased fat content of the raw fillets. The dietary fat levels had a less systematic effect on perceived fatness of the smoked fillets and caused a trend towards better odour and flavour. The fat content of raw fillets was significantly ( P ≤ 0.05) correlated to lower smoke odour, greater rancid flavour, fatness, and a yellower hue of the smoked fillets. Astaxanthin levels of the raw fillets varied between 6 and 11 mg kg⁻¹ of fillet and were significantly ( P ≤ 0.05) correlated with greater intensity of smoke odour, lower off-odour, and less whiteness, greater colour intensity and a redder hue of the smoked fish. It is proposed that salmon fillets can be graded according to weight, fat content and colour values prior to smoking to obtain more standardized quality characteristics of the final product after processing.     

Effect of triploidy on quality traits of shi drum (Umbrina cirrosa L.) until the second rearing year

Carcass and flesh morphometric, reological and chemical traits of triploid (3n) and diploid (2n) shi drum (Umbrina cirrosa L.) were evaluated through 7 months. Three age groups, 17‐, 21‐ and 24‐month‐old fish, were investigated. The effects of ploidy were statistically evaluated and the weight of fish was included in the model as a covariate because triploids grew less than diploids. As expected, fish weight was found to be significantly correlated with all the investigated morphometric traits, but showed a negative correlation with some chemical (pH) and colour traits (lightness) of raw fillet. In comparison with controls, triploid shi drums were characterized by different morphological traits that involved a slender body shape. In triploids, a reduction in condition factor, backbone weight, dressing index and an increase in the agility index were also recorded. When the commercial size (i.e. over 300 g) was achieved, triploids exhibited larger coelomatic and fillet (dorsal white muscle) fat deposition than diploids. Among reological traits, colour and texture were affected by ploidy; raw fillet lightness and cooked flesh tenderness were higher among triploids in all the investigated age groups. As fish were fed with a restricted feeding regimen, fillet fat deposition was supposed to be limited. Thus, the effects of ploidy on reological traits may be only partially explained by lipid fillet amount and are supposed to be more related to different fibre muscle architecture.     

Nutrient composition and sensory evaluation of fillets from wild-type Nile tilapia (Oreochromis niloticus, Linnaeus) and a red hybrid (Florida red tilapia × red O. niloticus)

A comparison of composition and sensory evaluation were performed on fillets of Oreochromis niloticus (wild type) and red hybrid tilapia (RHT) (Florida red tilapia ♂× red O. niloticus♀). Fifty male tilapia, 25 O. niloticus (initial weight 159.3 g) and 25 red hybrid (initial weight 132.4 g), were placed in each of three 2.0 m³ volume tanks. The fish were fed a commercial feed containing 35.9% crude protein during the 120‐day experimental period and then killed in cold water (3°C). All the fish were filleted. Twelve fillets from each treatment were used for proximate analyses, five fillets from each treatment were used for fatty acids analyses and the remaining fillets were used for sensory evaluation. The compositional analyses showed similar moisture, true protein and ash content in both genetic groups, but a lower crude fat content was measured in the red hybrid fillets (0.70%) compared with that of O. niloticus fillets (0.97%). No differences between O. niloticus and the red hybrid were observed in their fillet profile of fatty acids. In the sensory evaluation test, a difference in fillet flavour between both genetic groups was perceived. Of the 112 consumers in the preference test, 81.2% perceived a difference in fillet flavour between the two tilapias, with a general preference for the red hybrid over the wild‐type O. niloticus. The benefits of cultivating a RHT with a low lipid content are discussed.     

Comparison of freshwater and marine performances of all‐female diploid and triploid Atlantic salmon (Salmo salar L.)

The performance of all‐female diploid (AF2N) and triploid (AF3N) Atlantic salmon were compared in fresh water, under commercial production conditions in 1995 and 1996 year classes. The performance of the 1996 year class was also assessed for 14 months in a commercial sea farm. Freshwater mortality was higher in the triploid groups. The majority of losses occurred in the early stages of egg development and during the first feeding period, when the incidence of non‐feeding fry was consistently higher. In growth studies, although diploid fry were significantly heavier during first feeding there were no significant differences in weight between groups some 8 months after fertilization or in presmolt growth periods from February to April in 1996 and 1997. Smolting rates were high (range 93.5–95.3%) and the incidence of deformities was low (< 1%) in both groups. Marine survival was lower in the triploid group, largely as a consequence of higher losses sustained during a period of chronic stress, when triploid losses were 9% higher. Growth patterns were similar for the first 11 months in sea water. Although graded triploid salmon were heavier in January 1998 (AF3N 1.62 ± 0.033 kg, AF2N 1.46 ± 0.36 kg, P < 0.05), when the fish were harvested in May 1998 diploid salmon were significantly heavier than triploid salmon although there was no significant difference in weights after evisceration (AF3N 2.40 kg ± 0.04 AF2N 2.49 kg ±0.03). The increase in weight of the diploids between winter and harvest reflects the growth spurt that occurs in maturing fish in the spring. Overall yields of triploid salmon in salt water were lower as a result of inferior survival.     

Development of an indirect enzyme-linked immunoabsorbent assay using a monoclonal antibody to identify Ictalurus sp. fillets

The deceptive marketing of imported basa, Pangasius bocourti (Sauvage), fillets as catfish has resulted in serious economic losses to the channel catfish, Ictalurus punctatus (Rafinesque), industry in the US. The similar appearance of channel catfish and basa fillets created a need for a rapid method to differentiate uncooked, cooked and/or marinated channel catfish fillets from basa fillets and other fish products. A monoclonal antibody (MAb) specific for a 36.8 kDa channel catfish fillet protein was produced and characterized by an indirect enzyme‐linked immunoabsorbent assay (ELISA) and Western blotting. This MAb was used to develop an indirect ELISA specific for a fillet protein unique to fish of the genus Ictalurus. Using this ELISA, 100% of raw and cooked channel catfish fillets were correctly identified and differentiated from other fish in a single‐blind study. These results show that the indirect ELISA using MAbs specific for unique Ictalurus sp. fillet proteins is a rapid and sensitive method for the identification of raw and cooked catfish fillets.     

Effects of pre-rigour filleting on quality aspects of Atlantic cod (Gadus morhua L.)

Aquaculture is promising in increasing the amount of fresh Atlantic cod available all year around. The aim of this study was to investigate the effects of pre‐rigour filleting on fillet quality of wild and farmed cod. Pre‐rigour filleting resulted in significantly less fillet gaping than in fillets produced post rigour. The pre‐rigour fillets were, however, 12–13% shorter post rigour. In spite of the significantly lower water content of the muscle 6 days post mortem, a significantly higher liquid loss was seen in the pre‐rigour group. Differences in gaping score and muscle pH were dependent on whether the fish were wild or fed. Fillet gaping increased with storage time and was particularly pronounced for well‐fed cod. Fed cod had a significantly higher hydroxyproline (Hyp) content and significantly lower amount of glycosaminoglycans (GAGs) than wild cod. The ratio between GAGs and Hyp was thus significantly lower in fed cod. A connection between connective tissue components and fillet gaping may exist. However, further investigations are required.     

Muscle carotenoid concentrations in sexually maturing and immature Arctic charr, Salvelinus alpinus (L.)

Muscle carotenoid concentrations were measured in immature and maturing 2+ Arctic charr, Salvelinus alpinus (L.), sampled from April until ovulation started in November. In immature fish, muscle carotenoid concentration increased steadily and had reached about 10 mg kg^?1 by the end of the experiment. In mature fish of both sexes, pigment concentrations decreased during the autumn and muscle carotenoid concentrations were significantly lower than in the immature fish during the latter stages of the trial. No significant difference in muscle pigmentation was observed between sexes. Carotenoid concentrations were lowest in the cranial region of the fillet, but decreased in all parts of the fillet when the charr became mature. In females, the decrease seemed to be most marked in the caudal region. At the termination of the experiment, fillets accounted for about one-half of the carotenoid content in mature fish of both sexes. High concentrations of pigment were recorded in the skin and fins of mature males. In mature female charr, pigment was almost equally distributed among skin, fins and ovaries     

Color and Carotenoid Content Changes of Yellow Discolored Channel Catfish,Ictalurus punctatus,Fillets during Refrigerated Storage

Yellow pigment deposition is a quality defect associated with channel catfish fillets. This study evaluated the relationship between fillet color and carotenoid contents as well as the effect of refrigerated storage on the color and carotenoid content of discolored catfish fillets. The color and carotenoid content of the yellow fillets were analyzed using the L, a, b‐color system and high performance liquid chromatography analysis, respectively. A strong linear relationship between visual yellowness (i.e., the b‐values) of fresh catfish fillets and the sum of three major carotenoid contents was observed. Yellow discolored catfish fillets became darker and more yellow during 12 d of refrigerated storage. However, the total carotenoid content of yellow fillets decreased or remained unchanged during storage. Results suggest that while the yellow discoloration of fresh catfish fillets is related to carotenoid contents, the intensification of the discoloration during storage appears to be related to another chemical phenomenon.     

Effect of triploidy on muscle cellularity and flesh quality of turbot (Scophthalmus maximus)

Production of triploid turbot is a relevant goal for the aquaculture industry due to the benefits associated with their sterility and growth. In order for a better understanding of the final quality of the species, muscle cellularity and quality parameters of the flesh were studied in seven diploid and seven triploid turbot after sexual maturation. White muscle cellularity was evaluated throughout white muscle cross‐sectional area from the epaxial left muscle section of each fish. To ascertain the flesh quality, several physico‐chemical parameters (moisture, ash, protein, total fat, fatty acids and minerals) were analysed, and textural mechanical properties (springiness, hardness, chewiness, cohesiveness, gumminess and adhesiveness) were determined objectively with a texturometer. Muscle cellularity was different between both groups, such that muscle fibre density was higher for diploid specimens (P < 0.001) and muscle fibres diameters were higher for triploids (P < 0.001). Both ploidy groups showed no significant differences in moisture, ash, protein and total fat content (P > 0.05). All textural properties analysed showed no significant differences between both ploidy groups (P > 0.05). In both ploidy groups, fibre density and fibre diameter showed no significant correlations (P > 0.05) with textural parameters such as springiness, cohesiveness, chewiness and adhesiveness. Ploidy did not affect fatty acid composition, with the exception of eicosapentaenoic acid (C_20:5ω3) which was higher in the triploid group. No significant differences (P > 0.05) existed between diploid and triploid turbot in content of all minerals analysed. According to our results, the ploidy status determines significant variations on muscle cellularity but does not influence the flesh quality of the turbot.     

Effect of dietary lipid oxidation with vitamin C and E supplementation on fillet quality of red sea bream,Pagrus major (Temminck & Schlegel) during storage

An experiment was conducted to determine the effects of different levels of dietary vitamin C (VC) and E (VE) supplementation on fillet quality of red sea bream fed oxidized fish oil (OFO). Fish with an average body weight of 205.0 g were fed four test diets for 9 weeks. Control diet contained fresh fish oil (FFO) with 100 mg kg^?1 of VE and 500 mg kg^?1 of VC (FFO100E/500C). The other three diets contained OFO with varying levels of VE (mg kg^?1) and VC (mg kg^?1) (OFO100E/500C, OFO200E/500C and OFO200E/1000C). After feeding trial, two fillets from each fish by hand filleting were stored in a refrigerator at 4°C for 96 h during analyses. Results showed that fish fed OFO increased fillet thiobarbituric acid reactive substances (TBARS) and K‐value, and decreased fillet VC and VE concentrations during storage time. Supplementation of VC did not have any detectable effect on fillet quality. Increasing dietary VE supplementation increased fillet VE concentrations, reduced fillet TBARS and K‐value values of red sea bream. Therefore, we suggest that dietary supplementation of 200 mg kg^?1 of vitamin E could improve fillet oxidative stability of red sea bream fed OFO.     

Muscle growth of triploid Atlantic cod juveniles (Gadus morhua)

This study has investigated the muscle growth of diploid and triploid Atlantic cod (Gadus morhua) juveniles raised in replicate tanks over a period of 29 weeks and analysed at three sampling points (February, June and September). Data for weight, length, condition factor (K), muscle fibre growth and myogenic progenitor cells (MPCs) number were collected and results were analysed in relation to body growth and ploidy status. Diploids were significantly heavier than triploids throughout the trial (~10–20%) and had K in June and September samplings. Over the whole period, the rate of muscle fibres' recruitment was 318 fibres per day and 252 fibres per day for diploid and triploid cod respectively. The larger body weight of diploids resulted in a total number of fast fibre number of 114 979 compared to 91 086 in triploids. The average diameter of the 2.5% of the smallest fibres (2.5th percentile) was higher in diploids than triploids at the start of the trial, with a reversed picture for the average of the upper 2.5% (97.5th percentile) at the end of the trial. The probability density function of the estimated muscle fibre diameters showed similar fibre size distribution between size‐matched diploids and triploids at all sample points. The peak fibre diameter was approximately 25 μm in February and increased to approximately 50 μm in June and September, irrespectively of ploidy. Pax 7 were used as molecular markers for MPCs. A positive correlation between Pax 7⁺ cells and total body length was observed only among triploid fish at the onset of the experiment.     

Change in flesh quality associated with early maturation of Atlantic halibut (Hippoglossus hippoglossus)

To determine the effect of maturation on flesh quality, 20 Atlantic halibut (Hippoglossus hippoglossus) consisting of mature and immature fish of both sexes were killed on site, exsanguinated and stored on ice. After 6 days of storage, the fish was gutted and filleted before colour, texture hardness and shear force were evaluated to determine the effect of maturation. Results show that mature males excreted black mucus from the skin during ice storage, while a greyish mucus was observed from immature fish. Mature fish had approximately 2% lower slaughter yield and 6% lower fillet yield compared with immature fish. The fillets from mature males were significantly harder compared with fillets from immature fish and the muscle structure proved to be stronger as an increased fracturability was observed in mature fish. In colour, fillets from mature fish proved to have a whiter appearance (L^*) than immature fish, while no difference was seen in a^* and b^* values. We conclude that the physiological changes associated with maturation affects the end quality, and may be related to slower growth.     

Effects of acute environmental and handling exposure on physiology and fillet quality of market‐sized Channel Catfish

Catfish Ictalurus spp. are subjected to stressful conditions during harvest, which may be linked to fillet coloration and quality. Poor water quality in ponds, socks or hauling tanks, as well as handling stress, have been suggested to cause red fillets in catfish; however, chronic exposure has not resulted in red fillets. Short‐term occurrences of extreme poor water quality, particularly low dissolved oxygen, high carbon dioxide and high temperature, may occur in ponds or during harvest. Therefore, market‐sized Channel Catfish Ictalurus punctatus were acutely exposed (12 hr) to one of the three water quality treatments while confined during a simulated socking procedure and evaluated for stress responses by means of change in blood parameters and fillet quality. In fish subjected to the extreme treatment, hematocrit, plasma cortisol, glucose and lactate levels increased, with 22% mortality, indicating highly stressful conditions. In fish subjected to moderate and typical (control) treatments, cortisol increased but a lack of change or decrease in glucose and lactate indicated minimal anaerobic metabolism. Only one red fillet was produced by the extreme treatment and two by the typical treatment; therefore, the results suggest red fillets are not a product of poor water quality compounded by handling during harvest.     

Sensory characteristics and nutritional value of red drum Sciaenops ocellatus reared in freshwater and seawater conditions

This study compares sensory attributes, chemical composition, fatty acid profiles, and the taste of raw and cooked red drum Sciaenops ocellatus fillets, reared in seawater (SW) and in freshwater (FW) aquaculture systems. Significant nutritional differences were found in the raw fillets. The total lipid was higher (5.31%) in FW fish than the SW (2.60%). The ratio n‐3/n‐6 and EPA/DHA was higher in SW than FW fillets. The eicosenoic acid was only present in FW fillets. DHA was dominant in SW specimens, contrary to the arachidonic acid level, which was dominant in FW fillets. The assessors perceived a significant difference in the firmness and colour of raw fillets, but its odour intensity was not affected. Fillets from SW fish have higher acceptability (33.3%) than FW fillets (26.4%). Sensory differences in raw fillet were not correlated with consumer perceptions, as cooked fish was considered to have similar flavour, independent of its origin.     

Rapid Multiparameters Approach to Differentiate Fresh Skinless Sea Bass (Dicentrarchus labrax) Fillets from Frozen-Thawed Ones

Food authenticity is one of the major issues in the mind of today’s consumers. The sale of frozen-thawed fish fillets under the “fresh fillet” label is considered as a commercial fraud. However, their close sensory properties complicate the differentiation. This study focused on analyzing the composition of exudate (pressured flesh juice) in order to rapidly differentiate between fresh and frozen-thawed skinless fillets of sea bass (Dicentrarchus labrax). Protein concentration, α-D-glucosidase specific activity, nucleotides and related compounds (NRCs) concentration, and free calcium concentration were measured in exudates corresponding to fresh or frozen-thawed sea bass fillets. Significant increases of these four parameters were observed in exudates from frozen-thawed fillets, especially with a twofold increase in NRCs and free calcium concentrations. These results suggest that NRCs and free calcium concentrations can be promising indicators to rapidly detect mislabeling of fresh fillets.