Effect of grain processing and silage on microbial protein synthesis and nutrient digestibility in beef cattle fed barley-based diets

Effects of the extent of grain processing and the percentage of silage in barley-based feedlot diets on microbial protein synthesis and nutrient digestibility were evaluated using four steers (initial BW of 442 +/- 15 kg) with ruminal and duodenal cannulas. The experiment was a 4 x 4 Latin square with four periods of 21 d each. Dietary treatments were arranged as a 2 x 2 factorial with two levels of barley silage (20 and 5% DM basis) and two degrees of barley grain processing (coarsely and flatly steamrolled to a processing index [PI] of 86 and 61%, respectively). The PI was quantified as the volume weight of the barley grain after processing, expressed as a percentage of the volume weight prior to processing. Digest a flow (Yb) and microbial (15N) markers were continuously infused into the rumen for a period of 13 d. Ruminal, duodenal, and fecal samples were collected at various times over the last 6 d of marker infusion. Diurnal ruminal pH was measured for 48 h. Intake of DM averaged 1.8% of BW, and was not different among the dietary treatments (P > 0.10). Ruminal starch digestibility was higher (P < 0.05) for the more extensively processed grain and tended (P < 0.10) to be highest when the more extensively processed grain was combined with 5% barley silage. In contrast, ruminal fiber digestibility for the 5% silage diets was reduced (P < 0.05) when the grain was more extensively processed. There was, however, no effect of grain processing on ruminal OM digestibility (P > 0.10), and hence, no inhibitory effect on microbial N flow to the intestine (P > 0.10). There was also no effect of the level of silage on microbial N flow (P > 0.10), but there was a tendency for improved efficiency of microbial protein synthesis for the 20% silage diets (P = 0.072). Ruminal escape of nonmicrobial N (P = 0.003) was greater, and thus, protein flow to the intestine was greater for the 5% silage diets. Diurnal ruminal pH was lower (P < 0.05) for 11 of the 24 hourly time points in steers fed the 5% silage diets than those fed the 20% silage diets. In conclusion, barley grain rolled to a PI of 86 to 61% and combined with 20 and 5% barley silage had little effect on microbial protein supply. Microbial protein supply was not inhibited when the barley grain was extensively processed (PI of 61%) and the silage was limited to only 5% of the diet DM, but feed intake of steers in this study was lower than would be expected in the feedlot.     

Effects of dietary nonprotein nitrogen on performance, digestibility, ruminal characteristics, and microbial efficiency in crossbred steers

Two trials were conducted to evaluate the effects of dietary NPN levels on animal performance, diet digestibility, ruminal characteristics, and microbial efficiency. Experiment 1 was conducted with 24 Holstein x Nellore crossbred steers (350 +/- 20 kg of BW) distributed in 6 blocks to evaluate intake and digestibility of nutrients and performance. The diets consisted of 70% corn silage and 30% concentrate (DM basis) and were formulated to contain 12.5% CP (DM basis). Treatments consisted of 0, 15.5, 31, and 46.5% of dietary N as NPN. There were no treatment differences in the daily intakes of DM (P = 0.47), OM (P = 0.60), CP (P = 0.24), nonfiber carbohydrates (NFC; P = 0.74), or TDN (P = 0.63); however, NDF intake decreased linearly as NPN increased (P = 0.02). Additionally, no effects of NPN were observed on apparent total tract digestibility of DM (P = 0.50), OM (P = 0.53), NDF (P = 0.63), or NFC (P = 0.44). The apparent total tract digestibility of CP increased linearly (P = 0.01), but ADG (1.14 kg/d) was not influenced (P = 0.96) as NPN increased. In Exp. 2, 4 ruminally and abomasally cannulated steers (300 +/- 55 kg of BW) were fed the same diet used in Exp. 1 to evaluate the effects of NPN levels on intake and digestibility of nutrients, ruminal characteristics, and microbial efficiency. There were no differences in the daily intakes of DM (P = 0.22), OM (P = 0.17), CP (P = 0.31), NDF (P = 0.29), or TDN (P = 0.49). However, NFC intake increased linearly (P = 0.02), and there was a quadratic effect (P = 0.01) on intake of ether extract as NPN increased. Ruminal digestibility of CP increased linearly (P = 0.01) with the increase of dietary NPN. There were no differences (P >or= 0.28) in microbial protein synthesis and microbial efficiency among the treatments. The results of these trials suggest that dietary NPN levels (up to 46.5% of total N) can be fed to crossbred steers receiving corn silage-based diets without affecting their growth performance or ruminal protein synthesis.     

Effect of replacing corn with brown rice grain in a total mixed ration silage on milk production,ruminal fermentation and nitrogen balance in lactating dairy cows

Nine multiparous Holstein cows were used in a replicated 3 × 3 Latin square design to determine the effects of substituting corn grain with brown rice (BR) grain in total mixed ration (TMR) silage on milk yield, ruminal fermentation and nitrogen (N) balance. The TMR silages were made from the ensiling of TMR containing (dry matter basis) 50.1% forage in rice silage and corn silage combination, and 49.9% concentrate. The grain portion of the diets contained 31.2% steam‐flaked corn, 31.2% steam‐flaked BR or an equal mixture of corn and BR. Dietary treatments did not affect dry matter intake, milk yield and milk fat, protein and lactose yields. The ruminal pH and total volatile fatty acid concentrations were not affected by dietary treatment. The urinary N excretion decreased linearly (P < 0.01) in response to increased levels of BR, with no dietary effect on N intake, N secretion in milk and fecal N excretion. Our results indicate that steam‐flaked BR is a suitable replacement for steam‐flaked corn in dairy cow diets, and that it can be included in rations to a level of at least 31.2% of dry matter without adverse effects on milk production, when cows were fed rice silage and corn silage‐based diets.     

Effects of protein concentration and source on nutrient digestibility by mature steers limit-fed high-concentrate diets.

Five ruminally fistulated 3-yr-old mature Holstein steers (average BW 691+/-23 kg) were used in a 5 x 5 Latin square experiment with a 2 x 2 + 1 fact orial arrangement of treatments. Effects of protein concentration and protein source on nutrient digestibility, excretion of DM and fecal N, ruminal fluid volume and dilution rate, ruminal characteristics, and in situ DM disappearance of whole shelled corn, ground corn, and orchardgrass hay were measured in steers limit-fed high-concentrate diets at 1.5% of BW. A negative control basal diet (NC; 9% CP) was supplemented to achieve either 11 or 14% CP; supplemental CP was either from soybean meal (11 and 14% SBM) or a 50:50 ratio of CP from urea and soybean meal (11 and 14% U). Dry matter and OM digestibilities were 5% greater (P < .07) for steers fed the SBM diets than for those fed the U diets. Starch digestibility did not differ (P > .10) among steers fed any of the diets. Nitrogen source did not affect (P > .10) apparent N digestibility or fecal N excretion; however, steers fed the NC diet had the lowest (P < .10) apparent N digestibility compared with those fed all other diets. Ruminal fluid volume was lower (P < .06) when steers were fed the NC diet compared with all other diets; there were no differences (P > .74) among diets for ruminal fluid dilution rate. In general, ruminal ammonia N and VFA molar proportions were not affected by protein source or concentration. Although CP concentration affected (P < .06) in situ DM disappearance of ground corn, CP concentration did not (P > .48) affect total tract digestion of DM or OM. This indicates that CP concentration may have affected site of digestion, but not extent of digestion. When mature ruminants were limit-fed a corn-based diet to meet primarily a maintenance function, protein source and concentration had little effect on measures of nutrient digestion.     

Impact of corn vitreousness and processing on site and extent of digestion by feedlot cattle

Eight cannulated Holstein steers (average BW: 251 kg) were used in 2 simultaneous 4 x 4 Latin squares in a split-plot arrangement to test the effects of processing method [dry-rolled (DR) vs. steam-flaked (SF); main plot] and vitreousness (V, %; subplot) of yellow dent corn (V55, V61, V63, and V65) on site of digestion of diets containing 73.2% corn grain. No vitreousness x processing method interactions were detected for ruminal digestion, but ruminal starch digestion was 14.4% lower (P < 0.01) for DR than for SF corn. Interactions were detected between vitreousness and processing method for postruminal (P < 0.10) and total tract digestion (P < 0.05). With DR, vitreousness tended to decrease (linear effect, P < 0.10) postruminal OM and starch digestion. With SF, vitreousness did not affect (P > or = 0.15) postruminal digestion of OM and starch. Postruminal N digestion tended to decrease (linear effect, P = 0.12) as vitreousness increased. Postruminal digestion was greater for SF than for DR corn OM (25.7%, P < 0.05), starch (94.3%, P < 0.10), and N (10.7%, P < 0.01). Steam flaking increased total tract digestion of OM (11%, P < 0.05), starch (16%, P < 0.01), and N (8.4%, P < 0.05) but decreased total tract ADF digestion (26.7%, P < 0.01). With DR, total tract starch digestion was lower for V65 (cubic effect, P < 0.10) than for the other hybrids. With SF, total tract starch digestion was not affected (P > or = 0.15) by vitreousness. Fecal starch and total tract starch digestion were inversely related (starch digestion, % = 101 - 0.65 x fecal starch, %; r2 = 0.94, P < 0.01). Ruminal pH was greater for steers fed DR than for steers fed SF corn (6.03 vs. 5.62, P < 0.05). Steam flaking decreased (P < 0.01) the ruminal molar proportion of acetate (24%), acetate:propionate molar ratio (55%), estimated methane production (37.5%), and butyrate (11.3%, P < 0.05). There was a vitreousness x processing interaction (P < 0.01) for acetate:propionate. For DR, acetate:propionate tended to increase (linear effect; P < 0.10) with increasing vitreousness. With SF, acetate:propionate was greater (cubic effect, P < 0.01) for V65. Starch from more vitreous corn grain was less digested when corn grain was DR, but this adverse effect of vitreousness on digestion was negated when the corn grain was SF. Of the 19% advantage in energetic efficiency associated with flaked over rolled corn grain, about 3/4 can be attributed to increased OM digestibility, with the remaining 1/4 ascribed to reduced methane loss.     

Effects of rumen-protected methionine and lysine on ruminant performance and nutrient metabolism

Four trials were conducted to determine the effects of supplemental rumen-protected methionine (RPMet) and lysine (RPLys) on lamb N metabolism and steer feedlot performance. In trial 1, 20 Suffolk-sired, crossbred lambs (avg weight 32 kg) were fed diets containing no supplemental methionine (Met) and lysine (Lys), .03% RPMet, .05% RPLys or .03% RPMet + .05% RPLys. Lambs fed .03% RPMet + .05% RPLys had a 33% increase in N retention compared with lambs fed no supplemental Met and Lys. In trial 2, to verify the protection and availability of these amino acids, five Targhee lambs (avg weight 35 kg) were fed corn-soybran flake diets supplemented with urea and were assigned in a 5 X 5 Latin square to one of the following treatments: 1) control; 2) .03% RPMet + .05% RPLys offered in the diet; 3) .03% RPMet + .05% RPLys abomassally infused; 4) .03% non-protected Met + .05% non-protected Lys offered in the diet and 5) .03% Met + .05% Lys abomasally infused. Treatments 2, 3 and 5 decreased (P less than .05) urinary N (g/d) and increased N retention (P less than .05) compared with the control diet (treatment 1). Increases (P less than .05) in plasma Met and Lys concentrations indicated that the amino acids were protected and available for animals at the site of absorption. In trial 3, 40 crossbred Angus steers (avg weight 247 kg) were fed diets composed of 53% corn silage and 47% concentrate and supplemented with soybean meal to 11.3% crude protein. Steers that were fed diets containing .19% RPMet + .11% RPLys had greater daily gain (P less than .05) than those fed diets containing no supplemental amino acids, .11% RPMet + .01% RPLys, and .15% RPMet + .06% RPLys (1.39 vs 1.23, 1.22 and 1.20 kg/d, respectively). Similar improvements in feed conversion resulted and increases in plasma Met concentrations followed the same trend. In trial 4, 40 crossbred Angus steers (avg weight 368 kg) were fed corn grain-corn silage diets supplemented with urea. Treatments were: no supplemental amino acids; .05% RPMet + .01% RPLys; .10% RPMet + .04% RPLys; and .15% RPMet + .07% RPLys. No differences in steer performance resulted due to supplemental RPMet and RPLys (P greater than .05). The results of these trials suggest that the RPMet and RPLys used in this study are protected from ruminal degradation, are available post-ruminally and can improve lamb N balance and growing steer performance.     

Effects of Roughage Type and Restricted Feed Intake on Digestibility and Finishing Cattle Performance

Two-hundred sixty-four English-type crossbred cattle (mean initial BW 282 ± 6 kg) were used in a completely randomized design to evaluate the effects of restricted feeding and roughage source in finishing beef cattle diets. Treatments consisted of diets with 7.5% corn silage (DM basis), fed either ad libitum or restricted, and 7.5% (DM basis) corn stalks or millet hay fed ad libitum. Total DM intake was reduced by 4, 11, and 9% by restricting corn silage, corn stalks, and millet hay treatments, respectively. Average daily gain was not affected (P>0.05) by treatment, whereas feed efficiency was improved (P<0.05) for all treatments compared with corn silage diets fed ad libitum. Total feed cost of gain was highest (P<0.05) for the corn silage treatment fed ad libitum. Hot carcass weight, quality grade, and yield grade were not affected by treatment, and cattle fed restricted corn silage had a lower (P<0.05) dressing percentage. Fecal analysis of Cr concentrations indicated no difference (P>0.05) in OM, DM, or N digestibilities. However, restricted corn silage-fed cattle and cattle fed millet hay ad libitum tended to exhibit increased (P>0.05) OM, DM, and N digestibilities compared with the cattle fed corn silage ad libitum. The cattle fed corn stalks ad libitum tended to have decreased (P>0.05) OM, DM, and N digestibilities compared with the steers fed corn silage ad libitum. Fecal output was not different (P>0.05) between treatments. Restricted corn silage rations, corn stalk rations fed ad libitum, and millet hay rations fed ad libitum tended to decrease (P>0.05) fecal output by cattle compared with cattle fed the corn silage ration ad libitum.     

Effects of dietary energy level and protein source on site of digestion and duodenal nitrogen and amino acid flows in steers

Six steers (468 kg) with ruminal and duodenal cannulas were fed diets formulated for two levels of energy containing three crude protein (CP) sources in a 6 X 6 Latin square with a 2 X 3 factorial arrangement of treatments. Energy levels were 2.17 and 2.71 Mcal metabolizable energy (ME)/kg dry matter (DM) provided by hay-corn (H) and corn silage-corn (CS) diets, respectively. Soybean mean (SBM), corn gluten meal-urea (CGM) and urea (U) provided 33% of dietary CP in 12% CP diets. Apparent organic matter (OM) digested in the stomach was not affected (P greater than .05) by energy level or CP source, but OM truly digested in the stomach was greater (P less than .05) when steers were fed the CS compared with the H diet. Duodenal flow of non-NH3 N was greater (P less than .05) when steers were fed CS compared with H and when fed SBM or CGM compared with U. Efficiency of bacterial protein synthesis and duodenal bacterial N flow were increased (P less than .05) when steers were fed CS, but non-NH3, nonbacterial N flow to the duodenum was increased (P less than .05) when steers were fed H. When steers were fed CS rather than H, flows (g/d) of bacterial amino acids were greater (P less than .05), but flows of nonbacterial amino acids tended (P less than .08) to be less. Total amino acid flows were not affected (P greater than .05) by energy level. Duodenal flows of total amino acids tended (P less than .06) to be greater when steers were fed CGM compared with SBM or U, due mainly to an increased (P less than .05) flow of nonessential amino acids.     

Effects of distillers grains with high sulfur concentration on ruminal fermentation and digestibility of finishing diets

Twelve ruminally cannulated crossbred Angus steers were used to evaluate ruminal fermentation characteristics and diet digestibility when 30% (DM) corn dried distillers grains with solubles (DDGS) containing 0.42 or 0.65% (DM) of dietary S was incorporated into finishing diets based on steam-flaked corn (SFC) or dry-rolled corn (DRC). The study was a replicated, balanced randomized incomplete block design with a 2 × 2 factorial arrangement of treatments. Factors consisted of dietary S concentration (0.42 and 0.65% of DM; 0.42S and 0.65S, respectively) and grain processing method (SFC or DRC). The 0.65S concentration was achieved by adding H(2)SO(4) to DDGS before mixing rations. Steers were assigned randomly to diets and individual, slatted-floor pens, and fed once daily for ad libitum intake. Two 15-d experimental periods were used, each consisting of a 12-d diet adaptation phase and a 3-d sample collection phase. Samples were collected at 2-h intervals postfeeding during the collection phase. Ruminal pH was measured immediately after sampling, and concentrations of ruminal ammonia and VFA were determined. Fecal samples were composited by steer within period and used to determine apparent total tract digestibilities of DM, OM, NDF, CP, starch, and ether extract. Feeding 0.65S tended (P = 0.08) to decrease DMI but resulted in greater apparent total tract digestibilities of DM (P = 0.04) and ether extract (P = 0.03). Ruminal pH increased (P < 0.05) in steers fed 0.65S diets, which may be attributable, in part, to decreased (P = 0.05) VFA concentrations and greater (P < 0.01) ruminal ammonia concentrations when 0.65S was fed, compared with feeding 0.42S. These effects were more exaggerated in steers fed DRC (interaction, P < 0.01), compared with steers fed SFC. Steers fed DRC-0.65S had greater (P < 0.01) acetate concentration than steers fed DRC-0.42S, but acetate concentration was not affected by S concentration when SFC was fed. Propionate concentration was decreased (P < 0.01) in steers fed SFC-0.65S compared with steers fed SFC-0.42S, but dietary S concentration had no effect on propionate concentration when DRC was fed. Butyrate concentration was less (P < 0.01) in steers fed 0.65S diets than in steers fed 0.42S. Lactate concentrations tended (P = 0.06) to decrease in steers fed 0.65S diets. Feeding DDGS with increased S concentration may decrease feed intake and ruminal VFA concentration but increase ruminal ammonia concentration.     

Comparative feeding value of steam-flaked corn and sorghum in finishing diets supplemented with or without sodium bicarbonate.

A feedlot growth-performance trial involving 64 yearling steers and a metabolism trial involving four steers with cannulas in the rumen, proximal duodenum, and distal ileum were conducted to evaluate the comparative feeding value of steam-flaked corn (SFC, density = .30 kg/liter) and sorghum (SFS, density = .36 kg/liter) in finishing diets supplemented with or without .75% sodium bicarbonate (BICARB). No interactions between BICARB and grain type proved to be significant. Supplemental BICARB increased ADG 5.9% (P less than .10) and DMI 4.6% (P less than .05) but did not influence (P greater than .10) the NE value of the diet. Supplemental BICARB increased ruminal pH (P less than .01) and total tract fiber digestion (P less than .05). Differences in ruminal and total tract OM, starch, and N digestion were small (P greater than .10). Replacing SFC with SFS decreased (P less than .05) ADG 6.1% and increased (P less than .01) DMI/gain 9.7%. Corresponding diet NEm and NEg were decreased (P less than .01) 7.0 and 9.3%, respectively. Ruminal digestion of OM and starch tended to be lower (11.8 and 7.2%, respectively, P less than .10) for SFS. Ruminal degradation of feed N was 31% lower (P less than .05) for the SFS diets. Total tract digestibility of OM, N, DE, and ME were 3.3, 10.8, 4.4, and 5.5% lower (P less than .05), respectively, for the SFS vs SFC diets. In conclusion, 1) SFS had 92% the NEm of SFC; 2) differences in total tract starch digestibility were small and cannot explain the higher feeding value of SFC; 3) the low ruminal degradation of sorghum N (roughly 20%) should be considered in diet formulation to avoid a deficit in ruminally available N; and 4) .75% BICARB supplementation increased DMI and ADG of cattle fed highly processed grain-based diets.     

Supplemental corn grain for steers grazing native rangeland during summer

Effects of supplemental corn grain on forage OM intake (FOMI), digesta kinetics, ruminal fermentation patterns, in vitro OM digestibility (IVOMD), and in situ OM digestion were examined in steers grazing summer blue grama rangeland in northeastern New Mexico during July and August 1988. Sixteen ruminally cannulated steers (average BW 507 kg) were allotted to four treatments and individually fed whole-shelled corn at 0, .2, .4, and .6% of BW in a complete random design with repeated measurements over time. Forage OMI decreased linearly (P = .02) with increasing levels of supplemental corn; however, a tendency toward greater FOMI, as well as faster particulate and fluid passage, was observed when corn was fed at .2% of BW compared with 0, .4, or .6% of BW. Molar proportions of butyrate increased (P less than .10) but molar proportions of acetate and propionate, ruminal pH, and total VFA concentration did not change (P greater than .10) with added corn. Added corn linearly decreased (P less than .10) ruminal ammonia N concentrations in July, but patterns were inconsistent in August. A cubic response (P less than .05) for in situ OM disappearance with added corn was noted after 24, 72, and 96 h of incubation. Supplemental whole corn fed at .2% of BW had no detrimental effects and tended to increase FOMI. However, supplemental corn fed at .4 or .6% of BW decreased FOMI compared with 0 or .2% of BW.     

Influence of dietary protein and carbohydrate sources on nitrogen metabolism and carbohydrate fermentation by ruminal microbes in continuous culture

Four diets containing 15% CP were formulated to study the effects of dietary carbohydrate and protein sources on N metabolism and carbohydrate fermentation by ruminal bacteria. Diets were supplied to eight dual-flow continuous culture fermenters during three experimental periods in a randomized complete block design. Six replications were obtained for each diet. Treatments were arranged as a 2 X 2 factorial with two carbohydrate and two protein sources. Carbohydrate sources were corn and barley and protein sources were soybean meal (SBM) and fish meal (FM). Approximately 40% of the dietary CP was derived from SBM or FM and corn or barley provided 39% of dietary DM. All diets contained 15% grass hay, 20% wheat straw, and 10.1 to 15.3% solka floc (DM basis). Interactions (P less than .05) were observed between dietary carbohydrate and protein sources, resulting in a depression of VFA production (moles/day) and digestion (percentage) of ADF and cellulose when the corn-FM diet was fed. True OM digestion (percentage) was higher (P less than .05) for SBM than for FM diets and for corn than for barley diets. Although dietary CP degradation (percentage) was higher (P less than .05) for SBM than for FM diets, non-NH3 N in the effluent (grams/day) was not different among diets due to a greater (P less than .05) bacterial N flow for SBM than for FM diets. Despite the lower amino acid (AA) intake (P less than .05) for corn than for barley diets and also for FM than for SBM diets, flows (grams/day) of total AA, essential AA (EAA), and nonessential AA (NEAA) were similar (P greater than .05) among diets. However, greater (P less than .05) total AA, EAA, and NEAA flows (percentage of AA intake) were found for corn than for barley diets and for FM than for SBM diets. It is concluded, therefore, that ruminal escape protein derived from corn or FM has a significant effect on manipulating AA leaving the ruminal fermentation.     

Utilization of Bt corn residues by grazing beef steers and Bt corn silage and grain by growing beef cattle and lactating dairy cows

Three experiments were conducted to evaluate the impact of the Bacillus thuringiensis (Bt)-11 transformation event in two parental corn hybrids differing in date of maturity on beef and dairy cattle performance. Sixteen lactating Holstein dairy cows in replicated 4 x 4 Latin squares were assigned to four diets in a 2 x 2 factorial arrangement: Bt vs non-Bt trait and early- vs late-maturing corn hybrids. The diets contained 40% of the test corn silage plus 28% corn grain from the same corn hybrid (DM basis). There was no effect of the Bt trait on efficiency of milk production, ruminal pH, acetate:propionate ratio, or in situ digestion kinetics of NDF. The early-maturing corn hybrids resulted in greater total VFA concentrations in the rumen and efficiency of 4% fat-corrected milk production than the later-maturing hybrids (P < 0.05). Sixty-seven steer calves were used in a 70-d corn residue grazing trial for the late-maturing corn hybrids only. Daily BW gain of steers was similar for those grazing Bt and non-Bt corn residues, and the steers exhibited no grazing preference between Bt and non-Bt corn residue. One hundred twenty-eight steer calves were assigned to four silage-based growing diets in a 2 x 2 factorial arrangement: Bt vs non-Bt trait and early- vs late-maturing corn hybrids. The diets contained 90% corn silage and 10% supplement (DM basis). The DMI was higher for steers fed Bt compared with non-Bt hybrids (P < 0.02). An interaction (P < 0.03) was observed for feed efficiency between hybrid genotype and incorporation of the Bt trait. Feed efficiency was greater (P < 0.05) for steers fed the later-maturing non-Bt hybrid compared with the later-maturing Bt hybrid; however, feed efficiency was similar between steers fed early-maturing Bt and non-Bt corn silages. Steers fed the early-maturing hybrid gained 11% faster and were 7% more efficient compared with those fed the late-maturing hybrid. These latter results agree with the dairy experiment in which the early-maturing hybrid resulted in 5% greater efficiency of milk production than the later-maturing corn hybrid. In all experiments, incorporation of the Bt trait into corn had no consistent effect on cattle performance. In addition, background genetics of the corn hybrids appeared to have a more consistent impact on performance than did presence of the Bt trait.     

Fermentation substrate and dilution rate interact to affect microbial growth and efficiency

The effect of dilution rate (D) on carbohydrate, fibrous and nonfibrous, and protein fermentation by ruminal microorganisms was studied using a single-effluent continuous-culture system. The diets of fibrous carbohydrate, nonfibrous carbohydrate, or protein were formulated with soybean hulls (FC), ground corn (NFC), or isolated soy protein (PR) as the primary ingredient, respectively. Six dilution rates (.025, .050, .075, .10, .15, and .20/h of fermenter volume) were used. Digestibilities of DM, OM, and CP for the three diets and of NDF and ADF for the FC diet decreased (P<.001) as D increased, although the response of the digestibility to D varied with diet. Increasing D resulted in an increase in pH (P<.001) and a decrease (P<.001) in ammonia concentration. Daily volatile fatty acid production increased (quadratic; P<.01) for the FC and NFC diets, but decreased (quadratic; P<.001) for the PR diet. Increasing D quadratically increased (P<.001) the molar percentage of acetate and propionate, but quadratically decreased (P<.001) butyrate and valerate for the FC and NFC diets. For the PR diet, the molar percentage of propionate and valerate increased (quadratic; P<.01), whereas acetate and butyrate decreased (linear; P<.001) in response to increasing D. Molar percentage of isobutyrate and isovalerate decreased (P<.01) with increasing D for all three diets. As D increased, daily microbial N production showed quadratic responses with maximum values achieved at .126, .143, and .187/h D for the FC, NFC, and PR diet, respectively. There was a positive correlation between microbial growth efficiency (MOEFF) and D. A quadratic model fit the data of MOEFF as affected by D, and maximum MOEFF of 37.3, 59.6, and 71.4 g of bacterial N/kg OM truly fermented were calculated to be achieved at .177, .314, and .207/h D for the FC, NFC, and PR diet, respectively. Dilution rate significantly influenced the ruminal microbial fermentation of fibrous and nonfibrous carbohydrates and proteins, and was positively related to microbial yield and growth efficiency. In addition, microbial nitrogen composition, and therefore efficiency, was affected by substrate fermented.     

Effects of dietary energy level and supplemental protein source on performance of growing steers and nutrient digestibility and nitrogen balance in lambs

Four experiments were conducted to evaluate three crude protein (CP) sources (urea, U; soybean meal, SBM; corn gluten meal, CGM) in diets based on corn silage (high energy) or grass hay (low energy). In Exp. 1 and 2, growing steers were fed all combinations of energy and protein source at 10.5 or 12% CP. Steers fed high energy diets or 12% CP had improved (P less than .05) daily gains and feed:gain over 84 d. Protein source had no effect (P greater than .05) on performance except that steers fed U consumed more (P less than .05) feed than those fed CGM. Steers were fed experimental diets to a common weight and switched to an 85% concentrate diet for finishing. During finishing, steers fed low energy diets in the growing period consumed more (P less than .05) feed and had increased (P less than .05) feed:gain compared with those fed high energy diets. Growing lambs were fed the same diets as steers. At 10.5% CP, lambs fed high energy diets had higher (P less than .05) digestibilities of dry matter (DM), organic matter (OM), nitrogen (N) and fiber components, and retained more (P less than .05) N. For lambs on 12% CP, high energy diets had higher (P less than .05) DM and OM digestibilities and lower (P less than .05) N digestibilities. At 12% CP, energy level had no effect (P greater than .05) on N retained. Protein source had no effect (P greater than .05) on N retention. There appeared to be no advantage in supplementing with ruminally undegradable proteins, i.e. CGM, in these experiments.     

Neutral detergent fiber concentration of corn silage and rumen inert bulk influences dry matter intake and ruminal digesta kinetics of growing steers

Corn silage with high NDF concentration has the potential to reduce DMI because it has a greater filling effect in the rumen than low-NDF corn silage. Our objective was to determine whether ruminal fill influences DMI to the same extent with low- or high-NDF corn silage-based diets. Eight ruminally cannulated Holstein steers (198 +/- 13 kg) were randomly assigned to a 2 x 2 factorial arrangement of treatments in a replicated 4 x 4 Latin square design with 16-d periods. Treatments were diets containing corn silage from a normal hybrid (low-fiber; LF) or its male-sterile isogenic counterpart (high-fiber; HF), offered for ad libitum consumption to steers with or without rumen inert bulk (RIB). The LF and HF diets contained 33.8 and 50.8% dietary NDF, respectively. Rumen inert bulk was added at 25% of pretrial ruminal volume in the form of plastic-coated tennis balls filled with sand to achieve a specific gravity of 1.1 and a total volume of 7.5 L. No fiber level x inert bulk interactions were detected for DMI or NDF intake (P > 0.10), suggesting that DMI was limited to the same extent by physical fill at both levels of dietary fiber. Addition of RIB decreased DMI by an average of 10.7%, which was 65.5 g/L of added bulk. The HF diet depressed DMI by an average of 15.5%, increased NDF intake 27.1%, and reduced ruminal NDF turnover time by 21.0% compared to the LF diet (P < 0.01), with no effect on ruminal volume or amount of NDF in the rumen (P > 0.10). Addition of RIB also reduced ruminal NDF turnover time and amount of NDF in the rumen (11.8% and 20.7%, respectively; P < 0.01), with no change in ruminal digesta volume (P > 0.10). The HF treatment decreased digestibility of DM and GE (5.5 and 5.7%, respectively; P < 0.01) but increased NDF digestibility (10.4%; P < 0.01) compared to LF. Rumen inert bulk had no effect on digestibility of DM, NDF, or GE (P > 0.10). The lack of reduction in digesta volume with addition of inert fill suggests that DMI of light-weight steers receiving corn silage-based diets within a wide range of NDF concentrations was not regulated by ruminal distension alone.     

Evaluation of soybean meal, corn gluten meal, blood meal and fish meal as sources of nitrogen and amino acids disappearing from the small intestine of steers

The value of soybean meal (SBM), corn gluten meal (CGM), blood meal (BM) and fish meal (FM) in supplying N and amino acids (AA) escaping ruminal microbial degradation and disappearing from the small intestine (SI) was studied in steers using a regression approach. Replacement of corn starch in diets with protein sources resulted in decreases (P less than .05) in efficiency of microbial protein synthesis. Ruminal ammonia-N (NH3-N) had the greatest increase (P less than .05) when SBM was fed; BM supplementation resulted in only nonsignificant increases in ruminal NH3-N (P greater than .05). Soybean meal had the lowest proportion of N escaping ruminal degradation (.21). Corn gluten meal-N (.86) and BM-N (.92) escaped ruminal degradation to the greatest extent, and FM-N was intermediate (.68). Protein sources followed similar trends in providing absorbable nonbacterial N to the SI. Thirteen (+/- 6.2) percent of SBM-N was absorbed from the SI; 69 (+/- 6.2), 68 (+/- 9.1) and 50 (+/- 10.1)% of CGM-N, BM-N and FM-N, respectively, were absorbed from the SI. Values for ruminal escape and SI availability for individual and total AA are presented. Of the essential AA (EAA), threonine, valine and isoleucine were more resistant to ruminal degradation; methionine, cysteine, histidine and arginine were more extensively degraded than the total AA supply. Of the EAA escaping ruminal degradation, cysteine, histidine and threonine tended to be less digestible, whereas arginine was more digestible in the SI than the total AA supply.     

Effects of concentrated separator by-product (desugared molasses) on intake, site of digestion, microbial efficiency, and nitrogen balance in ruminants fed forage-based diets

In Exp. 1, 4 ruminally and duodenally cannulated beef steers (444.0 +/- 9.8 kg) were used in a 4 x 4 Latin square with a 2 x 2 factorial treatment arrangement to evaluate the effects of forage type (alfalfa or corn stover) and concentrated separator byproduct (CSB) supplementation (0 or 10% of dietary DM) on intake, site of digestion, and microbial efficiency. In Exp. 2, 5 wethers (44 +/- 1.5 kg) were used in a 5 x 5 Latin square to evaluate the effects of CSB on intake, digestion, and N balance. Treatments were 0, 10, and 20% CSB (DM basis) mixed with forage; 10% CSB offered separately from the forage; and a urea control, in which urea was added to the forage at equal N compared with the 10% CSB treatment. In Exp. 1, intakes of OM and N (g/kg of BW) were greater (P < 0.01) for steers fed alfalfa compared with corn stover. Steers fed 10% CSB had greater (P < 0.08) OM and N intakes (g/kg of BW) compared with 0% CSB-fed steers. Total duodenal, microbial, and nonmicrobial flows of OM and N were greater (P < 0.01) for steers fed alfalfa compared with corn stover. Steers fed 10% CSB had increased (P = 0.02) duodenal microbial flow (N and OM) compared with 0% CSB-fed steers. Forage x CSB interactions (P < 0.01) existed for total tract N digestibility; alfalfa with or without CSB was similar (67.4 vs. 69.5), whereas corn stover with CSB was greater than corn stover without CSB (31.9 vs. -23.9%). True ruminal OM digestion was greater (P < 0.09) in steers fed alfalfa vs. corn stover (73.0 vs. 63.1%) and in steers fed 10 vs. 0% CSB (70.3 vs. 65.8%). Microbial efficiency was unaffected (P > 0.25) by forage type or CSB supplementation. In Exp. 2, forage and total intake increased (linear; P < 0.01) as CSB increased and were greater (P < 0.04) in 10% CSB mixed with forage compared with 10% CSB fed separately. Feeding 10% CSB separately resulted in similar DM and OM apparent total tract digestibility compared with 10% CSB fed mixed. Increasing CSB led to an increase (linear; P < 0.02) in DM, OM, apparent N digestion, and water intake. Nitrogen balance (g and percentage of N intake) increased (linear; P < 0.08) with CSB addition. Feeding 10% CSB separately resulted in greater (P < 0.01) N balance compared with 10% CSB fed mixed. Using urea resulted in similar (P = 0.30) N balance compared with 10% CSB fed mixed. Inclusion of CSB improves intake, digestion, and increases microbial N production in ruminants fed forage-based diets.     

Effects of whole cottonseed and live yeast culture on ruminal fermentation and fluid passage rate in steers

The effects of adding whole cottonseed (WCS) and live yeast culture (YC) to a diet of 60% alfalfa and 40% concentrate on ruminal fermentation and liquid dilution rate in steers were examined in two trials. Twelve ruminally cannulated Hereford steers (approximately 420 kg) were used. Concentrates were 1) a basal grain mix composed of ground corn, ground barley and rice bran, 2) basal mix with 10% WCS, 3) basal mix with 1.6% YC and 4) basal mix with 10% WCS and 1.6% YC. No differences were detected (P greater than .10) in ruminal pH of steers fed WCS or YC in either trial. Ruminal ammonia levels tended to be higher (P greater than .10) in steers fed WCS. Acetate was higher and butyrate was lower in steers receiving 10% WCS (P less than .10) compared with controls. Molar proportions of acetate and butyrate increased while propionate decreased (P less than .05) over time after feeding. Intake and apparent digestibility of dry matter was not influenced by treatments. Whole cottonseed and(or) YC appear to have minimal effects on ruminal fermentation, but they might alter ruminal liquid passage rate with diets containing 60% ground alfalfa and 40% concentrate.     

Effect of cattle age, forage level, and corn processing on diet digestibility and feedlot performance

Three experiments were conducted to determine the effects of cattle age and dietary forage level on the utilization of corn fed whole or ground to feedlot cattle. In Exp. 1, 16 steers were used to investigate the effects of cattle age and corn processing on diet digestibility. Two cattle age categories were evaluated (weanling [254 +/- 20 kg BW] and yearling [477 +/- 29 kg BW]; eight steers per group), and corn was fed either ground or whole to each cattle age category. Cattle age and corn processing did not affect (P > 0.10) diet digestibility of DM, OM, starch, CP, NDF or ADF, and no interactions (P > 0.10) between these two factors were detected. In Exp. 2, the effects of forage level and corn processing on feedlot performance and carcass characteristics were evaluated. One hundred eighty steers (310 +/- 40 kg BW) were allotted to 24 pens, and were fed one of the following diets: high-forage (18.2% corn silage) cracked corn (HFCC); high-forage shifting corn (whole corn for the first half of the trial, then cracked corn until harvest; HFSC); high-forage whole corn (HFWC); low-forage (5.2% corn silage) cracked corn (LFCC); low-forage shifting corn (LFSC); and low-forage whole corn (LFWC). For the high-forage diets, steers fed cracked corn had 7% greater DMI than those fed whole corn, whereas for the low-forage diets, grain processing did not affect DMI (interaction; P = 0.02). No interactions (P > 0.10) between forage level and corn processing were found for ADG and G:F. Total trial ADG and G:F, and percentage of carcasses grading USDA Choice, and carcass yield grade were not affected (P > 0.10) by corn processing. Cattle with fewer days on feed grew faster and more efficiently when cracked corn was fed, whereas cattle with longer days on feed had greater ADG and G:F when corn was fed whole (interaction; P < 0.10). In Exp. 3, the effects of forage level and corn processing on diet digestibility were evaluated. The high-forage cracked corn, high-forage whole corn, low-forage cracked corn, and low-forage whole corn diets used in Exp. 2 were fed to 16 steers (350 +/- 27 kg BW) in a digestion trial. No interactions (P > 0.10) between forage level and corn processing were detected for starch digestibility. Forage level and corn processing (grinding) did not affect (P > 0.10) diet DM, OM, starch, CP, and NDF digestibility. Processing corn did not provide additional benefits to feedlot cattle performance under these experimental conditions.