High-moisture corn utilization in finishing cattle

Two finishing trials, one laboratory trial and one metabolism trial were conducted with the following objectives: 1) to determine the associative effects of feeding high-moisture corn (HMC) with either dry-rolled grain sorghum (DRGS) or dry-rolled corn (DRC) and 2) to evaluate HMC when harvested at different moisture levels, stored in different structures, or fed as whole or rolled HMC. In Trial 1, yearling steers (BW, 328 kg) were fed diets containing mixtures of HMC and DRGS. As level (0, 33, 100%, as percentage of grain DM) of DRGS increased, ADG (P less than .03) and gain/feed (P less than .001) decreased linearly; gain/feed tended to be affected quadratically (P = .14). In Trial 2, yearling steers (BW, 382 kg) fed HMC, stored whole in an upright, oxygen-limiting silo and rolled coarsely before feeding, gained faster (1.46 vs 1.36 kg/d) and more efficiently (.142 vs. .131 gain/feed) than steers fed whole HMC (P less than .01). In Trial 3, as length of storage of bunker HMC increased, in vitro rate of starch digestion and soluble N content increased (20.4 and 36.8%, respectively) and grain pH decreased (10.9%). In Trial 4, steers fed HMC or a mixture of 75% HMC with 25% DRGS had similar ruminal pH throughout a grain adaptation period, but total ruminal VFA were greater (P less than .005) for steers fed HMC alone. These data are interpreted to suggest that feeding a mixture of HMC, ground and stored in a bunker or silo bag, with DRGS will result in a 3.2% associative effect. However, no associative effects were measured when a mixture of HMC, stored whole and fed whole or rolled, and DRC were fed.     

The influence of oscillating dietary protein concentrations on finishing cattle. I. Feedlot performance and odorous compound production

We hypothesized that oscillation of the dietary CP concentration, which may improve N retention of finishing beef steers, would reduce production of manure odor compounds and total N inputs while yielding comparable performance. Charolais-sired steers (n = 144; 303 +/- 5 kg of initial BW) were used in a completely randomized block design (6 pens/treatment). The steers were fed to 567 kg of BW on the following finishing diets, which were based on dry-rolled corn: 1) low (9.1% CP), 2) medium (11.8% CP), 3) high (14.9% CP), or 4) low and high oscillated on a 48-h interval for each feed (oscillating). Steers fed low tended (P = 0.08) to have less DMI (7.80 kg/d) than steers fed medium (8.60 kg/d) or oscillating (8.67 kg/d), but not less than steers fed high (8.12 kg/d). Daily N intake was greatest (P < 0.01) for steers fed high (189 g), intermediate for medium (160 g) and oscillating (164 g), and least for low (113 g). The ADG was lower (P < 0.01) for steers fed low (1.03 kg) than for those fed medium (1.45 kg), high (1.45 kg), or oscillating (1.43 kg). Similarly, steers fed low had a lower adjusted fat thickness (P < 0.01) and yield grade (P = 0.05) and tended (P = 0.10) to have less marbling than steers fed the other 3 diets. In slurries with feces, urine, soil, and water, incubated for 35 d, nonsoluble CP was similar among slurries from steers fed medium, high, or oscillating, but was less (P < 0.01) in slurries from steers fed low. However, throughout the incubation period, slurries from steers fed high or oscillating had greater (P < 0.01) concentrations of total aromatics and ammonia than those from steers fed low or medium. Also, the slurries from steers fed oscillating had greater (P < 0.01) concentrations of branched-chain VFA than manure slurries from steers fed any of the other diets. These data indicate that although there is no apparent alteration in the performance of finishing steers fed diets with oscillation of the dietary protein, there may be undesirable increases in the production of compounds associated with malodor.     

Corn processing method in finishing diets containing wet corn gluten feed

Two trials were conducted to determine the effect of corn processing method on performance and carcass traits in steers fed finishing diets containing wet corn gluten feed (WCGF). In Trial 1, 480 steer calves (303 kg initial BW) were fed eight finishing diets: 1) dry-rolled corn (DRC) without; and 2) with 32% (DM basis) WCGF; 3) steam-flaked corn (SFC) without; and 4) with WCGF; 5) a combination of DRC and SFC without WCGF; 6) finely-ground corn (FGC) with WCGF; 7) high-moisture corn (HMC) with WCGF; and 8) whole corn (WC) with WCGF. Feeding WC + WCGF increased (P < 0.10) DMI and decreased gain:feed compared with all other treatments. Feeding DRC + WCGF increased (P < 0.10) DMI and decreased (P < 0.10) gain:feed compared with treatments other than WC + WCGF. Steers on treatments that included WCGF gained similarly, regardless of corn processing method, and at a rate 6% faster (P < 0.10) than steers fed diets that did not include WCGF. Gain:feed did not differ among steers fed SFC, SFC + WCGF, SFC + DRC, and HMC + WCGF. Steers fed SFC or SFC + WCGF were more efficient (P < 0.10) than steers fed DRC or FGC + WCGF. In Trial 2, 288 steer calves (382 kg initial BW) were fed six finishing diets: 1) DRC without; and 2) with 22% (DM basis) WCGF; 3) SFC without; and 4) with WCGF; 5) finely rolled corn (FRC) with WCGF; and 6) HMC corn with WCGF. Steers fed DRC + WCGF or FRC + WCGF consumed more DM (P < 0.10) than steers fed DRC, SFC, or SFC + WCGF. Feed intake did not differ between steers fed SFC + WCGF and HMC + WCGF. All treatment groups receiving WCGF consumed more DM (P < 0.10) feed than steers fed DRC or SFC without WCGF. Steers fed SFC + WCGF gained 8% faster (P < 0.10), and steers fed DRC 9.5% slower (P < 0.10) than steers receiving all other treatments. Daily gains did not differ among other treatment groups. Steers fed SFC or SFC + WCGF gained 10% more (P < 0.10) efficiently than all other treatment groups. Feed efficiency did not differ among steers fed DRC, DRC + WCGF, FRC + WCGF, and HMC + WCGF. Estimates for the NEg of WCGF calculated from animal performance indicated that WCGF contained approximately 25.3% more energy when fed with SFC than when fed with DRC. In general, more intensively processing corn improved gain:feed in finishing diets containing WCGF.     

Effects of distillers grains with high sulfur concentration on ruminal fermentation and digestibility of finishing diets

Twelve ruminally cannulated crossbred Angus steers were used to evaluate ruminal fermentation characteristics and diet digestibility when 30% (DM) corn dried distillers grains with solubles (DDGS) containing 0.42 or 0.65% (DM) of dietary S was incorporated into finishing diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC). The study was a replicated, balanced randomized incomplete block design with a 2 × 2 factorial arrangement of treatments. Factors consisted of dietary S concentration (0.42 and 0.65% of DM; 0.42S and 0.65S, respectively) and grain processing method (SFC or DRC). The 0.65S concentration was achieved by adding H(2)SO(4) to DDGS before mixing rations. Steers were assigned randomly to diets and individual, slatted-floor pens, and fed once daily for ad libitum intake. Two 15-d experimental periods were used, each consisting of a 12-d diet adaptation phase and a 3-d sample collection phase. Samples were collected at 2-h intervals postfeeding during the collection phase. Ruminal pH was measured immediately after sampling, and concentrations of ruminal ammonia and VFA were determined. Fecal samples were composited by steer within period and used to determine apparent total tract digestibilities of DM, OM, NDF, CP, starch, and ether extract. Feeding 0.65S tended (P = 0.08) to decrease DMI but resulted in greater apparent total tract digestibilities of DM (P = 0.04) and ether extract (P = 0.03). Ruminal pH increased (P < 0.05) in steers fed 0.65S diets, which may be attributable, in part, to decreased (P = 0.05) VFA concentrations and greater (P < 0.01) ruminal ammonia concentrations when 0.65S was fed, compared with feeding 0.42S. These effects were more exaggerated in steers fed DRC (interaction, P < 0.01), compared with steers fed SFC. Steers fed DRC-0.65S had greater (P < 0.01) acetate concentration than steers fed DRC-0.42S, but acetate concentration was not affected by S concentration when SFC was fed. Propionate concentration was decreased (P < 0.01) in steers fed SFC-0.65S compared with steers fed SFC-0.42S, but dietary S concentration had no effect on propionate concentration when DRC was fed. Butyrate concentration was less (P < 0.01) in steers fed 0.65S diets than in steers fed 0.42S. Lactate concentrations tended (P = 0.06) to decrease in steers fed 0.65S diets. Feeding DDGS with increased S concentration may decrease feed intake and ruminal VFA concentration but increase ruminal ammonia concentration.     

An in vitro study of manure composition on the biochemical origins,composition, and accumulation of odorous compounds in cattle feedlots

Very little is known about the biochemical origin of cattle feedlot odors and the environmental factors controlling their production. The tie between diet and manure composition is well established, but the effect of different manure compositions on odorous chemical production is unknown. This study describes the effect of starch, casein, and cellulose substrate additions to slurries of fresh (< 24 h) and aged cattle manure (> 1 d) on the anaerobic production of fermentation products and the consumption of substrates relative to no addition treatments. Aged cattle manure accumulated more VFA (245 to 290 mM) than the fresh manure (91 to 181 mM) irrespective of substrate additions (P < 0.001). In fresh manures, VFA concentrations were increased (P < 0.01) over no addition treatments when carbohydrate (starch or cellulose) was added, whereas starch and protein treatments to aged manure increased VFA content relative to no addition treatments (P < 0.001). Branched-chain VFA and aromatic compounds accumulated only in the aged manure (no addition and protein treatments), indicating that some protein fermentation occurred in those treatments. Based upon substrate loss, starch fermentation was the dominant process in both manures and all treatments with losses exceeding 18.6 g/L. Protein fermentation occurred only in the aged manure, specifically the no addition and protein treatments, when starch was no longer available. The production of odorous compounds from manure was controlled by substrate availability and pH, with pH related to lactate accumulation. We believe that calcareous soil and lactate-consuming microorganisms in the aged manure slurries minimized slurry acidification and resulted in greater accumulations of odorous products. Substrate additions had little effect on the overall accumulation of odor compounds in manure but had profound effects on odor compound composition. We propose that modifying cattle diets to limit starch and protein excretion would profoundly affect the production and accumulation of odor compounds in feedlots.     

Effects of wet corn gluten feed and intake level on diet digestibility and ruminal passage rate in steers

Twelve ruminally cannulated Jersey steers (BW = 534 kg) were used in an incomplete Latin square design experiment with a 2 x 2 factorial arrangement of treatments to determine the effects of wet corn gluten feed (WCGF) and total DMI level on diet digestibility and ruminal passage rate. Treatments consisted of diets formulated to contain (DM basis) steam-flaked corn, 20% coarsely ground alfalfa hay, and either 0 or 40% WCGF offered once daily for ad libitum consumption or limited to 1.6% of BW (DM basis). Two consecutive 24-d periods were used, each consisting of 18 d for adaptation, 4 d for collection, and a 2-d in situ period. Rumens of all steers were evacuated once daily at 0, 4, 8, and 12 h after feeding. Chromic oxide (10 g/[steer*d]) was fed as a digestibility marker, and steers were pulse-dosed with Yb-labeled alfalfa hay to measure ruminal particulate passage rate. Dacron bags containing 5 g of steam-flaked corn, WCGF, or ground (2-mm screen) alfalfa hay were placed into the rumens of all steers and removed after 3, 6, 12, or 48 h. Wet corn gluten feed increased percent apparent total-tract digestion of OM (P < 0.01), NDF (P < 0.01), and starch (P < 0.03), decreased (P < 0.01) ruminal total VFA concentration, increased (P < 0.01) ruminal NH3 concentration, and increased (P < 0.01) ruminal pH. Wet corn gluten feed also increased (P < 0.01) ruminal passage rate of Yb. Limit feeding decreased (P < 0.01) percent apparent total-tract digestion of both OM and NDF, ruminal total VFA concentration (P < 0.01), and ruminal fill (P < 0.01), but increased (P < 0.01) ruminal NH3 concentration. Apparent total-tract digestion of starch was not affected (P = 0.70) by level of DMI. A DMI level x hour interaction (P < 0.01) occurred for ruminal pH. Limit feeding increased ruminal pH before and 12 h after feeding, but decreased ruminal pH 4 h after feeding compared with diets offered ad libitum. A diet x DMI level interaction (P < 0.02) occurred for in situ degradation of alfalfa hay, with dietary addition of WCGF increasing (P < 0.02) the extent of in situ alfalfa hay degradation in steers fed for ad libitum consumption. This study suggests that WCGF increases OM and NDF digestion, and that limit feeding diets once daily might depress OM and NDF digestion, possibly due to decreased stability of the ruminal environment.     

Effects of dry, wet, and rehydrated corn bran and corn processing method in beef finishing diets

Two finishing trials were conducted to determine the effects of adding different types of corn bran, a component of corn gluten feed, on cattle performance. In Trial 1, 60 English crossbred yearling steers (283 +/- 6.7 kg) were used in a completely randomized design with four dietary treatments. Treatments were diets with no corn bran, dry corn bran (86% DM), wet corn bran (37% DM), and rehydrated dry bran (37% DM). Bran was fed at 40% of dietary DM. All finishing diets had (DM basis) 9% corn steep liquor with distillers solubles, 7.5% alfalfa hay, 3% tallow, and 5% supplement. Gain efficiency and ADG were greater (P < 0.01) for cattle fed no corn bran compared with all treatments containing corn bran; however, no differences were detected across corn bran types. In Trial 2, 340 English crossbred yearling steers (354 +/- 0.6 kg) were used in a randomized block design with treatments assigned based on a 2 x 4 + 2 factorial arrangement (four pens per treatment). One factor was the corn processing method used (dry-rolled corn, DRC; or steam-flaked corn, SFC). The other factor was corn bran type: dry (90% DM), wet (40% DM), or dry bran rehydrated to 40 or 60% DM. Bran was fed at 30% of dietary DM, replacing either DRC or SFC. Two control diets (DRC and SFC) were fed with no added bran. All finishing diets contained (DM basis) 10% corn steep liquor with distiller's solubles, 3.5% alfalfa hay, 3.5% sorghum silage, and 5% supplement. Corn bran type did not affect DMI (P = 0.61), ADG (P = 0.53), or G:F (P = 0.10). Dry matter intake was greater (P < 0.01) by steers fed bran compared with those fed no bran, and was greater by steers fed DRC than by steers fed SFC (P < 0.01). Interactions occurred (P < 0.01) between grain source and bran inclusion for ADG and G:F. The ADG by steers fed the SFC diet without bran was greater (P < 0.01) than by steers fed SFC diets with bran, whereas the ADG by steers fed DRC diets with or without bran was similar. Daily gain was 15.2% greater (P < 0.01) by steers fed SFC without bran than by steers fed DRC without bran. Gain efficiency was 16.9% greater (P < 0.01) for steers fed SFC without bran compared with steers fed DRC without bran. In DRC and SFC diets, feeding bran decreased (P < 0.01) G:F by 5.2 and 13.8%, respectively. The moisture content of corn bran had no effect on finishing steer performance, and drying corn bran did not affect its energy value in finishing cattle diets.     

Effect of corn processing on starch digestion and bacterial crude protein flow in finishing cattle

Six ruminally and duodenally cannulated yearling steers (523 kg) were used in a replicated 3 x 3 Latin square design experiment to study the effects of corn processing on nutrient digestion, bacterial CP production, and ruminal fermentation. Dietary treatments consisted of 90% concentrate diets that were based on dry-rolled (DRC), high-moisture (HMC), or steam-flaked (SFC) corn. Each diet contained 2.0% urea (DM basis) as the sole source of supplemental nitrogen. Each period lasted 17 d, with d 1 through 14 for diet adaptation and d 15 through 17 for fecal, duodenal, and ruminal sampling. Dry matter and OM intakes were similar for DRC and SFC but were approximately 15% higher (P < 0.05) for HMC. True ruminal OM digestibilities were 18 and 10% greater (P < 0.05) for HMC than for DRC or SFC, respectively. Ruminal starch digestibilities were similar between HMC and SFC and were approximately 19% greater (P < 0.05) than DRC. Postruminal OM digestibility was similar among treatments; however, postruminal starch digestibility was 15% greater (P < 0.05) for SFC than for DRC or HMC, which were similar. Total-tract DM and OM digestibilities were similar between HMC and SFC and were 4% greater (P < 0.05) than DRC. Likewise, total-tract starch digestibilities were similar between HMC and SFC and were 3% greater (P < 0.05) than DRC. Bacterial CP flow to the duodenum was 29% greater (P < 0.05) for HMC than for DRC or SFC, which were similar. Bacterial N efficiencies were similar among treatments. Based on bacterial CP flow from the rumen, we estimate that dietary DIP requirements are approximately 12% higher for HMC-based diets than for DRC or SFC-based diets, which were similar.     

Influence of genotype and diet on steer performance, manure odor, and carriage of pathogenic and other fecal bacteria. III. Odorous compound production

Three beef cattle diets were assessed for their potential to produce odorous compounds from cattle feces excreted during the growing and finishing periods. Eight pens containing 51 steers of varying proportions of Brahman and MARC III genotypes were fed either a chopped bromegrass hay diet or a corn silage diet for a 119-d growing period. After the growing period, all steers were switched to the same high-corn finishing diet (high corn) and fed to a target weight of 560 kg (finishing period). Fecal slurries were prepared from a composite of fresh fecal pats collected in each pen during both periods and incubated anaerobically. In additional flasks, starch, protein, or cellulose was added to the composite fecal subsamples to determine the preferred substrates for fermentation and odorous compound production. The content and composition of the fermentation products varied both initially and during the incubation, depending on the diet fed to the steers. The corn silage and high corn feces had the greater initial content of VFA (381.0 and 524.4 micromol/g of DM, respectively) compared with the bromegrass feces (139.3 micromol/g of DM) and accumulated more VFA than the bromegrass feces during the incubation. l-Lactic acid and VFA accumulation in the high corn and corn silage feces was at the expense of starch, based on starch loss and the production of straight-chain VFA. In the bromegrass feces, accumulation of branched-chain VFA and aromatic compounds and the low starch availability indicated that the protein in the feces was the primary source for odorous compound production. Substrate additions confirmed these conclusions. We conclude that starch availability was the primary factor determining accumulation and composition of malodorous fermentation products, and when starch was unavailable, fecal microorganisms utilized protein.     

The influence of oscillating dietary protein concentrations on finishing cattle. II. Nutrient retention and ammonia emissions

We hypothesized that oscillation of the dietary CP concentrations would improve efficiency of N use and reduce N loss to the environment. Charolais-cross steers (n = 8; 315 +/- 21 kg of BW) were used in a replicated 4 x 4 Latin square design. The steers were allowed ad libitum access to the following diets: 1) 9.1% CP (low), 2) 11.8% CP (medium), 3) 13.9% CP (high), or 4) low and high oscillated on a 48-h interval on each diet (oscillating). Dry matter intake did not differ among treatments (P = 0.46), but N intake differed (P < 0.01) from 94 (low) to 131 (medium), 142 (high), and 133 g/d (oscillating), as designed. Dry matter digestibility increased (P < 0.01) from 71.8% (low) to 75.8% (medium), 77.7% (high), and 77.5% (oscillating). Nitrogen digestibility increased (P < 0.01) from 62.2% (low) to 67.2% (medium) to 70.1% (high) and 70.9% (oscillating). Nitrogen retention was greater (P < 0.01) in steers fed oscillating (55.0 g/d) than in the steers fed low (34.8 g/ d) or high (40.2 g/d), but N retention of steers fed medium (49.8 g/d) differed (P = 0.02) only from that of steers fed low. Urinary urea N did not differ between steers fed medium (19.5 g/d) or oscillating (21.3 g/d) but was lowest (P < 0.01) for those fed low (8.2 g/d) and greatest for those fed high (39.2 g/d). Daily heat production (kcal/BW(0.75)) tended (P = 0.09) to be less for the steers fed low (177) than those fed medium (189), high (188), or oscillating (182). Cumulative in vitro ammonia volatilization from the manure of steers fed oscillating was lower (P < 0.01) for the initial 5 d of incubation than from manure of those fed medium, but there was no difference after 11 d of incubation. Additionally, there was a decrease (P < 0.01) in in vitro ammonia volatilization as protein concentration in the diet decreased from high to medium to low. These data indicate that oscillation of the dietary protein improved N retention of finishing steers compared with those in high and low N diets and that these changes were great enough to correspondingly alter ammonia volatilization from manure.     

Use of soybean hulls as a replacement for dry rolled corn in beef cattle feedlot receiving diets

Consecutive receiving studies were used to evaluate the replacement of starch (dry rolled corn; DRC) with a nonforage fiber source (soybean hulls; SBH) on performance, mineral, and blood metabolite status of newly arrived feedlot steer calves. Steers in yr 1 (Y1; 9 pens/diet, 8 to 10 animals/pen) and yr 2 (Y2; 6 pens/diet, 9 to 10 animals/pen) were blocked by weaning management, and then stratified by BW and randomly assigned to pens. Pens were randomly assigned to an oat silage-based diet containing starch (HS) from DRC or digestible fiber (HF) from SBH. Diets were formulated for 12% CP (DM basis) and to meet or exceed NRC (1996) nutrient requirements for Ca, P, and vitamins A and E. Mineral status was assessed in Y1 only via liver biopsies and serum samples collected on d 3 and 28. Mineral concentrations on d 28 were compared using d 3 concentrations as a covariate. Glucose, NEFA, and plasma urea N status were assessed in Y2 only via blood collections on d 0, 3, 7, 14, 28, and 59. Morbidity (<10%) and mortality rates were not different (P > 0.10) between treatments across years. Daily BW gain was similar (P > 0.10) between treatments both during the receiving period and cumulatively across years. Overall, feed intake was greater (P = 0.007) for steers fed HF compared with steers fed HS in Y1, but was not different in Y2 (P = 0.13). Steers consuming the HS diet tended (P = 0.07) to have better BW gain efficiency in Y1 only. Across years, BW gain efficiency and ADG were similar between treatments (P > 0.10), although DMI was greater for steers fed HF (P = 0.003). Based on 2 yr of performance, the calculated ME content of SBH was estimated at 92.5% of the ME value of DRC (2.74 vs. 2.96 Mcal/kg, respectively). Mineral concentrations on d 28 were similar (P > 0.10) for most minerals assayed. There was a steeper (P = 0.005) decline in hepatic Cu concentrations early in the feeding period for steers fed HF, resulting in decreased (P = 0.001) d 28 hepatic concentrations. Hepatic Mn was greater (P = 0.003) in steers fed HF on d 28 as a result of greater (P = 0.006) Mn accumulation during the initial 28 d on feed. Blood metabolites in Y2 (using d 0 values as a covariate) were similar (P > 0.10) across treatments, except for reduced (P = 0.025) plasma urea N concentrations on d 7 and greater (P = 0.050) NEFA concentrations on d 28 for steers fed HS. These studies indicate that the use of SBH in receiving diets can support BW gain similar to the use of DRC.     

Effects of virginiamycin and monensin plus tylosin on ruminal protein metabolism in steers fed corn-based finishing diets with or without wet corn gluten feed

Six ruminally cannulated steers (345 +/- 20 kg initial BW) were used in a 6 x 6 Latin square to evaluate effects of diet and antibiotics on ruminal protein metabolism. Two diets and three antibiotic treatments were arranged factorially. One diet contained (DM basis) 72% dry-rolled corn, 12% soybean meal, 10% alfalfa hay, and 4% molasses (SBM), and the other contained 63% dry-rolled corn, 30% wet corn gluten feed, and 5% alfalfa hay (WCGF). Antibiotic treatments included control, virginiamycin (175 mg/d; VM), and monensin/tylosin (250 and 100 mg/d, respectively; MT). Steers were fed at 12-h intervals at a rate of 2.4% of empty BW daily. Each period included 18 d of adaptation and 3 d of ruminal fluid collections. Samples were collected at 0, 2, 4, 6, 8, and 10 h after the morning feeding on d 19 and 20. On d 21, rumens were dosed 2 h after the morning feeding with 350 g of solubilized casein to evaluate in vivo ruminal protease and deaminase activities. Ruminal fluid samples were collected 1, 2, 3, 4, and 6 h after the casein dose. On d 19 and 20, antibiotics had no effect on ruminal pH or concentrations of VFA, lactate, ammonia, ciliated protozoa, alpha-amino nitrogen (AAN), or peptide N, but VM reduced (P < 0.01) the concentration of isovalerate compared to MT and control. After casein dosing (d 21), peptide N concentration was unaffected by antibiotics, but AAN were higher (P < 0.01) for VM than MT and control. Relative to MT and control, VM reduced ruminal isovalerate (P = 0.05) and increased ruminal propionate (P < 0.01) on d 21. Ruminal pH was lower (P < 0.01) in steers fed SBM than in steers fed WCGF, but lactate concentrations were unaffected by diet. Steers fed SBM had higher (P < 0.05) ruminal concentrations of total VFA and propionate. Ammonia concentrations were lower before feeding and higher after feeding for steers fed WCGF (P < 0.01). Steers fed WCGF had higher counts of total ciliated protozoa than steers fed SBM (P < 0.05) due to greater Entodinium sp. (P < 0.05). Steers fed WCGF had higher (P < 0.01) ruminal AAN and peptide N concentrations than those fed SBM on d 19 and 20. After casein dosing, ruminal peptide N concentrations were similar, but AAN were lower (P < 0.01) for WCGF than SBM. Overall, VM appeared to depress ruminal deaminase activity, and MT had minimal effects on ruminal fermentation products. The protein in WCGF appeared to be more readily degradable than that in SBM.     

Evaluation of sulfur content of dried distillers grains with solubles in finishing diets based on steam-flaked corn or dry-rolled corn

Crossbred yearling steers (n=80; 406 ± 2.7 kg of BW) were used to evaluate the effects of S concentration in dried distillers grains with solubles (DDGS) on growth performance, carcass characteristics, and ruminal concentrations of CH(4) and H(2)S in finishing steers fed diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC) and containing 30% DDGS (DM basis) with moderate S (0.42% S, MS) or high S (0.65% S, HS). Treatments consisted of SFC diets containing MS (SFC-MS), SFC diets containing HS (SFC-HS), DRC diets containing MS (DRC-MS), or DRC diets containing HS (DRC-HS). High S was achieved by adding H(2)SO(4) to DDGS. Ruminal gas samples were analyzed for concentrations of H(2)S and CH(4). Steers were fed once daily in quantities that resulted in traces of residual feed in the bunk the following day for 140 d. No interactions (P ≥ 0.15) between dietary S concentration and grain processing were observed with respect to growth performance or carcass characteristics. Steers fed HS diets had 8.9% less DMI (P < 0.001) and 12.9% less ADG (P=0.006) than steers fed diets with MS, but S concentration had no effect on G:F (P=0.25). Cattle fed HS yielded 4.3% lighter HCW (P = 0.006) and had 16.2% less KPH (P=0.009) than steers fed MS. Steers fed HS had decreased (P=0.04) yield grades compared with steers fed MS. No differences were observed among treatments with respect to dressing percentage, liver abscesses, 12th-rib fat thickness, LM area, or USDA quality grades (P ≥ 0.18). Steers fed SFC had less DMI (P < 0.001) than steers fed DRC. Grain processing had no effect (P > 0.05) on G:F or carcass characteristics. Cattle fed HS had greater (P < 0.001) ruminal concentrations of H(2)S than cattle fed MS. Hydrogen sulfide concentration was inversely related (P ≤ 0.01) to ADG (r=-0.58) and DMI (r=-0.67) in cattle fed SFC, and to DMI (r=-0.40) in cattle fed DRC. Feeding DDGS that are high in dietary S may decrease the DMI of beef steers and compromise the growth performance and carcass characteristics of feedlot cattle.     

Effects of wet corn gluten feed and roughage levels on performance, carcass characteristics, and feeding behavior of feedlot cattle

Two experiments were conducted to evaluate the effects of feeding different levels of wet corn gluten feed (WCGF) and dietary roughage on performance, carcass characteristics, and feeding behavior of feedlot cattle fed diets based on steam-flaked corn (SFC). In Exp. 1, crossbred steers (n = 200; BW = 314 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based diet containing 9% roughage (CON) and 3 SFC-based diets containing 40% WCGF, with either 9, 4.5, or 0% roughage. A linear (P = 0.04) increase in final BW and DMI (P < 0.01) was observed in diets containing WCGF as dietary roughage increased. Steers fed WCGF and higher levels of roughage had greater (P = 0.01) ADG than steers fed lower levels of roughage. Steers fed the CON diet had lower (P = 0.04) daily DMI and greater (P = 0.03) G:F than those fed WCGF. Most carcass characteristics of steers fed CON did not differ (P > 0.10) from those of steers fed WCGF. Based on feed disappearance and visual scan data, consumption rate did not differ (P > 0.10) among treatments; however, feeding intensity (animals present at the bunk after feeding) was greater for steers fed CON (P < 0.01) than for steers fed WCGF. In Exp. 2, yearling crossbred steers (n = 1,983; BW = 339 kg) were fed 4 dietary treatments (DM basis): a standard SFC-based control diet that contained 9% roughage (CON) and 3 SFC-based diets containing either 20% WCGF and 9% roughage or 40% WCGF with 9 or 4.5% roughage. Steers fed the CON diet tended to have lower final BW (P = 0.14), ADG (P = 0.01), and DMI (P < 0.01) than steers fed diets containing WCGF. Steers fed the 20% WCGF diet had greater (P = 0.08) G:F than steers fed the 40% WCGF diets. With 40% WCGF, increasing roughage from 4.5 to 9% decreased (P < 0.01) G:F and increased (P = 0.06) DMI. Gain efficiency was improved (P < 0.01) for steers fed CON vs. those fed diets containing WCGF, whereas HCW (P = 0.02) and dressing percentage (P < 0.01) were greater for steers fed WCGF. Percentage of cattle grading USDA Choice was greater (P = 0.02) for cattle fed WCGF. Results suggest that replacing SFC with up to 40% WCGF increased ADG and decreased G:F when 4.5 to 9.0% roughage was supplied. More CON steers were present at the feed bunk during the first hour after feeding than WCGF steers, suggesting that including WCGF at 40% of the diet affected feeding behavior.     

Influence of processed grains on fecal pH, starch concentration, and shedding of Escherichia coli O157 in feedlot cattle

Manipulation of cattle diets has been proposed as a possible preharvest control measure for Escherichia coli O157. Altering hindgut fermentation through diet changes may be a means to reduce fecal shedding of E. coli O157. In Exp. 1, the objective was to determine whether fecal shedding of E. coli O157 was related to fecal starch concentration. Beginning on d 20, and every week thereafter until d 61, steers in 54 pens (6 to 7 steers per pen) were sampled (n = 122) by fecal collection and rectoanal mucosal swabs (RAMS) for E. coli O157 and fecal starch concentration determinations. Escherichia coli O157 prevalence was 3.3% in fecal samples, 4.1% as measured by RAMS, and 4.9% by fecal or RAMS samples. Steers positive for E. coli O157 contained 21% more (P < 0.05) fecal starch than steers that were negative for E. coli O157. In Exp. 2, we attempted to alter the concentration of starch escaping rumen fermentation by feeding finishing diets based on steam-flaked corn (SFC) and dry-rolled corn (DRC) to 30 heifers prescreened for being culture positive for fecal E. coli O157. Beginning on d 13, heifers were sampled (feces and RAMS) weekly to monitor fecal pH and starch concentration, and prevalence of E. coli O157. Prevalence of E. coli O157 remained above 30% for the first 13 d, but declined (P < 0.05) over the entire 7-wk period. Based on RAMS, the prevalence of E. coli O157 tended to be greater (P = 0.08) for heifers fed SFC than for those fed the DRC diet. After d 20, heifers fed DRC had greater (P < 0.05) fecal starch and lower (P < 0.05) fecal pH than heifers fed SFC. Fecal pH was negatively correlated (r = - 0.34; P < 0.05; n = 143) with fecal starch concentration. Fecal starch concentration and pH were not different (P > 0.05) for heifers that were positive or negative for E. coli O157. Our data suggest that fecal shedding of E. coli O157 was not related to fecal pH or starch concentration in cattle fed grain-based diets.     

Interaction of corn processing and distillers dried grains with solubles on health and performance of steers

Feeding increased concentrations of distillers dried grains with solubles (DDGS) to ruminants has been avoided due to risks of S toxicity and concerns about animal performance. The objective of this study was to evaluate the influence of feeding an increasing concentration of DDGS and corn processing method on animal performance, incidence of polioencephalomalacia (PEM), and concentration of H(2)S gas in feedlot steers. Sixty steer calves (336 ± 13.2 kg) were individually fed for an average of 136 d in a completely random design with a 3 × 2 factorial arrangement of treatments. Main effects included concentration of DDGS (20, 40, or 60% DM basis) and corn processing method [high-moisture (HMC; 71.7% DM) vs. dry-rolled corn (DRC; 86.2% DM)] resulting in treatments of 1) 20% DDGS with DRC, 2) 40% DDGS with DRC, 3) 60% DDGS with DRC, 4) 20% DDGS with HMC, 5) 40% DDGS with HMC, and 6) 60% DDGS with HMC. Ruminal H(2)S gas concentrations were measured on d 0, 7, 14, 21, 28, 35, 49, 63, and 91 via rumen puncture. Animal performance and carcass characteristic data were collected. The day × corn processing × DDGS interaction for H(2)S gas concentrations was not significant (P = 0.91). Ruminal H(2)S concentration increased with increasing DDGS concentration (P < 0.001) and day (P < 0.001), but was not influenced by corn processing method (P = 0.94). Carcass-adjusted final BW decreased linearly (P = 0.009), whereas carcass-adjusted ADG decreased quadratically (P = 0.05) with increasing concentration of DDGS in the diet. Carcass-adjusted G:F was not affected (P ≥ 0.28) by increasing concentration of DDGS in the diet. Carcass characteristics reflected the decrease in final BW with decreased HCW (P = 0.009), as well as decreased fat depth (P = 0.005) with increasing concentrations of DDGS. The combination of decreased HCW and backfat thickness resulted in decreased (P = 0.02) yield grade with increasing DDGS inclusion. There were no confirmed cases of PEM. In conclusion, corn processing did not influence animal performance, incidence of PEM, or H(2)S concentrations under the conditions of this study. Feeding 60% DDGS in beef cattle finishing diets is not recommended due to poor animal performance.     

Influence of steam-flaked corn moisture level and density on the site and extent of digestibility and feeding value for finishing cattle

Performance and digestibility experiments were conducted to determine the influence of moisture and flake density (FD) on the feeding value of steam-flaked corn (SFC). Dietary treatments consisted of finishing diets that contained 78% (DM basis) SFC that was tempered using 0, 6, or 12% moisture and processed to either 360 (SF28) or 310 (SF24) g/L. A 3 x 2 factorial arrangement of treatments was used. In Exp. 1, 78 steers were individually fed the respective treatments for 106 d. Moisture added during tempering tended (linear; P < 0.10) to increase starch availability but linearly decreased (P < 0.01) particle size. Decreasing flake density increased (P < 0.001) starch availability and also decreased (P < 0.001) particle size. Starch availability (P < 0.001), moisture (P < 0.001), and particle size (P = 0.05) were all greater for SFC that was collected the day of processing compared with SFC that had been processed the previous day. Steers fed diets containing SF24 consumed less DM as the moisture level increased, whereas steers fed diets containing SF28 had increased DMI as moisture level increased (moisture x FD interaction; P < 0.01). Nonetheless, ADG, G:F, and most carcass characteristics did not differ among treatments. In Exp. 2, 6 multicannulated Jersey steers were used in a 6 x 6 Latin square using the same treatments as in Exp. 1. Increasing moisture intake linearly decreased (P < 0.05) starch intakes. Organic matter and N intakes followed similar trends but were not different. Decreasing FD tended to increase (P < 0.10) microbial N flow to the duodenum and increased microbial efficiency (P < 0.05). Ruminal starch digestibility was 90.5%, and total tract starch digestibility was 99.5% without adding moisture or processing beyond SF28. Moisture additions to corn before steam flaking resulted in few differences in performance or digestibility, despite increases in starch availability that occurred as moisture increased. Processing corn more extensively than SF28 may be unnecessary and cost-prohibitive.     

Effects of twenty percent corn wet distillers grains plus solubles in steam-flaked and dry-rolled corn-based finishing diets on heifer performance, carcass characteristics, and manure characteristics

Two hundred sixty-four crossbred heifers (initial BW = 354 kg ± 0.5) were used to determine effects of corn processing method and wet distillers grains plus solubles (WDGS) inclusion in finishing diets on animal performance, carcass characteristics, and manure characteristics. The study was conducted as a randomized complete block with a 2 × 2 factorial arrangement of treatments. Dietary treatments included steam-flaked corn (SFC)- and dry-rolled corn (DRC)-based finishing diets containing 0 or 20% WDGS (0SFC, 20SFC, 0DRC, and 20DRC, respectively). Heifers averaged 154 d on feed and were marketed in 3 groups. There were no interactions between corn processing method and WDGS detected (P ≥ 0.29) for any performance or carcass response variables. Heifers fed diets containing WDGS tended to have greater final BW (P = 0.10) and increased G:F (P = 0.08) compared with heifers fed diets without WDGS. Heifers fed SFC-based diets consumed 7% less feed (P < 0.01) and were 9% more efficient (P < 0.01) than heifers fed DRC-based diets. Carcass characteristics were not affected by corn processing method or WDGS inclusion (P ≥ 0.16). Intakes of OM, N, P, and K were greater (P ≤ 0.05) for heifers fed DRC-based diets than those fed SFC-based diets, which resulted in greater net accumulation of the nutrients in the manure (P ≤ 0.04). Heifers fed diets containing WDGS had greater (P < 0.01) intakes of N, P, and K than heifers fed diets without WDGS. As a result, a greater net accumulation of P and K (P ≤ 0.03) and N (P = 0.10) were present in the manure from cattle fed diets containing WDGS compared with those fed diets without WDGS. There was no interaction (P ≥ 0.16) between corn processing and WDGS on N volatilization losses. Nitrogen volatilization losses from manure (expressed as a percentage of intake and g·heifer(-1)·d(-1)) were greater (P < 0.01) for heifers fed SFC-based diets than heifers fed DRC-based diets. Feeding DRC-based finishing diets to heifers resulted in increased manure production and nutrient excretion and decreased N volatilization. Both corn processing method and WDGS inclusion affected animal performance and manure characteristics.     

Effect of low vitamin A diets with high-moisture or dry corn on marbling and adipose tissue fatty acid composition of beef steers

Angus-cross steers (n = 165; 295 +/- 16 kg of BW) were used evaluate the effect of low vitamin A diets with high-moisture corn (HMC) or dry corn (DC) on marbling and fatty acid composition. Steers were allotted to 24 pens (7 steers/pen), such that each pen had the same average initial BW. Treatments were randomly allotted to the pens. The experiment had a completely randomized design, with a 2 x 2 factorial arrangement of treatments: low vitamin A (Lo, no supplemental vitamin A) and HMC (LoHMC); LoDC; high vitamin A (Hi, supplemented with 2,200 IU of vitamin A/kg of DM) and HMC (HiHMC); and HiDC. Diets contained 76% corn, 10% corn silage, 11% protein supplement, and 3% soybean oil (DM basis). Samples of feed ingredients were collected for carotenoid analysis. Blood samples were collected for serum retinol determination. Steers were slaughtered after 145 d on feed. Carcass characteristics and LM composition were determined. Samples from the s.c. fat depot were analyzed for fatty acid composition. High-moisture corn had a greater vitamin A content, based on its carotenoid content, than DC (614 vs. 366 IU/kg of DM, P < 0.01). No vitamin A x corn type interactions were detected for feedlot performance, carcass characteristics, or serum, s.c. fat, or liver retinol concentration. Average daily gain, DMI, and G:F were not affected by vitamin A (P > 0.05). Marbling score and USDA quality grade were greater (P < 0.05) in Lo vs. Hi steers. Hot carcass weight, backfat, and yield grade were not affected by the treatments (P > 0.05). Vitamin A and corn type did not affect LM composition (DM, ash, CP, or ether-extractable fat, P > 0.05). Vitamin A supplementation increased (P < 0.06) serum retinol on d 112 and 145 and increased (P < 0.01) liver retinol at slaughter (Lo = 38.7 vs. Hi = 102.9 mug/g). The s.c. fat retinol concentrations were less (P < 0.01) for Lo (0.8 mug/g) than for Hi (1.4 mug/g) at slaughter. Cell diameter of adipocytes in the i.m. depot was not affected by dietary vitamin A (P > 0.05). A vitamin A x corn type interaction was observed (P < 0.05) for the s.c. fat cellularity. Feeding HMC increased the number of cells per square millimeter when Lo diets were fed (LoHMC = 128 vs. LoDC = 100 cells/mm(2), P < 0.05), but not when Hi diets were fed (HiHMC = 109 vs. HiDC = 111 cells/mm(2), P > 0.05). The CLA content of adipose tissue was not affected by the treatments. Regardless of the corn type used, feeding low vitamin A diets for 145 d to Angus-cross steers increased marbling and quality grade without affecting yield grade, animal health, or performance.     

Odorant production and persistence of Escherichia coli in manure slurries from cattle fed zero, twenty, forty, or sixty percent wet distillers grains with solubles

Corn ethanol production removes starch and concentrates the remaining nutrients, including CP and minerals. When wet distillers grains with solubles (WDGS) are fed to cattle in place of corn, CP and minerals often exceed dietary needs. This may increase N emission, P run-off, and odor production. These variables are evaluated in this study. Crossbred steers (n = 160; 434 +/- 8 kg) were assigned in a completely randomized block design to 9 x 9 m pens with concrete floor (10 animals/pen; 4 pens/treatment). Steers were fed a finishing diet that contained 0, 20, 40, or 60% WDGS on a DM basis, and provided 13.3, 15.5, 20.6, or 24.9% CP, respectively. Two kilograms of manure slurry (14 to 23% DM) were collected from each pen monthly (Aug. 20, Sep. 24, and Oct. 22). Samples were analyzed immediately for odorants, DM, pH, NH(3), total alcohol, l-lactate, and concentrations of generic Escherichia coli. After incubation of the samples at 22 degrees C for 2, 4, 7, 10, 15, 21, and 28 d, samples were analyzed for methane production in addition to the above characteristics. Before incubation, NH(3), H(2)S, indole, phenol, isovalerate, isobutyrate, and acetate increased (P < 0.01) with increasing amounts of WDGS in the diet. Other odorants, including skatole, caproate, valerate, butyrate, and propionate, were greater (P < 0.01) in manure slurries from cattle fed 20 or 40% WDGS, compared to 0% WDGS. The l-lactate was greater (P < 0.01) in slurries from cattle fed 0% WDGS (447 mu mol/g of DM) compared with the other treatment slurries (14 to 15 mu mol/g of DM). After incubation, l-lactate contributed to lowered slurry pH (6.3, 7.1, 7.6, and 8.2, respectively, for 0, 20, 40, and 60% WDGS), which inhibited microbial fermentation, E. coli persistence, and methane production. Because of the favorable, more neutral pH in the 40 and 60% WDGS slurries, many of the odorant compounds were rapidly converted to methane during a 28-d static incubation. Escherichia coli O157:H7 inoculated into subsamples of the manure slurries exhibited behavior similar to that of naturally present generic E. coli, surviving in greater numbers longer (P < 0.05) in 20 and 40% WDGS slurries than in 0% WDGS. These data indicate feeding WDGS can increase odorants in manure slurries and extend the persistence of E. coli.