Detection of rancid defect in virgin olive oil by the electronic nose

A sensor array of 32 conducting polymer sensors has been used to detect the rancid defect in virgin olive oils. A training set, composed of admixtures of a Portuguese virgin olive oil with different percentages (0-100%) of a rancid standard oil, was used for the selection of the best sensors classifying correctly the samples. Information on volatile compounds responsible for rancidity and the sensory evaluation of samples by assessors were used for explaining the mathematical selection of sensors. A tentative calibration, using unsupervised procedures (PCA and MDS) and a nonlinear regression, was carried out, with the training set, and later confirmed with a test set with which rancid commercial samples of different varieties were used to spike a Greek extra virgin olive oil at low levels of rancidity (0.5-6%).     

Comparison of static headspace, headspace solid phase microextraction, headspace sorptive extraction, and direct thermal desorption techniques on chemical composition of French olive oils

Static headspace (SHS), headspace solid phase microextraction (HS-SPME), headspace sorptive extraction (HSSE), and direct thermal desorption (DTD) were applied to the analysis of four French virgin olive oils from Corsica. More than 60 compounds were isolated and characterized by GC-RI and GC-MS. SHS was not suited to the characterization of olive oil volatile compounds because of low sensitivity. The SPME and HSSE techniques were successfully applied to olive oil headspace analysis. Both methods allow the characterization of volatile compounds (mainly C(6) aldehydes and alcohols), which contribute significantly to the "green" flavor note of virgin olive oils. The PDMS stir bar showed a higher concentration capacity than a DVB/CAR/PDMS SPME fiber due to the higher volume of polymeric coating. DTD was a very good tool for extracting volatile and especially semivolatile compounds, such as sesquiterpenes, but requires a significant investment like that for HSSE. Finally, SPME may be a more appropriate technique for routine quality control due to its operational simplicity, repeatability, and low cost.     

Solid-phase microextraction in the analysis of virgin olive oil volatile fraction: characterization of virgin olive oils from two distinct geographical areas of northern Italy

SPME was employed to characterize the volatile profile of virgin olive oils produced in two geographical areas of northern Italy: the region of the Gulf of Trieste and the area near Lake Garda. There are as yet no data on the headspace composition of virgin olive oils from these regions, characterized by particular conditions of growth for Olea europaea. Using the SPME technique coupled to GC-MS and GC-FID, the volatile components of 42 industrially produced virgin olive oil samples were identified and the principal compounds quantitatively analyzed. Significant differences in the proportion of volatile constituents from oils of different varieties and geographical origins were detected. The results suggest that besides the genetic factor, environmental conditions influence the volatile formation.     

SPME-GC-MS versus Selected Ion Flow Tube Mass Spectrometry (SIFT-MS) analyses for the study of volatile compound generation and oxidation status during dry fermented sausage processing

The use of selected ion flow tube mass spectrometry (SIFT-MS) and gas chromatography-mass spectrometry together with solid phase microextraction (GC-MS-SPME) has been compared in the analysis of volatile compounds during dry fermented sausage processing. Thus, the headspace (HS) of samples of dry fermented sausages with different fat contents was analyzed during their manufacture using both techniques, and significant and positive correlations were found between SIFT-MS and SPME-GC-MS measurements for the compounds pentanal, hexanal, 2-heptenal, octanal, 2-nonenal, 2-butanone, 2-pentanone, ethanol, acetic acid, and hexanoic acid. The oxidative status of fermented sausages during processing was also evaluated, and a significant correlation was obtained between the HS concentration of lipid autoxidation volatile compounds measured by SIFT-MS and SPME-GC-MS and the level of thiobarbituric acid reactive substances (TBARS) in the sausage. The hexanal measured by SIFT-MS resulted in a higher correlation coefficient (r = 0.936) than that obtained using SPME-GC-MS (r = 0.927). SIFT-MS is shown to be a fast, real time analytical technique for monitoring changes in the profile of volatile compounds in dry fermented sausages during processing and a useful tool to evaluate the oxidative status of meat products.     

Correlations of the phenolic compounds and the phenolic content in some Spanish and French olive oils

The total content of phenolic compounds (TAP) in 29 different monocultivar olive oil samples from France (Aglandau and Tanche) and Spain (Cornicabra, Picual, and Verdial) was assessed by the colorimetric Folin-Ciocalteu method. Also, individual phenolic compounds were determined and quantified by liquid chromatography coupled to mass spectrometry (LC-MS). The French olive oil samples had a lower TAP compared to Spanish samples. The quantity of individual phenolics was similar except for pinoresinol, which was lower in the French olive oil samples. TAP moderately correlated to the sum of quantified compounds (r = 0.64 and p < 0.01) Partial least-squares (PLS) regression analysis emphasized the importance of hydroxytyrosol and the total amount of quantified phenolic compounds by LC-MS in the prediction of the total amount of phenolic compounds as determined by the Folin-Ciocalteu method. The amount of alpha-tocopherol was generally different among the cultivars (Tanche > Picual > Verdial > Aglandau > Cornicabra). Of all quantified phenolic compounds in French olive oil samples, only luteolin correlated well to the altitude of the olive orchards (r = 0.76, p < 0.01).     

Characterization of volatiles in virgin olive oil produced in the Tunisian area of Tataouine

The Tataouine province in southern Tunisia is well known for its severe pedoclimatic conditions. Using solid phase microextraction (SPME) and gas chromatography (GC), coupled to flame ionization and mass spectrometer detectors, we characterized virgin olive oils from Chemlali Tataouine, Fakhari Douirat, Zarrazi Douirat, and Dhokar Douirat varieties, which grow in the harsh arid region of Tataouine. Significant differences in the proportions of volatile constituents from oils of different varieties were detected. The results showed that lipoxygenase products were generally the major metabolites of the volatile fraction, and (E)-Hex-2-enal was the principal compound characterizing the olive oil headspace for most samples, though the absolute levels varied greatly, never exceeding 76.45 and 32.16%, respectively. The C5 compounds were unusually abundant, comprising 42.97% of the total lipoxygenase products and a remarkably high level of penten dimers. Each autochthonous variety could thus be differentiated according to the percentage of each metabolite.     

Changes induced by UV radiation during virgin olive oil storage

The effects of UV radiation on the chemical and sensory characteristics of virgin olive oils (cv. Arbequina and Picual) were assessed. Even small doses of UV radiation induced oxidation of the virgin olive oil samples. Total phenols and fatty acids contents decreased during the process as well as the intensity of the bitter and fruity sensory attributes, while the intensity of the rancid sensory attribute notably increased. Acetaldehyde, 2-butenal, 2-pentenal, octane, octanal, hexanal, nonanal, and 2-decenal were the volatile compounds most affected, showing an important increase during the irradiation process. Nonanal, hexanal, and pentanal showed high correlation with the rancid sensory attribute (90%, 86%, and 86%, respectively). 2-Decenal and nonanal concentrations allowed us to predict the alteration level of the samples by mean of multiple Ridge regression.     

Authentication of vegetable oils by bulk and molecular carbon isotope analyses with emphasis on olive oil and pumpkin seed oil

The authenticity of vegetable oils consumed in Slovenia and Croatia was investigated by carbon isotope analysis of the individual fatty acids by the use of gas chromatography-combustion-isotope ratio mass spectrometry (GC/C/IRMS), and through carbon isotope analysis of the bulk oil. The fatty acids from samples of olive, pumpkin, sunflower, maize, rape, soybean, and sesame oils were separated by alkaline hydrolysis and derivatized to methyl esters for chemical characterization by capillary gas chromatography/mass spectrometry (GC/MS) prior to isotopic analysis. Enrichment in heavy carbon isotope ((13)C) of the bulk oil and of the individual fatty acids are related to (1) a thermally induced degradation during processing (deodorization, steam washing, or bleaching), (2) hydrolytic rancidity (lipolysis) and oxidative rancidity of the vegetable oils during storage, and (3) the potential blend with refined oil or other vegetable oils. The impurity or admixture of different oils may be assessed from the delta(13)C(16:0) vs. delta(13)C(18:1) covariations. The fatty acid compositions of Slovenian and Croatian olive oils are compared with those from the most important Mediterranean producer countries (Spain, Italy, Greece, and France).     

Bovine serum albumin produces a synergistic increase in the antioxidant activity of virgin olive oil phenolic compounds in oil-in-water emulsions

Virgin olive oil is valued for its flavor, but unacceptable off-flavors may develop on storage in food products containing this oil due to oxidation. The oxidative stability of oil-in-water emulsions containing bovine serum albumin (BSA) and virgin olive oil phenolic compounds was studied. Four oil-in-water emulsions with and without BSA and phenols isolated from virgin olive oil were prepared. These model systems were stored at 60 degrees C to speed up lipid oxidation. Primary and secondary oxidation products were monitored every three days. Peroxide values and conjugated diene contents were determined as measures of the primary oxidation products. p-Anisidine values and volatile compounds were determined as measures of the secondary oxidation products. This latter determination was carried out by headspace solid-phase microextraction coupled with gas chromatography. Although olive oil phenolic compounds and BSA contributed some antioxidant activity when present as individual additives, the combination of BSA with phenols in an emulsion showed 58-127% synergy, depending on which analytical method was used in the calculation. The emulsion containing phenolic compounds and BSA showed a low level of deterioration after 45 days of storage at 60 degrees C.     

Origin of French virgin olive oil registered designation of origins predicted by chemometric analysis of synchronous excitation-emission fluorescence spectra

The authentication of virgin olive oil samples requires usually the use of sophisticated and very expensive analytical techniques, so there is a need for fast and inexpensive analytical techniques for use in a quality control methodology. Virgin olive oils present an intense fluorescence spectra. Synchronous excitation-emission fluorescence spectroscopy (SEEFS) was assessed for origin determination of virgin olive oil samples from five French registered designation of origins (RDOs) (Nyons, Vallée des Baux, Aix-en-Provence, Haute-Provence, and Nice). The spectra present bands between 600 and 700 nm in emission due to chlorophylls a and b and pheophytins a and b. The bands between 275 and 400 nm in emission were attributed to alpha-, beta-, and gamma-tocopherols and to phenolic compounds, which characterize the virgin olive oils compared to other edible oils. The chemometric treatment (PLS1) of synchronous excitation-emission fluorescence spectra allows one to determine the origin of the oils from five French RDOs (Baux, Aix, Haute-Provence, Nice, and Nyons). Results were quite satisfactory, despite the similarity between two denominations of origin (Baux and Aix) that are composed by some common cultivars (Aglandau and Salonenque). The interpretation of the regression coefficients shows that RDOs are correlated to chlorophylls, pheophytins, tocopherols, and phenols compounds, which are different for each origin. SEEFS is part of a global analytic methodology that associates spectroscopic and chromatographic techniques. This approach can be used for traceability and vindicates the RDOs.     

Excitation-emission fluorescence spectroscopy combined with three-way methods of analysis as a complementary technique for olive oil characterization

This paper shows the potential of excitation-emission fluorescence spectroscopy (EEFS) and three-way methods of analysis [parallel factor analysis (PARAFAC) and multiway partial least-squares (N-PLS) regression] as a complementary technique for olive oil characterization. The fluorescence excitation-emission matrices of a set of Spanish extra virgin, virgin, pure, and olive pomace oils were measured, and the relationship between them and some of the quality parameters of olive oils (peroxide value, K232, and K270) was studied. N-PLS was found to be more suitable than PARAFAC combined with multiple linear regression for correlating fluorescence and quality parameters, yielding better fits and lower prediction errors. The best results were obtained for predicting K270. EEFS allowed detection of extra virgin olive oils highly degraded at early stages (with high peroxide value) and little oxidized pure olive oils (with low K270). The proposed methodology may be used as an aid to analyze doubtful samples.     

Near-infrared spectroscopic determination of degradation in vegetable oils used to fry various foods

Near-infrared (NIR) spectroscopic methods for measuring degradation products, including total polar materials (TPMs) and free fatty acids (FFAs), in soy-based frying oil used for frying various foods have been successfully developed. Calibration models were developed using forward stepwise multiple linear regression (FSMLR) and partial least-squares (PLS) regression techniques and then tested with an independent set of validation samples. The results show that the quality of oil used for frying different foods can be measured with a single model. First-derivative treatments improved results for TPM measurement. In addition, PLS models gave better prediction results than FSMLR models. For PLS models, the best correlations (r) between the NIR-predicted data and the chemical method data for TPMs and FFAs in oils were 0.995 and 0.981, respectively. For FSMLR models, the best r values for TPMs and FFAs in oils were 0.993 and 0.963, respectively.     

Characterization of the lipoxygenases in some olive cultivars and determination of their role in volatile compounds formation

Enzymatic extracts from olive pulp (Olea europea L.) were used to characterize lipoxygenase (LOX) activity in order to determine its role in the biogenesis of the volatile compounds that influence the aroma of extra virgin olive oil. The LOX activity was tested spectrophotometrically at an optimal pH of 6.0 in three olive cultivars, Ascolana Tenera, Kalamata, and FS17. The trend of the LOX activity was determined as a function of pH and temperature; the kinetic constants of the enzyme were also determined. The highest LOX activity was observed in the FS17 fruit, which had the highest concentrations of C(5) and C(6) compounds (aldehydes, alcohols, and ketones), followed by Kalamata and Ascolana T., respectively. Given the direct relationship between enzymatic activity and the quantity of aromas measured in the fruit, it is hypothesized that olive LOX is involved in the formation of C(5) and C(6) volatile compounds. To study the mechanism of the movement of the aromas from the fruit to the oil, which was obtained by simple mechanical extraction, the headspace of the oil for each cultivar was analyzed as well as the aromatic composition in order to compare it with the aromas of the fruit.     

Synthesis of volatile compounds of virgin olive oil is limited by the lipoxygenase activity load during the oil extraction process

The aim of this work was to determine whether the lipoxygenase (LOX) activity is a limiting factor for the biosynthesis of virgin olive oil (VOO) volatile compounds during the oil extraction process. For this purpose, LOX activity load was modified during this process using exogenous LOX activity and specific LOX inhibitors on olive cultivars producing oils with different volatile profiles (Arbequina and Picual). Experimental data suggest that LOX activity is a limiting factor for the synthesis of the oil volatile fraction, this limitation being significantly higher in Picual cultivar than in Arbequina, in line with the lowest content of volatile compounds in the oils obtained from the former. Moreover, there is evidence that this limitation of LOX activity takes place mostly during the milling step in the process of olive oil extraction.     

Comparison of natural polyphenol antioxidants from extra virgin olive oil with synthetic antioxidants in tuna lipids during thermal oxidation

Polyphenols extracted from extra virgin olive oil (EVOO) were tested for their ability to inhibit lipid oxidation of canned tuna. Hydroperoxide formation during oxidation was monitored by measurement of peroxide value and decomposition of hydroperoxides by static headspace gas chromatographic analysis of volatiles. In tuna oxidized at 40 and 100 degrees C, 400 ppm of the EVOO polyphenols was an effective antioxidant as compared with 100 ppm of a 1:1 mixture of the synthetic antioxidants butylated hydroxytoluene and butylated hydroxyanisole. However, at concentrations <100 ppm, the EVOO phenolic compounds promoted hydroperoxide formation and decomposition. The EVOO polyphenols were effective antioxidants when added to heated tuna muscle in the presence of either brine or refined olive oil. The oxidation rate in tuna muscle packed in brine was higher than that of tuna packed in refined olive oil. The EVOO polyphenols had higher antioxidant activity in the brine samples than in the refined olive oil. The higher antioxidant activity of EVOO polyphenols in tuna packed in brine may be explained by their greater affinity toward the more polar interface between water and the fish oil system.     

Simultaneous fluorometric determination of chlorophylls a and B and pheophytins a and B in olive oil by partial least-squares calibration

The resolution of quaternary mixtures of chlorophylls a and b and pheophytins a and b has been accomplished by partial least-squares (PLS) multivariate calibration, applied to the fluorescence signals of these pigments. The total luminescence information of the compounds has been used to optimize the spectral data set to perform the calibration. After preliminary studies, a method is described in acetone media, to avoid emulsions with the olive oil samples. Different scanning paths have been selected for each method. For the simultaneous determination of the pigments in olive oil samples, a comparative study of the results found by using excitation, emission, and synchronous spectral data, as analytical signal, was performed. The excitation spectra were selected as the better analytical signals for the determination of the pigments in olive oil samples. The optimum wavelength range to record the excitation spectra (lambda(em) = 662 nm) was selected to minimize the contribution of pheophytin a and to maximize the contribution of the other pigments, which are the minor constituents in olive oil. Determination of these pigments in olive oil samples was effected from the excitation spectra of dissolutions o suitable aliquots in acetone. Recovery values from olive oil, spiked with chlorophylls a and b and pheophytins a and b, were in the ranges of 70-112, 71-111, 76-105, and 82-109%, respectively.     

Changes in volatile and phenolic compounds with malaxation time and temperature during virgin olive oil production

Virgin olive oils produced at wide ranges of malaxation temperatures (15, 30, 45, and 60 degrees C) and times (30, 60, 90, and 120 min) in a complete factorial experimental design were discriminated with stepwise linear discriminant analysis (SLDA) revealing differences with processing conditions. Virgin olive oils produced at 15 and 60 degrees C for 30 min showed the most significant (p < 0.01) differences. Discrimination was based upon volatile and phenolic compounds detected in olive oils, peroxide value (PV), free fatty acids (FFA), ultraviolet (UV) absorbances, and oil yield. There were different discriminating variables for processing conditions illustrating the dependence of virgin olive oil quality on malaxation time and temperature. Volatile compounds were the dominant discriminating variables. Common oxidation indicators of olive oil (PV, K232, and K270) were not among the variables that significantly (p < 0.01) changed with malaxation time and temperature. Variables that discriminated both malaxation time and temperature were hexanal, 3,4-dihydroxyphenyl ethyl alcohol-decarboxymethyl elenolic acid dialdehyde (3,4-DHPEA-DEDA) and FFA, whereas 1-penten-3-ol, E-2-hexenal, octane, tyrosol, and vanillic acid significantly (p < 0.01) changed with temperature only and Z-2-penten-1-ol, (+)-acetoxypinoresinol, and oil yield changed with time only. Virgin olive oil quality was significantly influenced by malaxation temperature, whereas oil yield discriminated malaxation time. This study demonstrates the two modes of hexanal formation: enzymatic and nonenzymatic during virgin olive oil extraction.     

Detection of extra virgin olive oil adulteration with lampante olive oil and refined olive oil using nuclear magnetic resonance spectroscopy and multivariate statistical analysis

High-field 31P NMR (202.2 MHz) spectroscopy was applied to the analysis of 59 samples from three grades of olive oils, 34 extra virgin olive oils from various regions of Greece, and from different olive varieties, namely, 13 samples of refined olive oils and 12 samples of lampante olive oils. Classification of the three grades of olive oils was achieved by two multivariate statistical methods applied to five variables, the latter being determined upon analysis of the respective 31P NMR spectra and selected on the basis of one-way ANOVA. The hierarchical clustering statistical procedure was able to classify in a satisfactory manner the three olive oil groups. Subsequent application of discriminant analysis to the five selected variables of oils allowed the grouping of 59 samples according to their quality with no error. Different artificial mixtures of extra virgin olive oil-refined olive oil and extra virgin olive oil-lampante olive oil were prepared and analyzed by 31P NMR spectroscopy. Subsequent discriminant analysis of the data allowed detection of extra virgin olive oil adulteration as low as 5% w/w for refined and lampante olive oils. Further application of the classification/prediction model allowed the estimation of the percent concentration of refined olive oil in six commercial blended olive oils composed of refined and virgin olive oils purchased from supermarkets.     

Changes in virgin olive oil quality during low-temperature fruit storage

'Frantoio' olive fruits were stored at low temperature (4 +/- 2 degrees C) for 3 weeks to investigate the effect of postharvest fruit storage on virgin olive oil quality. Volatile compounds and phenolic compounds explained the changes in sensory quality that could not be explained with quality indices (FFA, PV, K232, and K270). Increases in concentrations of ( E)-2-hexenal and hexanal corresponded to positive sensory quality, whereas increases in ( E)-2-hexenol and (+)-acetoxypinoresinol were associated with negative sensory quality. Volatile and phenolic compounds were also indicative of the period of low-temperature fruit storage. Oleuropein and ligstroside derivatives in olive oil decreased with respect to storage time, and their significant ( p < 0.05) change corresponded to changes in bitterness and pungency. ( Z)-2-Penten-1-ol increased during low-temperature fruit storage, whereas 2-pentylfuran decreased. Changes in volatile compounds, phenolic compounds, quality indices, and sensory notes indicated that virgin olive oil quality was lost within the first week of low-temperature fruit storage and regained at 2 weeks. This research suggests that low-temperature olive fruit storage may be beneficial, with a possibility of increasing oil yield and moderating the sensory quality of virgin olive oils. This study demonstrates that deeper insights into virgin olive oil quality changes during low-temperature fruit storage may be gained by studying volatile and phenolic compounds in addition to quality indices and physical appearance of the fruit.     

Presence of phytosterol oxides in crude vegetable oils and their fate during refining

The content of phytosterol oxidation products was determined in samples of crude vegetable oils: peanut, sunflower, maize, palm nut, and lampante olive oils that were intended for refining and not for direct consumption. The 7 alpha- and 7 beta-hydroxy derivatives of beta-sitosterol, stigmasterol, and campesterol and the 7-keto-beta-sitosterol were the principal phytosterol oxides found in almost all of the oils analyzed. In some oils, the epoxy and dihydroxy derivatives of beta-sitosterol were also found at very low levels. The highest total concentrations of phytosterol oxides, ranging from 4.5 to 67.5 and from 4.1 to 60.1 ppm, were found in sunflower and maize oils, respectively. Lower concentrations were present in the peanut oils, 2.7-9.6 ppm, and in the palm nut oil, 5.5 ppm, whereas in the lampante olive oils, only three samples of the six analyzed contained a low concentration (1.5-2.5 ppm) of oxyphytosterols. No detectable levels of phytosterol oxides were found in the samples of palm and coconut oils. Bleaching experiments were carried out on a sample of sunflower oil at 80 degrees C for 1 h with 1 and 2% of both acidic and neutral earths. The bleaching caused a reduction of the hydroxyphytosterol with partial formation of steroidal hydrocarbons with three double bonds in the ring system at the 2-, 4-, and 6-positions (steratrienes). The same sunflower oil was deodorized at 180 degrees C under vacuum for 1 h, and no dehydration products were formed with a complete recovery of the hydroxyphytosterols. A bleaching test with acidic earths was carried out also with an extra virgin olive oil fortified with 7-keto-cholesterol, dihydroxycholesterol, and alpha-epoxy-cholesterol. There was no formation of steratrienes from these compounds, but dihydroxycholesterol underwent considerable decomposition and alpha-epoxycholesterol underwent ring opening with formation of the dihydroxy derivative, whereas 7-ketocholesterol was rather stable