Effect of heat treatment on the antioxidant activity, color, and free phenolic acid profile of malt

Green malt was kilned at 95 degrees C following two regimens: a standard regimen (SKR) and a rapid regimen (RKR). Both resulting malts were treated further in a tray dryer heated to 120 degrees C, as was green malt previously dried to 65 degrees C (TDR). Each regimen was monitored by determining the color, antioxidant activity (by both ABTS(.+) and FRAP methods), and polyphenolic profile. SKR and RKR malts exhibited decreased L* and increased b* values above approximately 80 degrees C. TDR malts changed significantly less, and color did not develop until 110 degrees C, implying that different chemical reactions lead to color in those malts. Antioxidant activity increased progressively with each regimen, although with TDR malts this became significant only at 110-120 degrees C. The RKR malt ABTS(.+) values were higher than those of the SKR malt. The main phenolics, that is, ferulic, p-coumaric, and vanillic acids, were monitored throughout heating. Ferulic acid levels increased upon heating to 80 degrees C for SKR and to 70 degrees C for RKR, with subsequent decreases. However, the levels for TDR malts did not increase significantly. The increase in free phenolics early in kilning could be due to enzymatic release of bound phenolics and/or easier extractability due to changes in the matrix. The differences between the kilning regimens used suggest that further modification of the regimens could lead to greater release of bound phenolics with consequent beneficial effects on flavor stability in beer and, more generally, on human health.     

Effect of kilning on the antioxidant and pro-oxidant activities of pale malts

Pale malts were prepared using standard and rapid kilning regimes that differed in the temperature and moisture profiles in the kiln. Samples were taken over the last 9 h of kilning, that is, at 18, 20, 22, 25, and 27 h. Antioxidant activity, assessed by redox potential, scavenging of the 2,2'-azinobis(3-ethylbenzothiazoline-6-sulfonic acid) radical cation (ABTS*+), and ferric reducing/antioxidant power (FRAP), increased at moisture levels below 6.7% for both regimes. The 27 h malt exposed to the rapid regime (moisture content of 4.8%) had a higher activity than the 27 h standard regime sample (moisture content of 4.8%). None of the malts scavenged oxygen. Pro-oxidant activity profiles were different for the malts obtained using each regime and, at 27 h, the rapid procedure gave malt with higher activity. Levels of (+)-catechin and ferulic acid (the most abundant phenolic compounds identified) generally increased as the moisture content of malt fell below 6.7%. Differences in antioxidant and pro-oxidant activities of the 27 h malts are partly attributed to the Maillard reaction, as evidenced by lower L* and higher b* values and higher levels of Maillard-derived flavor compounds, in the sample obtained by the rapid procedure. Levels of lipid-derived flavor compounds were significantly higher after 27 h of kilning using the rapid procedure.     

Antioxidant properties of kilned and roasted malts

Compounds possessing antioxidant activity play a crucial role in delaying or preventing lipid oxidation in foods and beverages during processing and storage. Such reactions lead to loss of product quality, especially as a consequence of off-flavor formation. The aim of this study was to determine the antioxidant activity of kilned (standard) and roasted (speciality) malts in relation to phenolic compounds, sugars, amino acids, and color [assessed as European Brewing Convention units (degrees EBC) and absorbance at 420 nm]. The concentrations of sugars and amino acids decreased with the intensity of the applied heat treatment, and this was attributed to the extent of the Maillard reaction, as well as sugar caramelization, in the highly roasted malts. Proline, followed by glutamine, was the most abundant free amino/imino acid in the malt samples, except those that were highly roasted, and maltose was the most abundant sugar in all malts. Levels of total phenolic compounds decreased with heat treatment. Catechin and ferulic acid were the most abundant phenolic compounds in the majority of the malts, and amounts were highest in the kilned samples. In highly roasted malts, degradation products of ferulic acid were identified. Antioxidant activity increased with the intensity of heating, in parallel with color formation, and was significantly higher for roasted malts compared to kilned malts. In kilned malts, phenolic compounds were the main identified contributors to antioxidant activity, with Maillard reaction products also playing a role. In roasted malts, Maillard reaction products were responsible for the majority of the antioxidant activity.     

Antioxidant properties of malt model systems

The aim of this study was to investigate the effect of kilning and roasting temperatures on antioxidant activity of malt model systems prepared from combinations of glucose, proline, and ferulic acid. Model systems (initial a(w) = 0.09, 6% moisture) were heated at 60 degrees C for up to 24 h, at 90 degrees C for up to 120 min, and at 220 degrees C for up to 15 min. The antioxidant activity of the glucose-proline-ferulic acid model system increased significantly on heating at 60 degrees C for 24 h or at 90 degrees C for 120 min. In contrast, the glucose-proline, ferulic acid-glucose, and ferulic acid-proline systems presented either nonsignificantly increased or unchanged antioxidant activity. The antioxidant activity of both the glucose-proline-ferulic acid and glucose-proline model systems increased significantly after heating at 220 degrees C for 10 min, followed by a significant decrease at 15 min. The data suggest that (1) at 60 degrees C, ferulic acid reacts with Maillard reaction products, resulting in a significant increase in antioxidant activity; (2) at 90 degrees C, the antioxidant activity of the glucose-proline-ferulic system comes from both ferulic acid and Maillard reaction products; and (3) at 220 degrees C, the major contributors to antioxidant activity in glucose-proline-ferulic acid and glucose-proline systems are glucose-proline reaction products.     

Variability in the release of free and bound hydroxycinnamic acids from diverse malted barley (Hordeum vulgare L.) cultivars during wort production

Volatile phenols have long been recognized as important flavor contributors to the aroma of various alcoholic beverages. The two main flavor-active volatile phenols in beer are 4-vinylguaiacol and 4-vinylphenol. They are the decarboxylation products of the precursors ferulic acid and p-coumaric acid, respectively, which are released during the brewing process, mainly from malt. In this study, the variability in the release of free and ester-bound hydroxycinnamic acids from nine malted barley ( Hordeum vulgare L.) varieties during wort production was investigated. A large variability between different barley malts and their corresponding worts was observed. Differences were also found between free ferulic acid levels from identical malt varieties originating from different malt houses. During mashing, free hydroxycinnamic acids in wort are both water-extracted and enzymatically released by cinnamoyl esterase activity. Esterase activities clearly differ between different barley malt varieties. Multiple linear regression analysis showed that the release of ferulic acid during mashing did not depend only on the barley malt esterase activity but also on the amount of ester-bound ferulic acid initially present in the wort and on its endoxylanase activity. The study demonstrates the importance of selecting a suitable malt variety as the first means of controlling the final volatile phenol levels in beer.     

Impact of low hydration of barley grain on β-glucan degradation and lipid transfer protein (LTP1) modifications during the malting process

One of the objectives of the malting industry is to reduce the energy cost during kilning without major effect on malt quality. In this study, the impact of a low hydration steeping process on lipid transfer protein (LTP1) modifications and β-glucan breakdown was evaluated in low (LH) and high (HH) hydrated malts. LTP1 modifications analyzed by MS/MS revealed acylation, glycation, and disulfide bond breakage in both LH and HH malts. LTP1 free amine content measurement and fluorescence of Maillard protein adducts revealed no significant difference between LH and HH malts. Immunolabeling of LTP1 during malting highlighted the diffusion of the protein from the aleurone layer to the endosperm at the end of steeping in both LH and HH malts. By contrast, a significant higher amount of β-glucans was measured in LH malts after five days of germination, whereas no significant difference between LH and HH malts was revealed through immunostaining of β-glucans or evaluation of the endosperm integrity after seven days of germination. The possibility to reduce the effects of a low hydration steeping process on β-glucan hydrolysis by increasing germination time was discussed.     

Ferulic acid release and 4-vinylguaiacol formation during brewing and fermentation: indications for feruloyl esterase activity in Saccharomyces cerevisiae

The release of ferulic acid and the subsequent thermal or enzymatic decarboxylation to 4-vinylguaiacol are inherent to the beer production process. Phenolic, medicinal, or clove-like flavors originating from 4-vinylguaiacol frequently occur in beer made with wheat or wheat malt. To evaluate the release of ferulic acid and the transformation to 4-vinylguaiacol, beer was brewed with different proportions of barley malt, wheat, and wheat malt. Ferulic acid as well as 4-vinylguaiacol levels were determined by HPLC at several stages of the beer production process. During brewing, ferulic acid was released at the initial mashing phase, whereas moderate levels of 4-vinylguaiacol were formed by wort boiling. Higher levels of the phenolic flavor compound were produced during fermentations with brewery yeast strains of the Pof(+) phenotype. In beer made with barley malt, ferulic acid was mainly released during the brewing process. Conversely, 60-90% of ferulic acid in wheat or wheat malt beer was hydrolyzed during fermentation, causing higher 4-vinylguaiacol levels in these beers. As cereal enzymes are most likely inactivated during wort boiling, the additional release of ferulic acid during fermentation suggests the activity of feruloyl esterases produced by brewer's yeast.     

Relationships between antioxidant activity, color, and flavor compounds of crystal malt extracts.

Aqueous extracts were prepared from five barley crystal malts (color range 15-440 degrees EBC, European Brewing Convention units). Antioxidant activity was determined by using the 2,2'-azinobis(3-ethylbenothiazoline-6-sulfonic acid) (ABTS(*)(+)) radical cation scavenging method. Antioxidant activity increased with increasing color value although the rate of increase decreased with increasing color value. Color was measured in CIELAB space. Extracts of the 15, 23, and 72 degrees EBC malts followed the same dilution pathway as did the 148 degrees EBC sample at higher dilution levels, indicating that they could each be used to give the same color by appropriate dilution. The 440 degrees EBC sample followed a different dilution pathway, indicating that different compounds were responsible for color in this extract. Fifteen selected volatile compounds were monitored using gas chromatography/mass spectrometry (GC/MS). Levels of methylpropanal, 2-methylbutanal, and 3-methylbutanal were highest for the 72 degrees EBC sample. When odor threshold values of the selected compounds were taken into account, 3-methylbutanal was the most important contributor to flavor. Relationships between levels of the lipid oxidation products, hexanal and (E)-2-nonenal, and antioxidant activity were complex, and increasing antioxidant activity for samples in the range of 15-148 degrees EBC did not result in reduced levels of these lipid-derived compounds. When different colored malt extracts were diluted to give the same a* and b* values, calculated antioxidant activity and amounts of 3-methylbutanal, hexanal, and (E)-2-nonenal decreased with increasing degrees EBC value.     

Evaluation of antioxidant capacity of cereal brans

Several oat brans (crunchy oat bran, oat bran alone, and oat breakfast cereal) and wheat brans (wheat bran alone, wheat bran powder, wheat bran with malt flavor, bran breakfast cereal, tablet of bran, and tablet of bran with cellulose) used as dietary fiber supplements by consumers were evaluated as alternative antioxidant sources (i) in the normal human consumer, preventing disease and promoting health, and (ii) in food processing, preserving oxidative alterations. Products containing wheat bran exhibited higher peroxyl radical scavenging effectiveness than those with oat bran. Wheat bran powder was the best hydroxyl radical (OH*) scavenger. In terms of hydrogen peroxide (H2O2) scavenging, wheat bran alone was the most effective, while crunchy oat bran, oat bran alone, and oat breakfast cereal did not scavenge H2O2. The shelf life of fats (obtained by the Rancimat method for butter) increased most in the presence of crunchy oat bran. When the antioxidant activity during 28 days of storage was measured by the linoleic acid assay, all of the oat and wheat bran samples analyzed showed very good antioxidant activities. The Trolox equivalent antioxidant capacity (TEAC) assay was used to provide a ranking order of antioxidant activity. The wheat bran results for TEAC (6 min), in decreasing order, were wheat bran powder > wheat bran with malt flavor > or = wheat bran alone > or = bran breakfast cereal > tablet of bran > tablet of bran with cellulose. The products made with oat bran showed lower TEAC values. In general, avenanthramide showed a higher antioxidant level than each of the following typical cereal components: ferulic acid, gentisic acid, p-hydroxybenzoic acid, protocatechuic acid, syringic acid, vanillic acid, vanillin, and phytic acid.     

Evolution of phenolic compounds and antioxidant activity during malting

Two barley varieties, Gan4 and Hamelin, were malted to investigate the evolution of phenolic compounds and antioxidant activity during malting. The antioxidant activity was evaluated with DPPH radical scavenging activity, ABTS radical cation scavenging activity, reducing power, and metal chelating activity. Results showed that malting had significant influences on individual and total phenolic contents as well as antioxidant activities of two barley varieties. The contents of some phenolic compounds and the antioxidant activities decreased significantly during steeping and the early stages of germination and then increased remarkably during the later stages of germination and subsequent kilning. The most phenolic compounds identified in barley were (+)-catechin and ferulic acid, which both changed significantly during malting. Moreover, results from the Pearson correlation analysis showed that there were good correlations among DPPH radical scavenging activity, ABTS radical cation scavenging activity, reducing power, total phenolic content and sum of individual phenolic contents during malting.     

Quantitative study of the formation of endoproteolytic activities during malting and their stabilities to kilning

The proteinases of germinating barley (Hordeum vulgare L.) hydrolyze storage proteins into amino acids and small peptides that can be used by the growing plant or, during brewing, by yeast. They are critical for the malting and brewing processes because several aspects of brewing are affected by the amounts of protein, peptide, and amino acids that are in the wort. This study was carried out to quantitatively measure when endoproteinases form in green malt and whether they are inactivated at the high temperatures that occur during malt kilning. Little endoproteolytic activity was present in ungerminated barley, but the activities began forming 1 day into the "germination" phase of malting, and they were nearly maximal by the third germination day. Quantitative studies with azogelatin "in solution" assays showed that the green malt endoproteolytic activities were not inactivated under commercial kilning conditions that use temperatures as high as 85 degrees C but that some actually increased during the final kilning step. Qualitative (2-D, IEF x PAGE) analyses, which allow the study of individual proteases, showed that some of the enzymes were affected by heating at 68 and 85 degrees C, during the final stages of kilning. These changes obviously did not, however, decrease the overall proteolytic activity.     

Effect of processing on the phytochemical profiles and antioxidant activity of corn for production of masa, tortillas, and tortilla chips

The phytochemical profiles (total phenolics, anthocyanins, ferulic acid, carotenoids) and antioxidant activities of five types of corn (white, yellow, high carotenoid, blue, and red) processed into masa, tortillas, and tortilla chips were studied. The nixtamalization process significantly (p < 0.05) reduced total phenolics and antioxidant activities when compared to raw grains. Nixtamalized grains exhibited higher concentration of free phenolics and soluble conjugated ferulic acid and had lower concentrations of bound phenolics and ferulic acid than unprocessed grains. Among processed products, there was little difference in the phytochemical contents and antioxidant activities. Among types of corn, the highest concentrations of total phenolics, ferulic acid, and antioxidant activity were observed in the high-carotenoid genotype followed by the regular yellow counterpart. The white corn contained the lowest amount of total phenolics and antioxidant activity. The pigmented blue corn had the highest anthocyanin concentration followed by the red counterpart. These findings suggest that lime-cooking significantly reduced the phytochemical content of nixtamalized products but released phenolics and ferulic acid.     

Potential Antioxidant Activity of γ‐Oryzanol in Rice Bran as Determined Using an In Vitro Mouse Lymph Axillary Endothelial Cell Model

A mouse lymphatic endothelial cell (SVEC4‐10) in vitro model was developed and found to be effective in the study of antioxidant activity of γ‐oryzanol in rice bran. The critical and vital parameters in developing these cell models included the emulsion preparation of hydrophobic compounds, the consistent management of cell culture, and the selection of cell viability detection methods compatible with the cell lines and the test substances. The SVEC4‐10 cell line had a fast metabolism and consequently could be used to determine antioxidant activity of a test substance in a relatively rapid manner. Results showed that γ‐oryzanol, ferulic acid, and α‐tocopherol could interact with cells such that oxidative damage induced by tert‐butyl hydroperoxide on cellular mitochondrial activity lessened, and in some situations, γ‐oryzanol was a more effective antioxidant than α‐tocopherol. The results also suggested different antioxidant mechanisms among γ‐oryzanol, ferulic acid, and α‐tocopherol. The three major components of γ‐oryzanol generally had higher antioxidant activity than γ‐oryzanol, with 24‐methylene cycloartanyl ferulate relatively more effective. Synergistic antioxidant activity among γ‐oryzanol, ferulic acid, and α‐tocopherol was also found.     

Brewing Performance of Malted Lipoxygenase‐1 Null Barley and Effect on the Flavor Stability of Beer

We examined the malting and brewing performances of a lipoxygenase‐1 (LOX‐1) null line of barley (Hordeum vulgare L.). The LOX‐normal malt and the LOX‐null malt were prepared from F₄ populations derived from a single cross. We could not observe any major differences in the general malt characteristics between the two malts. A brewing trial was performed using these malts. The analysis of the wort and beer revealed that the absence of LOX‐1 had little effect on the general characteristics of the wort and beer. In contrast, beer made from the LOX‐null malt showed reduced levels of beer‐deteriorating substances, trans‐2‐nonenal (T2N), and trihydroxyoctadecenoic acid (THOD). In the sensory evaluation, well‐trained panel members recognized the significant superiority of the aged LOX‐null beer in terms of staleness. These results show that the LOX‐1 null barley line can be effectively used to improve the flavor stability of beer without changing the other important beer qualities.     

Antioxidant effects of phenolic rye (Secale cereale L.) extracts, monomeric hydroxycinnamates, and ferulic acid dehydrodimers on human low-density lipoproteins

Dietary antioxidants that protect low-density lipoprotein (LDL) from oxidation may help to prevent atherosclerosis and coronary heart disease. The antioxidant activities of purified monomeric and dimeric hydroxycinnamates and of phenolic extracts from rye (whole grain, bran, and flour) were investigated using an in vitro copper-catalyzed human LDL oxidation assay. The most abundant ferulic acid dehydrodimer (diFA) found in rye, 8-O-4-diFA, was a slightly better antioxidant than ferulic acid and p-coumaric acid. The antioxidant activity of the 8-5-diFA was comparable to that of ferulic acid, but neither 5-5-diFA nor 8-5-benzofuran-diFA inhibited LDL oxidation when added at 10-40 microM. The antioxidant activity of the monomeric hydroxycinnamates decreased in the following order: caffeic acid > sinapic acid > ferulic acid > p-coumaric acid. The antioxidant activity of rye extracts was significantly correlated with their total content of monomeric and dimeric hydroxycinnamates, and the rye bran extract was the most potent. The data suggest that especially rye bran provides a source of dietary phenolic antioxidants that may have potential health effects.     

Antioxidant activity of steryl ferulate extracts from rye and wheat bran

Antioxidant activity of steryl ferulates from other sources than rice have not yet been studied much, despite the fact that rice steryl ferulates (gamma-oryzanol) have been shown to possess good antioxidant activity. In this study, steryl ferulate extracts from wheat or rye bran were studied for their capability to inhibit hydroperoxide formation in bulk methyl linoleate and methyl linoleate emulsion. Further, their activity to scavenge DPPH radicals was analyzed. The activities were compared to synthetic steryl ferulates, rice steryl ferulates, ferulic acid, and alpha-tocopherol. Nonrice cereal extracts of steryl ferulates exhibited good antioxidant activity, especially in the bulk lipid system. The radical scavenging activity was similar to that of nonesterified ferulic acid, indicating that the ferulic acid moiety is responsible for the antioxidant properties. This study illustrates a new aspect to the health-promoting properties of rye and wheat.     

Comparison of phenolic acids profile and antioxidant potential of six varieties of spelt (Triticum spelta L.)

Phenolic acids profile and antioxidant activity of six diverse varieties of spelt are reported. Antioxidant activity was assessed using eight methods based on different mechanism of action. Phenolic acids composition of spelt differed significantly between varieties and ranged from 506.6 to 1257.4 μg/g DW. Ferulic and sinapinic acids were the predominant phenolic acids found in spelt. Total ferulic acid content ranged from 144.2 to 691.5 μg/g DW. All analyzed spelt varieties possessed high antioxidant potential. In spite of the fact that bound phenolic acids possessed higher antioxidant activities, analysis of antioxidant potential and their relationship with phenolic acid content showed that free phenolics were more effective. Eight antioxidant methods were integrated to obtain a total antioxidant capacity index that may be used for comparison of total antioxidant capacity of spelt varieties. Total antioxidant potential of spelt cultivars were ordered as follows: Ceralio > Spelt INZ ≈ Ostro > Oberkulmer Rotkorn > Schwabenspelz > Schwabenkorn.     

Influence of corn size distribution on the diastatic power of malted barley and its impact on other malt quality parameters

Detailed studies were carried out on the influence of corn size distribution on the values obtained for diastatic power (DP) of commercially malted barley. Malted barley was screened using a screening box, and the DP activities of the different corns retained on the different compartments of the screening box were determined. The malt samples retained on the 2.8 mm screen had the highest DP activity, whereas the small corns (相似文献   

Characterization and quantification of free and esterified 9- and 13-hydroxyoctadecadienoic acids (HODE) in barley, germinating barley, and finished malt

The analysis of (R)-9- and (S)-9-hydroxy-10E,12Z-octadecadienoic acid as well as (R)-13- and (S)-13-hydroxy-9Z,11E-octadecadienoic acid (HODE) as free acids, esterified in triacylglycerols (storage lipids), and esterified in polar lipids (phospholipids, glycolipids, etc.) in barley, germinating barley, and finished malt was performed using [13-(18)O(1)]-(S)-13-HODE isotope dilution assays with GC-MS and straight- and chiral-phase HPLC. 9- and 13- HODE occur approximately racemically in barley, indicating an autoxidation. The enantiomeric excesses increase to 78% S for free 9-HODE and to 58% S for free 13-HODE in germinating barley as a result of lipoxygenase-2 (LOX-2) catalysis, but free HODEs are at low concentration. More than 90% of HODEs in barley and malt are esterified. In the storage lipids of green malt 53 mg/kg 9-HODE and 147 mg/kg 13-HODE were detected. This ratio of 30:70 reflects the regioselectivity of the LOX-2 enzyme in malt. In the polar lipids 45 mg/kg 9-HODE and 44 mg/kg 13-HODE were characterized. The latter indicate a hitherto unknown 9-lipoxygenase activity with polar lipids as substrates. During kilning the contents of most HODEs decreased significantly due to chemical and enzymatic degradation, whereas polar-esterified (R)-13-HODE increased (43%) in the finished malt.     

Influence of feeding malt, bread crust, and a pronylated protein on the activity of chemopreventive enzymes and antioxidative defense parameters in vivo

The aim of the present study was to investigate whether feeding of malt, bread crust, and a pronylated albumin modulates chemoprevention enzymes, such as glutathione-S-transferase (GST) and UDP-glucuronyl-transferase (UDP-GT), and antioxidative defense parameters in vivo and whether the intake of these foods rich in Maillard reaction compounds results in an accumulation of compounds formed in in vivo glycation reactions. After quantitation of pronylated lysine in malt and bread crust, male Wistar rats were fed a standard chow supplemented with 28% of protein containing different amounts of casein, bread crust, caraffa malt, or pronyl bovine serum albumin (BSA) for 15 days. GST activity in the kidneys was increased by 18% (p > 0.05) in animals of the bread crust group, while UDP-GT activity was elevated by 27% in the liver of animals administered pronyl-BSA. Contents of tocopherol in plasma were increased by 33, 14, and 14% in the bread crust, malt, and pronyl-BSA group compared to the control group, while the levels of thiobarbituric acid reactive substances were decreased and the total antioxidant capacity was increased. Parameters of endogenous glycation indicated a 32 and 46% higher load of advanced glycation end products in the kidneys after administration of the malt and the pronyl-BSA containing diet. However, the main systemic effects of dietary malt, bread crust, and pronyl-BSA were, for the first time, demonstrated to be the enhanced antioxidant capacity and the particulate increase in chemopreventive enzymes.