An experimental study of the utilisation, by the laying hen, of dietary energy partially supplied as animal fat

Experiments were carried out at two centres in which laying hens were fed diets containing up to 28.25 per cent tallow and in which an attempt was made to maintain a fairly constant calorie : protein ratio. The most satisfactory production was obtained on a diet containing 3.5 per cent added fat in one experiment and 7.5 per cent added fat in the other experiment. Food conversion efficiency (kg food/kg eggs) increased with increasing dietary fat content.

The efficiency of ME utilisation (Mcal/kg egg) decreased with increasing dietary ME content. The data indicate that at the higher levels of fat addition the net utilisation of ME was decreased.

In both experiments mean egg weight was increased by the addition of tallow to the diet whilst at the highest level of addition there was a very high mortality.     

The necessity of supplementing laying hen diets with linoleic acid

Results from four experiments with laying hens have been re‐examined using the means of individual 28‐d periods during egg production to investigate the influence of the developing ovary and linoleate storage during growth on the linoleic acid requirement of the laying hen.

Apart from a possible beneficial effect during the first few weeks of production, little increase in egg weight occurs when birds are fed on conventional rearing diets and then fed on laying diets containing linoleic acid in excess of requirement.

After depletion of linoleate reserves, dietary supplementation with linoleic acid significantly increases egg weight at any age.

The necessity of supplementing diets for laying hens with linoleic acid is discussed.     

Behavioural adaptation of laying hens to dilution of diets under mash and pellet form

1. Two laying diets, control (A) and a low‐energy (B) diet diluted by adding 450 g/kg wheat bran, were fed to semi‐heavy hens in three different forms: mash, small pellets and large pellets. The behavioural adaptations and the production characteristics for these six regimens were studied on 72 individually caged hens, between 19 and 29 weeks of age, subjected to a lighting pattern of 14 h light/24 h.

2. Diet B, as mash, showed a lower apparent physical density than the others. The hardness and durability of the pelleted diets were similar.

3. Hens fed the mash diet B could not completely adjust their food intake to compensate for the dilution and showed reduced egg output and body weight gain compared to the other groups.

4. Video observation of each hen for 14 consecutive hours showed that mash‐fed hens ate for longer periods than pellet‐fed hens during the first 11 h (proportion of time spent eating: 41.3% mash B, 32.5% mash A and 20% to 25% for all the pelleted diets). These differences were less pronounced during the last 3 h of the photoperiod.

5. Trough‐oriented stereotypies were noted in 14 out of 22 mash‐fed hens and in 12 out of 47 pellet‐fed hens. Dilution of the diet did not appear to exacerbate stereotyped behaviours under the conditions of the study.

6. This experiment demonstrates that the feeding behaviour of laying hens is affected by the physical characteristics of the diet and that this may lower their productivity.

7. Low‐energy pelleted diets might be used to feed hens efficiently in tropical countries where cereal by‐products are abundant.     

Incorporation of triticale in layer diets

1. Diets containing either maize or triticale were fed unsupplemented or supplemented with meat meal or groundnut oil to White Leghorn pullets for two periods of 11 weeks each.

2. The egg production of birds fed on the unsupplemented triticale diet was significantly higher than that of the birds fed on the unsupplemented maize diet, but was not significantly different from that of the birds fed on the maize plus meat meal diet.

3. Protein quality of the unsupplemented triticale diet as judged by efficiency of nitrogen retention was similar or inferior to that of the unsupplemented maize diet.

4. The higher protein content of triticale and the increased intake of these diets seemed to be responsible for the better performance observed.

5. Addition of groundnut oil to the triticale diet did not improve either egg weight or production.

6. It is concluded that the quantitative substitution for triticale of maize does not adversely affect egg production and egg weight.     

Rapeseed meals in broiler diets: Effect on performance and sensory evaluation of carcasses

1. The effect of including rapeseed meal (RSM) in lieu of soyabean meal in broiler diets was determined.

2. Live‐weight gains, from 8 to 63 d, were depressed when the diet contained 150 g RSM/kg and there was a highly significant negative correlation between weight gain and inclusion rate of RSM over this period.

3. The efficiency of food utilisation was worse when the diet included 150 g solvent RSM/kg than when it contained no RSM: food efficiency was consistently poorer whenever RSM was included in the diet but the difference was significant only when the diet contained 10 g tallow/kg.

4. Carcasses from birds fed on diets containing 10 g tallow/kg had a better appearance than those from birds on diets containing 30 g tallow/kg, while the flavour of meat from birds fed on a diet containing 150 g solvent RSM/kg treatment was adversely affected. However, up to 100 g solvent RSM/kg may be included in broiler diets without affecting appearance, taste, texture or acceptability of the meat.

5. Inclusion of 50 g or more, solvent RSM/kg reduced growth rate and worsened food efficiency.     

Phosphorus requirements of poultry. V. The effects during the subsequent laying year of feeding growing diets containing no animal protein or supplementary phosphorus

Pullets reared to 18 weeks of age on diets containing no feeding stuffs of animal origin and without phosphorus supplementation showed no significant difference in egg yield compared with similar pullets fed rearing diets containing animal protein and added phosphorus.

During the laying stage, diets in commercial use at this centre gave significantly higher egg yields, better average egg prices due to superior grading results and a higher margin over food cost than the same diets modified to conform with the nutrient recommendations of the National Research Council of America (1960).

Where the supplementary protein in both types of layers' diet was of vegetable origin, egg yield, food cost and margin of income over food cost were all significantly inferior to groups fed comparable diets containing supplementary protein of both vegetable and animal origin.

Soyabean meal and sunflower seed meal gave significantly poorer results when used in combination as the sole protein supplement compared with soyabean meal plus methionine.     

The use of rapeseed meals and a mustard seed meal as a protein source in diets for laying pullets

1. Three experiments with laying pullets were carried out in which rapeseed meals (B. napus and B. campestris) and a mustard seed meal (B. juncea) formed 12% of the diet.

2. Dietary rapeseed had no effect on the onset of lay when fed from 17 weeks of age but caused a delay when fed from 10 weeks of age: changing to a control soyabean diet for the laying period resulted in normal egg production.

3. Diets containing B. napus but not B. campestris consistently depressed egg production and reduced egg weight in one experiment. Mustard seed meal did not affect performance.

4. Significant number of eggs with a “fishy” taint were laid by brown‐egged birds fed on a diet containing rapeseed.

5. Thyroids of birds fed on rapeseed meal diets during the laying period were significantly heavier than those of birds fed on diets containing mustard seed or soyabean.

6. The enlargement of the thyroid gland is probably related to the oxazolidinethione content of the rapeseed.     

Comparison of laying rations with and without animal protein at the Canadian Random Sample Egg Production Test

For a number of years, the laying ration fed to the hens at the Canadian Random Sample Egg Production Test has contained foodstuffs of animal origin to the extent of 3 per cent meat meal, 2 per cent fish meal, 1 per cent dried whey and 2 per cent tallow. Recently, over a period of 2 years, this ration was compared with a modification in which all of the animal products except tallow were removed. The proportions of the remaining ingredients in the modified diet were adjusted to keep protein, energy, calcium and phosphorus levels comparable in the two rations.

In the first test year, the modified diet was slightly superior to the control diet in terms of egg numbers, egg weight and egg quality. In the second year, there were no significant differences in these traits between diets. Although 17 strains were tested in the first year, and 14 in the second, no significant strain × ration interactions occurred in any performance trait.

These trials provided no evidence that the laying hen responds to unknown factors contained in animal products. There was also no evidence that the removal of animal products adversely affected protein quality, although dietary protein levels may not have been low enough to reveal such a change.     

Absence of effects of dietary α‐tocopherol on egg yolk pigmentation

1. Three experiments were carried out in which yolk colour and carotenoid content were measured in hens fed diets containing soyabean oil or tallow and supplemented with 0, 10, 20, 40, 80, 160 or 320 mg tocopheryl acetate.

2. Fat type had no consistent effect on yolk carotenoid content but yolk α‐tocopherol concentrations were lower with the soyabean oil diet.

3. Yolk concentrations of all carotenoids measured and yolk colour were unaffected by dietary α‐tocopherol concentration.     

Hydrolysed feather protein as a source of amino acids for laying hens

1. The value of hydrolysed feather protein (HFM), included at 70 g/kg in a wheat‐based diet, as an amino acid source for laying hens was determined.

2. Egg production was reduced in hens fed on diets containing HFM owing to a deficiency in lysine, methionine and tryptophan.

3. Supplementation of the diet containing HFM with 3'0 g lysine (as L‐lysine HC1), 0.7g DL‐methionine and 0.5g L‐tryptophan per kilogram, resulted in a daily egg mass output similar to that achieved with a conventional layers’ diet.     

Effects of carbohydrase enzyme supplementation on performance,eggshell quality,and bone parameters of laying hens fed on maize- and wheat-based diets

1. This study was conducted to determine the effects of enzyme supplementation of maize/wheat-based diets on the performance, egg quality, and serum and bone parameters of laying hens.

2. During the 12-week experimental period, a total of 72 laying hens aged 52 weeks were randomly distributed among 6 experimental groups. Each experimental group contained 4 replicates, each with three birds. The experiment was a randomised design consisting of a 3 × 2 factorial arrangement, with three levels of wheat substitution and two levels of enzyme (xylanase: 1500.00 U/kg, β-glucanase: 100 000 U/kg, cellulase: 1 000 000 U/kg, α-amylase: 160 000 U/kg) inclusion in the diet. Wheat replaced 0, 50, or 100% of maize with or without 1.0 g/kg enzyme supplementation in iso-nitrogenous and iso-caloric experimental diets.

3. Body weight, egg production, egg weight, egg mass, eggshell thickness, and the feed conversion ratio were adversely affected by the wheat-based diet. The eggshell quality parameters decreased with enzyme supplementation to the diet.

4. Wheat-based diets adversely affected calcium and phosphorus concentrations in the tibia, but the addition of the enzymes to the wheat-based diet prevented the negative effects of wheat-based diets on tibia mineralisation in laying hens. The wheat-based diets tended to reduce plasma mineral contents, and the addition of enzymes tended to affect plasma minerals and biomechanical properties of the tibia positively in laying hens.

5. These results indicate that wheat-based diets in aged laying hens adversely affected the mineral metabolism compared with maize-based diets, and the negative effects of wheat on bone mineralisation can be prevented by enzyme supplementation to the diets in laying hens.     

Effect of feeding low lysine starters and developers on growth,sexual maturity and subsequent performance of broiler breeder pullets 1

Pullets that were fed diets containing 0.53 per cent and 0.42 per cent lysine grew at a slower rate and matured later than those that were given adequate amount of lysine. The latter pullets converted their food more efficiently than did the restricted pullets with the exception of the group fed the ration containing 0.53 per cent lysine for the first 12 weeks. The restricted pullets consumed less food during the growing period. A smaller bird was produced on less food. The restricted pullets were also lighter than the control pullets at the end of the laying season. A saving in food costs is indicated because the smaller hen would require less food for maintenance.

There was a higher mortality in the pullets fed a ration containing 0.53 per cent lysine during the growing period. The mortality in the group fed the ration containing 0.42 per cent lysine from 7 to 22 weeks of age was the same as that of the control. There were no differences in mortality during the laying season that could be related to methods of rearing the pullets.

During the laying season, the highest rate of lay was obtained from hens which had been fed the ration containing 0.42 per cent lysine from 7 to 22 weeks of age. Hens fed on the ration containing 0.53 per cent lysine from o to 4, 8 or 12 weeks of age showed no improvement in rate of lay as compared with controls.

Hens fed the ration containing 0.42 per cent lysine from 7 to 22 weeks laid fewer small eggs at the beginning of the laying season than did hens receiving adequate amounts of lysine throughout or fed the ration containing 0.53 per cent lysine from o to 4, 8 or 12 weeks. The hens fed the latter ration laid smaller eggs throughout the laying season.

No differences were found between the fertility, hatchability or embryonic mortality of eggs obtained from hens fed on lysine deficient diets during growth and those fed on diets adequate in lysine.     

The effects of crude and refined low erucic acid rapeseed oils in diets for laying hens

1. The effects of feeding diets containing 15% crude or refined low erucic acid Span rapeseed oils, refined regular rapeseed oil or lard to pullets on productive performance and the lipids of egg yolk were determined.

2. Productive performance was best with the low‐fat control diet, less good with the crude low erucic acid Span oil or lard‐containing diets, intermediate with the diet containing refined Span oil and worst with the diet containing regular rapeseed oil.

3. The various dietary treatments did not affect total lipid content of egg yolk but did affect the fatty acid composition of egg yolk lipids.

4. No substantial amounts of erucic acid were found in the eggs indicating that the hen is able to control the lipid concentration in egg yolk though control of the fatty acid composition of lipids is poorer.     

The laying performance of two strains of hens offered diets containing dried poultry manure during the laying stage

1. Light‐weight (Babcock B300) and medium‐weight (Warren‐SSL) hens were offered diets, containing 0, 100 or 200 g dried poultry manure (DPM) and 11.49, 11.12 or 10.83 MJ metabolisable energy/kg respectively, between 18 and 70 weeks of age. The true protein, metabolisable energy, calcium and phosphorus contents of the DPM, from caged layer hens, were used in the diet formulation.

2. The hen‐housed laying performance of hens offered the DPM‐containing diets was significantly better for number of eggs laid and total egg mass produced but the performance of the control groups was lower than would normally be expected of those stocks. The reason for the lower rate of lay and higher mortality of hens fed on the control diet was not identified. The amount of food consumed increased as the energy content of the diet decreased and the efficiency of food conversion (EFC) of the lightweight strain was reduced; there was no significant effect on the EFC of the medium‐weight hens.

3. The inclusion of DPM in the diets had no effect on albumen quality or on the incidence of hair‐cracked, cracked or broken eggs. However, with both strains of hens, shell weight and shell thickness were poorer when 100 or 200 g DPM/kg diets were fed.     

The response of egg weight to the inclusion of different amounts of vegetable oil and linoleic acid in the diet of laying hens

1. Four diets containing different amounts of vegetable oil and linoleic acid were fed to White Leghorn hens throughout a full laying year.

2. Egg weight was poor with the low fat basal diet but increased in relation to the amounts of maize oil (4 and 30 g/kg) included in the diet.

3. With a diet containing 30 g olive oil/kg, egg weight was similar to that obtained with the diet containing the same amount of maize oil.

4. Rearing the birds on diets containing low or moderate amounts of linoleic acid did not affect the response to fatty acid content of the layer's diet.

5. It is concluded that the requirement of the laying hen for linoleic add is not higher than 9 g/kg but that egg weight does respond to higher dietary amounts of readily absorbable fatty acids.     

Efficiency of egg production of three types of caged layers fed diets containing maize, oats or barley as the main cereal ingredient

The results of two similar experiments, each using 204 pullets in cages, are presented. In each experiment, a type of light commercial hybrid, heavier commercial hybrids and Brown Leghorn×Light Sussex cross‐breds were compared, in factorial design, on diets containing either 65 per cent barley, 55 per cent maize or 35 per cent oats and 15 per cent bran. Individual records of egg production, egg weight, food conversion and body weight were kept for eight 28‐day periods, starting when the pullets were in full production.

There were no significant differences in egg production between diets but in both experiments a significantly improved food conversion ratio was obtained on the high maize diets, which also gave the highest level of energy consumption.

Most breed differences were not significant but in Experiment 1 the crossbreds produced significantly fewer eggs than the hybrids and in Experiment 2 the light hybrids gave a significantly better food conversion ratio than the two heavier types. The crossbred pullets consumed the most energy in both experiments and in Experiment 1 had significantly the worst energetic efficiency of egg production.

There were no significant interactions between type of pullet and type of diet in either experiment. Thus there were no indications that, at the energy levels investigated, favourable effects may be expected from the feeding of higher energy diets to the lighter hybrid type pullet.

The practical significance of feeding a high barley diet is discussed.     

Effects on egg production of including high residual lipid copra meal in laying hen diets

1. The effects on egg production of including copra meals of 220.9 (Copra‐1) and 205.0 (Copra‐2) g residual lipids/kg, in laying hen diets at up to 400 g/kg, were examined in two feeding trials. In a separate experiment, the dry matter retention and ME of a 400 g Copra‐2/kg diet were determined between 6 to 9, 9 to 12 and 12 to 15 d of feeding.

2. Food intakes, egg output and efficiencies of food utilisation (g eggs/g food) of hens fed on Copra‐1 at 100 and 200 g/kg diet were not significantly different from controls; while food intakes at 400 g Copra‐1/kg diet were similar to controls, egg output (6.0% lower), efficiency of food utilisation and body weights of hens were significantly reduced. Hens fed Copra‐2 at 400 g/kg diet had 5.0 and 6.9% lower food intakes and egg output, respectively, and lost body weight compared to controls; however, egg output increased to that of the control group by the 11th week of feeding.

3. Initially, dry matter retention of the 400 g Copra‐2/kg diet was similar to, and ME slightly higher than the control diet; however, both were reduced significantly in the second and third collection periods. The water content of excreta from hens fed on 400 g Copra‐2/kg diet was significantly higher than that from controls.

4. Complete replacement of dietary maize, mainly with copra (experiment 1) led to an increase in pale yolks, with the 400 g Copra‐1/kg diet producing cream‐coloured yolks. Inclusion of maize at 180.6 g/kg of the 400 g Copra‐2/kg diet (experiment 2) resulted in eggs with slightly golden‐yellow yolks.     

Feeding layers of different genotypes in organic feed environments

1.?Two experiments were carried out to evaluate the suitability of an experimental laying hen genotype (SH) in organic egg production. SH had been selected over 25 generations on a low protein diet (130 g/kg) based on home grown feedstuffs. SH hens were compared with LSL (Experiment 1) and Hyline (Experiment 2) hens. The birds were kept in 12 aviary pens with access to outdoor runs.

2.?Four diets, which were different in each experiment, were used. A control diet was compared with diets based on feedstuffs supposed to be able to be grown and produced according to organic standards. The diets differed in the content of sulphur amino acids.

3.?There were no significant differences in mortality caused by diets or genotypes but an incidence of cannibalism occurred in one Hyline group fed on the diet with the lowest methionine content.

4.?Severe feather pecking of LSL birds occurred and was worst on the low protein diet. In Experiment 2, signs of feather pecking of birds on the low protein diet occurred at the end of the experiment, but there was no difference between the genotypes. There was no significant difference in number of eggs produced between diets. Egg weight was influenced by diets in both experiments and by genotype in Experiment 2. Number of misplaced eggs was higher in SH hens in both experiments. There were few significant diet × genotype interactions.

5.?The use of the outdoor area was influenced by diets and genotype in both experiments.

6.?In conclusion, diets low in methionine content influenced predominantly plumage condition and egg weight, although production of eggs by number was unaffected. The SH hen adapted well to organic conditions, as did the Hyline genotype.     

The effect of restricting the individual daily energy intake of caged layers on the efficiency of egg production

Two experiments are described in which the daily metabolisable energy intake of laying hens fed a concentrated diet (ME = 3550 kcal/kg) was restricted on an individual hen basis. Performance on this diet was compared with that of hens fed a high‐energy diet (ME = 2690 kcal/kg). In experiment 1 medium‐weight hybrid pullets were used and in experiment 2 two light‐weight hybrid strains were used.

In both experiments maximum egg production was obtained from the birds fed the high‐energy diet ad libitum. Restriction of the concentrated diet caused a significant reduction of body weight gain and a statistically insignificant fall in the total weight of egg product and in percentage production in both experiments.

Restriction of the concentrated diet caused improvements of 22 and 18 per cent in the efficiency of utilisation of metabolisable energy in experiments 1 and 2 respectively.

The data are discussed in relation to the relevant literature and the current cost of concentrated sources of energy.     

Calcium and phosphorus levels in the diet of laying birds

Two hatches of crossbred pullet chicks were brooded and reared to 18 weeks of age on diets which conformed to the recommendations of the National Research Council (N.R.C.) of America for calcium and phosphorus. The pullets of each hatch were then divided at random into six laying groups. Three groups were fed diets containing 2.25, 3.14 and 5.0 per cent respectively of calcium without supplementary phosphorus and the other three groups were fed diets of the same graded calcium levels but with supplementary phosphorus to give a total inorganic phosphorus content of 0.45 per cent. When the rate of egg production in the groups receiving 2.25 per cent calcium exceeded 70 per cent an ad libitum supply of limestone grit was provided and the intake recorded. Over the twelve months of lay this resulted in an average total dietary intake level of nearly 2.65 per cent calcium.

Egg yield was not significantly influenced by the diets, except that the production of birds fed on the diet containing 5 per cent calcium without supplementary phosphorus was significantly depressed. Food intake was not adversely affected by the higher levels of ground limestone; in fact, there was a positive regression of food consumption on the percentage of calcium in the diet. Because of the greater food intake and the lower egg production, food consumed per dozen eggs and cost of food per dozen eggs were higher in the groups receiving 5 per cent dietary calcium without phosphorus supplementation, compared with groups which received lower dietary levels of calcium. There were, however, no significant differences between the various groups in income or in the margin of income over costs, per bird or per dozen eggs.

The data on egg grading showed that over the two experiments and at all levels of calcium there was no evidence of any influence of phosphorus on the combined percentage of large and standard eggs. The average percentage for the two diets with the 5 per cent level of calcium was significantly greater than the combined average for all the other diets.

The average percentage of cracked eggs for the groups with diets containing 5 per cent calcium was 9.4 per cent compared with an average of 11.1 per cent for all the other diets, but the difference was not significant.

The results suggest that there is no economic advantage in raising the calcium content of the basal diet used in these experiments beyond the level of 3.14 per cent and that at this level there appears to be no need with this basal diet to supplement the phosphorus content.