Effect of Organic Residues and Their Derived Biochars on the Zinc and Copper Chemical Fractions and Some Chemical Properties of a Calcareous Soil

ABSTRACT

Addition of more resistant organic materials, such as biochars, to soils not only enhances soil C sequestration but also can also benefit soil fertility. The aim of this study was to investigate the effect of two organic materials (sheep manure and vermicompost) and their biochars produced at two pyrolysis temperatures (300 and 500°C) applied at 5% (w/w) on the chemical fractions of Zn and Cu and some chemical characteristics of an unpolluted, light textured calcareous soil. Addition of the raw organic materials and their-derived biochars significantly enhanced plant available K, P, and Zn but significantly decreased plant available Cu in the soil. Sheep manure biochar produced at 300°C was most effective at increasing plant available P (13-fold) and K (1.9 fold) likely due to formation of more soluble forms of P and K compared to raw material or biochar produced at higher temperature (500°C). Whereas, raw vermicompost and sheep manure were most effective at enhancing plant available Zn, by increasing water soluble and exchangeable Zn fraction likely due to organic complexation. All amendments, especially biochars produced at 300°C reduced water soluble and exchangeable Cu mainly attributed to increased soil P availability. The results of this study showed that in the short-term, addition of the low-temperature biochars was best for enhancing soil P and K availability, but concomitantly reduced Cu availability the most, whereas, addition of the raw organic materials was better for enhancing Zn availability compared to the biochars.     

Influence of Pyrolysis Temperatures on FTIR Analysis,Nutrient Bioavailability,and Agricultural use of Poultry Manure Biochars

This study was conducted to investigate the effect of pyrolysis temperature on chemical properties of poultry manure (PM) biochar over the range of 200–500°C. Chemical properties of biochar produced at 200°C were almost the same as PM, but significant changes were observed in higher-temperature-produced biochars. According to elemental and fourier transformation infrared analyses, the degree of carbonization in biochar was accelerated with increasing pyrolysis temperature. Biochar yield decreased, while its pH, cation exchange capacity, and P, K, Fe, Mn, Zn, and Cu contents increased with increasing pyrolysis temperature. The biochar produced at 400°C or 500°C was highly alkaline. Also, due to high electrical conductivity, these types of biochars may not be suitable for salt-sensitive crops. It was concluded that the pyrolysis temperature of more than 300°C reduces the quality of PM biochar for use in calcareous soils, although it may be suitable for acidic soils or environmental application.     

Impacts of biochar and processed poultry manure,applied to a calcareous soil,on the growth of bean and maize

Direct use of poultry manure on agricultural lands may cause environmental concerns, so there is a need to establish the suitability of the application of biochar derived from poultry manure for calcareous soil chemical properties and plant growth. The purpose of this study was to evaluate the effects of processed poultry manure (0, 5, 10 and 20 g/kg) and its biochar (0, 2.5, 5, 10 and 20 g/kg) on soil chemical properties of a calcareous soil and growth of bean (Phaseolus vulgaris) and maize (Zea mays) plants. In the incubation experiment, both processed poultry manure (PPM) and biochar decreased pH and the concentration of plant‐available Fe of soil but increased plant‐available P, Zn, Cu and Mn concentrations. PPM and biochar increased the concentrations of exchangeable cations (K, Ca and Mg) in soil. PPM and biochar applications increased the growth of maize and bean plants. PPM and biochar resulted in increased concentrations of N, P, K, Ca, Fe, Zn, Cu and Mn in bean plants. In maize plants, PPM and biochar applications increased the N, P, K, Zn, Cu and Mn but decreased the Ca and Mg concentrations. Results of this study reveal that poultry manure biochar can be used effectively for agricultural purposes.     

Corn growth and nitrogen nutrition after additions of biochars with varying properties to a temperate soil

The effects of biochar properties on crop growth are little understood. Therefore, biochar was produced from eight feedstocks and pyrolyzed at four temperatures (300°C, 400°C, 500°C, 600°C) using slow pyrolysis. Corn was grown for 46 days in a greenhouse pot trial on a temperate and moderately fertile Alfisol amended with the biochar at application rates of 0.0%, 0.2%, 0.5%, 2.0%, and 7.0% (w/w) (equivalent to 0.0, 2.6, 6.5, 26, and 91 t biochar ha⁻¹) and full recommended fertilization. Animal manure biochars increased biomass by up to 43% and corn stover biochar by up to 30%, while food waste biochar decreased biomass by up to 92% in relation to similarly fertilized controls (all P < 0.05). Increasing the pyrolysis temperature from 300°C to 600°C decreased the negative effect of food waste as well as paper sludge biochars. On average, plant growth was the highest with additions of biochar produced at a pyrolysis temperature of 500°C (P < 0.05), but feedstock type caused eight times more variation in growth than pyrolysis temperature. Biochar application rates above 2.0% (w/w) (equivalent to 26 t ha⁻¹) did generally not improve corn growth and rather decreased growth when biochars produced from dairy manure, paper sludge, or food waste were applied. Crop N uptake was 15% greater than the fully fertilized control (P < 0.05, average at 300°C) at a biochar application rate of 0.2% but decreased with greater application to 16% below the N uptake of the control at an application rate of 7%. Volatile matter or ash content in biochar did not correlate with crop growth or N uptake (P > 0.05), and greater pH had only a weak positive relationship with growth at intermediate application rates. Greater nutrient contents (N, P, K, Mg) improved growth at low application rates of 0.2% and 0.5%, but Na reduced growth at high application rates of 2.0% and 7.0% in the studied fertile Alfisol.     

Lead retention by broiler litter biochars in small arms range soil: impact of pyrolysis temperature

Phosphorus-rich manure biochar has a potential for stabilizing Pb and other heavy metal contaminants, as well as serving as a sterile fertilizer. In this study, broiler litter biochars produced at 350 and 650 °C were employed to understand how biochar's elemental composition (P, K, Ca, Mg, Na, Cu, Pb, Sb, and Zn) affects the extent of heavy metal stabilization. Soil incubation experiments were conducted using a sandy, slightly acidic (pH 6.11) Pb-contaminated (19906 mg kg(-1) total Pb primarily as PbCO(3)) small arms range (SAR) soil fraction (<250 μm) amended with 2-20 wt % biochar. The Pb stabilization in pH 4.9 acetate buffer reached maximum at lower (2-10 wt %) biochar amendment rate, and 350 °C biochar containing more soluble P was better able to stabilize Pb than the 650 °C biochar. The 350 °C biochar consistently released greater amounts of P, K, Mg, Na, and Ca than 650 °C biochar in both unbuffered (pH 4.5 sulfuric acid) and buffered (pH 4.9 acetate) systems, despite 1.9-4.5-fold greater total content of the 650 °C biochar. Biochars, however, did not influence the total extractable Pb over three consecutive equilibration periods consisting of (1) 1 week in pH 4.5 sulfuric acid (simulated leaching by rainfall), (2) 1 week in pH 4.9 acetate buffer (standard solution for toxicity characteristic leaching procedure), and (3) 1 h in pH 1.5 glycine at 37 °C (in vitro bioaccessibility procedure). Overall, lower pyrolysis temperature was favorable for stabilizing Pb (major risk driver of SAR soils) and releasing P, K, Ca, and other plant nutrients in a sandy acidic soil.     

Nutrient concentration of corn as effected by poultry manure

Abstract

The elemental composition of corn was evaluated during the 1973 growing season in an experiment with various rates of poultry manure. In general, the nutrient concentration of plant tissue reflected poultry manure applications with the exception of Mg which declined and Ca, Fe and Na which appeared to be largely unaffected. The elemental concentrations in the corn tissue were not in a toxic range however, the nutrient balance was changed by poultry manure application. Sampling of corn early in the growing season can be quite valuable with respect to predicting nutrient concentration of more mature corn for Mg, Mn, B and Zn, but it leaves much to be desired for the other elements tested.     

Low Pyrolysis Temperature Biochar Improves Growth and Nutrient Availability of Maize on Typic Calciargid

This experiment was conducted to investigate the effects of biochars, produced from maize straw at different temperatures (300, 400, and 500 °C), on growth of maize. Maximum cation exchange capacity (CEC) (106 cmol_c kg^?1) of biochar was observed at 400 °C. The pH, electrical conductivity (EC), and carbon content of biochars significantly increased with increasing temperature, and maximum pH (9.8), EC (3.0 dS m^?1), and carbon content (607 g kg^?1) were observed at 500 °C. Concentration of phosphorus (P), potassium (K), calcium (Ca), and magnesium (Mg) significantly increased with increasing temperature, while of nitrogen (N) decreased. Ammonium bicarbonate–diethylene triamine penta acetic acid (AB-DTPA)–extractable nutrients were decreased with increasing pyrolysis temperature. Shoot and root dry matter of maize increased significantly with application of biochar produced at 300 and 400 °C and decreased significantly at 500 °C. Maximum shoot and root dry matter of maize was obtained at biochar produced at 300 °C. Phosphorus and K concentration in shoots and roots increased with biochar, and it was significantly more with fertilizer application. In contrast to P, shoot and root K concentration increased significantly with increasing pyrolysis temperature. The results of this study indicated that application of biochar produced at low pyrolysis temperature may be a practical approach to improve crop growth.     

Effects of pyrolysis temperature and residence time on physicochemical properties of different biochar types

Here we selected eight types of feedstocks to assess the effects of pyrolysis temperature (300°C, 400°C, 500°C and 600°C) and residence time (0.5, 1, 2, 4, 8 and 24 h), respectively, on the physicochemical properties. The fixed-carbon content, pH value and amount of basic functional groups in biochars increased as the pyrolysis temperature increased from 300°C to 600°C; the opposite trend was found in the biochar yield, adsorption capacity and amount of acidic functional groups. Increasing the residence time at low pyrolysis temperature (300°C) resulted in a gradual reduction in the biochar yield and progressive increase in the pH and iodine adsorption number of biochars. However, increasing the residence time at high pyrolysis temperature (600°C) had little effect on the biochar yield or pH, while it decreased the iodine adsorption number of biochars. Given the effects of pyrolysis conditions on the pH and iodine adsorption number of biochars, low-ash agricultural wastes (e.g. wheat straw) can be pyrolysed at 300°C, 2 h to produce biochar for improving alkaline soils; high-ash agricultural wastes (e.g. sweet potato vine) and forest litter (e.g. fresh leaves of apricot tree) are preferably pyrolysed at 300°C, 4 h to produce biochar for use in acidic soils.     

Variations in mineral element concentrations of poultry manure biochar obtained at different pyrolysis temperatures,and their effects on crop growth and mineral nutrition

The effect of pyrolysis temperature on the nutritional quality of agricultural biochar is unclear, so better understanding of its properties and how it affects soil nutrient availability and plant growth is needed. Biochars obtained at different pyrolysis temperatures (250, 300, 350 and 400 °C) were characterized by thermogravimetric analyser and Fourier transform infrared spectroscopy. Biochars were applied at a rate of 10 g/kg to find out their effects on the mineral nutrition and growth of lettuce. The experimental results suggested that high biochar temperatures caused oxidation of the mineral elements, breaking of C–C and C–H bonds and removal of aliphatic and peptide groups from the pyrolysed materials. The total concentrations of phosphorus (P), potassium (K), calcium (Ca), magnesium (Mg), iron (Fe), zinc (Zn), copper (Cu), manganese (Mn) and boron (B) were increased by increasing pyrolysis temperatures, although water‐soluble concentrations of those elements were greatly reduced (with the exception of K and B). Compared to the control, dry weights of lettuce and maize crops were significantly increased by the biochar treatments obtained at 300 and 350 °C. Biochar treatments significantly increased the P and K concentrations of both plants compared to the control, while concentrations of Ca and Mg in lettuce plants were decreased. Iron, Mn and B concentration of the lettuce plants were reduced and Zn concentration of maize increased by the biochar treatments. It was concluded that in terms of an agricultural product, biochars produced at low temperature are better.     

Effect of acid modification of biochar on nutrient availability and maize growth in a calcareous soil

The nutritional quality of acid‐modified poultry manure biochar is unclear, so a better understanding of its properties and agronomic potential is needed. The biochar was modified with phosphoric acid (H₃PO₄) and nitric acid (HNO₃) and a combination of the two, before and after pyrolysis. After characterization of biochar samples and determination of total and water‐soluble mineral element concentrations, biochars were applied to a calcareous soil at a rate of 0.5% (w/w) to find out their effects on the mineral nutrition and growth of maize. Treatment with H₃PO₄+ HNO₃ enriches the biochar with phosphate, nitro groups and nitrate. The experimental results suggested that biochar modified with HNO₃ and/or HNO₃+H₃PO₄ after pyrolysis increased the water‐soluble phosphorus (P), potassium (K), calcium (Ca), magnesium (Mg), iron (Fe), zinc (Zn), copper (Cu) and manganese (Mn) concentrations and increased plant‐available nutrients and plant growth by positively affecting the absorption of plant nutrients. The highest plant dry weight was obtained from biochar post‐treated with HNO₃+H₃PO_4, and this was followed by HNO₃‐ and H₃PO₄‐modified biochars. Premodification with HNO₃+H₃PO4 also significantly increased plant dry weights. The results of this study revealed that poultry manure biochar modified with HNO₃ and H₃PO₄ can be used effectively in calcareous soil for the improvement of plant mineral nutrition.     

Effect of phosphorus‐enriched biochar and poultry manure on growth and mineral composition of lettuce (Lactuca sativa L. cv.) grown in alkaline soil

The use of pyrolysis products of manures gives positive effects on soil fertility, crop productivity and soil carbon sequestration. However, effects depend on soil characteristics, plant species and the raw material from which the biochar is derived, and some negative effects of biochar have been reported. The objective of this study was to evaluate the effectiveness of poultry manure (PM)‐derived biochar on the growth, and P, N, K, Ca, Mg, Fe, Zn, Cu and Mn concentration of lettuce (Lactuca sativa L.) plant. The treatments as follows: control, 20 g/kg poultry manure (PM), 20 g/kg phosphorus‐enriched poultry manure (PM+P), 10 g/kg Biochar (B), 10 g/kg Biochar+P (B+P). Application of biochar and PM significantly increased lettuce growth, and P‐enriched forms of PM and biochar gave the higher growth. PM has no significant effect on the N concentrations but biochar and, P‐enriched PM and biochar treatments significantly increased N concentrations. Phosphorus concentration of the lettuce leaves significantly increased by PM and biochar treatments. Plant K concentrations were also increased by PM and biochar, and their P‐enriched forms. Leaf Ca and Mg concentrations were lower in Biochar and B+P treatments than that of PM and PM+P treatments. Compared to control and PM treatments, biochar applications reduced Fe, Zn, Mn and Cu concentrations of the lettuce plants. The results of this study indicated that application of biochar to alkaline soil is beneficial for crop growth and N, P and K nutrition, but it certainly reduced Fe, Cu, Zn and Mn nutrition of lettuce.     

Designing relevant biochars as soil amendments using lignocellulosic-based and manure-based feedstocks

Purpose

Biochars are a by-product of the biofuel processing of lignocellulosic and manure feedstocks. Because biochars contain an assemblage of organic and inorganic compounds, they can be used as an amendment for C sequestration and soil quality improvement. However, not all biochars are viable soil amendments; this is because their physical and chemical properties vary due to feedstock elemental composition, biofuel processing, and particle size differences. Biochar could deliver a more effective service as a soil amendment if its chemistry was designed ex ante with characteristics that target specific soil quality issues. In this study, we demonstrate how biochars can be designed with relevant properties as successful soil amendments through feedstock selection, pyrolysis conditions, and particle size choices.

Materials and methods

Biochars were produced by pyrolysis of parent lignocellulosic feedstock sources—peanut hull (PH; Archis hypogaea), pecan shell (PS; Carya illinoensis), switchgrass (SG; Panicum virgatum), pine chips (PC; Pinus taeda), hardwood wastes (wood), and poultry litter manure (PL; Gallus domesticus), as well as blends of these feedstocks at temperatures ranging from 250 to 700 °C. Additionally, blended feedstocks were made into pellets (>2 mm) prior to pyrolysis at 350 °C. Dust-sized (<0.42 mm) biochar was obtained through grinding of pelletized biochars. After chemical characterization, the biochars were evaluated as fertility amendments in a Norfolk soil (fine-loamy, kaolinitic, thermic, Typic Kandiudult) during two different pot incubation experiments.

Results and discussion

PL biochars were alkaline and enriched in N and P, whereas biochar from lignocellulosic feedstocks exhibited mixed pH and nutrient contents. Blending PL with PC resulted in lower biochar pH values and nutrient contents. In pot experiment 1, most biochars significantly (P?<?0.05) raised soil pH, soil organic carbon, cation exchange capacity, and Mehlich 1 extractable P and K. PL biochar added at 20 g?kg^?1 resulted in excessive soil P concentrations (393 to 714 mg?kg^?1) and leachate enriched with dissolved phosphorus (DP, 22 to 70 mg?L^?1). In pot experiment 2, blended and pelletized PL with PC feedstock reduced soil pH and extractable soil P and K concentrations compared to pot experiment 1. Water leachate DP concentrations were significantly (P?<?0.05) reduced by pelletized biochar blends.

Conclusions

Short-term laboratory pot experiments revealed that biochars can have different impacts at modifying soil quality characteristics. Keying on these results allowed for creating designer biochars to address specific soil quality limitations. In the process of manufacturing designer biochars, first, it is important to know what soil quality characteristics are in need of change. Second, choices between feedstocks, blends of these feedstocks, and their accompanying particle sizes can be made prior to pyrolysis to create biochars tailored for addressing specific soil quality improvements. Utilization of these principles should allow for effective service of the designed biochar as a soil amendment while minimizing unwanted ex facto soil quality changes and environmental effects.     

Release Kinetics of Some Nutrients from a Sandy Loam Soil Treated with Different Organic Amendments

ABSTRACT

An incubation study was undertaken to examine the periodic release of some macronutrients and micronutrients in a sandy loam treated with different organic amendments (farmyard manure, mushroom compost, poultry manure, vermicompost, biogas slurry, and biochar of Lantana weed) added @ 15 t ha^?1 for 120 d through entrapment of released nutrients on ion exchange resins. Among organic amendments, the highest total contents were recorded for Ca, Mg, and S in farmyard manure, for K, Fe, and Mn in mushroom compost, for P, Zn, and Cu in biogas slurry, for B in biochar. The highest average release was recorded for P, Zn, Mn, and B from poultry manure, for Cu from biogas slurry, for Fe from vermicompost, for Ca, Mg, and S from mushroom compost, and for K from farmyard manure. The kinetics of mineralization and release of these nutrients conformed well to the zero-order kinetics and also to a power function equation. The initial release amount and release rate coefficient estimated by the power function equations were correlated significantly to the general properties of organic amendments and also to the type of C species present in organic amendment. Organic amendments having relatively higher content of water soluble C or fulvic or humic acids are likely to release nutrients through an early mineralization/solubilization from soil reserve.     

Sorption and desorption of phosphate on biochar and biochar–soil mixtures

The term biochar refers to materials with diverse chemical, physical and physicochemical characteristics that have potential as a soil amendment. The purpose of this study was to investigate the P sorption/desorption properties of various slow biochars and one fast pyrolysis biochar and to determine how a fast pyrolysis biochar influences these properties in a degraded tropical soil. The fast pyrolysis biochar was a mixture of three separate biochars: sawdust, elephant grass and sugar cane leaves. Three other biochars were made by slow pyrolysis from three Amazonian tree species (Lacre, Ingá and Embaúba) at three temperatures of formation (400 °C, 500 °C, 600 °C). Inorganic P was added to develop sorption curves and then desorbed to develop desorption curves for all biochar situations. For the slow pyrolysis, the 600 ºC biochar had a reduced capacity to sorb P (4–10 times less) relative to those biochars formed at 400 °C and 500 °C. Conversely, biochar from Ingá desorbed the most P. The fast pyrolysis biochar, when mixed with degraded tropical mineral soil, decreased the soil's P sorption capacity by 55% presumably because of the high soluble, inorganic P prevalent in this biochar (909 mg P/kg of biochar). Phosphorus desorption from the fast pyrolysis biochar/soil mixture not only exhibited a common desorption curve but also buffered the soil solution at a value of ca. 0.2 mg/L. This study shows the diversity in P chemistry that can be expected when biochar is a soil amendment and suggests the potential to develop biochars with properties to meet specific objectives.     

Biochar derived from dairy cattle carcasses as an alternative source of phosphorus and amendment for soil acidity

Two pot experiments were conducted to evaluate biochar derived from dead dairy cattle as a mineral fertilizer, especially phosphorus (P) fertilizer, and to clarify the effect of particle size of biochar on plant growth (Zea mays L.) and P uptake. To produce the biochar, body parts of dead cattle were placed in a charring chamber and allowed to char at 450°C for 4 h. The biochar was of high pH and rich in major plant nutrients, especially P. Application of fine biochar (< 1 mm) increased P uptake by the corn plants grown in soil of low available P status. As a result, plant growth was improved following biochar application and dry matter production was also increased. The effect of the biochar application on the P uptake and plant growth was promoted by the application of mineral nitrogen (N) fertilizer. Soil analysis after harvest indicated that the biochar application increased soil pH, available P and exchangeable calcium (Ca) and magnesium (Mg) compared with the soil before seeding, while soil available N and exchangeable potassium (K) were considerably decreased. The decrease in the soil available N was incomprehensible, because the result of the mass balance given by the difference between input as the applied N from the biochar and fertilizer N and output as the N uptake by the plants was positive. We observed a similar result in the mass balance of K to the case of N. The medium (2–4 mm) and coarse (> 4 mm) grade biochar did not significantly affect plant growth, because P uptake was not, or was only slightly, increased by the application of these biochars. Dissolution of P from the coarser biochars was probably slower than that of the fine biochar. The lower dissolution of P from the medium and coarse biochars was supported by the lower P absorption efficiency of these biochars compared with that of the fine biochar and superphosphate. The effect of fine biochar on plant growth and P uptake was similar to that of superphosphate. We can therefore conclude that fine biochar derived from cattle carcasses is an effective source of P fertilizer and amendment for soil acidity. The N and K contents in the biochar, although relatively high, cannot be relied upon as a mineral fertilizer. Further studies are needed to assess whether the N and K contents of the biochar indicate it can be regarded as a useful fertilizer.     

Influence of poultry manure–derived biochars on nutrients bioavailability and chemical properties of a calcareous soil

This study was conducted to investigate the effects of poultry manure (PM) and its derived biochars on chemical properties of a calcareous soil. PM and biochars prepared at 200°C (B200), 300°C (B300) and 400°C (B400) were applied to a calcareous soil at 2% level (w/w) and incubated for 150 days. Selected soil chemical properties and phosphorous, potassium, iron, manganese, zinc and copper availability and recovery were determined at 1, 15, 45 and 150 days of incubation. Soil nutrients availability, organic carbon (OC), electrical conductivity (EC) and cation exchange capacity (CEC) increased by addition of all organic substances. Biochars prepared at higher temperatures were more effective in increasing soil OC with higher durability compared to other treatments. The addition of PM and B200 decreased soil pH, whereas B400 increased it. Although the highest soil EC was observed in B300- and B400-treated samples in the early stages of incubation, the rate of increase in soil EC was higher for PM- and B200-treated soils compared to other treatments. It was concluded that biochar prepared at 300°C had the highest positive effect on nutrients availability and lasts longer in calcareous soil compared to the other produced biochars and PM.     

Recycling of Chicken and Duck Litter Ash as a Nutrient Source for Japanese Mustard Spinach

ABSTRACT

Recycling combusted poultry litter ash as a soil amendment would potentially ameliorate problems normally associated with poultry waste management. We evaluated the effect of chicken litter ash (CLA) and duck litter ash (DLA) as nutrient sources for Japanese mustard spinach (Brassica rapa L. var. perviridis) grown on a sand dune soil. Chicken and duck litter were ashed at five temperatures: 200, 400, 600, 800, and 900°C and the resulting ash samples were applied at the rate of 100 kg phosphorus (P) ha^?1. Laboratory analysis showed the highest P extraction with citric acid from CLA and DLA obtained at 600°C. Chicken litter ash was richer in P and potassium (K) than DLA but the later contained more calcium (Ca) and magnesium (Mg). The amount of ammonium acetate soluble calcium (Ca), magnesium (Mg), and K recovered increased with increasing temperature except for Ca and Mg at the highest temperatures, 800 and 900°C. Plants grown in pots with the CLA and DLA obtained at 400°C had the highest P concentration, yielding significantly more biomass with dense green leaf color but on average, the DLA amended soil had greater biomass. However, the P level was higher in CLA treated plants than DLA due to the higher available P level (citric acid soluble). Increases in electrical conductivity and pH of the soil were noted after harvest due to litter ash application. Our experiment demonstrated that poultry litter is potential source of P and other nutrients for horticutural crops.     

A rapid-test for screening biochar effects on seed germination

We developed a rapid-test to screen for effects of biochar on seed germination and soils. Crop seeds were placed in containers and covered with 15 g of soil with 1% biochar by weight. Two agricultural soils from South Carolina USA were used. Eighteen biochars were produced from six primary feedstocks [pine chips (PC), poultry litter (PL), swine solids (SS), switchgrass (SG); and two blends of PC and PL, 50% PC/50% PL (55), and 80% PC/20% PL (82)]. Each feedstock was pyrolyzed at 350, 500 and 700°C. There were few biochar effects on seed germination. Shoot dry weight was increased for carrot, cucumber, lettuce, oat, and tomato; primarily with biochars containing PL. Soil pH, electrical conductivity and extractable phosphorus primarily increased with PL, SS, 55, and 82 treatments for both soil types and across species. This method can be an early indicator of biochar effects on seed germination and soil health.     

Effect of low‐temperature biochar derived from pig manure and poultry litter on mobile and organic matter‐bound forms of Cu,Cd, Pb and Zn in sandy soil

Numerous studies conducted so far have shown that biochar has a significant effect on physical, chemical and biological properties of soils. Biochar can be used to alleviate the effects of soil contamination with organic and inorganic compounds, for instance, to reduce the mobility of heavy metals. The aim of the research was to evaluate the effect of pig manure and poultry litter, as well as biochars produced from these materials at a temperature of 300 °C on Cu, Cd, Pb and Zn contents in mobile and organic matter‐bound forms in soil. The research was conducted under laboratory conditions. The materials were introduced into sandy acid soil in doses of 0.5, 1.0 and 2.0% w/w. The application of pig manure‐derived biochar (BPM) and poultry litter‐derived biochar (BPL), depending on the amount added, reduced the mobility of copper from 28 to 69%, from 77 to 100% in the case of cadmium, from 94 to 99% in the case of lead, and from 15 to 97% in the case of zinc. The 2% amendment of pig manure (PM) and poultry litter (PL) caused an increase in the content of Cu extracted with NH₄NO₃ in comparison with the control treatment. A similar situation was observed in the case of zinc after the application of 0.5 and 1% amendments of pig manure (PM). Cu, Cd, Pb and Zn contents extracted with 0.025 mol C₁₀H₂₂N₄O₈ were higher than contents of these elements extracted with 1 m NH₄NO₃, mainly due to different extraction force of the extractants. The obtained results indicate that, compared with the content determined in soil from the control treatment, 1 and 2% amendments of both unconverted and thermally converted materials to the soil had a greater effect on contents of Cu, Pb and Zn in the organic matter‐bound fraction than the 0.5% amendment. The organic materials applied did not affect the content of cadmium in organic matter‐bound fraction.     

A new 3D conceptual structure modeling of biochars by molecular mechanic and molecular dynamic simulation

Purpose

The combination of analytical chemistry and simulation methods provides more complete information about biochars.

Materials and methods

The biochars prepared by pyrolysis of the crop straw at 300 and 500 °C were investigated by elemental analysis, pyrolysis-gas chromatography-mass spectrometry (Py-GC-MS) and solid-state ¹³C nuclear magnetic resonance (NMR) spectrometry to build the 2D structural models of biochars. The most stable and balanced 3D conformations were gained by optimizing in the optimized potential for liquid simulation (OPLS) force field of molecular mechanic and molecular dynamic simulation of HyperChem® software.

Results and discussion

There were few O-containing and N-containing compounds in biochars. According to the results of Py-GC-MS, 41 and 28 pyrolysis products were identified for the building of the conceptual models of 300 and 500 °C biochars. Solid-state ¹³C NMR data also demonstrated that there were very high values of unsaturated C in biochars. The agreement between elemental concentration and chemical functional groups of two simulated models and experimental biochars was successfully achieved. Quantitative structure activity relationship (QSAR) properties were calculated and indicated the correlation of molecular structures with properties such as surface area, volume, polarizability, refractivity, and hydration energy.

Conclusions

The conceptual structural models of corn straw biochars produced at 300 and 500 °C were C₇₈H₆₈N₂O₂₅ and C₅₉H₂₉NO₁₀, respectively. The simulation results showed that the 3D structure of the 300 °C biochar with ?4 charges and the nonprotonated 3D structure of the 500 °C biochar were the most stable. Deprotonation reaction is an endothermic process.