乙醇溶剂与超临界CO2相结合提取高纯度卵黄磷脂的研究

采用乙醇溶剂首先提取蛋黄粉中的卵黄油，然后用超临界CO₂萃取方法脱除卵黄油中的中性脂肪，获得高纯度的卵黄磷脂。考察了工艺参数对提取效果的影响。试验表明：在乙醇溶剂提取卵黄油阶段，乙醇浓度是影响卵黄油提取率的最主要因素，温度是影响卵黄磷脂提取率的最主要因素；在超临界CO₂萃取阶段，磷脂的溶解度随萃取温度的升高而降低，中性脂质在55℃时溶解度最大。采用此工艺，卵黄磷脂得率为17.66%，纯度94.41%，且不含胆固醇。     

超临界CO_2萃取脱皮菜籽饼粕油脂的可行性

为提高脱皮双低菜籽低温压榨饼的附加值,采用Box-Behnken响应面设计优化超临界CO2萃取脱皮双低菜籽低温压榨饼中油脂的工艺,研究萃取压力、温度和时间对油脂提取率的影响,并对萃取得到的油和粕的品质进行检测。结果表明:萃取温度对油脂提取率的影响显著(P0.05);萃取压力和时间对油脂提取率的影响极显著(P0.001),且交互作用非常显著(P0.01);最佳工艺参数为萃取温度40℃、压力28 MPa和时间120 min,此条件下菜籽油的提取率为95.08%。超临界萃取的油色泽较浅,酸价与过氧化值都优于正已烷工艺,磷脂质量分数为0.051 mg/g约是正已烷工艺的1/32,维生素E和总酚含量较高;超临界萃取的脱脂粕蛋白溶解度高,颜色较浅,硫甙含量较少,品质明显优于正已烷脱脂粕。研究结果可为脱皮双低菜籽低温压榨饼的高值化利用提供数据参考。     

超临界CO2流体萃取海滨锦葵籽油的工艺条件优化

为了提高海滨锦葵籽的利用价值,开发生物柴油新原料,该文以海滨锦葵籽为原料,利用超临界CO2流体萃取技术提取海滨锦葵籽油。通过单因素试验及正交试验研究了萃取压力、萃取温度、CO2流量和萃取时间等因素对油脂得率的影响,确定了超临界CO2流体萃取技术提取海滨锦葵籽油的最佳工艺条件。结果表明,在试验范围内各影响因素对海滨锦葵籽油得率作用的大小依次为：萃取压力＞萃取温度＞CO2流量＞萃取时间。超临界CO2流体萃取技术提取海滨锦葵籽油的最佳工艺参数为：萃取压力25 MPa,萃取温度45℃,CO2流量21 kg/h,萃取时间为100 min,在该工艺条件下萃取3次,海滨锦葵籽油得率达到19.35%。     

裸大麦中生育三烯酚的超临界CO2流体萃取工艺

采用四元二次通用旋转设计研究了裸大麦中生育三烯酚的超临界CO2流体萃取工艺.结果表明:萃取温度对生育三烯酚提取率有显著影响,乙醇添加量和萃取时间对生育三烯酚提取率有极显著影响,而萃取压力对生育三烯酚提取率无显著影响,但萃取压力和乙醇添加量的交互项对生育三烯酚提取率有显著影响;在本实验条件下,生育三烯酚最佳超临界CO2萃取条件为:萃取温度51.8℃、萃取压力34.7 MPa、乙醇添加量9%、萃取时间120 min.     

超临界CO_2萃取大蒜精油及油树脂的研究

研究了大蒜精油及油树脂的超临界 CO2 提取工艺 ,探讨了粒度 ,萃取及分离的温度、压力和时间对各萃取率的影响 ,建立了萃取温度、压力与各萃取率的数学模型。确定了超临界 CO2 同时提取大蒜精油及油树脂的优化工艺条件     

超临界CO2萃取毛竹笋油的工艺及产品成分

为优化超临界CO2萃取毛竹笋油的工艺参数,该研究通过单因素试验和正交试验考察了萃取压力、萃取温度、萃取时间和CO2流量等因素对毛竹笋油得率的影响,并利用气质联用（GC-MS）对毛竹笋油进行成分分析。研究确定超临界CO2萃取毛竹笋油的较佳工艺为：萃取压力25 MPa、萃取温度55℃、萃取时间2.5 h和CO2流量15 L/h,较佳工艺条件下笋油得率为5.74%;GC-MS分析毛竹笋油,共鉴定出17种组分,其中β-谷甾醇、9,12-十八碳二烯酸和9,12,15-十八碳三烯酸的相对含量分别为26.00%、10.50%和9.83%。     

裸大麦中生育三烯酚的超临界CO2流体萃取工艺

采用四元二次通用旋转设计研究了裸大麦中生育三烯酚的超临界CO₂流体萃取工艺。结果表明：萃取温度对生育三烯酚提取率有显著影响，乙醇添加量和萃取时间对生育三烯酚提取率有极显著影响，而萃取压力对生育三烯酚提取率无显著影响，但萃取压力和乙醇添加量的交互项对生育三烯酚提取率有显著影响；在本实验条件下，生育三烯酚最佳超临界CO₂萃取条件为：萃取温度51.8 ℃、萃取压力34.7 MPa、乙醇添加量9%、萃取时间 120 min。     

亚临界流体萃取胡麻籽低温压榨饼中油脂

为高品质提取胡麻籽低温压榨饼残油,采用D-optimum响应面设计优化亚临界丁烷萃取胡麻饼工艺,研究萃取温度、时间和液料比对油脂提取率的影响,并将所得油与粕与正已烷工艺进行品质比较。结果表明:液料比和萃取时间对油脂提取率的影响显著(P0.05);液料比与萃取温度交互作用显著(P0.05);最佳工艺参数为液料比8.4 m L/g、萃取时间40 min、萃取温度26℃,此条件下胡麻籽油的提取率为96.50%。亚临界丁烷萃取的胡麻籽油红色较浅、黄色较深,酸价与过氧化值都优于正已烷工艺,磷脂质量分数约为正已烷工艺的1/10。亚临界丁烷萃取后的胡麻籽粕,中性洗涤纤维质量分数低,蛋白中可溶性氮质量分数是正已烷工艺的3.5倍。研究结果可为胡麻籽高品质加工利用提供数据参考。     

均匀设计-BP神经网络优化超临界CO2提取杜香挥发油工艺

将均匀设计和BP神经网络运用于杜香挥发油超临界CO2流体的萃取研究中,采用均匀设计的试验样本,单因素法筛选BP神经网络提取模型的隐含层节点数、学习函数、传递函数和训练函数;采用独立样本t检验和相关性分析讨论试验值和模拟值的关系评价模型;利用建立好的模型仿真提取,分析提取工艺因素（提取时间、提取温度、提取压强、原料粒度）对提取率的影响。试验结果显示,BP网络模型平均误差为0.0116,超临界CO2萃取时间、萃取压力、原料粒度和萃取温度与挥发油提取率之间的模型拟合度良好;通过模型仿真及优化,杜香枝干最优萃取条件为375 bar、17.5℃、1.0 h、大于20目的原料,仿真得率为1.82%,验证试验的得率的平均值为1.73%;杜香叶片萃取最佳条件为275 bar、15℃、3.0 h、大于20目的原料,仿真得率为2.65%,试验验证平均值为2.66%。该方法为杜香挥发油的提取研究提供新方法。     

超临界CO2流体萃取杏仁油工艺研究

该研究以单因素试验和正交试验相结合的方法对苦杏仁脂肪油的超临界CO2萃取工艺进行了研究.确定了超临界CO2萃取杏仁油的最佳工艺为:萃取压力35 MPa、萃取温度50 ℃、CO2流量24 L/h、粒径60目、萃取时间2 h.各因素影响杏仁的得率的顺序为:粒径＞时间＞萃取压力＞CO2流量＞萃取温度.最佳工艺验证试验的杏仁油的得率为52.98%.本研究的结果为下一步综合、无毒、高效地开发利用苦杏仁奠定了基础.     

Supercritical CO2 extraction of beta-carotene from a marine strain of the cyanobacterium Synechococcus species

Dynamic extraction of carotenoids from a marine strain of Synechococcus sp. (Cyanophyceae) with supercritical CO2 (SC-CO2) was investigated with regard to operation pressure and temperature effects on extraction efficiency. Extraction yield (milligrams of pigment per gram of dry weight) for SC-CO2) was compared with the extraction yield for dimethylformamide (DMF). Carotenoids extracted with SC-CO2 were beta-carotene (Ct), zeaxanthin (Z), beta-cryptoxanthin (Cr), and equinenone; chlorophyll a was poorly extracted, whereas myxoxanthophyll, another major carotenoid, was not extracted under any experimental condition. The highest relative yield, which is defined here as y(r) = [(mg of pigment(SC-CO2)/mg of pigment(DMF))] x 100, was 76.1 +/- 8.6% for Ct, but it rose to 87.0 +/- 3.4% when 15% ethanol was used as cosolvent. The pressure effect on y(r) was found to be significant (p < 0.05) for both Cr and Z, along with total carotenoids, whereas the effect of square T (TT) was significant for only Ct. From empirical correlations, pairwise pressure (bar) and temperature (degrees C), respectively, for optimal extraction were determined to be (358, 50) for Ct, (454, 59) for Cr, and (500, 60) for Z. Cell disruption by sonication or detergent treatment of the biomass did not improve the extraction efficiency. Matrix structure together with material state could explain the low carotenoid extraction yield obtained with SC-CO2 as compared to DMF in Synechococcus sp. However, the process can be applied to selective extraction of different carotenoids.     

Supercritical CO(2) extraction of beta-carotene and lycopene from tomato paste waste

Lycopene and beta-carotene were extracted from tomato paste waste using supercritical carbon dioxide (SC-CO(2)). To optimize supercritical fluid extraction (SFE) results for the isolation of lycopene and beta-carotene, a factorial designed experiment was conducted. The factors assessed were the temperature of the extractor (35, 45, 55, and 65 degrees C), the pressure of the extraction fluid (200, 250, and 300 bar), addition of cosolvent (5, 10, and 15% ethanol), extraction time (1, 2, and 3 h), and CO(2) flow rate (2, 4, and 8 kg/h). The total amounts of lycopene and beta-carotene in the tomato paste waste, extracts, and residues were determined by HPLC. A maximum of 53.93% of lycopene was extracted by SC-CO(2) in 2 h (CO(2) flow rate = 4 kg/h) at 55 degrees C and 300 bar, with the addition of 5% ethanol as a cosolvent. Half of the initially present beta-carotene was extracted in 2 h (flow rate = 4 kg/h), at 65 degrees C and 300 bar, also with the addition of 5% ethanol.     

Effect of variety and maturation of cheese on supercritical fluid extraction efficiency

Supercritical fluid extraction (SFE) has been utilized by the food industry in many applications to extract, fractionate, and recover compounds from various food matrices. However, little research has been conducted using SFE as an alternative process for producing reduced-fat cheese. Lipids in cheeses may be selectively extracted due to the nonpolar properties of supercritical carbon dioxide (SC-CO2), without leaving residual chemicals as is the case in solvent extraction. The objective of this study was to evaluate the influence on the extraction process due to cheese variety and protein breakdown by age. A Latin square design was utilized to test the extractability of lipids from Parmesan and Cheddar cheeses, aged young (9-10 months) or old (24 months). Extraction took place in a 500 mL SFE vessel using 100 g of grated cheese samples. The SFE parameters of the extraction were 350 bar, 35 degrees C, and supercritical carbon dioxide at a flow rate of 20 g/min for 55 min. Compositional analysis measured all treated samples and controls of total lipids, lipid profiling, total protein, protein/peptide analysis, moisture, ash, and pH. Cheese type was a major variable in fat extraction. The extraction in Cheddar showed an average fat reduction of 53.56% for young cheese, whereas that in old Cheddar was 47.90%. However, young Parmesan was reduced an average of 55.07%, but old Parmesan was reduced at 68.11%, measured on a dry basis. SFE extracted triglycerides and cholesterol, but did not remove phospholipids. This investigation introduces the observations of the effect of Cheddar and Parmesan varieties on SFE, offering data on the important parameters to consider in the design of SFE processes to reduce fat in cheese.     

Impact of a treatment with phospholipase A2 on the physicochemical properties of hen egg yolk

Changes in physicochemical properties of egg yolk were investigated after a treatment with phospholipase A 2 (PLA 2), where phospholipids are converted in lyso-phospholipids. Protein solubility and protein denaturation before and after modification by PLA 2 was monitored as well as the functionality of egg yolk by means of interfacial tension. Enzymatic treatment showed a significant impact on the properties of egg yolk with regard to protein solubility and denaturation behavior. To gain a closer insight, egg yolk was separated in its water-soluble fraction called plasma and the insoluble granules. Both fractions were separately modified by PLA 2. The granule fraction shows a higher protein solubility, and the plasma proteins show very high heat stability after modification by PLA 2. Hypotheses regarding related changes in the low-density lipoprotein (LDL) particles are discussed. Results suggest that significant differences in the functional properties of untreated and PLA 2-modified egg yolk do not primarily result from the existence of lyso-phospholipids but from structural changes in egg yolk granules and LDL particles.     

Development of yellow pigmentation in squid (Loligo peali) as a result of lipid oxidation

The impact of lipid oxidation on yellow pigment formation in squid lipids and proteins was studied. When the squid microsomes were oxidized with iron and ascorbate, thiobarbituric acid reactive substance were observed to increase simultaneously with b values (yellowness) and pyrrole compounds concomitantly with a decrease in free amines. Oxidized microsomes were not able to change the solubility, sulfhydryl content, or color of salt-soluble squid myofibrillar proteins. Aldehydic lipid oxidation products were able to decrease solubility and sulfhydryl content of salt-soluble squid myofibrillar proteins but had no impact on color. Aldehydic lipid oxidation products increased b values (yellowness) and pyrrole compounds and decreased free amines in both squid phospholipid and egg yolk lecithin liposomes. The ability of aldehydic lipid oxidation products to change the physical and chemical properties of egg yolk lecithin liposomes increased with increasing level of unsaturation and when the carbon number was increased from 6 to 7. These data suggest that off-color formation in squid muscle could be due to nonenzymatic browning reactions occurring between aldehydic lipid oxidation products and the amines on phospholipids headgroups.     

Inhibitory effect of monogalactosyldiacylglycerol, extracted from spinach using supercritical CO2, on mammalian DNA polymerase activity

We investigated the effective extraction of monogalactosyldiacylglycerol (MGDG) from dried spinach (Spinacia oleracea) using supercritical fluid carbon dioxide (SC-CO(2)) with a modifier/entrainer. The yield of MGDG in the SC-CO(2) extract was not influenced by increasing temperature at a constant pressure, although the total extract yield was decreased. The total extract yield and MGDG yield in the extract from commercially purchased spinach (unknown subspecies), were greatly influenced by lower pressure. In a modifier (i.e., ethanol) concentration range of 2.5-20%, both the extract and MGDG yield increased as the ethanol concentration rose. The highest total extract yield (69.5 mg/g of spinach) and a good MGDG yield (16.3 mg/g of spinach) were obtained at 80 degrees C, 25 MPa, and 20% ethanol. The highest MGDG concentration (76.0% in the extract) was obtained at 80 degrees C, 25 MPa, and 2.5% ethanol, although the total extract yield under these conditions was low (5.2 mg/g of spinach). The optimal conditions for the extraction of MGDG were 80 degrees C, 20 MPa, and 10% ethanol. Of the 11 subspecies of spinach tested under these conditions, "Ujyou" had the highest concentration of MGDG. The total extract yield and MGDG concentration of Ujyou were 20.4 mg of the extract/g of spinach and 70.5%, respectively. The concentration of MGDG was higher in the SC-CO(2) extract than in the extract obtained using solvents such as methanol and n-hexane. The extract of Ujyou, which was the optimal subspecies for the extraction of MGDG, inhibited the activity of calf DNA polymerase alpha with IC(50) values of 145 microg/mL but was not effective against DNA polymerase beta.     

蛋黄油的提取及其氧化产物挥发性成分分析

为提高淘汰蛋鸡副产物——卵泡的利用率,本研究以鸡卵泡为试验原料,经提取卵磷脂、脱去胆固醇后,将其卵泡残渣以溶剂萃取法提取出蛋黄油,通过单因素试验和正交试验研究了提取温度、提取时间、料液比和乙醇浓度对蛋黄油提取的影响。之后将提取的蛋黄油进行氧化调控,采用气相离子迁移色谱(GC-IMS)进行测定与分析。正交试验结果表明,鸡卵泡中蛋黄油提取的最佳工艺条件:提取温度80℃,提取时间55 min,料液比1∶10,乙醇浓度95%。氧化蛋黄油中含有多种挥发性物质,包括4种醇类、3种醛类、2种酯类、2种酮类、1种呋喃,其中3-甲基丁醛是氧化蛋黄油的特征风味物质。本研究结果为开发利用蛋鸡副产物,提高产品附加值提供了新思路。     

制取淀粉用甘薯的最佳收获期及磨浆分离机的研究

通过对河北省甘薯集中产区“一窝红”和“卢选1号”两个具有代表性的甘薯品种,在不同收获时间甘薯淀粉亩产量的试验测定,确定出该区甘薯用来制取淀粉的最佳收获时间。同时,为在甘薯最佳收获时间内制取淀粉,提高甘薯淀粉的亩产量,研究设计了适合甘薯集中产区的6SF-20型薯类磨浆分离机。该机的淀粉分离率为96.4%,淀粉提取率为92.0%,达到国际先进水平     

亚麻籽双液相多级逆流萃取工艺模拟试验

为了考察双液相技术萃取亚麻籽的工业化效果,应用模拟试验探讨了多级逆流萃取工艺应用于正己烷-乙醇-水三元双液相亚麻籽萃油脱氰苷生产的可行性。结果表明,在料烷比1︰5 (m/V),料醇比1︰2 (m/V),温度55℃,时间 30 min,乙醇质量分数85% (m/m),NaOH添加量为乙醇相0.05% (m/V)的条件下,实验室串级模拟四级逆流萃取达到工艺要求,亚麻粕中残油量小于1%,氰苷残余小于0.7 mg/kg,多级逆流接触法萃取流程适宜于亚麻籽双液相萃油脱氰苷生产工艺。     

响应面法优化茉莉花茶茶多糖提取工艺

本实验以茉莉花茶为供试材料,优化茶多糖的提取工艺,旨在提高茶多糖的提取率,为茶叶深加工提供理论依据。在单因素实验的基础上,利用Box-Benhnken的中心组合设计,选定温度、水料比和沉淀茶多糖时所用的乙醇浓度3个因素分别选3水平进行中心组合实验,通过响应面分析实验,拟合出数学模型：Y=6.55＋1.30A＋0.83B＋1.10C-0.092AB＋0.11AC＋0.34BC-1.56A2-0.64B2-1.48C2。利用该函数关系来优化茶多糖提取条件,最终确定茶多糖的最佳浸提条件为：浸提温度100℃;水料比为26.8;乙醇浓度为90%。在该条件下茶多糖得量有所提高,且验证值为7.8610mg/g,比单因素最高提取率高25.6%,表明响应面法可有效用于茶多糖提取方法的优化。