Capillary electrophoresis analysis of orange juice pectinesterases

Pectinesterase (PE) was extracted from orange juice and pulp with 1 M NaCl, desalted, and separated using capillary electrophoresis (CE) gel procedures (CE-SDS-CGE) and isoelectric focusing (CE-IEF). PE resolved as a single peak using noncoated fused silica columns with CE-SDS-CGE. CE-IEF separation of PE required acryloylaminoethoxyethanol-coated columns, which had limited stability. Thermal stability of PE extracts before and after heating at 75 degrees C for 30 min and at 95 degrees C for 5 min established heat labile and heat stabile fractions with identical PE migration times by CE-SDS-CGE or CE-IEF. Peak magnitude decreased to a constant value as heating time increased at 75 degrees C. Regression analysis of CE-SDS-CGE peak migration times of molecular weight (MW) standards estimated both heat labile and heat stable PE at MW approximately 36 900. Traditional SDS-PAGE gel separation of MW standards and active PE isolated by IEF allowed estimation of MW approximately 36 000. CE-SDS-CGE allowed presumptive, but not quantitative, detection of active PE in fresh juice.     

Flavonoids in pigmented orange juice and second-pressure extracts

Flavanone glycosides (FGs) and polymethoxylated flavones (PMFs) have been studied in pigmented orange (Citrus sinensis) juices and second-pressure extracts (SPEs) by high-performance liquid chromatography and diode array detector. Detection was performed simultaneously at two different wavelengths: 278 nm (for determination of FGs) and 325 nm (for determination of PMFs). Qualitative distribution patterns of FGs and PMFs in juices and SPEs were similar, although the quantitative results are quite different. An increased narirutin/hesperidin ratio after centrifugation and the presence of high amounts of PMFs in SPEs, which remain unchanged after centrifugation, were observed. Therefore, a simple and affordable procedure to distinguish an orange juice from SPEs was proposed.     

Identification and aroma impact of norisoprenoids in orange juice

Four norisoprenoids, alpha-ionone, beta-ionone, beta-cyclocitral, and beta-damascenone, along with their putative carotenoid precursors, were identified in Valencia orange juice using time-intensity GC-O, GC-MS, and photodiode array HPLC. alpha-Ionone and beta-cyclocitral are reported in orange juice for the first time. GC-O aroma peaks were categorized into seven groups with similar sensory qualities: citrus/minty, metallic/mushroom/geranium, roasted/cooked/meaty/spice, fatty/soapy/green, sulfury/solventy/medicine, floral, and sweet fruity. The four norisoprenoids contributed approximately 8% of the total aroma intensity and 78% of the total floral aroma category. The putative carotenoid norisoprenoid precursors, alpha- and beta-carotene, alpha- and beta-cryptoxanthin, and neoxanthin, were identified in the same orange juice using photodiode array HPLC retention times and spectral characteristics.     

橙汁冷冻浓缩动力学模型的研究

为了降低果汁在冷冻浓缩过程中由于冰晶夹带造成的的损失并提高浓缩速度,需要获得冷冻浓缩过程中冰晶的增长规律。以橙汁为原料,采用二级冷冻浓缩方法,利用冰与水溶液之间的固液相平衡的原理,将水分从液态转变为固态的冰,使橙汁的浓度从13°Bx浓缩到34°Bx。该试验中,测定了橙汁的浓度及其对应的冻结点温度的关系,结果表明:在试验范围内,冻结点与浓度呈线性关系并随浓度的升高而降低。该文还研究了在冰晶中所夹带的可溶性固形物与橙汁浓度的关系,所获得分配系数K表明,冰晶中所夹带的可溶性固形物随浓度的提高而增加。根据Fick扩散方程式建立了冰晶增长动力学模型,模型显示冰晶增长速率与冰晶质量成正比,同时也受到最大冰晶量的抑制,采用Powell法,对试验数据回归模型参数、采用龙格—库塔法进行数值积分求得模型解,计算结果与试验结果吻合,该模型有助于为建立冰晶增长的质量、热量传递之间的平衡提供一定的理论依据和试验参考,加深对橙汁冷冻浓缩过程的认识。     

Carotenoid profile modification during refrigerated storage in untreated and pasteurized orange juice and orange juice treated with high-intensity pulsed electric fields

A comparative study was made of the evolution and modification of various carotenoids and vitamin A in untreated orange juice, pasteurized orange juice (90 degrees C, 20 s), and orange juice processed with high-intensity pulsed electric fields (HIPEF) (30 kV/cm, 100 micros), during 7 weeks of storage at 2 and 10 degrees C. The concentration of total carotenoids in the untreated juice decreased by 12.6% when the juice was pasteurized, whereas the decrease was only 6.7% when the juice was treated with HIPEF. Vitamin A was greatest in the untreated orange juice, followed by orange juice treated with HIPEF (decrease of 7.52%) and, last, pasteurized orange juice (decrease of 15.62%). The decrease in the concentrations of total carotenoids and vitamin A during storage in refrigeration was greater in the untreated orange juice and the pasteurized juice than in the juice treated with HIPEF. During storage at 10 degrees C, auroxanthin formed in the untreated juice and in the juice treated with HIPEF. This carotenoid is a degradation product of violaxanthin. The concentration of antheraxanthin decreased during storage, and it was converted into mutatoxanthin, except in the untreated and pasteurized orange juices stored at 2 degrees C.     

Linalool in orange juice: origin and thermal stability

Linalool concentrations were determined in juice from three groups of 60 Valencia oranges using pentane:ether extraction and high-resolution capillary GC. The outer peel (flavedo) was removed from one group. The other two groups retained their peel intact. Juice was extricated from the halved fruits of the flavedo-less group and from one of the peel-intact groups using a hand reamer. A peel-cutting/macerating juice extractor was used for the other peel-intact group. Linalool concentrations were 0.004 mg/L in peeled fruit juice and 0.020 and 0.106 mg/L for hand-reamed and mechanically extracted peel-intact juice, respectively. Juice from peeled fruit contained significantly (P < 0.05) less linalool than peel-intact juice. Approximately 80% of the total juice linalool content was associated with peel using reamer design, and 96% was associated with peel-cutting/macerating design. Linalool increased with increasing peel oil levels; however, the increases were not proportionate. Since all commercial juices are mechanically extracted, the vast majority of linalool in commercial orange juice originates from the peel and not from the juice vesicle cytoplasm. Juice from peel-macerated, mechanically extracted fruit increased from 0.106 to 0.134 mg/kg after thermal processing, whereas juice from reamer extraction was essentially unchanged.     

Bioavailability and antioxidant effects of orange juice components in humans

Seven healthy females and six males consumed daily 256 mg of vitamin C, 271 mg of flavanones (mainly as glycosides), 6 mg of carotenoids (mainly xanthophylls and cryptoxanthins), and 0.16 mg of folate by incorporation of daily three times 236 mL of not from concentrate orange juice (OJ) into their habitual diet. At the end of 3 weeks, mean vitamin C, folate, carotenoid, and flavanone plasma concentrations increased significantly relative to baseline by 59% (p < 0.001), 46% (p = 0.018), and 22% (p < 0.001), and 8-fold (p = 0.045), respectively. Flavanones were excreted in urine 9-fold more at the end of the intervention (p = 0.01) but returned to baseline 2 days after study completion. After the 3 week intervention, plasma concentrations of vitamins A and E did not change. 8-Hydroxydeoxyguanosine in white blood cells declined by 16% (p = 0.38; n = 11), and in individuals with high baseline concentrations by 29% (p = 0.36; n = 7), respectively. Low-density lipoprotein (LDL)-/high-density lipoprotein (HDL)-cholesterol ratios decreased but cholesterol (HDL, LDL, total) and thiobarbituric acid reactive substance plasma concentrations did not change significantly. We conclude from this pilot study that OJ is an excellent food source to enhance circulating concentrations of valuable hydrophilic as well as lipophilic phytochemicals.     

Early stages of maillard reaction in dehydrated orange juice.

The formation of furoylmethyl derivatives of amino acids as indicators of the early stages of Maillard reaction in dehydrated orange juices and model systems was studied. In stored dehydrated orange juices, the presence of furoylmethyl derivatives of arginine, asparagine, proline, alanine, glutamic acid, and GABA was detected. Their formation increased with temperature of storage. After 2 weeks at 30 degrees C and a(w) = 0.44, the reconstituted orange juice contained 94 mg/L furoylmethyl derivatives, whereas up to 1215 mg/L was detected in samples stored at 50 degrees C.     

Anaerobic digestion of wastewater derived from the pressing of orange peel generated in orange juice production

A study of the anaerobic digestion of wastewater from the pressing of orange peel generated in orange juice production was carried out in a laboratory-scale completely stirred tank reactor at mesophilic temperature (37 degrees C). Prior to anaerobic treatment the raw wastewater was subjected to physicochemical treatment using aluminum sulfate as a flocculant and to pH reduction using a solution of sulfuric acid. The reactor was batch fed at COD loads of 1.5, 2.0, 2.5, 3.0, 3.5, 4.0, 4.5, and 5.0 g of COD. The process was very stable for all of the loads studied, with mean pH and alkalinity values of 7.5 and 3220 mg of CaCO3/L, respectively. The anaerobic digestion of this substrate was found to follow a first-order kinetic model, from which the specific rate constants for methane production, K(G), were determined. The K(G) values decreased considerably from 0.0672 to 0.0078 L/(g h) when the COD load increased from 1.5 to 5.0 g of COD, indicating an inhibition phenomenon in the system studied. The proposed model predicted the behavior of the reactor very accurately, showing deviations of <5% between the experimental and theoretical values of methane production. The methane yield coefficient was found to be 295 mL of CH4 STP/g of COD removed, whereas the mean biodegradability of the substrate (TOC) was 88.2%. A first-order kinetic model for substrate (TOC) consumption allowed determination of the specific rate constants for substrate uptake, K(C), which also decreased with increasing loading, confirming the above-mentioned inhibition process. Finally, the evolution of the individual volatile fatty acid concentrations (acetic, C2; propionic, C3; butyric, C4; isobutyric, iC4; valeric, C5; isovaleric, iC5; and caproic, C6) with digestion time for all loads used was also studied. The main acids generated were acetic and propionic for all loads studied, facilitating the conversion into methane.     

Stability and sensory shelf life of orange juice pasteurized by continuous ohmic heating

Electrical heating of food products provides rapid and uniform heating, resulting in less thermal damage to the product. The objective of this research was to examine the effects of ohmic heating on the stability of orange juice with comparison to conventional pasteurization. During storage at 4 degrees C, degradation curves of ascorbic acid followed a linear decrease pattern in both ohmic-heated and conventionally pasteurized orange juices. For five representative flavor compounds (decanal, octana, limonene, pinene, and myrcene), higher concentrations were measured during storage in the ohmic-heated orange juice than in conventionally pasteurized juice. Although residual pectin esterase activity remained negligible in both types of juices, particle size was lower in the ohmic-heated orange juice. The sensory shelf life was determined by using the Weibull-Hazard method. Although both thermal treatments prevented the growth of microorganisms for 105 days, the sensory shelf life of ohmic-treated orange juice was >100 days and was almost 2 times longer than that of conventionally pasteurized juice.     

Liquid chromatographic determination of naringin and neohesperidin as a detector of grapefruit juice in orange juice

Naringin/neohesperidin ratios can be used to differentiate orange juice which may contain added grapefruit juice from orange juice which may include juices from other naringin-containing cultivars. The naringin/neohesperidin ratios in juice vary from 14 to 83 in grapefruit (C. grandis) and from 1.3 to 2.5 in sour orange (C. aurantium) cultivars; the ratio is always less than 1 for the K-Early tangelo. Concentrations of both naringin and neohesperidin can be determined in orange juice by using a single liquid chromatographic isocratic reverse-phase system with a C-18 column. The detection limit for both compounds is 1 ppm with a linear working range to 500 ppm. Concentration relative standard deviations range from 0.47 to 1.06% for naringin and from 0.4 to 1.27% for neohesperidin. Naringin and neohesperidin recoveries ranged from 93 to 102% at concentrations of 5 and 50 ppm. Naringin values from blind duplicate samples of orange/grapefruit juice blends could be duplicated to +/- 3%.     

Immunoanalytical method for quality control of orange juice products

The main goal of the present study is to develop an immunoanalytical method for the quality control of orange juice products. Peptides from various parts (juice, albedo, and flavedo) of citrus fruits (orange, mandarin, grapefruit, and lemon) were analyzed and isolated by SDS-PAGE. Antisera were developed in mice against the protein pool of orange juice and peel and tested by Western blot analysis. Using these antisera, some juice- and peel-specific peptides were detected. One of the antibodies in the antiserum developed against peel proteins recognized a single peel-specific peptide with a molecular mass of 28 kDa in 10000-fold dilution. It did not give any positive reactions against the sample prepared from the juice. The 24 and 27 kDa juice-specific peptides were isolated in electrophoretically pure form, and polyclonal antibodies were developed against them in mice. The anti-27 kDa antibody reacted with a 29 kDa protein in the peel sample, and it gave a positive reaction against the 27 kDa peptide of the juice. The antibodies developed in the course of the present work seem to be useful for determining the juice content in commercial citrus beverages and for evaluating the peel contamination in them.     

Liquid chromatographic methodology for the characterization of orange juice

Liquid chromatographic (LC) methodology potentially useful for the characterization of orange juice, with particular regard to detecting adulteration of orange juice by computer pattern recognition analysis, has been developed. After dilution with methanol the juice is extracted with hexane to remove the carotenoids, which are chromatographed on a C18 column with an acetonitrile-methanol-methylene chloride mobile phase and detection at 450 nm. Further extraction of the juice with methylene chloride isolates the methoxylated flavones, which are chromatographed by reverse phase LC with an acetonitrile-methanol-water mobile phase and detection at 280 nm. The flavanone glycosides remaining in solution are chromatographed on a C18 column with an acetonitrile-water mobile phase and detection at 280 nm. The precisions of the heights of the 32 LC peaks selected for pattern recognition analysis were determined from 5 replicate analyses of a single juice. Coefficients of variation of the replicates ranged from 0.3 to 4.5%, with an average of 2.1%. Adulteration of products with sodium benzoate-fortified pulpwash or grapefruit juice can be detected by this method. Pattern recognition analysis of the data obtained for 80 authentic and 19 adulterated orange juices showed that the method is potentially useful for distinguishing between authentic and adulterated products.     

In vitro availability of flavonoids and other phenolics in orange juice

Hand-squeezed navel orange juice contains 839 mg/L phenolics, including flavanones, flavones, and hydroxycinnamic acid derivatives. The flavanones are the main phenolics in the soluble fraction (648.6 mg/L) and are also present in the cloud fraction (104.8 mg/L). During refrigerated storage of fresh juice (4 degrees C), 50% of the soluble flavanones precipitate and integrate into the cloud fraction. Commercial orange juices contain only 81-200 mg/L soluble flavanones (15-33%) and the content in the cloud is higher (206-644 mg/L) (62-85%), showing that during industrial processing and storage the soluble flavanones precipitate and are included in the cloud. An in vitro simulation of orange juice digestion shows that a serving of fresh orange juice (240 mL) provides 9.7 mg of soluble hesperidin (4'-methoxy-3',5,7-trihydroxyflavanone-7-rutinoside) and 4.7 mg of the C-glycosylflavone vicenin 2 (apigenin, 6,8-di-C-glucoside) for freshly squeezed orange juice, whereas pasteurized commercial juices provide 3.7 mg of soluble hesperidin and a higher amount of vicenin 2 (6.3 mg). This means that although orange juice is a very rich source of flavanones, only a limited quantity is soluble, and this might affect availability for absorption (11-36% of the soluble flavanones, depending on the juice). The flavanones precipitated in the cloud are not available for absorption and are partly transformed to the corresponding chalcones during the pancreatin-bile digestion.     

Characterization of the anthocyanin fraction of sicilian blood orange juice by micro-HPLC-ESI/MS

Anthocyanins of red orange juices were analyzed by micro-HPLC coupled on-line with an MS detector equipped with an ESI source. The use of microcolumn HPLC greatly enhanced detection performance, allowing direct identification of the anthocyanins present in the orange juices. The use of a soft ionization technique allows detection of the molecular ions of the aglycons. Eight components were identified, five of them for the first time in red orange juice. Three additional anthocyanins were detected, of which only the aglycon was identified.     

Gas chromatographic determination of fatty acids and sterols in orange juice

A gas chromatographic (GC) method has been developed for the simultaneous quantitation of fatty acids and sterols in orange juice, using a bonded phase fused silica capillary column of intermediate polarity, splitless automatic injection, and flame ionization detection. Sample preparation has been simplified by using 1 g C-18 adsorbent in a disposable minicolumn to extract 2 mL orange juice. Methylation of fatty acids and silylation of the sterols were carried out in the eluted extract (low polarity lipid fraction). The method precision was 7%; recoveries ranged from 83 to 113%. The precision of the injection technique was 2%. Seven major fatty acids and 5 sterols in orange juice were quantitated by the GC method and identified by GC/mass spectrometry. Quantitative data for several orange juice samples indicated that the levels of the compounds of interest were in the 1.3-72.0 mg/L range. The results demonstrate that bonded phase fused silica capillary GC has great versatility and potential for the quantitative determination of fatty acids and sterols.     

柑桔汁陶瓷膜微滤澄清和污染阻力试验

为了探讨柑桔汁微滤澄清技术及微滤膜污染阻力,建立膜清洗方法,研究以0.2 mm陶瓷膜微滤柑桔汁时膜通量变化及处理效果,结果表明：当温度30℃、压差0.16 MPa及膜面流速4 m/s时,全循环模式下稳定膜通量为22.4 L/(m2·h),浓缩模式下体积浓缩因子为12时,膜通量为10.6 L/(m2·h),澄清汁得率达91.67%;澄清汁浊度仅为0.62 NTU,澄清度高达99.93%,且各主要营养成分变化不大。通过建立膜污染阻力模型,考察操作参数对各分解阻力的影响,进而研究膜污染动力学后发现：压差对不可逆极化层阻力影响最为明显;增大膜面流速显著降低各极化层阻力,但对不可逆污染阻力作用不大;升高温度使得各阻力下降;膜污染可用拟二级速率方程描述。研究污染膜清洗过程,结果表明采用去离子水、1% NaOH和0.5% NaClO混合液、0.2% HNO3溶液依次清洗膜,膜通量可迅速恢复。     

猕猴桃汁维生素C降解动力学的研究

以猕猴桃原汁为试材,采用控制温度、调节pH值以促使维生素C氧化降解的方法,探讨猕猴桃汁中维生素C的降解动力学,为控制猕猴桃汁加工中维生素C损失提供理论依据。结果表明：猕猴桃汁中的维生素C降解十分复杂,存在多种降解途径,但主要是有氧降解;其还原型维生素C不经氧化型维生素C生成其他产物的不可逆途径可能存在,但不占主导地位。猕猴桃汁中维生素C无氧降解速度比有氧降解速度慢,温度升高,维生素C有氧降解速度加快,无氧降解速度变化不明显。